Baumatic WD01SS
Contents
1. INSTRUCTION MANUAL User Manual for your Baumatic WDO1SS 14cm High warming drawer WDO2SS 30cm High warming drawer gt gt i Baumatic NOTE This User Instruction Manual contains important information including safety amp installation points which will enable you to get the most out of your appliance Please keep it in a safe place so that it is easily available for future reference for you or any person not familiar with the operation of the appliance GS 31 08 10 Contents Environmental note Important safety information Specifications WDO1SS dimensions WDO2SS dimensions Product specifications Electrical details The warming drawer Using the warming drawer Before first use Setting the drawer to warm Selecting a temperature Heating times Load capacity Cleaning and maintenance Installation Electrical connections Installing the warming drawer into the kitchen cabinet Positioning the appliance without an oven Positioning the appliance with an oven My appliance isn t working correctly Contact details 4 5 7 8 11 8 9 10 10 11 11 14 11 12 12 12 13 13 13 14 14 15 15 19 15 16 16 19 16 17 17 19 19 21 Environmental note This appliance is marked according to the European directive 2002 96 EC on Waste electrical and Electronic Equipment WEEE By ensuring this product is disposed of correctly you will help prevent potential2. O Place the dishes into the drawer Select the temperature see below section Set the warming time using the timer dial 3 The minimum time that can be set is 10 minutes The maximum time that can be set is 90 minutes The power light 2 turns on to show that the appliance is switched on Close the warming drawer When the set time has elapsed the hot air heating system stops and a bell will sound To turn the bell off turn the temperature dial to 0 Selecting a temperature O Place the crockery that you wish to warm in the drawer Use the control knob 1 to set the most suitable temperature for the crockery that you are warming The temperature control knob adjusts the temperature between 30 C and 70 C The temperature should be set at 40 C to warm cups or glasses This may be ideal for gently heating cups before pouring a hot drink in them so that it stays hotter longer The temperature should be set at 60 C to warm plates and dishes Food served on preheated plates or dishes maintain their heat but the dishes can still be touched without risking burns IMPORTANT Care should be taken when removing items from the warming drawer when appropriate you should use oven gloves when removing items from the drawer You should make sure that the appliance is switched off before removing items from the drawer Heating times The time required to heat crockery depends on several factors o The mate
3. appliance Heat steam and moisture will be created during use of the appliance take care to avoid injury and ensure that the room is adequately ventilated If the appliance is going to be used for prolonged periods of time then additional ventilation may be required Make sure that the appliance is firmly secured to the cabinet Please consult with your qualified installer if you are in any doubt about the amount of ventilation that you will require Declaration of conformity o In the parts destined to come into contact with foodstuffs this appliance is in accordance with the requirements of the EC directive 89 109 transposed in the Italian Legislative Decree No 108 of 25 01 92 CE Appliance conforming to the European directives 89 336 EEC 93 68 EEC 73 23 EEC and subsequent revisions and RoHS directive 2002 95 CE The manufacturer declares that the warming drawer is built using certified materials and requires the appliance to be installed in accordance with the standards currently in force This appliance must be used by a trained person for domestic purposes only The RoHS directive stands for the restriction of the use of certain hazardous substances in electrical and electronic equipment This directive bans the placing on the EU market of new electrical and electronic equipment containing more than the agreed levels of lead cadmium mercury hexavalent chromium polybrominated biphenyl PBB and polybromina
