Fisher-Price K4563 Instruction Sheet
Contents
1. eon 8 x4 Screw 2 8 32 x 1 625 Screw 2 fan 8 Acorn Lock Nut 2 8 x 5 3 Screw 1 Lens Guard 2 Headlight Lens 2 Aap 8 Lock Nut 1 Hood Latch 2 Light Cover 2 3 Washer 1 For your convenience we included extra fasteners Note Tighten and loosen all screws with a Phillips screwdriver Do not over tighten the screws Part Not Shown Label Sheet Fasteners Shown Actual Size K4563pr 0922 5 D PARTS PICTURE Note Some parts shown are assembled on both sides of the vehicle Vehicle Steering Column Hood Latch Lens Guard 2 00 2 Parts Not Shown Short Seat Belt Strap p a Door Hinge 2 8 x 1 Screw 6 8 Acorn Lock Nut 2 Windshield Steering Wheel Cap 10 x 3 4 Screw 23 8 Lock Nut 1 12 Volt Battery Brush Guard 752 X 11 0 Pin 8 y 4 Screw 2 3 4 Washer 1 12 Volt Charger steering Wheel yw Backpack 8 32 x 15 s Screw 2 Label Sheet Key Assembly Seat Backpack Holder 8 x 5 8 Screw 1 Taillight Lens Taillight Housing Hood ate Dash ah Headlight Lens 2 lt Long Seat Belt Strap 4J Map Spacer 2 c Te Map Clip sport Bar sport Bar Support 2 Light Cover 2 1 2 3 4 5 G F4 8 9 6 K4563pr 0922 BATTERY CHARGING E ELECTRICAL HAZARD NWARNING e Battery can fall out and injure a child if vehicle tips over Always use battery retainer2. Please read this manual and save it with your Original sales receipt Tools needed for assembly Phillips Screwdriver Adiustable Wrench or Pliers and Safety Scissors all not included Use only with a Power Wheels 1 2 Volt Lead Acid fiat Rechargeable Batterv and Power Wheels 12 Volt Charge ra with Type 12ViConnector both included WY Requires fouraC LR14 alkaline batteries for FM Radio operation not included pu ae j i SA Tx i 4 van SH ai gt WE i 1 yh a wN SAN AN MANAA m 1 al hl F wh K gt peT e x f T he kigi i b Tig k pa 1 ifm ray th lk a T i n oth ia i MNT N f A a Pa pri k j i 4 k i VE N Product features may vary from the pictur above Hi pee a aa et ON ee i EN Cs Pa af HR heh ta n SN ne PT iy 1 FA eee a ee TN T Ni ah rh Fae oe ant a WHEELS P R e K A Owner Manual Pr NM A TP eee a eS fg Fe i ee Ke es HEF T NW Aw sithi essay ES ctions SS i a IET ET ae teas Seat Na he N ia Ang aw VS ale et ey NE PER AA SN Mace 7 a a An so Model K4563 AN STRESS aT 1 N ENR T RUAN MENG A i E aie La eek 0 DA W Nia NN ti wl 1 a TABLE OF CONTENTS A poranenia ne eee E01 2 EB anne A O E ee ee ne 3 G Pa eea a Oe ee Ceo E70 4 p Earns Picture ae eee ee eee ee te eee Cee eee ee ee eee ee ae ee eee ee ee ee ee ee er ee eee eee eee 6 E Bate
3. N WARNING e Prevent Injuries and Deaths e Direct Adult Supervision Required e Never Ride at Night e Keep Children Within Safe Riding Areas These areas must be away from swimming pools and other bodies of water to prevent drownings generally level to prevent tipovers away from steps steep inclines cars roads and alleys Riding Rules Make sure children know and follow these rules for safe driving and riding Always sit on the seat Always wear shoes Only 2 two riders at a time Teach Safety Rules to Children While children can quickly develop the skill necessary to drive this vehicle it is important to remember that their judgment skills are still very immature Unsupervised driving by children can lead to serious injury Before children use this vehicle an adult Should carefully evaluate the driving area as well as the children s Skill level and ability to drive this vehicle safely Children are not always able to recognize or anticipate hazards even when they have been taught about them There is no acceptable substitute for direct adult supervision Teach appropriate safety rules to your child before allowing operation of this vehicle These rules should also be reviewed with neighborhood children or other playmates who want to drive this vehicle Riding Rules Make sure children know and follow these rules for safe driving 1 Always sit on the seat 2 Always wear shoes 3 Only
4. first check the Problems and Solutions Guide below If you still experience a problem please contact Power Wheels Consumer Relations toll free at 1 800 348 0751 between 9 AM 7 PM EST Monday through Friday or 11 AM 5 PM EST Saturday Or contact your local Power Wheels authorized service center For the location nearest you please visit us on line at www powerwheels com or call 1 800 348 0751 PROBLEM POSSIBLE CAUSE SOLUTION Vehicle does not run Undercharged battery Charge the battery A new battery should have been charged for at least 18 hours before using the vehicle for the first time After first time use recharge the battery for at least 14 hours after each use Never charge the battery longer than 30 hours Check all connectors Make sure the charger connector is plugged into the battery and that the charger is plugged into the wall Make sure power flow to the wall outlet is ON Charger is not working There is no sure way to tell if your charger is working unless you have a volt meter If you suspect there is a problem with your charger contact your local Power Wheels authorized service center They can test your charger for you Tripped thermal fuse The built in thermal fuse may trip and shut down operation of the vehicle if the vehicle is overloaded or the driving conditions too severe Once a fuse has tripped remove your foot from the pedal and wait 25 seconds before operating the vehicle again T
5. COM Stop the vehicle before switching direction Do not tow anything behind the vehicle or overload it Do not exceed the maximum weight capacity of 130 Ibs 59 kg K4563pr 0922 WARNINGS AND CAUTIONS B ELECTRICAL HAZARD N WARNING e Battery can fall out and injure a child if vehicle tips over Always use battery retainer e PREVENT FIRE Never modify the electrical system Alterations could cause a fire resulting in serious injury and could also ruin the electrical system Use of the wrong type battery or charger could cause a fire or explosion resulting in serious injury Use of Power Wheelse components in products other than Power Wheels vehicles could cause overheating fire or explosion e The battery must be handled by adults only The battery is heavy and contains sulfuric acid electrolyte Dropping the battery could result in serious injury e Never allow children to charge the battery Battery charging must be done by adults only A child could be injured by the electricity involved in charging the battery e Read the safety instructions on the battery e Examine the battery charger and their connectors for excessive wear or damage each time you charge the battery If damage or excessive wear is detected do not use the charger or the battery until you have replaced the worn or damaged part e HOT motors Handle carefully RIDING HAZARD N WARNING e Prevent Injuries and Deaths e Direct Adult Supervision
