DEFY DHG 116 User's Manual
Contents
1. e The wall switch e The LPG cylinder and hose connections e Remember that you may be charged for a service call even during the warranty period if the fault is due to or caused by any of the above e If you have followed the instructions and still have a problem contact the near est Defy Service Centre They will be able to advise you on any aspect of the product or send a qualified technician to repair it Page 10 Service Centres If you have followed the instructions and still have a problem contact the nearest Defy Service Centre They will be able to advise you on any aspect of the product or send a qualified technician to repair it BLOEMFONTEIN CAPE TOWN DURBAN EAST LONDON JOHANNESBURG Commercial Head Office Administration Distribution National Groups Tel Sales Contracts and Credit POLOKWANE PORT ELIZABETH PRETORIA 160 Long Street Hilton Bloemfontein 9301 Tel 051 400 3900 Bloemfontein Service defy co za 5A Marconi Rd Montague Gardens 7441 Tel 021 551 8314 CapeTown Service defy co za 35 Intersite Avenue Umgeni Business Park Durban 4051 Tel 031 268 3300 Durban Service defy co za 16 Bowls Rd Arcadia East London 5201 Tel 043 743 7100 EastLondon Service defy co za Cnr Mimetes amp Kruger Sts Denver ext 12 Johannesburg 2094 Tel 011 621 0200 or 011 621 0300 Gauteng Service defy co za 87 Nelson Mandela Drive Superbia 0699 Tel 0152 92 1166 7 82. 9 Polokwane Service defy co za 112 Patterson Road North End Port Elizabeth 6001 Tel 041 401 6400 PortElizabeth Service defy co za Block A1 Old Mutual Industrial Park Cnr D F Malan Drive amp Moot Str Hermanstad 0082 Tel 012 377 0061 Pretoria Service defy co za OTHER AREAS ARE SERVICED BY OVER 200 AUTHORISED SERVICE AGENTS PLEASE CONSULT THE NEAREST REGIONAL DEFY SERVICE CENTRE FOR DETAILS Page 11 Warranty This certificate is issued by DEFY APPLIANCES LIMITED manufacturers of Defy and Ocean products hereinafter the Company to the original purchaser only of the appliance described on the certificate and shall constitute the only warranty given in respect of this appliance The Company warrants to the original purchaser that for a period of TWO YEARS from date of pur chase the appliance is free from defect under normal domestic use both in workmanship and mate rial subject to the following conditions 1 Repair or replacement of any part of this appliance found by the Company to be defective shall be at the election of the Company The Company reserves the right to effect such service through any of its Service Divisions or Authorised Service Dealers The cost of such service shall be borne by the Company in full provided that the appliance is located no further than 50 km from a Com pany Service Centre or an Authorised Service Dealer Where the appliance is located beyond the 50 km radius the purchase
3. t leave children unsupervised when the hob is in use Don t store items above the hob which are tempting to chil dren Don t sit or stand on the hob Don t use a pan large enough to cover two or more burners Don t use water to extinguish fat or oil fires Don t use the hob as a space heater or dryer Don t heat up any unopened cans or containers as internal pressure build up could cause these to explode Don t place flammable materials plastics cloth paper aero sols etc on or near the hob Don t use abrasive or aggressive chemical cleaners to clean any part of the hob Don t cover or obstruct any ventilation slots Do not cover the hob or burners with aluminium foil Don t use a steam cleaner to clean the hob Page 9 Technical specifications BURNER DATA BURNER TYPE PRESSURE INJECTOR GAS POWER Kw RECOMMENDED SAINTE DIAMETER sizes in mm kPa ABO an SUMPTION oh G30 G31 3 0 3 7 AURIEIARY D 55 NATURAL 2 0 feof SEMI RAPID 275 felon e RAPID 2100 NATURAL 2 0 In reference conditions gas temperature 15 C atmospheric pressure 101 32 kPa In compliance with burner and pot performance DIMENSIONS Length left to right 590mm Width front to back 510mm Depth from top of burners to bottom of base 85 Problem check e Do not attempt any repairs yourself e Before calling a service technician to assist with a problem please check e The mains distribution board
