Simplex Filter - LP Installation & Service Manual
Contents
1. m 3 ioi ELENERI sass 3 TAO AFE TAINF ORMA TON t 4 Resqeuevi euunaddl AEAEE Ent 5 1 06a CUT AWAY VIEW Simplex Filter LP sessi enne nnn 6 1055 BAP LO PRU ees tS dE aM M G m 6 105 BOM Simplex Filter Euer iis tudo tUEPUSE NU RUE RUDMED US DUM ainai RUSO IUS n EAE EMI ONU MS Ud SMS ESI UM UM Hd UD UE 6 1 06 GA DRAWING Simplex Filter LP with Optional Differential Pressure Pop Up Assembly sssssseenennnnnnnnns T 1 06a CUT AWAY VIEW Simplex Filter LP with Optional Differential Pressure Pop Up Assembly seeeennnnnnes 8 1 06b EXPLODED VIEW Simplex Filter LP with Optional Differential Pressure Pop Up Assembly sseeennnes 8 1 06c BOM Simplex Filter LP with Optional Differential Pressure Pop Up ASSEMDIY ccccccccccccsccsecsscsssssececesssessessessseceessessssceesaessesseesaessaseateatens 8 1 07 GA DRAWING Simplex Filter LP with Optional Differential Pressure Pop Up amp Atex Switch 9 1 07a CUT AWAY VIEW Simplex Filter LP with Optional Differential Pressure Pop Up amp Atex Switch sseennee 10 1 076 EXPLODED VIEW Simplex Filter LP with Optional Differential Pressure Pop2. 2 03 INSTALLATION PROCEDURE SIMPLEX FILTER LP with Optional Differential Pressure Pop Up amp Atex Switch e Installation of the Amflow Simplex Filter System should be in a vertical position only This orientation will allow safe maintenance of filter elements e Position drain valve so vent is directed away from operator e Vent tubes are 6mm and can be connected to an extension using standard tube fittings C DIFFERENTIAL PRESSURE POP UP ASSEMBLY OUTLET PORT SIMPLEX HP BODY emm IE X Copyright 2015 A amp H Enterprises Inc All rights reserved 00001080 0904 001 Rev C 09 15 Page 13 of 19 a AMFLOW SIMPLEX FILTER LP Installation amp Service Manual INSTALLATION 2 03 INSTALLATION PROCEDURE SIMPLEX FILTER LP with Optional Differential Pressure Pop Up amp Atex Switch continued z 1G and 2G DIN EN 60947 5 6 for zones 0 and 1 provides protection in explosive areas DIN EN 60947 5 6 1 500 Hz NAMUR m CABLE LENGHT 2M pa ATEX DEVICE CATEGORY OUTPUT ACCORDING TO CATEGORY 1G AND 2G OUTPUT ACCORDING TO SWITCHING FREQUENCY OUTPUT TYPE OUTPUT FUNCTION ENCLOSURE RATING CONNECTION TYPE Z O IP 67 1 Cable 2 wire 2 m SIP VAILELE 7 5 VDC 25 V DC 1 me 1 eie OE IneHi e ME x 30 mA 2 Current Consumption Current Consumption 22mA sensor is not activated Hysteresis 15 Vo Temperature Drift of Sr xeu veeeniumaAma E
3. Micron 00001071 0501 004 30 Micron 00001071 0501 006 75 Micron 00001071 0501 007 100 Micron Copyright 2015 A amp H Enterprises Inc All rights reserved 00001080 0904 001 Rev C 09 15 Page 3 of 19 1h AMFLOW SIMPLEX FILTER LP Installation amp Service Manual INFORMATION 1 04 SAFETY INFORMATION SAFETY INFORMATION e Use filter only within range of pressure and temperature conditions indicated on product data sheet e Do not use with chemicals which are incompatible with 316L or seal materials e Equipment is certified for Group 2 Category Il e Equipment should not be used in systems requiring a higher level of certification Faults and Damage The safety features and integrity of filter may be compromised by any of the following e External damage to body e Exposure to pressure loads in excess of maximum rated pressure e Maintenance performed by improperly trained personnel Protection from Pressure Releases e To avoid injury due to release of high pressure use only adaptors and fittings rated to withstand appropriate pressure e Confirm that all adaptors and fittings are securely connected e To avoid a violent release of pressure slowly bleed off pressure before attaching or removal from pressure line Avoid Mechanical Damage e Do not damage any threaded components during maintenance procedure Damage could compromise the pressure safety factor of filter e Use care when replacing seals to avoid damage to
