Owner`s Manual
Contents
1. Getting Started This appliance is a Decorative Gas Appliance for OUT DOOR USE ONLY and MUST NOT be used for cooking Place the Crystal Fire on a flat and stable surface in an out door location such as a patio or deck This location must be adjacent to the gas supply line or LP gas supply cylinder DO NOT locate the appliance where it can get excessively wet or submerged in water A Design and Installation Considerations When planning an appliance installation its necessary to determine the following information before installing Where the appliance is to be installed See Sections 3 and 4 e Gas supply piping See Section 4 Framing and finishing details See Sections 3 and 4 B Tools and Supplies Needed Before beginning the installation be sure that the following tools and building supplies are available Gloves Safety glasses Flat blade screwdriver Non corrosive leak check solution Wrenches Fire Stone Home Products disclaims any responsibility for and the warranty will be voided by the following actions Installation and use of any damaged components Modification of the burner assembly Installation other than as instructed by Fire Stone Home Products Installation and or use of any component part not approved by Fire Stone Home Products Any such action may cause a fire hazard Do NOT use this appliance if any part has been un der water Immediately call a qualified service techni cia2. Make sure electrode is sparking Step 2 Turn gas on at tank Step 5 Turn shut off valve to ON position Step 3 Begin pressing sparker The Outdoor Greatroom Company Crystal Fire Rev1 6 Framing and Clearances Note WARNING e Illustrations reflect typical installations and are FOR DESIGN PURPOSES ONLY Fire Risk Illustrations diagrams are not drawn to scale Provide adequate clearance Actual installation may vary due to individual de Around air openings sign preference For service access Locate appliance away from traffic areas A Select Appliance Location When selecting a location for your appliance it is important to consider the required clearances to walls See Figure 3 1 B Clearances to Combustibles 24 inches to side wall and back wall from edge of unit 72 inches to overhang from top of metal bowl Figure 3 1 Clearances to Combustibles The Outdoor Greatroom Company Crystal Fire Rev1 C Framing Enclosure for LP Gas Supply System If you build an enclosure for an LP gas cylinder follow these recommended specifications and local codes Ventilation Enclosures must be ventilated by openings at the level of the cylinder valve and at floor level Effectiveness must be determined with the cylinder s in place One side of the enclosure must be completely open or Foran enclosure having four sides a top and a bottom At least two ventilation openings
3. stay lit The Outdoor Greatroom Company Crystal Fire Rev1 17 Maintaining and Servicing the Appliance Although the frequency of appliance servicing and main tenance will depend on use and the type of installation a A WARNING qualified service technician should perform an appliance check up annually Annual inspection by qualified technician recommended Ay WARNING Check Risk of injury or property damage e Obstructions of combustion and venti lation air Before servicing Condition of burner assembly Turn off utilities to appliance Burner ignition and operation Ensure appliance is completely cooled Burner air shutter adjustment Gas connections and fittings Storage of an appliance indoors is permissible only if the ds Risk of cylinder is disconnected and removed from the appli ance e Fire Delayed ignition or explosion Exposure to combustion fumes Odors Maintenance and Service Tasks Burner Assembly 1 Remove tumbled glass and examine burner Vacuum and wipe out as needed Use cau rr when cleaning these areas 2 Inspect for warping and corrosion Repair as necessary Check the hose connecting the LP gas cylinder to ensure it is not damaged Replace as sore pe air shutter area is clean Burner ignition and 1 Verify all gas connections are tight and leak free operation Clean off burner top inspect for plugged ports corrosion or deterioration Replace b
4. the Product will be free from defects in material and workmanship for a period of one year from its date of purchase This war ranty is subject to the conditions exclusions and limitations described below This warranty applies only to the original owner of the Product and is non transferable The Outdoor Greatroom Company obligation under this warranty does not extend to damages resulting from 1 assembly operation or maintenance of the Product not in accordance with the Installation Assembly Instructions Operating Instruc tions and the Listing Agency Identification Label furnished with the Product 2 installation or use which does not comply with local building codes and ordinances 3 shipping improper handling improper operation abuse misuse accident or unworkmanlike repairs 4 use of fuels other than those specified in the Operating Instructions 5 Installation or use of components not supplied with the Product or any other components not expressly authorized and approved in writing by The Outdoor Greatroom Company and or 6 modification of the Product not expressly authorized and approved in writing by The Outdoor Greatroom Company Any of the circumstances described in the previous sentence voids this warranty This warranty is void if the Product or any component has been removed repaired or replaced before The Outdoor Greatroom Company has been afforded a reasonable opportunity to inspect the Product This warranty is
