Chameleon Paradize Service Manual
Contents
1. D FUSE 9 aa 05 5 F D 9024 912 1 pe FUSE 9 4 1 12 25 3 1 4 D RFD32024 Owners Manual Chameleon Paradize Page 32 To Purchase This Item Visit BMI Gaming www bmigaming com 800 746 2255 1 561 391 7200 Power Section l2VDC tV 12 Vdc 5 Cl l2z00uF B4 Hi g t0 3 21 g ta 3 22 190 443 g a J47 4 J4 10 a 44 14 5 1 lt 45 21 a 10 5 e a J107 g a 111 3 a Owners Manual Chameleon Paradize J6 3 J 3 J8 3 J9 3 J10 1 J10 2 J11 1 p ig J34 32 0 3a 4323 J324 p 6 44 17 y 4 18 452 3a 5 11 45 12 tq 5 22 Page 33 To Purchase This Item Visit BMI Gaming www bmigaming com 800 746 2255 1 561 391 7200 Processor Section Input RD J4 1 J4 5 14 9 44 13 14 11 04 8 J4 4 cal c26 OluF OluF p gt 4 F __ Y ptam c29 c28 luF OluF p 4 E 9 4 F 4a pps 27 OluF pp 4 p a pps C25 OluF 2 4 Owners Manual 17 756 DATA BUS PUTA LE DUTC LE RN13 470 c9 1 J d luFa luF T luFar T A Chameleon Paradize Page 34 To P2. That cable or related component Turn power OFF Green LED Light is shorted out See Jumper Cable Reconnect the outputs remains OFF Pin Outs to see which at the Main Circuit component might be at fault Board one at a time Wait 3 minutes Green LED Light 86 oum dims A related component such as a solenoid is causing an overload See Jumper Cable Pin Outs Green LED Light That cable is OK beginning on page 18 to see comes ON which component might be at fault Owners Manual Chameleon Paradize Page 21 To Purchase This Item Visit BMI Gaming www bmigaming com 800 746 2255 1 561 391 7200 Service and Repair CAUTION Electric Shock Hazard Do not perform repairs or maintenance on this game with the power ON Unplug the unit from the wall outlet or shut off power at the power strip inside the game CAUTION Static electricity could harm circuit boards and processor chips Always ground yourself by cable or by touching a metal surface prior to working on the game Main Circuit Board Replacing the main Gen 5 board 1 With the power off carefully unplug the various connectors black chase light cables and white or grey display cables 2 Remove the four screws holding the board to the game 3 Before installing the new board check to be sure the new dipswitches are set Note If swapping the board with a spare remember to also swap the programming chips Use extreme care to prevent static b
3. Factory Settings Bank 2 Dip Dip2 Dips Dips AHH HHHH J Bank 1 Bank 2 Owners Manual Chameleon Paradize Page 10 To Purchase This Item Visit BMI Gaming www bmigaming com 800 746 2255 1 561 391 7200 Ticket Payout Select Standard Patterns and Fixed Patterns Chart Bank 1 1 Ticket Payout Select Allows you to choose between a Standard ticket payout or a Fixed ticket payout A standard payout pays ticket per bug A fixed ticket payout pays a fixed amount of tickets regardless of the score Standard OFF The factory default is Standard Ticket Payout Chart Bank 1 2 Ticket Payout Select Allows you to choose between a Standard ticket payout or a Ticket Bucket payout A standard payout pays tickets per bug A ticket bucket payout pays tickets based on point groups Ticket Buckets Standard OFF The factory default is Standard Ticket Payout Bank 1 Standard Ticket Payout Patterns Chart 3 1 Ticket per One Point OF F OFF 1 Ticket for every two On Off Doin 2 tickets for every one Off On 2 tickets for every two On On gain Bank 1 Fixed Tickets If you choose to use the Standard Ticket Payout you can now choose a pattern the game will payout One point is gained for every one bug knocked over The mercy ticket feature is active and cannot be disabled If you choose pattern
4. 2 or 4 please see the bonus table on the next page The factory default is Pattern 1 Chart 4 Fixed Ticket Payout Patterns If you choose to go with the Fixed Ticket Pattern you may now choose a payout pattern The selected 3 Tickets pattern will pay the player the same amount of tickets 4 Tickets regardless of the score You will need to contact Bay Tek Parts for a new 5 Ticket ticket decal on the pelican stand 8 Off Off Off 5 Off Owners Manual Chameleon Paradize Page 11 Off Off O ff On ff On ff On ff On O 5 O 2 2 2 2 UH 2 To Purchase This Item Visit BMI Gaming www bmigaming com 800 746 2255 1 561 391 7200 Ticket Bucket Option Coin Token per Play Free play Multi Credits and Game Timer Bank 1 5 Bucket Option Dip2 0 2 Points 1 Tickets Off Off Chart 2 Coins Tokens per Play 1 Coin oro Play Option Dip 6 On Ticket Bucket Payout If you choose to use the Ticket Bucket Payout option you will need to replace to ticket decal on the pelican stand with the bucket decal in the cashbox Call Bay Tek Parts for the ticket value sheet to place under the bucket decal 3 5 Points 4 Tickets 6 9 Points 6 Tickets 10 13 Points 8 Tickets 14 17 Points 9 Ticket
