Home

TEAC DV-W5500S

image

Contents

1. 6 2 TRAY LOADER MECHANISM LIFE This drive shall have a power tray to load and unload the disc The drive is capable of at least 30 000 tray loading unloading operations without degradation or failure Both motions of extending and retracting the tray from the drive is smooth and quiet 6 3 MTBF The MTBF is 70 000 power on hours POH when operated at 25 deg C temperature nominal voltage and other environmental limits based on the following assumptions the operating duty cycle is 10 of power on time During this time the drive is either reading or seeking random multiple block read the drive is in dormant mode i e the laser diode is off and spindle motor not spinning the drive is power on for 90 of power on time The spindle motor is a brushless motor 6 4 OPTICAL PICKUP ACTUATOR MECHANISM The drive is capable at least 4 000 000 Random seeks 6 5 MTTR MEAN TIME TO REPAIR 30 minutes TEAC Corporation DVD CD Rewritable Drive Specification DV W5500S 000 Rev 0 94 16 24 6 6 ELECTROSTATIC DISCHARGE SUSCEPTIBILITY ESD 6 6 1 GENERAL The drive installed in specified shielded case meet the ESD specified as below Tested in the IEC 61000 4 2 EN61000 4 2 Contact discharge 6kV No performance degradation or failure 8kV Temporary performance degradation or failure No destroy Air discharge 12kV No performance degradation or failure 15kV Temporary performance degradation
2. Access time is the time from the raising edge of DAO of the last command byte to the falling edge of IOCS16 of after the first data byte returned to host assumes no disconnect at horizontal operation This measurement is done per 200 times of random seeks after a disc insertion Access time specifications will be met at horizontal operation and in the following environmental conditions Temperature 10 deg C 30 deg C Reliative humidity lt 85 no condensation 4 3 10 1 DVD medium FULL STROKE Average 200 seeks after 10 seeks from LBA 0 to 2 293 759 and from block 2 293 759 to block 0 A total of 400 seeks 6 6 16x CAV Spindown to 5 13xCAV without sequential access 250 msec typical 1 3 STROKE Average over 100 seeks after 10 seeks from LBA 532 480 to 1 265 664 6 6 16x CAV Spindown to 5 13xCAV without sequential access 160 msec typical RANDOM STROKE Average over 500 random access after 10 seeks 6 6 16x CAV Spindown to 5 13xCAV without sequential access 160 msec typical 4 3 10 2 CD medium FULL STROKE Average 200 seeks after 10 seeks from block 0 to block 269 999 and from block 269 999 to block 0 A total of 400 seeks 20 48x CAV Spindown to 8 20xCAV without sequential access 230 msec typical 1 3 STROKE Average over 100 seeks after 10 seeks from block 67 350 to 157 350 20 48x CAV Spindown to 8 20xCAV without sequential access 140 msec typical RANDOM STROKE Average over 500 random access after 10 seeks 20 48x CAV
