Sabina, Sabina ll EE, EM
Contents
1. When maintenance is performed mark specified square with X When part is replaced mark specified square with R Lubricate with PTFE or silicon grease Page 4 shows the check points locations Information reguarding the check points from page 5 and forward Interval Month Date Serviced by Preventative Maintenance Sabina 65 www liko com Check points www liko com 10 0 Instructions reguarding the check pionts for Sabina EE EM Sabina EE EM Surface treatment Lift type Serial No Prod Year Contract No Name Month 12 24 36 48 60 72 84 96 108 120 Address Check Zip Code Tools required 7 Product No 20190048 5 Product No 20190029 1 If needed clean the patient lift with warm water or ethanol Warning Do not use chemicals containing phenol or chlorine since the aluminium parts may be damaged 2 Touch up painted surfaces 3 Replace broken missing leg protectors Preventative Maintenance Sabina 67 www liko com 10 0 Instructions reguarding the check pionts for Sabina EE EM Sabina II EE EM Front castor cleaning Contract No Lift type Serial No Prod Year Name Month 12 24 36 48 60 72 84 96 108 120 Address Check Zip Code2. Battery Serial No Prod Year Contract No Name Month 12 24 36 48 60 72 84 96 108 120 Address Check Replace battery Zip Code Tools required C 3 eet 1 Remove the charger cable holder then the battery 2 Inspect V shaped metal contacts on the batterypack casing for uniformity Check the battery with the battery tester part No 2101100 A signal should be audible for more than 5 sec If not replace battery see 5 21 in the service manual 3 Inspect V shaped metal contacts on controlbox for 4 Place the removable battery pack into position on uniformity Verify that plastic housing for metal top of the controlbox Adjust until you hear a clicking contacts is not damaged deformed Tighten screws sound Recommended replacement every 3rd year Preventative Maintenance Sabina 75 www liko com 11 0 14 Liko Sabina Il EE Sabina Il EM A CI Company Product changes Prod No 2020003 EE 2020004 EM 2010 03 30 e 2010 Changes SIN Project Document update according to ISO 10535 2006 1059 2008 Changes SIN Project New version of casings mob 30 452000 749 New pivot point arm mast mob 54 Holder for quick reference guide with colour codes for sling sizes introduced New version of foot frame Two new screws at the mast
3. Viking XL Viking L Viking M M 2 UN A NOTE Make sure the spare part is mounted according to the assembly instruction Check all functions related to the changed spare part Repairs and maintenance may only be performed by personnel authorized by Liko and using original Liko spare parts 12 www liko com Company 5 23 1 Cable for Charging UK Laddningskabel UK Assembly Instruction Monteringsanvisning a Contains Charging cable UK Fits Golvo 7000ES 7007ES Uno 100 EM EE Uno 102 EM EE ES Sabina EM EE Sabina Il EM EE Viking XL Viking L Viking M Qty B 1 Prod No 20090027 3SE630241 03 2009 11 04 NOTE Make sure the spare part is mounted according to the assembly instruction Check all functions related to the changed spare part Repairs and maintenance may only be performed by personnel authorized by Liko and using original Liko spare parts 13 www liko com 5 24 1 L Li ko Cable for Charging US Laddningskabel US A CEED Company Assembly Instruction Monteringsanvisning Contains Qty Charging cabel US 1 Prod No 20090028 Fits 35 630242 03 Golvo 7000ES 7007ES 2009 11 20 Uno 100 EM EE Uno 102 EM EE ES Sabina EM EE Sabina EM EE Viking XL Viking L Viking M
4. 1 Remove the split pin Pull out the bearing and the 2 Remove the split pins pin bolt Keep the bolt for later use x A 3 Remove the rounded locking bolt nuts 4 Pull out the jointed arms Assemble in from the jointed arms and the legs reverse order Jointed arms new bearing new pin bolt old Drive the actuator to the 27 highest position E gt 37 www liko com LE 5 Adjust the legs to the minimum spreading size D in the Technical Specifications 5 217 2 m e Tightening torque 17 NM 6 Mount the ball couplings on the legs in the same position as before Xe NOTE Make sure spare is mounted according to assembly instruction Check all functions related to the changed spare part Repairs and maintenance may only be performed by personnel authorized by Liko and using original Liko spare parts www liko com 5 220 1 FU Restoration set Emergency Lowering 14 Li ko Renoveringssats mekanisk n ds nkning A CEAD Company Assembly Instruction Monteringsanvisning Contains Casing emergency lowering Prod No 20190051 Bushing emergency lowering Shim emergency lowering 3SE630222 06 Washer PTFE em lowering 2010 03 09 qud 01 Tools required Uno 102 ex 2x17mm Uno 100EM EE oy dO iam Uno 102EM EE
5. Assembly Instruction Contains Monteringsanvisning Manual Base 1 Domed locking nut M10 2 Prod No 20190049 Domed locking nut 8 2 35 630226 03 Fits 2009 11 20 Uno 100 EM Ms hcl Tools required abina Il EM p 4 fm 0 13 mm BL 1L 19 17 mm z N 1a Remove the old manual base 1b 35 www liko com 5 216 2 2a Assemble the new manual base 2b 2c Adjust the legs to the minimum spreading 2d see the Instruction guide Tightening torque 17 NM 9 MES D D t Q NOTE Make sure the spare part is mounted according to the assembly instruction Check all functions related to the changed spare part Repairs and maintenance may only be performed by personnel authorized by Liko and using original Liko spare parts 36 www liko com 5 217 1 Restoration set Electrical Base 24 Li ko Renoveringssats elektrisk breddning A company Assembly Instruction Monteringsanvisning 6 Contains Qty Prod No 20190050 Jointed arm right 1 Jointed arm left 1 3SE630227 03 Bearing 103 10 12 Uno 1 2009 06 25 Split Pin SP 3 2x20 2 Split Pin SP 2 5x16 1 Tools required Fits 13mm Uno 101 102 Uno 100EM EE 102EM EE ES 17mm Sabina add EM J a A
6. 40 Cable for Charging 248 cete 5 248 1 41 Extension Cable US 263 eme 5 263 1 42 Hook for Hand control 2 4 6 button 292 ws 5 2921 ms 43 Screw M12x105 U1 2 312 Re 5 312 1 44 Pivotpoint actuator 45 Sabina Liftarm incl locking handles 383 ii 5 383 1 46 Locking handles icto itt etti mete i 5 384 1 47 Exploded views 6 0 48 Sabina EE SAR 6 2 50 COMP NS cree 7 0 Sabina I EN Ren i NE 52 Sabina EE 54 Sleeve Bearings iE Pe ied RP f 56 Decal Dm 8 0 Sabina Il EM 98 T eoe 57 Sabina WEE win 58 Periodic Inspection 9 0 59 Preventative 2 TO 65 Product Changes ac eb ete tuae 76 Liko AB Nedre v gen 100 SE 975 92 Lule Sweden tel 46 0 920 47 47 00 fax 46 0 920 47 47 01 info l
