Operating Instructions K 6.200
Contents
1. Illustration Cl gt Pull out the transport handle until it audibly snaps into place gt Pull the appliance by its transport handle When transporting in vehicles gt Secure the appliance against shift ing and tipping over VII y English 11 Storage Maintenance and care Caution In order to prevent accidents or injuries keep in mind the weight of the appliance when selecting a storage location for it see Specifications Storing the Appliance gt Park the machine on an even sur face gt Press the disconnect on the trigger gun and remove the high pressure hose from the trigger gun gt Pushthe casing of the quick coupling forthe high pressure hose toward the rear and disconnect the high pres sure hose from the appliance Illustration II gt Stow away the mains cable the high pressure hose and accessory on the appliance Prior to extended storage periods as during the winter also observe the in structions in the Care section Frost protection Caution Protect the appliance and its ac cessories against frost The appliance and its accessories can get destroyed through frost if there is any water residues in them To avoid damage to them 3 Completely drain all water from the appliance Switch the appliance on with detached high pressure hose and detached water supply max 1 minute and wait until no more wa ter exits at the high pressure con nection Turn off the appl2. and turn the unit on at the ON OFF switch Press the trigger on the gun the unit is ready for use once there is a constant water system STEP 4 gt Connect the high pressure nozzle and press the hand trigger to begin cleaning English 9 Start up Caution Dry runs lasting longer than two minutes lead to damages to the high pressure pump If the appli ance does not build up pressure within two minutes switch it off and proceed as instructed in the Chapter Troubleshooting Illustration gt Insert the high pressure hose tightly into the quick coupling on the appli ance it will lock in audibly Note Make sure the connection nipple is aligned correctly Check the secure connection by pulling on the high pressure hose Illustration D gt Push the spray lance into the trigger gun and fasten it by turning it through 90 gt Completely open the water tap gt Insert the mains plug into the sock et gt Turn on the appliance I ON Operation Caution Risk of damage The appliance must only be operated laying down horizontal A Danger The handgun is subjected to a recoil force when the water jet is discharged Make sure that you have a firm footing and are also holding the handgun and spray lance firmly 10 English Caution Prior to cleaning make sure that the high pressure is placed safe ly on level ground Wear protec tive goggles and protective clothing during the cleaning pro ce
3. men tal capacities or lacking expe rience and or skills unless such persons are accompa nied and supervised by a per son in charge of their safety or they have received precise instructions on the use of this appliance and have under stood the resulting risks m Children must not play with this appliance m Supervise children to prevent them from playing with the appliance m Keep packaging film away from children risk of suffoca tion m The operator mustuse the appliance correctly When working with the appliance he must consider the local conditions and pay due care and attention to other per sons in particular children who are nearby m Do notuse the appliance when there are other persons around unless they are also wearing safety equipment m Wear protective clothing and safety goggles to protect against splash back contain ing water or dirt m This appliance was designed to be used with detergents which are supplied or recom mended by the manufacturer The use of other detergents or chemicals may compromise the safety of the appliance Caution m In case of extended down times switch the appliance off at the main switch appli ance switch or remove the mains plug English 5 m Do not operate the appliance at temperatures below 0 C m Observe a distance of at least 30 cm when using the jet to clean painted surfaces to avoid damaging paintwork m Never leave the appliance unattended
4. when it is in oper ation m Make sure that the power ca ble or extension cables are not damaged by running over pinching dragging or similar Protect the power ca ble from heat oil and sharp edges m All current conducting parts in the working area must be protected against jet water m The appliance may only be connected to an electrical supply which has been in stalled in accordance with IEC 60364 m The appliance may only be connected to alternating cur rent The voltage must corre spond with the type plate on the appliance m For safety reasons we rec ommend that you operate the appliance only via an earth leakage circuit breaker max 30 mA m Cleaning operations which produce oily waste water e g engine washes underbody washes may only be carried out using washing stations equipped with an oil separa tor 6 English Safety Devices Caution Safety devices protect the user and must not be modified or by passed Power switch The appliance switch prevents unin tentional operation of the appliance Lock trigger gun This lock locks the lever of the trigger gun and prevents the inadvertent start of the appliance Overflow valve with pressure switch The overflow valve prevents the per missible working pressure from being exceeded If the lever on the trigger gun is re leased the pressure switch turns off the pump the high pressure jet is stopped If the lever is pulled the pump is t
