Owner`s Manual - Invacare Continuing Care
Contents
1. Invacare TheraPure Supine Whirlpool Tubs 8 Part No 1167456 1167456 3 OVERVIEW Shower Massage ON OFF Button Shower Massage Wand Fill Spout Shower Spray Adjustment Flow Control N Valve 9 Invacare TheraPure Supine Whirlpool Tubs 3 OVERVIEW 3 2 Product Labeling Labels located inside the Service Access Door D INVACARE CONTINUING CARE INC H 40 USA 4 DANGER ELECTRICAL SHOCK HAZARD CAUTION MODEL NO SERIAL NO MFG DATE Hes fauit Some state local plumbing codes require the circuit interrupter GFCI on all 1 installation of a reduced pressure zone RPZ assembl therapeutic pools and tubs DO NOT operate or service F vours _115_ vac hydro therapeutic tanks Failure on both the incoming hot and cold supply lines to prevent to follow thle requirement could s equipment without first back flow contamination into the potable water system amps _ 7 0 Max Continuous Duty result in serious or fatal injury reading and understanding Hack cael isascembly and maintenance th l nvacare recommends you check local plumbing code 60 of the Tub MUST be dania by a io user manual requirements to determine if RPZs are required on your electrician or plumber Disconnect i C eui A tub installation RPZs are NOT supplied by Invacare and m ical supply or turn OFF ev 4 circ2. Clean the pieces with Dispatch Cleaner and Disinfectant Lay the pieces in the bottom of the tub Spray all surfaces of the tub with Dispatch Cleaner and Disinfectant Take a long handled brush and thoroughly clean the interior surfaces of the tub and the jet casings 5 Allow the Dispatch Cleaner and Disinfectant to sit on the surfaces for one minute 6 Rinse all surfaces and pieces of the jet assemblies with water 7 Use a clean towel to dry all tub surfaces Invacare TheraPure Supine Whirlpool Tubs 24 Part No 1167456 5 OPERATION 8 Replace the impeller and impeller cap on each jet assembly by rotating them counterclockwise Cross threading the jet assembly onto the casing may cause damage to the whirlpool motor After installation ensure that the jet assembly is flush against the jet casing Sanijet 9 Assemble each jet assembly to the jet casings A Position the Sanijet logo and red indicator at the 11 o clock position B Insert the jet assembly into the jet casing and rotate the jet assembly clockwise until it locks into place Removing Soap Film and Hard Water Deposits Use a commercially available cleaner such as Invacare Heavy Duty Cleaner Remove the jet assemblies Remove the impeller caps Thoroughly spray the exposed surfaces including the jet casings Use a long handled soft brush or similar product to wipe down all surfaces and allow the heavy duty cleaner to remain in contact with the exposed
3. DO NOT adjust the tub so it hits the stretcher lift If necessary adjust the height of the stretcher lift NND UN Otherwise damage to the tub may occur The tub stops automatically when the maximum height adjustment UP or DOWN is reached Perform one of the following Press and hold the UP button Release the UP button when the desired height is reached e Press and hold the DOWN button Release the DOWN button when the desired height is reached Invacare TheraPure Supine Whirlpool Tubs 28 Part No 1167456 6 INSPECTION MAINTENANCE AND TROUBLESHOOTING 6 Inspection Maintenance and Troubleshooting If any part of the system is not functioning properly DO NOT use the system For parts and technical service information please contact ICC Technical Service at 800 668 2337 Extension 2 6 1 Safety Inspection Checklists Every six months or as necessary have a qualified technician perform a thorough inspection and servicing Routine maintenance will extend the life and efficiency of your tub Initially Clean and Disinfect the tub Refer to Cleaning and Disinfecting on page 23 Visually inspect plumbing for leaks Make repairs as necessary Ensure that the maximum water supply temperature does not exceed 10 F Ensure that the maximum water pressure does not exceed 55 PSI Verify the water flow temperature with a separate thermometer Visually inspect for cracks in the tub surface Check that all labels are present an
