EGG6042 EN HOB USER MANUAL - St Andrews Park Residents
Contents
1. for connection is easily accessible with the appliance installed www electrolux com The appliance is supplied with a 3 core flexible power cable with a 3 amp plug If it is necessary to change the fuse use a 3 amp ASTA approved BS 1362 fuse A B A Green and Yellow B 3 amp fuse C Brown D Cord clamp E Blue The wires in the cord are coloured as follows Green and yellow Earth Blue Neutral Brown Live WARNING A cut off plug inserted into a 13 amp socket is a serious shock hazard Ensure that the cut off plug is disposed of safely A 8 7 Replacement of the connection cable i The replacement of electric cable must be carried out exclusively by the service force centre or by personnel with similar competencies in accordance with the current regulations To replace the connection cable use only HO5V2V2 F T90 or equivalent type Make sure that the cable section is applicable to the voltage load and the working temperature The yellow green earth wire B must be approximately 2 cm longer than the live and neutral wire A 1 Connect the green and yellow earth wire to the terminal which is marked with the letter E or the earth symbol or coloured green and yellow 2 Connect the blue neutral wire to the terminal which is marked with the letter N or coloured blue 3 Connect the brown live wire to the terminal which is marked with2. pipes copper with mechanical end 8 4 Injectors replacement 1 Remove the pan supports 2 Remove the caps and crowns of the burner 3 With a socket spanner 7 remove the injectors and replace them with the ones which are necessary for the type of gas you use see table in Technical Information chapter 4 Assemble the parts follow the same procedure backwards 5 Replace the rating plate it is near the gas supply pipe with the one for the new type of gas supply You can find this plate in the package supplied with the appliance If the supply gas pressure is changeable or different from the necessary pressure you must fit an applicable pressure adjuster on the gas supply pipe 8 5 Adjustment of minimum level To adjust the minimum level of the burners 1 Light the burner 2 Turn the knob on the minimum position 3 Remove the knob 4 With a thin screwdriver adjust the bypass screw position A A 5 If you change e from natural gas G20 20 mbar to liquid gas fully tighten the bypass screw in e from liquid gas to natural gas G20 20 mbar undo the bypass screw approximately 1 4 of a turn WARNING Make sure the flame does not go out when you quickly turn the knob from the maximum position to the minimum position ENGLISH 13 8 6 Electrical connection e Do nat pull the mains cable to disconnect the appliance Always pull the mains plug if applicable e The app
3. the letter L It must always be connected to the network phase There must be no cut or stray strands of wire present The cord clamp must be correctly attached to the outer sheath 8 8 Building In min 600 mm min 100 mm A supplied seal B supplied brackets CAUTION Install the appliance only on a worktop with flat surface 8 9 Possibilities for insertion The panel installed below the hob must be easy to remove and let an easy access in case a technical assistance intervention is necessary 9 TECHNICAL INFORMATION 9 1 Hob dimensions Width ENGLISH 15 Kitchen unit with door 30 mm min 20 mm max 150 mm A Removable panel B Space for connections Kitchen unit with oven The electrical connection of the hob and the oven must be installed separately for safety reasons and to let easy remove oven from the unit 580 mm Depth 500 mm 9 2 Bypass diameters BURNER BYPASS 1 100 mm Rapid 42 Semi rapid 32 Auxiliary 28 9 3 Other technical data Gas original G20 2H 20 mbar 8 kW TOTAL POWER Gas replacement Electric supply 230 V 50 Hz G30 3 28 30 mbar 567 g h G31 3 37 mbar 557 g h 3 core flexible cable with non rewireable plug fitted with a 3 amp cartridge fuse 16 wwweelectrolux com Appliance category 112H3 Gas connection R 1 2 Appliance class 3 9 4 Gas b
4. EGG6042 EN HOB USER MANUAL 2 www electrolux com CONTENTS 1 SAFETY INFORMATION ctas anne 3 2 SAFETY INSTRUCTIONS ia 4 3 PRODUCT DESCRIPTION nn 7 4 DAILY USE iii 7 5 HINTS DE ennen ore erie 8 6 CARE AND CLEANING cc es 9 7 TROUBLESHOO ING 10 A NE 11 9 TECHNICAL INFORMATION nn 15 WE RE THINKING OF YOU Thank you for purchasing an Electrolux appliance You ve chosen a product that brings with it decades of professional experience and innovation Ingenious and stylish it has been designed with you in mind So whenever you use it you can be safe in the knowledge that you ll get great results every time Welcome to Electrolux Visit our website for S Get usage advice brochures trouble shooter service information O www electrolux com f Register your product for better service E www registerelectrolux com Buy Accessories Consumables and Original spare parts for your appliance Yo www electrolux com shop CUSTOMER CARE AND SERVICE Always use original spare parts When contacting our Authorised Service Centre ensure that you have the following data available Model PNC Serial Number The information can be found on the rating plate A Warning Caution Safety information i General information and tips O Environmental information Subject to change without notice ENGLISH 1 SAFETY INFORMATION Before the installation and use of the appliance carefully read the supplied instructions The manufacturer
