Nokia 2730 classic RM-578 579 Service Manual L1L2
Contents
1. will reduce the capacity and lifetime of the battery Always try to keep the battery between 15 C and 25 C 59 F and 77 F A phone with a hot or cold battery may temporarily not work even when the battery is fully charged Batteries performance is particularly limited in temperatures well below freezing Do not dispose batteries in a fire Dispose of batteries according to local regulations e g recycling Do not dispose as household waste 8 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Care ee ee Academy Service Manual Level 1 amp 2 7 EXPLODED VIEW A COVER ASSY V Lal ee ee __ KEYMAT ASSY 10002 screw 10004 10003 eA LCD MODULE i D 10005 A1 LIGHT SWAP PACKAGE 10006 10012 19998 pe 3 gt ome sHEET f 10006 LIGHT SWAP PWB cll gt RAPS SHIELDING LID 10007 4 pe e 10008 METS POWER SHIELDING LID 10009 A2 ANTENNA MODULE ASSY MICROPHONE TTT 10013 10015 MICROPHONE 10015 IHF SPEAKER 10014 ANTENNA MODULE 10016 10016 10020 10020 USB DOOR 10019 EARPIECE FRAME ASSY Ave la le TYPE LABEL 0017 N Se Ih 10013 2MM DC JACK 10018N B COVER ASSY 10022 ofp Only available as These parts can not be assembly reused after removal 9 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Care Academy 8 SERVICE DEVICES FLS 5 Flash Device CA 101 Serv2. 2730 classic disassembly is now complete 16 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Care Nokia 2730 classic RM 578 RM 579 Academy Service Manual Level 1 amp 2 11 ASSEMBLY HINTS an _ e sce 1 Nokia 2730 Tighten the four TORX size 6 screws 2 Nokia 2730 Tighten the two TORX size 6 screws to the torque of 15 Ncm in the order shown to the torque of 17 Ncm in the order shown Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Care ee ee Academy Service Manual Level 1 amp 2 12 SOLDER COMPONENTS BOTTOM mie pa LI i if i 18 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1
3. of the reach of small children Keep the phone dry Precipitation humidity and all types of liquids or moisture can contain minerals that will corrode electronic circuits Do not use or store the phone in dusty dirty areas Its moving parts can be damaged Do not store the phone in hot areas High temperatures can shorten the life of electronic devices damage batteries and warp or melt certain plastics Do not store the phone in cold areas When it warms up to its normal temperature moisture can form inside which may damage electronic circuit boards Do not drop knock or shake the phone Rough handling can break internal circuit boards Do not use harsh chemicals cleaning solvents or strong detergents to clean the phone e Do not paint the phone Paint can clog the moving parts and prevent proper operation e Use only the supplied or an approved replacement antenna Unauthorised antennas modifications or attachments could damage the phone and may violate regulations governing radio devices All of the above suggestions apply equally to the product battery charger or any accessory T Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Care eee ane Academy Service Manual Level 1 amp 2 6 BATTERY INFORMATION Note A new battery s full performance is achieved only after two or three complete charge and discharge cycles The battery can be charged and discha
4. NOKIA Care ee ee Academy Service Manual Level 1 amp 2 SERVICE MANUAL Level 1 amp 2 CLASSIC RM 578 RM 579 Transceiver characteristics Band RM 578 GSM 850 900 1800 1900 WCDMA 900 2100 NO KIA RM 579 GSM 850 900 1800 1900 WCDMA 850 1900 Tile Operator i Display 2 QVGA 320 X 240 up to 256k colours Camera 2 megapixel camera Operating System Series 40 5 Edition Feature Pack 1 Connections Menu Names e Bluetooth 3 0 e 3 5mm AV connector e Micro USB USB 2 0 e MicroSD card hot swap Transceiver with BL 5C 1020 mAh battery pack Best Talk Time Best Standby i GSM Up to 446 hours Talk times are dependant on ECTEL Talk Time network Up to 4 1 hours CDMA Up to 3 1 hours Up to 380 7 hours 1 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Care eee ane Academy Service Manual Level 1 amp 2 Table of contents i Ceo 3 COVO 4 3 Warnings and e201 Silla 5 ill Moniga iii 5 gt CAR CANNING CRETE 5 4 ESD protecliolesn al iL ee ne eee Pe mEre 6 5 Care AMA MAINEO MANCA iii T 6 BRENNA 8 i POGANI eere E nC E A EA EE E R ee Pe 9 8 Service COV CS essien eei E r aE AEE AEE i 10 5 Update 11 10 Disassembly INSECUCHIONS tttttrtrtrirerereceeee cere re rese se rese ce ee secesce rece seseseeeee sese se sce rece se seeeeniereseseezeeee ee see cere receseceeececenee 12 i ASM 17 t 6 21k CONDONE S Gee nen Pa epee Ee