5. Position the assembly in the desired location This loca tion must be adjacent to the gas supply line You must have easy access to the gas valve control knob after it is installed and connected to the gas supply because the ON OFF gas valve is used to turn the burner on and off LP Gas Models Make sure the tank valve is turned completely off clock wise Ensure the tank valve has the proper external mating threads tank valve marked USE WITH TYPE 1 Inspect the hose shipped with the appliance for any damage Do not use if there is evidence of damage Connect the end of the hose onto the ON OFF gas valve of the appliance Make sure it is secured tightly Connect the regulator assembly to the tank valve Hand tighten only clockwise Do not use a wrench to tighten Use of a wrench may damage the quick closing nut and result in a hazardous condition Position the hose out of pathways where people might trip over it or in areas where the hose might be subject to accidental damage The Outdoor Greatroom Company Crystal Fire 11 Open the tank valve fully counterclockwise Turn the ON OFF valve slowly to the ON position All connec tions must be tightened and checked for leaks with a commercially available non corrosive leak check solu tion Be sure to rinse off the solution when done leak testing If a leak is found turn the tank valve off and do not use the appliance until repairs can be made
6. The Outdoor Greatroom Company 12400 Portland Ave So Burnsville MN 55337 2 Affirm that you are the original owner of the Product 3 Provide The Outdoor Greatroom Company reasonable opportunity to investigate the claim including rea sonable opportunity to inspect the Product prior to any repair or replacement work and before the Product or any component of the Product has been removed 4 Obtain The Outdoor Greatroom Company s consent to any warranty work before the work is done 2007 Fire Stone Home Products The Outdoor Greatroom Company Crystal Fire Rev1 20 C Contact Information Aart OutdoorGreatRoom company The Outdoor Greatroom Company 12400 Portland Ave So Burnsville Mn 55337 www outdoorgreatrooms com Please contact your Outdoor Greatroom Company dealer with any questions or concerns For the number of your near est Outdoor Greatroom dealer please call 952 358 7410 NOTES CAUTION gt Do NOT discard this manual Important operating and maintenance instructions included Read understand and follow these instruc tions for safe installation and operation Leave this manual with party responsible for use and operation The Outdoor Greatroom Company Crystal Fire Rev1 21
7. be constructed and marked in accordance with the specifications for LP gas cylinders of the U S Depart ment of Transportation DOT Cylinders must be stored outdoors in a well ventilated area out of the reach of children Disconnected cylin ders must have threaded valve plugs tightly installed and must not be stored in a building garage or any other enclosed area e Storage of this appliance indoors is permissible only if it has been disconnected from its fuel supply natural gas line or LP gas cylinder The LP gas cylinder supply system must be arranged for vapor withdrawal he LP gas cylinder used must include a collar to pro tect the cylinder valve e When an LP model is not in use the LP gas must be turned off at the supply cylinder The specific size and capacity of the cylinder s to be used 20 Ib or hard plumbed to propane tank The Outdoor Greatroom Company Crystal Fire 10 Rev1 Appliance Setup A Burner Assembly All Models Check for damage Do not use damaged components The hose assembly must be replaced prior to the ap pliance being put into operation if there is evidence of excessive abrasion or wear or if the hose is damaged The replacement hose assembly specified by the man ufacturer The burner must be replaced prior to the appliance be ing put into operation if it is evident that the burner is damaged The replacement burner assembly specified by the manufacturer