5. R Side Ticket Dispenser WHT RED Ground L Side Coin Door Switch BLK WHT Input R Side Coin Door Ground RED BLK WHT RED L Side Counter 12v R Side Coin Switch Input RED GRN L Side Coin Door 12v BLK L Side Ticket Dispenser BLU Ground L Side Ticket Notch BLK WHT Signal L Side Coin Door Ground WHT RED L Side Ticket Dispenser L Side Ticket Dispenser Enable 12v Owners Manual Chameleon Paradize Page 24 To Purchase This Item Visit BMI Gaming www bmigaming com 800 746 2255 1 561 391 7200 J5 Connector GRN L Side Cham Spine BLK View Direction Lights R Side Bug Wheel Motor R Side Cham Motor and 12v Sensor Grounds TAN L Cham 3 Spine Light RED RED R Side Bug Wheel Motor L Side Button Light Enable Enable BLU RED R Side Cham 1 Spine L Side Bug Wheel Motor Light Enable Enable YEL L Side Spine Light 42 and 5 Enable TAN R Cham 3 Spine Light Enable RED R Side Button Light Enable BLK ORG L Side Bug Wheel Motor L Side Cham Eye Lights 12v 12v BLU GRY R Side Cham Spine L Side Cham Eye Lights Light 1 Enable Enable YEL GRY R Side Cham Spine R Side Cham Eye Lights Light 2 and 5 Enable Enable DIO BRW Stripped R Side Tongue Motor Enable DIODE R Side Tongue Motor Braking DIO BRW Stripped L Side Tongue Motor Enable DIODE L Side Tongue Motor Braking PUR R Side Cham Spine Light Ground L Side Cham Motor and Sensor Ground ORG 12v Tongue Motor Sens
6. as needed AABD1204 f Replace main board with a spare Gen 5 board if possible to isolate the problem to the main circuit board Refer to Tongue not Operating Correctly section a Calibration sensor problem b Motor problem Refer to Tongue not Operating Correctly section a Motor problem b Calibration sensor problem a Clean or replace silver tape on back of bug wheel b Check wiring from main board to sensor c Replace sensor AABD5010 d If 12 Volts DC is at motor replace motor A5MO1201 e Check diode board replace as needed AABD1204 f Replace main board with a spare Gen 5 board if possible to isolate the problem to the main circuit board Page 19 To Purchase This Item Visit BMI Gaming www bmigaming com 800 746 2255 1 561 391 7200 Bug Wheel Replacement If you have a bug wheel you think needs replacement you can first swap the wheel with a working wheel from another game This will help isolate the problem Tools Needed Drill w 2 Sq bit 1 Turn the game off 2 Remove the backdoors 3 Carefully unplug the connections 4 Unscrew the assembly have another person standing by to hold the assembly when the last Screw is removed 5 Slide the assembly down and then up thru the inside of the game 6 Replace with a working wheel from the same game or different game 7 If the new wheel still doesn t work you will need to call Bay Tek G
7. the ticket dispensers This is a Bay Tek OFF function and we do not recommend it for your use Dispensers The factory default is Dispensers ON Bank 1 Bonus Tickets Chart 11 No Bonus If you choose the standard pattern 2 or 4 you may also use a Tickets 25 point bonus The game will award 25 total tickets for the pattern 2 and 50 total ticket for pattern 4 regardless of the score Chart Bank 1 12 Farto Concerto You may disable the end of game gassy sound effects but why Kids seem to find it funny Bonus Tickets Gassy Sounds The factory default is Gassy Sounds Enabled Enabled OFF Bank 1 Attract Mode The game is equipped with an Attract Mode If the game isn t being played the game will play selected tracks form the audio file every 5 minutes Chart 13 No Attract Mode Mode The factory default is Attract Mode Enabled Enabled Chart 2 14 Wheel Speed Options With this feature the game will ramp up the bug wheel speed if the player scores 4 or more points in the first 8 seconds of the game The ramp up will last 15 seconds then the wheel will On No Ramp Up return to the default speed for the remainder of the game Ramp Up The factory default is Ramp Up Based on Score Enabled OFF Score 2 Chart 15 Filter Board This switch