5. e and maintenance including important safety information Note also the following 3 1 Warnings 1 CARE MUST BE TAKEN ON INSTALLATION IN VEHICLES FITTED WITH ELECTRONIC ENGINE MANAGEMENT SYSTEMS AND ANTI SKID BRAKING SYSTEMS UNDER CERTAIN FAULT CONDITIONS EMITTED RF ENERGY CAN AFFECT THEIR OPERATION IF NECESSARY CONSULT THE VEHICLE DEALER MANUFACTURER TO DETERMINE THE IMMUNITY OF VEHICLE ELECTRONIC SYSTEMS TO RF ENERGY 2 THE HANDPORTABLE TELEPHONE MUST NOT BE OPERATED IN AREAS LIKELY TO CONTAIN POTENTIALLY EXPLOSIVE ATMOSPHERES EG PETROL STATIONS SERVICE STATIONS BLASTING AREAS ETC 3 OPERATION OF ANY RADIO TRANSMITTING EQUIPMENT INCLUDING CELLULAR TELEPHONES MAY INTERFERE WITH THE FUNCTIONALITY OF INADEQUATELY PROTECTED MEDICAL DEVICES CONSULT A PHYSICIAN OR THE MANUFACTURER OF THE MEDICAL DEVICE IF YOU HAVE ANY QUESTIONS OTHER ELECTRONIC EQUIPMENT MAY ALSO BE SUBJECT TO INTERFERENCE 3 2 Cautions 1 Servicing and alignment must be undertaken by qualified personnel only 2 Ensure all work is carried out at an anti static workstation and that an anti static wrist Strap is worn 3 Use only approved components as specified in the parts list 4 Ensure all components modules screws and insulators are correctly re fitted after servicing and alignment 5 Ensure all cables and wires are repositioned correctly 5 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Care eee ane Acad
6. eS te err er E ee nrg ner 18 2 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Care eee ane Academy Service Manual Level 1 amp 2 1 CHANGE HISTORY Status VersionNo Date Comment Approved 10 03 08 2009 Approved The purpose of this document is to help NOKIA service levels 1 and 2 workshop technicians to carry out service to NOKIA products This Service Manual is to be used only by authorized NOKIA service suppliers and the content of it is confidential Please note that NOKIA provides also other guidance documents e g Service Bulletins for service suppliers follow these regularly and comply with the given instructions While every endeavor has been made to ensure the accuracy of this document some errors may exist If you find any errors or if you have further suggestions please notify NOKIA using the address below CMO Operation amp Logistics Training and Vendor Development Multimedia Creation amp Support mailto Service Manuals nokia com Please keep in mind also that this documentation is continuously being updated and modified so watch always out for the newest version 3 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Care eee ane Academy Service Manual Level 1 amp 2 2 COPYRIGHT Copyright 2009 Nokia All rights reserved Reproduction transfer distribution or storage of part or all of the contents in this document in any
7. emy 4 ESD PROTECTION Service Manual Level 1 amp 2 Nokia requires that service points have sufficient ESD protection against static electricity when servicing the phone Any product of which the covers are removed must be handled with ESD protection The SIM card can be replaced without ESD protection if the product is otherwise ready for use To replace the covers ESD protection must be applied All electronic parts of the product are susceptible to ESD Resistors too can be damaged by static electricity discharge All ESD sensitive parts must be packed in metallized protective bags during shipping and handling outside any ESD Protected Area EPA Every repair action involving opening the product or handling the product components must be done under ESD protection ESD protected spare part packages MUST NOT be opened closed out of an ESD Protected Area For more information and local requirements about ESD protection and ESD Protected Area contact your local Nokia After Market Services representative Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Care eee ane Academy Service Manual Level 1 amp 2 5 CARE AND MAINTENANCE This product is of superior design and craftsmanship and should be treated with care The suggestions below will help you to fulfil any warranty obligations and to enjoy this product for many years e Keep the phone and all its parts and accessories out
8. erted remove it also amp na n 4 n 6 Place the SS 93 between the A COVER ASSY and D COVER ASSY Detach the clips by sliding the SS 93 between the covers 4 Nokia 2730 Unscrew the two TORX size 6 screws in the order shown Do not use them again 12 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Care Nokia 2730 classic RM 578 RM 579 Academy Service Manual Level 1 amp 2 7 Remove the A COVER ASSY 8 Separate the KEYMAT ASSY from the A COVER by pressing the keymat lightly When the keymat is separated protect both sides of the window with protective film to avoid scratches 9 Protect the LCD with protective film E 10 Nokia 2730 Unscrew the four TORX size 6 screws in the order shown Do not use them again as A Uni L lr Alia 14 11 Release the clips holding the UI SHIELDING ASSY with the SS 93 Then lift up the assy as shown in the SWAP PWB small picture mpar 4 13 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Care RM578 RM579 Academy Service Manual Level 1 amp 2 SN NN SOS SU A NENNEN i K PAE OORT 13 Nokia 2730 Separate the UI SHIELDING ASSY by 14 R Remove the UI SHIELDING ASSY detaching the hooks on both sides with the SS 93 tool 15 Use the SS 93 to open the LCD connector Be on Resia the LCD AM TFT careful n