8. limited to the replacement or repair of defective components or workmanship and The Outdoor Greatroom Company may fully discharge its obligations under this warranty by repairing or replacing at its discretion the defective components The Outdoor Greatroom Company will provide replacement parts at no charge and will pay reasonable and necessary labor and freight costs related to replacing or repairing defective components under this warranty The maximum amount recoverable under this warranty is limited to the pur chase price of the Product and if The Outdoor Greatroom Company is unable to provide replacement or repair in an expedient and cost effective manner The Outdoor Greatroom Company may discharge all obligations under this warranty by refunding the purchase price of the Product EXCEPT TO THE EXTENT PROVIDED BY LAW THE OUTDOOR GREATROOM COMPANY MAKES NO EXPRESS WARRANTIES OTHER THAN THE WARRANTY EXPRESSED HEREIN THE DURATION OF ANY IMPLIED WARRANTY IS LIMITED TO THE DURATION OF THE WARRANTY SPECIFIED ABOVE IN NO EVENT SHALL THE OUTDOOR GREATROOM COMPANY BE LIABLE FOR ANY INCIDENTAL OR CONSE QUENTIAL DAMAGES CAUSED BY DEFECTS IN THE PRODUCT Some states do not allow limitations on how long an implied warranty lasts or do not allow exclusion or limitation of incidental or consequential dam ages so these limitations may not apply to you To obtain service under this warranty you must 1 Send written notice of the claimed condition to
9. of unit to adjacent combustible construction below top of unit 24 inches from sides and 24 inches from back Minimum horizontal clearance from sides and back of unit to adjacent vertical combustible construction horizontal clearance from sides and back of unit to adjacent vertical combustible construction extending above top of unit 24 inches from sides and 24 inches from back The Outdoor Greatroom Company Crystal Fire Rev1 u s Table of Contents 1 Listing and Code Approwvals 4 A Appliance Certification 4 B BTU Specifications eesseeesseese 4 C High Altitude Installations 4 2 Getting Started sseeeseseeesesss 5 A Design and Installation Considerations 5 B Tools and Supplies Needed 5 C Inspect the Appliance and Components 6 D Step by Step Lighting Instructions 6 3 Framing and Clearances 7 A Select Appliance Location 7 B Clearances to Combustibles 7 C Framing Enclosure for LP Gas Supply System 8 4 Gas Information snesena a 9 Ao co eae etme es eee Se ner orc ene C Pad IUS EU 9 B Gas Pressure ais cucehedsacecot bas ann ibedcovenlensuretancins 9 Gi Gas Connection a
10. valve during any pressure testing of the gas supply piping system at test pressures equal to or less than 1 2 psi 3 5 kPa C Gas Connection Note Have the gas supply line installed in accordance with local building codes if any If not follow ANSI 223 1 Installation should be done by a qualified installer ap proved and or licensed as required by the locality In the Commonwealth of Massachusetts installation must be performed by a licensed plumber or gas fitter Note A listed and Commonwealth of Massachusetts approved 1 2 in 13 mm T handle manual shut off valve and flexible gas connector are connected to the 1 2 in 13 mm control valve inlet e f substituting for these components please consult local codes for compliance Incoming gas line should be piped to the 1 2 inch con nection on the manual shutoff valve Fire Risk Explosion Risk Gas build up during line purge may ignite Purge should be performed by qualified technician Ensure adequate ventilation Ensure there are no ignition sources such as sparks or open flames e A small amount of air will be in the gas supply lines When first lighting appliance it will take a short time for air to purge from lines Subsequent lighting of the log set will not require such purging Never allow the ON OFF valve to remain in the open position with out placing a burning match on top of the burner FIRST CHECK FOR GAS LEAKS Fire Ri
11. Aart OutdoorGreatRoom company Model Crystal Fire Decorative Gas Appliance The Outdoor Greatroom Company Owner s Manual Installation and Operation GAS FIRED c UL Dus LISTED CAUTION Important operating and maintenance instructions included If the information in these instruc tions is not followed exactly a fire or explosion may result causing property damage personal injury or loss of life Do not store or use gasoline or other flam mable vapors and liquids in the vicinity of this or any other appliance What to do if you smell gas Do not try to light any appliance Do not touch any electrical switch Do not use any phone in your building Immediately call your gas supplier from a neighbor s phone Follow the gas supplier s instructions f you cannot reach your gas supplier call the fire department e Installation and service must be per formed by a qualified installer service agency or the gas supplier Improper installation adjustment alteration service or maintenance can cause injury or property damage Read the installation and maintenance instructions thoroughly before installing or servicing this equipment The Outdoor Greatroom Company Crystal Fire 2 DO NOT DISCARD THIS MANUAL Read understand and follow Leave this manual these instructions for safe installation and operation with party responsible for use and operation HOT DO N