4. Up Assembly cccccccccsecsscsscssccsecsesseccsessessesceessesseseateaeenes 10 1 07c BOM Simplex Filter LP with Optional Differential Pressure Pop Up Assembly sse nnns 10 BEC HON 2 INSTALE ATION 11 2 01 INSTALLATION PROCEDURE Simplex Filter EP vscscsasicccsiscssscestandsasventecssinstacsiansticsstscunsesbauaeicatelicsaatteudeass alma grat tcrtia oath 11 2 02 INSTALLATION PROCEDURE SIMPLEX FILTER LP with Optional Differential Pressure Pop Up sn 12 2 03 INSTALLATION PROCEDURE SIMPLEX FILTER LP with Optional Differential Pressure Pop Up amp Atex Switch ssses 19 SECTION 3 OPERATION mr 15 SOTOPERATIONPROSBDURE recie tc Inquit dE Iit bU MEN REPE EUREN EUM 15 3 02 INSTALLATION S OPERATION PRECAUTIONS scene rr atat mu hne Eu DU UE A C IU ERE SAN SK RERAN en tuta EAE ONAE Oana 15 SECTION 4 i jpzfs e 16 STANDARDS amp CERTIFICATIONS m 17 El guzii posagpfee 18 END OF SECTION Copyright 2015 A amp H Enterprises Inc All rights reserved 00001080 0904 001 Rev C 09 15 Page 2 of 19 SIMPLEX FILTER LP Installation amp Se
5. sealing surfaces Damage could lead to a sudden release of pressure during operation END OF SECTION Copyright 2015 A amp H Enterprises Inc All rights reserved 00001080 0904 001 Rev C 09 15 Page 4 of 19 AMFLOW SIMPLEX FILTER LP Installation amp Service Manual d INFORMATION 1 05 GA DRAWING Simplex Filter LP Max 25 mounting holes 4 pls 3 lj2 BSRR ens F 94 Copyright 2015 A amp H Enterprises Inc All rights reserved 00001080 0904 001 Rev C 09 15 Page 5 of 19 axe AMFLOW SIMPLEX FILTER LP Installation amp Service Manual INFORMATION 1 06a CUT AWAY VIEW Simplex Filter LP 1 05b EXPLODED VIEW Simplex Filter LP 1 05c BOM Simplex Filter LP ITEM PART DESCRIPTION QTY To001555 2134 108 Body ORing 5 Item 5 Last three digits indicate size of filter element to be ordered Copyright 2015 A amp H Enterprises Inc All rights reserved 00001080 0904 001 Rev C 09 15 Page 6 of 19 w AMFLOW SIMPLEX FILTER LP Installation amp Service Manual 4 Ay INFORMATION 1 06 GA DRAWING Simplex Filter LP with Optional Differential Pressure Pop Up Assembl Pop up Indicator ms 4 pls 6 0 amp m 1 2 BSPP Mmm gi 172 BSPP 373 P 6 172 BSPP 00001080 0904 001 Rev C 09 15 Page 7 of 19 Copyright 2015 A amp H Enterprises Inc All rights reserved SIMPLEX FILTER LP Installation amp Se
6. A amp H Enterprises Inc 11812 NE 116th Street TEL 425 883 4040 A m fl O we Kirkland WA 98034 USA FAX 425 823 1962 www amflow com EMAIL ah amflow com INSTALLATION amp SERVICE MANUAL AMFLOW SIMPLEX FILTER LP Low Pressure SIMPLEX FILTER LP SIMPLEX FILTER LP with OPTIONAL with OPTIONAL DIFFERENTIAL ATEX SWITCH PRESSURE ASSEMBLY POP UP ASSEMBLY Part Number 00001080 0501 A nore Reference the As Built data sheet supplied with order for specific filter configuration Explanation of Graphic Symbols A DANGER AND OR WARNING The exclamation point within an equilateral triangle surrounded by red is intended to alert the user to the presence of important operating and maintenance instructions that may cause personal injury or harm to the system A CAUTION AND OR IMPORTANT The exclamation point within an equilateral triangle that is solid yellow with an exclamation point is intended to alert the user to use caution or contains important information Copyright 2015 A amp H Enterprises Inc All rights reserved 00001080 0904 001 Rev C 09 15 Page 1 of 19 s AMFLOW SIMPLEX FILTER LP Installation amp Service Manual TABLE OF CONTENTS SEGTION 1 INFORMATION X 3 101 DESCRIPTION T 3 OZ DE SION FEATURE D oen
