American Standard 3395B.001.021 Installation Guide
Contents
1. Review Step 7 of installation procedure Review Step 1 through 6 of installation procedure Toilet does not shut off Toilet bowl rocks after installation Flapper seal leaking or deformed Sand or debris lodged in water control Flush valve chain too tight holding flapper open Wax ring not fully compressed Floor not level Clean debris from seal surface Replace flapper seal as needed See web for more info Shut off water supply Remove cap and clean as per Fluidmaster maintenance instructions at www americanstandard us com enews fluidmasterguide pdf Readjust chain length as needed Retighten bowl to floor knobs Use toilet shims and or place a bead of caulk around the base of the toilet In the United States American Standard Brands P O Box 6820 Piscataway New Jersey 08855 Attention Director of Customer Care For residents of the United States warranty information may also be obtained by calling the following toll free number 800 442 1902 www americanstandard com In Canada AS Canada ULC 5900 Avebury Rd Mississauga Ontario Canada L5R 3M3 Toll Free 800 387 0369 www americanstandard ca In Mexico American Standard B amp K Mexico S de R L de C V Via Morelos 330 Col Santa Clara Ecatepec 55540 Edo Mexico Toll Free 01 800 839 1200 www americanstandard com mx 7301964 100 Rev A2. INSTALLATION INSTRUCTIONS urat CARE AND MAINTENANCE Aandord Champion 4 HET 2 piece Toilet 241AA Series Champion 4 HET Right Height Elongated 241BA Series Champion 4 HET Right Height Round Front Thank you for selecting American Standard the benchmark of fine quality for over 100 years To ensure this product is installed properly please read these instructions carefully before you begin Certain installations may require professional help Also be sure your installation conforms to local codes CAUTION PRODUCT IS FRAGILE TO AVOID BREAKAGE AND POSSIBLE INJURY HANDLE WITH CARE NOTE Pictures may not exactly define contour of china and components TANK 4149A EZ INSTALL KIT INCLUDED WITH TANK Tank To Bow Gasket Attachment Handles Plastic Washers 2 with Nuts 2 BOWL 3395A RIGHT HEIGHT ELONGATED BOWL 3395B RIGHT HEIGHT ROUND FRONT EZ INSTALL KIT INCLUDED WITH BOWL OO I I co cape Wax Ring T Bolts with Retainer 2 z Bowl To Floor Knobs 2 SOLD SEPARATELY KEK KK KKK KKK KK KKK RRR SS Water Supply Line ies Slow Close Toilet Seat Product names listed herein are trademarks of AS America Inc 7301964 100 Rev A AS America Inc 2013 730196 4 10 OA USE FUTURE R FO SAVE ROUGHING IN DIMENSIONS NOTE Distance from wall to closet flange centerline must be as listed below 12 305mm Champion 4 HET 241BA Series Right Height Round Front Champion 4 HET 241AA
3. Series Right Height Elongated FINISHED WALL 18 457mm 1 1 2 m 470mm 1 3 16 30mm C L OF SEAT POST HOLES Y 5 1 2 140mm CENTERS AS REQ D 16 1 2 419mm SUPPLY 9 3 8 13 13 16 FINISHEN 238mm 351mm FLOOR C L OF OUTLET Before You Start Turn Off Water Supply Flush to remove water from tank sponge remaining water from bowl before removing toilet Recommended fitting type for back to back installations FINISHED WALL 28 1 4 9 1 8 232mm 1 3 16 30mm 16 1 2 419mm C L OF SEAT POST HOLES yf 5 1 2 140mm CENTERS 718mm 18 457mm SUPPLY AS REQ D 16 1 2 419mm et 9 3 8 _ 13 7 16 FINISHEDS 238mm 341mm FLOOR 2 ___ _cyL OF OUTLET 12 305mm 1 BACK TO BACK INSTALLATION Press firmly 0 254mm A Caution If leaving floor flange open for more than 1 2 hours cover flange to prevent escaping sewer gases Depending upon your plumbing and venting conditions the flow from the Champion 4 HET in a back to back installation may create a vacuum on the system and draw water from the opposing bowl The National Standards Plumbing Code prohibits the use of a cross fitting for drainage as throw over is possible The code does approve a directional Y style fitting with proper venting to direct the water downward and away from the othe
4. oroughly with clear water and dry with a soft cloth WARNING Do not use in tank cleaners These products can seriously corrode fittings in the tank This damage can cause leakage and property damage American Standard shall not be responsible or liable for any damage caused by the use of in tank cleaners TROUBLESHOOTING GUIDE See Step 8 For Diagram Problem Possible Cause Corrective Action Does not flush Water supply valve closed Supply line blocked Flush valve chain too loose or disconnected Sand or debris lodged in water control Open valve and allow water to fill tank Shut off water supply disconnect supply line and inspect all gaskets and washers Reassemble Readjust chain length as required Shut off water supply Remove cap and clean as per Fluidmaster maintenance instructions at www americanstandard us com enews fluidmasterguide pdf Poor or sluggish flush Bowl water level too low Supply valve partly closed Partially clogged trapway and or drain pipe and or vent i Supply pressure too low Check that refill tube is connected to water control and inserted into overflow tube without being kinked or damaged Open supply valve fully Be sure that proper supply tube size is used Remove obstruction Consult a plumber if necessary Normal supply pressure must be at least 20 psi Toilet leaks Poor supply line connection Poor bowl to tank floor connection
5. r toilet Wax Ring sold separately 7301964 100 Rev A Apply weight evenly Do not move after placement Water tight seal may break Hand tighten only Do not overtighten Tighten handles alternately until the tank contacts the front and back of the bowl achieving china to china contact NOTE To ease installation push down on the top of the tank while tightening handles A WARNING Overtightening of water supply line nuts could Connect water result in breakage and potential supply line Sold separately Hand tighten nut flooding If the connection leaks after hand tightening replace the supply line Do not use any type of sealant on the water supply connection Use of plumber s putty pipe dope or any other type of sealant will void the warranty Turn on water supply 3 7301964 100 Rev A Water Level Adjustment Knob A Refill Tube Adjust water level to level indicated on tank by turning water level adjustment knob to move float cup up or down Trip Lever Rod Approximate Water Level Float Cup Flush Valve Chain Fill Valve va Flapper Or Water Flapper Flush Control A 7 Seal Valve Pa g Overflow Tube Tank to Bowl Gasket REPAIR PARTS LABEL LOCATED UNDER TANK LID Water Supply Line CARE AND CLEANING When cleaning your toilet wash it with mild soapy water rinse th
Download Pdf Manuals
Related Search