4. the hob for preparing food and use a deep pan large enough to cover the appropriate burner Always dry food thoroughly before placing it in hot oil or fat Frozen food in particular will spit and splatter if added too quickly Never fill the pan more than one third full of fat or oil and never heat fat or fry with a lid on the pan Do noat once This lowers the temperature of the oil or fat and results t fry too much food in fatty foods Do not leave hot fat or oil unattended If overheating occurs these could catch fire Page 6 In the event of a pan fire e Burns and injuries are usually caused by picking up the burning pan and rushing out side with it e Do NOT use water to extinguish an oil or fat fire e Switch off the electrical and gas supplies e Smother the flames with a blanket or damp cloth Cleaning General e Switch the electricity off at the wall socket and remove the plug before attempting any cleaning operation e Allow the burners to cool down before cleaning Never use sharp instruments abrasive cleaners chemical sprays wire wool acid or chlorine based cleaners or steam cleaners on any part of the hob Exterior e The pot supports on the hob may be removed to allow easy access to the hob panel e Wash the exterior pot supports and burner caps with hot soapy water e Rinse and dry e Acidic spills such as lemon juice should be cleaned as soon as possible as these tend to etch into metals i
5. INDEX 2 Introduction e Unpacking e Positioning Instructions for the installer e Electrical installation e LPG installation e Check for gas leaks Safety Compliance e Permanent installation e Installers details The control panel Operating the burners Flame failure and safety cut out Action in the event of a burn back Ventilation LPG gas hob Flame failure Action to be taken in the event of a burn back e Ventilation Maintenance and service Fitting the burner caps Minimum flame adjustment Important safety advice In the event of a pan fire In the event of a pan fire e Cleaning e General e Exterior e Control panel e Stainless steel model 8 Care guide for stainless steel 9 Important Do s and don ts 10 Technical specifications e Problem check 11 Service centres 12 Warranty DEFY You can rely on Defy To simplify Owner s Manual DHG 116 Black enamel DHG 117 Stainless steel GAS HOB The Manufacturer strives for continuous improvements For this reason the text and illustrations in this book are subject to change without notice www defy co za Part Number 066 986 Introduction Congratulations on the purchase of this quality product We trust that you will enjoy many years of trouble free use Please read these instructions carefully before use as they will provide you with infor mation on how to operate and care for your hob in order that you gai
6. by routine clean ing For slight scratches use a nylon pad loaded with an iron free abra sive polishing compound Rub in the direction of the original texture Follow up with routine cleaning For deep scratches use a coarser abrasive initially and follow up as for light scratches If possible use warm to hand hot water A 5 addition of ammonia is beneficial Minimize re occurrence by apply ing a wax or silicone based house hold polish to the clean dry sur face Apply whenever necessary Repeat several times rather than resorting to a single aggressive cleaning method Deep scratches will be difficult to remove completely Do not use steel wool or metal scourers unless they are made from stainless steel It must be appreciated that some of the above suggested procedures will alter the surface appearance of the treated area They should therefore only be applied with due consideration and care Page 8 Important Do s and Don ts Do have the hob installed by a qualified technician Do read all the instructions before using the hob Do keep children away from the hob when in use as sur faces can get extremely hot Do switch the electricity off before cleaning any part of the hob Do remember to switch the hob off after cooking is com pleted Do keep ventilation slots free of any obstructions Do allow the hob to cool down before cleaning Do refer servicing to qualified service technicians Don
7. f left unattended e Never wash the burner caps in a dishwasher Control panel e Do not use oven cleaners aerosols scouring pads or abrasive cleaners e Wipe the control panel with a damp cloth and dry with a dry lint free cloth e Do not attempt to remove any of the control knobs Stainless Steel model e Frequent cleaning is recommended rather than an occasional aggressive clean e Routine cleaning will preserve the corrosion resistance and appearance of the stainless steel for many years e Clean the stainless steel as often as necessary when noticeably dull or dirty and use the simplest cleaning method that will effectively do the job e Use clean water or a mild detergent solution applied with a soft cloth or sponge Rinse well and wipe dry Page 7 Care guide for Stainless Steel model CONDITION ACTION COMMENTS Requires routine Mild detergent solution applied Finger prints Stubborn stains and discolouration Grease and fat splatter Scratches on the brushed finish with soft sponge or cloth Rinse and wipe dry Pre treat finger marks with alcohol or an organic solvent Follow immediately with routine cleaning Wipe with a little baby oil and a soft lint free cloth Buff to shine Use a little Ceran cleaning paste available from Defy Service Centres Rinse and dry Wipe off excess with a soft cloth or paper towel Use a water borne de greasing agent dishwashing liq uid Follow up