5. Metallic objects such as knives forks spoons and lids should not be placed on the hob surface since they can get hot Do not use a steam cleaner to clean the appliance If the supply cord is damaged it must be replaced by the manufacturer an authorized Service or similarly qualified persons in order to avoid a hazard Where the appliance is directly connected to the power supply an all pole isolating switch with a contact gap is required Complete disconnection in compliance with the conditions specified in overvoltage category III must be guaranteed The earth cable is excluded from this When you route the mains cable make sure that the cable doesn t come into direct contact for example using insulating sleeving with parts that can reach temperatures of more than 50 C above room temperature 2 SAFETY INSTRUCTIONS This appliance is suitable for the following appliance when the door or the markets GB window is opened e f the appliance is installed above drawers make sure that the space 2 1 Installation between the bottom of the appliance WARNING and the upper drawer is sufficient for air circulation e The bottom of the appliance can get hot Make sure to install a non Only a qualified person must install this appliance Remove all the packaging combustile separation panel under the Do not install or use a damaged appliance to prevent access to the appliance bottom Obey the installation instru
6. ance The surface can be damaged Do not activate the cooking zones with empty cookware or without cookware Do nat put aluminium foil on the appliance Use only stable cookware with the correct shape and diameter larger than he dimensions of the burners Make sure the flame does not go out when you quickly turn the knob from he maximum to the minimum position Use only the accessories supplied with he appliance Do not install a flame diffuser on the burner The use of a gas cooking appliance results in the production of heat and moisture Provide good ventilation in the room where the appliance is installed Prolonged intensive use of the appliance may call for additional ventilation for example opening of a window or more effective ventilation for example increasing the level of mechanical ventilation where present This appliance is for cooking purposes only lt must not be used for other purposes for example room heating Do not let acid liquids for example vinegar lemon juice or limescale remover touch the hob This can cause matt patches 2 5 Care and cleaning Clean regularly the appliance to prevent the deterioration of the surface material Deactivate the appliance and let it cool down before you clean it Disconnect the appliance from the electrical supply before maintenance Do not use water spray and steam to clean the appliance Clean the appliance with a moist soft cloth Only use neutral d
7. applicable for the positions surface of the hob 4 For the burners to operate correctly e Wash stainless steel parts with water make sure that the arms of the pan and then dry them with a soft cloth supports are aligned with the centre of the burner 6 2 Pan supports The pan supports are not AN Y a resistant to washing in a UY dishwasher They must be washed by hand 8 Il 1 Remove the pan supports to easily ms clean the hob NY 6 3 Cleaning the hob e Remove immediately melted plastic plastic foil and food with sugar If not the dirt can cause damage to the hob www electrolux com e Remove when the hob is sufficiently cool limescale rings Keep these components well clean to prevent difficult lighting and check that the water rings fat stains shiny metallic discoloration Clean the hob with a moist cloth and some detergent After cleaning rub the hob dry with a soft cloth e To clean the enamelled parts cap and crown wash them with warm soapy water and dry them carefully before you put them back 6 4 Cleaning the spark plug This feature is obtained through a ceramic ignition candle with a metal electrode 7 TROUBLESHOOTING WARNING Refer to Safety chapters 7 1 What to do if Problem There is no spark when you try to activate the spark generator Possible cause T
8. ction i supplied with the appliance 2 2 Electrical Connection Keep the minimum distance from the other appliances and units WARNING Always be careful when you Move the bes fire and electrical shock appliance because it is heavy Always wear safety gloves Seal the cut surfaces with a sealant to prevent moisture to cause swelling Protect the bottom of the appliance from steam and moisture Do not install the appliance adjacent to a door or under a window This prevents hot cookware to fall from the e All electrical connections should be made by a qualified electrician e The appliance must be earthed e Before carrying out any operation make sure that the appliance is disconnected from the power supply e Make sure that the electrical information on the rating plate agrees with the power supply If not contact an electrician Make sure the appliance is installed correctly Loose and incorrect electricity mains cable or plug if applicable can make the terminal become too hot Use the correct electricity mains cable Do not let the electricity mains cable tangle Make sure that a shock protection is installed Use the strain relief clamp on the cable Make sure the mains cable or plug if applicable does not touch the hot appliance or hot cookware when you connect the appliance to the near sockets Do not use multi plug adapters and extension cables Make sure not to cause damage to the mains plug i