4. loading of the drawer allows it to shut properly IMPORTANT If your appliance appears not to be operating correctly then you should disconnect it from your mains supply and then contact the Baumatic Service Department on telephone number 0118 933 6911 DO NOT ATTEMPT TO REPAIR THE APPLIANCE YOURSELF Please note that if an engineer is asked to attend whilst the product is under guarantee and finds that the problem is not the result of an appliance fault then you may be liable for the cost of the call out charge The appliance must be accessible for the engineer to perform any necessary repair If your appliance is installed in such a way that an engineer is concerned that damage will be caused to the appliance or your kitchen then he will not complete a repair This includes situations where appliances have been tiled in sealed in with sealant have wooden obstructions placed in front of the appliance like plinths Or any installation other than the one specified by Baumatic Ltd has been completed 20 oo gt Baumatic United Kingdom Baumatic Ltd Baumatic Buildings 6 Bennet Road Reading Berkshire RG2 0QX United Kingdom Sales Telephone 0118 933 6900 Sales Fax 0118 931 0035 Customer Care Telephone 0118 933 6911 Customer Care Fax 0118 986 9124 Spares Telephone 01235 437244 Advice Line Telephone 0118 933 6933 E mail sales baumatic co uk customercare baumatic co uk spa
5. must be able to withstand a minimum temperature of 85 C above the ambient temperature of the room it is located in whilst in use o Certain types of vinyl or laminate kitchen furniture are particularly prone to heat damage or discolouration at temperatures below the guidelines given above o Any damage caused by the appliance being installed in contravention of this temperature limit or by placing adjacent cabinet materials closer than 4mm to the appliance will be the liability of the owner o For use in leisure accommodation vehicles please refer to the appropriate information given in the installation instructions for this appliance o The use of this appliance for any other purpose or in any other environment without the express agreement of the manufacturer will invalidate any warranty or liability claim o Your new appliance is guaranteed against electrical or mechanical defects subject to certain exclusions that are noted in Baumatic s Conditions Of Guarantee The foregoing does not affect your statutory rights o Repairs may only be carried out by Baumatic Service Engineers or their authorised service agent Warning and safety instructions O This appliance complies with all current European safety legislation Baumatic do wish to emphasise that this compliance does not remove the fact that the appliance surfaces will become hot during use and retain heat after operation Child Safety O We strongly recomm
6. negative consequences for the environment and human health which could otherwise be caused by inappropriate waste handling of this product The symbol on the product or on the documents accompanying the product indicates that this appliance may not be treated as household waste Instead it shall be handed over to the applicable collection point for the recycling of electrical and electronic equipment Disposal must be carried out in accordance with local environmental regulations for waste disposal For more detailed information about treatment recovery and recycling of this product please contact your local city office your household waste disposal service or the shop where you purchased the product o The packaging materials that Baumatic uses are environmentally friendly and can be recycled o Please discard all packaging material with due regard for the environment IMPORTANT SAFETY INFORMATION Your safety is of the utmost importance to Baumatic Please make sure that you read this instruction booklet before attempting to install or use the appliance If you are unsure of any of the information contained in this booklet please contact the Baumatic Technical Department General Information o This appliance is designed for domestic household use and can be built into a standard kitchen cabinet or housing unit o IMPORTANT The adjacent furniture or housing and all materials used in the installation
7. W Mains Supply Lead 3 x 1 5mm2 For future reference please record the following information which can be found on the Rating Plate and the date of purchase which can be found on your sales invoice Model Number Serial Number Date of Purchase The warming drawer 1 Temperature control dial 2 Power light 3 Timer switch 4 Drawer for dishes 5 Anti skid mat o The controls are only visible when the warming drawer is open o When the drawer is closed the power light on the front of the drawer comes on to show the appliance is running o The floor of the drawer is covered with an anti skid mat that prevents the dishes from sliding when the drawer is opened and closed Using the warming drawer Before first use o Clean the surfaces with a soft damp cloth o To remove any residue from the warming drawer that may have been left from the manufacturing process you should turn the control knob to the maximum temperature setting o Itis perfectly normal for a smell to be produced during this process You should make sure that any windows in the room are left open during this process It is advisable for you not to remain in the room whilst the burning off process is taking place You should leave the warming drawer on the maximum setting for 2 hours Setting the drawer to warm O