5. ere injury or even death A Warning Possible hazardous situation that could lead to severe injury or even death Caution Possible hazardous situation that could lead to mild injury to persons or damage to property Symbols on the machine 1 Riskof damage The appliance must only be operated laying down horizontal 2 The high pressure jet may not be directed at persons ani mals live electrical equip ment or at the appliance itself 3 Protect the appliance against frost Environmental protection Sy The packaging material can be O recycled Please do not place the packaging into the ordinary refuse for disposal but arrange for the proper re cycling Old appliances contain valuable materials that can be recycled Please arrange for the proper re cycling of old appliances Please dis pose your old appliances using appro priate collection systems Notes about the ingredients REACH You will find current information about the ingredients at www kaercher com REACH Warranty The warranty terms published by the relevant sales company are applicable in each country We will repair potential failures of your appliance within the warranty period free of charge provid ed that such failure is caused by faulty material or defects in manufacturing In the event of a warranty claim please contact your dealer or the nearest au thorized Customer Service centre Please submit the proof of purchase Englis
6. ge 230 240 V 1 50 Hz Connected load 2 2 KW Protection class IP X5 Protective class Mains fuse slow blow 16 A Water connection Max feed pressure 0 6 MPa Max feed temperature 60 C Min feed volume 11 I min Max Suction height 1 0 m Performance data Working pressure 13 MPa Max permissible pressure 15 MPa 2200 PSI Water flow rate 8 2 min Recoil force of trigger gun 19 N Detergent flow rate 0 0 3 I min Dimensions and weights Length 552 mm Width 290 mm Height 333 mm Weight 15 4 kg Subject to technical modifications 14 English Spare Parts 2 642 172 0 4 760 527 0 Lx T3 4 470 041 0 5 731 652 0 S d 6 388 216 0 6 465 031 0 K Ls 6 649 869 0 5 731 620 0 5 965 075 0 10 13 English 15 KARCHER aaa www karcher com au
7. h 3 Safety instructions A Danger m Never touch the mains plug and the socket with wet hands The appliance must not be used if the power cord or im portant parts of the appliance e g high pressure hoses trig ger gun or safety devices are damaged Check the power cord and mains plug for damage be fore every use If the power cord is damaged please ar range for it to be replaced im mediately by an authorised repair agent or a skilled elec trician Check the high pressure hose for damage before eve ry use Please arrange for the immediate replacement of a damaged high pressure hose The appliance may not be used in areas where a risk of explosion is present If the appliance is used in hazardous areas e g filling stations all of the safety pro visions and operating instruc tions detailed in this manual must be observed High pressure jets can be dangerous ifimproperly used The jet must not be directed at persons animals live elec trical equipment or at the ap pliance itself 4 English m The high pressure jet must not be directed at other per sons or directed by the user at him herself to clean cloth ing or footwear Never use the appliance to clean objects containing haz ardous substances e g as bestos Vehicle tyres or tyre valves are susceptible to damage from the high pressure jet and may burst The first indication of this is a discolouration of the tyre Damaged vehicle
8. iance gt Store the appliance and the entire accessories in a frost free room 12 English A Danger Turn off the appliance and re move the mains plug prior to any care and maintenance work Care Prior to longer periods of storage e g in the winter gt Remove filter from suction hose for detergent and clean under running water gt Pull out the sieve in the water con nection using flat nose pliers and clean under running water Maintenance The appliance is maintenance free Spare parts Use only original KARCHER spare parts You will find a list of spare parts at the end of these operating instruc tions Special accessories Special accessories expand the possi bilities of using your appliance Please contact your KARCHER dealer for fur ther information Troubleshooting You can rectify minor faults yourself with the help of the following overview If in doubt please consult the author ized customer service A Danger Turn off the appliance and re move the mains plug prior to any care and maintenance work Repair works may only be per formed by the authorised cus tomer service Appliance is not running gt Check whether the voltage indicat edon the type plate corresponds to the voltage of the mains supply gt Check the mains connection cable for damages gt Release the lever of the hand spray gun the appliance will switch on Pressure does not build up in the appliance g
