INSTALLATION & OPERATING INSTRUCTIONS - Garland
Contents
1. III II II II I hh hh heh hr rere rir ter tree rx terr rere 3 BEFORE TINSTAEESTIOB osoccpy ee E E D CAU 4 PREPARA MON A L c 4 INSTALLA TON INS FRUC MONS ZUR TO 4 Cae Sa Cal O80 P 4 TEMPERA PORE ADJUSTMENT DUE 4 CLEANING amp MAINTENANCE INSTRUCTIONS 00 00 c cece eee eee eee eee eee I I IRI I3 ne herr rrr rris 5 SERVIO 5 WARRANT f 6 2 Euro Series Operations Manual UNIT SPECIFICATIONS Standard 32 95 Models 26 0 NENNEN 16 5 44 66 0 cm 41 9 111 8 cm Models with optional Mm flip up doors 2 A Voltage Amps Width Net Wt Ship Wt Ship Vol 120 208V 120 240V in kg Ibs kg Ibs ft cu meter ESA P 122 1460 16 5 41 9 95 43 1 110 499 102 020 AEN 1810 33 83 8 130 59 0 175 79 5 16 5 0 46 ES 3 3P 2290 44 111 8 170 77 2 215 97 6 22 0 62 Euro Series Operations Manual 3 BEFORE INSTALLATION NOTE Upon receipt of this product immediately unpack and inspect for possible concealed shipping damage If the unit is found to be damaged save all packing materials and contact your deliver2. Do not allow food to cool before placing in the unit Food that has been heated once CAUTION CAUTION Do not allow food items to rest directly on the shelf All food items should be placed in removable pans to ensure the utmost in product quality Turn ON OFF switch to the ON position Allow the unit to heat for approximately 30 minutes 3 Place hot cooked food in removable pans on the shelf shelves inside the unit NOTE Food items must be placed in pans prior to placing on shelves Never place food items directly onto the shelves TEMPERATURE ADJUSTMENT If temperature adjustment is needed set the knob to the desired setting 4 Euro Series Operations Manual CLEANING amp MAINTENANCE INSTRUCTIONS Disconnect power supply before servicing or cleaning this unit Safeguard power so it cannot be accidentally restored Failure to do so could result in serious injury Be careful not to allow water to run into electrical compartments as electrical shock or damage could result Unit must be cool to touch and disconnected from power source prior to cleaning Do not use power cleaning equipment steel wool or wire brushes on stainless steel or painted surfaces Do not use caustic or alkaline cleaners on the interior of the unit These cleaners can damage the specially finished surfaces of the unit interior GENERAL CLEANING 1 The exterior of this unit may be cleaned with a soft damp soapy cloth or sponge Be car
3. 111 North Hadley Road Fort Wayne Indiana 46804 USA www mercosavory com 6 Euro Series Operations Manual This page intentionally left blank Euro Series Operations Manual Merco Merco Savory LLC 1111 North Hadley Road Fort Wayne Indiana 46804 United States of America Telephone 260 459 8200 U S Facsimile 888 790 8193 Int Facsimile 260 436 0735 Technical Support Hotline 800 678 951 1 www mercosavory com cl Vos Enodis CERTIFIED SERVICE AMD PARTS
4. INSTALLATION amp OPERATING INSTRUCTIONS for EURO SERIES HOT FOOD MERCHANDISERS MODELS ES 1 1P ES 2 2P ES 3 3P Shown with optional flip up doors TO BE SERVICED ONLY BY AUTHORIZED PERSONS LISTED GR SERVICE AND PARTS PN 20000067 IMPORTANT WARNING AND SAFETY INFORMATION A This manual contains important safety and installation operation instructions Require all operators to read this manual thoroughly before installing operating or servicing this equipment Improper installation adjustment alteration service or maintenance can Cause property damage injury or death DANGER Disconnect power supply before servicing or cleaning this unit Safeguard power so it cannot be accidentally restored Failure to do so could result in serious injury If the power supply cord appears to be damaged do not attempt to operate the unit Contact a service agent or qualified electrician to repair When replacing bulbs it is critical that they meet or exceed NSF standards for use in WARNING food holding areas This is necessary to ensure that in the event of breakage food contamination and or personal injury doesn t occur CAUTION When using cleaning solutions be sure they meet local and national health standards TABLE OF CONTENTS WARNING AND SAFETY rA EUR d ead vd bu Eabb nan ton rtu Na rd ad Ex 2 UNIT
5. RVICES OF OTHERS REMEDIES The liability of Merco for breach of any warranty obligation hereunder is limited to i the repair or replacement of the equipment on which the liability is based or with respect to services re performance of the services or ii at Merco s option the refund of the amount paid for said equipment or services Any breach by Merco with respect to any item or unit of equipment or services shall be deemed a breach with respect to that item or unit or service only WARRANTY CLAIM PROCEDURE Customer shall be responsible to e Immediately advise the Dealer or Merco s Authorized Service Agent of the equipment serial number and the nature of the problem e X Verify the problem is a factory responsibility Improper installation or misuse of equipment are not covered under this Limited Warranty e Cooperate with the Service Agency so that warranty service may be completed during normal working hours e ravel Time not to exceed two hours and mileage not to exceed one hundred 100 miles e Portable equipment weighting less than ninety 90 pounds must be delivered to the Service Agent at Customer s expense GOVERNING LAW This Limited Warranty shall be governed by the laws of the state of Delaware USA excluding their conflicts of law principles The United Nations Convention on Contracts for the International Sale of Goods is hereby excluded in its entirety from application to this Limited Warranty Merco Savory LLC 1
