Moldex 7010 Use and Care Manual
Contents
1. Flash point Not available Evaporation rate Not available Flammability solid gas Not applicable Upper lower flammability or explosive limits Flammability limit lower Not available Flammability limit upper Not available Explosive limit lower Not available Explosive limit upper Not available Vapor pressure Not available Vapor density Not available Relative density Not available Solubility ies Not available Auto ignition temperature Not available Decomposition temperature Not available Viscosity 40 60 Cp VOC 0 g L 25706 Page 3 of 8 Issue date 10 March 2015 Reactivity Possibility of hazardous reactions Chemical stability Conditions to avoid Incompatible materials Hazardous decomposition products Routes of exposure 10 Stability and Reactivity Reacts violently with acids May react with incompatible materials Hazardous polymerization does not occur Stable under recommended storage conditions Do not mix with other chemicals Contact with incompatible materials Oxidizing agents Acids May include and are not limited to Hydrogen chloride Chlorine Oxides of nitrogen Sodium oxides Oxides of carbon 11 Toxicological Information Eye Skin contact Inhalation Ingestion Information on likely routes of exposure Ingestion Inhalation Skin contact Eye contact Symptoms related to the physical chemical and toxicological characteristics2. Hazard class Packing group Special provisions Packaging exceptions DOT TDG Canadian federal regulations UN3082 ENVIRONMENTALLY HAZARDOUS SUBSTANCE LIQUID N O S Sodium hypochlorite Limited Quantity Canada III 16 lt 5L Limited Quantity 15 Regulatory Information This product has been classified in accordance with the hazard criteria of the Controlled Products Regulations and the SDS contains all the information required by the Controlled Products Regulations Canada WHMIS Ingredient Disclosure Threshold limits Sodium hypochlorite CAS 7681 52 9 1 Sodium metasilicate CAS 6834 92 0 1 WHMIS status WHMIS classification US federal regulations Exempt Exempt Consumer product Consumer product TSCA Section 12 b Export Notification 40 CFR 707 Subpt D Not regulated US CWA Section 311 Hazardous Substances Listed substance Sodium hypochlorite CAS 7681 52 9 Listed CERCLA Hazardous Substance List 40 CFR 302 4 Sodium hypochlorite CAS 7681 52 9 Listed Clean Air Act CAA Section 112 r Accidental Release Prevention 40 CFR 68 130 Not regulated Clean Air Act CAA Section 112 Hazardous Air Pollutants HAPs List Not regulated Superfund Amendments and Reauthorization Act of 1986 SARA Hazard categories SARA 302 Extremely hazardous substance SARA 311 312 Hazardous chemical Immediate Hazard Yes Delayed Hazard No Fire Hazard No Pressure Hazard No Reactivity
3. Hazard No No No 25706 Page 6 of 8 Issue date 10 March 2015 SARA 313 TRI reporting Not regulated Other federal regulations Safe Drinking Water Act SDWA Food and Drug Administration FDA US state regulations Not regulated Not regulated This product does not contain a chemical known to the State of California to cause cancer birth defects or other reproductive harm US California Hazardous Substances Director s Listed substance Sodium hypochlorite CAS 7681 52 9 Listed US California Proposition 65 Carcinogens amp Reproductive Toxicity CRT Listed substance Not listed US Illinois Chemical Safety Act Listed substance Sodium hypochlorite CAS 7681 52 9 Listed US Louisiana Spill Reporting Listed substance Sodium hypochlorite CAS 7681 52 9 Listed US Minnesota Haz Subs Listed substance Sodium hypochlorite CAS 7681 52 9 Listed US New Jersey RTK Substances Listed substance Sodium hypochlorite CAS 7681 52 9 Listed US New York Release Reporting Hazardous Substances Listed substance Sodium hypochlorite CAS 7681 52 9 Listed US Texas Effects Screening Levels Listed substance Sodium hypochlorite CAS 7681 52 9 Listed Sodium metasilicate CAS 6834 92 0 Listed US Massachusetts RTK Substance List Sodium hypochlorite CAS 7681 52 9 Listed US Pennsylvania RTK Hazardous Substances Sodium hypochlorite CAS 7681 52 9 Listed US Rhode Island RTK Sodium h