7. 1 56 Leg Sabina Uno100 rg 3 s Geersarui O 1 ss 2 anu ma ee NE 80 CylindicbotHCB 10x35 1 NI gt INININ NEN 55 7 2 Part no 2020003 www liko com Components Sleeve bearing 30 Position 9 page 73 and 79 Screw M6S M6x40 S S Sleeve bearing Mob 30 Lock nut M6 Nyloc Cover hat Liko Sleeve bearing 52 Position 10 page 73 and 79 it 6 s covera 2 s 56 7 3 www liko com 8 1 d Li ko Sabina EM A Company Decal Instruction Dekalanvisning a 2x v Lik Size Storlek 159 x 24 mm B Prod No 2020004 22 LIKO omv Prod No Art nr 900002231 1 Size Storlek 70 x 11 feet 59202 03 x m m ize Storlek 70 x 11 mm 212 Gs NES Prod No Art nr 900002233 1 Size Storlek 107 x 52 mm Prod No Art 900001457 Layout layout_PE6_Samhall e 5 2x i Size Storlek 80 x 20 mm Jabina IL Prod No Art nr 900001109 Jabma Il Centrera i h jdled Likadant pa b da sidor Centre vertically The same on both sides Centrera i sidled Centre laterally Placera i h jd med kontrollboxens underkant Centrera i sidled OBS F rs kra er om att kanterna pa etiketten ordentligt fastsatta Place on the same level as the bottom of the co
8. Ns A NOTE Make sure the spare part is mounted according to the assembly instruction Check all functions related to the changed spare part Repairs and maintenance may only be performed by personnel authorized by Liko and using original Liko spare parts 14 www liko com 5 43 1 rufa Actuator LA 28 Stalldon LA 28 A Hill Rom Company Assembly Instruction Monteringsanvisning Contains Screw SK6SS M8x10 Prod No 20190003 Actuator LA28 grey U102 3SE640284 03 2009 06 24 Fits Uno 101 Uno 102 Uno 100EM EE Uno 102EM EE ES Sabina Sabina EE EM Tools required Assemble the screws enclosed with the sparepart Connect the cables as follows Tightening torque 8Nm 5 Cable handcontrol to socket 1 Cable from the motor for lift arm to socket 2 Cable motor for base width adjustment to outlet 3 A NOTE Make sure the spare part is mounted according to the assembly instruction Check all functions related to the changed spare part Repairs and maintenance may only be performed by personnel authorized by Liko and using original Liko spare parts 15 www liko com d Liko 5 51 1 Emergency Lowering Device N ds nkning U1 2 Sa Make sure the spare part is mounted according to the assembly instruction Check all functions
9. Repairs and maintenance may only be performed by personnel authorized by Liko and using original Liko spare parts 32 www liko com 5 188 1 11 Li ko Control Box Kontrollbox A C Company Assembly Instruction Monteringsanvisning Prod No 20290024 contains Qty E Control Box 1 Fits Sabina EM EE Tools required F N 7 IP Cg A NOTE Make sure the spare part is mounted according to the assembly instruction Check all functions related to the changed spare part Repairs and maintenance may only be performed by personnel authorized by Liko and using original Liko spare parts 33 www liko com 5 189 1 PT Actuator Sabina Il 14 Li ko St lldon Sabina II A Company Assembly Instruction Monteringsanvisning Contains Actuator Sabina II Prod No 20290023 Fits 35 640247 03 Sabina II EE EM 2009 06 26 Tools required Make sure the spare part is mounted according to the assembly instruction Check all functions related to the changed spare part Repairs and maintenance may only be performed by personnel authorized by Liko and using original Liko spare parts 34 www liko com 5 216 1 Ful Restoration set Manual Base 24 Li ko Renoveringssats manuell breddning A
10. o 55 Foot Tray Sabina 56 Leg Sabina Unotoo rg 1 s Oo 3 OS Spacer 2 60 Distans amp x12x80 uram J a 61 PomedikngnaMS 2 Wemigpae 3 69 Plastio cover IKPT 28286 3 64 Pressure spring 3050 3 Turmable plate UTO2EM 66 Barcon 67 Screw PSH mors J gt 32m Pinwith snapping 3 70 3 PesteewerK22198 3 72 n 75 cemereingUt2EM 3 74 Washer o erem en mtn a6 1 NJ gt NINJN 53 www liko com Components Sabina Il EE Lever M10x60 grey Lift arm Sabina II COo 7 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 2 4 54 7 2 Part no 2020003 www liko com Components Sabina Il EE 12 44 2 _ 45 legwoecionSaUnol 2 45 Sabina Uno100 IE m a4 Frontwheel7 mm 2 _ 51 4 SE Conen 54 1 55 Foot Tray Sabinan
11. Exploded views Base Sabina II EM R3009134 9 49 www liko com Exploded views Mast Sabina Il EE Se page 63 R3979116 16 50 www liko com Exploded views Base Sabina EE R3979115 9 51 www liko com Components 7 1 Sabina EM Part no 2020004 772 2 3 hook casing fa 4 JSorewkesmexeoEzoe 2 1 6 Plastic cover RBo702 86 1 7 Lever wioxsogrey 2 8 Liar Sabina 1 9 sieeve bearings 15 Washer plastic 1252002 a 4 Nylon bearing 0426 1 15 Charging cable oder M 16 PasicewerP3026G a Mast Sabina 38 eaey 9 Emegenygud 1 30 4010006 22 Locking rat Leg support 1 25 Actuator Sabina 24 SwmeflegsupotSa 1 25 Strap uphoistey Sa M 326 Leg support board 5 p TEE lt a So BB Plug for hole CB12 14 gre 52 www liko com Components 7 1 Sabina EM Part no 2020004 45 Soewskess Mao J gt 2 45 Legprotecton J 2 46 Leg Sabina Unot00le 1 ar FemwhelT mm gt 51 Domed iocking numo 52 Screw mes maros 2 59 Screw mes mers 2 5 Foot frame Sabina
12. Replacement if worn Tools required cs 1 Remove cover 2 Loosen and remove screw 3 Remove and clean the castor wheels Replace and tighten Re assemble in reverse order 4 If wheels are worn or do not roll smoothly replace them Recommended replacement is every 5th year Preventative Maintenance Sabina 68 www liko com 10 0 Instructions reguarding the check pionts for Sabina EE EM Sabina Il EE EM Rear castor cleaning Lift type Serial No Prod Year Contract No Name Month 12 24 36 48 60 72 84 96 108 120 Address Check Zip Code Replacement if worn Tools required 1 Remove cover 2 Loosen and remove screw 3 Remove and clean the castor wheel and housing Re assemble in reverse order 4 If wheels are worn or do not roll smoothly replace them Recommended replacement is every 5th year 5 Check the brakes They should lock in all directions Preventative Maintenance Sabina 69 www liko com 10 0 Instructions reguarding the check pionts for Sabina EE EM Sabina EE EM Pin bolt lubrication Month Check 12 24 36 48 60 72 84 96 108 120 1 Remove footplate or plastic cover from center Name Address Zip Code Tools require