3. 15 DVD Content Scramble System Authentication 4 3 16 Region Playback Control 4 3 17 Maximum Playback Speed with various Disc 4 3 18 Tolerance pertaining to Media 5 ENVIRONMENTAL 5 1 5 2 5 3 5 4 Did TEMPERATURE NON CONDENSING 5 1 1 NON OPERATING 5 12 OPERATING HUMIDITY 5 2 1 NON OPERATING 5 2 2 OPERATING VIBRATION 5 3 1 OPERATING 5 3 2 NON OPERATING SHOCK 5 4 1 NON OPERATING 5 4 2 OPERATING VIBRATION AND DROP PACKAGED 5 5 1 VIBRATION PACKAGED 5 5 2 DROP PACKAGED 6 QUALITY AND RELIABILITY 6 1 COSMETIC TEAC Corporation DVD CD Rewritable Drive Specification DV W5500S 000 Rev 0 94 2 24 6 2 TRAY LOADER MECHANISM LIFE 6 3 MTBF 6 4 OPTICAL PICKUP ACTUATOR MECHANISM 6 5 MTTR MEAN TIME TO REPAIR 6 6 ELECTROSTATIC DISCHARGE SUSCEPTIBILITY ESD 6 6 1 GENERAL 6 7 PRODUCTION FINAL TEST 7 REGULATIONS AND STANDARDS 7 1 SAFETY APPROVAL 7 2 EMC AND COMPLIANCE 7 3 FDA COMPLIANCE 7 4 RoHS COMPLIANCE 8 ACOUSTIC NOISE 8 1 GENERAL 8 2 TEST CONDITION 8 3 NOISE SPECIFICATION 9 MECHANICAL 9 1 DIMENSIONS AND MOUNTING ORIENTATION 9 1 1 DIMENSIONS 9 12 MOUNTING ORIENTATION 9 13 WEIGHT 9 2 COLOR 9 2 1 EJECT BUTTON FRONT BEZEL AND TRAY DOOR 9 2 2 TRAY 9 2 3 ACTIVITY LED 9 3 APPLICABLE CABLE 9 3 1 SIGNAL CABLE 9 4 DRIVE CONNECTORS 9 4 1 POWER CONNECTOR 9 4 2 Serial ATA CONNECTOR 9 5 DISC TRAY LOADING MECHANISM 9 5 1 MANUAL EJECT BUTTON 9 5 2 PIN HOLE EMERGENCY EJECT
4. 6 MBytes sec 6x CLV 7 9 MBytes sec 4x CLV 5 3 MBytes sec 2 4x CLV 3 2 MBytes sec d DVD R Write Speed 24x CAV 13 7 33 MBytes sec 20x CAV 11 0 26 4 MBytes sec 18x CAV 9 9 23 8 MBytes sec 16x CAV 8 7 21 1 MBytes sec 13x CAV 6 6 17 2 MBytes sec 12x ZCLV 7 9 15 8 MBytes sec 8x ZCLV 7 9 10 6 MBytes sec 6x CLV 7 9 MBytes sec 4x CLV 5 3 MBytes sec TEAC Corporation DVD CD Rewritable Drive Specification DV W5500S 000 Rev 0 94 10 24 2x CLV e DVD R DL Write Speed 12x CAV 8x ZCLV 6x ZCLV 4x CLV 2x CLV f DVD RW Write Speed 6x CLV 4x CLV 2x CLV 1x CLV g DVD RAM Version 2 Write Speed 5x CAV 3x CLV 2x CLV h CD R Write Speed 48x CAV 40x CAV 32x ZCLV 24x ZCLV 16x CLV 8x CLV i CD RW Write Speed 32x ZCLV 24x ZCLV 16x CLV 10x CLV 4x CLV 4 3 8 Serial ATA Interface PIO DMA 4 3 9 ROTATION SPEED 4 3 9 1 DVD Rotation Speed a 10 24x CAV b 8 3 20x CAV c 7 5 18x CAV d 6 6 16x CAV e 5 13x CAV SL 5 12xCA V DL f 12x ZCLV g 8x ZCLV SL h 8x ZCLV DL i 6x CLV SL j 6x ZCLV DL k 3 3 8x CAV DL 1 3 3 8x CAV SL m 2 5x CAV DL n 2 5x CAV SL o 4x CLV p 2 4x CLV q 2x CLV r Ix CLV 4 3 9 2 DVD RAM Version 2 Rotation Speed a 12x PCAV b 5x CAV c 3x CLV TEAC Corporation 2 6 MBytes sec 6 6 15 8 MBytes sec 5 3 10 6 MBytes sec 5 3 8 7 MBytes sec 5 3 MBytes sec 2 6 MBytes sec 7 9 MBytes sec 5 3 MBytes sec 2 6 MByte
5. Spindown to 8 20xCAV without sequential access 140 msec typical 4 3 10 3 DVD RAM medium FULL STROKE Average 200 seeks after 10 seeks from LBA 0 to 2 293 759 and from block 2 293 759 to block 0 A total of 400 seeks 5x CAV 700 msec typical TEAC Corporation DVD CD Rewritable Drive Specification DV W5500S 000 Rev 0 94 12 24 1 3 STROKE Average over 100 seeks after 10 seeks from LBA 532 480 to 1 265 664 5x CAV 300 msec typical RANDOM STROKE Average over 500 random access after 10 seeks 5x CAV 300 msec typical 4 3 11 SPIN UP AND TRAY OPEN TIME Drive s firmware has 10 seconds time out for the Start Stop Unit command for spin up spin down and tray open SPIN UP TIME Spin up to drive ready Time to pause position from disc complete stop Tested with disc