9. e burner WARNING Do not put unstable or damaged pots on the burners to prevent from spill and injury CAUTION Make sure that the bottoms of pots do not stand above the control knobs otherwise the flame heats the control knobs up CAUTION Make sure that pot handles are not above the front edge of the cooktop ENGLISH 9 AN CAUTION E A Make sure that the pots are Burner Diameter of placed centrally on the cookware burners in order to get mm maximum stability and to get Rapid 180 260 lower gas consumption Semi rapid 120 220 5 2 Energy saving Auxiliary 80 180 e f it is possible always put the lids on the cookware e When the liquid starts to boil turn down the flame to barely simmer the liquid 5 3 Diameters of cookware Use cookware with diameters applicable to the size of burners WARNING i Be very careful when you Refer to Safety chapters replace the pan supports to prevent the hob top from damage 6 1 General information 2 The enamel coating occasionally can e Clean the hob after each use have rough edges so be careful when e Always use cookware with clean you wash the pan supports by hand bottom and dry them If necessary remove e Scratches or dark stains on the surface stubborn stains with a paste cleaner have no effect on how the hob 3 After you clean the pan supports operates make sure that they are in correct e Use a special cleaner
10. etergents Do not use abrasive products abrasive cleaning pads solvents or metal objects Do not clean the burners in the ishwasher o 2 6 Disposal WARNING Risk of injury or suffocation Contact your municipal authority for information on how to discard the appliance correctly Disconnect the appliance from the mains supply Cut off the mains cable and discard it Flat the external gas pipes 3 PRODUCT DESCRIPTION 3 1 Cooking surface layout 3 2 Control knob Symbol Description no gas supply off posi O tion 4 DAILY USE WARNING Refer to Safety chapters 4 1 Burner overview ENGLISH Rapid burner Semi rapid burner Auxiliary burner Control knobs Symbol Description ignition position maxi pa mum gas supply M minimum gas supply 7 A Burner cap B Burner crown C Ignition candle D Thermocouple 4 2 Ignition of the burner i Always light the burner before you put on the cookware MN WARNING Be very careful when you use open fire in the kitchen environment The manufacturer declines any responsibility in case of the flame misuse 1 Push the control knob down and turn it counterclockwise to the maximum gas supply position X 2 Keep the control knob pushed for equal or less than 10 seconds This 8 www electrolux com lets the thermocouple warm up If not the gas supply is interrupted 3 Adjust the flame after it is regu
11. f applicable or to the mains cable Contact an Authorised Service Centre or an electrician to change a damaged mains cable The shock protection of live and insulated parts must be fastened in such a way that it cannot be removed without tools Connect the mains plug to the mains socket only at the end of the installation Make sure that there is access to the mains plug after the installation If the mains socket is loose do not connect the mains plug Do nat pull the mains cable to disconnect the appliance Always pull the mains plug Use only correct isolation devices line protecting cut outs fuses screw type fuses removed from the holder earth leakage trips and contactors The electrical installation must have an isolation device which lets you disconnect the appliance from the mains at all poles The isolation device must have a contact opening width of minimum 3 mm 2 3 Gas connection All gas connections should be made by a qualified person Before installation make sure that the local distribution conditions nature of ENGLISH 5 the gas and gas pressure and the adjustment of the appliance are compatible Make sure that there is air circulation around the appliance The information about the gas supply is on the rating plate This appliance is not connected to a device which evacuates the products of combustion Make sure to connect the appliance according to current installation regulations Pa
12. he hob is not connected to an electrical supply or it is connected incorrectly burner crown holes are not obstructed 6 5 Periodic maintenance Speak to your local Authorised Service Centre periodically to check the conditions of the gas supply pipe and the pressure adjuster if fitted Remedy Check if the hob is correctly connected to the electrical supply The flame extinguishes im mediately after ignition The fuse is released Burner cap and crown are placed incorrectly Thermocouple is not heated up sufficiently Make sure that the fuse is the cause of the malfunc tion If the fuse releases again and again contact a qualified electrician Place the burner cap and crown correctly After lightning the flame keep the knob pushed for equal or less than 10 sec onds The flame ring is uneven Burner crown is blocked with food residues Make sure that the injector is not blocked and the burner crown is clean 7 2 If you cannot find a solution If you cannot find a solution to the problem yourself contact your dealer or an Authorised Service Centre operated the hob correctly If not the servicing by a service technician or dealer will not be free of charge also during the Give the data from the rating plate Make sure you warranty period The instructions about the Service Centre and conditions of guarantee are in the guarantee booklet 7 3 Labels supplied with
