Operating instructions Dish- and Glasswashing machine
Contents
1. gt Open the door gt Place the screen and stand pipe in position gt Close the door Danger of contusion Close the appliance with both hands gt Switch on the appliance by pressing a programme pre selection key During the filling and heating phase the light above the pre selection key will flash When the light remains constantly lit the machine is ready for operation The time until the operation readiness is reached depends on the tem perature of the supplied water and the installed boiler resp tank heating capacity With cold water connection the duration is about 35 minutes 2 3 Manual dosing of detergent If there is no detergent dosing pump the detergent must be added manually to the washing water To obtain a concentration of 2 g l an ini tial amount of 40 g and a later addition of 30 g after each of 5 cycles should be added If the detergent is in powder form the powder should be scattered evenly on the water in the tank and dissolved after the tank has been filled This will prevent discolouration of stainless steel parts Operating instructions Operation ECOSTAR 530 F M FA A Programme start key a 2 4 Automatic dosing The required detergent and rinse aid is transported out of the containers into the tank resp boiler via electronically controlled dosing units The dosing is effected automatically acc to the requirements arising during the wash process If unsuitable products are used t2. gt Please notify the service engineer 5 2 2 The boiler temperature display on the right remains dark The pre set rinse water temperature is not reached in the time al lowed The cause can be a defective boiler heating element or boiler temperature sensor gt Please notify the service engineer 5 2 3 Both temperature displays remain dark This can indicate that the water supply from the building has been cut off or that the screen in the inlet valve is dirty It is impossible to fill the wash tank gt Notify the service engineer if the malfunction cannot be remedied by opening the water supply line or by cleaning the screen 5 2 4 All displays remain dark There is no power gt Switch the main switch in the building or the main safety devices on If this does not rectify the fault operation in emergency mode will no longer be possible gt Please notify the service engineer in all cases Appendix 6 1 Name and address of manufacturer MEIKO Maschinenbau GmbH amp Co KG Englerstrake 3 D 77652 Offenburg Telefon 49 781 203 0 Telefax 49 781 203 1179 www meiko de e mail info meiko de
3. turers of such products After de scaling gt Flush the de scaling product completely out of the appliance To do so 1 or 2 rinse cycles with fresh water are necessary Even little amounts of left over de scaling product may cause plastic J components and sealing materials to deteriorate If the appliance is heavily scaled you should charge the service engi neer of the responsible agency with the de scaling of the boiler Operating instructions Trouble shooti Ng ECOSTAR 530 F M FA 5 Trouble shooting Despite being expertly designed the machine may develop minor faults which are usually easy to eliminate This section explains a number of possible problems and how you can deal with them yourself Before carrying out work on the appliance it must be disconnected from the power supply The local main switch must be switched OFF or the local main fuse must be removed Should any of the described faults arise repeatedly their cause must be established Faults not described here can in general only be eliminated by a techni cian or electrician Please contact the agency responsible or the author ised dealer 5 1 Information messages and trouble shooting Washing button 0 Button gr faa fais taray AN Temperature Temperature tank boiler Illustration 2 Information display 5 1 1 Empty indication detergent rinse agent option If suction lances with conductivity sensors have b
4. Operating instructions mo MEIKO Dish and Glasswashing machine EcoStar 530 F M FA Operating instructions 1_EcoStar530F M_FA_XXX_Bedienung_EN_ 2005 12 doc Update Operating instructions Contents ECOSTAR 530 F M FA 1 Contents Contents 2 2 Operation 2 3 Setting the appliance out of operation 5 4 Maintenance and care 5 5 Trouble shooting 8 6 Appendix 9 2 Operation This appliance is a technically based piece of equipment and is not a consumer product within the meaning of the Regulations and Specifica tions GPSG Without a thorough knowledge of the instructions Installation and set ting in operation instructions the appliance must not be used False operation could result in injuries or damages to the appliance 2 1 Operating panel Programme pre selection key Appliance is switched on mn Programme is running Off key Programme start key Temperature indication Tank Boiler Fault indication Information indication Code indication Illustration 1 Operating panel Operating instructions Ope ration ECOSTAR 530 F M FA Normal cycle Wash programme 3 Intensive cycle Wash programme II Final rinse temperature Programme start Tank drain Self cleaning cycle Switching off Cycle interruption Table 1 Assigned to Programme key Items to be washed 2 2 Preparation for washing and rinsing The below described preparation works must be carried out before each setting in operation
5. een installed in the storage containers for detergent and or rinse agent the lights of the tank temperature display left will flash if one of the containers is empty The empty indication will be automatically cancelled when liquid is rec ognised in the relevant storage container 5 1 2 Empty indication partial demineralisation cartridge option If a partial demineralisation cartridge is used for water softening it is possible to store the values for the cartridge capacity and the existing carbonate hardness in the controls the service technician can set these values on site In this way an automatic calculation and display of the exhausted cartridge is possible on the basis of the water consumption The lights in the boiler temperature display right will flash if the car tridge is x This indication will not be automatically cancelled when the cartridge is changed This must be done manually as described in the Short Programming Manual Operating instructions Trouble shooti Ng ECOSTAR 530 F M FA 5 2 COMMON FAULT messages with emergency service If these fault messages are displayed only limited operation of the ma chine is possible The program times will certainly be extended when operating in emergency mode 5 2 1 The tank temperature display on the left remains dark The pre set rinse water temperature is not reached in the time allowed The cause can be a defective tank heating element or tank temperature sensor