without scratches or dust Normal Speed or 20 48xCAV 6 5 sec Max SPIN DOWN TIME Normal Speed or 20 48xCAV 6 sec Max TRAY OPEN TIME not include spin down time 5 sec Max TRAY CLOSE TIME not include spin up time 5 sec Max 4 3 12 USER ERROR RATES Hard Error Rate DVD and CD Mode 1 with up to 5 retries and layered ECC on lt 1071 Block bit Soft Error Rate CD Mode 2 with up to 5 retries lt 107 Block bit Seek Error Rate lt 106 Block bit 4 3 13 MPC3 COMPLIANCE This drive complies with the Microsoft specification for MPC3 The CPU utilization is less than 40 at data rate of 600 KB sec less than 20 at data rate of 300 KB
6. or failure No destroy Energy storage capacitance 150pF 10 Discharge resistance 330 ohm 10 7 REGULATIONS AND STANDARDS 7 1 SAFETY APPROVAL UL UL60950 C UL cUL C22 2 N0 60950 TUV EN60950 EN60825 CB IEC60950 TEC60825 7 2 EMC AND COMPLIANCE CE Marking EN55022 Class B ENS5024 C tick AS NZS CISPR 22 2006 ClassB BSMI MIC 7 3 FDA COMPLIANCE The product satisfies all the requirements specified in the Code of Federal Regulation 21CFR part 1040 10 and 1040 11 7 4 RoHS COMPLIANCE The product complies with EU Directive 2002 95 EC RoHS 8 ACOUSTIC NOISE 8 1 GENERAL Noise measurement must conform to the testing procedure for measuring Acoustic Noise on office equipment as specified by the ISO Standard ISO 7779 Seated Operator Position 8 2 TEST CONDITION The test condition is free field condition over are flexing plane This condition can be simulated in an echoic chamber with the disc drive sitting on a reflecting plane The drive is acoustically isolated from the plane with e g a polyurethane foam Test Media 0 3gfcm unbalanced media Mode Read DVD at 16x CAV speed 8 3 NOISE SPECIFICATION A Weighted RMS Slow Drive On Seeking 45dB A Average 47 5dB A Max Drive On non seek 45dB A Average 47 5dB A Max TEAC Corporation DVD CD Rewritable Drive Specification DV W5500S 000 Rev 0 94 17 24 9 MECHANICAL 9 1 DIMENSIONS AND MOUNTING ORIENTATION 9
7. 1 1 DIMENSIONS 148 2 03 132 d m 254 aaa 50 1 uesa baie DV W5500S 545 Permission limit Max 6 5kgf cm ful 2 General Tolerance 0 5 9 12 MOUNTING ORIENTATION This drive unit shall be installed and operated in the horizontal and vertical orientation The drive operates in the horizontal and vertical orientation within the angular tolerance range described below Horizontal front side up or down 15 deg left side up or down 15 deg Vertical front side up or down 15 deg top side up or down 15 deg 9 1 3 WEIGHT 0 630Kg 9 2 COLOR 9 2 1 EJECT BUTTON FRONT BEZEL AND TRAY DOOR Manual eject button front bezel and tray door shall be molded as follows Material PC ABS Flame Retardant Grade UL94 5V Tray door 94V 0 Color BLACK Finish Mat 922 TRAY Tray shall be molded as follows Material ABS Frame Retardant Grade UL94V 2 Color BLACK Finish Mat 9 2 3 ACTIVITY LED Busy Green TEAC Corporation DVD CD Rewritable Drive Specification DV W5500S 000 Rev 0 94 18 24 9 3 APPLICABLE CABLE 9 3 1 SIGNAL CABLE The signal cable is a 7 wire flat ribbon cable It has a 7 pin female connector on one side to connect to the 7 pin shrouded male Serial ATA connector on the PC mother board or els
