Admiral Craft COH-3100WPRO Owner's Manual
Contents
1. COH 3 LOOWPRO Half Size Convection Oven PRO This manual contains important information regarding your Admiral Craft unit Please read the manual thoroughly prior to equipment set up operation and maintenance Failure to comply with regular maintenance guidelines outlined in this manual may void the warranty PLEASE READ WARNINGS Do not touch any hot surfaces e Plug only into a 3 hole grounded electrical outlet e Do not immerse unit cord or plug in liquid at any time e Unplug cord from outlet when not in use and before cleaning e Do not operate unattended e Do not use this unit for anything other than intended use e Do not use outdoors e Do not clean unit with a water stream or jet e Always use on a firm dry and level surface at least 12 from walls or any other obstruction e Do not use if unit has a damaged cord or plug in the event the appliance malfunctions or has been damaged in any manner e Keep children and animals away from unit e Any incorrect installation alterations adjustments and or improper maintenance can lead to property loss and injury All repairs should be done by authorized professionals only e Ensure that the designated power supply is adequate for continual usage and the voltage is correct BEFORE USE Remove all packing and protective plastic coating from the side panels Operate the oven for 1 hour at 400 degrees F Baking 1 Turn power on Once on the power switch will illuminate 2 Set therm2. 570 degrees F to prevent the damage to the oven Place oven rack normally on the top position When the element has reached bright red 5 minutes position the dish under the grill broil element Heat food on one side and then turn on the other side Itis not recommended to close door when grilling broiling 3 Set baking timer by turning the knob clockwise to the required time The time can be adjusted in either direction throughout baking For baking less than 10 minutes first set to greater setting then turn down to the required time period Note This 60 minute oven time is completely independent of the oven control 4 When the timer reaches O minutes the buzzer sounds and indicator illuminates To cancel the buzzer turns the timer to the off position 5 Remove product from oven This convection oven will cook a greater quantity of food faster at a lower temperature and more evenly than an ordinary oven When the door is opened the fan will switch off but elements will remain on to provide quick heat recovery A high powered top element is fitted for toasting or broiling FOOD TEMP C TEMP F TIME 165 330 Sponges Small Cakes Butter Cakes Fruit Loaf Macaroons Biscuits Shortbread Scones Madeira Bread Plain Fruit Cake Rich Fruit Cake Gingerbread Baked Custard Souffle 10 12 mins 8 12 mins 35 mins 40 50 mins 15 20 mins 12 20 mins 15 20 mins 10 12 mins 35 50 mins 25 35 mins 1 11 2 hrs 2 3 hrs 35 50 mins 50 mins 2
3. for any damages to any person or to any property which may result from the use of this equipment thereafter This equipment is intended for commercial use only and this warranty is void if equipment is used in other than a commercial application For warranty and non warranty related issues technical support purchase replacement parts and warranty registration visit www admiralcraft com Please have your model number serial number and proof of purchase ready It is not necessary to contact the place where you originally purchased your product from THE FOREGOING WARRANTY IS IN LIEU OF ANY AND ALL WARRANTIES EXPRESSED OR IMPLIED INCLUDING ANY IMPLIED WARRANTY OF MERCHANTABILTY OR FITNESS FOR PARTICULAR PURPOSES AND CONSTITUES THE ENTIRE LIABILITY OF ACE IN NO EVENT DOES THE LIMITED WARRANTY EXTEND BEYOND THE TERMS STATED HEREIN VER1212
4. the grill broil element Heat food on one side then turn on the other side Toast sandwiches etc on a scone tray on the top rack position It is not recommended to close the door when grilling broiling Troubleshooting Possible Cause The mains isolating switch on the wall circuit The oven does not operate start breaker or fuses are off at the power board The power switch on the oven is off Turn on Depress switch Switch will illuminate For settings less than 10 minutes Bake timer does not time down Bake timer not set correctly first set the grater setting then turn back to desired setting Depress Roast n Hold button Cook timer does not time down Cook amp Hold button not depressed Roast time only operates when Roast function is selected Oven light not illuminating Blown bulb Replace bulb Too high a temperature selected Oven or racks not level Insufficient air Uneven cooking space around trays or baking tins Opening oven door unnecessarily Faulty thermostat oven door or restricted oven venting Smoking or discoloration around door Oven too hot Food spillovers not cleaned up Faulty oven door seal CLEANING NOTE To maintain cleanliness and increase service life the oven should be cleaned daily Do not immerse the unit in water or any other liquid If liquid enters the electrical compartment it may cause a short circuit or electrical shock 1 Clean the exterior with a good quality stainless steel com
