User manual Condenser dryer ZDC 37201W
Contents
1. User manual Condenser dryer U Q E R MANUAL ZDC 37201W ZANUSSI Contents Important safety information Environment Installation 222222 Product description Control panel ________________ _ Before first use NNNN SB BD Important safety information Important In the interest of your safety and to ensure the correct use before installing and first using the appliance read this user manual carefully including its hints and warnings To avoid unnecessary mistakes and accidents it is important to ensure that all people using the appliance are thoroughly familiar with its operation and safety features Save these instructions and make sure that they remain with the appliance if it is moved or sold so that everyone using it through its life will be properly informed on appliance use and safety Please read the instruction book be fore using this appliance General safety It is dangerous to alter the specifications or attempt to modify this product in any way This appliance is not intended for use by persons including children with reduced physical and sensory conditions or lack of experience and knowledge unless they have been given supervision or instruction con cerning use of the appliance by a person re sponsible for their safety Make sure that small children and pets do not climb inside the drum To avoid this please check into the drum before using Any objects such as coins safety2. the socket Cut off the cable and plug and dispose of them Dispose of the door catch This prevents children from trapping themselves inside and endangering their lives tilation grille or the air intake grilles at the back of the machine To keep vibration and noise to a minimum when the dryer is in use it should be placed on a firm level surface Once in its permanent operating position check that the dryer is absolutely level with the aid of a spirit level If it is not raise or lower the feet until it is The feet must never be removed Do not re strict the floor clearance by using deep pile carpets strips of wood or similar This might www zanussi com cause heat built up which would interfere with the operation of the appliance Important The hot air emitted by the tumble dryer can reach temperatures of up to 60 C The ap pliance must therefore not be installed on floors which are not resistant to high temper atures When operating the tumble dryer the room temperature must not be lower than 5 C and higher than 35 C as it may affect the performance of the appliance Should the appliance be moved it must be transported vertically The appliance must not be installed behind the lockable door a sliding door a door with a hinge on the opposite side to that of the appliance in such a way that a full opening of the dryer is restricted Ensure min 5cm free space around the app
3. and seams 1 In accordance with IEC61121 Programme chart in accordance with IEC61121 Sorting and preparing laundry FSF JA The appliance should be tested based on time controlled programmes Sorting laundry Sort by fabric type Cotton linen for programmes in COT TONS programme group Mixtures and synthetics for programmes in SYNTHETICS programme group Sort by care label The care labels mean 7 O 73 E Drying in the tumble dryer possible in principle Drying at normal temperature www zanussi com Drying at reduced temperature I Drying in the tumble dryer not possible Important Do not place in the appliance any wet laundry which is not specified on the care label as being suitable for tumble drying This appliance can be used for all wet laundry items which are labelled as suitable for tumble drying Do not dry new coloured textiles together with light coloured laundry items Textile col ours may bleed Do not dry cotton jersey and knitwear with the EXTRA DRY programme Items may shrink Preparing laundry To avoid laundry becoming tangled close zips button up duvet covers and tie loose ties or ribbons e g of aprons Empty pockets Remove metal items paper clips safety pins etc Turn items with double layered fabrics inside out e g with cotton lined anoraks the cot ton layer should be outermost These fab rics will then dry
4. aundry max weight Type of use Ambient temperature Energy consumption 1 Annual energy consumption 2 Energy efficiency class 12 Width Height Depth Voltage Frequency Fuse Total power Min Max kWh cycle 85 x 60 x 58 cm 1090 mm 950 mm 230 240 V 50 Hz 13A 2350 W 108 I 37 kg 7 kg Household 5 C 35 C 4 70 kWh 552 kWh C www zanussi com Power consumption Left on mode ow Off mode ow 1 With reference to EN 61121 7 kg of cotton and a spin speed at 1000 rpm 2 Energy consumption per year in kWh based on 160 drying cycles of the standard cotton programme at full and partial load and the consumption of the low power modes Actual energy consumption per cycle will depend on how the appliance is used REGULATION EU No 392 2012 Machine settings BUZZER permanent off 2 Press simultaneously the Delicate and Cotton Synthetic buttons and hold down for approx 5 seconds 3 The buzzer is by default always off 1 Turn the programme selector to any pro gramme www zanussi com 13 14 www zanussi com www zanussi com 15 www zanussi com shop S Es 8 Y ZN N 136926400 B 092013