13. SK6SS 8 10 Emergency guard introduced 2006 Changes SIN Project Batterybox with display 423853 550 Batterybox without display 423704 550 New pivot points arm actuator 421809 426 2005 Changes SIN Project New locking handles 419031 4 sh 76 www liko com 11 0 A Liko Sabina Il EE Sabina Il EM A CI Company Product changes Prod No 2020003 EE 2020004 EM S 2003 Changes S N Project New version of screw M6S M12x105 414443 Sabina II EM replaces Sabina EM 413621 Waxed inner packaging introduced bubble plastic and foam discontinued 413373 New version of centre Locking nut M12 instead of welded castellated nut EM 406485 New version of centre Locking nut M12 instead of welded castellated nut Sabina Il 413260 Foot tray tested on every lift 412854 New serial number decal EM 406453 New serial number decal EE 412630 2002 Changes SIN Project New colour coating on handcontrols 411496 Plastic spacer washer 12 5 20x0 42 added to sleeve on emergency lowering de 410702 vice EM S6SS M6x10 discontinued mounted in the centre 410702 New screw on mast attach MRT GF M5x16 410702 2001 Changes SIN Project Last Sabina in old style 406250 First Sabina 11 410001 oh 77 www liko com
14. 00 eee 5 60 1 19 Rear Wheel 75 Tir t enne 061 nee 5 61 12 20 Liftarm Plastic Cover 063 5 63 1 se 21 Front Wheel 100 22 064 caet 5 64 1 ns 22 Rear Wheel 100 05 cae 5 65 1 23 Foot tray complete rt ecce ern Of 5 07 11 24 Actuator JKAS 250 69 lt lt 5 69 1 25 Control Box WO PEDE 27 L g LT A 5 41 1 es 28 Strap Tor leg support Du 2 29 Safety latch tete o Set ecce Lors ex incer da B ssi 5 8 1 ue 30 Extra Battery Box incl 139 des 5 1391 e 31 Extension cable 160 5 160 1 32 Control Box Sabina 188 de 5 188 1 33 SA Mosa ess EE 189 5 189 1 34 Restoration set Manual 210 tees 5216 35 Restoration set Electrical 211i kie 5 217 1 37 Restoration set Emergency 220 nins 5 220 1 39 FOOL Thay 290 niis 5 230 1
15. ES Sabina LikoLight to S N 2504053 nap Viking S 31590015 Viking XS Seal colour Emergency Lowering Uno Sabina LikoLight up to S N 2504053 e Replace 4 spare part 4 Assemble the product in reverse order Replace spare part Seal screw with 31590015 Seal colour Emergency Lowering NOTE Make sure the spare part is mounted according to the assembly instruction Check all functions related to the changed spare part Repairs and maintenance may only be performed by personnel authorized by Liko and using original Liko spare parts 39 www liko com 5 230 1 4 Foot tray cover 24 Li ko Fotplatta A C Company Assembly Instruction Bantains Monteringsanvisning db ue Prod No 20290026 Fits 3SE630245 04 Sabina EE EM Sabina 200 2009 09 22 RollOn y opel 2 Tools required Sabina 9 1 Place the footrest over the base of the mast as shown in the illustration Make sure it s correctly aligned 2 Press down the foot tray in a stable position over the foot frame RollOn Foot frame 2 LY gt Foot tray 1 Place the foot frame in position at the middle 2 Press down the foot tray in a stable position over beam as shown in the illustration Make sure it s the foot frame correctly aligned A NOTE Make sure the spare part is mounted according to the assembly instruction Ch
16. 311110122 Comfort SlingBar 413 689 417 342218 59 272 449 209 9 354 82 354 393 4209 66 7 318 309 3111240134 Different measurements depending on the height setting position please see Assembly p 5 Note The measurements are based on the lift being equipped with standard wheels When changing wheels check that the lift still achieves desired lifting height Reference measurement according to Standard EN ISO 10535 2006 4 www liko com Maximum load Material Weight Wheels Foot rest Lower leg support Turning diameter Emergency lowering device Lifting Speed without load Maximum Noise Output Protection class Technical Data Active lifting 200 kg 440 Ibs Passive lifting 150 kg 330 Ibs Powder painted steel Total 45 2 kg 100 Ibs Heaviest removable part 22 7 kg 50 Ibs Standard front 75 mm twin wheel Standard back 75 mm individual wheel fitted with brake Removable Adjustable in terms of height and depth Removable 1180 mm 46 5 in Mechanical and electrical SlingBar 350 54 mm s 2 13 in s Comfort SlingBar 47 mm s 2 1 in s 46 dB A IP 43 Operating forces of controls Intermittent operation Batteries Battery charger Lift motor Motor base 3 0 2 4N Int Op 10 90 active operation max 2 min Only 1096 of a given length of time may be active yet n
17. To be actioned these actions should be performed immediately After performed actions sign below If anything is unclear or if you have questions please contact Liko or your local Liko representative Contact information is to be found at www liko com Inspection performed by Final approval by Next inspection Date Approval date Inspection performed in accordance with ISO 10535 2006 Annex B Periodic inspection Periodic Inspection Sabina 59 www liko com 9 0 Check points Sabina Sabina Comfort 2 8 lt NI i 12 15 16 11 13 7 Sabina Il eA VAL 3 i CN TD 3 Sabina 200 10 9 20 14 12 15 16 Periodic Inspection Sabina 60 www liko com 9 0 Instructions for the check points 1 a amp b General inspection Check for scratches dents deformities or unusual surface wear On mast inspect weld at leg support tube 2 Type model identification decal Verify presence of mast decal with model type and serial number 3 Castor wheels Roll the lift unloaded along the floor checking to ensure that all castors roll and turn freely Verify that castor fasteners are tight 4 Castor brakes Lock the brakes Make sure the wheels do not turn and the castor housing does not swivel when the lift is pushed 5 Base opening and closing linkage Sabina Sabina Il Sabina Comfort Ver
18. Viking XL Viking L Viking M 2040005 Caroli RE J V E x P 5 139 1 Extra Battery Box incl Batteries Batteribox inkl batterier Assembly Instruction Monteringsanvisning Prod No 2006106 3SE630224 04 2009 11 24 NOTE Make sure the spare part is mounted according to the assembly instruction Check all functions related to the changed spare part Repairs and maintenance may only be performed by personnel authorized by Liko and using original Liko spare parts Old batteries are to be left at the nearest recycling station or given to personnel authorized by Liko X Pb A 31 www liko com 5 160 1 Extension Cable 24 Liko Skarvkabel A 1171 Company Assembly Instruction Monteringsanvisning camane Qty B Extension cable EU 1 Prod No 21090001 Fits 3SE630225 03 Golvo 7000ES 7007ES 2009 11 04 Uno 100 EM EE Uno 102 EM EE ES da EE Length 21 cm 8 5 inch Viking XL Viking L Viking M prod no 2040005 T ee mS Nes 2 1 m 2 O 3 24 7 7 50 40 0 Qe O oi tol A A NOTE Make sure the spare part is mounted according to the assembly instruction Check all functions related to the changed spare part
