600344934 Traveler Lite 210 manual
Contents
1. Hand spray unit leaks Hand sprayer is defective Replace hand sprayer Water does not enter toilet bowl properly Insufficient water flow rate at toilet Water valve clogged Plugged rim wash holes in toilet Check water flow rate at toilet Rate should be 2 gpm 7 6 Ipm at toilet Remove and clean screen located on water valve Clean holes If still a problem replace toilet bowl Water is leaking from water valve Water valve body cracked due to freeze damage Water line connection is loose or not seated properly Defective water valve Stripped threads Replace water valve Insure that threads are not cross threaded and tighten Replace water valve Replace water valve Water is leaking from bottom of toilet base Toilet is not secured to floor Worn or defective toilet mounting floor seal Cracked base Worn or defective floor flange Tighten toilet mounting bolts Replace floor seal between floor flange and toilet base Replace base assembly Replace floor flange Water is leaking from rear of toilet bowl Worn or defective vacuum breaker Loose vacuum breaker Cracked or defective toilet bowl Remove white cap from vacuum breaker Flush toilet If water leaks during flush vacuum breaker needs to be replaced Secure vacuum breaker connection Replace toilet bowl If loose push breaker into bowl Water i2. FICATION The model identification label is located on the toilet base and will show the model number DOMETIC CORPORATION and serial number Remove base cover to P O BOX 38 13128 STATE RT 226 800 321 9886 locate identification label see page 3 BIG PRAIRIE OH 44611 USA movEL NO QQ SERIAL NUMBER 000000 HOW TO USE To prepare the Traveler Lite toilet for use check to be sure water supply to the toilet is connected Turn on water supply and check system for leaks Flush toilet and check for leaks To properly use the Traveler Lite toilet follow these simple instructions 1 To add water to the toilet lift or raise the flush lever until desired water level is reached Generally more water is required only when flushing solids 2 To flush toilet push lever all the way down until contents leave toilet bowl Water flow pressures vary at different locations therefore holding the flush lever down for 4 8 seconds may be required We require a minimum flow at the toilet of two gpm 7 6 Ipm for proper rim and bowl wash 3 Release flush lever by allowing it to snap back which permits positive sealing around the flush ball 4 Asmall amount of water should remain in bowl Note Holding flush lever down longer than necessary results in excessive water usage INSTALLATION 1 To replace an older toilet turn off water supply to toilet Disconnect water line at toilet water valve Unscrew floor bolt nuts an
3. OR DAMAGES RESULTING FROM IMPROPER INSTALLATION OR FOR DAMAGES CAUSED BY NEGLECT ABUSE ALTERATION OR USE OF UNAUTHORIZED COMPONENTS THIS INCLUDES FAILURES WHICH MAY RESULT FROM NOT FOLLOW ING THE WINTERIZATION OR CLEANING PROCEDURES AS DESCRIBED ON PAGE 5 OF THIS OWNER S MANUAL ALL IMPLIED WARRANTIES INCLUDING ANY IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR ANY PARTICULAR PURPOSE ARE LIMITED TOA PERIOD OF ONE 1 YEAR FROM DATE OF PURCHASE IMPLIED WARRANTIES No person is authorized to change add to or create any warranty or obligation other than that set forth herein Implied warranties including those of merchantability and fitness for a particular purpose are limited to one 1 year from the date of purchase for products used for personal family or house hold like purposes and ninety 90 days from the date of purchase for products placed in com mercial or business use OTHER RIGHTS Some states do not allow limitations on the duration of an implied warranty and some states do not allow exclusions or limitations regarding incidental or consequential damages so the above limitations may not apply to you This warranty gives you specific legal rights and you may have other rights which vary from state to state To obtain warranty service first contact your local dealer from whom you purchased this product O Dometic mae Dometic Corporation Sanitation Systems 13128 State Rt 226 P O Box 38 Big Prairi
4. TRAVELER LITE FINE CHINA TOILET OWNER S MANUAL Traveler Lite Toilet Model 210 O Dometic as Dometic Corporation Sanitation Systems 13128 State Rt 226 PO Box 38 Big Prairie OH 44611 SeaLand Product Hotline 1 800 321 9886 8 00 a m 5 00 p m ET TABLE OF CONTENTS Important Information ceeeeeeeeeeeee 2 Winterizing wicsiscaccverccesveelceeds sincascisacceesaeceee 4 Toilet Model Identification wd Deodorants and Special Tissue 5 How to Use uu eee Troubleshooting cceeeeees 6 7 Installati n eia iaeei taaan 3 Warranty ANE NEEE EE E EET 8 Proper Cleaning and Maintenance 4 IMPORTANT INFORMATION 1 Do not use chlorine or caustic chemicals such as laundry bleach or drain opening types in the system These products damage the seals in toilets and dump valves 2 Do not permit foreign objects paper towels paper cups diapers sanitary napkins etc to be flushed through the toilet 3 Mechanical seal toilets like SeaLand Traveler Lite units are designed to only discharge directly into a holding tank Horizontal pipe runs as found in conventional residential or commercial plumbing systems cannot be accommodated 4 Toilet bowl and flush seals must be regularly cleaned and winterized according to Proper Cleaning and Maintenance and Winterizing procedures on page 4 or your warranty coverage may be voided TOILET MODEL IDENTI