5. better Daily use Switching machine on Turn the programme selector to any pro gramme The machine switches on Operating I es a 0 S o o oo OG Drying options DELICATE www zanussi com Important Do not overload the appliance Observe max loading volume Laundry weights Type otaua Weight Bathrobe 1200g Napkin 100g Quilt cover 700g Sheet 500 g Pillow case 200 g Tablecloth 250g Towelling towel 200g Tea cloth 100g Night dress 200 g Ladies briefs 100g Man s work shirt 600 g Man s work shirt 200 g Man s pyjamas 500 g Blouse 100g Men s underpants 100g gentle drying with reduced heat of sensitive fabrics and temperature sensitive textiles e g acrylic vis ar cose marked on care label with COTTONS SYNTHETICS type of laundry selection for time controlled pro grammes Starting the programme Press the Start Pause button Changing programme To change a programme which has been se lected by mistake once the programme has started first turn the programme selector to O off and then set the programme again Drying cycle complete removing laundry Once the drying cycle is complete the LED Anti crease End is on as well as warning LED s Filter and Tank If the Buzzer button has been pressed an acoustic signal sounds intermittently for about one minute Remove the laundry 1 Open door 2 Remove visible fluff from the fluff filters It is b
6. e button to continue the drying cycle Cleaning condenser AA O Important Never operate the dryer without condenser Clogged condenser cause higher energy consumption drying cycle elongation and dryer damage What to do if Troubleshooting by yourself Problem Possible cause Dryer not connected to mains supply Dryer does not work Loading door opened The START PAUSE button not pressed Incorrect programme set Unsatisfactory Fluff filt drying results uber clogged Heat exchanger clogged www zanussi com Do not use sharp objects to clean Cleaning the drum Caution Do not use abrasives or steel wool to clean the drum Lime in the water or cleaning agents may form a barely visible lining on the inside of the drum The degree to which the laundry has been dried is then no longer detected reliably The laundry is damper than expected when re moved from the appliance Use a standard domestic cleaner e g vinegar based cleaner to wipe down the inside of the drum and drum ribs Clean control panel and housing Caution Do not use furniture cleaners or aggressive cleaning agents to clean the machine Use a damp cloth to wipe down the control panel and housing Remedy Plug in at mains socket Check fuse in fuse box domestic installation Close loading door Press the START PAUSE button Set suitable programme 2 Clean fluff fi
7. er supply cable to remove the plug from the socket always take hold of the plug itself Never use the tumble dryer if the power sup ply cable the control panel the working sur face or the base are damaged so that the in side of the tumble dryer is accessible Fabric softeners or similar products should be used as specified by the fabric softener instructions Caution hot surface Do not touch the door light cover surface when the light is switched on Only dryers equipped with internal drum light Child safety This machine is not intended for use by young children or infirm persons without su pervision Children often do not recognise the hazards associated with electrical appliances Chil 3 dren should be supervised to ensure that they do not play with the appliance AN Warning Danger of suffocation The packaging components e g plastic film polystyr Environment Recycle the materials with the symbol Put the packaging in applicable containers to recycle it Help protect the environment and human health and to recycle waste of electrical and electronic appliances Do not dispose appliances marked with the symbol 2 with the household waste Return the product to your local recycling facility or contact your municipal office Environmental tips In the dryer laundry becomes fluffy and soft Fabric softeners are not therefore needed when washing Your dryer will function most eco
8. est to use a damp hand for this pur pose see chapter Maintenance and cleaning 3 Remove laundry Cleaning and maintenance Cleaning fluff filters The filters collect all the fluff which accumu lates during drying To ensure that the dryer works perfectly the fluff filters fine filters and fluff filters must be cleaned after each drying cycle Caution Never operate the dryer without fluff filters or with damaged or blocked fluff filters _ 10 4 Turn the programme selector to off Important after each drying cycle clean the fluff filters drain the water reservoir see chapter Maintenance and cleaning 5 Close the door The drying cycles are automatically fol lowed by an anti crease phase which lasts around 30 minutes The drum rotates at inter vals during this phase to protect the laundry from creases The laundry can be removed at any time during the anti crease phase Clean the door seal Wipe the door seal with a damp cloth immedi ately after the drying cycle has finished Emptying the water reservoir Empty the water reservoir after every drying cy cle A Er www zanussi com Caution The condensed water is not suitable for drinking or for preparing foodstuffs If the programme has been interrupted as a result of the water reservoir being full Press the Start Paus
9. f in doubt do not use it and contact the Service Centre All packaging must be removed before use Serious damage can occur to the product and to property if this is not adhered to See relevant section in the user manual Any electrical work required to install this appliance should be carried out by a quali fied electrician or competent person If the machine is situated on a carpeted floor please adjust the feet in order to allow air to circulate freely under the appliance www zanussi com After having installed the appliance check that it is not pressing or standing on its elec trical supply cable If the tumble dryer is placed on top of a washing machine it is compulsory to use the stacking kit optional accessory Use This appliance is designed for domestic use It must not be used for purposes other than those for which it was designed Only wash fabrics which are designed to be machine dried Follow the instructions on each garment label Do not dry unwashed items in the tumble dryer Do not overload the appliance See the rele vant section in the user manual Clothes which are dripping wet should not be placed in the dryer Garments which have been in contact with volatile petroleum products should not be machine dried If volatile cleaning fluids are used care should be taken to ensure that the fluid is removed from the garment before placing in the machine Never pull the pow