19. 0283 02 2009 09 22 dd gt Tools required 17 mm le 1 1 1 Capella E Z Tightening Torque Atdragningsmoment 45 5 Nm NOTE Make sure the spare part is mounted according to the assembly instruction Check all functions related to the changed spare part Repairs and maintenance may only be performed by personnel authorized by Liko and using original Liko spare parts 19 www liko com A company Contains Rear wheel 75mm Domed locking nut M10 Screw MC6S M10x25 Fits Uno 101 102 Uno 100EM EE Uno 102EM EE ES Qty 1 1 5 61 1 Rear Wheel 75 mm Bakhjul 75 mm Assembly Instruction Monteringsanvisning Prod No 20190043 3SE640282 02 2009 09 22 17mm Tools required Sabina 8 Sabina EE EM Caroli ie p ZA Tightening Torque Atdragningsmoment 45 5 Nm A NOTE Make sure the spare part is mounted according to the assembly instruction Check all functions related to the changed spare part Repairs and maintenance may only be performed by personnel authorized by Liko and using original Liko spare parts www liko com C Company contains Plastic cover Cover hat Liko Cover hat Liko bottom Sleeve bearing Mob 52 Locking
20. EM EE J lt lt 19mm Uno 100 to S N 7092715 Uno 102 to S N 41550 Sabina EM EE to S N 406484 Sabina II EM EE to S N 413259 PTFE grease S Dismount and dispose the bolt S b lt gt Acum m k N ce 6 Ss In Remove plastic cover Uno Foot plate Sabina Remove split pin PES 2 3 N N Do cs ce m ___ amp Lubricate new screw with grease mount together with new split pin j Uno 100 from S N 7092716 Uno 102 from S N 41551 Sabina EM EE from S N 406485 Sabina Il EM EE from S N 413260 pe Lubricate new screw with PTFE grease oe Tightening torque 17Nm x 2Nm NOTE Make sure the spare part is mounted according to the assembly instruction Check all functions related to the changed spare part S Repairs and maintenance may only be performed by personnel authorized by Liko and using original Liko spare parts P 44 www liko com Company Contains Cover hat Liko Cover hat Liko bottom Sleeve bearing Mob 30 Nylon bearing 10x12x6 Locking nut M6 Nyloc Screw M6S M6x40 Washer PS 6x12x1 Washer 12 5 20x0 42 Bush Piston LA34 Fits Sabina II EE EM et 5 317 1 Pivotpoint actuator Sa B
21. Sabina Sabina EE EM Service Manual English Prod No 2020003 Sabina II EE 2020004 Sabina II EM 3EN550401 05 2010 04 01 Proj 1059 s v LM C N M Sabina Il EE C Company Copyright Liko AB 1 0 Table of Contents Sabina Sabina Il EE EM Position Ref no Page Table of TOi 2 Spare Parts POSILIONS Eaa 3 Technical Data E BO 4 Troubleshooting inert etit atte ec en reti eds 6 SA p 7 Attachment for control iit reis nes 10 Hand control ES 6 button 20 isis 5 20 1 11 Cable for charging 22 12 Cable for charging 5 23 55 13 Cable for charging P adn 5 24 1 iusso 14 Actuator LA28 for base 9 43 15 Emergency Lowering Ea i 16 Hand control EM 2 Lo 5 54 1 17 Leg protector U1 2 22 5 58 18 Front Wheel 75
22. Test Run the lift with specified load all the way up and down Make sure the load is hanging straight down from the lift hooks so they don t bend Run the base in and out with specified load Listen for peculiar noises and vibrations Test load Sabina Sabina Comfort Sabina ll Sabina 200 150kg 330165 150kg 330165 120 kg 265 105 19 Documentation Instructions Instruction guide Sabina Il from S N 452000 Sabina 200 Quick Reference Guide shall be placed in the intended holder control unit Periodic Inspection Sabina 63 www liko com 64 www liko com 10 0 Li ko Sabina EE EM Sabina EM Preventative Maintenance 3EN551101 03 2007 06 19 Customer Reference Litt type A E Contract No b Serial No Name Version Address ee Prod Year 4 Code Base Month 12 24 36 48 60 72 84 96 108 120 Surface treatment Front castor cleaning Rear castor cleaning Pin bolt lubrication Actuator linkage A Electric Base linkarm lubrication B Mechanical Base mounting plate inspection Mast 1 Surface treatment 6 Lift arm 7 Emergency lowering device Sabina EE ES 8 Battery check battery capacity
23. are part is mounted according to the assembly instruction Check all functions related to the changed spare part Repairs and maintenance may only be performed by personnel authorized by Liko and using original Liko spare parts 10 www liko com 4A Liko A CI Company Hand control EM EE ES Fits Golvo 7000ES 7007ES Uno 100 EM EE Uno 102 EM EE ES Sabina EM EE Sabina EM EE LikoLight Viking XL Viking L Viking M prod no 2040005 Viking S od XS S Qty 1 Q Connect cable as indicated 5 20 1 Hand Control 2 4 6 button Handkontroll 2 4 6 knapp Assembly Instruction Monteringsanvisning Prod No 20090024 20190016 20190017 3SE630204 08 2009 11 04 Connect cable as indicated NOTE Make sure the spare part is mounted according to the assembly instruction Check all functions related to the changed spare part Repairs and maintenance may only be performed by personnel authorized by Liko and using original Liko spare parts www liko com 5 22 1 14 Li ko Cable for Charging EU Laddningskabel EU A Company Assembly Instruction 7 Monteringsanvisning Contains Qty Charging cable EU 1 Prod No 20090026 Fits 3SE630237 03 Golvo 7000ES 7007ES 2009 11 04 Uno 100 EM EE Uno 102 EM EE ES Sabina EM EE Sabina
24. d 3 Pull out the pin bolts Before cleaning and lubricating inspect the screw according to fig 4 and 5 4 Measure pin bolt thread dimension A If thread dimension A is not within 19 2 mm replace pin bolt with part No 20190057 5 Clean holes and pin bolts If pin bolts are worn replace with part No 20190057 Lubricate the holes and the pin bolts Preventative Maintenance Sabina 70 6 Re assemble base as in Fig 3 2 Tighten bolts and replace pins or locking nuts www liko com 10 0 Instructions reguarding the check pionts for Sabina EE EM Sabina EE EM Actuator linkage Lift type Serial No Prod Year Contract No Name Month 12 24 36 48 60 72 84 96 108 120 Address Nr 1 A Nr 2 7 Zip Gods Tools required Electric base linkarm lubrication Fo 1 Remove splitpin bolt and bushing Lubricate center pin and plastic bushing Replace if worn 4 Pull out link arms 5 Clean the link arms and hole in center Start by brushing grease into the holes Apply a thin layer of grease to the link arms Re assemble in reverse order ap EC 6 Adjust base width D in technical data 7 Adjust the linkarms so that it goes up through the base at a 90 degree angle Tighten locking nuts check play a
