Elkay EFRU718 Installation Guide
Contents
1. Installation Instructions sinks faucets EFU EFRU PLAFRU and COSTCO SCUZ Series Undermount Stainless Steel Sinks with 1 8 Overhang Countertop Installation ATTENTION INSTALLER ELKAY RECOMMENDS THAT UNDERMOUNT SINKS SHOULD BE INSTALLED BY A PROFESSIONAL EXPERIENCED INSTALLER WARNING THE ENCLOSED CUTOUT TEMPLATE WILL CREATE AN OVERHANG OF APPROXIMATELY 1 8 IT IS RECOMMENDED THAT YOU DISCUSS THIS WITH YOUR CUSTOMER AND AGREE THAT THIS FINISHED APPEARANCE IS THE DESIRED EFFECT ELKAY IS NOT RESPONSIBLE FOR IMPROPER SINK OR COUNTERTOP INSTALLATIONS DUE TO THE AESTHETIC QUALITIES OF THE CONVERGING BOWL RADII THE TEMPLATE FURNISHED WITH EACH SINK PROVIDES THE ONLY OPENING RECOMMENDED FOR INSTALLATION OF ELKAY UNDERMOUNT SINKS SEE ILLUSTRATION BELOW ELKAY UNDERMOUNT SINKS SHOULD ONLY BE FASTENED TO A SOLID SURFACE COUNTERTOP I E GRANITE CORIAN SILESTONE ELKAY IS NOT RESPONSIBLE FOR SINK OR COUNTERTOP IF DAMAGED DURING INSTALLATION METAL EDGES MAY BE SHARP USE CAUTION WHEN HANDLING FOLLOW ALL LOCAL PLUMBING AND BUILDING CODES INSPECT SINK FOR DAMAGE PRIOR TO BEGINNING INSTALLATION INSTALLING SINK 1 Position template on countertop Locate the template front to rear so that sink will not inter fere with the cabinet 2 Trace a line around the template Cut along the inside of this line to provide opening This size opening will provide approximately an 1 8 over hang of countertop Please see item2. 2 under Attention Installer 3 Locate and drill the mounting holes following the countertop manufacturer s instructions as shown below Holes should allow even spacing of mounting brackets around the sink Type of fasteners to be as recommended by countertop supplier 4 Fasten mounting brackets to countertop loosely Using a good quality silicone caulk apply a bead evenly all around the top of the sink flanges 6 Position and align sink over the countertop 7 opening Press silicone onto countertop Tighten fasteners until mounting brackets are snug against sink Check alignment of sink to countertop opening Tighten down fasteners evenly Be careful not to overtighten Remove excess silicone a COUNTERTOP SILICONE CAULK rose 55 5s NOT FURNISHED MOUNTING BRACKET FASTENER NOT FURNISHED 1 8 Countertop Overhang 1 3 8 1 4 SINK lt 1 8 APPROX OVERHANG sinks faucets Installation Instructions Suggestions for the Care and Cleaning of your Elkay Stainless Steel Sink RECOMMENDED CLEANSERS Elkay has tested general household cleansers to measure their effec tiveness in cleaning stainless steel sinks The most aggressive cleansers consist of Bar Keeper s Friend Zud and Lawrence Right Work Other cleansers which are still effective but less aggressive include Ajax Comet Shiny Sinks Plus Luneta Soft Scrub Mr Clean M
3. aas and Flitz For everyday cleaning we recommend using Elkay s Stainless Butler Stainless Steel Cleaner Polisher The non abrasive formula is safe and effective for day to day cleaning So to help main tain the beautiful finish of your stainless steel sink use one of the cleansers that Elkay recommends RECOMMENDATIONS FOR PROPER MAINTENANCE Do Rinse thoroughly after each use Thorough rinsing can be done by running water for a few minutes and rubbing the cleaned area with a clean sponge Do Towel dry after each use to prevent mineral deposits from building up on the surface of the sink Do Clean the sink once a week being sure to rub in the direction of the satin finish grain lines using an Elkay recommended cleanser Do Use an Elkay bottom grid or rinsing basket to protect the finish Bottom grids and rinsing baskets can remain in the sink and will not cause rusting or pitting Do Not Rub the sink across the satin finish lines Scouring across the satin finish lines can damage the original sink finish Do Not Allow soap or other household cleansers to dry on the surface of the sink Most brands contain chemical additives which will affect the original finish Do Not Use solutions of chlorine bleach and water in the sink Chlorides which are found in most soaps detergents bleaches and cleansers are very aggressive to stainless steel If left on the sink too long they can cause surface pitt