4. Warnings Signal words are used in this manual and apply to hazards or unsafe practices which could result in personal injury or property damage See the information below for definitions of the signal words A DANGER Danger indicates an imminently hazardous situation which if not avoided will result in death or serious injury A WARNING Warning indicates a potentially hazardous situation which if not avoided could result in death or serious injury A CAUTION Caution indicates a potentially hazardous situation which if not avoided may result in property damage or minor injury or both IMPORTANT Indicates a hazardous situation that could result in damage to property if it is not avoided Gives useful tips recommendations and information for efficient trouble free use Invacare TheraPure Supine Whirlpool Tubs 4 Part 1167456 GENERAL 1 2 Limited Warranty PLEASE NOTE THE WARRANTY BELOW HAS BEEN DRAFTED TO COMPLY WITH FEDERAL LAW APPLICABLE TO PRODUCTS MANUFACTURED AFTER JULY 4 1975 This warranty is extended only to the original purchaser user of our products This warranty gives you specific legal rights and you may also have other legal rights which vary from state to state Invacare Continuing Care Inc ICC 1 warrants its bathing whirlpool products to be free from defects in materials and workmanship for a period of three years from the date of purchase Warranty obligation is limited to parts replacement
5. NOT lift the tub by the plumbing DO NOT modify the tub in any way Modifications to the system or any component may cause the system to malfunction and will void the warranty 4 Preparing the Work Area Access for servicing the tub MUST be provided Follow the recommended floor plan when installing the tub Refer to Minimum Floor Space and Clearance Requirements on page 13 Carefully remove the tub from the carton and inspect for shipping damage If damage is found contact the carrier 2 Remove the tub from the shipping pallet by removing the screws from the leg mounting pads Invacare TheraPure Supine Whirlpool Tubs 14 1167456 4 0 Tub Dimensions and Connection Details lt a 94 4 INSTALLATION 38 Connection Location Type 10 254 mm from centerline 5 5 140 mm up from floor 3 4 Cold water stub with recommended shut off valve D 5 127 mm from centerline 29 736 mm from tub back edge 2 Drain floor drain recommended E 10 5 267 mm from centerline I 15V AC 60 Hz 15 A Input H 6 5 165 mm from centerline 5 5 140 mm up from floor 3 4 Hot water stub with recommended shut off valve Part No 1167456 Invacare TheraPure Supine Whirlpool Tubs 4 INSTALLATION 4 3 Securing the Tub A WARNINGS Protective eye wear MUST be worn when drilling to avoid possible eye injury DO NOT
6. Sanijet and Pipeless TM are registered trademarks of Maple Industries LLC d b a Sanijet ExactTemp is a registered trademark of Moen Incorporated Betadine is a registered trademark of Purdue Pharma LP Rev C 12 11
7. breaker before installing or performing any maintenance on the tub The National Electric Code requires the use of a ground fault circuit interrupter on all therapeutic pools and tubs hydro therapeutic tanks Failure to follow this requirement could result in serious or fatal injury Use a 15 breaker only Be certain ALL electrical work is performed by a qualified electrician and is in compliance with local electrical codes ALL electrical connections MUST be water resistant WARNINGS The unit MUST be connected only to a supply circuit that is protected by a ground fault circuit interrupter GFCI Such a GFCI should be provided by the installer and should be tested on a routine basis To test the GFCI push the test button The GFCI should interrupt power Push the reset button Power should be restored If the GFCI fails to operate in this manner GFCI is defective If the GFCI interrupts power to the bathtub without the test button being pushed a ground current is flowing indicating the possibility of an electric shock DO NOT use this tub Disconnect the tub and have the problem corrected by a qualified service representative BEFORE use All electrical conduit fittings and wire to unit are to be supplied and installed by a professional electrician in accordance with the National electrical code as a minimum requirement including the supply and installation of a Ground Fault Circuit Interrupter GFCI For Canadian installation g
8. surfaces for approximately ten minutes Rinse off surfaces using the shower wand adjusted to spray position Removing Calcium Deposits Scale and Lime Build up Spray a commercially available cleaner full strength for the intended application on all surfaces to be cleaned Allow the cleaner to remain in contact with surfaces for at least five minutes to as long as 12 hours Rinse off surfaces using the shower wand adjusted to the spray position Use the cleaner according to the manufacturer s instructions Part No 1167456 25 Invacare TheraPure Supine Whirlpool Tubs 5 OPERATION 5 3 Water Temperature Setting WARNING The causes symptoms and effects of hyperthermia may be described as