Lanier 480-0006
Contents
1. should be avoided May cause temporary eye discomfort Health Hazards of Long Term exposure Chronic A manufacturer sponsored chronic inhalation study in rats using a special test toner revealed there were no lung changes at all in the lowest exposure level 1mg m the most relevant level to potential human exposures A very slight degree of fibrosis was noted in 25 of the animals at the middle exposure level 4mg m while a slight degree of fibrosis was observed at the highest exposure level 16mg m in all animals These findings are attributed to Lung Overloading a generic response to excessive amount of any dust retained in the lungs for a prolonged interval The special test toner was ten times more respirable than commercially available toner to comply with EPA testing protocol and would not function properly in Xerographic equipment Carbon Black is listed on the IARC Monograph and the Massachusetts Substance List The IARC has evaluated the evidence for the carcinogenicity of Carbon Black as inadequate to determine a carcinogenic risk for humans This product contains no known hazardous materials as defined by the OSHA Hazard Communication Standard 29 CFR 1910 1200 Section 4 First Aid Measures Remove to fresh air if effects occur Get medical attention if needed In case of contact immediately flush eyes with water for 15 minutes Get medical attention if needed Dilute stomach contents with several glasses of water G2. to user s intended purposes or for consequences of its use All materials may present unknown hazards and should be used with caution Although certain hazards are described herein we do not guarantee that these are the only hazards that exist Information on this data sheet represents our current data and best opinion as to the proper use in handling of this product under normal conditions On the basis of the data available to us this product is not a dangerous substance One should however observe the usual precautionary measures for dealing with chemicals
3. LANIER Lanier Worldwide Inc 2300 Parklake Dr N E Atlanta GA 30345 2979 Emergency Telephone 800 526 4371 MATERIAL SAFETY DATA SHEET Section 1 Chemical Product and Company Information Identity Toner for M5112 MSDS No FX 066 Product ID 480 0006 Issued 02 06 2004 Synonyms Supersedes 01 11 2001 amp Common Date 02 06 2004 Names Toner for Lanier 5112 4900 MFD Prepared by Lanier Worldwide Inc EH amp S Department 770 496 9500 Uses Lanier 5112 4900 MFD Approved by Larry Choskey Manager EH amp S European Contact Lanier Worldwide Inc Manager Safety amp Chemical Environment Walter Fricke Formula Mixture Im Taubental D 41468 Neuss Germany 49 2131 387 177 Section 2 Composition Information on Ingredients PERCENT CAS No EXPOSURE LIMITS SOURCE Styrene acrylate copolymer 86 90 25767 47 9 Not listed n a Carbon black 5 6 1333 86 4 3 5 mg m 3 5 mg m OSHA TWA ACGIH TLV 6 mg m NAS Polypropylene 4 5 9003 07 0 Not listed N a Organic pigment 2 31714 55 3 Not listed N a PEL as the product 15mg n total dust 5mg m respirable dust TLV as the product 10mg m total dust 5mg m respirable dust Section 3 Hazards Identification HMIS Rating FLAMMABILITY 1 HEALTH 1 REACTIVITY 0 SPECIAL none Health Hazards Acute Chronic Immediate and Potential Minimum irritation to respiratory tract may occur as with exposure to any non toxic dust May cause gasping if inhaled Inhalation
4. et medical attention Inhalation Eye Contact Skin Contact Wash with soap and water Ingestion Section 5 Fire Fighting Measures Suitable extinguishing media CO dry chemical foam or water Explosion limits n a Extinguishing media which may not be used for safety reasons none This material will burn in case of fire The decomposition products are CO COz and No Avoid inhalation of smoke Special protective equipment for fire fighters none LEL n a UEL n a MATERIAL SAFETY DATA SHEET Page 2 of FX 066 Section 6 Accidental Release Measures Spill leak Procedures If spilled sweep up using an approved toner vacuum with a 0 5 micron filter or smaller such as the Atrix AAA Toner Vacuum or 3M Toner Vacuum Use of a vacuum cleaner not rated for toner particles could result in a fire or personal injury Remove residue with soap and cold water Miscellaneous Keep product out of sewers and watercourses Personal protection Avoid inhalation of dust Section 7 Handling and Storage Special Handling Cleanse skin after contact before breaks or meals and end of workday Special Storage Avoid direct sunlight Keep out of reach of children Store in a cool dry place Section 8 Exposure Control and Personal Protection Information Ventilation Local exhaust Respiratory Protection Nuisance dust respirator Hand Protection none required under normal use Eye Protection Safety goggles Skin Protection Gloves Section 9 Ph
5. sed Toner should be disposed of under conditions that meet all federal state and local environmental regulations Disposal regulations vary from locality to locality therefore consult your local Lanier office or the EPA to determine the proper method for disposal Section 14 Transportation Information None This is not a hazardous product Section 15 Regulatory Information This product consists of chemical substances which are included in the TSCA inventory Marking according to EC Directive Not required no R phrases no S phrases Information on this data sheet represents our current data and best opinion as to the proper use in handling of this product under normal conditions On the basis of the data available to us this product is not a dangerous substance One should however observe the usual precautionary measures for dealing with chemicals MATERIAL SAFETY DATA SHEET Page 3 of FX 066 National Regulations No special regulations and restrictions WHMIS Legislation Canada This product is not a controlled product Section 16 Miscellaneous Information Judgment as to the suitability of information contained herein for user s purposes is the responsibility of the purchaser Therefore although reasonable care has been taken in the preparation of this information Lanier Worldwide Inc extends no warranties makes no representations and assumes no responsibility as to the accuracy or suitability of such information for application
6. ysical and Chemical Properties CHARACTERISTICS Appearance Black Melting point 116 C Form Powder Vapor pressure n a Odor Odorless Vapor density n a Solubility in Water Negligible Evaporation rate n a Specific gravity 1 2 Boiling point n a Section 10 Stability and Reactivity Conditions to avoid none Materials to avoid none Stability Stable Hazardous decomposition products CO and CO2 and other decomposition products when burned Section 11 Toxicological Information Acute oral toxicity rat LDs9 Over 2 0 g kg Ames Test result Negative Skin irritation rabbit none Eye irritation rabbit mild Acute inhalation rat 4 hour LCs and LC are in excess of 5 46 mg L Carcinogenicity In 1996 the IARC reevaluated carbon black as a GROUP 2B carcinogen possible human carcinogen This evaluation is given to carbon black for which there is inadequate human evidence but sufficient animal evidence The latter is based upon the development of lung tumors in rats receiving chronic inhalation exposures to free carbon black at a level that induce particle overload of the lungs Studies performed in mice have not demonstrated an association between carbon black and lung tumors Moreover a two year cancer bioassay using a typical toner preparation containing carbon black demonstrated no association between toner and tumor development in rats Section 12 Environmental Ecological Information None Section 13 Disposal Consideration U
Download Pdf Manuals
Related Search