Lanier 4910282
Contents
1. LANIER Lanier Worldwide Inc 2300 Parklake Dr N E Atlanta GA 30345 2979 Emergency Telephone 800 526 4371 MATERIAL SAFETY DATA SHEET Section 1 Chemical Product and Company Information Identity Toner for 1210 1240 1260 1205 MSDS No FX 071 Product ID 491 0282 Issued 02 06 2004 Synonyms Supersedes 08 12 2002 amp Common Date 02 06 2004 Names Toner for Lanier 1210 1240 1260 1205 Prepared by Lanier Worldwide Inc EH amp S Department Fax 770 496 9500 Uses Approved by Larry Choskey Manager EH amp S Lanier 1210 1240 1260 1205 Fax European Contact Lanier Worldwide Inc Manager Safety amp Chemical Environment Walter Fricke Formula Im Taubental D 41468 Neuss Germany Mixture 49 2131 387 177 Section 2 Composition Information on Ingredients PERCENT CAS No EXPOSURE LIMITS SOURCE Polyester resin gt 85 Confidential Not listed n a Carbon black 1 5 1333 86 4 3 5 mg m 3 5 mg m OSHA TWA ACGIH TLV 6 mg m Yai Polyolefin wax 1 5 Confidential Not listed N a Organic pigment 1 5 Confidential Not listed N a Quaternary ammonium salt 1 5 Confidential Not listed N a PEL as the product 15mg n total dust 5mg m respirable dust TLV as the product 10mg m total dust 5mg m respirable dust Section 3 Hazards Identification HMIS Rating FLAMMABLLITY 1 HEALTH 1 REACTIVITY 0 SPECIAL none Health Hazards Acute Chronic Immediate and Potential Minimum irritation to respirat2. emical substances in this product comply with all applicable rules or orders under TSCA RCRA 40 CFR 261 Not regulated NTP Annual Report on Carcinogens Not listed as a NTP carcinogen IARC See Section 11 California Proposition 65 Neither toner nor any of its components are listed as chemicals known to the state of California to cause cancer Controlled Products Regulations Canada This product has been classified in accordance with the hazard criteria of the CPR Other State Regulations Carbon Black is listed in the New Jersey Right To Know List Pennsylvania Hazardous Substance List and Massachusetts Substance List U S Canada Label Standards LOW HAZARD FOR RECOMMENDED HANDLING Minimize dust generation and accumulation Use with adequate ventilation EU Information Label Information according to Directives 67 548 EEC amp 88 379 EEC Symbol amp Indication Not required Risk Phase Not required Safety Advice Phase Not required EEC Directive 76 548 EEC 79 831 92 32 EEC All chemical substances in this product comply with all applicable rules or order under EEC Directive Section 16 Miscellaneous Information Notice Judgments as to the suitability of information contained herein for purchaser s purposes are the purchaser s responsibility Therefore although reasonable care has been taken in the preparation of such information Lanier Worldwide Inc extends no warranties makes no representations and assumes no responsibility as to t
3. er normal use Eye Protection Safety goggles Skin Protection Gloves Section 9 Physical and Chemical Properties CHARACTERISTICS Appearance Black Melting point 120 130 C Form Powder Vapor pressure n a Odor Faint odor Vapor density n a Solubility in Water Negligible Evaporation rate n a Specific gravity 1 2 Ignition temp 450 C Section 10 Stability and Reactivity Conditions to avoid Electronic discharge or throwing into fire Materials to avoid Oxidizing materials Stability Stable Hazardous decomposition products CO and CO2 and other decomposition products when burned Section 11 Toxicological Information Acute oral toxicity rat LD5 Over 5 0 g kg Acute Inhalation LCs 4H is in excess of 0 74 g m rat Mutagenicity Ames Test result Negative Dermal LD50 Over 2 0 g kg rat Skin sensitizer None indicated Guinea pig Eye Irritation Not an irritant rabbit Section 12 Environmental Ecological Information Mobility No data is available on the adverse effects of this material on the environment Persistence Degradability No data is available on the adverse effects of this material on the environment Bioaccumulation No data is available on the adverse effects of this material on the environment Ecotoxicity Behavior in Sewage works No data is available on the adverse effects of this material on the environment Aquatic Toxicity No data is available on the adverse effects of this material on the environmen
4. he accuracy or suitability of such information for application to purchaser s intended purposes or for consequences of its use All materials may present unknown hazards and should be used with caution Although certain hazards are described within we do not guarantee that these are the only hazards which exist References IARC 1996 IARC Monographs on the Evaluation of the Carcinogenic Risks of Chemical to Humans Vol 65 Printing Processes and Printing Inks Carbon Black and Some Nitro Compounds Lyon pp 149 261 H Muhle B Bellmann O Creutzenberg C Dasenbrock H Ernst R Kilpper J C MacKenzie P Morrow U Mohr S Takenaka and R Mermelstein 1991 Pulmonary Response to Toner upon Chronic Inhalation Exposure in Rats Fundamental and Applied Toxicology 17 pp 280 299 Abbreviations 1 OSHA PEL Permissible Exposure Limit under Occupational Safety and Health Administration USA 2 ACGIH TLV Threshold Limit Value under American Conference of Governmental Industrial Hygienists USA DFG MAK Maximale Arbeitsplatzkonzentrationen under Deutsche Forschungsgemeinschaft TWA Time Weighted Average IARC International Agency for Research on Cancer NTP National Toxicology Program USA NIOSH National Institute for Occupational Safety and Health USA 3 4 5 6 7 8 DOT Department of Transportation USA SS SS Ss SS Information on this data sheet represents our current data and best opinion as to the proper