6. Required s Never Ride at Night e Keep Children Within Safe Riding Areas These areas must be away from swimming pools and other bodies of water to prevent drownings generally level to prevent tipovers away from steps steep inclines cars roads and alleys e Riding Rules Make sure children know and follow these rules for safe driving and riding Always sit on the seat Always wear shoes Only 2 two riders at a time N CAUTION e In the unassembled state this package contains small parts Adult assembly is required e Use the charger in dry locations only K4563pr 0922 3 Cc PARTS e f you experience a problem with this product or are missing a part please call us at 1 800 348 0751 rather than return this product to the store e Please identify all parts before assembly and save all packaging material until assembly is complete to ensure that no parts are discarded e Metal parts have been coated with a lubricant to protect them during shipment Wipe all metal parts with a paper towel to remove any excess lubricant Steering Wheel Cap Backpack Sport Bar Support 2 Holder Long Seat Belt Strap ie Short Seat Belt Strap 2 TT Steering Column Door Hinge 2 Left and Right Left and Right K4563pr 0922 NN 8 x 1 Screw 6 CND 12 Volt Charger 10 x 34 Screw 23 SA Taillight Lens Set Taillight Housing Set 5 32 x 11 2 Pin 1
7. into the shifter box to lock out high speed To Drive e Make sure the shifter is in the high speed lt a position Hl e Press down on the foot pedal E The vehicle goes forward at a maximum of 5 mph J Help your child practice steering to learn how far and how quickly to turn the steering wheel when driving forward in high speed 2 1 K4563pr 0922 FM RADIO DIGITAL CLOCK USE L O cp1 MIP By a A 03 14 Main Reset Power Volume e Press the power button o e to turn the radio on or off e Turn the volume dial to adjust to a comfortable listening level Hint The FM Radio will turn off automatically after about one hour of non use FM Radio e Press the scan button Q to find a station e Press the scan button Q again to go to the next station e To reset the radio to the first station press the scan reset button 3 e FM Radio reception varies from area to area If the tuned station is lost due to poor reception the radio automatically scans to the next Station with good reception Hint Each time power is turned off and back on the FM Radio will reset to the first station IMPORTANT If the FM Radio functions erratically press the main reset button with the point of a pen or similar object K4563pr 0922 Evi VEHICLE CARE LIMITED WARRANTY O e Check all screws cap nuts and their protective coverings regularly and tighten as required Check plastic parts on a regular basis fo
8. operating instructions before using your vehicle Keep are available to take your call in English or French Habla this manual for future reference as it contains important Espa ol Si usted tiene alguna pregunta necesita asistencia information llame gratis 1 800 348 0755 para los Estados Unidos Tenemos e This vehicle is designed for use on concrete grass asphalt and representantes que hablan espanol para atender su llamada other hard surfaces on generally level terrain and by children For your convenience Power Wheels maintains an 3 years of age and older independently owned and operated Authorized Service e This vehicle has been pre set so it will only operate in low Center Network with more than 300 authorized service centers speed See the instructions on page 21 to remove the high nationwide Our authorized service centers will repair or replace speed lock out screw parts under warranty at no extra charge and can perform non e Use this vehicle ONLY outdoors Most interior flooring can warranty repairs for a minimal charge To find the authorized be damaged by riding this vehicle indoors Fisher Price will service center nearest you please visit us on line at ee www powerwheels com or call 1 800 348 0751 not be responsible for damage to the floor if the vehicle is gt used indoors e To register your vehicle please visit us on line at e To prevent damaging the motors and gears teach your child to MA HOWE RMIEEIS
9. x 0 O a oan a LY N SN GR CRS oa BATTERY INSTALLATION H IMPORTANT Use only a Power Wheels 12 volt lead acid rechargeable battery Use of any other battery will damage your vehicle Make sure that you charge the battery for at least 18 hours using the enclosed Power Wheels 12 volt Motor Harness charger before operating your vehicle for the first time Connector Charge the battery for at least 14 hours after each use of the vehicle Never charge the battery longer than 30 hours Failure to follow these instructions may damage your battery and will void your warranty Battery Compartment e Turn the hood latches a 4 turn e Lift the hood to access the battery compartment Power Wheels 12 Volt Battery e Lower the hood and secure the hood latches e Lift and pull the battery retainer forward e Place the battery in the battery compartment and release the battery retainer K4563pr 0922 BATTERY CARE AND DISPOSAL Care lf a battery leak develops avoid contact with the leaking acid and place the damaged battery in a plastic bag See information below for proper disposal lf acid comes in contact with skin or eyes flush with cool water for at least 15 minutes and call a physician lf acid is internally ingested give water milk of magnesia or egg whites immediately Never give emetics or induce vomiting Call a physician e Charge a new batter