follows Hyperthermia occurs when the internal temperature of the body reaches a level several degrees above the normal body temperature of 98 6 F The symptoms of hyperthermia include an increase in the internal temperature of the body dizziness lethargy drowsiness and fainting The effects of hyperthermia include Failure to perceive heat Failure to recognize the need to exit the spa or hot tub Unawareness of impending hazard Fetal damage in pregnant women Physical inability to exit the spa or hot tub Unconsciousness resulting in the danger of drowning The use of alcohol drugs or medication can greatly increase the risk of fatal hyperthermia Flow Water Thermometer measures the temperature of water coming from the tub fill spou
9. Invacare TheraPure Supine Whirlpool Tubs Model 6302G EE do Model 6302GADH d User Manual L This manual MUST be given to the user of the product C BEFORE using this product read this manual and save for future reference Yes you can CONTENTS GENERAL 4 Oud M 4 Limited Wartanty DRE 5 SAFETY 6 eren cL M P Pr 6 Important Safety Information eed ter e e Apes De cesi de UA ect E deci ce cepe ete Ute teat 6 OVERVIEW 8 Features Product Labeling 10 Typical Product Parameters 5 o o t 11 Minimum Floor Space and Clearance lt 13 INSTALLATION 14 Preparing the Work Area 14 Tub Dimerisions and Connection Details 3 1 inet tienes dene e ode er LERRA ee EE Fe AUI EE NE D e oed eee 15 Securing the Ub ten eed dei a E T e t Ren pes l6 Leveling the M 16 Electrical Installations sickened du ie d ecc isa naw daria teh eR aie 17 Pluribing Connection Details eb bet peti a die RUE cot once PUR HER Ree RCRUM ede de UR eee ALE athe 18 Plumbing Instal
10. NY CONSEQUENTIAL OR INCIDENTAL DAMAGES WHATSOEVER THIS WARRANTY SHALL BE EXTENDED TO COMPLY WITH STATE PROVINCIAL LAWS AND REQUIREMENTS Part No 1167456 5 Invacare TheraPure Supine Whirlpool Tubs 2 SAFETY 2 Safety The Safety section contains important information for the safe operation and use of this product 2 General Guidelines A WARNING DO NOT use this product or any available optional equipment without first completely reading and understanding these instructions and any additional instructional material such as owner s manuals service manuals or instruction sheets supplied with this product or optional equipment If you are unable to understand the warnings cautions or instructions contact a healthcare professional dealer or technical personnel before attempting to use this equipment otherwise injury or damage may occur ACCESSORIES WARNING Invacare products are specifically designed and manufactured for use in conjunction with Invacare accessories Accessories designed by other manufacturers have not been tested by Invacare and are not recommended for use with Invacare products NOTICE THE INFORMATION CONTAINED IN THIS DOCUMENT IS SUBJECT TO CHANGE WITHOUT NOTICE 2 2 Important Safety Information DANGERS ELECTRICAL SHOCK HAZARD Grounding is required The installation and maintenance of the tub MUST be done by a qualified technician certified electrician or plumber Disconnect electrical supply or
11. T ES CN E In House Water Service HOT J COLD Optional Pressure Regulator Mixing Valve Tub Spout Shower Control Valve Tub Fill Valve Shower Massage Wand Backflow Preventor located inside tub cabinet Part No 1167456 19 Invacare TheraPure Supine Whirlpool Tubs 4 INSTALLATION 4 8 Post Installation Checklist Before putting the tub into service check the following Water lines have been purged of any foreign matter Both hot and cold water lines are properly connected to the tub All water lines are checked for leaks Power line is protected by a 15 AMP GFCI ICCI skin care and cleaning products have been ordered To place your order call 800 668 2337 CoccUOZOZO ICCI representative has been called to arrange for an In Service on the tub To schedule call 800 668 2337 Invacare TheraPure Supine Whirlpool Tubs 20 Part No 1167456 5 OPERATION 5 Operation 5 1 Overview WARNINGS A Read and understand ALL information in this manual BEFORE use Clean and disinfect the tub after EACH use to avoid resident infection and contamination of the tub DO NOT clean or disinfect the tub when it is occupied Otherwise injury may occur To reduce the risk of injury DO NOT permit children or infirm persons to use this tub UNLESS THEY ARE SUPERVISED ALL TIMES Recommended length of time spent in a bath is 5 to 10 minutes However if you or the person you are caring fo