4. Health injuries are not known or expected under normal use Health injuries are not known or expected under normal use May cause irritation to the respiratory system Causes skin irritation Causes irritation Direct contact with eyes may cause temporary irritation Information on toxicological effects Acute toxicity Components Species Test Results N N dimethyl 1 tetradecanamine N oxide CAS 3332 27 2 Acute Dermal LD50 Not available Inhalation LC50 Not available Oral LD50 Not available Sodium hypochlorite CAS 7681 52 9 Acute Dermal LD50 Rabbit 10000 mg kg Inhalation LC50 Rat gt 5250 mg m3 Oral LD50 Mouse 5800 mg kg Rat 8200 mg kg Sodium metasilicate CAS 6834 92 0 Acute Dermal LD50 Not available Inhalation LC50 Not available Oral LD50 Mouse 2400 mg kg Rat 1153 mg kg Skin corrosion irritation Prolonged skin contact may cause temporary irritation Exposure minutes Not available Erythema value Not available 25706 Issue date 10 March 2015 Oedema value Serious eye damage eye irritation Corneal opacity value Iris lesion value Conjunctival reddening value Conjunctival oedema value Recover days Not available Causes irritation Not available Not available Not available Not available Not available Respiratory or skin sensitization Respiratory sensitization Skin sensitization Germ cell mutagenicity Mutagenicity Carcinogenicity Not available This product is not exp
5. SDS please contact the supplier manufacturer listed on the first page of the document 25706 Page 7 of 8 Issue date 10 March 2015 Prepared by Dell Tech Laboratories Ltd Phone 519 858 5021 Other information This Safety Data Sheet was prepared to comply with the current OSHA Hazard Communication Standard HCS adoption of the Globally Harmonized System of Classification and Labeling of Chemicals GHS This SDS conforms to the ANSI Z400 1 Z129 1 2010 Standard 25706 Page 8 of 8 Issue date 10 March 2015
6. 1 1 N oxide Sodium metasilicate 6834 92 0 0 1 1 Composition comments Inhalation Skin contact Eye contact This product is regulated by the CCCR Consumer Chemicals and Containers Regulations 2001 amp the CPSC Consumer Product Safety Commission The exact concentration of composition has been withheld as a trade secret in accordance with paragraph i of the OSHA HCS 1910 1200 4 First Aid Measures If symptoms develop move victim to fresh air If symptoms persist obtain medical attention Immediately flush with cool water for 15 minutes while removing contaminated clothing and shoes Discard or wash well before reuse Obtain medical advice immediately Immediately flush with cool water Remove contact lenses if applicable and continue flushing for 15 minutes Obtain medical attention immediately Ingestion If vomiting occurs naturally have victim lean forward to reduce risk of aspiration Never give anything by mouth if victim is unconscious or is convulsing Obtain medical attention 25706 Page 1 of 8 Issue date 10 March 2015 Most important symptoms effects acute and delayed Indication of immediate medical attention and special treatment needed General information Suitable extinguishing media Unsuitable extinguishing media Specific hazards arising from the chemical Special protective equipment and precautions for firefighters Fire fighting equipment instructions Specific methods General fi
7. Product identifier Other means of identification Recommended use Recommended restrictions Manufacturer Physical hazards Health hazards Environmental hazards OSHA defined hazards Label elements Hazard symbol Signal word Hazard statement Precautionary statement Prevention Response Storage Disposal Hazard s not otherwise classified HNOC Supplemental information SAFETY DATA SHEET 1 Product and Company Identification Moldex Instant Mold and Mildew Stain Remover Not available Stain remover None known EnviroCare Corporation 10 Upton Drive Wilmington MA 01887 US Phone 1 978 658 0123 Emergency Phone CHEMTREC US Canada 1 800 424 9300 Intl Maritime 1 703 527 3887 2 Hazards Identification Not classified Not classified Not classified Not classified None None The mixture does not meet the criteria for classification Observe good industrial hygiene practices If swallowed Rinse mouth Do NOT induce vomiting Store away from incompatible materials Dispose of waste and residues in accordance with local authority requirements None known This product is not subject to 29 CFR HCS 1910 1200 regulations The following HCS exemption for consumer products applies 29 CFR 1910 1200 b 6 ix 3 Composition Information on Ingredients Mixture Chemical name Common name and synonyms CAS number Sodium hypochlorite 7681 52 9 3 7 N N dimethyl 1 tetradecanamine 3332 27 2 0
