OPERATING INSTRUCTIONS FOR WESSAMAT ICE
Contents
1. WESSAMAT Cleaner Remove rubber plug of rest water drain Clean inside area and insertion compartment with a brush and clear water repeat this process 2 or 3 times 10 Rub off inlet metal sheet with a soft cloth and insert it into the compartment 11 Wipe out ice bin with WESSAMAT Cleaner and rinse thoroughly with clear water 12 Insert ice bin 13 Put in rubber plug of rest water drain OONOARWN gt Attention As almost all cleaner contain acid all parts treated with cleaner are to be rinsed thoroughly in order to avoid corrosion caused by the acid Outside area Clean housing with a soft cloth Insert mains plug end of cleaning For health reasons it is recommended to remove the first production batch after the cleaning from the ice bin and not to consume it BA C103_e 10 03 2004 18 10 2011 page 2 operating instructions WESSAMAT Eismaschinenfabrik GmbH 4 Spare Parts 43335 42405 25125 18627 18628 32314 34107 31410 43443 43440 43334 32313 outer casing crusher shaft VA ice container PE limit switch limit switch gear motor knob handle for plexiglass lid operating capacitor bearing of the shaft motor coupling plexiglass lid spiral wheel 5 Wiring Diagram Legend S1 S2 R N p 5 l l io C1 230 V 50 Hz M1 S1 S2 limit switch filling lid limit switch ice container BA C103_e 10 03 2004 18 10 2011 C1 operating capacitor 5uF M1 gear motor2. OPERATING INSTRUCTIONS FOR WESSAMAT ICE CUBE CRUSHER C 103 1 Basic Safety Instructions 1 1 Proper Use The ice cube crusher is solely meant for crushing of small ice cubes For crushing only the ice cubes produced of ice cube makers should be used not the deep frozen one s Proper use shall also comprise observation of all directions of the operating instructions 1 2 Setting Up The ice cube crusher shall not be used in the following surroundings surroundings exposed to explosion hazards toxic atmospheres humid rooms CAUTION Under certain ambient conditions e g high ambient temperature and or high humidity there can be formation of condensation water in the area of the ice cube crusher 1 3 Adherence to Directions of the Operating Instructions A basic prerequisite for safe handling and troublefree operation of this machine is the knowledge of the basic safety instructions and safety regulations These operating instructions particularly the safety instructions shall be observed by all persons operating the machine In addition the accident prevention rules and regulations valid at the place of installation shall be observed 1 4 Hazards when Handling the Machine The ice cube crusher was built in accordance with the state of technique and the approved technical safety rules Nevertheless use of this machine can cause threats for life and limb of the person using the machine or third parties respectively result in impairmen
3. are parts do not guarantee to work correctly concerning security and wear and tear Otherwise the manufacturers warranty expires 2 Operation 2 1 Setting Up The machine shall be set up on a firm and horizontal subbase BA C103_e 10 03 2004 18 10 2011 page 1 operating instructions WESSAMAT Eismaschinenfabrik GmbH 2 2 Electrical Connection The ice cube crusher is delivered ready for connection and operates with alternating voltage of 230 V 50 Hz 2 3 Operation Open plexiglass lid and fill in ice cubes up to max 80 of the total capacity Completely slide the ice collecting container into the ice crusher and shut plexiglass lid Keep cover shut until the filled in quantity of ice has been crushed Caution For reasons of safety the ice cube crusher only operates when the ice collecting container has been slidden in completely and the plexiglass lid is shut 2 4 Saftey regulations The ice cube crusher may only be operated with completely slidden in ice collecting container The unit may only be operated with the enclosed sheet metal plate underneath the ice collecting container Never block the limit switches 3 Cleaning Inside area Pull out mains plug Take out ice bin and empty it Take out inlet metal sheet Insert ice bin Open filling shaft wipe out interior with a brush and WESSAMAT Cleaner Take out ice bin and remove rests of cleaner Thoroughly wipe out insertion compartment for ice bin with a brush and
4. page 3
5. t of the machine or actual values The machine shall only be used e for operation in accordance with instructions e if in technically safe and unobjectionable condition Troubles which may impair safety shall be eliminated immediately 1 5 Warranty and Liability On principle our General terms and conditions are applicable The latter are available for the user of the machine as of conclusion of the contract at the latest Warranty and liability claims for injuries to persons and property damages are excluded if they are not to be attributed to one or more of the following causes e operation of the machine not in accordance with instructions e improper installation initial operation operation and maintenance of the machine e operation of the machine with defective safety appliances or not properly installed or unoperable safety and protection devices non compliance with the directions of the operating instructions arbitrary modifications of the machine insufficient inspection of machine parts subject to wear and tear improperly performed repairs emergencies due to foreign matter and acts of God 1 6 Structural Modifications of the Machine No modifications alterations or attachments to the machine shall be made without written approval by the manufacturer In case of non compliance the manufacturer s warranty expires Change all parts of the machine which are not in an efficient shape Use only original spare parts Other sp
Download Pdf Manuals
Related Search