7. N 60947 5 6 Cable Material Oe ale Ufo Co di GT do 1 e 1ei e 1 0 34 mme Cable Diameter Slater AELH 30 g 11 ms 10 55 Hz 1 mm Ple 0 80 3 6 Ue ME CEHE 20 C 70 C EC Approval Certificate Hazardous Area Category Input Voltage Ui Max Input Power Pi Max Input Current Li Max Internal Capacitance Ci Max Internal Inductance Li Max Nominal Voltage YES Get dareem Il 1 G Ex ia IIB T6 Ta 20 C 55 C Il2 G Ex ia IIC T6 Ta 20 C 70 C Cable Resistance END OF SECTION Copyright 2015 A amp H Enterprises Inc All rights reserved 00001080 0904 001 Rev C 09 15 Page 14 of 19 s AMFLOW SIMPLEX FILTER LP Installation amp Service Manual OPERATION SECTION 3 OPERATION 3 01 OPERATION PROCEDURE e Ensure all fittings are tight e Open drain valve slowly e Maximum Differential Pressure 35 bar e In flow through direction with back flush 10 bar e Maximum Operating Temperature 200 Celsius 392 Fahrenheit The system design should take into consideration that materials which come into contact with the injected media should not contribute to foreign matter entering into the system Meaning it is unwise to use material that can be easily corroded such as mild steels 3 02 e INSTALLATION amp OPERATION PRECAUTIONS DANGER The design of this filter system allows for online servicing of the filter elements therefore in order to avoid personal injury the operator should
8. anual INSTALLATION SECTION 2 INSTALLATION 2 01 INSTALLATION PROCEDURE Simplex Filter LP e Installation of the Amflow Simplex Filter System should be in a vertical position only This orientation will allow safe maintenance of filter elements e Position drain valve so vent is directed away from operator e Vent tubes are 6mm and can be connected to an extension using standard tube fittings Amflow Simplex Filter System Vertical Position A EB j OUTLET PORT SIMPLEX HP BODY mmm uh Ki 7 LU L E h B P Copyright 2015 A amp H Enterprises Inc All rights reserved 00001080 0904 001 Rev C 09 15 Page 11 of 19 SIMPLEX FILTER LP Installation amp Service Manual INSTALLATION 2 02 INSTALLATION PROCEDURE SIMPLEX FILTER LP with Optional Differential Pressure Pop U e Installation of the Amflow Simplex Filter System should be in a vertical position only This orientation will allow safe maintenance of filter elements e Position drain valve so vent is directed away from operator e Vent tubes are 6mm and can be connected to an extension using standard tube fittings DIFFERENTIAL PRESSURE POP UP ASSEMBLY OUTLET PORT SIMPLEX HP BODY Tl d Page 12 of 19 Copyright 2015 A amp H Enterprises Inc All rights reserved 00001080 0904 001 Rev C 09 15 une AMFLOW SIMPLEX FILTER LP Installation amp Service Manual INSTALLATION
9. be properly trained Before carrying out any maintenance activities insure that proper personal protective equipment is used END OF SECTION Copyright 2015 A amp H Enterprises Inc All rights reserved 00001080 0904 001 Rev C 09 15 Page 15 of 19 x AMFLOW SIMPLEX FILTER LP Installation amp Service Manual Ash MAINTENANCE SECTION 4 MAINTENANCE Step 1 e Strongly recommended that a drip pan be installed below assembly so any fluid that may escape during servicing of filter elements is collected in a safe and environmentally friendly manner ZNWARNING Proper safety gear PPE should be worn at all times during maintenance e n particular eye and hand protection otep 2 e Tochange or service filter elements drain fluid from cylinder housing using drain valve gt Unscrew cylinder housing and remove filter element END OF SECTION Copyright 2015 A amp H Enterprises Inc All rights reserved 00001080 0904 001 Rev C 09 15 Page 16 of 19 AMFLOW SIMPLEX FILTER LP Installation amp Service Manual STANDARDS amp CERTIFICATIONS STANDARDS A amp H Enterprises designs its products to meet the applicable ASME and API standards for valve design and pressure vessels Products are also CE marked and ATEX approved for Hazardous area installations MEMBERSHIPS Fieldbus MEMBER ILE A AA FEAE YV v COMMUNICATION FOUNDATION CERTIFICATIONS ATEX DIRECTIVE 94 9 EC In the in