25. d maintenance may only be performed by personnel authorized by Liko and using original Liko spare parts www liko com 5 72 1 Strap for Leg Support a Liko Secon A Company Assembly Instruction Monteringsanvisning Contains Qty Prod No 20290022 Band 40mm 688 green 1 Lightweight buckle 2 35 640279 02 D ring plastic 2 2009 06 24 Fits Sabina Sabina Il EE EM A NOTE Make sure the spare part is mounted according to the assembly instruction Check all functions related to the changed spare part Repairs and maintenance may only be performed by personnel authorized by Liko and using original Liko spare parts 29 www liko com 5 87 1 y Liko Safety Latch Urkrokningsskydd A D Company Assembly Instruction s Monteringsanvisning Contains Qty Safety Latch 2 d Prod No 31190018 Fits 3SE640271 03 SlingBar Standard 450 2009 09 22 Sabina Caroli Capella E NOTE Make sure the spare part is mounted according to the assembly instruction Check all functions related to the changed spare part Repairs and maintenance may only be performed by personnel authorized by Liko and using original Liko spare parts 30 www liko com JL Liko A Company Qty Battery box 1 Fits Golvo 7000 7007 all models Uno 100EM EE 102EM EE ES Sabina LikoLight
26. ddress Contract ciii tte ikea N Zip Code The Lift must be thoroughly inspected at least once per year Inspection and service must be carried by Liko authorized personnel Instructions for check points from next page Check points Base Approved To be Not actioned approved 1 a General inspection 2 Type model identification decal Castor wheels Castor brakes Base opening and closing linkage Base frame castor play amp levelling NO BW Foot tray Mast 8 Locking handles 9 Lift arm hardware amp covers 10 Sling bar with safety latches 11 Adjustable lower leg support 12 Mast actuator 13 Battery amp electrical cable installations 14 Functions on the hand control 15 Emergency Stop function 16 Electrical emergency lowering device functions 17 Charger function Load testing 18 Load Test Documentation 19 Instructions Instruction guide Comments Approval to use the patient lift Approved To be actioned Not approved If the patient lift has one or more check points with result Not approved the system must not be used If the system has one or more check points with result
27. e sure the spare part is mounted according to the assembly instruction Check all functions related to the changed spare part Repairs and maintenance may only be performed by personnel authorized by Liko and using original Liko spare parts 42 www liko com C Company Contains Qty Hook for Handcontr 2 4 6 1 Fits Golvo 7000 7007 7000 7007ES Golvo Classic Golvo Facelift Sabina Sabina II EE EM Sabina 200 LikoLight Viking XL Viking L Viking S _ Viking XS 5 292 1 Hook for handcontrol 2 4 6 button Krok f r handkontroll 2 4 6 knappar Assembly Instruction Monteringsanvisning Prod No 20090058 3SE630210 04 2009 06 25 Tools required LL THE NOTE Make sure the spare part is mounted according to the assembly instruction Check all functions related to the changed spare part Repairs and maintenance may only be performed by personnel authorized by Liko and using original Liko spare parts 43 www liko com 44 Liko 5 312 1 Screw M12x105 U1 2 Sa Skruv M12x105 U1 U2 Sa A CEED Company Assembly Instruction ay Monteringsanvisning Split Pin SP 3 2x20 2 Prod No 20190057 Screw M6S M12x105 2 3SE640245 04 Tape 19x30 Uno 8 2010 03 09 Fits gt Uno 101 Uno 102 Y N N Tools required Uno 100 EM EE Uno 102 EM EE ES I K N 2 0 Sabina Sabina
28. eck all functions related to the changed spare part Repairs and maintenance may only be performed by personnel authorized by Liko and using original Liko spare parts 40 www liko com 5 248 1 P d Cable for Charging AU NZ 24 Li ko Laddningskabel AU NZ A Assembly Instruction Monteringsanvisning Prod No 20090050 3SE630243 04 Fits 2009 11 13 Golvo 7000ES 7007ES Uno 100 EM ES Uno 102 EM EE ES Sabina EM EE Sabina II EM EE Viking XL Viking L Sa M Contains Qty Cable for Charging AU NZ 1 NOTE Make sure the spare part is mounted according to the assembly instruction Check all functions related to the changed spare part Repairs and maintenance may only be performed by personnel authorized by Liko and using original Liko spare parts 41 www liko com A Liko 5 263 1 Extension Cable US Skarvkabel US A D Company Assembly Instruction ES Monteringsanvisning Contains Qty Extension cable US 1 Prod No 21090011 Fits 3SE630218 03 Golvo 7000ES 7007ES 2009 11 13 Uno 100 EM EE Uno 102 EM EE ES Sabina EM EE Sabina EM EE Length 26 5 cm 10 5 inch Viking XL Viking L Viking M prod no 2040005 a ee mS Ne A 4 NOTE Mak
29. emergency lowering device to lower the patient onto a firm surface 4 Check the battery voltage 5 If the problem remains please contact Liko Contact Liko 6 www liko com 5 0 Spare Parts List Sabina Sabina EE EM PROD NO POS NO NAME 20090023 Attachment for Control Box 20090024 2 Hand control ES 6 Button B eee fits Sabina EE Sabina II EE 20090026 2 Cable for Charging EU 1 an S j 20090027 Cable for Charging UK q 20090028 Cable for Charging US 20190003 43 Actuator for Base Widening p fits Sabina EE Sabina EE 9 0 2 20190011 1 Emergency Lowering Device 8 1 3 TN SS 20190016 4 control EM 2 Button fits Sabina EM Sabina Il EM 20190042 Front Wheel 75 mm 20190043 Rear Wheel 75 mm 20190045 20190046 Front Wheel 100 mm Lift Arm Plastic Cover 20190029 Leg Protector U1 Sa 7 www liko com 5 0 Spare Parts List Sabina Sabina EE EM PROD NO POS NO NAME UNIT 20190047 Rear Wheel 100 mm Extra Battery box incl Batteries 65 67 70 71 72 87 39 88 20290006 Foot Tray complete Sa 20290011 i Control Box Sa 20290021 i Leg Support 31190018 Safety Latch 20290024 Control Box Sa II 20290023 Ac