8. to working game on Bank 2 Push button CC is not displayed 3 Replace switch 7300 4 Check wiring from main board to switch 5 Replace main board 12v DC at the motor 1 Replace motor ASMO1201 Check for 12v DC at 1 Check wiring from the main the motor No 12v DC at the motor paara meter 2 Faulty main board 1 Dip switch setting on the 1 Turn dip 4 on bank 2 OFF main board 2 Replace as needed AABD1204 Bug wheel spinning too fast 2 Diode board faulty 3 Replace motor as needed 3 Motor faulty A5MO1201 Owners Manual Chameleon Paradize Page 16 To Purchase This Item Visit BMI Gaming www bmigaming com 800 746 2255 1 561 391 7200 PROBLEM PROBABLE CAUSE REMEDY Bugs not scoring Ticket do not dispense Owners Manual 1 Black toggle the bugs fall on is sticking 2 Silver tape is not reflection 3 Faulty sensor 4 Wiring damage or disconnected 1 Ticket tray is empty due to faulty low ticket sensor or broken loose wires Sensor switch stuck or bent out of position 2 Faulty cable to the dispenser 3 Dirty opto sensor or paper dust built up 4 Ticket notch is too shallow 5 Faulty ticket dispenser 6 Main board malfunction Chameleon Paradize 1 Ensue the toggle moves freely 2 Clean or replace silver tape on the toggle 3 Replace sensor AABD5010 4 Check wiring from main board to sensor 1 Fill ticket tray Replace low ticket senso
9. 24 16 Page 30 To Purchase This Item Visit BMI Gaming www bmigaming com 800 746 2255 1 561 391 7200 Output Section B 017 024 a Owners Manual Output Section B Q17 Q24 417 Spec Cl4 8 2 FUSE 1 35 luF 0 E 4 149917 45 20 E IRLDOZ4 a 018 068 F18 FUSE 1 354 4 D ai Q18 J5 18 5 Dj E IRLDOZ4 019 m F19 10k 11 2 FUSE 1 358 1 15 16 13 os IRLDOZ4 T 183 Nu 020 328 FEL b m d x q020 J5 14 IRLDOZ4 021 F21 2 2 FOE qs 13021 05 10 E n DUTB SEL IRLDOZ4 022 22 2 FUSE 1 354 i J5 8 q022 E DF IRLDOZ4 923 F23 2 FUSE 1 354 i 2 21023 15 6 3 IRLDOZ4 024 F24 FUSE 1 354 1 2 00 17024 J5 4 I r3 P D IRLDOZ4 Chameleon Paradize Page 31 To Purchase This Item Visit BMI Gaming www bmigaming com 800 746 2255 1 561 391 7200 Output Section C Q5 Q12 12 05 FS 3 DE FUSE 9 5 1 al Ly 2 05 25 19 sype IDE P E 3 E FUSE 3A i 2 1406 45 17 BUSY 2 RFD3024 3 4 5 07 F 2 D FUSE 9A i 4 aw 45 15 3 mni 9024 08 r8 DF FUSE 9 A a i 44908 05 13 4 LRFD9024 09 FUSE 9 i 2 1109 45 9 Flog FUSE 9 i 2 11010 J5 7 011
10. 8 J3 16 J3 14 J3 5 J3 7 J3 9 J3 11 J3 12 J3 10 J3 8 J3 6 Owners Manual Chameleon Paradize Page 29 To Purchase This Item Visit BMI Gaming www bmigaming com 800 746 2255 1 561 391 7200 Output Section Chase lights Q13 Q16 01 Output Section FUSE T 3 Chase Lights gt Q13 16 6 PAGE 02 RD6 F2 ah pE FUSE 1 ak IRLDO24 EM DE FUSE 1 10k 5ypc 5 b IRLD024 E pe FUSE 1 Ak ME IRLD024 013 L F13 L ag DE FUSE 1 pL X GUT SEL 014 E FUSE 1 Ak IRLD024 015 F15 DE FUSE 1 4 p IRLD024 016 FUSE 1 35a T D a IRLD024 a Owners Manual Chameleon Paradize 35A 4 10 CHASEA 5 10 CHASEA CHASEA L L4 35A yla CHASEB CHASEB 35A Lyla CHASEC o cHASEC L L q 35A A c CHASED 5 12 CHASED y o CHASED LL CHASED 35A J6 1 27 1 98 1 79 1 76 2 771 2 78 2 79 2 26 3 27 3 28 3 29 3 26 4 27 4 28 4 29 4 19913 24 19 5 2 014 44 20 24 15 Aqqdi6
11. Dispenser Control Bonus Tickets Farto Concerto Attract Mode Wheel Speed Control Filter BOS reete bases E er x Cv aas 10 Preventive 11 Trouble Shooting 12 Error Codes ee v VE ets 15 Bug Wheel 17 Trouble Shooting the Power Supply 18 Service and 19 Owners Manual Chameleon Paradize Electrical Drawing Section 20 J3 0 4 2 20 2 2 21 J5 CONnNGClOls hae ee 22 Ji D edere 23 Gonneclorz uide 23 Gen 5 Main Board Schematics 24 Communications Serial EEprom 25 Input Section A Con Switches 25 Input Section B Inputs RE 26 Output Section Chase Lights Q13 Q16 27 Output Section B Q17 Q24 28 Output Section C 5 012 2 29 Power Seclioni i eii ee et nde ei 30 Processor Section Input RD 31 Technical 32 Warranty Information 33 Repair 34 Parts L
12. To Purchase This Item Visit BMI Gaming www bmigaming com 800 746 2255 1 561 391 7200 NEW AND IMPROVED TROUBLESHOOTING GUIDESII Service Manual Bay Tek Games Inc Service 920 822 3951 EXT 1102 1077 East Glenbrook Dr Parts 920 822 3951 EXT 1101 Pulaski WI 54162 Fax 920 822 8936 On the web baytekgames com Service Fax 920 822 1496 E Mail service baytekgames com Owners Manual Chameleon Paradize Page 1 To Purchase This Item Visit BMI Gaming www bmigaming com 800 746 2255 1 561 391 7200 Table Of Contents New Game 1 Future 2 Chameleon Paradize 3 Operation and Set Up 4 Safety 2 1 2 2 2 4 Service 2 2 2 4 Unpacking Assembly and Installations coe sees eit eee lee es 4 Ticket TAS sc ite eror rere ERRORES RE Re 5 Clear 222 4 6 Programming 7 Ticket Payout Select Standard Ticket Payout Patterns Fixed Ticket Payout 8 Ticket Bucket Payout Patterns Coin Token per Play Free Play Mode Multi Credit Mode Game Tilmer isi ie cedex bte t t Ebr b 9 Ticket