12. The symptoms of hyperthermia include an increase of the internal temperature of the body dizziness lethargy drowsiness and fainting The tub is specifically designed to be used with a bath lift ICCI recommends use of the Stretcher Lift Model 1200 ONLY Bath lifts designed by other manufacturers are NOT to be used with the tub Use the Stretcher Lift Model 1200 to maintain resident safety and product utility Refer to the lift owner s manual for complete lift operating and safety instructions To reduce the risk of injury DO NOT permit children or infirm persons to use this tub UNLESS THEY ARE SUPERVISED AT ALL TIMES Recommended length of time spent in a bath is 5 to 10 minutes However if you or the person you are caring for becomes nauseated or dizzy or the person develops a headache get out of the tub at once and safely bring the body temperature back to normal 98 6 F Seek medical attention if symptoms or sickness persist Check with the physician BEFORE using the tub again Anyone under a doctor s supervision pregnant or with poor health should check with a physician BEFORE using this tub gt Part No 1167456 7 Invacare TheraPure Supine Whirlpool Tubs 3 OVERVIEW 3 Overview 3 1 Features Tub Raise and Lower Buttons Model 6302GADH ONLY Water Temperature Thermometer Whirlpool ON OFF Button Fill Button Push in once to auto fill push in and hold to add additional water to tub Water Temperature Control
13. VES RINGS SEALS PARTS BROKEN DUE TO ABUSE OR IMPROPER USE ITEMS THAT BECOME INOPERABLE DUE TO LACK OF MAINTENANCE OR NON COMPATIBLE CHEMICALS STAINS DUE TO HARD WATER IODINE SOLUTIONS OR OTHER UNAPPROVED CHEMICALS SPIDER CRACKS OR CRACKING DUE TO MISHANDLING OR ABUSE IN ADDITION THE FOREGOING WARRANTY SHALL NOT APPLY TO SERIAL NUMBERED PRODUCTS IF THE SERIAL NUMBER HAS BEEN REMOVED OR DEFACED PRODUCTS SUBJECTED TO NEGLIGENCE ACCIDENT IMPROPER OPERATION MAINTENANCE OR STORAGE OR PRODUCTS MODIFIED WITHOUT ICCI S EXPRESS WRITTEN CONSENT INCLUDING BUT NOT LIMITED TO MODIFICATION THROUGH THE USE OF UNAUTHORIZED PARTS OR ATTACHMENTS PRODUCTS DAMAGED BY REASON OF REPAIRS MADE TO ANY COMPONENT WITHOUT THE SPECIFIC CONSENT OF PRODUCTS DAMAGED BY CIRCUMSTANCES BEYOND ICCI S CONTROL PRODUCTS REPAIRED BY ANYONE OTHER THAN AN ICCI DEALER SUCH EVALUATION SHALL BE SOLELY DETERMINED BY ICCI THE FOREGOING EXPRESS WARRANTY IS EXCLUSIVE AND IN LIEU OF ANY OTHER WARRANTIES WHATSOEVER WHETHER EXPRESS OR IMPLIED INCLUDING THE IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE AND THE SOLE REMEDY FOR VIOLATIONS OF ANY WARRANTY WHATSOEVER SHALL BE LIMITED TO REPAIR OR REPLACEMENT OF THE DEFECTIVE PRODUCT PURSUANT TO THE TERMS CONTAINED HEREIN THE APPLICATION OF ANY IMPLIED WARRANTY WHATSOEVER SHALL NOT EXTEND BEYOND THE DURATION OF THE EXPRESS WARRANTY PROVIDED HEREIN THE MANUFACTURER SHALL NOT BE LIABLE FOR A
14. adjust height of legs more than inch The leg will disassemble from leg mounting pad and serious injury may occur Setthe tub in place 2 Ensure the plumbing and electrical hook ups have been installed 3 Mark the locations of the anchor holes using pre drilled holes in leg mounting pads as a template 4 Move the tub away from the mounting area 5 Drill anchor holes in floor Use jack drill and carbide bit in concrete or a wood bit for wood floors 6 Reposition the tub in the mounting area aligning the holes in the leg mounting pads with the holes drilled in STEP 4 4 4 Leveling the Tub l Level the tub by adjusting the telescopic legs either up or down using a wrench to arrive at the desired height 2 Check to make sure the tub is level by placing a level on the front and sides of the tub Repeat STEPS and 2 until the tub is level 4 Secure the legs to the floor using fasteners appropriate to the floor material and in keeping with local codes Invacare TheraPure Supine Whirlpool Tubs SECURING LEGS TO FLOOR Leg Leg Mounting Pad Lag Bolt Lag Bolt Anchors LEVELING SIDE TO SIDE Part No 1167456 4 INSTALLATION 4 5 Electrical Installation AN DANGERS ELECTRICAL SHOCK HAZARD Grounding is required The installation and maintenance of the tub MUST be done by a qualified technician certified electrician or plumber Disconnect electrical supply or turn off circuit