30. fter assembly No 2 7 every 3rd year Preventative Maintenance Sabina 71 www liko com 10 0 Instructions reguarding the check pionts for Sabina EE EM Sabina EE EM Actuator linkage Serial No Prod Year Contract No Name Month 12 24 36 48 60 72 84 96 108 120 ddress Check Replacement if worn Zip Code Tools required O s Mechanical base mounting plate inspection 1 Replace mounting plate if teeth is worn 2 Pull back the handle to check compression spring 3 Ensure that the turnable plate welding is not bent and secures in turnable plate teeth when the handle is released 4 Inspect linkage arms and ball coupling hardware Recommended replacement is every 5th year Preventative Maintenance Sabina 72 www liko com 10 0 Instructions reguarding the check pionts for Sabina EE EM Sabina Il EE EM Lift arm Lift type Serial No Prod Year Contract No Name Month 12 24 36 48 60 72 84 96 108 120 Address Check Zip Code Tools required C 1 0 ge 00 000 1 Remove covers 2 Remove and lubricate lift arm hardware 3 Lift up the arm and check that the slot between Visually inspect lift arm plastic shells for plastic cover retains the same size if not t
31. he screw is to wear cracks or deformation Reassemble in tight Release so that it falls to the lowest position If the reverse order arm does not fall to the lowest position the screw is to tight Preventative Maintenance Sabina 73 www liko com 10 0 Instructions reguarding the check pionts for Sabina EE EM Emergency lowering device Lift type Serial No Prod Year Contract No Name Month 12 24 36 48 60 72 84 96 108 120 Address Check Replace emergency Zip Code lowering rest set Tools require 0 1 Loosen screws and remove cylinder 2 Remove the countersunk screw Twist up the red cylinder NOTE Turn it slowly to prevent damage to the threads 3 Clean the cylinder 4 Clean sleeve and holes in the emergency lowe N NOTE Keep this surface free of grease ring device and lift arm Lubricate sleeve with grease Mount the new friction washer part No 20190051 before re assembly 5 Re assemble the emergency lowering device accord ing to 5 51 in the Service manual Replace emergency lowering restoration set every 3rd year Preventative Maintenance Sabina 74 www liko com 10 0 Instructions reguarding the check pionts for Sabina EM Sabina EE EM
32. ify that the M12 x 105mm pin bolt is secured with a nyloc nut or cotter split pin in welded castle nut Manual Base EM Inspect mounting plate teeth for wear Pull back on handle to check compression spring pressure Turnable plate welding should secure in mounting plate teeth when the handle is released Inspect linkage arms and ball coupling hardware Verify max amp min dimensions Can be found in the Instruction Guide Electrical Base EE Check that the set screws 2 in center section collar are tight Inspect Pivot Arms left and right for scratches gouges Inspect linkage arms and ball coupling hardware Verify max amp min dimensions Can be found in the Instruction Guide Sabina 200 Check that the screws and nuts in base motor are tight Inspect the diagonal bar Sabina 200 Inspect linkage and plastic covers Verify max amp min dimensions Can be found in the Instruction Guide 6 Base frame castor play amp levelling Sabina Sabina Il Sabina Comfort Roll the lift along a level floor surface and check to ensure that the distance between the wheels and the floor does not exceed 6 mm 0 24 Inch Manually open and close legs at the front casters to measure wheel play Base width wheel play should not exceed 35 mm 1 38 Inch total 7 Foot tray Inspect plastic Foot tray cover for cracks and secure fit on metal frame Verify that the foot frame sits securely on base 8 Locking handles L
33. iko se www liko com 2 0 Spare Parts Positions PROD NO PRODUCT PROD NO PRODUCT 2020001 Sabina EE 2020003 Sabina Il EE 2020002 Sabina EM 2020004 Sabina Il EM Sabina EE Sabina EM 87 63 ES Fits Sabina all models Ee 20Y54 692 00 19 69 70 Y f 22 as aa 048 A 5 Sa N Ww 67 43 rtg 58 N 2191 7 5 2 SS 7 7 61465 3 www liko com 3 0 Technical Data Anax Amin E v Ly y v 7 Measurements mm Sabina Il A B1 B2 B3 C D 01102 F Lmin 01119 M EE EM interval pc 1050 1770 1060 870 590 190 690 1115 530 1005 915 210 900 1000 107 22 1725 800 825 790 280 310 Comfort SlingBar 1050 1750 1060 870 555 150 690 1115 530 1005 900 210 900 1000 107 22 1695 810 785 790 316 340 inch Sabina Il Amar B 1 B2 B3 C D D1 D2 E Lmax Lmin Lifting M N O EE EM interval SlingBar geo 41 3 69 6 417 34 2 23 2 7 5 272 44920 9 39 5 360 82 354 393 4209 679 31 5 325
34. lvo 7000ES 7007ES Uno 100 EM EE 3SE630204 08 Uno 102 EM EE ES 2009 11 04 Sabina EM EE Sabina EM EE LikoLight Viking XL Viking L Viking M prod no 2040005 Viking S Viking XS 6 L Connect cable as indicated Q m Connect cable as indicated 054 NG E NOTE Make sure the spare part is mounted according to the assembly instruction Check all functions related to the changed spare part Repairs and maintenance may only be performed by personnel authorized by Liko and using original Liko spare parts www liko com 5 58 1 Fr Lik Leg Protector U1 Sa 4 LIKO Benskydd U1 Sa A D Company Assembly Instruction Monteringsanvisning canana Qty n Leg protector Sabina 2 Prod No 20190029 Tape cushion 19x30 Uno 6 Fits Uno 100 Sabina F 2x ed S NOTE Make sure the spare part is mounted according to the assembly instruction Check all functions related to the changed spare part Repairs and maintenance may only be performed by personnel authorized by Liko and using original Liko spare parts 18 www liko com A CEAD Company a Contains Front wheel 75mm Screw F6S M10x40 Locking nut M10 nyloc Fits Uno 101 Uno 102 Uno 100EM EE Uno 102EM EE ES Sabina Sabina II EE EM Qty 5 60 1 Front Wheel 75 mm Framhjul 75 mm Assembly Instruction Monteringsanvisning Prod No 20190042 3SE64
35. na Sabina Comfort Sabina II Hand control large DIN receptacle H Mast actuator 1 Base motor 2 Extension cord 3 connected to the charging cable Sabina 200 Charging cable 1 Hand control 2 Base motor 3 Mast actuator 4 14 Functions on the hand control With the emergency stop out verify that all functions on the hand control are working 15 Emergency Stop function Press the emergency stop button With the emergency stop pressed in verify that the lift does not operate with the hand control buttons Turn the red emergency button in the direction of the arrows Verify that the button releases from the locked position into the raised open position 16 Electrical emergency lowering device functions With the emergency stop out verify that the electrical emergency lowering device functions Periodic Inspection Sabina 62 www liko com 9 0 Instructions for the check points 17 Charger function With the emergency stop out insert the charger cable into a power outlet 110 240 V AC The yellow diode li on the control unit should light up Sabina Sabina Comfort Sabina Il Make sure that both indicator lamps on the charger are illuminated yellow light during charging green light during maintenance charging Sabina 200 When the charger is connected a diode light at the charger indicates yellow light during charging green light during maintenance di 18 Load