5. al with opening on side of cover Push base cover back until it locks into place making sure it does not interfere with flush pedal operation Figure E Removing Pedal Cover 1 Press tab on back of pedal to release pedal 1 Co cover pt n m 7 a 2 Pull cover forward to remove it Cover snaps Dand back into place i Traveler Lite Model 210 2 bolt connection two wood screws in rear of base PROPER CLEANING AND MAINTENANCE The Traveler Lite toilet should be cleaned regularly for maximum sanitation and operational efficiency You can clean it just as you would a household toilet Do not use caustic chemicals such as drain opening types as they will damage the seals BOWL CLEANING For stubborn stains use SeaLand Bowl and Seal Cleaner Fig A It s manufactured especially for use with Traveler Lite toilets In certain locations where water is hard a build up of lime may dull the toilet bowl finish Restore the shine with this SeaLand cleaner If you cannot find it in your area contact Dometic for your nearest dealer If the cleaner is not available you can also use Bar Keepers Friend cleanser It is not necessary to vigorously scrub with either product Please follow label instructions SEAL CLEANING After an extended time mineral deposits from hard water can build up under the edge of the rubber bowl seal resulting in a slow leakdown of water from the bowl To prevent th
6. d remove toilet Discard old floor seal and mounting bolts The old floor flange may be used if it is in good condition 2 When installing new floor flange make certain that the toilet mounting bolts align properly with Traveler Lite toilet mounting pattern Figure A 3 Secure flange to floor using flat head screws through countersunk holes in flange Insert floor bolts into slotted holes in flange Figure A 4 If toilet is being installed in a shower stall apply a 1 4 thick by 3 4 wide bead of glazing compound around the circumference of the floor flange Figure B 5 Position floor seal by pressing the floor bolts up through holes in the seal 6 Set toilet in place with bolts protruding up through mounting holes in base Figure C 7 Install washers and hex nuts provided with toilet Snug nuts down equally with standard 7 16 open end wrench Remove excess glazing compound from around base in shower stall installation Install two wood screws provided in two holes at rear of base See Figure C 8 Remove pedal cover from flush pedal before connecting water supply line see instructions below Connect water supply line to water valve 1 2 MPT inlet using appropriate fittings or an extension Figure D 9 Turn on water supply and flush toilet to test for leaks 10 Re attach pedal cover to flush pedal after making sure there are no leaks at connections 11 Put base cover in front of toilet base aligning flush ped
7. e OH 44611 0038 USA SeaLand Product Hotline 1 800 321 9886 8 00 a m 5 00 p m ET Registered Trademark of Dometic Corporation Bar Keepers Friend is a trademark of Servaas Laboratories Teflon is a registered trademark of Du Pont Co Dometic Corporation 600344934 3 04 8
8. esives prevent the tissue from breaking apart and their use in ultra low flow systems can cause system clogging SeaLand tissue is especially designed for use in low water toilet systems Its rapid dissolving properties minimize the amount of residual paper in the holding tank and allow deodorizers to work more efficiently SeaLand Brand versus Other Brands We constantly strive to provide our system owners with effective products that have minimal environmental impact and good value Many deodorant products do not measure up to our standards of performance and value SeaLand Liquid Deodorant Environment Friendly 32 oz bottle Part No Anpeid Dissadving Tether Tine 379114032 Poplor de pallette a diisolution rede SeaLand SeaLand Rapid Dissolving Cleaner Toilet Tissue 16 oz bottle Four 400 sheet rolls Part No Part No 379441204 379314016 TROUBLESHOOTING GUIDE TRAVELER LITE BASE ASSEMBLY WATER VALVE ASSEMBLY TOP VALVE CAP FILTER SCREEN VALVE SCREWS PEDAL COVER Problem 1 Toilet emits odor flush ball open ADJUSTING NUT FLUSH BALL FLUSH PEDAL SPRING CARTRIDGE VALVE BODY VACUUM BREAKER BALL SEAL TRAVELER LITE TOILET BOWL REAR VIEW HOSE CONNECTION VACUUM BREAKER BOWL CONNECTION Possible Cause Odor emitting from base of toilet Plugged holding tank vent line Service Instructions Use SeaLand brand deod