13. altered defaced or removed from its original position Should your game need servicing determine the serial number from the decal on the back of the cabinet or the logic unit and call 920 822 3951 or email to SERVICE BAYTEKGAMES COM Owners Manual Chameleon Paradize Repair of NON Warranty Units Should your game need servicing determine the serial number from the decal on the back of the cabinet or the logic unit and call 920 822 3951 or email to SERVICE BAYTEKGAMES COM An estimate of the repair charges will be quoted to you for approval You can proceed in one of two ways 1 Request the immediate shipment of advanced replacement part s You will receive the part s with an RMA for the return of the faulty part s You must return the faulty parts in 14 days to avoid additional charges 2 Send in the defective part s for repair or replacement Please include the following information Name Address Phone Number Serial Number Purchase Order Number or Signed Authorization to perform service Repair and returned parts will be shipped back using the same mode of transportation in which they were received Repairs are warranted 30 days from the date installed into service Page 36 To Purchase This Item Visit BMI Gaming www bmigaming com 800 746 2255 1 561 391 7200 Repair Record Make copies of this page for the future Game Serial Number Date Maintenance Performed Parts Replaced No
14. ames parts and service at 920 822 3951 Ex 1102 for further instructions Owners Manual Chameleon Paradize Bug Wheel Installation Tools Needed Drill w 2 Sq bit 1 From inside the game slide the new wheel in 13 2 Before tightening the screws check the tongue height on the bug eyes You want the tongue to hit just above the eye 3 Plug in the three connections 4 Now because the motors aren t always set the same you may need to reset the games memory on the wheel speed To do so turn the game off Turn the game back on have someone hold down both yellow buttons for 5 seconds during the start up process then release Page 20 To Purchase This Item Visit BMI Gaming www bmigaming com 800 746 2255 1 561 391 7200 Troubleshooting the Power Supply Use the following procedure to check the power supply for the Gen 5 board Check the small Green light on the power supply circuit board If the light is out there is a short somewhere If the light dims there is a overload in one of the circuits such as a bad motor Turn power OFF Disconnect all 12 volt output wires only Turn power ON Green LED Light Green LED Light comes ON remains OFF Replace Power Supply Turn power OFF Unplug all outputs from the Gen 5 Circuit Board Reconnect the 12 volt output wires to the Power Supply Turn power ON Green LED Light Green LED Light Short in Main Board comes ON remains OFF Replace
15. e cost of the board and charged only the bench fee for our processing and retesting that board If you choose the Repair and Return option we ll test your board before we begin If no problems are found you will only be charged the bench fee Note Bench fees apply regardless of whether the repair was your choice or a recommendation from a Bay Tek technician It s a small price to pay for trouble shooting the issues with your a AREE M You can count on our Technical Team for service and support BAY ATEK Chameleon Paradize Page 35 To Purchase This Item Visit BMI Gaming www bmigaming com 800 746 2255 1 561 391 7200 Warranty Information Bay Tek Games Inc warrants to the original purchaser that the game will be free of defects in workmanship and materials for a period of 6 months from the date of installation Bay Tek Games Inc will without charge repair or replace at it s option defective product or component parts upon notification to the factory service department Warranty replacement part s will be shipped immediately via ground service along with a Return Material Authorized RMA number for the return of defective part s Defective parts must be shipped back to Bay Tek Games unless otherwise instructed This warranty does not apply in the event of any misuse or abuse of the product or as the result of any unauthorized repairs or alterations The warranty does not apply if the serial number decal is