8. lled in below INSTALLER S NAME INSTALLER S REGISTRATION HAVE YOU RECEIVED A NUMBER WRITTEN CERTIFICATE The control panel LEFT FRONT LEFT BACK RIGHT FRONT RIGHT FRONT BURNER BURNER BURNER BURNER Operating the burners e To switch a burner on push down slightly on the relevant control knob and then turn it to the left counter clockwise The large flame symbol on the knob indicates the maximum and the small flame the lowest setting e The gas will then be lit automatically e Release the knob 3 to 5 seconds after the flame is observed at the burner e Ifthe flame fails to continue burning please repeat the sequence Important Flame failure safety cut out e Should the flame extinguish for whatever reason the flow of gas to the burner will automatically be terminated Action to be taken in the event of a burn back e In the event of a burn back where the flame burns back into the jet immediately turn off the control to the affected burner e Wait a few minutes and relight the burner in the normal manner e Ifthe burn back occurs again turn off the control knob to the affected burner and consult the nearest Defy Service Centre who will advise you Ventilation e Room ventilation is vital for the efficient performance of the appliance and for the safety of the occupants in the room in which the appliance is installed Page 5 Maintenance and servicing Every twelve months the hob should be se
9. n the maximum benefit from it Unpacking Please ensure that packaging material is disposed of in a responsible manner Plastic bags should be cut up to prevent children playing with them and accidentally suffocating If the appliance is damaged in any way do not use it Report the damage to your dealer who will take the necessary corrective action Positioning Good room ventilation is vital for the efficient performance of the appliance and for the safety of the occupants in the room in which the appliance is installed Cooking appliances generate considerable heat The layout and materials of the sur rounding cabinets should take account of these characteristics Surfaces of cabinets immediately adjacent to the hob should be able to withstand tem peratures of up to 100 C without delaminating or discolouring Allow an unrestricted air space of at least 150mm at the sides and 750mm above the hob The hob should be installed in a ventilated cupboard fitted with a sturdy worktop and must be secured using the fixing brackets provided Invert the hob on the worktop adjacent to the aperture before making the electrical connection This will ensure sufficient cable length for subsequent servicing Aperture dimensions are given below 550 ps P 5 4 ri Page 2 Instructions for the installer Electrical installation e This product has an electrical connection for the flame ignition system which re qui
10. nsure that there are no further leaks Page 3 Safety compliance with local requirements The appliance may only be installed by a Qualified Gas Fitter who is registered with the LPGSASA Liquid Petroleum Gas Association of Southern Africa and must be installed in accordance with the requirements of SANS 10087 1 and any fire depart ment regulations and or local bylaws applicable in the area Permanent installation All registered Gas Fitters are issued with an identity card which carries their registration number Make a note of this on the space provided below The Gas Fitter should also provide you with a written certificate after completion of the work Failure to comply with the above will render the warranty invalid Before the installer hands over the installed appliance be sure that you fully understand a The position of the isolation or shut off valve in the gas supply line to the appliance b The requirements for safe operation of the appliance Note This appliance is supplied ex factory with jets and air settings for use with LPG gas only Flexible hose Not supplied Any hose that is used to connect the hob to the gas system shall comply with SANS 1156 2 or BS 3212 Gas cylinder Not supplied For best results we recommend that gas cylinders with a minimum capacity of 19kg be used Regulator Not supplied A 2 8 kPa LPG gas regulator which complies with SANS 1237 must be used Installer s details to be fi
