scotsman europe service department
Contents
1. 0 1 2 3 n 5 6 7 8 9 L pe ONLY FOR WATER TYPE gt o N y gt SOLO PER MODELLI AD ACQUA ONLY FOR EASY FIT TYPE 2 amp SOLO PER MODELLI EASY FIT W 20 ST2 i BIN THERMOSTAT ONLY FOR AIR TYPE POWER SA SE o TERMOSTATO SOLO PER MODELLI AD ARIA 4 SWITCH pd mec MAGAZZINO 5 UM INTER 1 T 69 BU BLUE AZZURRO GENERALE 36 10 x GY GREY GRIGIO FEES GNYE GREEN YELLOW VERDE GIALLO 573 9 u GN GREEN VERDE G RD RED ROSSO EVAPORATOR THERMOSTAT i BN YE YELLOW ALME x x TERMOSTATO t T WH WHITE BIANCO EVAPORATORE OG ORANGE ARANCIONE PINK ROSA 2 3 4 SK1 CN3 wy E qa GY e BK u 2 x pp B CLEANING E xi SWITCH _ SA2 INTERRUTTORE 3 RETE 2 PULIZIA 1 2 2 poro sd s a 5 ET CONDENSER TEMP 3 E x SENSOR X Ly SENSORE 5 qe EVI T 55 ane 5 TEMPERATURA COND S M ES QE v w3 PES Qe Qe tu tu 5 85 amp amp Z VALVOLA TCI so Los s SiS GAS CALDO WS1 EMEN 7 d eo 3 55 Je AIT sE WATER LEVEL SENSOR SENSORE 5 BU LIVELLO H20 m N FAN WATER WATER COND TER INLET 01 MODIFICATO COLLEGAMENTO ELETTROVALVOLA PE2. ANDPURGE VALVES RELAY BOARD UVP AC SERES Pa ME EIL ENS J UVP OUT NO DELAY I3 CSTEADY JUMPIN 60 DELAY WATER DRAIN PUMP RELAY FREEZING SWCHES SOC WATER LEVEL SENSOR EC SERIES ONLY OPTICAL ICE LEVEL CONTROL SENSOR HOT GAS WATER INLET TERMNAL CONDENSER SENSOR ANDPURGE VALVES RELAY BOARD i PRO EL IND B LI 0 1 2 3 n B 6 7 8 9 t EASY FIT MODEL MODELLO EASY FIT b e O ERN d UN BERLIN __ AIR COOLED MODEL MODELLO CONDENSATO ARIA 69 TOO TEMPERATURE COND I z 0 ALLARME ALTA TEMPERATURA COND O E w Tm 60 PRU ND PIENO Qo 2 R ON z 2 06 60 PRINTED CIRCUIT MAIN BOARD BN BROWN MARRONE JE CIRCUITO STAMPATO DI COMANDO B APURO E GY GREY GRIGIO GNYE GREEN YELLOW VERDE GIALLO RD GN GREEN VERDE a RD RED ROSSO
3. Scotsman Ice Systems SCOTSMAN EUROPE SERVICE DEPARTMENT SP 08 01 FEBR 08 MC 1210 AT 230 60 3 NEW COPELAND COMPRESSOR Starting from MC 1210 s n 3666 the previous Tecumseh Europe compressor operating at 230V 50 60Hz 3Ph has been replaced with a new Copeland one that operate ONLY at 230V 60Hz 3Ph The Part Nbr of this new compressor is 18008749 24 and it s exchangeable with the former one making some modification on the refrigerant tubes Zum CC OMAN Scotsman Ice Systems SCOTSMAN EUROPE SERVICE DEPARTMENT SP 08 02 FEBR 08 MV SERIES CHANGES IN PC BOARD SOFTWARE Starting from end of 2007 the Software of the PC Board used in all MV units has been modified on the operation of the AUTORESET Jumper Contacts Rather then move automatically the machine in Auto Reset Mode when the AUTORESET contacts are open see photo below the new software is keeping a constant level of the water into the water reservoir during the entire freezing cycle by energizing the water inlet solenoid valve once the water level drops down from the two metal plates of the water level sensor This modification has been required for the machines installed on board of the vessels in order to assure water all the time into the water reservoir at lower level compare with the standard machines during the freezing cycle In case the MV PC Board Part Nbr CM 33580150 is installed in a