10. 2 two riders at a time A child who is not sitting on the seat or who is standing on the vehicle could fall off cause a tip over or block the driver s view A child could be Seriously injured 4 Do not allow any child to drive the vehicle in the street or near moving motorized vehicles 9 Do not allow any child to drive near bodies of water Such as pools or creeks obstructions Such as furniture low tree limbs or play equipment or drop offs Such as stairs or decks 6 Do not allow any child to drive the vehicle in the dark A child could encounter unexpected obstacles and have an accident Operate the vehicle only in the daytime or a well lit area 7 Do not allow your child to drive on sloped or inclined surfaces Restrict your child s driving to generally level ground ONLY 8 Do not allow your child to drive down or across a steep slope The vehicle may gain unsafe speed even if the pedal is released to stop The vehicle may tilt and tip over The wheels could lose traction causing the vehicle to slip 9 Do not allow your child to drive up steep inclines The motor may stop and the vehicle could roll backwards at an unsafe speed 10 Never put anything near any moving parts Rotating parts such as motors gear boxes and wheels can snag fingers hair etc Causing serious injury Do not allow operation of the vehicle when it is on its side or in an upside down position Do not operate the vehicle near f
11. PREVENT FIRE Never modify the electrical system Alterations could cause a fire resulting in serious injury and could also ruin the electrical system Use of the wrong type battery or charger could cause a fire or explosion resulting In serious injury Use of Power Wheels components in products other than Power Wheels vehicles could cause overheating fire or explosion The battery must be handled by adults only The battery is heavy and contains sulfuric acid electrolyte Dropping the battery could result in serious injury Never allow children to charge the battery Battery charging must be done by adults only A child could be injured by the elec tricity involved in charging the battery Read the safety instructions on the battery Examine the battery charger and their connectors for excessive wear or damage each time you charge the battery If damage or excessive wear is detected do not use the charger or the battery until you have replaced the worn or damaged part N CAUTION Use the charger in dry locations only About Thermal Fuses Your Power Wheels 12 volt battery is equipped with a built in thermal fuse The thermal fuse is a self resetting safety device which automatically trips and shuts down operation of the vehicle if the vehicle is overloaded or the driving conditions too severe Once a fuse has tripped remove your foot from the pedal and wait approximately 25 seconds bef
12. are tight Contact your local Power Wheels authorized service center for diagnosis and repair Contact your local Power Wheels authorized service center for diagnosis and repair Teach your child to stop the vehicle before switching direction Contact your local Power Wheels authorized service center for diagnosis and repair No action required If your charger does not get warm during use it does not mean that it is not working properly No action required If your battery does not make noise or swell slightly during charging it does not mean that it is not accepting the charge PROBLEMS AND SOLUTIONS GUIDE PROBLEM POSSIBLE CAUSE SOLUTION FM Radio does not function at all Power is off Power automatically turns off after about one hour of non use Press the power button oO to turn it back on C batteries are weak or dead Replace all four batteries with new C LR14 alkaline batteries FM Radio station Poor reception You may find better reception of a particular station in a changes automatically different location Power was turned off and the radio Use the scan button to reset to your favorite station reset back to the first station FM Radio functions erratically Electronic lock up Press the main reset button on the front of the unit with the point of the pen or similar object ICES 003 This Class B digital apparatus complies with Canadian ICES 003 Operation is subject to the following two co
13. attery needs charging Be sure to charge the battery after each use Battery is old and will not accept full charge Even with proper care a rechargeable battery does not last forever Average battery life is 1 to 3 years depending on the vehicle use and use conditions Replace the battery with a new Power Wheels 12 volt rechargable battery Do not substitute parts Vehicle is overloaded Make sure you do not overload the vehicle by allowing more than one rider at one time by exceeding the 130 Ib 59 kg maximum weight capacity or by towing objects behind the vehicle Driving conditions are too stressful Use only on generally level ground K4563pr 0922 PROBLEMS AND SOLUTIONS GUIDE PROBLEM Vehicle runs in low speed but does not run in high speed Please note The vehicle is designed to operate in low speed only in reverse When the foot pedal is pressed one rear wheel spins Sometimes the vehicle doesn t run but other times it does When the go foot pedal is pressed the vehicle won t run without a push Battery s thermal fuse constantly trips but the vehicle is not overloaded nor the driving conditions too severe Loud clacking or grinding noise from a motor gearbox Charger gets warm during use Battery makes a sizzling or gurgling noise when charging K4563pr 0922 POSSIBLE CAUSE High speed lock out not disconnected Operation of vehicle in low speed Loose wire or connector Motor or elec
14. dge of e Using safety scissors cut the plastic tie holding Map in the clip the seat into the slots in the foot well wall EN e Fit the clip to the windshield e Push down firmly on the edge of the seat above each tab to e Insert a 10 x 3 4 screw into the clip and tighten snap the tabs into the slots EJ e Rotate the back of the seat down E to snap the seat back tabs into the slots in the vehicle Push down firmly on the seat back e Replace Map into the clip Note to Retailer Do not remove the plastic tie Simply remove Map from the clip Assemble the clip to the windshield and replace Map in the clip e Insert a 10 x 3 4 screw into the rear edge of the seat Tighten the screw e Using safety scissors cut the plastic tie holding Backpack in the holder Remove Backpack from the holder Note to Retailer Do not remove the plastic tie Simply lift Backpack from the holder and assemble the holder to the top edge of the vehicle Replace Backpack in the holder e Fit the holder to the top edge of the vehicle as shown e Insert two 10 x 3 4 screws into the holder Tighten the screws K4563pr 0922 13 F ASSEMBLY Supports 33 harman E e Fit a support to one side of the sport bar e Insert a 8 32 x 1 625 screw through the support the sport bar and out through the support e Fit an 8 acorn lock nut to the end of the screw e While holding the acorn lock nut with an adjustable wrench or pliers tighten t