10. he wire coloured blue must be connected to the terminal N or coloured black The wire coloured brown must be connected to the terminal marked L or coloured red Upon completion there must be no cut or stray strands of wire present and the cord clamp must be secure over the outer sheath Warning A cut off plug inserted into a 13 amp socket is a serious safety shock hazard Ensure that the cut off plug is disposed of safely Warning The plug must be accessible after installing the machine Permanent connection In the case of permanent connection it is nec essary that you install a double pole switch be tween the appliance and the electricity supply mains with a minimum gap of 3 mm between the switch contacts and of a type suitable for the required load in compliance with the cur rent electrical regulations The switch must not break the yellow and green earth cable at any point Door reversal To make it easier to load or unload the laundry the door can be reversed Warning The door must only be reversed by an authorised service engineer Please contact your local Service Force Cen tre The engineer will carry out the door rever sal at your cost Special accessories stack kit 1 Available from your Service Force Centre or your specialist dealer These intermediate installation kits can be used to arrange the dryer and an washing machine 60 cm wide front loaded as a space saving washer dr
11. ke As these substances are volatile they could cause an explosion Only tumble dry items washed with water Risk of fire items that have been spotted or soaked with vegetable or cooking oil con stitute a fire hazard and should not be placed in the tumble dryer www zanussi com If you have washed your laundry with stain remover you must execute an extra rinse cy cle before loading your tumble dryer Please make sure that no gas lighters or matches have accidentally been left in pock ets of garments incase they are loaded into appliance Warning Risk of fire Never stop a tumble dry before the end of the drying cy cle unless all items are quickly re moved and spread out so that the heat is dissipated Lint must not be allowed to accu mulate around the tumble dryer Risk of electric shock Do not spray down the appliance with jets of water The final part of a tumble dryer cycle occurs without heat cool down cycle to ensure that the items are left at a temperature that ensures that items will not be damaged The tumble dryer is not to be used if industri al chemicals have been used for cleaning Ensure you have good ventilation in the in stallation room to avoid the back flow of gases into the room from appliances burning other fuels including open fires Installation This appliance is heavy Care should be tak en when moving it When unpacking the appliance check that it is not damaged I
12. li ance Removing transport safety packaging Caution Before use all parts of the transport packaging must be removed A 1 Open loading door 2 Pull off adhesive strips from inside ma chine on top of drum www zanussi com 3 Remove foil hose and polystyrene padding from the machine Electrical connection Details on mains voltage type of current and the fuses required should be taken from the rating plate The rating plate is fitted near the loading aperture see Product description chapter Connect the machine to an earthed socket in accordance with current wiring regulations Warning The manufacturer declines any responsibility for damage or injury through failure to comply with the above safety precautions Should the appliance power supply cable need to be replaced this must be carried out by an authorised service engineer or a qualified electrician The appliance is supplied with a 13 amp plug fitted In the event of having to change the fuse in the plug supplied a 13 amp ASTA approved BS 1363 A fuse must be used The wires in the mains lead are coloured in ac cordance with the following code Blue Neutral cord clamp Brown Live Green and Yellow Earth The wire coloured green and yellow must be connected to the terminal marked with the let ter E or by the earth symbol 2 or coloured green and yellow T
13. lters 3 Clean heat exchanger 3 11 Loading door does not close Programme in active Drying cycle to short Drying cycle to long 4 Max loading exceeded Covered ventilation grill Residue inside the drum To little free space around the appliance Filters not locked in place Full water reservoir Small laundry volume Too dry laundry for selected programme Fluff filters clogged To high loading volume Laundry insufficiently spun Particularly high room temperature no ma chine fault Respect max loading volume Uncover ventilation grill in base area Clean the drum inside Ensure min 5cm free space around the ap pliance Install fine filter and or snap course filter in to place Empty water reservoir press START PAUSE button Select time programme or higher drying lev el e g EXTRA DRY Clean fluff filters Respect max loading volume Spun adequately the laundry Lower the room temperature if possible 1 Switch the dryer off Set programme time Press the START PAUSE button 2 follow program recommendation see Programme overview chapter 3 see Care and cleaningchapter 4 Note After around 5 hours the drying cycle ends automatically see Drying cycle complete section Technical data Dimensions mm Max depth with the appliance door open Max width with the appliance door open Electrical connection Drum volume Weight of the appliance L