4. Pr E ES E Ww ru L Attached the wiring diagram as well as the new PC Board layout ZUERA OMAN zi z 0 1 2 3 n 5 6 7 8 9 BK BLACK NERO SCK1 230 Vac 50 Hz BN BROWN MARRONE n N FUNZDNE O mH Y Y BU BLUE AZZURRO a GY GREY GRIGIO Q E ENT PIENO a E GNYE GREEN YELLOW VERDE GIALLO PRINTED CIRCUIT MAIN BOARD BN 5 2 BU GN GREEN VERDE aco CIRCUITO STAMPATO DI COMANDO A cin _ jem _ 4 4 YE YELLOW GIALLO 60 Jii pFN OG ORANGE ARANCIONE wi G9 D BE EVA AR NE ERRATA a t9 1 PK PINK ROSA Wow T qoo 411 MEP R 2 B x 1 2 3 5 030 SBI A B CN2 CNS POWER EZ Y 4131211 a 2 0 40 RD RO BK BU BK GN C BN BU WATER LEVEL rra LIVELLO ACQUA WS1 101 1 ZNIE D amp amp RTI RIOJ EVI GEAR MOTOR ROTATION aids ROTAZIONE MOTORIDUTTORE M Hes
5. oss OX crises asses com som css os css os en cose son swa cos mars POALE ESSE SUT EI Fo usmew usmew E c c c COS 90033796 C05 99933796 98 99083796 COS 99033796 COS 99933796 DIFF OIL PRESSURE SWITCH COS 1732075 SAFETY RELIEF VALVE COS 99943008 COS 99943008 cos 99943008 cos 99943008 COS 99943008 COS 99943008 COS 99943008 COS 99943008 cos 99943008 cos 99943008 COS 99943008 CRANCASE HEATER COS 2619501 cos 2619501 cos 2619501 cos 2619501 cos 2619501 cos 2619501 cos 2619501 cos 2619502 COS 2619502 COS 2619502 COS 2619496 DISCHARGE LINE TSTAT COS 2619154 COS 2619154 COS 2619154 COS 2619154 COS 2619154 COS 2619409 COS 2619409 COS 2619409 COS 2619410 O COS CAJ 24647 COS TFH2480Z coszro9 05 7826 coszri5 coszis coszris coszr24 coszr24 CoszF33 COS2706526 COS 9010480 COS 9910480 COS 9910480 COS 9910480 COS 9910480 COS 9910480 COS 9910480 COS 9910480 COS 9910480 COS 9910480 COS 9910480 DELAY COS 9910490 COS 9910490 COS 9910490 COS 9910490 COS 9910490 COS 9910490 COS 9910490 COS 9910490 COS 9910490 COS 9910490 COS 9910490 COS 99939451 COS 99939450 COS 99939450 COS 99939450 COS 99939452 COS 99939452 COS 99939452 COS 99939453 COS 99939452 COS 99939453 COS 99939453 OVERLOAD PROTECTION COS 99939303 COS 99939352 COS 9993935
6. C3 M1 Li OP1 1 COND TEMP SENSOR 8 t SENSORE TEMP COND C Be 2 z BU e o EVAP TEMP SENSOR Tee 242 Sy uj E SENSORE TEMP EVAP C e E 29 o gt BE zu oo c S 98 5 p 00 EMISSIONE 00 04648 Rc 09 11 07 DATA 09 11 07 gt 230 Vac 50 60 Hz SCHEMA ELETTRICO DISEGN R GHIANI MF 26 36 46 56 E WIRING DIAGRAM Scotsman VISTO G ROMAGNOLI FG 2 REV MODIFICA SG DATA FIRMA APPR G ROMAGNOLI SOS IL 09 11 07 SOST DA FILE 05057600 DWG FRIMONT S p a 05057600 00 0 2 3 n 5 6 7 8 9 0 1 2 3 4 5 6 7 8 9 Sim NSym Sigla Ntem FunzioneNUse Type SimASym Sigla Ntem Funzione Use Type Sim NSym Sigla Ntem Funzione Use Type Fan motor m Ventilatore Compressor aS M1 Compressore Drive Motor M3 B Motoriduttore n BIN full sensor Sensore contenitore pieno LIII Ya Gear motor rotation sensor RT1 Sensore rotazione motoriduttore C PA ta Power switch SA1 L424 Interruttore generale FESTA Reset push button 5 1 Eae Pulsante di reset D Printed circuit command board SCK1 Sc
7. AB YE YELLOW GIALLO CN2 CN3 CN4 POWER WH WHITE BIANCO 653 06 ORANGE ARANCIONE PK PINK ROSA RD BU BK BK GN BK BLACK NERO BN 1 BN Pr 21 l l 2 z 5 amp a 71 2 51 TC2 nip 19 EVI RT l 2 1 YV2 Yvia YVib HX HX HX E 1 1 RX YY l L E E J l amp a a a a BU BU WATER LEVEL EVAP TEMP COND TEMP BIN FULL PUMP WATER HOT GAS WATER INLET WATER DISCHARGE FAN WATER SENSOR SENSOR SENSOR SENSOR DISCHARGE VALVE VALVE VALVE MOTOR PUMP COMPRESSOR SENSORE SENSORE SENSORE SENSORE POMPA SCARICO ELETTROVALVOLA ELETTROVALVOLA ELETTROVALVOLA VENTILATORE POMPA COMPRESSORE LIVELLO H20 TEMP EVAP TEMP COND CONT PIENO ACQUA GAS CALDO INGRESSO ACQUA SCARICO ACQUA ACQUA 00 EMESSO 00 04520 RG 08 11 07 DATA 08 11 07 gt 230 Vac 50Hz ph DSEGN R GHANI SCHEMA ELETTRICO AC EC 126 176 e 230 Vac 60Hz i VISTO G ROMAGNOLI ELECTRICAL WIRING DIAGRAM AC EC 206 226 Scotsma REV MODIFICA SG DATA FIRMA APPR G ROMAGNOLI SOST IL 08 11 07 SOST DA i FLE 05057230 DWG FRIMONT S p a 0505 2 03 00 r 4 0 2 3 5 6 7 8 9 0 1 2 3 4 5 7 8 9 SimASym SiglaWtem FunzioneNUse Type Sim NSym Sigla Ntem FunzioneNUse Type SimASym SiglaWtem