15. down operation of the vehicle if the vehicle is overloaded or the driving conditions too severe Once a fuse has tripped remove your foot from the pedal and wait 25 seconds before operating the vehicle again To avoid repeated automatic shutdowns do not overload the vehicle by exceeding the 130 Ib 59 kg maximum weight capacity or by towing anything behind the vehicle Do not drive up hills or run into fixed objects which can cause the wheels to stop spinning while power is still being supplied to the motors If a thermal fuse continually trips contact your local Power Wheels authorized service center K4563pr 0922 PROBLEMS AND SOLUTIONS GUIDE PROBLEM POSSIBLE CAUSE SOLUTION Short run time Less than Undercharged battery Charge the battery A new battery should have been charged for at least 1 3 hours per charge 18 hours before using the vehicle for the first time After first time use recharge the battery for at least 14 hours after each use Never charge the battery longer than 30 hours Check all wires and connectors Make sure the charger connector is plugged into the battery and that the charger is plugged into the wall Make sure power flow to the wall outlet is ON Overcharged battery Do not charge the battery longer than 30 hours If you suspect that your battery is damaged as a result of overcharging contact your local Power Wheels authorized service center They can test your battery for you Ba
16. e each time you charge the battery lf damage is detected do not use the charger or the battery until you have replaced the worn or damaged part Disposal x X e Your Power Wheels battery is a non spillable sealed lead acid battery It must be recycled or disposed of in an environmentally sound manner e Do not dispose of a lead acid battery in a fire The battery may explode or leak e Protect the environment by not disposing of this product with household waste 2002 96 EC Check your local authority for recycling advice and facilities Europe only e Do not dispose of a lead acid battery in your regular household trash The incineration landfilling or mixing of Sealed lead acid batteries with household trash is prohibited by law in most areas e Return an exhausted battery to a federal or state approved lead acid battery recycler such as a Power Wheels authorized service center or a local seller of automotive batteries For the authorized service center location nearest to you please visit us on line at www powerwheels com or call 1 800 348 0751 Contact your local waste management officials for other information regarding the environmentally sound collection recycling and disposal of lead acid batteries If you live in the State of Florida or the State of Minnesota it is prohibited by law for anyone to throw away lead acid batteries in the municipal waste stream 19 K4563pr 0922 SAFE DRIVING RULES J RIDING HAZARD
17. end of the door the screw holes aligned as shown Hint Each hinge is designed to fit one way If the hinge does e Insert two 8 x 1 screws through the taillight lens housing not fit try the other hinge and into the vehicle as shown Tighten the screws e Insert three 10 x 3 4 screws into the hinge and tighten e Repeat this procedure to attach the other taillight assembly e Repeat assembly steps 29 and 30 to assemble the other door and hinge e Fit a door into the groove on the side of the dash Hint Each door is designed to fit one way If the door does not fit try the other door K4563pr 0922 15 F ASSEMBLY DECORATION G e Before applying the labels wipe the surface of the vehicle with a clean dry cloth to remove any dust or oils e Place the labels exactly as shown in the illustrations For best results avoid repositioning a label once it has been applied to the vehicle e After applying a label rub the label firmly with a clean dry cloth to make sure the label is adhered to your vehicle Start at the center of a label and smooth towards the outer edges to remove air bubbles Loosen These Screws SS a a y i ale C et og f y 5 eep E Compartment Door e Locate the FM Radio on the dash e Loosen both screws in the battery compartment door e Remove the battery compartment door e Insert four new C LR14 alkaline batteries Hint We recommend using alkaline batter
18. er causes polish applied to a soft cloth Do not use automotive wax Do not arising out of defects in materials or workmanship not use soap and water or spray the vehicle with a hose Evidence of any attempt at consumer repair will void this e To ensure that your vehicle stays in good operating order we warranty THIS WARRANTY DOES NOT COVER AND IS recommend that you periodically have your vehicle checked by INTENDED TO EXCLUDE ANY LIABILITY ON THE PART OF a Power Wheels authorized service center For the location of POWER WHEELS WHETHER UNDER THIS WARRANTY OR the authorized service center nearest you please visit us on line IMPLIED BY LAW FOR ANY INDIRECT OR CONSEQUENTIAL at www powerwheels com or call 1 800 348 0751 DAMAGES FOR BREACH OF WARRANTY SOME STATES DO NOT ALLOW THE EXCLUSION OR LIMITATION SO THIS LIMITATION MAY NOT APPLY TO YOU Should you need service or assistance with your vehicle during the warranty period do not return the vehicle to the FCC STATEMENT store Power Wheels has provided a nationwide network of authorized service centers If there is not an authorized service center in your area please visit us on line at United States Only www powerwheels com or call Consumer Relations for This equipment has been tested and found to comply with information 1 800 348 0751 the limits for a Class B digital device pursuant to Part 15 This warranty gives you specific legal rights and you may of the FCC Rules These l