15. d legible Replace if necessary Before Each Use Clean and Disinfect the tub Refer to Cleaning and Disinfecting on page 23 Ensure that the maximum water fill temperature does not exceed 10 F 43 C Ensure that the maximum water pressure does not exceed 55 PSI Visually inspect for cracks in the tub surface Every Six Months Verify the water flow temperature with a separate thermometer Visually inspect plumbing for leaks Make repairs as necessary Visually inspect the power cord for damage or breakage Replace if necessary Check that all labels are present and legible Replace if necessary Clean the Water Temperature Control Valve to remove lime deposits Refer to Removing Calcium Deposits Scale and Lime Build up on page 25 6302GADH ONLY Apply white lithium grease to Glide Pads Refer to Refer to Maintenance for 6302GADH Adjustable Height Rub Panels and Glide Pads on page 30 Part No 1167456 29 Invacare TheraPure Supine Whirlpool Tubs 6 INSPECTION MAINTENANCE AND TROUBLESHOOTING 6 2 Maintenance for 6302GADH Adjustable Height Rub Panels and Glide Pads The application of white lithium grease to the glide pads must be done every six months to keep the tub in good working order l Remove the side panel to access the rub panels and glide pads 2 Generously apply white lithium grease to the stainless steel rub panels and glide pads 3 Repeat STEPS 1 2 for t
16. he opposite side 4 Replace the side panels 6 3 Troubleshooting If problems are not remedied contact technical support at 1 800 668 2337 Extension 2 SYMPTOMS FAULTS SOLUTION Hydromassage System System will not start No electrical power to tub Check and reset breaker Switch air hose disconnected Reconnect hose to switch and controller System is ineffective Water deposits in whirlpool jets Disassemble inspect and clean whirlpool jets System is noisy Whirlpool jets are turned on without water Turn off the whirlpool jets Add water to the tub to completely cover the completely covering the jet assemblies jet assemblies and test the whirlpool function again Tub Operation No water flow Water supply turned off no electrical con Turn on water supply check and reset breaker nection Restricted water flow Water temperature control valve Inspect and clean the water temperature control valve Refer to the Moen service manual at www moen com Search for Model 3371 ExactTemp Temperature Control Valve Service Manual Number 153768 Invacare TheraPure Supine Whirlpool Tubs 30 Part No 1167456 6 INSPECTION MAINTENANCE AND TROUBLESHOOTING SYMPTOMS FAULTS SOLUTION Height Adjustment Model 6302GADH Only Tub will not raise or Glide pads and rub panels not greased Apply grease to glide pads and rub panels Refer to Maintenance for lower 6302GADH Adjustable Height Rub Panels and Glide Pads
17. he the resident Drain the tub Transfer the resident from the tub Clean disinfect and rinse the tub Cleaning and Disinfecting WARNINGS Clean and disinfect the tub after EACH use to avoid resident infection and contamination of the tub DO NOT clean or disinfect the tub when it is occupied Otherwise injury may occur Read and understand ALL information on disinfecting BEFORE use ALWAYS wear rubber gloves an apron and a face shield when using disinfectant In case of eye or skin contact follow procedures on the disinfectant container A CAUTION NEVER use abrasive cleaners like scouring powder or liquid cleaners containing pumice stone The use of these types of cleaners will make the gel coat finish of your tub scratched and dull NEVER use cleaners containing lodine Household Bleach Bromine Betadine or Methylene Blue The use of these types of cleaners will cause the tub to stain Use of unapproved cleaners will dry out the rubber seals and gaskets and the tub will not function properly Use the drain plug to close the drain Part 1167456 23 Invacare TheraPure Supine Whirlpool Tubs 5 OPERATION 2 Remove and disassemble all jet assemblies A Rotate each jet assembly counterclockwise and pull away from the jet casing Detail A B Remove each impeller cap by rotating it clockwise Detail B C Remove each impeller Detail Detail Detail Detail Jet Casing 3
18. ing chart for shower head adjustment settings ry Stream Pulse Massage A Shower Spray f Mixture of Shower Spray and Pulse Massage Flow Control serves as a volume control and water saver The use of the Flow Control permits the reduction of water flow without the need for readjustment of water temperature during bathing A trickle of water through the Flow Control when in the closed position is normal Part 1167456 27 Invacare TheraPure Supine Whirlpool Tubs 5 OPERATION 5 6 Using the Whirlpool Function If the water level does not cover the whirlpool jets push the tub fill button to auto fill the tub 2 After the water level covers the whirlpool jets and after bathing the resident add Invacare Defoamer to the bath water Refer to the Defoamer bottle for directions Push the whirlpool button to start whirlpool jets After use press the whirlpool button again to stop the whirlpool jets Drain the tub completely Use the stretcher lift to transfer the resident from the tub Uv eo Clean and disinfect the tub Refer to Cleaning and Disinfecting on page 23 5 7 Adjusting the Tub Height 6302GADH Only WARNING INVACARE A DO NOT stand on the tub frame Keep feet away from UP Button tub and frame otherwise injury may occur HHO DO NOT adjust the height more than three cycles up and down within a ten minute period Damage to the DOWN Button actuator may result