8. EPORATORSENSOR HOT GAS WATER INLET TERMNAL ANDPURGE VALVES RELAY BOARD UVP AC SERES Pa ME EIL ENS J UVP OUT NO DELAY I3 CSTEADY JUMPIN 60 DELAY WATER DRAIN PUMP RELAY FREEZING SWCHES SOC WATER LEVEL SENSOR EC SERIES ONLY OPTICAL ICE LEVEL CONTROL SENSOR HOT GAS WATER INLET TERMNAL CONDENSER SENSOR ANDPURGE VALVES RELAY BOARD i PRO EL IND B LI Scotsman Ice Systems MC 8 AS WS ICE LEVEL OPTICAL CONTROL INSTALLATION 1 Remove screw and ice chute frame 3 Cut plastic strap and release ice level control from its holding bracket 2 Take ice chute frame out from side panel opening area 4 Install the cable protection grommet 5 Fit in cable with its protection grommet in suitable hole E s available on the ice chute opening perimeter area 6 Check for proper installation not too bend or pinched 7 Install again ice chute frame m EC and secure it with former removed screws Scotsman Ice Systems Zum CC OMA SCOTSMAN EUROPE SERVICE DEPARTMENT SP 08 08 MARCH 08 AC 176 amp AC 226 AS WS NEW PC BAORD On the following serial numbers of models AC 176 amp AC 226 AC 176 From s n 02686 to 02716 AC 226 From s n 53790 to 53819 has been installed a new type of PC Board exactly the same on
9. est branch e sur une centrale frigorifique a Liquide SOUS REFROIDI Quand la machine est branch e sur une centrale frigorifique Standard ou sur une groupe de condensation a distance il est IMPERATIF de changer la buse de 1 mm du D tendeur par la buse de 2 mm fourni avec la machine La V lvula de Expansi n Termostatica o v lvula Termostatica de serie vienen equipada con un orificio de 1m m de di metro para utilizar solo y nicamente cuando la maquina es conectada a una central frigor fica con l quido subenfriado Tewis En el caso de que la maquina fuese conectada a una central est ndar o a una unidad condensadora independiente es Necesario sustituir el cartucho de 1m m por el de 2m m que viene como dotaci n en la maquina Scotsman Ice Systems SCOTSMAN EUROPE SERVICE DEPARTMENT SP 08 11 APRIL 08 AC EC 86 WS MODIFICATION IN HI PRESSURE SWITCH WIRING CONNECTION Starting from the AC 86 WS Serial Nbr 2247 the hi pressure switch used to energizing the coil of the water solenoid valve providing water to the water cooled condenser it s now electrically connected in parallel to the compressor so to energize the water inlet valve coil during both freezing and harvest cycles Attached the new Wiring Diagram with the new electrical connection in the red square Zum CC OMAN
10. contact numbers are not very easily readable we suggest you to look all the time to the small pin see on the circle of the bottom photo anytime it s needed to replace it The same are also shown on the drawings attached The Switches used on AC 6 Series manufactured from mid 2007 up to now will be kept available as spare parts under the following part nbrs Green Master Lighted Switch P N 620487 02 Re Set Switch 620487 03 Red Warning Light 620504 00 OLD VERSION NEW VERSION 0 1 2 3 4 5 6 7 8 9 P SWITCH CONNECTIONS DIAGRAM N N Sim NSym Sigla Ntem FunzioneNUse Type 0 SCHEMA COLLEGAMENTO INTERRUTTORI gt CANAL ELECTRIC pun d L 3 Interruttore generale sar 37 220 rj 4 SB1 Reset push button e BK Pulsante di reset ERES es 1 1 3 5 1 2 E SK1 PWC Control board POWER TH Scheda controllo PWC SWITCH INTER GENERALE amp 2 4 SK1 wH Q3 aK 2 RD q 1 2 RD Y Y BU 00 EMESSO BU BU NEUTRO NEUTRAL Am 7 Seotsman FRIMONT S p a 230 Vac 50 Hz 230 Vac 60 Hz 050575 00 00 FG 00 04538 RG 1 08 11 07 DATA 08 11 07 DISEGN _IR GHIAN ELECTRICAL WENG DIAGR