16. ference we ship the game using factory defaults 7 Replace the backdoors and move the game into position 8 Plug the game in Turn ON the power strip The software will adjust both bug wheels to the proper speed Once the adjustment is made the game be played Ticket Tray Controls Counters Counters are located on the left player station ticket tray The game counter counts each game played on both sides The ticket counter counts each ticket dispensed on both sides The counters can not be reset Volume Control The volume control knob is also located on the left player station ticket tray Chameleon Paradize features a stereo speaker system This along with the voice chip enhances the visual effect of the game play Ticket Clear Button The ticket clear buttons are located on both ticket trays If the game runs out of tickets before the player is rewarded the game will remember the tickets owed and pay out when the tickets are replaced By pressing the clear button before hand no tickets will be paid out Clear Credits You may need to clear accumulated credits from your game To do so you will need 2 people 1 Power the game OFF 2 Move dips 6 7 and 8 on bank 2 to the ON position 3 Power the game ON 4 Hold down the two yellow push buttons The tongues will move Hold the button until the tongues stop moving 5 Move dips 6 7 and 8 to the OFF position Owners Manual Chameleon Paradize 6 Po
17. function that of a working same type game to isolate the problem Halogen lights not functioning ere 1 Replace lamp with 12v 20 watt properly RAS MR16 halogen bulbs 51 9050 2 Wiring damage or disconnected from the power 2 Check for 12v to the fixtures supply 5 Lamp Damage or had 3 Repair or replace faulty sockets solder connections 4 Refer to the power supply ae eed power supply troubleshooting guide Owners Manual Chameleon Paradize Page 15 To Purchase This Item Visit BMI Gaming www bmigaming com 800 746 2255 1 561 391 7200 PROBLEM PROBABLE CAUSE REMEDY 1 Loosen the screw on the tongue slide It is locate on the opposite side of the clean window below the assembly set screw linkage 5 Tighten sel sen 1 Inspect and clean both pieces of the silver tape One in on the forked end and the other is on the body 1 Assembly binding Mechanical Problem 1 Calibration sensor not reading silver tape strip Calibre on sensor problem 2 Check the wiring continuity from the chameleon to the main board 3 Fault nsor 3 Replace sensor if needed MOON AABD5010 1 Button is good 2 Faulty wiring 2 Check wiring from the motor to CC is displayed the main board 3 Replace main board Put the game s into test 1 Button is bad Player push mode button Turn ON dips 2 Ensure switch is wired correctly problem 6 7 and 8 Compare
18. ice baytekgames com to order replacement parts CAUTION Lifting Hazard Lifting heavy objects can cause 77 back neck and other injuries Be sure adequate lifting and moving devices are available when unloading unpacking and moving this game Service Connections All Bay Tek games are 110V or 220V optional and draw 2 3 amps at start up Outlets should be rated for 20 amps or higher Important Be sure that the electrical power outlets match the games requirements See the serial number decal on the back of the game Owners Manual Chameleon Paradize Unpacking Assembly and Installation Tools Needed 1 4 Socket Drill w 2 sq bit 1 Remove the keys taped in the coin return slots Remove the hardware pack from the cash box 2 Attach the chase light assembly to the back of the marquee board using the silver screws and tube clamps 3 Using two people hoist the marquee to the top of the game and attach using the black bolts washers and nuts 4 Run the chase light cord thru the open clamps and into the first hole Plug into the jumper board located on the inside of the cabinet Page 8 To Purchase This Item Visit BMI Gaming www bmigaming com 800 746 2255 1 561 391 7200 Operation and Set Up Cont 5 Uncoil the black power cord located in the back lower part of the game and feed it thru the hole on the floor of the game 6 Check that the dip controls are set to your pre
19. ide surfaces with warm soapy water only Do Not use solvents on decals or Acrylic surfaces Owners Manual Chameleon Paradize Page 14 To Purchase This Item Visit BMI Gaming www bmigaming com 800 746 2255 1 561 391 7200 Trouble Shooting Guide Caution When troubleshooting moving parts make sure the game is unplugged PROBLEM PROBABLE CAUSE REMEDY No power to the game 1 Unplugged 1 Check wall outlet 2 Check transformer fuse 220 v 2 Blown Fuse only 7 amp fast burn 3 Reset power strip breaker or Circuit breaker tipped building circuit breaker 4 See power supply diagnostic pawar supply Replace if faulty A5PS1001 5 Halogen lights shorting out Replace bulbs with 20watt MR16 power supply bulbs A5LA9050 N di 1 Increase volume at the control eels 1 Volume too low on the inside of the left ramp door 2 Check audio cable connections 2 Loose wire at the control or to the speakers volume control speaker knob and main board Check continuity 3 Bad connection between head 3 Check connection between the piece and ramp piece pieces 4 Defective potentiometer 4 Replacement A5PO2000 5 Replace the main board with a 5 Main circuit board malfunction known same type main board to isolate the problem 1 Check and repair cable from the Attract lighting not working properly 1 Cable problem matguee ta the mali board 2 Replace the main board with 2 Main board mal