9. is will mix the detergent with the water stream Recommended cleaning method 3 Spray the detergent sparingly on the dry surface and allow it to react but not to dry 3 Spray off loosened dirt with the high pressure jet Interrupting operation Release the lever on the trigger gun Lock the lever on the trigger gun During longer breaks more than 5 minutes also turn the appliance off using the O OFF switch Finish operation Caution Only separate the high pressure hose from the trigger gun or the appliance while there is no pres sure in the system Vu 3 After working with detergent sus pend detergent suction hose ina container filled with clear water switch the appliance on for around 1 minute once the spray lance has been removed and rinse until water runs clear Release the lever on the trigger gun Turn off the appliance 0 OFF Turn off tap Press the lever on the trigger gun to release any remaining pressure in the system Detach the appliance from the wa ter supply A Warning When disconnecting the sup ply or high pressure hose hot water may leak from the con nections after operation 3 Lock the lever on the trigger gun gt Pull out the mains plug Caution In order to prevent accidents or injuries keep in mind the weight of the appliance during transport see Specifications When transporting by hand Illustration gt Lift and carry the appliance by the transport and carrying handle
10. nn KARCHER FE Operating Instructions Before first use of the unit read these operating instructions and act in accordance with them Ai 59653420 03 14 General information 3 Safety instructions 4 Description of the Appliance 8 Operation 9 Transport 00 0c eee 12 Storage ee et ae ee 13 Maintenance and care 13 Troubleshooting 14 Customer Service 14 Technical specifications 15 Spare Parts 16 2 English General information Dear Customer Please read and comply with AU these original instructions prior to the initial operation of your ap pliance and store them for later use or subsequent owners Scope of delivery The scope of delivery of your appliance is illustrated on the packaging Check the contents of the appliance for com pleteness when unpacking In the event of missing accessories or any transport damage please contact your dealer Proper Use This high pressure cleaner is designed for domestic use only to clean machines vehicles build ings tools facades terraces gar den equipment etc using a high pressure water jet and detergents if required with accessories replacement parts and detergents approved by KARCHER Observe the instructions provided with these detergents Symbols in the operating instructions A Danger Immediate danger that can cause sev
11. ss Illustration amp gt Unlock the lever on the trigger gun gt Pull on the lever of the trigger gun the device will switch on Note Release the lever of the trig ger gun the device will switch off again High pressure remains in the system Spray lance with pressure regulation Carrying out the most common clean ing tasks The work pressure can be in finitely regulated between Min and Max gt Release the lever on the trigger gun gt Turn the spray lance to the desired position Spray lance with Dirtblaster For particularly dirty items or areas Caution Car tyres paint or sensitive sur faces such as wood should not be cleaned with the dirt blaster as there is a risk of damage Not suitable for use with detergents Working with detergent Please use exclusively KARCHER de tergents and care products to carry out the respective cleaning task as these were specifically developed for your appliance The use of other detergents and care products may lead to prema ture wear and can invalidate your war ranty claims Please obtain information at your local dealer or request informa tion directly from KARCHER Illustration 3 3 Pull detergent suction hose as far as is required out of the housing gt Suspend end of detergent suction hose in a container filled with deter gent 3 Use spray lance with pressure reg ulation Vario Power gt Turn the spray lance to Mix posi tion Note Th