11. discharge system EC Series Setting of the Dip Switches for Medium Size Cube is This new PC Board is no longer equipped with the I R Trimmer as the calibration of the Optical Ice Level Control can be done directly with the PC Board as per here below procedure e Be sure that both Transmitter amp Receiver of the Ice Level Control are properly clean and scale free Switch OFF the machine at Green Master Push Button Switch Push and Hold the PC Board Push Button Switch ON the machine at Green Master Push Button Switch Wait few seconds till the PC Board Leds flash once Release the PC Board Push Button Calibration is done This operation can be done anytime is needed and MUST be done when a new PC Board or a new Optical Ice Level Control is installed replaced in the machine This new PC Board is also set up to Switch OFF the machine at Bin Full ONLY at the end of the Harvest Defrost cycle enabling the machine to discharge ONLY full size cubes and have the water system already filled up with water for new freezing cycle Attached please find the instruction for the removal of the Optical Ice Level Control in case it s needed from its inside transport location The MC 8 Service Manual will be available shortly in internet at our web site www scotsman ice it START UPDELAY TIME O C BLINKING J UVP OUT NODELAY 13 C STEADY JUMPIN GJ DELAY WATER DRAIN PUMP RELAY WATER LEVEL SENSOR ECSERIES ONLY
12. show us that in many cases at time of replacement of the Seal Mechanism Kit due to a refrigerant leak the Seal Mechanism S S and graphite rings is still in very good conditions and can be re fitted in the machine In order to reduce the repairing costs on MAR machines we made available since now a new O Rings amp Gaskets repair kit available under Part Nbr 060670 00 in alternative to the Seal Mechanism Kits P N 001028 05 consisting of the following parts 2 ORing P N 640041 10 1 Oring 640041 13 1 Oring for graphite ring No nbr 1 Oring for S S Seal Mechanism ring No nbr 1 Gasket 640076 09 1 Ring Gasket with Spring 640096 00 1 Gasket 640101 00 Scotsman Ice Systems SCOTSMAN EUROPE SERVICE DEPARTMENT SP 08 10 APRIL 08 MF 58 MF 68 ORIFICES NOZZLES TXV Starting from the following serial nbrs MF 58 S N 01559 MF 68 01542 the above models will be supplied with two different orifices nozzles for the TXV s i e one of 1 mm ID and a second one of 2 mm ID The orifice nozzle of 1 mm ID Part Nbr 620427 09 MUST be used when the MF 58 68 is connected to a R404A centralized refrigerant system that supplies refrigerant in sub cooled liquid state to the machine At contrary the 2 mm ID Part Nbr 620427 08 MUST be used when the same models are connected to a system supplying refrigerant in liquid state at normal standard temperature 35 40 We would like to alert you that the use of th