10. epair the product will be returned to the Buyer transportation and insurance prepaid and the Buyer will be billed for the repairs and the return transportation and insurance charges THIS WARRANTY IS BUYER S SOLE AND EXCLUSIVE REMEDY AND IS IN LIEU OF ALL OTHER WARRANTIES EXPRESS OR IMPLIED INCLUDING BUT NOT LIMITED TO ANY IMPLIED WARRANTY OR MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE A amp H ENTERPRISES SHALL NOT BE LIABLE FOR ANY SPECIAL INDIRECT INCIDENTAL OR CONSEQUENTIAL DAMAGES OR LOSSES ARISING FROM ANY CAUSE OR THEORY Since some countries or states do not allow limitation of the term of an implied warranty or exclusion or limitation of incidental or consequential damages the limitations and exclusions of this warranty may not apply to every buyer If any provision of the Warranty is held invalid or unenforceable by a court or other decision maker of competent jurisdiction such holding will not affect the validity or enforceability of any other provision Copyright 2015 A amp H Enterprises Inc All rights reserved 00001080 0904 001 Rev C 09 15 Page 18 of 19 TA AMFLOW SIMPLEX FILTER LP Installation amp Service Manual REPRESENTATIVES AMFLOW NORGE Norway Sweden Denmark Netherlands Germany U K Italy Prinsens vei 12 4315 Sandnes Norway Telephone 47 922 19 656 Fax 47 520 00 591 E mail leif egil pettersen amflow no AMFLOW CONTROLS ASIA SDN BHD Malaysia Indonesia Singap
11. misused altered neglected contaminated damaged by accident or abnormal conditions of operation or handling At A amp H Enterprises option the A amp H Enterprises warranty obligation is limited to the replacement or repair of a defective product that is returned to A amp H Enterprises within the warranty period Merchandise returned to A amp H Enterprises within the warranty period which in A amp H Enterprises opinion is defective by accident improper operation or improper handling shall be subject to a charge for repair Merchandise free from defects returned to A amp H Enterprises shall be subjected to a 2096 restocking fee within thirty 30 days of the purchase date Written authorization is required for all merchandise returned to A amp H Enterprises To obtain warranty service contact A amp H Enterprises to obtain return authorization information Then send the product to A amp H Enterprises with a description of the difficulty transportation and insurance prepaid A amp H Enterprises assumes no risk for damage in transit Following warranty repair the product will be returned to Buyer transportation and insurance prepaid If A amp H Enterprises determines that failure was caused by neglect misuse contamination alteration accident or abnormal condition of operation or handling A amp H Enterprises will provide an estimate of repair costs and obtain authorization before commencing the work Following r
12. ore India Thailand Vietnam No 1701 Block 1 TTDI ADINA Jalan Judo 13 45 Seksyen 13 40675 Shah Alam Selangor Malaysia Telephone 603 5523 8418 Mobile 6012 3323 118 E mail amflowcontrols gmail com SUDIFLOW INTERGRATED SERVICES LTD Nigeria 25 Elelenwo Road Port Harcourt Nigeria Telephone 234 803 309 1405 705 679 4894 E mail sudiflow yahoo com PROPRIETARY DISCLOSURE NOTICE This material contains proprietary information belonging to A amp H Enterprises Inc and may not be disclosed in whole or in part without express written permission of A amp H Enterprises Inc A amp H Enterprises Inc 11812 NE 116th Street TEL 425 883 4040 iN Ay A aati lo we Kirkland WA 98034 USA FAX 425 823 1962 www amflow com EMAIL ah amflow com Copyright 2015 A amp H Enterprises Inc All rights reserved 00001080 0904 001 Rev C 09 15 Page 19 of 19