6. eful not to scratch the surface Rinse with a clean damp soft cloth or sponge The glass may be cleaned with Windex or a multi surface cleaner CAUTION Be careful not to allow water to run into electrical compartments as electrical shock or damage could result The interior surface of these units needs nothing more than a daily wiping with a damp soft cloth Do not use abrasive cleaners on any part of unit This will cause damage to the finish of the unit SERVICE If the unit fails to operate check the circuit breaker to be sure it is turned on and check the ON OFF switch to be sure it is turned on before you call a service agency To find the service agency nearest you call Merco Savory Technical Service at 800 678 9511 or visit our website at www mercosavory com Euro Series Operations Manual 5 LIMTED WARRANTY FOR COMMERCIAL PRODUCTS LIMITED WARRANTY Merco Savory LLC Merco warrants this product to be free from defects in material and workmanship for a period of one 1 year from the date the product is installed or eighteen 18 months from the date of shipment from our facility which ever comes first During the warranty period Merco shall at Merco s option repair or replace parts determined by Merco to be defective in material or workmanship and with respect to services shall re perform any defective portion of said services The foregoing shall be the sole obligation of Merco under this Limited Warranty with re
7. or equipment manufactured or sold by Merco when such products or commercial equipment is installed or used in a residential or non commercial application Installations not within the applicable building or fire codes render this Limited Warranty and any responsibility or obligations associated therein null and void This includes any damage costs or legal actions resulting from the installation of any Merco commercial cooking equipment in a non commercial application or installation where the equipment is being used for applications other than those approved for by Merco LIMITATIONS OF LIABILITY The preceding paragraphs set forth the exclusive remedy for all claims based on failure of or defect in products or services sold hereunder whether the failure or defect arises before or during the warranty period and whether a claim however instituted is based on contract indemnity warranty tort including negligence strict liability implied by statute common law or otherwise and Merco its servants and agents shall not be liable for any claims for personal injuries incidental or consequential damages or loss howsoever caused Upon the expiration of the warranty period all such liability shall terminate THE FOREGOING WARRANTIES ARE EXCLUSIVE AND IN LIEU OF ALL OTHER WARRANTIES WHETHER WRITTEN ORAL IMPLIED OR STATUTORY NO IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR PARTICULAR PURPOSE SHALL APPLY MERCO DOES NOT WARRANT ANY PRODUCTS OR SE
8. spect to the equipment products and services With respect to equipment materials parts and accessories manufactured by others Merco s sole obligation shall be to use reasonable efforts to obtain the full benefit of the manufacturer s warranties Merco shall have no liability whether in contract tort negligence or otherwise with respect to non Merco manufactured products WHO IS COVERED This Limited Warranty is available only to the original purchaser of the product and is not transferable EXCLUSIONS FROM COVERAGE e Repair or replacement of parts required because of misuse improper care or storage negligence alteration accident use of incompatible supplies or lack of specified maintenance shall be excluded e Normal maintenance items including but not limited to light bulbs fuses gaskets O rings interior and exterior finishes lubrication de liming broken glass etc e Failures caused by improper or erratic voltages e Improper or unauthorized repair e Changes in adjustment and calibration after ninety 90 days from equipment installation date e his Limited Warranty will not apply to any parts subject to damage beyond the control of Merco or to equipment which has been subject to alteration misuse or improper installation accidents damage in shipment fire floods power changes other hazards or acts of God that are beyond the control of Merco e his Limited Warranty does not apply and shall not cover any products
9. y carrier within 15 days Refer to Shipping Damage Instructions enclosed for detailed instructions Failure to follow these instructions will negate Merco s or your ability to file claims and receive compensation for shipping damage This manual contains important safety and installation operation instructions Require all operators to read this manual before using the unit Failure to follow the instructions contained in this manual may cause injury or damage to the unit and will void the warranty SITE PREPARATION Choose a well ventilated location Place the unit on a suitable table or counter capable of supporting its weight The power supply must be in accordance with the specifications on the data plate located on the rear of the appliance It should be installed on a dedicated service line with no other equipment on the circuit The unit must be positioned so that the unit s plug is accessible INSTALLATION INSTRUCTIONS 1 Insure the electrical circuit used to supply electricity to the unit has the same voltage rating as indicated on the data plate 2 Place unit on an appropriate bench or table 3 Plug cordset into receptacle OPERATING INSTRUCTIONS DANGER UNIT MAY BE HOT Use caution while working around this unit as it may become hot j to touch Failure to heed these instructions could result in serious injury and then cooled has lost most of its moisture while setting out It cannot be reheated with satisfactory results
Download Pdf Manuals
Related Search