8. ected to cause skin sensitization No data available to indicate product or any components present at greater than 0 1 are mutagenic or genotoxic No data available to indicate product or any components present at greater than 0 1 are mutagenic or genotoxic The finished product is not expected to have chronic health effects IARC Monographs Overall Evaluation of Carcinogenicity Sodium hypochlorite CAS 7681 52 9 Reproductive toxicity Teratogenicity Specific target organ toxicity single exposure Specific target organ toxicity repeated exposure Aspiration hazard Chronic effects Further information Name of Toxicologically Synergistic Products Volume 52 3 Not classifiable as to carcinogenicity to humans This product is not expected to cause reproductive or developmental effects Non hazardous by WHMIS OSHA criteria Not classified Not classified Not classified Not classified This product has no known adverse effect on human health Not available 12 Ecological Information Ecotoxicity See below Components Species Test Results Sodium hypochlorite CAS 7681 52 9 Crustacea EC50 Daphnia 2 1 mg L 48 Hours Aquatic Fish LC50 Chinook salmon Oncorhynchus 0 038 0 065 mg l 96 hours tshawytscha Sodium metasilicate CAS 6834 92 0 Aquatic Crustacea Fish Persistence and degradability Bioaccumulative potential Mobility in soil Mobility in general Other adverse effects Disposal instruction
9. nal exposure limits US AIHA Workplace Environmental Exposure Level WEEL Guides Components Type Value Sodium hypochlorite CAS STEL 2 mg m3 7681 52 9 Biological limit values No biological exposure limits noted for the ingredient s Exposure guidelines Chemicals listed in section 3 that are not listed here do not have established limit values for ACGIH or OSHA PEL Appropriate engineering Ensure adequate ventilation controls Individual protection measures such as personal protective equipment Eye face protection Safety glasses recommended Follow label directions carefully Skin protection Hand protection Rubber gloves recommended but not required Follow label directions carefully Other Follow label directions carefully Respiratory protection Not normally required if good ventilation is maintained Follow label instructions Thermal hazards Not available General hygiene Wash hands before breaks and immediately after handling the product Use good industrial considerations hygiene practices in handling this material When using do not eat or drink 9 Physical and Chemical Properties Appearance Clear Physical state Liquid Form Liquid Color Pale yellow Odor Fresh Slight chlorine Odor threshold Not available pH 11 12 Melting point freezing point Not available Initial boiling point and boiling Not available range Pour point Not available Specific gravity 1 05 1 10 Partition coefficient Not available n octanol water
10. om and upwind of spill leak Do not touch damaged containers or spilled material unless wearing appropriate protective clothing For personal protection see section 8 of the SDS Stop the flow of material if this is without risk Large Spills Dike the spilled material where this is possible Cover with plastic sheet to prevent spreading Absorb in vermiculite dry sand or earth and place into containers Prevent entry into waterways sewer basements or confined areas Following product recovery flush area with water Small Spills Wipe up with absorbent material e g cloth fleece Clean surface thoroughly to remove residual contamination Never return spills to original containers for re use For waste disposal see section 13 of the SDS Avoid discharge into drains water courses or onto the ground 7 Handling and Storage Use only with adequate ventilation Avoid breathing vapors or mists of this product Avoid prolonged exposure Wash thoroughly after handling Do not get in eyes on skin or on clothing Use good industrial hygiene practices in handling this material Keep container tightly closed Use according to package label instructions Use only as directed on the container label Store in a closed container away from incompatible materials Store away from incompatible materials see Section 10 of the SDS 25706 Page 2 of 8 Issue date 10 March 2015 8 Exposure Controls Personal Protection Occupatio