5. 5 mins Rice Pudding 2 3 hrs Pastry Puff Short Flakey 8 12 mins 8 12 mins 8 12 mins 12 20 mins 35 mins Jam Fruit Roasting Set the oven temperature to 150 170 degrees C 300 degrees F 340 degrees F The hot air circulating in the oven reduces moisture loss and shrinkage Roasting times are reduced by approximately 10 minutes per kg MEAT TIME per kg Beef Rare 30 40 min Beef Medium 40 50 min Beef Well Done 50 60 min Veal 50 70 min Lamb 30 40 min Duck 50 min Goose 50 min Turkey 30 40 min Chicken under 1 kg 50 60 min over 1 kg 40 min Cook amp Hold This system will automatically cook food for a set time and then hold the oven at a preset temperature indefinitely to maintain food at a serving temperature after cooking has been completed Browning Different foods may be cooked together e g baking and roasting may be carried out at the same time Food which requires a slightly higher temperature or more browning should be placed at the top of the oven so that the broil element may be selected with the door shut during the last few minutes of cooking As the top element is quite powerful keep a close watch on browning progress Grilling Broiling Turn the oven thermostat to Grill Broil Place an oven rack normally on the second position from the top Place the food on a grill tray This allows fat to drain to prevent smoking When the element has reached a bright red 5 minutes position the dish under
6. T OVER TIGHTEN THE LAMP GLASS 12 To remove the oven seals hold at the center position and pull forward until the seals unclip Remove the side seals first then the top and finally the bottom The seals may be washed in the sink but take care not to damage them as they are fragile To replace face the lip towards the oven opening Fir the top and bottom seals first then the side seals m Convection oven COH 3100WPRO Circuit diagram Sa z 4 8kW 220VAC 60Hz ls do Us Max power 3100W na a E a L he E i S Switch Q Switch 5 Ex o o Lm pT2 180min A HL2 2 S relay Timer light S3 fa 7 MicroSwitch Le 1 P5 P6 ST1 ST2 u Thermostat JL 2 4 nm Switch 2 5 6 Thermosta a is E LJ S J L E o Heating i KV E X E element sra p Heating a a m relay light EH1 HL3 EH2 HL4 EH3 element light ieht Power cord is TILL AC L N240V 50Hz E ole HAINE Terminal Earth tial 4 Fan Motor Bottom element 2kW see E Light AY switch 40 IM 28 21 26 23 24 25 Vz 20 19 50 49 48 18 4 53 52 51 u 54 58 57 56 55 59 6 COH 3100WPRO 66 67 69 70 VER811 Pro Half Size Convection Oven COH 3100WPRO po JrixationBarUnderGlassDoor __ a oo Jpoortande S O 4 oo Jrackfortande O Bot 6 RackBeforeBottomElement po eft Support Rack O po 8 Support Pla
7. ith a new unit by ACE after defective unit has been inspected and defect has been confirmed ACE does not assume any liability for extended delays in replacing any item beyond its control This warranty does not apply to rubber and non metallic synthetic parts that may need to be replaced due to normal usage wear or lack of preventative maintenance This warranty covers products shipped into the 48 contiguous United States Hawaii and metropolitan areas of Alaska and Canada Warranty coverage on products used outside the 48 contiguous United States Hawaii and metropolitan areas of Alaska and Canada may vary Contact ACE for details at 1 800 223 7750 The following conditions are not covered by warranty e Equipment failure relating to improper installation improper utility connection or supply and problems due to improper ventilation e Equipment that has not properly been maintained damage from improper cleaning and water damage to controls e Equipment that has not been used in an appropriate manner or has been subject to misuse neglect abuse accident alteration negligence damage during transit delivery or installation fire flood riot or act of God e Equipment that has the model number or serial number removed or altered e Equipment on which the security seal has been broken If the equipment has been changed altered modified or repaired without express written permission from ACE then the manufacturer shall not be liable
8. ostat to desired temperature 3 Once the oven is up to temperature place product inside oven Avoid delays in loading the oven with the door open as this will delay the ovens temperature recovery Note the ovens fan will switch off and the oven lights will illuminate when the door is opened 4 Set baking timer by turning the knob clockwise to the required time The time can be adjusted in either direction throughout baking For baking less than 10 minutes first set to greater setting then turn down to the required time period Note This 60 minutes time is completely independent of the oven control 5 To view the product while baking press the light switch down on the control panel The light will stay on while latched in this position 6 When the time reached O minutes the buzzer will sound and the indicator illuminates To cancel the buzzer turn the time to the off position 7 Remove product from oven Note The ovens fan will switch off and the oven light will illuminate when the door is opened Cook amp Hold 1 Turn power on Once on the power switch will illuminate 2 Set thermostat to desired temperature 3 Once the oven is up to temperature place product inside oven Avoid delays in loading the oven with the door open as this will delay the ovens temperature recovery 4 Set Cook and Hold timer to desired time 3 hour time is electrically driven and is set by turning the timer knob in either direction to the required