13. standard machine W OUT the Jumper on the Auto Reset contacts the machine is constantly asking for water during the freezing cycle If so to solve the problem just Jump IN the two contacts in Manual Reset mode to have the water level sensor energizing the water inlet solenoid valve just at the beginning of the freezing cycle Zum CC OMAN Scotsman Ice Systems Zum CC OMAN SCOTSMAN EUROPE SERVICE DEPARTMENT SP 08 03 FEBR 08 AC 46 AC 56 AC 86 AC 106 NEW MASTER AND ALARM RE SET SWITCHES Starting from the following serial nbrs AC46 SN 4743 AC 56 1860 AC 86 1968 AC 106 1552 the Green Master Lighted Switch as well as the Red Alarm Re Set Switch have been changed again going back to the original solution application used on the AC 6 series manufactured till mid 2007 The new Switches are available under the same part nbrs of the first ones i e Green Master Lighted Switch P N 620487 00 Red Alarm Re Set Switch 620487 01 These new Switches are a little bit different in size 19 6 mm wide at plastic clips location rather then 19 4 mm of the former one as well as in their contacts spade connectors identification numbers Attached the wiring diagram showing the electrical connections of the two Lighted Switches with the references of the electrical contacts of the old ones inside the brackets and new current ones with no brackets Anyway as in the new switches the
14. 3 COS 99939356 COS 99939364 COS 99939358 COS 99939364 COS 99939358 COS 99939358 COS 99939360 COS 99939360 27 Scotsman Ice Systems SCOTSMAN EUROPE SERVICE DEPARTMENT SP 08 13 MAY 08 AC 46 AC 56 AC 86 AC 106 WATER COOLED VERSIONS TWO SEPARATE WATER INLET SOLENOID VALVES Starting from the following serial nbrs AC 46 S N 05213 AC 56 02140 AC 86 02304 AC 106 01787 the above listed models in water cooled version are now equipped with two separate Water Inlet Solenoid Valves in order to allow the connection to two different water sources when available as detailed on here below photo WATER OUT MELTED ICE OVERFLOW Sa 3 WATER IN WATER WATER OUT COOLED WATER COOLED CONDENSER CONDENSER Zum CC OMA The Part Nbrs of the two new Water Inlet Solenoid Valves for the different models are 650105 64 650105 65 650105 66 650105 66 WATER COOLED CONDENSER 650105 74 650105 74 650105 74 650105 74 In order to facilitate the installation of the machine when only one water source is available together with the unit are supplied an additional water inlet hose Part Nbr 060513 00 and a Y fitting Part Nbr 660894 00 as shown on the photo This Y water fitting is equipped with a 3 4 female connection to be connected to the water tap and two 3 4 male fittings for the connection to the two Water Inlet Solenoid Valves Scotsman SP 08 14 JUNE 08 AC 106
15. AC 126 AC 176 AC 206 AC 226 230 50 60 1 VERSIONS ONLY NEW PC BOARD Starting from the following serial nbrs AC 106 S N 01858 AC 126 01761 AC 176 02932 AC 206 00259 AC 226 53920 the above listed models are now equipped definitively with new PC Board P N 620462 06 with the integration of the Cleaning Remind Board as detailed on the Service Bulletin SP 08 08 the information about the operation of this new PC Board as well as the Wiring Diagram are detailed on the Service Bulletin SP 08 08 Service manuals as well as spare lists in Internet will be up to dated soon Zum CC OMAN Scotsman Ice Systems SCOTSMAN EUROPE SERVI CE DEPARTMENT SP 08 15 JULY 08 AF MF SERIES NEW PC BOARD For field test we are putting in the field some MF 36 s equipped with a new type of PC Board with the following features e Push button for the calibration of the Optical Ice Level Control e 16 Amps compressor relay so to provide power directly to the compressor e Connection to the external Switches not yet used as done recently with the AC Cube Series In case of positive result of the field test the modification will be extended to all our Electronic Flakers starting from the first quarter of next year The part number of this new PC Board is 620462 08 and it s NOT exchangeable with the former one due to the different power connectors as you can see from the bottom photo mim