8. again o If you have to change the power cord the earthing yellow green conductor must always be 10 mm longer than the line conductors Care must be taken to ensure that the temperature of the mains supply cable does not exceed 50 C If the mains supply cable is damaged then it must be replaced by an appropriate replacement which can be obtained from the Spares Department Installing the warming drawer into the kitchen cabinet Positioning the appliance without an oven O Ensure that the aperture that you will be fitting the warming drawer into is of the size given in the diagrams below Ensure that the rear panel of the furniture housing unit has been removed WDO1SS WDO2SS Positioning the appliance with an oven o Ensure that the aperture that you will be fitting the warming drawer into is of the size given in the diagrams below o Ensure that the ventilation requirements shown in the diagrams below are observed WDO1SS 8TZ STZ WDO2SS 875 878 18 My appliance isn t working correctly o The warming drawer isn t heating crockery Check that the appliance is switched on Check that the drawer is closed completely Check that the crockery has been warmed for a sufficient period of time Check that the drawer has not been left open for too long Check your mains power supply o The drawer does not close properly Check that the
9. awer is cool The appliance should be disconnected from your mains supply before commencing any cleaning process o Never clean the drawer surfaces by steam cleaning o All surfaces of the warming drawer should only be cleaned with warm soapy water using either a sponge or soft cloth No abrasive cleaners should be used o IMPORTANT The slots in the protective grill that covers the heating element and fan should not be cleaned with water Any water penetration into this area may result in the breakdown of the appliance short circuits and or create a hazard for the user o If you use any form of cleaner on your appliance then you must check with the manufacturer of the cleaner that it is suitable for use on your appliance o To maintain the appearance of the stainless steel drawer front a good quality stainless steel cleaner should be utilised Please refer to the manufacturer s instructions when using a stainless steel cleaner o DO NOT USE detergents that contain soda acids or chlorine abrasive detergents powders or cream abrasive sponges e g 14 steel wool pads or sponges that contain a residual abrasive detergent The anti slip warming drawer bottom can be cleaned if you are thoroughly cleaning the appliance It can be hand washed with warm water and a mild detergent The bottom should be dried thoroughly afterwards and not placed back into the appliance until it is completely dry Any damage that is caused
10. end that babies and young children are prevented from being near to the appliance and not allowed to touch the appliance at any time If it is necessary for younger family members to be in the kitchen please ensure that they are kept under close supervision at all times General Safety Do not allow electrical fittings or cables to come into contact with areas on the appliance that get hot Do not lean or sit on the open drawer the telescopic runners will become damaged Do not use the appliance to heat the room it is located in or to dry clothing Do not install the appliance next to curtains or soft furnishings Do not keep plastic or flammable objects inside the appliance Do not use the appliance to warm re heat or cook foods or beverages Do not insert ANY objects through the slots in the protective grill that covers the heating element and fan Cleaning O Cleaning of the warming drawer should be carried out on a regular basis Great care should be taken whilst using this appliance and when following the cleaning procedure IMPORTANT The appliance must be disconnected from the mains before following the cleaning procedure Installation This appliance must be correctly installed by a suitably qualified person strictly in accordance with the manufacturer s instructions Baumatic Ltd declines any responsibility for injury or damage to person or property as a result of improper use or installation of this