11. re hazards Hazardous combustion products Explosion data Sensitivity to mechanical impact Sensitivity to static discharge Personal precautions protective equipment and emergency procedures Methods and materials for containment and cleaning up Environmental precautions Precautions for safe handling Conditions for safe storage including any incompatibilities Causes serious eye irritation Symptoms may include stinging tearing redness swelling of the eyes and blurred vision Treat symptomatically If you feel unwell seek medical advice show the label where possible Show this safety data sheet to the doctor in attendance Avoid contact with eyes and skin Wear rubber gloves and chemical splash goggles Keep out of reach of children 5 Fire Fighting Measures Water Carbon dioxide Dry chemical Foam Not available Firefighters should wear a self contained breathing apparatus Firefighters should wear full protective clothing including self contained breathing apparatus Move containers from fire area if you can do so without risk Use standard firefighting procedures and consider the hazards of other involved materials No unusual fire or explosion hazards noted May include and are not limited to Oxides of carbon Oxides of nitrogen Oxides of sodium Chlorine Not available Not available 6 Accidental Release Measures Keep unnecessary personnel away Keep out of low areas Keep people away fr
12. s Local disposal regulations Hazardous waste code Waste from residues unused products EC50 LC50 Water flea Ceriodaphnia dubia 0 28 0 57 mg l 48 hours Western mosquitofish Gambusia affinis 1800 mg l 96 hours No data is available on the degradability of this product No data available No data available Not available No other adverse environmental effects e g ozone depletion photochemical ozone creation potential endocrine disruption global warming potential are expected from this component 13 Disposal Considerations Dispose of contents container in accordance with local regional national international regulations See above Not established This material and its packaging must be disposed of in a safe manner see Disposal instructions 25706 Page 5 of 8 Issue date 10 March 2015 Contaminated packaging Since emptied containers may retain product residue follow label warnings even after container is emptied 14 Transport Information U S Department of Transportation DOT Basic shipping requirements UN number Proper shipping name Hazard class Packing group Special provisions Packaging exceptions UN3082 Environmentally hazardous substances liquid n o s Sodium hypochlorite Limited Quantity US III 8 146 335 IB3 T4 TP1 TP29 lt 5L Limited Quantity Transportation of Dangerous Goods TDG Canada Basic shipping requirements UN number Proper shipping name
13. ypochlorite CAS 7681 52 9 Listed Inventory status Country s or region Inventory name On inventory yes no Canada Domestic Substances List DSL Yes Canada Non Domestic Substances List NDSL No United States amp Puerto Rico Toxic Substances Control Act TSCA Inventory Yes A Yes indicates that all components of this product comply with the inventory requirements administered by the governing country s LEGEND Severe Serious Moderate Slight Minimal Disclaimer Issue date Effective date Expiry date Further information 16 Other Information HEALTH FLAMMABILITY PERSONAL PROTECTION The information in the sheet was written based on the best knowledge and experience currently available Information contained herein was obtained from sources considered technically accurate and reliable While every effort has been made to ensure full disclosure of product hazards in some cases data is not available and is so stated Since conditions of actual product use are beyond control of the supplier it is assumed that users of this material have been fully trained according to the requirements of all applicable legislation and regulatory instruments No warranty expressed or implied is made and supplier will not be liable for any losses injuries or consequential damages which may result from the use of or reliance on any information contained in this document 10 March 2015 01 March 2015 01 March 2018 For an updated
Download Pdf Manuals
Related Search