16. AM AC EC VISTO G ROMAGNOLI Serie 6 REV MODIFICA S DATA FIRMA APPR G ROMAGNOLI SOST IL 08 11 07 SOST DA G ROMAGNOLI FILE 05057500 DWG 0 2 3 4 5 6 1 8 Scotsman Ice Systems SCOTSMAN EUROPE SERVI CE DEPARTMENT SP 08 04 MARCH 08 TC 180 NEW WATER TRAY DRAIN FILTER Starting from last month we have changed the drain filter of the water drip tray moving from the standard one used in all storage bin to a version with a central hole for easy cleaning of the inside of the water drain waste hoses as shown on the here below photo This drain filter with central hole is available under Part Nbr 660211 03 and can be used in place of the old one Zum 0 Scotsman Ice Systems Zum CC OMA SCOTSMAN EUROPE SERVICE DEPARTMENT SP 08 05 MARCH 08 ACC COMPRESSORS NEW TERMINAL BOARD Recently we have received from our compressor supplier ACC former name Cubigel compressors equipped with a new electrical control box To help you in its electrical connections mainly when new compressor is used in place of a old version one we are sending here below a photo showing the power connectionS so to avoid any possible confusion at time of installation Ss GROUND A e y eb NEUTRAL Scotsman Ice Sustems SCOTSMAN EUROPE SERVICE DEPARTMENT SP 08 06 MARCH 08 AF MF SERIES COUP
17. FunzioneNUse Type Fan motor Hot gas valve M EX YV2 Ventilatore Elettrovalvola gas caldo Compressor Water inlet valve 1 X YVla Compressore Elettrovalvola ingresso acqua Water pump Water discharge valve M2 FX YV1b Pompa acqua Elettrovalvola scarico acqua Pump water discharge M3 Pompa scarico acqua i Bin full sensor Wl OP1 til Sensore contenitore pieno r1 414 Power switch SA1 Interruttore generale Tel Reset push button 5 1 LATA Pulsante di reset H Printed circuit main board SCK1 Circuito stampato di comando Evaporator temperature sensor TC2 Sensore temperatura evaporatore Condenser temperature sensor TC3 Sensore temperatura condensatore E Water level sensor WS1 E Sensore livello acqua 00 04520 RG 08 11 07 DATA 08 11 07 pem 230 Vac 50Hz 1 LEGENDA SIMBOLI AC EC 126 176 DSEGN R GHANI SIMBOLS LEGEND 230 Vac 60Hz 19h VISTO C ROMAGNOLI S LEI AC EC 206 226 Scotsman REM 3 REV MODIFICA SG DATA FIRMA APPR G ROMAGNOLI SOS IL 08 11 07 SOST DA Is FLE 05057230 DWG FRIMONT S p a 0505 2 03 00 Fr 4 0 2 3 4 5 7 8 9 Scotsman Ice Systems Zum CC OMAN SCOTSMAN EUROPE SERVICE DEPARTMENT SP 08 09 MARCH 08 MAR SERIES O RINGS amp GASKETS KIT Field reports
18. LING LUBRICATION We would like to remind you that it s very important to provide correct proper lubrication of the inside bore of the upper semi coupling as well as to the external surfaces of the teeth as shown on the here below photo The correct lubrication allows the upper semi coupling to move it down by the load of the upper spring in case of any rising up during its rotation Zum CC OMAN Scotsman Ice Systems Zum CC OMAN SCOTSMAN EUROPE SERVICE DEPARTMENT SP 08 07 MARCH 08 MC 8 AS WS NEW MODEL A new Modular Cuber is now available for the market It s mainly based on the same refrigerant water and electrical system of the model AC 206 but