12. B Glass Installation Spread glass out evenly over burner area use all glass supplied for best affect Rev1 Operating Instructions A Before Lighting Appliance Must run sparker prior to turning gas on LP Propane Before lighting this appliance ensure both the LP tank valve and the manual shutoff valve are closed Open the LP tank valve first THEN the manual shutoff valve This is required due to built in safety features of your LP tank Before operating the appliance have a qualified technician e Inspect the burner Remove or clean any debris that may have fallen on the appliance If a thorough clean ing is required remove the glass material and wipe off burner surface making sure all burner ports are free of debris If there is any evidence that the burner is dam aged replace it with an approved replacement part Check the air shutter adjustment Ensure that there are no gas leaks Inspect all gas supply lines If there is evidence of excessive abrasion wear or any damage replace those components with approved replacement parts Ensure that the flow of combustion and ventilation air is not obstructed Improper installation adjustment alteration service or maintenance can cause injury or property damage Re fer to the owner s information manual provided with this appliance For assistance or additional information consult a qualified installer service agency or the gas supplier Do N
13. ON OFF valve slowly at the appliance For an LP appliance turn the valve on the LP tank counterclockwise all the way and then turn on the ON OFF valve slowly at the appliance If the burner does not light before the match goes out immediately turn the gas valve to OFF Wait at least five minutes to clear out any gas Then smell for gas including the base of the appliance If you smell gas STOP Follow B in the safety infor mation above If you do not smell gas repeat Step 4 E TO TURN OFF GAS TO APPLIANCE EE Turn the ON OFF valve to the OFF position at the appliance for a natural gas appliance The Outdoor Greatroom Company Crystal Fire 13 e For an LP appliance turn the ON OFF valve to the OFF position at the appliance and then with a Type or Il Connection turn the valve at the LP cylinder clockwise to the OFF position when the appliance is not in use Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance Rev1 C After the Appliance is Lit A WARNING Initial Break in Procedure When you light the appliance you may notice that it pro Fire Risk duces heat which may have an odor or smell If you feel Keep combustible materials gasoline this odor is excessive it may require the initial three to four and other flammable vapors and liquids hour continuous burn on high followed by a second burn clear of appliance up to 12
14. OT TOUCH SEVERE BURNS MAY RESULT CLOTHING IGNITION MAY RESULT Glass and other surfaces are hot during ANITA sh operation and cool down Keep children away e CAREFULLY SUPERVISE children near or around this appliance Alert children and adults to hazards of high tem peratures Keep clothing furniture draperies and other com bustibles away Ay WARNING Ay WARNING lts imperative the burner be kept clean Installation and service of this appliance should be performed by qualified personnel Fire Stone Home Products suggests NFI certified or factory trained professionals or technicians supervised by an NFI certified Wood Energy professional Gene rime Rev1 Read this manual before installing or operating this appliance Please retain this owner s manual for future reference Congratulations Congratulations on selecting an Outdoor Greatroom Com The information contained in this owner s manual unless pany decorative gas appliance The Crystal Fire you have noted otherwise applies to all models and gas control sys selected is designed to provide the utmost in safety reli tems ability and efficiency d d Your new Crystal Fire will give you years of durable use and As the owner of a Crystal Fire you ll want to read and care trouble free enjoyment fully follow all of the instructions contained in this owner s manual Pay special attention to all cautions and warnings This owner s manual
15. OT use this appliance if any part has been un der water Immediately call a qualified service techni cian to inspect the appliance and to replace any part of the control system and any gas control which has been under water TN Fire Risk Burn Risk HOT DO NOT TOUCH SEVERE BURNS MAY RESULT CLOTHING IGNITION MAY RESULT Glass and other surfaces are hot during operation and cool down Children and adults should be alerted to the hazards of high surface temperatures and should stay away to avoid burns or clothing ignition Young children should be carefully supervised when they are in the area of the appliance Clothing or other flammable materials should not be hung from the appliance or placed on or near the appliance Installation and repair should be done by a quali fied service person The appliance should be inspected before use and at least annually by a qualified service person More frequent cleaning may be required as necessary It is imperative that control compartment burners and circulating air passageways of the appliance be kept clean The Outdoor Greatroom Company Crystal Fire Rev1 12 B Lighting the Appliance E FOR YOUR SAFETY READ BEFORE LIGHTING i WARNING If you do not follow these instructions exactly a fire or explosion may result causing property damage personal injury and or loss of life A This appliance must be lit manually When lighting follow these instructi