11. r shall be liable for the standard travelling charges as determined by the Company CARRY IN SERVICE Microwave ovens Compact cookers Domino hobs and small appliances are repaired in our service centres and are not collected from the customers home Faulty units should be delivered to the purchasing dealer or to the nearest Company Service Centre for warranty repairs 2 Rusted or corroded plates vitreous enamelware fuses and lamps are specifically excluded from these warranties It is an express condition of these warranties that the purchaser takes due care and attention in the use and maintenance of the appliance Abuse misuse in conflict with operating in structions connection to incorrect voltages and subjection to commercial use shall release the Company from its obligations 3 This warranty shall become void and cease to operate if the appliance is dismantled by or any re pairs to the appliance are effected by any persons not duly authorised by the Company or if substi tute parts not approved by the Company are used in the appliance or if the serial number of the ap pliance is removed 4 The Company shall not be responsible for damages resulting from fire flood civil disturbances or any Act of God The Company shall not in terms of these warranties be responsible nor held liable for any consequential loss or damage of any kind caused by or due to the failure or malfunction of the appliance 5 The Company shall not be respon
12. res a 230V 50 Hz power supply e The product is fitted with a 15 Amp 3 pin plug e Insert the plug into an earthed 15 Amp wall socket e The wall socket should be located where it is easily accessible but not above the hob e If the mains power cord is damaged it must be replaced by a qualified electrician e This appliance must be earthed e The manufacturer and the seller do not accept responsibility for any damage due to incorrect installation or electrical connection LPG Liquid Petroleum Gas installation e Soak the end of the gas supply hose in hot water to soften it e Then push the hose end fully over the gas supply nozzle located at the rear of the hob see sketch 1 below e Secure the hose by tightening the hose clamp See sketch 2 below e Similarly secure the other end of the hose to the regulator on the gas bottle O SEAL 2 AND NOZZLE 2 T REGULATOR AND HOSE CLAMP AND HOSE Check for gas leaks e Never use a naked flame to check for gas leaks e Check for gas leaks after installation and whenever a new or re filled gas bottle is used for the first time Ensure that the gas burner control knobs are in the OFF position Open the valve on the Gas bottle Using a small paint brush apply some soapy water to all the connections If there is a leak bubbles will appear If this happens close the valve on the gas bottle Check and tighten the connections immediately Repeat the procedure to e
13. rviced by a Defy Service agent to ensure continued efficient and safe operation Note If required the cleaning of the valves should only be carried out by a qualified Defy technician i e Burner not functioning correctly Removable burner parts should be washed weekly with hot water and detergent Take care to remove any encrustations and ensure that the burner holes are clear The condition of the gas hose and valve should be inspected for leaks every time the gas bottle is re filled Fitting the burner caps pune QD Carefully align the 2 holes in the alu minium burner cap body with the igni m Burer tion electrode and the flame failure sen Fit Burner Cap eee cut out over sor i f the spigot gt Gently lower the burner cap into posi on pane Cap tion with the cut out over the spigot in Bod the burner cap body 2 Flame failure Centralise and level the burner cap eisor cover onto the burner cap Ignition electrode Minimum flame adjustment Screwdriver is supplied with accessories e Remove the push on type knobs e Light the burners and adjust the Af Highest minimum adjustment minimum flame by turning the ad p Lowest minimum adjustment justment screw clockwise to decrease aa or anticlockwise to increase the flame Important safety advice When using gas ensure that the room is well ventilated Always keep children and infirm persons away from the product when it is in use Only use
14. sible for transportation or other costs other than those incurred within the provisions of Point 1 of this Certificate 6 These warranties shall not apply to the appliance if it is purchased or used beyond the borders of the Republic of South Africa Namibia Botswana Swaziland and Lesotho 7 Where service is requested under warranty and no fault or defect can be found by the Company all costs incurred will be for the purchaser s account 8 This Certificate as well as your invoice will serve as proof of purchase For the purpose of war ranty it will be essential to produce this Certificate and invoice Failure to do so will render the purchaser liable for service costs KEEP THIS CERTIFICATE AND SALES INVOICE AS PROOF OF PURCHASE FOR WARRANTY PURPOSES Page 12 Part Number 066 986
Download Pdf Manuals
Related Search