w out the storage bin About PC Board this new model is equipped with a new generation of PC Board already tested in the field on more then one hundred machines This new PC Board available under Part Nbr 620462 06 consists of the standard PC Board used till new with the integration of the Cleaning Reminder Board Moreover the compressor relay installed in this PC Board can load up to 16 amps current enabling the direct connection of the compressor to the PC Board Attached you can find the schematic diagram of this new PC Board of both our two PC Board suppliers Syen amp Pro El Ind where it s also possible to connect directly the water reservoir level sensor Red Sensor Socket of the machines equipped with water pump
19. R MODELLI AD ACQUA ELIMINATO VENTILATORE AGGIUNTIVO 02 INSERITA DOPPIA PINATURA INTTERRUTTORI MOTOR PUMP VALVE VALVE O3 AGGIUNTA TENSIONE 230 50 11 VENTILATORE POMPA ELETTROVALVOLA EL TTROVALVOLA ACQUA CONDENSATORE ACQUA INGRESSO ACQUA 01 104496 RG 22 05 07 DATA 27 02 07 Vac 50 Hz 1ph 01 04546 RG 07 09 07 DISEGN R GHIANI BECA WBA DRAM AC 86 Y Seotsman 230 Vac 60 Hz 1ph 02 04651 Rc 11 03 08 VISTO G ROMACNOLI FG 2 REV MODIFICA SG DATA FIRMA APPR G ROMAGNOLI SOS IL 11 0308 SOST DA FLE 05053923 DWG FRIMONT S p a 05053902 03 4 0 2 3 n 5 6 7 8 9 Sim NSym Sigla Ntem FunzioneNUse Type SimASym Sigla Ntem FunzioneNUse Type Sim NSym Sigla Ntem Funzione Use Type 22 Fan motor aem Water level sensor Evi WS1 Ventilatore Sensore livello acqua Compressor Water condenser valve M1 HX YV1 Compressore Elettrovalvola acqua condensatore Water pump Water inlet valve M2 x YV2 Pompa acqua Elettrovalvola ingresso acqua Water discharge pump Hot gas valve e M3 FX YV3 Pompa scarico acqua Elettrovalvola gas caldo rT T Power switch l I SA1 L 3 Interruttore generale 1 Reset push button SB1 LAA Pulsante di reset Lt E PWC Control board SK1 HTH Scheda controllo PWC Water pr
20. e 2 mm ID orifice nozzle in conjunction with refrigerant in sub cooled liquid state supplied to the machine can produce a very hard ice with the increasing of the mechanical load to drive the auger with the consequence of shorting a lot the life of the mechanical parts To avoid this type of problem all MF 58 68 will be supplied with the 1 mm ID orifice nozzle installed inside the TXV with the 2 mm orifice nozzle and the attached Warning Sheet packed together into a plastic bag Zum CC OMAN La Valvola d Espansione Termostatica o le Valvole Termostatiche di serie sono equipaggiate con un orifizio da 1 mm di diametro da utilizzare SOLO ed UNICAMENTE quando la macchine collegata una centrale frigorifera liquido SOTTORAFFREDDATO Qualora la macchine venisse collegata ad una centrale Standard oppure ad un gruppo condensante dedicato IMPERATIVO sostituire l ugello da 1 mm della Valvola d Espansione Termostatica con quello fornito in dotazione da 2 mm The TXV s is are equipped with an orifice nozzle of 1 mm diameter to be used ONLY when the machine is connected to a rack cooling system providing refrigerant in SUB COOLED Liquid state In case of its connection to a Standard rack system or to a dedicated Condensing Unit the original 1 mm orifice nozzle of the TXV MUST be replaced with the 2 mm ones supplied in the machine Le D tendeur est equipp d une buse de 1 mm a utiliser SEULEMENT lorsque la machine