19. he screw e Repeat this procedure to fasten the other support to the sport bar e Fit the light covers to the top of the sport bar as shown e Insert a 10 x screw into each light cover Tighten the screws Side Fender e Fit the sport bar assembly into the holes in the top side of the vehicle e Push down firmly on a sport bar support while pulling up on the side fender to fit the sport bar into the vehicle e Repeat this procedure on the other side of the vehicle pp Sa 7 Vehi of _ il Vehicle Neo NM BOTTOM VIEW ID e Turn the vehicle on its side e Insert two 10 x screws into the holes behind the rear wheels in the underside of each rear wheel well through the vehicle and into the ends of the sport bar Tighten the screws e Next insert two 10 x screws into the holes in front of the rear wheels in the underside of each wheel well through the vehicle and into the end of the sport bar Tighten the screws K4563pr 0922 ASSEMBLY F Taillight Housing 5 D me gt 8 x 1 Screws 37 EE g e Turn the vehicle upright e Using safety scissors remove the taillight lenses and the taillight housings from the plastic connectors Dispose of the plastic connectors e Face the rear of the vehicle e Fit a taillight lens inside a taillight housing e Position the taillight housing with lens against the vehicle with e Fit a hinge over the top
20. ies for longer battery life e Replace the battery compartment door and tighten the screws e When sounds become faint or stop it s time for an adult to change the batteries Please refer to page 22 for general information and tips for use of the FM Radio X e Protect the environment by not disposing of this product with household waste 2002 96 EC Check your local authority for recycling advice and facilities Europe only C LR14 Battery Safety Information In exceptional circumstances batteries may leak fluids that can cause a chemical burn injury or ruin your product To avoid battery leakage e Do not mix old and new batteries or batteries of different types alkaline standard carbon zinc or rechargeable nickel cadmium e Insert batteries as indicated inside the battery compartment 7 e Remove batteries during long periods of non use Always remove exhausted batteries from the product Dispose of batteries safely if Do not dispose of product in a fire The inside batteries may explode or leak e Never short circuit the battery terminals e Use only batteries of the same or equivalent type as recommended e Do not charge non rechargeable batteries e Remove rechargeable batteries from the product before charging e lf removable rechargeable batteries are used they are only to be charged under adult supervision 16 K4563pr 0922 FRONT LEFT SIDE FRONT RIGHT SIDE 2 0 q
21. imits are designed to provide also have other rights which may vary from state to state reasonable protection against harmful interference in a PLEASE SAVE YOUR ORIGINAL SALES RECEIPT residential installation This equipment generates uses and can radiate radio frequency energy and if not installed and used in accordance with the instructions may cause harmful interference to radio communications However there is no guarantee that interference will not occur in a particular installation If this equipment does cause harmful interference to radio or television reception which can be determined by turning the equipment off and on the user is encouraged to try to correct the interference by one or more of the following measures e Reorient or relocate the receiving antenna e Increase the separation between the equipment and receiver e Consult the dealer or an experienced radio TV technician for help Note Changes or modifications not expressly approved by the manufacturer responsible for compliance could void the user s authority to operate the equipment This device complies with Part 15 of the FCC Rules Operation is subject to the following two conditions 1 this device may not cause harmful interference and 2 this device must accept any interference received including interference that may cause undesired operation 23 K4563pr 0922 PROBLEMS AND SOLUTIONS GUIDE IMPORTANT If you experience a problem with your vehicle
22. lammable vapors gasoline paint thinner acetone liquid wax etc The vehicle s electrical switches like most electrical switches emit an internal spark when first turned on or turned off The presence of flammable liquids or vapors could cause an explosion or a fire Keep all flammable products in tightly sealed containers and away from the vehicle 12 Do not allow a child to operate the vehicle without direct adult supervision To prevent unsupervised use of the vehicle disconnect the motor harness from the battery when the vehicle is not in use Ss mk K4563pr 0922 20 VEHICLE OPERATION IMPORTANT Use this vehicle ONLY outdoors Most interior floor ing can be damaged by riding this vehicle indoors Fisher Price will not be responsible for damage to the floor if the vehicle is used indoors Beginner Use Low Speed Drive As assembled your vehicle is ready to roll in low speed 21 2 mph maximum It has been pre set so it will only operate in low speed After your child has mastered the basic skills of driving and understands the rules for safe driving it s time to remove the high speed lock out screw to allow the vehicle to Operate in low or high speed See the instructions on this page to remove the high speed lock out screw e Make sure the shifter is in the low speed position El e Press down on the foot pedal Ej The vehicle goes forward at a maximum of 21 2 mph J Help your child practice steering t
23. n Chanter sete cf bho een cent een 02 Meta aide A nba gue ak aed okt 1 PASSO IT ULAN 8 UI Dc ACE SE 16 BW Baten n Tea MAUI O 18 defy Garesandh SposSda oo 19 Wy cS be DIVNORUIES Sets eee fat sate a ne ld octet cra fla nt erie intent tematic tateta at A eae on eee 20 BR HN CHIGIELO DS ee wo 2 0670 mation Ae 21 22 Venice Gare emcee ae anes eRe RO pat NA ar eee Tan Ye oe Rae oe eae a Re Re 23 NOC SIEMON aa A E E Sect a a Ret cee Veal a a S 23 Oime d Nan nae a a a a a a E A E E 23 BODIES Ind O IDNA LES GU LOG ata ceaseless NE cect Ae eae tcl E Sees ed een eae ahaha tee ot 24 IMPORTANT INFORMATION e Your new vehicle requires adult assembly Please set aside at e This vehicle has adjustable play seat belts Please note that the least 60 minutes for assembly adjustable seat belts are designed to be a play feature and do e You must charge your battery for 18 30 hours before you use not function as protective safety restraints your vehicle for the first time We recommend that you start e f you have any questions about your Power Wheels vehicle charging your battery before beginning assembly Please see please call our toll free service lines at 1 800 348 0751 from Battery Charging beginning on page 7 for detailed instructions 9 AM to 7 PM EST Monday through Friday and 11 AM to 5 e Read this manual carefully for important safety information PM EST Saturday Trained customer service representatives and