11. res baumatic co uk technical baumatic co uk Website www baumatic co uk Republic of Ireland Service Telephone 1 890 812 724 Spares Telephone 091 756 771 Czech Republic Baumatic CR spol s r o Pr myslov z na Sever 696 460 11 Liberec 11 Czech Republic 420 483 577 200 www baumatic cz Slovakia Baumatic Slovakia S r o Galv niho 7 D Slovakia 421 255 640 618 Germany Baumatic Gmbh Lilienthalstrasse 1 320 52 Herford Deutschland 49 5221 694 99 0 www baumatic de Italy Baumatic Italia S R L Via Galvani N 3 35011 Campodarsego PD 3904 9920 2297 www baumatic it Holland Baumatic Benelux B V Grindzuigerstraat 22 1333 MS ALMERE Nederland 3136 549 1555 www baumatic nl 21 22 23
12. rial that the crockery is manufactured from and the thickness of the crockery o The amount that has been loaded into the warming drawer o The way in which the load has been arranged o The temperature setting that has been selected It is not possible to give an exact heating time and you should experiment to find out which heating temperature and time are the most appropriate for particular types and amounts of crockery As a general guide for a temperature setting of 60 C to heat evenly o Dishes for a meal with six people take approximately 30 minutes o Dishes for a meal with twelve people take approximately 40 minutes Load capacity IMPORTANT The drawer can withstand a maximum load of 20 kilograms WDO1SS Load capacities Dimensions 9 6 x dinner plates 28 cm 6 x soup bowls 22 cm 1 x serving dish 22 cm 1 x serving dish 20 cm 1 x serving dish 18 cm 2 x meat plates 36 cm 16 x large plates 28 cm 8 x bowls 10 cm 24 x soup bowls 22 cm 40 x bowls 10 cm 60 x cups 8 cm WDO2SS Load capacities Dimensions 9 12 x dinner plates 28 cm 12 x soup bowls 22 cm 2 x serving dishes 22 cm 2 x serving dishes 20 cm 2 x serving dishes 18 cm 2 x meat plates 36 cm 32 x large plates 28 cm 600g each 50 x large plates 22 cm 400g each 60 x bowls 10 cm 132 x cups 8 cm Cleaning and maintenance Cleaning operations must only be carried out when the dr
13. ted diphenyl ether PBDE flame retardants Specifications WDO1SS Product dimensions with front panel Height 140 mm Width 595 mm Depth 545 mm Aperture dimensions without an oven Height 138 mm Width 560 mm Depth 560 mm For more specific information on the size of the aperture required to install the warming drawer please see the Installation section of this manual WDO2SS Product dimensions with front panel Height 300 mm Width 595 mm Depth 545 mm Aperture dimensions without an oven Height 298 mm Width 560 mm Depth 560 mm For more specific information on the size of the aperture required to install the warming drawer please see the Installation section of this manual Product specifications WDO1SS Adjustable temperature 30 C to 70 C Integrated hot air fan Heater on the side Fully expandable telescopic drawer Holds 6 place settings Maximum load 20 kg Can be installed alone or together with a single or compact oven O 0 0000 50 WDO2SS Adjustable temperature 309C to 709C Integrated hot air fan Fully expandable telescopic drawer Holds 12 place settings Maximum load 20 kg Designed to be installed alone or together with single or compact oven 000000 Electrical details both models Rated Voltage 220 240 Vac 50 Hz Supply Connection 13 A double pole switched fused outlet with 3mm contact gap Max Rated Inputs 0 41 k
14. to the appliance by a cleaning product will not be fixed by Baumatic free of charge even if the appliance is within the guarantee period INSTALLATION The installation must be carried out by a suitably qualified person in accordance with the current O O version of the following UK Regulations and Safety Standards or their European Norm Replacements Building Regulations issued by the Department of the Environment Building Standards issued by the Scottish Development Department IEE Wiring Regulations Electricity At Work Regulations Before connecting the appliance make sure that the supply voltage marked on the Rating Plate corresponds with your mains supply voltage WARNING THIS APPLIANCE MUST BE EARTHED O MAINS POWER EARTH SUPPL O This appliance should be wired into a 13 A double pole switched fused spur outlet having 3 mm contact separation and placed in an easily accessible position adjacent to the appliance The spur outlet must still be accessible even when your warming drawer is located in its housing LIVE Es rj BROWN gt 5 YELLOW oreen POWER CORD 7 BLUE Ei Y NEUTRAL N To connect the power cord loosen and remove the cover on the terminal block in order to gain access to the contacts inside Make the connection securing the cord in place with the cable clamp provided and then immediately close the terminal block cover
Download Pdf Manuals
Related Search