36. nctions related to the changed spare part Repairs and maintenance may only be performed by personnel authorized by Liko and using original Liko spare parts www liko com A Company Contains Spacer front 50 10 5 15mm Castor with brake 100mm Screw K6S M10x50 Locking nut M10 nyloc Fits Uno 101 102 Uno 100EM EE Uno 102EM EE ES Sabina Sabina EE EM Qty B 1 1 1 1 5 65 1 Rear Wheel 100 mm Bakhjul 100 mm Assembly Instruction Monteringsanvisning Prod No 20190047 3SE640285 02 2009 06 23 Tools required 17 mm 6 mm SS Tightening Torque Atdragningsmoment 45 5 Nm NOTE Make sure the spare part is mounted according to the assembly instruction Check all functions related to the changed spare part Repairs and maintenance may only be performed by personnel authorized by Liko and using original Liko spare parts www liko com 5 67 1 11 1 Foot Tray complete Sabina a Liko Fotst d komplett Sabina A Company Assembly Instruction Monteringsanvisning Contains Qty B Foot Tray Sabina II 1 Prod No 20290006 Foot frame Sabina 1 3SE640239 02 Fits 2009 06 24 Sabina ES uu 1 2 e ae 1 Place the footrest over the base of the mast as shown in the illustration Check to see that the brackets are correctly aligned 2 Check to see that the
37. nel authorized by Liko and using original Liko spare parts 26 www liko com 5 70 1 11 Control Box 24 Li ko Kontrollbox A CD Company Assembly Instruction Monteringsanvisning Prod No 20290011 contains Qty Control Box 1 Fits Sabina EE Sabina EM Tools required 3 mm a i Lal jx ext 12 NOTE Make sure spare is mounted according to the assembly instruction Check all functions related to the changed spare part Repairs and maintenance may only be performed by personnel authorized by Liko and using original Liko spare parts 27 www liko com A Liko A CEED Company Contains Leg Support Sabina Fits Sabina Sabina EE EM Qty Place the brace for the leg support into the bracket on the mast Use knob A to adjust the depth i e the distance to the patients knees Adjust the height of the leg support and turn knob B to lock the leg support in place Tighten the knobs securely after making these adjustments 5 71 1 Leg Support Underbensst d Sabina Assembly Instruction Monteringsanvisning Prod No 20290021 3SE640280 02 2009 06 24 NOTE Make sure the spare part is mounted according to the assembly instruction Check all functions related to the changed spare part Repairs an
38. ntrol box Centre laterally NOTE Make sure that the edges of the decal are properly pasted 17mm Centrera i h jdled Li ko A company Likadant b da sidor Centre vertically The same on both sides 57 www liko com 8 2 Liko Sabina II EE A Company Decal Instruction Dekalanvisning 1 Size Storlek 70 x 11 mm Prod No Art nr 900002233 1x Size Storlek 107 x 52 mm Prod No Art nr 900001457 Rist Layout layout_PE6_Samhall Centrera i sidled Centre laterally Placera i h jd med kontrollboxens underkant Centrera i sidled OBS F rs kra er om att kanterna pa etiketten r ordentligt fastsatta Place on the same level as the bottom of the control box Centre laterally NOTE Make sure that the edges of the decal are properly pasted Centrera i h jdled s az em Likadant p b da sidor Centre vertically The same on both sides 58 www liko com i4 Uko A D Company 9 0 Sabina EE EM Sabina EE EM Sabina Comfort Sabina 200 Periodic Inspection Prod No EE 2020001 EM 2020002 II EE 2020003 II EM 2020004 Comfort 2020005 200 2020020 2010 03 26 Customer Reference Lift type Prod No S N Prod Year Name A
39. nut M6 Nyloc Washer PS 6x12x1 Screw M6S M6x65 gt Fits Sabina Il LikoLight Vi S up to S N 7300867 5 63 1 Liftarm Plastic Cover Pelarkapa sats Assembly Instruction Monteringsanvisning Prod No 20190045 3SE630211 08 2009 01 28 Tools required F 2 qo 10 mm Ns A Viking S up to S N 7300867 B eee oes Erstes Yoon QGOe Not included in sparepart Make sure the spare is mounted according to the assembly instruction Check all functions related to the changed spare part Repairs and maintenance may only be performed by personnel authorized by Liko and using original Liko spare parts 21 www liko com A Company C Contains Spacer rear 50 10 5 10 mm Castor 100 mm Locking nut M10 nyloc Screw F6S M10x50 Fits Uno 101 Uno 102 Uno 100EM EE Uno 102EM EE ES Sabina Sabina II EE EM Qty 1 1 1 1 5 64 1 Front Wheel 100 mm Framhjul 100 mm Assembly Instruction Monteringsanvisning Prod No 20190046 3SE640281 02 2009 06 24 V Tools required 17 p SAMT J Tightening Torque Atdragningsmoment 45 5 Nm A NOTE Make sure the spare part is mounted according to the assembly instruction Check all fu
40. o more than 2 min 2x 12 V 2 9 Ah Valve regulated lead acid gel type batteries New batteries are provided by the supplier Built in charger for 100 240 VAC 50 60 Hz max 400 mA 24 V 9 2 A permanent magnetic motor with mechanical safety mechanism 24 V 5A permanent magnetic motor 4 The device is intended for use indoors Type B in accordance with the electrical shock protection class E Class II equipment www liko com The lift does not go up down Base width adjustment does not work in out The charger doesn t work The lift is stuck in a high position If you hear unusual sounds 4 0 Troubleshooting 1 Check that the emergency stop has not been engaged 2 Make sure that the cables to the control box are connected correctly 3 Make sure that the charging cable is not connected to a socket 4 Check the battery voltage 5 Check that the battery s contact plates are not defective or broken 6 If the lift still does not work properly please contact Liko gt 4 Check that the emergency stop has not been engaged 2 Check that the battery s contact plates are not defective or broken 3 If the lift still does not work properly please contact Liko F 1 Check that the emergency stop has not been engaged 2 Use the selected electrical emergency lowering device to lower the patient onto a firm surface 3 Use the selected mechanical