24. nd of the steering column up through the hole in the vehicle frame and the vehicle floor and out through e Before applying the labels wipe the surface of the vehicle with a clean dry cloth to remove any dust or oils e toe mihe dih e Place the labels exactly as shown in the illustration e While holding the steering column in place turn the e For best results avoid repositioning a label once it has been vehicle upright applied to the vehicle Key Assembly Steering Column Steering Wheel e Position the steering wheel so that the large opening and the tab on the steering wheel stem are both UP e Fit the steering wheel onto the steering column e Insert and snap the key assembly into the opening in the dash as shown K4563pr 0922 9 F ASSEMBLY Ja x 1 Pin PN End of e Insert the ss x 11 2 pin through the hole in the end of the Steering column e Lower the steering column so that the pin fits inside the center of the steering wheel e Insert a 8 x 5 s screw through the hole in the end of the Steering column e Fit a 8 lock nut on the end of the screw and tighten e While holding the lock nut with an adjustable wrench or pliers tighten the screw e Turn the vehicle upright NN Lens Guard Wide Tab e Fit the steering wheel cap into the center of the steering wheel e Insert two 8 x 1 screws and tighten End of Steering Column Steering Rod Hole e Fit the wide no
25. nditions 1 this device may not cause harmful interference and 2 this device must accept any interference received including interference that may cause undesired operation NMB 003 Cet appareil num rique de la classe B est conforme la norme NMB 003 du Canada L utilisation de ce dispositif est autoris e seulement aux conditions suivantes 1 il ne doit pas produire de brouillage et 2 Putilisateur du dispositif doit tre pr t accepter tout brouillage radio lectrique re u m me si ce brouillage est susceptible de compromettre le fonctionnement du dispositif K4563pr 0922 Before first time use you must charge the battery 18 hours Charge the battery immediately after each use Charge the battery once a month even if the vehicle is not used or stored Do not return your vehicle to the store We re a toll free phone call away and we can help If you are missing parts or need assistance please call 1 800 348 0751 Or contact your local independently owned and operated Power Wheels Authorized Service Center For the location nearest you visit us on line at www powerwheels com lt gt Jeep and the Jeep grille design are registered trademarks of DaimlerChrysler Jeep Wrangler and its trade dress are used under license DaimlerChrysler Corporation 2004 2008 Viacom International Inc Nickelodeon Nick Jr Dora the Explorer and all related titles logos and characters are trademarks
26. o learn how far and how quickly to turn the steering wheel when driving forward in low speed To Back Up IMPORTANT To avoid damaging the motors and gears stop the vehicle before shifting from forward to reverse e Once your child is completely comfortable with operating the vehicle in the forward mode introduce reverse e Make sure the shifter is in the reverse position El e Press down on the foot pedal El The vehicle will go in reverse at a maximum of 21 2 mph IE The vehicle is designed to Operate in low speed only in reverse Help your child practice Steering to learn how far and how quickly to turn the steering wheel when driving in reverse e Your vehicle has a patented electronic braking system that automatically stops the vehicle when your child s foot lifts from the pedal Make sure your child is comfortable with steering the vehicle and automatically knows how to stop Advanced Use High Speed Drive e Before you disconnect the high speed lock out make sure your child knows how to steer how to start and stop the vehicle and knows the rules for safe driving When the high speed lock out is disconnected the vehicle can be driven forward in low speed 21 2 mph maximum or high speed 5 mph maximum e Make sure the shifter is in the reverse position e Loosen and remove the screw in the shifter box e Replace the lock out screw into the hole in the shifter for future use It can be re inserted
27. o avoid repeated automatic shutdowns do not overload the vehicle by exceeding the 130 Ib 59 kg maximum weight capacity or by towing anything behind the vehicle Do not drive up hills or run into fixed objects which can cause the wheels to stop spinning while power is still being supplied to the motors If a thermal fuse continually trips contact your local Power Wheels authorized service center Loose wire or loose connectors Check all wires and connectors Make sure the motor harness connector is plugged into the battery and that there are no loose wires around the motors Dead battery If your battery is old or if you have not followed Battery Care instructions your battery may be dead If you are unsure whether or not the battery is dead you can have it tested at your local Power Wheels authorized Service center Electrical switch damage The electrical switches can become corroded due to exposure to water or moisture or can jam due to loose dirt sand or gravel Contact your local Power Wheels authorized service center for diagnosis and repair Motor damage Contact your local Power Wheels authorized service center for diagnosis and repair Vehicle was running but Loose wire or loose connectors Check all wires and connectors Make sure the motor harness connector suddenly stopped is plugged into the battery and that there are no loose wires around the motors Tripped thermal fuse The built in thermal fuse may trip and shut
28. of Viacom International Inc Fisher Price Inc a subsidiary of Mattel Inc East Aurora New York 14052 U S A 2008 Mattel Inc All Rights Reserved and designate U S trademarks of Mattel Inc PRINTED IN MEXICO K4563pr 0922