13. rvice Manual INFORMATION 1 06a CUT AWAY VIEW Simplex Filter LP with Optional Differential Pressure Pop Up Assembl 1 1 ITEM PART DESCRIPTION QTY 00001071 0501 000 FilterElement 1 00001082 0301 001 7 Pop Up Assy Item 5 Last three digits indicate size of filter element to be ordered Copyright 2015 A amp H Enterprises Inc All rights reserved 00001080 0904 001 Rev C 09 15 Page 8 of 19 zw AMFLOW SIMPLEX FILTER LP Installation amp Service Manual INFORMATION 1 07 GA DRAWING Simplex Filter LP with Optional Differential Pressure Pop Up amp Atex Switch 6 172 BSFF H 172 BSPP Copyright 2015 A amp H Enterprises Inc All rights reserved 00001080 0904 001 Rev C 09 15 Page 9 of 19 ae AMFLOWS SIMPLEX FILTER LP Installation amp Service Manual INFORMATION 1 07a CUT AWAY VIEW Simplex Filter LP with Optional Differential Pressure Pop Up amp Atex Switch 1 07b EXPLODED VIEW Simplex Filter LP with Optional Differential Pressure Pop Up Assembl 1 ITEM PART DESCRIPTION QTY 00001071 0501 000 FilterElement 1 00001082 0301 001 7 Item 5 Last three digits indicate size of filter element to be ordered END OF SECTION Copyright 2015 A amp H Enterprises Inc All rights reserved 00001080 0904 001 Rev C 09 15 Page 10 of 19 oye AMFLOW SIMPLEX FILTER LP Installation amp Service M
14. rvice Manual INFORMATION SECTION 1 INFORMATION 1 01 DESCRIPTION The Amflow SIMPLEX FILTER LP is a low pressure filter assembly for pressures up to 414 bar 6 000 PSI and incorporates a large reusable filter element that can be back flushed for cleaning purposes Filter elements are available from 2 5 to 100 microns 1 02 DESIGN FEATURES e Filter Construction 316L Stainless Steel e Operating Pressure 414 bar 6 000 PSI e Operating Temperature 15 C 5 F to 200 C 392 F e Standard Inlet amp Outlet Ports 1 2 BSPP e Weight 24 lbs 10 8 kg e Multiple Configurations e Reusable Filter Elements e Provision for Back Flushing e Ease of Operation e Variety of Micron Element Sizes 1 03 FILTER ELEMENTS 1 FILTER ELEMENT Outside to Inside Flow through with Back flush 1 01 Maximum Differential Pressure 35 bar 10 bar 2 CONSTRUCTION MATERIALS Standard Special Order 2 01 Element Parts 2 vilius Duten WEAVE Contact Manufacturer Sintered Stainless Steel PARTICLES SIZE EO 8 8 B 4 FILTER ELEMENT SIZE S Standard Sizes Custom Order Sizes eH GIO NICO 20 Micron 30 Micron 75 Micron amp 100 Micron amp 50 Micron Filters can be configured with one of eight elements each sold sepertely STANDARD SIZES 00001071 0501 000 2 5 Micron 00001071 0501 001 5 0 Micron 00001071 0501 002 10 Micron 00001071 0501 005 50 Micron CUSTOM ORDER SIZES 00001071 0501 003 20
15. terest of safety and quality A amp H Enterprises Inc has certified its Amflow series of filters for use in potentially explosive atmospheres as defined by the ATEX Directive 94 9 EC as Category 2G To ensure the safety of all parties the filters must be regularly checked for signs of fluid leaks Only genuine Amflow parts must be installed in accordance with supplied instructions good engineering and construction practices The filter bodies are constructed from 316L and therefore must not be used with chemicals which are incompatible with 316L or with the seal materials used The filters must not be modified in any way from the original purchased filters The filters must only be operated in the range of pressure and temperature conditions indicated on product data sheet This equipment is certified for Group 2 Category II Equipment should not be used in systems requiring a higher level of certification Copyright 2015 A amp H Enterprises Inc All rights reserved 00001080 0904 001 Rev C 09 15 Page 17 of 19 SIMPLEX FILTER LP Installation amp Service Manual WARRANTY LIMITED WARRANTY Each Amflow product is warranted to be free from defects in material and workmanship under normal use and service The warranty period is three 3 years and begins on the date of original purchase This warranty extends only to the original buyer and does not apply to any product which in A amp H Enterprises opinion has been
Download Pdf Manuals
Related Search