12. t Check setting at the spray lance gt Appliance ventilation Switch on the appliance without connection the high pressure hose max 2 minutes and run it until the water discharging from the high pressure outlet is free of bubbles Switch off appliance and reconnect high pressure hose Check the water supply Pull out the fine filter in water con nection using flat nose pliers and clean with running water yy Appliance does not start motor hums Voltage reduction due to weak mains supply or when using an extension ca ble 3 When switching on first pull the le ver of the trigger gun and then switch the appliance switch to I ON Strong pressure fluctuations gt Clean high pressure nozzle Re move dirt and debris from the noz zle bore using a needle and rinse through with water from the front 3 Check water flow quantity Appliance is leaking 3 Slight leakage from the appliance pump is normal If the leakage in creases contact the authorized cus tomer service No detergent infeed 3 Use spray lance with pressure reg ulation Vario Power Turn the spray lance to Mix posi tion 3 Clean the detergent suction hose filter 3 Check the detergent suction hose for kinks Customer Service Australia KARCHER Pty Ltd 40 Koornang Road Scoresby Victoria 3179 1800 675 714 Free Call www karcher com au English 13 Technical specifications Electrical connection Volta
13. tyres tyre valves are highly dangerous Ensure that a dis tance of at least 30 cm is ob served when cleaning with the jet Risk of explosion Do not spray flammable liq uids Never draw in fluids contain ing solvents or undiluted ac ids This includes petrol paint thinner and heating oil The spray mist thus generated is highly inflammable explosive and poisonous Do not use acetone undiluted acids or solvents as they are damag ing to the materials from which the appliance is made A Warning The mains plug and the cou pling of an extension cable must be watertight and must never lie in water Moreover the coupling may never lie on the ground The use of cable reels that ensure that the sockets are at least 60 mm above the ground is recom mended Unsuitable electrical exten sion cables can be hazardous Only use electrical extension cables outdoors which have been approved and labelled for this purpose and have an adequate cable cross section 1 10 m 1 5 mm 10 30 m 2 5 mm Always fully unroll electrical cables from the cable drum High pressure hoses fixtures and couplings are important for the safety of the appli ance Only use high pressure hoses fixtures and couplings recommended by the manu facturer The appliance must not be operated by children or per sons who have not been in structed accordingly This appliance is notintended for use by persons with limit ed physical sensory or
14. urned on again Prerequisites for the appliance s stability Caution Create stability for the appliance prior to all work on or with the appliance to prevent accidents or damage The stability of the appliance is war ranted when it is placed onto an even surface Description of the Appliance 1 Storage for accessories 10 Coupling element for water 2 Transport handle detachable connection 3 Quick coupling for high pressure 11 Detergent suction hose with sieve hose 12 Trigger gun 4 Appliance switch 0 OFF ON 13 Lock trigger gun 5 Mains cable with mains plug 14 Key to detach the high pressure 6 Carrying handle hose from the trigger gun 7 Wheels 15 High pressure hose 8 Water connection 16 Spray lance with pressure 9 Fine filter in the water connection regulation Vario Power 17 Spray lance with Dirtblaster English 7 Operation 8 English Before Startup Illustration EN gt Screw the coupling element to the water connection on the appliance Illustration E gt Push the high pressure hose into the trigger gun until it locks audibly Note Make sure the connection nipple is aligned correctly gt Check the secure connection by pulling on the high pressure hose Water supply According to the applica ble regulations the appli D ance must never be used on the drinking water supply with out a system separator Use a suitable system separator manu factured b
15. y KARCHER or as an alternative a system separator as per EN 12729 Type BA Water flowing through a system separator is considered non drinkable Caution Always connect the system sep arator to the water supply never directly to the appliance Note Impurities in the water can dam age the high pressure pump and ac cessories For protection the use of the KARCHER water filter optional ac cessory order no 4 730 059 is rec ommended Water supply from mains Observe regulations of water supplier For connection values see type plate technical data gt Use a fibre reinforced water hose not included with a standard cou pling Minimum diameter 1 2 inch 13 mm minimum length 7 5 m gt Push the water supply hose onto the coupling unit then connect it to the water supply How to draw water from a bucket K RCHER recommends using the suction hose accessory sold sepa rately Order no 9 505 779 0 STEP 1 gt Connectthe suction hose to the wa ter inlet on the pressure cleaner and drop the other end into a bucket Tip If you are not using this accessory coil a hose into the bucket and ensure that you only use a standard hose clamp to connect to the pressure washer CLICK FITTINGS MUST NOT BE USED STEP 2 gt Fill up your bucket with water STEP 3 gt Connect the K RCHER power cord to an electricity source and turn on at powerpoint Make sure the high pressure nozzle is not connected
Download Pdf Manuals
Related Search