User Manual - Camping World
Contents
1. SURGE GUARD RV Power Protection MODEL 34850 www SurgeGuard com MODEL 34830 PORTABLE PORTABLE INSTALLATION amp OPERATING INSTRUCTIONS INPUT POWER CORDS OVER UNDER VOLTAGE PROTECTION Should voltage drop below 102V or rise above 132V for more than 8 seconds power to RV is turned off SEE TIME DELAY INDICATOR The green LED indicates power to RV when illuminated TIME DELAY INDICATOR When unit is plugged in the red caution LED is flashing indicating delay The LCD at the same will count up to 128 seconds When the delay expires the red caution LED will stop flashing and power will be applied to the RV Time delay will also be applied to reset once power is restored to a safe range following the 128 second delay This allows head pressure to bleed off the A C Compressor SURGE FAILURE If the red SURGE indicator LED is on it means that the built in surge protection has been sacrificed to protect your equipment and is no longer functioning properly Other features will still function but the a amigas unit is recommended to be replaced POWER PROTEC www SurgeGuard com CAUTION LIGHT POLARITY PROTECTION Indicates possible mis wiring or current to ground condition present Will prevent power on 50 amp unit only The LCD screen will also indicate REVERSE POLARITY 38 n POWER PROTECTION www SurgeGuard com 3 MODE SURGE PROTECTION Protects the RV s sensitive electronic systems and appliances from po2. ain screen showing voltages and currents for power Lines 1 and 2 coming into the RV and a secondary screen showing whether power to the RV is ON or OFF with voltage for Line 1 coming into the RV The main screen for Model 34850 50Amp will show the voltages and currents for Lines 1 and 2 whereas Model 34830 will only show Line 1 since there is no Line 2 for that Model There are two rows or text lines on the LCD screen The top row for the main screen shows information for Line 1 in the following format 120V 50A This means that the voltage on power Line 1 coming into the RV is at 120 volts and the RV is drawing 50 amps of current on Line 1 The peat row of the main screen for 34850 shows voltage and current for ine 2 Model 34850 120V 25A 120V_25A Model 34830 Main Screen Secondary Screen The top row of the secondary screen for both models shows RV ON See and the bottom row shows the voltage on power Line 1 as If the power coming into the RV is less than 102 volts on either Line 1 or 2 then the main screen will show L1 Low or L2 Low in place of the voltage or current If the power coming in is greater than 132 volts then the main screen will show L1 High or L2 High Display During Fault Conditions When the Surge Guard is powered up the LCD screen will display ey and the elapsed time in L011 Sec seconds until it reaches 128 seconds After the delay is completed the unit will go to the Normal Operati
3. ng screen showing voltages and currents as described above If there is a fault condition during normal operation such as high or low voltage the unit will display that L1 or L2 is high or low and when power comes back within range 102V 132V the unit will seu the Delay as described above before returning to the main screen that shows the voltages and currents Reverse Polarity Conditions If the polarity of the voltages coming into the RV is REVERSE reversed then the ae Guer unit will display POLARITY the REVERSE POLAR until this condition is corrected Also current or voltages on ground will be displayed as reversed polarity
4. s verify RV power is on NOTE USING WITH POWER CORD ADAPTERS Purchased power cord adapters will work in most cases with Surge Guard but TRC does not recommend using them for full load applications due to the possibility of over heating Be advised that power cord adapters have been known to cause fires when Amps electrical current Ratings are exceeded Should you decide to use an adapter our recommendation is to check on the power cord from time to time to make sure it is not overheating TROUBLESHOOTING SYMPTOM CAUSE SOLUTION Caution light is There is a fault For reverse polarity flashing Read LCD for infor or voltage on mation ground move RV to new electrical source Only partial 1 Move to a new power at 50 source Amp source 2 Use inverter No power at or generator source power High or low voltage Change site or use is present at source inverter or generator power LCD reads less than 102V on first line or L1 L2 Low on either line When first plugging into pedestal power caution light flashes momentarily then goes out LCD DISPLAY INDICATORS Surge Expended Open Ground Any line wired to neutral S TY LT High 115V 32A 118V 2A L Hioh Voltage gt 132 118V_42A L2 Low Voltage lt 102 Current gt 130 Current gt 125 Temperature gt 200 F Display for Normal Operation During normal operation the Surge Guard s LCD screen alternates between two displays a m
5. tentially damaging power surge events without power interruptions to the RV OUTPUT POWER CORDS gt FOR YOUR RECORDS 2 y a MODEL NO C DATE PURCHASED TECHNOLOGY RESEARCH LLC A Southwire Company WHERE PURCHASED 5250 140th Avenue North Clearwater Florida 33760 727 535 0572 505 00088B TECHNICAL SPECIFICATIONS FEATURES Operating Current Operating Voltage Maximum Watts MODEL 34830 30 Amps 120 Volts 3600 Watts Yes L N L G N G 3850 Joules lt S00 VAC 6500A per MOV 6500A per MOV Yes Yes LCD Voltage amp current reading MODEL 34850 50 Amps 120 240 Volts 12000 Watts Yes L N L N L G 3 Mode Surge Protection N G L L Energy Dissipation Clamping Voltage Maximum Spike Current Over Under Voltage Protection Voltage Range Trip Time Yes 132 102V 8 10 seconds 130 200 F 128 seconds High Neutral Current Trip Plug Receptacle Temperature Trip Time Delay for A C Reverse Polarity Check Yes Voltage On Ground Check Yes LCD Voltage amp Power Indicator current reading Warranty Corrosion Resistant Easy Installation Industrial Contactor OPERATING INSTRUCTIONS MODELS 34830 34850 1 Plug the Surge Guard 34830 34850 into an approved RV receptacle and plug the RV power cord into the Surge Guard 2 Verify the delay indicator is flashing the LCD is counting The LCD will read between 102V and 132V 3 Once caution light stops flashing this takes 128 second
Download Pdf Manuals
Related Search