9. pound 2 To avoid damage do not use abrasive cleaners or scouring pads 3 If soap or chemical cleaners are used be sure they are completely rinsed away with clear water immediately after cleaning Chemical residue could damage or corrode the surfaces of the unit 4 To clean the interior ensure that the oven chamber is cool Take care not to damage the fan or the tube on the right side of the oven as this controls the thermostat 6 If soap or chemical cleaners are used be sure they are completely rinsed away with clear water immediately after cleaning Chemical residue could damage or corrode the surfaces of the unit 7 Clean oven door glass with conventional glass cleaner 8 To remove oven racks slide to the out position raise the front edge up and lift out Different types of food trays can be placed on oven racks 9 To remove side racks undo the thumb screws counter clockwise rotation securing rack to the oven wall Swing the rack towards the center of the oven to disengage location pin in the front and pull the rack to remove To replace engage rack in rear holes Swing towards side of oven to engage in front hole and replace thumbscrew 10 Lift out the bottom element cover and thoroughly clean once per week 11 To remove the fan baffle unscrew the oven lamp glass and lift the baffle out To replace locate the bottom edge of the baffle over the bottom element terminal plate and secure in place with the oven lamp glass DO NO
10. teforBottomElement A 9 COMP TropElement po Right Support Rack O apo Jrancover _____ Screw ps FrontBottomStrenhtenBr poner Chamber a ppp JuunctionBox _____ part Screw _____ A JpiatetoFixRelay O O B3 Plate to FixPowerCord gt JRearpiate O O S ao PlatetoFix Motor O aa Rear Bottom Housing Boarding a COHP 40 60 MinuteTimer __ O COHP 42 o Right Fix Bar pa fod to Push Toggle Switch Re pA Rubber Ring S O pa Plate to Fix Flue i O ao Top Housing Boarding a Decorate Bar on FrontDoor pO oor Beam S O pet Fix Bar a Bulb Base a 5 Rivet ____________ a 5 Screw o ______ A Strengthen Bar for Door Frame sa Screw po fo comp6O JDoortatch o Rubber to Press Door Glass sa oo FixBarfor Door Glass TO o 6 63 gt fPoorfrilme____________ ACE Equipment One Year Limited Warranty Admiral Craft Equipment Corp ACE warrants its equipment against defects in materials and workmanship subject to the following conditions ACE Equipment is warranted for one year effective from the date of purchase by the original owner A copy of the original receipt or other proof of purchase is required to obtain warranty coverage This warranty applies to the original owner only and is not assignable Should any product fail to function in its intended manner under normal use within the limits defined in this warranty at ACE s discretion such product will be repaired replaced with a refurbished unit or replaced w
11. time The time can be set when convenient but will not start working until the oven control is set and the Roast n Hold switch is depressed 5 Depress the Roast n Hold switch The switch will illuminate and the time will begin to count down 6 To view the product while baking press the light switch down on the control panel The light will stay on while latched in this position 7 When the time reached the hold position the main oven thermostat is turned off and a pre set hold thermostat located behind the control panel will control the oven to keep the food warm at the serving temperature as long as required until the Roast n Hold switch is turned off Note The hold light will illuminate when the timer reaches hold until the Cook Hold switch is turned off The hold light may come on briefly when the Cook amp Hold control is first switched on until the oven heats up beyond the pre set holding temperature Grilling Broiling L Turn thermostat fully clockwise until the grill broil position is reached The grill broil indicator will illuminate indicating that the grill broil function has been set The heating indicator will also illuminate whenever the element is on Itis also recommended that the grill broil mode is only used with the oven door open as the oven fan is then automatically off If however the grill broil mode is used with the door closed the elements will cycle on off when oven temperature rises above 300 degrees C
Download Pdf Manuals
Related Search