13. ill not accept liability should the above instructions or any of the other safety instructions incorporated in this instruction booklet be ignored On the end of the shaft which includes the G 1 2 threaded elbow adjustment is fixed so that the washer is fitted between the components as shown in the diagram Screw the parts together without using excessive force O A C A End of shaft with nut B Washer C Elbow Connection to the gas supply should be with either rigid or semi rigid pipe i e steel or copper The connection should be suitable for connecting to R 1 2 1 2 BSP male hread When the final connection has been made it is essential that a thorough leak test is carried out on the hob and installation Make sure that the main connection pipe does not exert any strain on the hob If you use flexible metal pipes make sure hat they agree to ISO 10380 and ISO 10807 standards Be careful they do not come in touch with mobile parts or they are not squeezed Also be careful when he hob is put together with an oven A CAUTION It is important to install the elbow correctly with the shoulder on the end of the thread fitted to the hob connecting pipe CAUTION Failure to ensure the correct assembly will cause leakage of gas CAUTION Make sure that the gas supply pressure of the appliance obeys the recommended values Rigid connection Carry out connection by using metal rigid
14. is not responsible if an incorrect installation and use causes injuries and damages Always keep the instructions with the appliance for future reference 1 1 Children and vulnerable people safety e This appliance can be used by children aged from 8 years and above and persons with reduced physical sensory or mental capabilities or lack of experience and knowledge if they have been given supervision or instruction concerning use of the appliance in a safe way and understand the hazards involved Do not let children play with the appliance Keep all packaging away from children operates or when it cools down Accessible parts are hot If the appliance has a child safety device we recommend you activate it e Cleaning and user maintenance shall not be made by children without supervision Children of less than 3 years should be kept away unless continuously supervised 1 2 General Safety e The appliance and its accessible parts become hot during use Do not touch the heating elements e Do not operate the appliance by means of an external timer or separate remote control system Unattended cooking on a hob with fat or oil can be dangerous and may result in fire e Never try to extinguish a fire with water but switch off the appliance and then cover flame e g with a lid or a fire blanket e Do not store items on the cooking surfaces 3 Keep children and pets away from the appliance when it 4 www electrolux com
15. lar i If after some tries the burner does not light check if the crown and its cap are in correct positions A WARNING Do not keep the control knob pushed for more than 15 seconds If the burner does not light after 15 seconds release the control knob turn it into off position and try to light the burner again after minimum 1 minute CAUTION In the absence of electricity you can ignite the burner without electrical device in this case approach the burner with a flame turn the ontrol knob counter ockwise to maximum gas upply position and push it own Keep the control knob ushed for equal or less than 10 seconds to let the thermocouple warm up 5 HINTS AND TIPS WARNING Refer to Safety chapters O O O O jo 5 1 Cookware MN CAUTION Do not use cast iron pans potstones earthenware grill or toaster plates The stainless steel can become tarnished if it is too much heated WARNING Do not put the same pan on two burners i If the burner accidentally goes out turn the control knob to the off position and try to light the burner again after minimum 1 minute The spark generator can start automatically when you switch on the mains after installation or a power cut It iS normal 4 3 Turning the burner off To put the flame out turn the knob to the off position A WARNING Always turn the flame down or switch it off before you remove the pans from th
16. liance must not be connected with an extension cable an adapter or a multiple socket There is a risk of fire e Do not let the power cable to heat up to a temperature of more than 90 C The cable should be guided by means of clamps fixed to the side of the cabinet in order to avoid any contact with the equipment beneath the cooktop e Make sure that there is access to the mains plug after the installation Electrical Requirements Permanent electrical installation must agree with the latest E E Regulations and local Electricity Board regulations For your own safety the installation must be done by a qualified electrician e g your local Electricity Board or a contractor who is on the roll of the National Inspection Council for Electrical Installation Contracting NICEIC i The manufacturer refuses to be held responsible if these safety measures are not abided by Supply connections This hob has to be connected to 230 240 V 50 Hz electricity supply The hob has a terminal block which is marked as follows e L Live terminal e N Neutral terminal or E Earth terminal Before carrying out the connection make sure 1 The limiter valve and the electrical system can take the appliance load see the rating plate 2 The supply system is equipped with an efficient earth connection in compliance with the current standards and regulations 3 The outlet or omnipolar switch used