29. ore operating the vehicle again To avoid repeated automatic shut downs do not overload the vehicle by exceeding the 130 Ibs 59 kg maximum weight capacity or by towing anything behind the vehicle Avoid severe driving conditions such as driving up slopes or running into fixed objects which can cause the wheels to stop spinning while power is still being supplied to the motors and make sure your child stops the vehicle before switching direction lf a thermal fuse in a battery continually trips under normal driving conditions please contact your local Power Wheels Authorized Service Center For the location of the Authorized Service Center nearest to you visit us on line at www powerwheels com or call 1 800 348 0751 Important Notes e Your new battery must be charged for at least 18 hours before you use it in your vehicle for the first time e We recommend that you start charging your battery before beginning assembly of your new vehicle e The battery must be upright while charging e The charger is not a toy e Do not short circuit the battery e You do not need to remove the battery from your vehicle to recharge it e Before charging the battery examine the battery case for cracks and other damage which may cause sulfuric acid electrolyte to leak during the charging process If damage is detected do not charge the battery or use it in your vehicle Battery acid is very corrosive and can cause severe damage to surfaces i
30. r cracks or broken pieces Bumper to Bumper Limited Warranty e During snowy or rainy weather the vehicle should be stored _ inside or under a protective cover Remember to charge the One year limited warranty from the date of battery at least once per month while your vehicle is not in purchase on the Power WheelSe vehicle regular use B Six month limited warranty on the 12 volt battery e Avoid operating the vehicle in wet or snowy conditions and do not spray the vehicle with a hose Do not wash the vehicle with For the original purchaser this one year limited warranty soap and water Water or moisture in the motors or electrical covers the Power Wheels ride on vehicle purchased switches can cause them to corrode and could cause switch or from Power Wheels against defects in materials and motor failure workmanship The six month limited warranty applies e Avoid operating the vehicle on sand loose dirt or gravel Sand only to the 12 volt battery included by Power Wheels loose dirt or gravel in the motors or electrical switches can with the original purchase of the vehicle This warranty cause them to jam and could cause switch or motor failure covers normal use and does not cover the Power Wheels e The vehicle can be wiped down with a soft dry cloth For a vehicle or battery if damaged by unreasonable use neglect shiny finish you can wipe plastic parts with a non wax furniture accident abuse misuse improper service or oth
31. r end of a short seat belt strap through the slot e Fit and hold the brush guard against the front end of the vehicle near the outer edge of the seat Make sure the side of the seat Hint Using the end of a Phillips screwdriver poke a hole in the belt with the fastener faces the outer edge of the seat thin plastic covering over the lower holes in the brush guard e Pull the short seat belt strap completely through the slot until the e Insert two 10 x 34 screws through the lower holes in the last T loop at the opposite end of the belt catches against the slot brush guard and into the vehicle Tighten the screws You will pull one T loop through the slot e Repeat this procedure to assemble the other short seat belt strap Long Seat Belt Strap N Fastener End D 1 4 17 18 e nsert each fastener end of the long seat belt strap through a slot in the center of the seat Make sure the fasteners face the outer edge of the seat e Pull each side of the long seat belt strap evenly through the slots Make sure to pull each T loop through a slot e Turn the seat upright e Fit two spacers between the upper holes of the brush guard and the front end of the vehicle EN e Insert two 8 x 4 screws through the upper holes in the brush guard through the spacers and into the front end of the vehicle E Tighten the screws 12 K4563pr 0922 ASSEMBLY F Seat Back e With the seat at an angle insert the tabs on the front e
32. t contacts e Do not charge the battery on a surface such as a kitchen counter top which could be damaged by the acid contained inside the battery Take precautions to protect the surface on which you charge your battery e Use only a Power Wheels 12 volt charger with 12V connector input 120 VAC 60 Hz with an output of 12 VDC 1200 mA to charge your Power Wheels 12 volt battery Adults Note Regularly examine the charger for damage to the cord plug housing or other parts that may result in the risk of fire electric shock or injury In the event of any damage do not use the charger until the damage has been properly repaired Please call 1 800 348 0751 e f your battery is old and will not accept a charge do not leave it in the vehicle Always remove a dead battery from the vehicle K4563pr 0922 F ASSEMBLY N WARNING Children can be harmed by small parts sharp edges and sharp points in the vehicle s unassembled state or by electrical items Care should be taken in unpacking and assembly of the vehicle Children should not handle parts including the battery or help in assembly of the vehicle E BATTERY CHARGING ES 12V Battery Bateria de 12V Batterie de 12 V N Charger Connector Conector del cargador Connecteur du d chargeur e Plug the charger connector into the battery EN e Plug the charger into a standard wall outlet E Motor l Harness Notes gt Connec
33. tch in the side of a headlight lens under the wide tab on a lens guard e Press firmly on the inside of the headlight lens to snap it into e Turn the vehicle on its side the lens guard e Insert the end of the steering column through the hole In the e Repeat this procedure to assemble the other headlight lens to steering rod the remaining lens guard e Place a 3 s washer on the end of the steering column K4563pr 0922 ASSEMBLY e Fit a lens assembly tab into the headlight slots in the grille e Press firmly to snap the lens assembly into the grille e Repeat this procedure to snap the other lens assembly into the grille e Insert the tabs on the hood into the slots in the front end of the vehicle e Pull the hood forward and lower it closed Windshield e Insert a hood latch into one of the slots in the vehicle near the hood area e Twist the base of the hood latch 1 4 turn to secure it in the vehicle e Repeat this procedure on the other side of the hood area to attach the other hood latch to the vehicle e Position the windshield so that the molded detail on the wipers face the front end of the vehicle e Insert and snap the two large tabs on the windshield into the large slots in the dash e Pull up on the windshield to be sure it is secure K4563pr 0922 11 F ASSEMBLY Short Seat Belt Strap T Loop Pull through slot Fastener End e Turn the seat upside down e Insert the fastene