16. at cylinder valve level shall be provided in the side wall equally sized spaced at 180 degrees 3 14 rad and unobstructed Each opening must have a total free area of not less than 1 2 square inch per pound 3 2 sq cm kg of stored fuel capacity and not less than a total free area of 10 square inches 64 5 sq cm Ventilation opening s must be provided at floor level and shall have a total free area of not less than 1 2 square inch per pound 3 2 sq cm kg of stored fuel capacity and not less than a total free area of 10 square inches 64 5 sq cm If ventilation openings at floor level are in a side wall there must be a least two openings The bottom of the openings must be at floor level and the upper edge can t be more than 5 in 127 mm above the floor The openings must be equally sized spaced at 180 degrees 3 14 rad and unobstructed Every opening must have minimum dimensions to permit the entrance of a 1 8 inch 3 2 mm diameter rod Accessibility Cylinder valves must be readily accessible for hand op eration A door on the enclosure to gain access to the cylinder valves is acceptable provided it is non locking and can be opened without the use of tools The design of the enclosure must be such that The LP gas supply cylinder s can be connected disconnected and the connections inspected and tested outside the cylinder enclosure Those connections which could be disturbed when installing the cylinde
17. hours to fully drive off any odor from paint and lubricants used in the manufacturing process Y Do NOT store flammable materials in the vicinity of the appliance Do NOT use gasoline lantern fuel kerosene charcoal lighter fluid or similar liquids in this appli ance Fire Risk High Temperatures Combustible materials may ignite Keep combustible household items away from ap pliance Do NOT obstruct combustion and ventilation air Do NOT place combustible items on top of or near appliance Keep furniture draperies away from appliance D Frequently Asked Questions Bina flames This is a result of normal operation and the flames will begin to yellow as the log set is allowed to burn for 20 to 40 minutes Noise is caused by metal expanding and contracting as it heats up and Metallic noise cools down similar to the sound produced by a furnace or heating duct This noise does not affect the operation or longevity of the appliance The Outdoor Greatroom Company Crystal Fire Rev1 14 Finishing A decorative surround can be made from noncombustible material Such as bricks landscape blocks rocks etc or three models of fabricated surrounds are available see Figures 7 1 through 7 3 Figure 7 1 Sierra Surround Figure 7 3 San Juan Grey Surround Shock Risk Fire Risk Use ONLY optional accessories approved for this appliance Using non listed accessories voids war ranty Using non
18. ireplaces CR 97 003 The Crystal Fire has been tested in accordance with IAS US requirements for Outdoor Gas Fireplaces Draft 4 96 and CSA requirement for Outdoor Gas Fireplaces CR 97 003 for Canada and has been listed by Underwriters Labo ratory UL for installation and operation as described in these installation and operating instructions The installation must conform with local codes or in the absence of local codes with the National Fuel Gas Code ANSI 2223 1 or CAN CGA B149 1 National Gas Instal lation Code or CAN CGA B149 2 Propane Installation Code B BTU Specifications Model Wax input BTUR Crystal Fire LP 60 000 43 C High Altitude Installations U L Listed gas appliances are tested and approved with out requiring changes for elevations from O to 2000 feet in the U S A and Canada When installing this appliance at an elevation above 2000 ft it may be necessary to decrease the input rating by chang ing the existing burner orifice to a smaller size Input rate should be reduced by 4 for each 1000 ft above a 2000 ft elevation in the U S A or 10 for elevations between 2000 and 4500 ft in Canada If the heating value of the gas has been reduced these rules do not apply To identify the proper orifice size check with the local gas utility If installing this appliance at an elevation above 4500 ft in Canada check with local authorities The Outdoor Greatroom Company Crystal Fire Rev1