20. ist is EE 36 Page 3 To Purchase This Item Visit BMI Gaming www bmigaming com 800 746 2255 1 561 391 7200 About Chameleon Paradize Chameleon Paradize is a two player game with an exciting island theme Players attempt to eat as many tasty bugs as they can in a set time limit Using the chameleons tongue the players knock over bug targets to score tickets Chameleon Paradize s bright graphics and cool island music will attract kids of all ages Chameleon Paradize is great by itself or connect two games together to create an exciting center piece for your game room Owners Manual Chameleon Paradize Page 7 To Purchase This Item Visit BMI Gaming www bmigaming com 800 746 2255 1 561 391 7200 Operation and Set Up Safety Precautions CAUTION Electric Shock Hazard Do not perform repairs or maintenance on this game with the power ON Unplug the unit from the wall outlet or shut off power at the power strip inside the game CAUTION Electric Shock Hazard Always plug game into grounded circuit CAUTION Use of flammable substances can cause severe burns or personal injury Always use non flammable solvents for cleaning parts and surfaces Do not use substances such as gasoline kerosene or thinners Unpacking Assembly and Installation Inspect the game for any damaged loose or missing parts If damage is found please contact the carrier first Then contact Bay Tek Games at 920 822 3951 or serv
21. n ning as quickly as possible When you get your new board just repackage the defective board in the same box and send it back to us We make it easy by including a UPS Return Shipping label for you to put on the box Spare Parts Take matters into your own hands and purchase new spare Circuit Boards for your Bay Tek games Many of our games share the same main board electronics This means you can buy one set of spare electronics to support many of your Bay Tek games Spare boards allow you to get your game up and running the quickest and provide you a valuable troubleshooting option Call our technicians to get recommendations for what you should keep on hand for scare pars AA Technical Support You are the best tool for troubleshooting Your abilities to understand the game and your skills to repair the game are invaluable to us If you need help give us a call It s not easy to diagnose a game remotely by phone but our tech nicians do a great job They ll need your help to perform some troubleshooting steps and convey to them exactly what s happening with your game Be sure to have your game Serial Number when you call in Returns amp Credits Sometimes the issue isn t what it seemed to be If you chose the Advance Re placement option and now need to return that circuit board just give us a call to Set Return Authorization You will be credited for th
22. ors 12v R Side Cham Eyes Owners Manual Chameleon Paradize Page 25 To Purchase This Item Visit BMI Gaming www bmigaming com 800 746 2255 1 561 391 7200 J1 Connector RED 12v Input BLACK 12v Ground RED 12v Input J2 Connector BLACK 12v Ground WHITE GREEN Left Right Channel Channel RED BLACK Left Right Channel Channel Owners Manual Chameleon Paradize Page 26 To Purchase This Item Visit BMI Gaming www bmigaming com 800 746 2255 1 561 391 7200 Gen 5 Main Board Schematics Audio Section SOI IK rid HHHH 2 002 P 42 1 1g RIGHT 1716 1545 42 2 1 RIGHT J2 3 1g LEFT J2 4 LEFT Owners Manual Chameleon Paradize Page 27 To Purchase This Item Visit BMI Gaming www bmigaming com 800 746 2255 1 561 391 7200 Communications Serial EEprom J11 2 J11 4 J10 4 J10 6 J10 8 J10 2 Input Section A Con Switches 2 2 4 5 6 Y 8 rij 2 2 4 5 6 7 Owners Manual Chameleon Paradize Page 28 To Purchase This Item Visit BMI Gaming www bmigaming com 800 746 2255 1 561 391 7200 Input Section B Inputs RE RC J3 13 J3 15 J3 17 J3 19 J3 20 J3 1
