User manual stream pump “Garda” GB
Contents
1. 92206 0 Fax Nr 09605 92206 10 Internet www esotec de Disposal Dear customer please cooperate in avoiding waste When you intend to dispose of the product in future please consider that it contains valuable raw materials suited for recycling Therefore do not dispose it of with domestic waste but bring it to a collection point for the recycling of waste electrical and electronic equipment Thank you very much for your cooperation Copyright esotec GmbH2. 1 1 extender cable 5 m for water pump Power input approx 8 W at 12 VDC approx 17 W at 18 VDC Item no 101736 Delivery height max 1 05 m at 12 VDC max 2 1 m at 18 VDC Delivery rate max 1800 I h at 12 VDC max 2450 I h at 18 VDC Operating temperature range 4 to 40 C a Note The pump is only suited for the delivery of water Note Protect the pump against frost During the cold winter months you may take the pump out of the water and store it in a warm place the solar module may be left outside during the winter 9 Safety notes DANGER for children Keep your children away from the swallowable small parts standpipe and sprinkler and the packaging material Danger of suffocation WARNING tripping hazard Lay the connecting cable so that it won t constitute any tripping hazard CAREFUL material damage If you set up the solar module without a module hold er you must make sure that it is sturdy enough to retain its position If the module falls down or a foreign object hits against it the solar module can be damaged 10 Spare parts 1 Plastic pre filter Art No 911100 2 Water outlet Art No 911101 3 Discs and spacer ring Art No 911102 4 Ceramic shaft Art No 911103 5 Impeller wheel Art No 911104 6 Seal Art No 911105 7 Hose connection Art No 911106 8 Gland nut Manufacturer Importer esotec GmbH Gewerbegebiet Weberschlag 9 D 92729 Weihernammer Tel Nr 09605
3. User manual stream pump Garda Customer support If you have problems or questions regarding this product simply contact us Monday to Friday 8 am to 12 noon and 1 pm to 4 pm By phone 09605 92206 27 By e mail for ordering spare parts ersatzteil esotec de By e mail for questions about the product technik esotec de Product Manufacturer Item No 101760 These instructions relate ONLY to this product and contain important informa tion for using the product for the first time Please keep these instructions for later reference and should always accompany the product in the event of trans ference to a new user 1 Introduction Dear Costumer Thank you for purchasing the solar light With this solar light you purchased a product manufactured according to the current state of technology This product fulfils all requirements of the valid European and national regula tions The conformity was proved The relevant declarations and documentati on are deposited with the manufacturer To maintain this state and guarantee a safe operation you as the user will have to fol low this operating manual 2 Safety Instructions In case of damages caused by not following this operating manual the warranty rights will expire We exclude liability for any consequential damages We exclude liability for property or personal damages caused by inappropriate handling or not following the safety instructions In these cases any guar
4. antee rights will expire Due to safety and admission reasons CE it is not allowed to arbitrarily reconstruct and or change the solar light Therefore please keep to the operating manual The accident prevention rules of the association of the industrial trade cooperative association for electric plants and working material are to be considered in industrial environments 3 Intended use This submersible pump is designed for the delivery feeding of water in a garden stream fountain or similar Via a hose connection this pump is able to deliver water and is particularly suited for the feeding of streams This pump is only suited for the delivery of water A solar module with a minimum power of 25 W a rechargeable battery with an ope rating voltage of 12 V or a power supply unit with a voltage of 12 Volt may be used as energy sources In case the pump is used with a solar module the pump will only work if the solar module is exposed to sufficient solar radiation The water pump does not have an on off switch The pump starts delivering water as soon as it is connected to the power supply 4 Assembly and activation 1 Completely unroll the connecting cable on the stream pump 2 The hose connection is suitable for various hose diameters inside diameter 25 32 or 38 mm Cut the connection according to the diameter of your hose by means of a saw Attach the hose onto the outlet and secure it by means of a matching hose clamp not
5. d twist off the hose connection Loosen the 4 screws on the bottom side of the pump Carefully open the body and take the pump out of the body Take off the plastic pre filter and clean it with warm water Rotate the water outlet anticlockwise by approx 90 and take it off carefully Remove the discs and the spacer ring from the ceramic shaft and pull out the impeller wheel The ceramic shaft may be pulled out if required Now carefully clean all parts with warm water Clean the contacts at the side of the pump with a soft brush After the cleaning assemble the pump in reverse order he pump is ready to use again 0 01 e e ONS Joo N Sensors for dry run protection 1 Plastic pre filter 2 Water outlet 3 Discs and spacer ring 4 Ceramic shaft 5 6 7 Impeller wheel Seal Sensors for the protection against dry running 8 Hose connection 3 9 Gland nut 10 Screws 7 Malfunctions The pump does not deliver any water ls the pump completely immersed in the water protection against dry running point 5 Was the supply voltage connected with reverse polarity Cable color brown positive pole blue negative pole Pump dirty For the cleaning of the pump see point 6 Capacity of the connected solar module or power supply unit sufficient 8 Technical data 11 Accessories Operating voltage 12 18VDC Protection class IP 68 1
6. included in the delivery 3 Mount the hose connection to the pump outlet by means of the enclosed gland nut Via the ball joint the hose outlet may according to the circumstances be adjusted under water 4 Completely immerse the stream pump into the water in doing so please pay attention to point 5 5 Now supply the stream pump with energy For this purpose please use the enclosed connector and cable brown positi ve pole blue negative pole In case you bought the pump as a complete solar system then the solar module is already equipped with the matching con nector Note The connector is reverse polarity protected please do not apply force when plugging it in 5 Protection against dry running By standard the pump is equipped with a protection against dry running For this purpose there are two sensor points attached to the side of the pump body not visible from the outside The pump will work if those points are underwater The pump does not work of one of the points protrudes from the water 6 Maintenance and care In order to maintain the performance of the pump it is from time to time depending on the water contamination required to wash out the pump with warm water For this purpose open the body as follows Note Please do not apply force when assembling and disassembling the pump The parts are were delicate and may break easily Unplug the connector of the pump Take the pump out of the water an
Download Pdf Manuals
Related Search