19. lations et e e le e ebat dein tr tr t beide ine DA HE ec e ee ER uet danni enemas Post Installation Checklist Invacare TheraPure Supine Whirlpool Tubs 2 Part No 1167456 CONTENTS 5 OPERATION 21 OVENVIOW 21 Cleaning and Disinfecting ER e Re RR ea de t PE Re Bb ee E main aaa 23 Water Temperature Setti sssrinin rade the RE Re tee bdo aaou aas aiene eiae aaaea S AE aeaaaee itina EERE T r REEE eaaa ET LERA 26 t ie tlie EE RU ire e Rr at Rec e EAR does Nice Sik 27 Using the Shower Massage Ward ete i tH Rit OR RH LO DH oU e LER dtes on eI pode UR PR 27 Using the Whirlpool FUrictlori ccce ee NERE eta AREA EUER EU REEF E Aa TA EDD Li be eA aes 28 Adjusting the Tub Height 6302GADH Only viiveet A tentent teen ten tentent E 28 6 INSPECTION MAINTENANCE AND TROUBLESHOOTING 29 Safety Inspection Checklists e eo eo edebat e der dede A ae edo o b E das 29 Maintenance for 6302GADH Adjustable Height Rub Panels and Glide 30 Troubleshooting teen EBENE es R pp prre ve dde deett pese FE tbe der ett ed e I 30 Maintenance 82 M 3l Part No 1167456 Invacare TheraPure Supine Whirlpool Tubs GENERAL General Symbols
20. on page 30 Bad electrical connections no electrical Unplug the tub Check and reset GFCI Check electrical cord plug and power to tub outlet for damage Replace damaged parts as necessary per local codes Actuator overload Wait five minutes and try to adjust the height again Actuator burned out Contact your Invacare Dealer Obstacle in UP DOWN travel path Inspect for and remove any obstacle Maintenance Record MAINTENANCE PERSON TYPE OF MAINTENANCE PERFORMED Part No 1167456 3l Invacare TheraPure Supine Whirlpool Tubs Invacare Corporation www invacare cc com USA and Canada Manufacturing Location One Invacare Way 899 Cleveland Street Elyria Ohio USA Elyria Ohio 44036 44036 2125 Customer Service e 1 800 668 2337 Yes you can Technical Support 1 800 668 2337 Extension 2 For more information regarding Invacare products parts and Part No 1167456 services please visit www invacare cc com Invacare Continuing Care Inc is a subsidiary of Invacare Corporation 2011 Invacare Corporation All rights reserved Republication duplication or modification in whole or in part is prohibited without prior written permission from Invacare Trademarks are identified by and 9 All trademarks are owned by or licensed to Invacare Corporation or its subsidiaries unless otherwise noted Dispatch is a registered trademark of Clorox Industries Inc
21. only Warranty replacement parts are only covered for the duration of the warranty period All purchased replacement parts will carry a 30 day warranty from the date of shipment If within such warranty period any such product shall be proven to be defective such product shall be repaired or replaced at ICCI s option This warranty does not include any labor or shipping charges incurred in replacement part installation or repair of any such product ICCI s sole obligation and your exclusive remedy under this warranty shall be limited to such repair and or replacement For warranty service please contact the dealer from whom you purchased your ICCI product In the event you do not receive satisfactory warranty service please write directly to at the address below Provide dealer s name address model number date of purchase indicate nature of the defect and if the product is serialized indicate the serial number ICCI will issue a return authorization The defective unit or parts must be returned for warranty inspection using the serial number when applicable as identification within thirty days of return authorization date DO NOT return products to our factory without our prior consent C O D shipments will be refused please prepay shipping charges LIMITATIONS AND EXCLUSIONS THE WARRANTY SHALL NOT APPLY TO PROBLEMS ARISING FROM NORMAL WEAR OR FAILURE TO ADHERE TO THE ENCLOSED INSTRUCTIONS LABOR EXPENDABLE ITEMS I E SHOWER HOSES VAL