34. tor If power flow to the wall outlet is controlled by a switch make Ht LE Wire sure the switch is ON Use the charger only in a wall outlet Do not plug the charger into a ceiling outlet The power indicator on the charger does not indicate the charge status of your battery The power indicator allows you to see that there is power from the wall outlet to the charger e Before first time use charge the battery for at least 18 hours Never charge the battery longer than 30 hours 7 e Recharge the battery for at least 14 hours after each use of e Position the dash on the vehicle your vehicle Do not charge the battery longer than 30 hours e Make sure the motor harness connector wire is through the e Once the battery is charged disconnect the battery connector groove In the dash from the charger connector Unplug the charger from the wall e Insert five 10 x34 screws into the dash tabs and tighten outlet The battery is now ready to be installed in your vehicle Please see the Battery Installation section on page 18 for detailed instructions on installing your battery If your battery is already installed in your vehicle simply re connect the motor harness connector to the battery S K4563pr 0922 ASSEMBLY F Ml iS E BOTTOM VIEW e Wipe the steering column with a paper towel to remove any excess lubricant e Turn the vehicle on its side e Insert the straight e
35. trical switch damage Loose wire or connector Dead Spot on motor Damaged battery Child is switching between FORWARD and REVERSE without stopping Broken gears It is normal for some chargers to get warm during use and is not reason for concern It is normal for some batteries to make noise and swell slightly while charging and is not reason for concern SOLUTION The vehicle was pre set to run only in low speed To allow the vehicle to run in low and high speed you must disconnect the High Speed Lock Out Follow the instructions on page 22 to remove the High Speed Lock Out screw It is possible that only one rear wheel may spin when both rear wheels are raised off the ground and the vehicle is in low speed This does not necessarily indicate a problem Check for proper operation of the drive system by raising the rear wheels off the ground and pressing the foot pedal If only one rear wheel spins carefully press your hand on the spinning wheel to slow it down The other rear wheel should begin to spin If the other rear wheel does not begin to spin there may be a problem with the vehicle Contact your local Power Wheels authorized service center for diagnosis and repair Check all wires around the motors and all connectors to make sure they are tight Contact your local Power Wheels authorized service center for diagnosis and repair Check all wires around the motors and all connectors to make sure they
36. ttery is old and will not accept full charge Even with proper care a rechargeable battery does not last forever Average battery life is 1 to 3 years depending on vehicle use and use conditions Replace the battery with a new Power Wheels 12 volt rechargeable battery Do not substitute parts Tripped thermal fuse The built in thermal fuse may trip and shut down operation of the vehicle if the vehicle is overloaded or the driving conditions too severe Once a fuse has tripped remove your foot from the pedal and wait 25 seconds before operating the vehicle again To avoid repeated automatic shutdowns do not overload the vehicle by exceeding the 130 Ib 59 kg maximum weight capacity or by towing anything behind the vehicle Do not drive up hills or run into fixed objects which can cause the wheels to stop spinning while power is still being supplied to the motors If a thermal fuse continually trips contact your local Power Wheels authorized service center Vehicle runs sluggishly Undercharged battery Charge the battery A new battery should have been charged for at least 18 hours before using the vehicle for the first time After first time use recharge the battery for at least 14 hours after each use Never charge the battery longer than 30 hours Check all connectors Make sure the charger connector is plugged into the battery and that the charger is plugged into the wall Make sure power flow to the wall outlet is ON B
37. y for at least 18 hours before first use Never charge the battery longer than 30 hours Overcharging or undercharging the battery may shorten battery life and decrease vehicle running time e After the first charge recharge the battery for at least 14 hours after each use Never charge the battery longer than 30 hours Charge the battery after each use regardless of how long the vehicle was used e The battery must be upright while charging e Do not allow the battery to run down completely before charging e Charge the battery before storing the vehicle e Charge the battery at least once per month even if the vehicle has not been used e Leaving the battery in a discharged condition will ruin it e Always remove an exhausted battery from the vehicle Battery leakage and corrosion can damage the vehicle e Do not store the battery on a surface such as a kitchen counter top which could be damaged by the acid contained inside the battery Take precautions to protect the surface on which you store the battery e Do not store the battery in temperatures above 75 F or below 10 F e Use only a Power Wheels 12 volt battery Remember to charge the new battery for at least 18 hours before first use e Prevent the battery from moving freely inside the battery compart ment Always use the battery retainer to secure the battery in the battery compartment e Examine the battery charger and their connectors for excessive wear or damag
Download Pdf Manuals
Related Search