4. ing Do Not Use a steel wool pad to clean your sink If a more abra sive product is needed use a green Scotch Brite pad being sure to rub in the direction of the satin finish grain lines Steel wool pads have a tendency to break apart and small particles of steel can become embedded in the surface of the sink The steel particles will rust and will give the appearance that the sink itself is rusting Do Not Use rubber mats or dishpans in the sink Leaving rubber mats or dishpans in the sink can lead to surface rust or possible pitting However if you insist on using mats or dishpans please remove them after each use and rinse thoroughly Do Not Leave wet sponges cloths or cleaning pads on the sink This can lead to surface rust Following these recommendations for the care and cleaning of your stainless steel sink will insure that it will provide you with many years of service CHLORIDES Today chlorides are found in most all soap detergents bleaches and cleansers chlorides can be aggressive to stainless steel However chlorides are very water soluble Therefore THOROUGH RINSING of your sink after each use to remove any chloride residue and a weekly cleaning is all that is required to keep your sink looking bright and shiny SCRATCHES Like many metallic surfaces your stainless steel sink will scratch These are merely usage scratches and over time will blend into the overall finish of your sink with proper clean
5. ing KNIVES Your sink is designed to serve as many things but not as a cutting board or chopping block This type of use will lead to deep scratches in the sink finish and will dull your knives Elkay does offer various cutting boards which will provide an additional work area WATER QUALITY The quality of your water can affect your sink s appearance If your water has a high iron content a brown surface stain can form on the sink giving the appearance of rust Additionally in areas with a high concentration of minerals or with over softened water a white film may develop on the sink To combat these problems we suggest that the sink be towel dried after use and again on a weekly basis the sink should be cleaned using a recommended cleanser FOODS Heavy salt concentration or foods containing high levels of salt should not be allowed to dry on the sink surface Rinse your sink thoroughly after use ELKAY LIMITED LIFETIME SINK WARRANTY Elkay warrants to the original purchaser of an Elkay stainless steel sink that Elkay will at its option replace or repair without charge such product if it fails due to a manufacturing defect for a lifetime of normal residential use Product replacement does not include transportation cost or labor installa tion cost This warranty covers only stainless steel self rimming drop in sinks installed in a conventional countertop surface and stainless steel under mount sinks installed in a convent
6. ional solid surface countertop and applies to residential installations only Elkay reserves the right to examine product in question and its installation prior to replacement WASTE FITTINGS AND ACCESSORIES ARE NOT WARRANTED OTHER WARRANTY CONDITIONS ON SINKS This warranty applies to sinks purchased after March 1st 2001 as shown on the purchaser s dated receipt For sinks purchased prior to March 1st 2001 the applicable warranty at that time will be in effect Our warranty does not cover product failure or damage caused by the use of optional Elkay acces sories abusive treatment misuse environmental factors normal wear including dents and scratches improper care and cleaning use of aggres sive and abrasive cleaners damage due to handling or failure to follow the recommended procedures for installation care and maintenance as detailed in the installation and care guide provided with every sink This warranty is extended only to the original consumer purchaser of the product This war ranty does not cover shipping costs labor costs or any other charges for such items as installation or replacement of the sink diagnosis or replace ment of any faucet or component part or any other expense or loss ELKAY 2222 Camden Court Oak Brook IL 60523 2011 Elkay Printed in USA elkayusa com All incidental or consequential damages are specifically excluded No additional warranties express or implied are given including but not limi
7. ted to any implied warranty of merchantability or fitness for a par ticular purpose Some states do not allow the exclusion or limitation of incidental or conse quential damages or limitations on how long an implied warranty lasts so the above limitations or exclusions may not apply to you This warranty gives you specific legal rights and you may also have other rights which vary from state to state TO OBTAIN SERVICE UNDER WARRANTY 1 Write to Elkay Manufacturing Company Attention Consumer Services 2222 Camden Court Oak Brook IL 60523 2 Include a letter containing the following information a Date of purchase and installation b Proof of Purchase copy of original dated invoice c Description of nature of defect d Model number or description of model and or component part if possible Rev H 5 11 74180164
Download Pdf Manuals
Related Search