22. r becomes nauseated or dizzy or the person develops a headache get out of the tub at once and safely bring the body temperature back to normal 98 6 F Seek medical attention if symptoms or sickness persist Check with the physician BEFORE using the tub again Anyone under a doctor s supervision pregnant or with poor health should check with a physician BEFORE using this tub The Supine Tub is specifically designed to be used with a bath lift ICCI recommends use of the Traverse Lift Model 1200 ONLY Bath lifts designed by other manufacturers are NOT to be used with the Supine Tub Use the Traverse Lift Model 1200 to maintain resident safety and product utility Refer to the lift owner s manual for complete life operating and safety instructions Part No 1167456 21 Invacare TheraPure Supine Whirlpool Tubs 5 OPERATION Tub Raise and Lower Buttons Model 6302GADH ONLY Water Temperature Thermometer Whirlpool ON OFF Button Fill Button Push in once to auto fill push in and hold to add additional water to tub Water Temperature Control Invacare TheraPure Supine Whirlpool Tubs 22 Part No 1167456 5 OPERATION Perform these procedures in the following order Make sure that the tub has been cleaned disinfected and rinsed BEFORE each use Refer to Cleaning and Disinfecting on page 23 Use the stretcher lift to transfer the resident to the tub The resident will remain the stretcher lift during bathing Bat
23. round fault interrupter and a 30 minute maximum timer MUST be installed in the electrical circuit Parts not supplied by ICCI The unit must be operated through the circuit The 30 minute timer must be located in a position where a person in the unit cannot reach the timer Use a 15 breaker only Ensure a 15 breaker is installed to protect the unit Insert the plug into a pre installed GFCI protected hospital grade receptacle Part No 1167456 17 Invacare TheraPure Supine Whirlpool Tubs 4 INSTALLATION 4 6 Plumbing Connection Details Drain Wall 38 in 965 mm Centerline of Tub IC 3 4 in Ball Valve MUST be a minimum of 6 in above the floor 5in 127 mm Tub Back of Tub Front of Tub Elbow Accommodate Reduced Pressure Zone RPZ if required 2 in PVC stub Drain FIGURE 4 1 Plumbing Connection Details 4 7 Plumbing Installation DANGER Be certain all plumbing work is performed by a qualified plumber and is in compliance with local codes Check local codes regarding maximum water temperature allowed at hot water outlets for facility type A WARNINGS Be certain all plumbing work is performed by a qualified plumber and is in compliance with local codes Some state and local plumbing codes require the installation of a reduced pressure zone RPZ assembly on both the incoming hot and cold supply lines to prevent back flow contamination into the potable wa
24. t or shower massage wand Water Temperature Control Valve sets and maintains constant temperature for all incoming water w Cold BLUE Hot RED Flow Water Thermometer Water Temperature Control Valve Invacare TheraPure Supine Whirlpool Tubs 26 Part No 1167456 5 OPERATION 5 4 Filling the Tub Use the drain plug to close the drain 2 Position the resident on the stretcher lift in the tub 3 Push the tub fill button once to start auto fill The tub will fill to a predetermined level To stop the tub from filling during auto fill press the fill button a second time there will be a five second delay After the tub has auto filled push in and hold the tub fill button to add additional water 4 Use the water temperature control valve to adjust the water temperature while watching the flow water thermometer Test the water temperature with your hand 5 5 Using the Shower Massage Wand These instructions are to be done while holding the shower massage wand over the tub Turn the shower massage on by pushing the ON OFF button Adjust the water temperature using the water temperature valve while watching the flow water thermometer Test the temperature with your hand 2 3 Adjust the flow of the water by turning the flow control 4 Adjust the shower spray by rotating the shower wand head 5 Turn the shower massage off by pressing the ON OFF button again Refer to the follow
25. ter system Invacare recommends you check local plumbing code requirements to determine if RPZs are required on your tub installation RPZs are NOT supplied by Invacare and are to be provided by the customer if required Invacare TheraPure Supine Whirlpool Tubs 18 Part No 1167456 4 INSTALLATION CAUTIONS Purge water lines Hot and cold lines MUST be purged blown down to clear lines of debris prior to connection Valves and spray heads may become inoperable and or damaged if lines are not properly cleared Items damaged in this way are not covered under the warranty When operating water pressure exceeds 55 PSI pressure regulators similar to the Watts U5 MUST be installed Refer to Tub Dimensions and Connection Details on page 15 for the location of the hot water stub and cold water stub Measure the location of the drain on the unit Install the drain in the floor Purge water lines Hot and cold lines MUST be purged blown down prior to connection to clear lines of debris Install ON OFF valves at wall and use unions between valves and stubs Connect 2 inch drains in accordance with local plumbing codes Connect hot and cold supply lines to 34 inch copper pipes found on back of tub in accordance with applicable building codes Attach the shower massage wand and flow valve Be sure to use the washers supplied Check for leaks in supply or drain lines and check operation of tub Refer to Operation on page 21 OON U