19. listed accessories may result in a safety hazard e Only Fire Stone Home Products approved accessories may be used safely Figure 7 2 Chat Fire Granite Top Surround The Outdoor Greatroom Company Crystal Fire Rev1 15 Converting to Natural Gas Crystal Fire Natural Gas Conversion Kit Part 2006 330 Step 1 Shut off gas supply at tank or source Step 5 Follow the above steps 3 and 4 in reverse order with new natural gas orifice Set shutter opening to closed position No screen showing for Natural Gas Step 3 Remove shutter screw and slide off The Outdoor Greatroom Company Crystal Fire Rev1 16 Troubleshooting With proper installation operation and maintenance your Crystal Fire will provide years of trouble free service If you do experience a problem this troubleshooting guide will assist a qualified service person in the diagnosis of a problem and the corrective action to be taken This troubleshooting guide can only be used by a qualified service technician Symptom Possible Causes Corrective Actions No LP in tank Check the LP propane tank You may be out of Crystal Fire won t gas light ifi g m Plugged burner orifice Check the burner orifice for stoppage Remove stoppage Manual shutoff valve open or not in stalled between LP tank and appli ance Close LP tank and manual shutoff valves Open LP tank valve first THEN the manual shutoff valve Low flames or won t
20. n to inspect the appliance and to replace any part of the control system and any gas control which has been under water The Outdoor Greatroom Company Crystal Fire ua CAUTION Check building codes prior to installation Installation MUST comply with local regional state and national codes and regulations Consult insurance carrier local building fire offi cials or authorities having jurisdiction about restric tions installation inspection and permits Asphyxiation Risk This gas appliance is for outdoor use in a well ventilated space This unit must not be installed inside an enclosed structure or unvented appliance CAUTION Y Sharp Edges Wear protective gloves and safety glasses during installation Ay WARNING Do NOT burn solid fuels in this gas appliance Inspect appliance and components for damage Damaged parts may impair safe operation Do NOT install damaged components Do NOT install incomplete components DoNOT install substitute components Report damaged parts to dealer Carefully remove the appliance and components from the packaging Report to your dealer any parts damaged in shipment Read all of the instructions before starting the installa tion Follow these instructions carefully during the in stallation to ensure maximum safety and benefit Rev1 Must run sparker prior to turning gas on D Step by Step Lighting Instructions Step 4
21. ons exactly B Before lighting smell all around the appliance area for gas Be sure to smell next to the base of the appliance because some gas is heavier that air and will settle on the floor WHAT TO DO IF YOU SMELL GAS Do not try to light any appliance Do not touch any electric switch do not use any phone in your building Immediately call your gas supplier from a neighbors phone Follow the gas supplier s instructions If you cannot reach your gas supplier call the fire department C Use only your hand to turn the gas control knob or valve Never use tools If the valve will not turn by hand don t try to repair it call a qualified service technician Force or attempted repair may result in a fire or explosion Do not use the appliance if any part has been under water Immediately call a qualified service techni cian to inspect the appliance and to replace any part which has been underwater The gas pressure regulator provided with this ap pliance must be used This regulator is set for an outlet pressure of 3 5 inches water column M LIGHTING INSTRUCTIONS is 1 Stop Read the safety information above 2 Find the manual gas control valve 3 Find automatic spark push button and depress it make sure you see the spark if not light with a match place burning match in the middle of where ports are present Do not hold the match in your hands For a natural gas appliance turn on the
22. r s in the enclosure can be leak tested inside the enclosure Be certain to mount or set the LP gas cylinder on a flat stable surface and retain it to prevent it from tipping Minimum Clearances There must be a minimum clearance of 2 in 50 8 mm between the lower surface of the floor of the LP gas supply cylinder enclosure and the ground The Outdoor Greatroom Company Crystal Fire Rev1 Gas Information A Fuel Before making gas connections ensure appliance being installed is compatible with the available gas type B Gas Pressure Proper input pressures are required for optimum appli ance performance Gas line sizing requirements need to be made following NFPA51 Fire Risk Explosion Risk Verify inlet pressures High pressure may cause overfire condition Low pressure may cause explosion Verify minimum pressures when other household gas appliances are operating Install regulator upstream of valve if line pressure is greater than 1 2 psig Pressure requirements for appliance are shown in table below Minimum pressures must be met when other house hold gas appliances are operating Inlet Pressure 7 in W C 11 in w c a The appliance and its individual shutoff valve must be dis connected from the gas supply piping system during any pressures in excess of 1 2 psi 3 5 kPa The appliance must be isolated from the gas supply piping system by closing its individual manual shutoff