23. p diagnostics At power up 1 Tongue motor cycles finds game for up to 10 minutes home Error 88 will clear 2 Bug wheel spins calibrates A new error may be speed displayed Leave game for up to 10 minutes to see if 88 clears a Load tickets Make sure ticket stack rests on top of wire actuator a Ticket tray empty of switch b Replace switch AASW200 b Faulty low ticket switch c Broken loose wires c Check cable connections from switch to main circuit board Owners Manual Chameleon Paradize Page 18 To Purchase This Item Visit BMI Gaming www bmigaming com 800 746 2255 1 561 391 7200 PROBLEM PROBABLE CAUSE REMEDY Owners Manual Player 1 tongue sensor not being seen Player 1 tongue sensor is constantly being seen Player 1 bug wheel speed sensor not being seen Player 2 tongue sensor not being seen Player 2 tongue sensor is constantly being seen Player 2 bug wheel speed sensor not being seen Chameleon Paradize Refer to Tongue not Operating Correctly section a Calibration sensor problem b Motor problem Refer to Tongue not Operating Correctly section a Motor problem b Calibration sensor problem a Clean or replace silver tape on back of bug wheel b Check wiring from main board to sensor c Replace sensor AABD5010 d If 12 Volts DC is at motor replace motor A5MO1201 e Check diode board replace
24. r switch Repair wiring Clean ticket tray of dirt and loose tickets or debris Bend switch wire to correct position under tickets 2 Check wiring continuity from dispenser to main board Check for pinched broken or disconnected wires Replace as necessary 3 Clean with compressed air and if necessary wipe sensor with isopropyl alcohol on a cotton swab 4 Flip tickets and load upside down to have large cut notch toward opto sensor 5 Replace dispenser with spare working dispenser 6 Replace main board with a spare Gen 5 board if possible to isolate the problem to the main circuit board Page 17 To Purchase This Item Visit BMI Gaming www bmigaming com 800 746 2255 1 561 391 7200 PROBLEM PROBABLE CAUSE REMEDY 1 Check and reset dipswitches for proper setting 1 Ticket Pattern dipswitches set wrong 2 Clean with compressed air or wipe with isopropyl alcohol on a 2 Dirty opto sensor on ticket cotton swab dispenser 3 Push reset tickets owed button 3 Many tickets in memory If up button on bracket to reset Wrong number of tickets dispenser X ticket meter is counting the tickets tickets out coming out then reset tickets owed 4 Replace with spare working dispenser 4 Faulty ticket dispenser 5 Replace main board with a 5 Main circuit board malfunction spare Gen 5 board if possible to isolate the problem to the main circuit board Error Codes Part of start u
25. s 18 20 Points 10 Tickets 21 24 Points 12 Tickets The mercy ticket is active and cannot be disabled Over 25 25 Tickets This will allow you to set the number of Coins Tokens per Play the game needs to be played The factory default is 1 Coin Token 2 Free Play Mode Chart 7 Allows you to set the game to Free Play Mode In this mode the game needs no credits to be played This is a Bay Tek function and is not recommended for your use Normal i The factory default is Normal Game Play Game Play 6 Free Play 2 Chart 8 Play Option Dip5 Normal OFF The factory default is Normal Game Play Game Play Multi Credits The game can be set to only grant one game despite the number of credits inserted This is a Bay Tek function and is not recommended for your use Chart 9 Game Timer This will allow you to set the Game Timer The time starts after the yellow push button is pushed the first time after a coin token is inserted The factory default is 32 seconds Owners Manual Chameleon Paradize Page 12 To Purchase This Item Visit BMI Gaming www bmigaming com 800 746 2255 1 561 391 7200 Ticket Dispensers Bonus Special Effects Attract Mode Wheel Speed and Filter Board Chart Bank 1 10 Ticket Dispensers Dispensers Allows you to turn off
26. shouldn t be used unless you are directed to do so by the Bay Tek Service Department Enabled Owners Manual Chameleon Paradize Page 13 The factory default is Disabled Disabled To Purchase This Item Visit BMI Gaming www bmigaming com 800 746 2255 1 561 391 7200 Preventive Maintenance Maintenance Chart Use the following maintenance chart as a guide only Actual maintenance intervals will depend on usage and environmental conditions at the location of the game Keep a log of all inspections even if no problems exist with the date and time of the inspection Record all action taken A repair log sheet is located at the end of this manual Important Do not use any cleaning solvents on the games graphics Use only a mild soap solution and a clean lint free cloth Inspect the game for damage Repair as needed Important The game should be turned off for cleaning and maintenance CAUTION Use of flammable substances can cause severe burns or personal injury Always use non flammable solvents for cleaning parts and surfaces Do not use substances such as gasoline kerosene or thinners Weekly Monthly Check all game lighting Repair or replace lamps as needed Fill ticket trays Empty coin box Test game to ensure proper operation Clean front glass with glass cleaner and a clean lint free cloth Blow paper dust from each ticket dispenser Clean more often if conditions dictate Clean outs