9. is mineral build up periodically clean under the bowl seal with SeaLand Bowl and Seal Cleaner Fig B 1 Shut off water supply 2 Apply cleaner onto the seal cleaning tool supplied with new toilet open the flush ball by pressing on flush lever and scrub under the seal Make sure to push bristles between bottom of seal and top of flush ball surface to scrub all parts of seal that come into contact with flush ball 3 Close ball and wait 2 3 minutes 4 Open flush ball Use brush and water to rinse away cleanser and loosened deposits WINTERIZING At the end of each season the Traveler Lite toilet should be winterized for storage by either draining or using potable water safe antifreeze in the system To drain 1 Thoroughly flush system with fresh water 2 Empty holding tank 3 Shut off water supply to toilet and remove inlet waterline Fig C Do not remove brass cap on bottom of valve 4 Press flush lever until all water is drained from toilet To use antifreeze 1 Drain potable water tank 2 Add freshwater antifreeze to potable water tank 3 Flush potable water antifreeze and water mixture through toilet and into the waste holding tank Each installation is different so amounts may vary User discretion is required to assure adequate protection 4 Empty holding tank NOTE Use nontoxic antifreeze designated for potable water systems See vehicle owner s manual Never use automotive
10. orants Clear obstruction from vent line Water will not stay in bowl Loose band clamp Improper seal around flush ball due to dirt or debris on underside of ball seal Worn or damaged seal Worn or damaged flush ball Tighten adjusting screw Inspect flush ball and underside of seal Clean under seal if needed see page 4 Cleaning tool available part no 600344236 Replace seal i Replace flush ball Flush ball will not close completely Too much friction between flush ball and ball seal Water valve screws are too tight Lubricate between flush ball and ball seal with furniture polish or cooking spray Loosen screws slightly TROUBLESHOOTING GUIDE cont d Problem Flush ball will not close completely continued Possible Cause Defective spring cartridge Service Instructions Check spring tension by pushing flush lever down then release it suddenly If lever does not snap back to original position replace spring cartridge Flush ball will not open Broken shaft Shaft not fully engaged in the spring cartridge Replace shaft Rotate flush ball slightly until shaft lines up with square in spring cartridge and is fully engaged Water does not shut off in toilet toilet overflows Worn or defective water valve Worn or defective spring cartridge Replace water valve Replace spring cartridge
11. s leaking from the base toilet connection Band clamp may be loose Ball and bowl seals may be worn or defective Remove plastic base cover on applicable models and tighten the band clamp Replace ball and bowl seals MANUFACTURER S 3 YEAR AND 10 YEAR LIMITED WARRANTY Dometic Corporation warrants to the original purchaser only that this SeaLand gravity dis charge toilet if used for personal family or household like purposes is free from defects in material and workmanship for a period of three 3 years from the date of purchase Dometic also warrants to the original purchaser only that the ceramic portion of the toilet bowl will not discolor stain scratch or craze for a period of ten 10 years if used for personal family or household like purposes and is regularly cleaned as described in the product s owner s manual If this Dometic product is placed in commercial or business use it will be warranted to the original purchaser only to be free of defects in material and workmanship for a period of ninety 90 days from the date of purchase Dometic reserves the right to replace or repair any part of this product that proves upon inspec tion by Dometic to be defective in material or workmanship All labor and transportation costs or charges incidental to warranty service are to be borne by the purchaser user EXCLUSIONS IN NO EVENT SHALL DOMETIC BE LIABLE FOR INCIDENTAL OR CONSEQUENTIAL DAMAGES F
12. type antifreeze in freshwater systems 4 DEODORANTS AND SPECIAL TISSUE Your Traveler Lite toilet requires the regular addition of a deodorant product to reduce malodors and to help break down holding tank contents Several factors should be consid ered in selecting a deodorant product Liquid or Granulated Liquid products work more quickly by readily going into solution Granulated powder formulations have the advantage of requiring less storage space and are less likely to leak if the package is inadvertently damaged Formaldehyde versus Non Formaldehyde Dometic manufactures both types of deodor ants Generally speaking formaldehyde formulas control odor very effectively at all tempera tures and with all degrees of water hardness SeaLand Environment Friendly brand which is formaldehyde free is similarly effective How Much Deodorant and How to Add It The deodorant is added directly into the toilet bowl then flushed into the holding tank Follow bottle or package instructions Conditions of extremely warm weather longer waste holding time and larger tank capacities may require more deodorant treatment Also to maintain optimum efficiency in odor control the waste holding tank should be cleaned thoroughly at least once or more each season depending on use Why Not Use Household Toilet Paper in Your Toilet Household tissues often contain adhesives which bond together the paper fibers from which the tissue is made The adh
Download Pdf Manuals
Related Search