17. the accessories bag Stick the adhesive labels as indicated below ENGLISH 11 B MOD PROD NO SER NO MOD PROD NO SER NO DATA 03 IT DATA MODEL MODEL x X C E0049 MOD TYPE PROD NO 230V 50Hz SER NO 1P20 MADE IN ITALY A Stick it on Guarantee Card and send this part if applicable B Stick it on Guarantee Card and keep this part if applicable 8 INSTALLATION WARNING Refer to Safety chapters 8 1 Before the installation Before you install the hob write down the information bellow from the rating plate The rating plate is on the bottom of the hob 8 2 Important safety requirements This hob must be installed in accordance with the Gas Safety Installation and Use Regulations Current Edition and the IEE Wiring Regulations Current Edition C Stick it on instruction booklet For appliances installed in the Republic of Ireland please refer to NSAI Domestic Gas Installation 1 S 813 Current Editions and the ETCI Rules for Electrical Installations Provision for ventilation Detailed recommendations are contained in the following British Standards Codes Of Practice B S 6172 B S 5440 Par 2 and B S 6891 Current Editions The hob should not be installed in a bed sitting room with a volume of less than 20 me If it is installed in a room of volume less than 5 m8 an air vent of effective area of 100 cm is req
18. uired If it is installed in a room of volume between 5 m3 and 10 m an air vent of effective area of 50 cm is required while if the volume exceeds 11 m no air vent is required However if the room has a door which opens directly to the outside no air vent is www electrolux com required even if the volume is between 5 m and 11 m8 If there are other fuel burning appliances in the same room B S 5440 Part 2 Current Edition should be consulted to determine the requisite air vent requirements For appliances installed in the Republic of Ireland please refer to the NSAI Domestic Gas Installation I S 813 Current Editions Table Four Location The hob may be located in a kitchen a kitchen diner or bed sitting room with a volume greater than 20 m3 but not in a bathroom or shower room The minimum distance combustible material can be fitted above the hob in line with the edges of the hob is 400 mm If it is fitted below 400 mm a space of 50 mm must be allowed from the edges of the hob For appliances installed in the Republic of lreland please refer to NSAI Domestic Gas Installation I S 813 Current Edition Section 7 Permitted Locations of Appliance 8 3 Gas Connection WARNING Any gas installation must be carried out by a GAS SAFE REGISTER installer Make sure that once the hob is installed it is easily accessible for the engineer in the event of a breakdown The manufacturer w
19. urners for NATURAL GAS G20 20 mbar BURNER NORMAL POWER MINIMUM POWER INJECTOR MARK kW kW 1 100 mm Rapid 3 0 0 75 119 Semi rapid 2 0 0 45 96 Auxiliary 110 0 33 70 9 5 Gas burners for LPG G30 G31 28 30 37 mbar BURNER NORMAL MINIMUM INJECTOR NOMINAL GAS FLOW g h POWER POWER MARK kW kW 1 100 mm 30 28 30 G31 37 mbar mbar Rapid 2 8 6 75 86 204 200 Semi rapid 2 0 0 45 71 145 143 Auxiliary 1 0 0 33 50 T 71 10 ENVIRONMENTAL CONCERNS Recycle the materials with the symbol amp Put the packaging in applicable containers to recycle it Help protect the environment and human health and to recycle waste of electrical and electronic appliances Do not dispose appliances marked with the symbol E with the household waste Return the product to your local recycling facility or contact your municipal office ENGLISH 17 18 www electrolux com ENGLISH 19 www electrolux com shop M 867305071 GB 072014 C
20. y attention to requirements regarding adequate ventilation 2 4 Use WARNING Risk of injury burns and electrical shock Remove all the packaging labelling and protective film if applicable before first use Use this appliance in a household environment Do not change the specification of this appliance Make sure that the ventilation openings are not blocked Do not let the appliance stay unattended during operation Set the cooking zone to off after each use Do not put cutlery or saucepan lids on he cooking zones They can become hot Do not operate the appliance with wet hands or when it has contact with water Do not use the appliance as a work surface or as a storage surface When you place food into hot oil it may splash WARNING Risk of fire and explosion Fats and oil when heated can release flammable vapours Keep flames or heated objects away from fats and oils when you cook with them The vapours that very hot oil releases can cause spontaneous combustion Used oil that can contain food remnants can cause fire at a lower www electrolux com temperature than oil used for the first time Do nat put flammable products or items that are wet with flammable products in near or on the appliance WARNING Risk of damage to the appliance Do not keep hot cookware on the control panel Do not let cookware to boil dry Be careful not to let objects or cookware fall on the appli
Download Pdf Manuals
Related Search