27. tes Owners Manual Chameleon Paradize Page 37 To Purchase This Item Visit BMI Gaming www bmigaming com 800 746 2255 1 561 391 7200 Repair Record Make copies of this page for the future Game Serial Number Date Maintenance Performed Parts Replaced Notes Owners Manual Chameleon Paradize Page 38 To Purchase This Item Visit BMI Gaming www bmigaming com 800 746 2255 1 561 391 7200 Parts List Owners Manual Chameleon Paradize Page 39
28. uild up and prevent bending the chip pins 4 Install the new board and reconnect the cables 5 Turn power back on and test the game Owners Manual Chameleon Paradize Page 22 To Purchase This Item Visit BMI Gaming www bmigaming com 800 746 2255 1 561 391 7200 Electrical Drawings Section J3 Connector ORG L Side Tkt Clr Ground RED L Side Lo Tkt Ground BRW L Side Lo Ticket Input BLU L Side Ticket Clear Button Input WHT L Side Wheel Sensor Input RED L Side Tongue Motor Sensor Input GRN L Side Score Sensor Input BLK Wheel and Score Sensor Grounds Owners Manual Chameleon Paradize Vie GRN R Side Lo Tkt Ground BLK R Side Tkt Clr Ground PUR R Side Lo Ticket Input YEL R Side Ticket Clear Button Input RED R Side Wheel Sensor Input BLK R Side Tongue Motor Sensor Input BRW R Side Score Sensor Input WHT R Side Action Button Input Page 23 To Purchase This Item Visit BMI Gaming www bmigaming com 800 746 2255 1 561 391 7200 J4 Connector BLU BLK VieW Direction L Side Ticket Counter BLU BLK Unused Output neo i R Side RED GRN R Side Coin Door 12v BLU WHT L Side Game Counter BLU WHT Unused Output WHT R Side Ticket Dispenser Enable BLU ORG R Side Ticket Dispenser 12v Wheel and Score Notch Signal Sensors GRN WHT WHT BLK Both 2 L Side 1 Button GRN WHT P Both Action Button Light Ground BLK
29. urchase This Item Visit BMI Gaming www bmigaming com 800 746 2255 1 561 391 7200 Technical Support Know Your Options Excellent Customer Service is very important to Bay Tek We know that keeping your games in great operating condition is important to your business When you need us we are here to help You can call us for free technical assistance and you can count on us to have parts on hand to support your game When you do need us its important that you know what to expect We offer options that fit your needs fan Call us M F Sam 5pm CST at 920 822 3951 ext 1102 B Fax us at 920 822 1496 Email us 24 hours a day at service cibay tek com Also order parts online at www bay tek com Send parts to 1077 E Glenbrook Dr Pulaski WI 54162 Owners Manual Electronics Circuit Boards Repair amp Return If you have Circuit Board issues with your Bay Tek game you can send the board to us and we ll repair it right away Most items sent to us are repaired and returned to you within one day This option is your best value as we offer this fast turn around service at the most reasonable price Advance Replacement If you have Circuit Board issues with your Bay Tek game but you don t have time to send in your board for repair give us a call and ask for an Advance Replacement We ll send you out a replacement board that same This is your best option when you need to get your game up and ru
30. wer the game OFF 7 The game is ready to be played again 8 Once everything checks out replace the Bay Tek test tickets with tickets of your own 9 Close and lock all doors Clean the windows using glass cleaner and a clean lint free cloth Important The game should be turned off for cleaning and maintenance VAN substances can cause severe burns or personal injury Always use non flammable solvents for cleaning parts and surfaces Do not use substances such as gasoline kerosene or thinners CAUTION Use of flammable 227 VOLUME CONTROL TICKET CLEAR Page 9 To Purchase This Item Visit BMI Gaming www bmigaming com 800 746 2255 1 561 391 7200 Programming Section The ticket patterns attract mode and more are Important controlled by two banks of dipswitches located on Power must be OFF to the game before adjusting the main circuit board the dipswitches Turn OFF the power strip inside The main circuit board is located in the back the game Set the desired settings wait 30 seconds inside lower part of the game then turn power back ON Be sure the power is off before adjusting the game settings See the charts on the following pages for programming options Factory Default Settings Goins per Play oon 6 8 Game Timer 82 Seconds 9 Factory Settings Bank 1 Dipi Dip2 Dips Dip7 Dips
Download Pdf Manuals
Related Search