14. nomically if you Always keep the ventilation slots on the base of the dryer unobstructed Use the loading volumes specified in the programme overview Ensure you have good ventilation in the in stallation room Installation Important The appliance must be moved in vertical position for transport Appliance positioning It is recommended that for your conven ience the machine is positioned close to your washing machine The tumble dryer must be installed in a clean place where dirt does not build up Air must be able to circulate freely all round the appliance Do not obstruct the front ven ene can be dangerous to children Keep them out of children s reach Keep all detergents in a safe place out of children s reach Make sure that children or pets do not climb inside the drum Clean the micro fine filter and fine strainer after each drying cycle Spin the laundry well before drying w Energy consumption depends on spinning speed set in washing machine Higher spinning speed lower energy consumption Environmental information The packaging materials are environmentally friendly and can be recycled The plastic com ponents are identified by markings e g gt PE lt gt PS lt etc Please dispose of the packaging materials in the appropriate container at the community waste disposal facilities Warning When the unit is no longer being used Pull the plug out of
15. pins nails screws stones or any other hard sharp ma terial can cause extensive damage and must not be placed into the machine Sorting and preparing laundry 8 Daily use ___2______2_ 2 2 __ 9 Cleaning and maintenance _________ 10 What to do EE EEE 11 Technical data ______________ _ 12 Machine settings ______________ 13 Subject to change without notice In order to avoid danger of fires caused by excessive drying do not use appliance to dry the following items Cushions quilts and the like these items accumulate heat Items such as foam rubber latex foam shower caps waterproof textiles rubber backed articles and clothes or pillows fitted with foam rubber pads should not be dried in the tumble dryer Always unplug the appliance after use cleaning and maintenance Under no circumstances should you attempt to repair the machine yourself Repairs car ried out by inexperienced persons may cause injury or serious malfunctioning Con tact your local Service Centre Always insist on genuine spare parts Items that have been soiled with substances such as cooking oil acetone petrol kero sene spot removers turpentine waxes and wax removers should be washed in hot wa ter with an extra amount of detergent before being dried in the tumble dryer Danger of explosion Never tumble dry items that have been in contact with inflam mable solvents petrol methylated spirits dry cleaning fluid and the li
16. ryer drum with a damp cloth or carry out a Programme chart E u i c z x Time in E E Programmes minutes 2 Application properties CSTN Z ke O E x E COTTON EXTRA 140 7k Thorough drying of thick or multi layered fabrics DRY 9 e g terry towelling items bathrobes www zanussi com 7 Time in minutes about Programmes max load weight when dry COTTON STRONG Application properties Thorough drying of thick or multi layered fabrics DRY 130 meg e g terry towelling items bathrobes COTTON STOR Thorough drying of fabrics of even thicknesses e g I 125 7 kg BAN AGE DRY 1 terry towelling items knitwear towels For thin textiles which are still to be ironed e g knit 4 1 1 Om COTTON DAMP 1 110 7kg ted items cotton shirts e COTTON IRON 85 7k For thin fabrics which are also to be ironed e g knit I DRY 0 g wear cotton shirts O SYNTHETICS EX 50 3k Thorough drying of thick or multi layered fabrics O TRA DRY I e g pullovers bedding table linen SYNTHETICS For thin fabrics which are not ironed e g easy care TORAGE DRY 1 40 3kg shirts table linen baby clothes socks lingerie with STORAGE bones or wires SYNTHETICS IRON 30 3k For thin fabrics which are also to be ironed e g knit DRY g wear cotton shirts O For leisure clothing such as jeans sweat shirts JEANS 125 7kg etc of different material thicknesses e g at the neck cuffs
17. yer stack The wash ing machine is at the bottom and the dryer is at the top Read carefully the instructions supplied with the kit drain kit Available from your Service Force Centre or your specialist dealer Installation kit for direct draining of conden sate into a basin siphon gully etc The con densate tank then no longer has to be drained it must however remain in its inten ded position in the machine Read carefully the instructions supplied with the kit pedestal with the drawer Available from your Service Force Centre or your specialist dealer To situate the dryer in optimal high and have some additional space to store e g laun dry Read carefully the instructions supplied with the kit www zanussi com Product description Worktop Rating Plate Heat exchanger Water reservoir Heat exchanger door 6 Control panel 2 Fluff filters EJ Loading door 2 5 El Ventilation grille Adjustable feet Control panel Programme knob and OFF switch Delicate button e z s 8 8 Cotton Synthetic selection button OG ES Function status led Drying Anti H crease End Condenser Filter Tank ooo lights Start Pause button Before first use In order to remove any residues which may brief drying cycle ca 30 min with damp have been produced during production wipe cloths in the machine the d
Download Pdf Manuals
Related Search