9. form without the prior written permission of Nokia is prohibited Nokia Nokia Connecting People and Nokia X and Y are trademarks or registered trademarks of Nokia Corporation Other product and company names mentioned herein may be trademarks or tradenames of their respective owners Nokia operates a policy of continuous development Nokia reserves the right to make changes and improvements to any of the products described in this document without prior notice Under no circumstances shall Nokia be responsible for any loss of data or income or any special incidental consequential or indirect damages howsoever caused The contents of this document are provided as is Except as required by applicable law no warranties of any kind either express or implied including but not limited to the implied warranties of merchantability and fitness for a particular purpose are made in relation to the accuracy reliability or contents of this document Nokia reserves the right to revise this document or withdraw it at any time without prior notice The availability of particular products may vary by region IMPORTANT This document is intended for use by qualified service personnel only 4 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Care eee ane Academy Service Manual Level 1 amp 2 3 WARNINGS AND CAUTIONS Please refer to the phone s user guide for instructions relating to operation car
10. ice Cable 00 3 7V BL 5CT NOKIA BL 5C Battery Nokia 2730 classic RM 578 RM 579 Service Manual Level 1 amp 2 AC 3 Travel Charger NOKIA Standard Toolkit V2 NMP standard toolkit v2 For more information refer to the Service Bulletin SB 011 on NOKIA Online Supplier or manufacturer contacts for tool re order can be found in Recommended service equipment document on NOKIA Online 10 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Care ee ee Academy Service Manual Level 1 amp 2 9 SW UPDATE Flash concept Point of Sales To use the FLS 5 Flash Dongle follow the user guide inside the sales package Please check always for the latest version of flash software wich is available on Nokia Online SERVICE Zia SOFTWARE PRODUCT SPECIFIC OF BATTERY 11 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Care Nokia 2730 classic RM 578 RM 579 Academy Service Manual Level 1 amp 2 10 DISASSEMBLY INSTRUCTIONS 1 Nokia 2730 classic disassembly NOTE Due to the 2 You must use the Nokia Standard Toolkit version similarities of Nokia 2700 and 2730 images usedin 2 and the AV plug disassembly instructions are of 2700 unless notified otherwise Li g 192 Z NOKIA 3 To remove the B COVER ASSY press and push it in 4 Remove the B COVER ASSY If there is a battery to the direction shown ins
11. ot to damage the connector or components nearby ANNA Ra ae 17 Nokia 2730 Use the SS 93 to lift up the se 18 Nokia 2730 Remove the MICROPHONE with the ANTENNA MODULE from the D COVER ASSY and then dental tool Be aware of the sharp point of the separate the module dental tool be careful not to injure yourself 14 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Care Academy La 19 Nokia 2730 Detach the IHF SPEAKER with the dental tool and remove the speaker with the tweezers 21 Nokia 2730 Detach the EARPIECE FRAME ASSY with the SS 93 23 Detach the DOMESHEET with the dental tool The 24 Nokia 2730 Use the dental tool to lever out the domesheet cannot be reused Nokia 2730 classic RM 578 RM 579 Service Manual Level 1 amp 2 20 Nokia 2730 Remove the adhesive with the tweezers Do not use it again 22 Release the DC jack with the charger plug by lifting up the DC jack Then remove the DC jack Remove also the USB door ISOLA Re m ORO ANRA Sorgen a DAVRAN ays k A ANIAN ON I RE ni i N D Lo tt ix iL mu MA WN RNY ONAN AA DANN RAND He reenter sha gt POWER SHIELDING LID and the RAPS SHIELDING LID Be careful not to damage nearby components 15 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Care pin Academy Service Manual Level 1 amp 2 END OF DISASSEMBLY 25 Nokia
12. rged hundreds of times but it will eventually wear out When the operating time talk time and standby time is noticeably shorter than normal it is time to buy a new battery Use only batteries approved by the phone manufacturer and recharge the battery only with the chargers approved by the manufacturer Unplug the charger when not in use Do not leave the battery connected to a charger for longer than a week since overcharging may shorten its lifetime If left unused a fully charged battery will discharge itself over time Temperature extremes can affect the ability of your battery to charge For good operation times with Ni Cd NiMh batteries discharge the battery from time to time by leaving the product switched on until it turns itself off or by using the battery discharge facility of any approved accessory available for the product Do not attempt to discharge the battery by any other means Use the battery only for its intended purpose Never use any charger or battery which is damaged Do not short circuit the battery Accidental short circuiting can occur when a metallic object coin clip or pen causes direct connection of the and terminals of the battery metal strips on the battery for example when you carry a spare battery in your pocket or purse Shortcircuiting the terminals may damage the battery or the connecting object Leaving the battery in hot or cold places such as in a closed car in summer or winter conditions
Download Pdf Manuals
Related Search