26. ters per minute Part No 1167456 11 Invacare TheraPure Supine Whirlpool Tubs 3 OVERVIEW 6302G 6302GADH FIXED HEIGHT ADJUSTABLE HEIGHT Water Pressure 65 PSI maximum 448 kPa Water Drain Rate 25 gallons per minute 95 liters per minute Number of Jets 4 Electrical Classification Class Type B Power 115 VAC 60 Hz Current Rating 7 Amps Tub Material Double wall gel coated fiberglass Thermometer 2 inch dial 75 to 120 F 25 50 C Anti Scald Water Regulator Moen ExactTemp Invacare TheraPure Supine Whirlpool Tubs 12 amp 1167456 3 OVERVIEW 3 4 Minimum Floor Space and Clearance Requirements 12 Laer 7 pa 36 36 MIN MIN 9 RECOMMENDED i SERVICE ACCESS AWAY FROM WALL 12 MINIMUM TUB CLEARANCE 6302G OR 6302GADH SUPINE TUB 1200 TRAVERSE STRETCHER LIFT Part No 1167456 13 Invacare TheraPure Supine Whirlpool Tubs 4 INSTALLATION 4 Installation A WARNINGS Check all parts for shipping damage In case of damage DO NOT use Contact the carrier for further instruction The installation area MUST be able to support the 66 pounds per square inch 45 load capacity of the tub Otherwise injury or damage might occur Access for servicing the tub MUST be provided Install the tub in a location that will permit access to the service panels plumbing and electrical hookup A CAUTIONS DO
27. turn off circuit breaker before installing or performing any maintenance on the tub The unit MUST be connected only to a supply circuit that is protected by a ground fault circuit interrupter GFCI Be certain ALL electrical work is performed by a qualified electrician and is in compliance with local electrical codes ALL electrical connections are to be water resistant DANGER RISK OF SCALDING The hot water supply to the tub MUST not exceed 110 43 C to protect the user from scalding Invacare TheraPure Supine Whirlpool Tubs 6 Part No 1167456 2 SAFETY WARNING PLUMBING Be certain all plumbing work is performed by a qualified plumber and is in compliance with local codes WARNING FLOOR LOAD CAPACITY The installation area MUST be able to support 66 pounds per square inch 45 n cm load capacity of the tub Otherwise damage may occur WARNINGS SAFE USE Use this unit only for its intended use as described in this manual If any part of the system is not functioning properly DO NOT use the tub NEVER drop or insert any object into any opening DO NOT operate the tub without the jet assemblies installed The tub MUST be cleaned and disinfected after each use Refer to Cleaning and Disinfecting on page 23 Keep hair and body away from the jet assemblies when pump is running Hyperthermia occurs when the internal temperature of the body reaches a level several degrees above the normal body temperature of 98 6 F
28. uit breaker before performing to provided by the customer if required any maintenance to the Tub pore Costorna UA 60001 1 aed 17 129 3 948 10 01 CSA 1167464 Rev DO NOT remove this label camne w canicea SPA M 129 08 10761098 An ZANA 200 Label located on Interior Hardware Invacare TheraPure Supine Whirlpool Tubs 10 Part No 1167456 3 3 Typical Product Parameters 3 OVERVIEW 6302G 6302GADH FIXED HEIGHT ADJUSTABLE HEIGHT Weight Tub shipping weight Tub empty Tub w 103 gallons of water max water capacity Floor Load Capacity 820 pounds 371 kg 795 pounds 360 kg 1 695 pounds 767 kg 66 PSI 45 n cm Tub Exterior Tub Interior at Shoulder Tub Interior at Hip Tub Interior at Foot Height Tub Rim 32 inches 813 mm Raised N A 4 inches 1041 mm Lowered N A 27 inches 686 mm Overall Tub Height 56 inches 1422 mm Raised N A 65 inches 1651 mm Lowered N A 5 inches 1295 mm Width 38 inches 965 mm 30 inches 762 mm 25 inches 635 mm 22 inches 559 mm with Tub occupied average usage Length Overall Tub Length 94 inches 2388 mm Tub Interior 69 inches 1753 mm Frame Base 49 inches 1245 mm Water Capacity Maximum 103 gallons 390 liters 70 77 gallons maximum 265 to 292 liters Water Fill Rate 17 gallons per minute 65 li
Download Pdf Manuals
Related Search