EZ Sprayer Instruction Manual.indd
Contents
1. 3 7X10 1 Gasket ring for nozzle Elbow 5 Spray rod _ P N i9 Flat washer 05 Self Mam 5 Anchor arm 1 Self tap screws 3 7X1 C D F 4 uy e D ountersink screw M5X15 Tube clamp 0 ring idge Valve cartridge TM Spring _ G inc Switch fi 8 A Nylon layer Tube couplings ountersink screw M X10 1 1 1 e Limit cap 5 58 Hold down plate 1 Pin of swith asket ring for handle 2 witch filter screen Protective seal C Screen frame Screen cover Vent valve Holding tank cover Large screen 5 5 5 5 5 5 5 5 6 val nozzle IB Fan spray nozzle hole adjustable nozzl Charger 2 5 26 2 2 9 0 2 3 4 5 6 7 3 9 4 M Gasket of switch 77 28 2 EU EE 32 33 EH 35 E E E 32 A mr Un Un E J2 2 3 d 4 d 5 d 6 d 7 EN 8 9 d 0 d E 2 ER O ring for valve cartridge 1 3 d ES 4 EN 2 5 ER 2 6 d EB 7 d 8 d 1 9 d ETE 0 d EN 2 d EM 6 i i TROUBLESHOOTING PROBLEMS causes SOLUTIONS Motor fails to start after Power cable Dismantle base to being powered on disconnected reconnect cables Battery 15 not charged Charge battery Damaged power switch Replace switch Abnormal motor sound Fastening screws of pump Tighten screws are loose Leakage occurring2. 4 0 45Mpa PRESSURE FLOWRATE SPRAY NOZZLE TYPE Mpa GPM Conical Spray 0 29 0 32 184 211 Flat Fan Spray 0 16 0 17 317 343 4 Hole Adjustable 0 27 0 28 211 224 Double Conical Spray 0 17 0 18 422 449 OPERATING INSTRUCTIONS Be sure to fully charge the battery prior to operation Fill the holding tank with prepared liquid through the screen and screw on cover Inspect full holding tank for any leakage Turn on power switch and squeeze spray lever to start spraying There are four nozzles to choose from e CONICALSPRAY NOZZLE sprays a cone shape with fluid flow throughout the cone angle e FLATFAN NOZZLE sprays a pattern that is a fan configuration in one axis and flat in the other axis e 4 HOLEADJUSTABLE NOZZLE sprays a light misty cone pattern or a full saturated spray pattern depending on the adjustment of the nozzle e DOUBLE CONICAL SPRAY NOZZLE sprays a dual cone shapes with fluid flow throughout the 2 cone angles OPERATING NOTES Charge the battery until the charger s Green Charged light comes on indicat ing that the battery is fully charged Never operate the sprayer without liquid in it or it may damage the diaphragm In case of humming sound from inside the sprayer or poor atomization after long time use recharge the battery Battery must be charged at least 8 hours Keep charger in a dry well ventilated safe place Test sprayer with water prior to use
3. at e Inlet and or outlet tubes of Dismantle base and bottom of sprayer base pump are damaged or not tighten tube clamps securely connected and or replace tubing Poor atomization Clogged spray nozzle Clean nozzle Spray nozzle worn out Replace spray nozzle Spray sheet inverted Correct Clogged filter screen Clean Tubes not securely Tighten connected Battery low on power Alarm not working replace and recharge Air remaining in pump Remove nozzle or spray rod to discharge air TROUBLESHOOTING TIP If the unit functions properly then just stops spraying you probably have an air bubble in the unit oo 009 This is simple to fix Remove the lid and reach your hand inside the unit through the top 5 mouth Remove the silver screen filter off of the bottom MGE p y le DES LE hs of the unit by gently pulling up on it E Pour a few inches of water into the bottom of the unit Take a garden hose and cover the opening where the silver screen was Turn on the hose while squeezing the trigger with the unit turned on This will push the air out and the unit will function properly Replace the silver screen www nationalgardenwholesale com Printed in China
