Spalding 211230 User's Manual
Contents
1. 13 04 06 ID 211230 Attach struts 23 to board assembly using bolts 10 29 and washers 17 as shown Attach struts to E pole using bolt 10 washers 17 and nut 5 Place assembled unit in desired location Fill tank 1 completely with water 14 gallons 53 11 liters or sand approx 170 Ib 77 kg and install tank cap 9 i DO NOT LEAVE ASSEMBLY UNATTENDED WHEN EMPTY IT MAY TIP OVER ADD ONE GALLON 3 78 LITERS OF NON TOXIC ANTIFREEZE IN SUB FREEZING CLIMATES IF USING SAND 1 GALLON OF ANTI FREEZE IS NOT REQUIRED ID 211230 04 06 14 6 Install net 12 READ AND UNDERSTAND FAILURE TO FOLLOW INSTRUCTIONS COULD RESULT IN INJURY OR DAMAGE TO PROPERTY OPERATING IDA 211230 04 06 15 Adjusting Height Rest unit on support table Remove adjustment knob 11 T and carriage bolt 27 to extend or retract backboard and rim Height adjustment ranges from 4 1 2 6 1 2 ID 211230 04 06 162. 0 PARTS IDENTIFIER Actual Size RR 27 1 PARTS IDENTIFIER Not Actual Size Lo Pa 21 1 aa 22 1 11 1 13 1 ID 211230 04 06 6 SECTION A ASSEMBLE THE POLES 1 Correctly identify each pole section Poles have an identification sticker a that will be used as a reference point in the next step Reference Stickers MIDDLE BOTTOM 7 04 06 IDA 211230 IMPORTANT ONCE POLE SECTIONS ARE POUNDED TOGETHER THEY CANNOT BE TAKEN APART Align poles using alignment marks Pound 2 middle and bottom poles together by bouncing a them on a scrap piece of wood on the ground THE IDENTIFICATION STICKER IS i i LOCATED 3 3 4 FROM THE END OF as shown in FIG A until they no longer move THE POLE WHEN PROPERLY toward pole identification stickers POUNDED TOGETHER THE POLE SECTIONS SHOULD HAVE A 2 1 2 MINIMUM OVERLAP LEAVING 1 1 4 BETWEEN THE OVERLAPPING POLE AND THE IDENTIFICATION STICKER scrap wood Not Supplied MIDDLE _ IDENTIFICATION STICKER alignment mark BOTTOM lt IDENTIFICATION STICKER ID 211230 04 06 8 3 Attach pole assembly to tank as shown Secure pole assembly to tank by turning the pole assembly clockwise as shown TWO PEOPLE REQUIRED FOR THIS PROCEDURE FAILURE TO FOLLOW THIS WARNING COULD RESULT IN SERIOUS INJURY AND OR PROPERTY DAMAGE CAREFULLY TIPPING THE SYSTEM FORWARD WILL ALLOW EASIER ACCESS IMPORTANT T
3. O UNDERSIDE OF BASE NOTE ORIENTATION LC 04 06 IDA 211230 4 Secure tank struts 21 amp 22 to pole E TIGHTEN BOLT 10 IN LOCK NUT 5 UNTIL FLUSH EVEN WITH LOCK NUT S OUTER EDGE FAILURE TO FOLLOW THIS WARNING COULD RESULT IN SERIOUS INJURY AND OR PROPERTY DAMAGE Rotate struts down and bend struts outward to line up with holes on base as shown Secure free ends of tank struts to tank with carriage bolt 16 washer 17 and nut 20 as shown Repeat for other side ID 211230 04 06 A Slide the top pole through the locking collar 25 and attach snap bushing to the bottom of the middle pole section 2 B Slide top pole 2 into middle pole 3 C Secure the poles together with carriage bolt 27 and knob 11 as shown Bushing 28 MUST snap into hole of middle pole 2 11 04 06 ID 211230 Install the angled board mount 7 onto the top pole 2 and secure with the screws 26 as shown 8 Pole bracket will need to be lightly pressed into backboard ribbing Be sure to press a completely into place Attach rim 12 to backboard and pole bracket 14 with nut 20 reinforcement bracket 15 and carriage bolt 8 as shown Tighten nut completely NOTE BOARD STYLE MAY VARY PRESS BRACKET 14 INTO PLACE ID 211230 04 06 12 9 Carefully tip unit forward and slide backboard assembly onto pole as shown using E bolts 24 and nuts 5 SAWHORSE OR SUPPORT TABLE
4. Portable Basketball System Owner s Manual s 2 Customer Service Center AN 2 People N53 W24700 South Corporate Circle Sussex WI 53089 U S A Adult Assembly Required e Wood Board scrap This manual accompanied by sales receipt should be saved and kept on hand as a convenient reference as it contains important information about your model e Sawhorse or Support Table Garden Hose or Sand e 2 each Wrenches and or Socket Wrenches and Sockets OL 1 2 9 16 AND OR Write Model Number READ AND UNDERSTAND From Box Here OPERATOR S MANUAL BEFORE USING THIS UNIT OPTIONAL TOOLS OPERATING INSTRUCTIONS AND MATERIALS COULD RESULT IN INJURY OR DAMAGE TO PROPERTY NO Toll Free Customer Service Number for U S 1 800 558 5234 For Canada 1 800 284 8339 For Europe 00 800 555 85234 Sweden 009 555 85234 For Australia 1 800 632 7921 Internet Address http www huffysports com e Large and Small Adjustable Wrenches COPYRIGHT 2005 by SPALDING 1 04 06 ID 211230 ID 211230 04 06 Read and understand warnings listed below before using this product Failure to follow these warnings may result in serious injury and or property damage Owner must ensure that all players know and follow these rules for safe operation of the system DO NOT HANG on the rim or any part of the system including backboard support braces or net During play especially when performing dunk type act