6. g level of the container and if necessary replace it by a full one Only non foaming acid rinse aid pH lt 7 suitable for commercial dish washers may be used 4 4 Cleaning After the tank draining the following must be done gt Food residues sticking to the tank tank heating element and sieves must be removed with a brush gt Disassemble the wash arms and rinse them with flowing water gt Wash nozzles to be cleaned daily gt Cleanness of final rinse nozzles must be checked weekly and if nec essary they must be rinsed with flowing water The inserts should be inserted with the journal facing the direction of flow 4 5 Maintenance of stainless steel surfaces The appliance is made of high quality stainless steel Nevertheless un der certain conditions corrosion may appear For keeping the stainless steel surfaces constantly corrosion free gt use only suitable products Use only products which do not attack the material build up a film or cause discolourations Operating instructions Maintenance and care ECOSTAR 530 F M FA 4 6 De scaling If the appliance was operated with hard water the boiler and wash tank could calcify then a de scaling of the tank interior boiler housing tank heating boiler heating and wash and final rinse system becomes neces Sary For de scaling the appliance use only products suitable for industrial AN dishwashing machines Please observe the instructions of the manufac
7. he life of the dosing equipment will be significantly shortened We therefore recommend that detergents should have a pH value greater than 7 and that rinse agents should have a pH value between 7 and 2 2 5 Operation during washing and rinsing cycle When inserting the items to be washed into the baskets the following must be observed gt Hollow ware always to be loaded up side down Otherwise the water will be trapped inside and they will not dry to a brilliant finish gt Plates trays and big plates should always stand at a slight angle in the basket with their inside faces pointing upwards gt When using cutlery quivers ensure that cutlery is always inserted handle down gt Load the quivers with a mixture of spoons knives and forks as iden tical items of cutlery can be too close together gt Do not overload the quivers gt Do not stack the dishes in the wash basket as the wash water could not strike the items directly and the wash times would have to be un necessarily prolonged Short wash times with baskets which are not overloaded are much more economical 2 5 1 Start the wash cycle gt Pre wash the dishware major food residues serviettes tooth picks etc and place in the basket gt Basket to be inserted into the appliance and correctly centred gt Close the door gt Press the programme start key The appliance washes and rinses automatically and switches off the wash programme after co
8. inte 1 nance is necessary To facilitate the procedure a maintenance contract can be concluded with the manufacturer or agency Works repairs which were not correctly executed and the use of foreign parts through unauthorised persons endanger the operators and the appliance and will invalidate the warranty 4 2 Refilling of detergent There are two different types of detergent containers Incorporated container The storage container is translucent white in colour and is located in the lower part of the stationary dishwashing machine The lid can be opened after the container has been removed from its position gt Re fill the container marked detergent if necessary External container The container is located next to the appliance gt Check the filling level of the container and if necessary replace it by a full one Only non foaming alkali detergents pH gt 7 suitable for commercial AN dishwashers may be used Operating instructions ECOSTAR 530 F M FA i y Maintenance and care 4 3 Refilling of rinse aid There are two different types of rinse aid containers Incorporated container The container is situated behind the front panel in the lower part of the appliance The front panel can be tilted towards the front after a slight lifting gt Re fill the container marked rinse aid if necessary External container The container is located next to the appliance gt Check the fillin
9. mpletion The programme cycle is indicated by a light on the programme start key The wash time can differ from the adjusted programme time if the boiler heating capacity is not sufficient for heating up the supplied fresh water to the adjusted boiler temperature during the programme time In this case the automatic wash time extention is activated 2 5 2 Remove the washed items gt When the light goes out open the door and remove the basket Operating instructions Maintenance and care ECOSTAR 530 F M FA 3 Setting the appliance out of operation Off key gt Press the 0 key OFF key If no light is lit up the appliance is out of 0 operation gt Remove the stand pipe Programme start Machines without built in drain pump y gt After the water has been drained from the tank the tank is sprayed with clean hot water by pressing the Program Start button The door must remain closed Machines with built in drain pump gt For draining the tank press the programme start key gt After the draining of the tank water the tank interior is sprayed with hot fresh water The door must remain closed The waste water pump switches off automatically 4 Maintenance and care 4 1 Care general The appliance has been designed to keep the need for cleaning care and maintenance to a minimum However for a reliable safe and permanent function of the appliance and in the interest of hygiene and cleanliness a correct care and ma
Download Pdf Manuals
Related Search