4. made to last repeated uses e Superior TRIPLE SCREEN PROTECTION prevents foreign matter and particles from clogging the nozzle The triple screen can be easily dismantled and cleaned e The UNDER VOLTAGE ALARM will go off if the battery power goes below 10 5V This protects the battery The included charg ing adapter can be used as a 12V power supply as well as a charging unit eThe CHARGING ADAPTER features intelligent charging constant current con stant voltage maintenance and short circuit over current inverse connection protection The charger indicator lamps are as follows Red Charging and Green Charged Stand by Just slide the The battery charger socket Large fill screen keeps automatic lock into place is conveniently located contaminates from getting for continual spray use at the base of EZ Sprayer into the holding tank An additional 3 nozzles included flat fan nozzle 1 split conical nozzle and 1 he nozzle gt A wand holder is molded into the Ergonomic 4 gallon tank design surta E EM ii body of the EZ Sprayer allows EZ Sprayer to across the floor with ease making transport and storage easy comfortably mount on your back TECHNICAL INFORMATION Type Backpack or Floor Use Size 21 6 high X 15 wide X 7 5 deep Net Weight 16 75 lbs Holding Tank Capacity 4 Gallons Pump Mini Diaphragm Pump Battery 12V Charger Input AC110 240V 50 60HZ Output DC12V 2A Max Pressure 0
5. to assure that no leakage occurs and that proper atomization occurs CAUTION e Always wear a mask and gloves when operat ing EZ Sprayer Always remain fully clothed to avoid skin contact with overspray e Never spray pesticides against the wind Never spray at humans animals or food e Never operate this sprayer in temperatures exceeding 112 F or lower than 15 F Always comply with safety instructions of liquid you are spraying e Never use sprayer for strong acid or flammable liquids Never use high persistent and toxic pesticides on vegetables fruit trees herbs or medicinal plants e Always clean unit thoroughly after each use to avoid corrosion clogging and contamination of future spray liquids Clean exterior by scrubbing with wet cloth Clean interior by filling holding tank with a small amount of water and shaking before turning on power to discharge Never immerse machine in water for any reason e Switch off power before storage e Do not use sprayer near fire e Never use sprayer for dry ingredients use only liquids e Unauthorized removal of the charger s housing will void warranty COMPONENT DIAGRAM ape x 7 Bossa aTY _1 TERA Cover of opening 1 EHI Conical mist spray sheet 1 PEN Sleeve of tube gt clam 2 Shoulder strap 2 Rubber tube ETH Shoulder strap cushion 2 E Strap dasp 2 Ed Strap hook 2 _Self tap screw
6. EZ SPHAYER EX Battery Powered Sprayer Table of Contents Overview Page 1 E 5 i 7 A 5 cd cd Po a MEN js mm ER m E a Teoublechooting caus anni MP c Thank you for purchasing EZ Sprayer M Please familiarize yourself with the EZ Sprayer User Manual for proper operation and maintenance of your new sprayer OVERVIEW 4 Gallon Battery Powered backpack floor use EZ Sprayer is designed to withstand the most demanding spraying needs This heavy duty European designed sprayer is safe easy to operate amp incorporates shoulder straps for use as a backpack sprayer This sprayer is ideal for applying liquid fertilizer nutrients insec ticides fungicides disinfectants etc Powered by a 12V battery this sprayer is much more efficient than a manual sprayer EZ Sprayer can be operated continuously for up to 10 hours amp spray up to 100 gallons of liquid on a single battery charge which consumes only 0 3 kwh of electricity COMPONENTS The EZ Sprayer consists of a holding tank a base a battery a mini pump a charger a spraying system rubber tubes switch spraying rod nozzle shoulder straps and rollers o FEATURES e The HOLDING TANK is ergonomically designed to comfortably mount on your back e Includes compact MINI DIAPHRAGM PUMP that is light weight highly pressurized featuring a pressure limit protection switch and
Download Pdf Manuals
Related Search