5. ity of serious injury exists if this system is not installed maintained and operated properly If using a ladder during assembly use extreme caution Check base regularly for leakage Slow leaks could cause the system to tip over unexpectedly Seat the pole sections properly if applicable Failure to do so could allow the pole sections to separate during play and or during transport of the system Climate corrosion or misuse could result in system failure If technical assistance is required contact Huffy Sports Minimum operational height is 4 6 1 37m to the bottom of backboard Most injuries are caused by misuse and or not following instructions Use caution when using this unit NOTICE TO ASSEMBLERS Adult Assembly Required Dispose of ALL packaging materials promptly As with all products periodically inspect for loose small parts Assembled unit MUST be filled with sand or water at ALL times ALL basketball systems including those used for DISPLAYS MUST be assembled and installed according to instructions Failure to follow instructions could result in SERIOUS INJURY It is NOT acceptable to devise a makeshift support system IMPORTANT Remove all contents from boxes Be sure to check inside pole sections hardware and additional parts are packed inside Questions or Missing Parts PRODUCT REGISTRATION Please remember to complete your product registration form on DON T go back to store ine at www huff
6. ivities keep player s face away from the backboard rim and net Serious injury could occur if teeth face come in contact with backboard rim or net Do not slide climb shake or play on base and or pole After assembly is complete fill system completely with water or sand Never leave system in an upright position without filling base with weight as system may tip over causing injuries When adjusting height or moving system keep hands and fingers away from moving parts Do not allow children to move or adjust system During play do not wear jewelry rings watches necklaces etc Objects may entangle in net Surface beneath the base must be smooth and free of gravel or other sharp objects Punctures cause leakage and could cause system to tip over Keep organic material away from pole base Grass litter etc could cause corrosion and or deterioration Check pole system for signs of corrosion rust pitting chipping and repaint with exterior enamel paint If rust has penetrated through the steel anywhere replace pole immediately Check system before each use for proper ballast loose hardware excessive wear and signs of corrosion and repair before use Check system before each use for instability Do not use system during windy and or severe weather conditions system may tip over Place system in the storage position and or in an area protected from the wind and free from personal property and or overhead wires Never p
7. lay on damaged equipment When moving system use caution to keep mechanism from shifting Keep pole top covered with cap at all times Do not allow water in tank to freeze During sub freezing weather add 2 gallons of non toxic antifreeze sand or empty tank completely and store Do not use salt While moving system do not allow anyone to stand or sit on base or have added ballasting on base Do not leave system unsupervised or play on system when wheels are engaged for moving Use Caution when moving system across uneven surfaces System may tip over Use extreme caution if placing system on sloped surface System may tip over more easily See instruction manual for proper installation and maintenance SPALDING HYDRA RIB In the U S 1 800 558 5234 In the U S 1 800 334 9111 In Canada 2002648399 3 RUSSELL ATHLETIC HUFFY SPORTS In the U S 1 800 858 5234 intha U S 1 888 718 5488 In Canada 1 800 284 8339 ID 558200 05 05 A SAFETY INSTRUCTIONS A FAILURE TO FOLLOW THESE SAFETY INSTRUCTIONS MAY RESULT IN SERIOUS INJURY OR PROPERTY DAMAGE AND WILL VOID WARRANTY Owner must ensure that all players know and follow these rules for safe operation of the system To ensure safety do not attempt to assemble this system without following the instructions carefully Proper and complete assembly use and supervision are essential for proper operation and to reduce the risk of accident or injury A high probabil
8. ysports com customer_support product_registration Call TOLL FREE Customer Service Number listed on the front page 3 04 06 ID 211230 Get to know the basic parts of your basketball system IDA 211230 04 06 4 Silver Part No R 600002 908213 908144 908132 203099 D aS un 908217 203223 266300 203740 201344 i 908211 908129 203217 203218 203309 203679 203100 900454 900255 908633 203157 600000 204558 203038 600014 204962 r 2 1 1 1 1 1 2 6 1 1 3 4 2 2 1 4 1 1 2 PARTS LIST Description Tank Black Top Pole Section Middle Pole Section with Label Bottom Pole Section Nut Ny Lock 5 16 18 Net Pole Elbow Section Bolt Carriage 5 16 18 x 1 Long Cap Tank Bolt Hex Yellow Dichromate 5 16 18 x 2 63 Long Knob Plastic 3 sided Rim Backboard Backboard Mounting Bracket Rim Bracket Bolt Carriage 5 16 18 x 1 1 2 Long Washer Flat 5 16 Washer Flat 1 0 O D Bolt Hex 3 8 16 x 2 Long Nut Flange 5 16 18 Strut Left Strut Right Strut Board Bolt Carriage 5 16 18 x 2 1 4 Long Bushing Snap Plastic Screw Phillips Pan Bolt Carriage 5 16 18 x 2 3 4 Long Bushing Snap Plastic Bolt Hex 5 16 18 x 625 Long You may have extra parts with this model 5 04 06 IDA 21123
Download Pdf Manuals
Related Search