41. oosen amp re tighten locking handles Verify that threads are not damaged or binding Periodic Inspection Sabina 61 www liko com 9 0 Instructions for the check points 9 Lift arm hardware amp covers Make sure the screw not is tightened too hard The arm must not fasten in the top position Inspect the plastic protective cover shells for cracks deformation or gaps 10 SlingBar with safety latches Inspect visually that the SlingBar is free from any scratches sharp edges or deformities Make sure that both safety latch clips are mounted and fall back against the body of the Lift hooks Inspect both Lift hook screws Make sure they are tightened 11 Adjustable lower leg support Verify that upper and lower locking knobs are tight Inspect plastic backing for cracks Sabina Sabina Il Sabina Comfort Inspect vinyl cushion cover for rips tears Inspect buckles for secure snap fit within shin support strap 12 Mast actuator Verify that the upper and lower actuator fasteners to the mast are tight Visual inspection of tubes back fixture and piston rod eye Check of abnormal noise level Sabina Il Sabina 200 Check of electric end stop by using Service box 21090013 EU 21090014 21090015 US 13 Battery amp electrical cable installations Verify battery charge recharge battery or test with Prod No 2101100 Inspect that all cords are in the proper receptacles of the control box Sabi
42. plastic footrest is pressed down and in a stable position over the foot rest frame A NOTE Make sure the spare part is mounted according to the assembly instruction Check all functions related to the changed spare part Repairs and maintenance may only be performed by personnel authorized by Liko and using original Liko spare parts 24 www liko com 5 69 1 Li k Actuator JKAS 250 G L4 LIKO St lldon JKAS 250 G Assembly Instruction Monteringsanvisning Prod no 20290008 3SE630252 04 2007 06 20 Proj 484 6 Tools required 2x Cs 17 8 mm V SORS 14 mm Remove the actuator e p MC6S M10x25 SSV ARM Uno 100 S N lower than 7094429 Uno 102 S N lower than 45055 Drill the regular hole to 14 mm A Make sure both casings are in the assembly gt 25 www liko com Actuat ctuator L4 Li ko St lldon JKAS 250 G Assembly Instruction Monteringsanvisning Prod no 20290008 3SE630252 04 2007 06 20 Proj 484 M6S M10x50 Connect the cables as follows Handcontrol to pos 1 Motorcable mast to pos 2 Motorcable base to pos 3 NOTE Make sure the spare part is mounted according to the assembly instruction Check all functions related to the changed spare part Repairs and maintenance may only be performed by person
43. related to the changed spare part Repairs and maintenance may only be performed by personnel authorized by Liko and using original Liko spare parts A D Company Assembly Instruction Monteringsanvisning Comans Qty O ring 20 22x3 53 U102 3 Prod No 20190011 Bearing 12 14x6 1 Washer 12 5 20x0 42 2 35 630230 05 Twist casing 1 2009 11 19 Mounting bush 1 Butt piston housing 1 Tools required Casing em lowering 1 8 mm Bushing em lowering 1 Shim emergency lowering 1 Washer PTFE em lowering 1 SS 17 Locking nut M10 nyloc 1 2 Screw MC6S 10 25 1 Screw 2 9x9 5 1 10 mm Bolt 12x34 Em lowering 1 Fits SSS 2 7 Uno 102 V Uno 100 EM EE Uno 102 EM EE ES N 1 2 Adjust the twist casing until the mounting bush slides easily Drill a 11 mm deep hole located 4 mm above the edge of the twist casing Use a drill with 0 2 7 mm To countersink the screw into the 00 2 0 SS twist casing drill with a 5 5 mm drill M10 nyloc for the head of the screw 4 2 9x9 5 9 2 screw with 31590015 Seal colour Emergency Lowering A NOTE b 16 www liko com a Liko 5 54 1 Hand Control 2 4 6 button Handkontroll 2 4 6 knapp A cD Company Assembly Instruction Monteringsanvisning Qty Hand control EM EE ES 1 Prod No 20090024 20190016 Go
44. tuator Sa II 20190049 Restoration set Manual Base i 8 www liko com 20290008 Actuator JKAS 250 G Sa 20290022 Strap for Leg support pce 21090001 Extension Cable pce pce pce set 5 0 Spare Parts List Sabina Sabina Il EE EM PROD NO POS 20190050 Restoration set Electrical Base 20190051 Restoration set Emergency Lowering 20290026 Foot Tray cover Sa II 20090050 Cable for Charging AU NZ 21090011 Extension Cable US pce 20090058 Hook for Hand control 2 4 6 20190057 Screw M12x105 U1 2 Sa 20290029 Pivot point actuator Sa II 2027010 Sabina Lift Arm incl Locking Handles 2107101 Locking handles Sabina Uno 9 www liko com il Liko A D Company Screw MRT GF 5 16 Screw MCL6S M5x8 Control box attachment pl Fits Golvo 7000ES 7007ES Uno 100 EM EE Uno 102 EM EE ES Sabina EM EE Sabina II EM EE Viking XL Viking L Viking M prod no 2040005 Qty 3 1 5 19 1 Attachment for Control Box Monteringsbeslag kontrollbox Assembly Instruction Monteringsanvisning Prod no 20090023 3SE630238 03 2009 11 13 Tools required 1 x 3 Viking M L XL Golvo 7000ES 7007ES m x 3 Sabina Uno MV FK 3 LA B 4 y x1 AN A NOTE Make sure the sp
45. ultf rband st lldon Sa Il Assembly Instruction Monteringsanvisning Prod No 20290029 3SE640246 04 2009 06 24 Tools required 2x 10mm 2x eres 7mm NOTE Make sure the spare part is mounted according to the assembly instruction Check all functions related to the changed spare part Repairs and maintenance may only be performed by personnel authorized by Liko and using original Liko spare parts www liko com 5 383 1 Sabina II 350 Slingbar Sabina II Comfort Slingbar Sabina Liftarm inkl locking handles A Company Sabina II 350 Lyftbygel Sabina II Comfort Lyftbygel Sabina Lyftarm med l svred Prod No 2027002 Innehaller Assembly Instruction Monteringsanvisning Prod No 2027002 2027003 2027010 7NN155205 01 2009 07 07 Tools required N dv ndiga verktyg 2x 17 mm Fits Passar till Sabina all models samtliga modeller 1x Lo 8 mm 46 www liko com 5 384 1 Lik Locking Handles 44 LIKO Lasvred A C Company iem Assembly Instruction Monteringsanvisning Prod No 2107101 ix 3SE650248 01 2009 09 25 Fits Uno 100 all models Uno 102 all models Sabina all models Viking all models Caroli Capella 4 1 X gt 47 www liko com 6 1 Exploded views Mast Sabina Il EM Se page 63 R3039105 5 48 www liko com 6 1
Download Pdf Manuals
Related Search