23. should be retained for future refer ence We suggest you keep it with your other important documents and product manuals Homeowner Reference Information We recommend that you record the following pertinent information about your appliance Model Name Date purchased installed Serial Number Location on appliance Dealership purchased from Dealer phone Notes Listing Label Information Location The model information regarding your specific appliance can be found on the rating plate located in the control area of the appliance Model Gas Type Orifice Size Serial Number GAS FIRED LISTED The Outdoor Greatroom Company DECORATIVE OUTDOOR 12400 Portland Ave S Suite 195 C US GAS FIRED FIREPLACE Burnsville MN 55337 LISTED Crystal Fire Model Crystal Fire MFG DATE Serial CSA 4 96 U S 3rd Ed Gas Fired Outdoor Fireplace DATE DE FAB XX XX For Canada CR 97 003 Outdoor Gas Fireplaces Natural Gas and Propane Gas Type of Gas Natural Gas Propane Gas Input 60 000BTU 17 5 kW ORIFICE SIZE NG 72331 LPG 43 NG Min Gas supply for Input Adj in w c 2 7kPa 7 0 in w c 1 7kPa Max Inlet Supply Pressure in w c 3 5kPa 14 0 in w c 3 5kPa Manifold Pressure in w c 2 5kPa 3 5 in w c 87kPa WARNING Must Not Be Used For Cooking WARNING For Outdoor Use Only If stored indoors detach and leave cylinder outdoors MINIMUM CLEARANCES Top 6 Ft 72 Sides 2 Ft 24 Minimum clearance from sides and back
24. sk Explosion Risk Asphyxiation Risk Check all fittings and connections Do not use open flame After the gas line installation is complete all connections must be tightened and checked for leaks with a commercially available non corrosive leak check so lution Be sure to rinse off all leak check solution following testing Fittings and connections may have loosened during shipping and handling The Outdoor Greatroom Company Crystal Fire Rev1 D High Altitude Installations U L listed gas appliances are tested and approved with out requiring changes for elevations from O to 2000 ft in the USA and Canada When installing this appliance at an elevation above 2000 ft it may be necessary to decrease the input rating by changing the existing burner orifice to a smaller size In put rate should be reduced by 4 for each 1000 ft above a 2000 ft elevation in the U S A or 10 for elevations between 2000 and 4500 ft in Canada If the heating value of the gas has been reduced these rules do not apply To identify the proper orifice size check with the local gas utility If installing this appliance at an elevation above 4500 ft in Canada check with local authorities E LP Gas Supply The pressure regulator and hose assembly supplied with LP models must be used Replacement pressure regulators and hose assemblies must be those speci fied in this manual The LP gas supply cylinder used with LP models must
25. ssimkcessue dpa aeree EX iar Rau 9 D High Altitude Installations 10 E BP as SUDDIV uscite oo toda trien 10 10 11 Appliance Setup eeeeeseees 11 A B rnerASSemblys isseesaiu derer vence a vagas 11 B Glass Installation esesssse 11 Operating Instructions 12 A Before Lighting Appliance 12 B Lighting the Appliance sssssse 13 C After the Appliance is Lit 14 D Frequently Asked Questions 14 anti e M 15 Converting to Natural Gas 16 Tro bleshootlhg on E m ec eee 17 Maintaining and Servicing the Appliance 18 Reference Materials ssss 19 A Service Parts List sseessss 19 B Limited One Year Warranty 20 C Contact Information sseuesssse 21 The Outdoor Greatroom Company Crystal Fire Rev1 Listing and Code Approvals A Appliance Certification MODEL CRYSTAL FIRE CF 20 LP LABORATORY Underwriters Laboratories Inc UL TYPE Decorative Gas Fired Outdoor Fireplace STANDARD IAS US requirements for Outdoor Gas Fireplaces Draft 4 96 and CSA requirement for Outdoor Gas F
26. urner if necessary S oo 6 Verify manifold and inlet pressures Adjust regulator as required Gas Hose The gas hose with regulator supplied with the appliance must be used The replace 1 s with Regulator ment must be those specified by the appliance manufacturer The Outdoor Greatroom Company Crystal Fire Rev1 18 1 1 Reference Materials A Service Parts List Crystal Fire Besmp onofPat Part Number ay SRV FT CF a jose see I Cs savas o o SRVBv GF e owotwawewNG E 3 7 ElctonicPiezo CFS parker 1 8 GasHosewithRegulato SRVHoseCF J 1 9 IgnitionElectrode Electrode J 1 The Outdoor Greatroom Company Crystal Fire Rev1 19 B Limited One Year Warranty N OutdoorGreatRoom The Outdoor Greatroom Company Outdoor Products Limited One Year Warranty The Outdoor Greatroom Company extends the following warranty for Outdoor Greatroom outdoor products used in the United States of America or Canada Dealers and employees of The Outdoor Greatroom Company have no authority to make any warranty or authorize any remedies in addition to or inconsistent with the terms of this warranty This warranty gives you specific legal rights You may also have other rights that vary from state to state The Outdoor Greatroom Company warrants that this Outdoor Greatroom Outdoor Product
Download Pdf Manuals
Related Search