21. e of the model MC 8 see Service Bulletin SP 08 07 As detailed in the Service Bulletin SP 08 07 this new PC Board available under part nbr 620462 06 has integrated in its hardware the Cleaning Reminder Board as well as a 16 amps relay so to enable the direct connection of the compressor to the PC Board The setting of the Dip Switches are exactly the same of the former PC Board used in the same models As detailed in the Service Bulletin SP 08 07 the calibration of the Optical Ice Level Control must be done as per follow procedure e Be sure that both Transmitter amp Receiver of the Ice Level Control are properly clean and scale free Switch OFF the machine at Green Master Push Button Switch Push and Hold the PC Board Push Button Switch ON the machine at Green Master Push Button Switch Wait few seconds till the PC Board Leds flash once Release the PC Board Push Button Calibration is done and the machine trips OFF at Bin Full only at the end of the Harvest Defrost cycle Due to the different electrical connections this new PC Board is NOT exchangeable with the former one used on the same models Attached you can find the schematic diagram of the PC Board as well as the wiring diagram of the machine START UPDELAY TIME O C BLINKING J UVP OUT NODELAY 13 C STEADY JUMPIN GJ DELAY WATER DRAIN PUMP RELAY WATER LEVEL SENSOR ECSERIES ONLY EPORATORSENSOR HOT GAS WATER INLET TERMNAL
22. essure control SP1 Pressostato acqua Bin thermostat ST2 Termostato magazzino 3 STi Evaporator thermostat h Termostato evaporatore C1 Condenser temperature sensor Sensore temperatura condensatore 01 04496 RG 22 05 07 DATA _ 27 02 07 pom 230 Vac 50 Hz Iph 01 04546 RG 07 09 07 DISEGN R GHIANI ds 86 GaoXtsmnmer 230 Vac 60 Hz 1ph 02 04651 RG 11 03 08 visto G ROMAGNOLI 3 REV MODIFICA SG DATA FIRMA APPR G ROMAGNOLI SOST IL 11 0308 SOST DA G ROMAGNOLI FLE 05053923 DWG FRIMONT S p a 05053902 03 4 0 2 3 n B 6 7 8 9 Scotsman Ice Systems SCOTSMAN EUROPE SERVICE DEPARTMENT SP 08 12 APRIL 08 MAR MF SPLIT SERIES SCOTSMAN COS CONDENSING UNITS SPARE PARTS LIST Attached please find the up to dated chart showing the Part Numbers of the major components used on the following Scotsman COS condensing units SCOTSMAN MODE COS MODEL NBR UCM UC071 UcM UC101 UC 121 UC 12 UC 201 UC 202 UCMFOEG UC 301 SLIB66C8 51 1366 10 SL 1406C25 SM1456C70 SL 1456C45 SM2456C130 SL 2406 5 SM2456C150 SL2406C65 SL2456C55 UL VISHCDS CONDENSING UNT COMPONENT os EI os ene S EET
23. heda elettronica di comando l E Water level control WS1 Controllo livello acqua E Condenser temperature sensor TC1 Sensore temperatura condensatore Evaporator temperature sensor TC2 Sensore temperatura evaporatore F 00 EMISSIONE 00 104648 RG 09 11 07 DATA 09 11 07 LEGENDA SIMBOLI 230 Voc 50 60 Hz DISEGN R GHIANI MONY MF 26 36 46 56 4 SIMBOL S LEGEND Seorsman VISTO G ROMAGNOLI FG 5 REV MODIFICA SG DATA FIRMA APPR G ROMAGNOLI SOST IL 09 11 07 5057 DA G ROMAGNOLI FLE _05057600 DWG FRIMONT S p a 050576 00 00 0 2 3 4 5 6 7 8 9 Scotsman SCOTSMAN EUROPE SERVICE DEPARTMENT SP 08 16 NOV 08 B 193 B 393 REINFORCED BIN DOOR Starting from the following Serial Nbrs B 193 S N 5900 B 393 8925 the plastic bin doors used on the above storage bins have been modified with a metal plate inside as shown on the attached drawing With this modification on new bin doors the two plastic hinges are now secured to a stronger inside bracket that can support much higher loads mainly when the hinge pin is partially seized Zum 0
Download Pdf Manuals
Related Search