5. ntact water for 5 minutes Get medical attention if needed Skin Contact Wash with soap and water Ingestion Dilute stomach contents with several glasses of water Get medical attention Section 5 Fire Fighting Measures Suitable extinguishing media CO dry chemical foam or water Explosion limits n a Extinguishing media which may not be used for safety reasons none This material will burn in case of fire The decomposition products are CO COz and No Avoid inhalation of smoke Special protective equipment for fire fighters none LEL n a UEL n a MATERIAL SAFETY DATA SHEET Page 2 of FX071 Section 6 Accidental Release Measures Spill leak Procedures If spilled sweep up using an approved toner vacuum with a 0 5 micron filter or smaller such as the Atrix AAA Toner Vacuum or 3M Toner Vacuum Use of a vacuum cleaner not rated for toner particles could result in a fire or personal injury Remove residue with soap and cold water Miscellaneous Keep product out of sewers and watercourses Personal protection Avoid inhalation of dust Section 7 Handling and Storage Special Handling Cleanse skin after contact before breaks or meals and end of workday Special Storage Avoid direct sunlight Keep out of reach of children Store in a cool dry place Section 8 Exposure Control and Personal Protection Information Ventilation Local exhaust Respiratory Protection Nuisance dust respirator Hand Protection none required und
6. ory tract may occur as with exposure to any non toxic dust May cause gasping if inhaled Inhalation should be avoided May cause temporary eye discomfort Health Hazards of Long Term exposure Chronic A manufacturer sponsored chronic inhalation study in rats using a special test toner revealed there were no lung changes at all in the lowest exposure level 1mg m the most relevant level to potential human exposures A very slight degree of fibrosis was noted in 25 of the animals at the middle exposure level 4mg m while a slight degree of fibrosis was observed at the highest exposure level 16mg m in all animals These findings are attributed to Lung Overloading a generic response to excessive amount of any dust retained in the lungs for a prolonged interval The special test toner was ten times more respirable than commercially available toner to comply with EPA testing protocol and would not function properly in Xerographic equipment Carbon Black is listed on the IARC Monograph and the Massachusetts Substance List The IARC has evaluated the evidence for the carcinogenicity of Carbon Black as inadequate to determine a carcinogenic risk for humans This product contains no known hazardous materials as defined by the OSHA Hazard Communication Standard 29 CFR 1910 1200 Section 4 First Aid Measures Remove to fresh air if effects occur Get medical In case of contact immediately flush eyes with Inhalation attention if needed Eye Co
7. t Ecological Data EC Csb Value EC No data is available on the adverse effects of this material on the environment AOX Remark EC No data is available on the adverse effects of this material on the environment BsB5 Value EC No data is available on the adverse effects of this material on the environment Significant Components EC Not applicable Section 13 Disposal Consideration Used Toner should be disposed of under conditions that meet all federal state and local environmental regulations Disposal regulations vary from locality to locality therefore consult your local Lanier office or the EPA to determine the proper method for disposal Section 14 Transportation Information Special Precautions None International Transport Information UN Classification number None DOT Identification number None Information on this data sheet represents our current data and best opinion as to the proper use in handling of this product under normal conditions On the basis of the data available to us this product is not a dangerous substance One should however observe the usual precautionary measures for dealing with chemicals MATERIAL SAFETY DATA SHEET Page 3 of FX 071 Domestic Transportation n a Land RID EC None ADR EC None Inland Waterways ADNR Rhine R None Sea IMDG None Air ICAO TI None IATA DGR None Section 15 Regulatory Information OSHA Hazard Communication Standard 29 CFR 1910 1200 Not regulated TSCA All ch
8. use in handling of this product under normal conditions On the basis of the data available to us this product is not a dangerous substance One should however observe the usual precautionary measures for dealing with chemicals
Download Pdf Manuals
Related Search