8. 9 5 3 EJECT COMMAND 9 5 4 PUSH TRAY IN POSITION 9 5 5 OPEN CLOSE TIME OUT 10 ELECTRICAL 10 1 POWER 10 1 1 VOLTAGE 10 1 1 1 VOLTAGE TOLERANCE 10 1 1 2 RIPPLE AND NOISE TOLERANCE 10 1 2 CURRENT 10 2 Serial ATA INTERFACE 10 2 1 GENERAL 10 2 2 ELECTRICAL 10 2 2 1 CONNECTORS 10 2 2 2 CONNECTOR PIN DEFINITION 10 2 2 3 SIGNAL TYPE 10 2 3 COMMANDS 10 2 3 1 GENERAL 10 2 3 2 TASK FILE RESISTER 10 2 3 3 TASK FILE COMMANDS 10 2 3 4 PACKET COMMANDS 10 3 DATA BUFFER 11 PACKAGING 11 1 GENERAL Appendix Revision Figure 1 MECHANICAL DRAWING Attached sheet of paper TEAC Corporation DVD CD Rewritable Drive Specification DV W5500S 000 Rev 0 94 3 24 1 INTRODUCTION AND SCOPE This document contains information for OEM customer to purchase the internal are DVD CD Rewritable drive model DV W5500S that is a half height 5 25 form factor with a Serial ATA interface The drive is capable to write DVD RAM Ver 2 discs DVD R discs DVD R Double Layer DVD R DL discs DVD RW discs DVD R discs DVD R Dual Layer DVD R DL discs DVD RW discs CD R discs and CD RW discs and also havs the same function as ordinary DVD ROM drive The drive has 5xCAV speed DVD RAM Ver 2 writing 24xCAV speed DVD R writing 12xCAV speed DVD R DL writing 8xZCLV speed DVD RW writing 24xCAV speed DVD R writing 12xCAV speed DVD R DL writing 6xCLV speed DVD RW writing 48x CAV speed CD R writing and 32xZCLV speed CD RW writing 16xCAV speed DVD ROM reading and 48xCAV
9. D a Format and Modes Supported DVD Video 8cm 12cm Single and Dual Layer DVD ROM 8cm 12cm Single and Dual Layer Multi Border Multi Session b Block Length Supported 2048 bytes sector 4 3 1 2 DVD WRITABLE FORMAT MODES AND BLOCK LENGTH SUPPORTED a Format and Modes Supported DVD Video DVD ROM Multi Border DVD R RW Multi Session DVD R b Block Length Supported 2048 bytes sector 4 3 2 DVD WRITE METHOD SUPPORTED a Uninterrupted Write Disc at Once b Interrupted Write Random write DVD RW DVD RAM Ver 2 Sequential write DVD R RW DVD RAM Ver 2 Incremental DVD R RW Multi Border DVD R RW Restricted overwrite DVD RW 4 3 3 DVD WRITABLE MEDIA Refer to Support Media List for details of media and recording speed a DVD R Media max 16x Media Mitsubishi Verbatim Tatyo Yuden b DVD R DL Media max 16x Media Mitsubishi Verbatim c DVD RW Media max 8x Media Mitsubishi Verbatim Sony d DVD R Media max 16x Media Mitsubishi Verbatim Tatyo Yuden e DVD R DL Media max 12x Media Mitsubishi Verbatim Taiyo Yuden f DVD RW Media max 6x Media JVC Mitsubishi Verbatim g DVD RAM Ver 2 Media max 5x Media Panasonic Hitachi maxell TEAC Corporation DVD CD Rewritable Drive Specification DV W5500S 000 Rev 0 94 8 24 4 3 4 CD MODES AND BLOCK LENGTH SUPPORTED 43 4 1 CD READABLE FORMAT MODES AND BLOCK LENGTH SUPPORTED a Format and Modes Supported CD Audio 8cm 12cm C
10. D ROM mode 1 and mode 2 CD ROM XA mode 2 form 1 and form 2 Photo CD single or multiple sessions CD I FMV Video CD CD Extra CD TEXT b Block Length Supported CD Audio 2352 and 2368 Bytes CD ROM mode 1 2048 and 2352 Bytes CD ROM XA CD I form I 2048 2328 2336 2340 and 2352 Bytes form 2 2328 2336 2340 and 2352 Bytes 4 3 4 2 CD WRITABLE FORMAT MODES AND BLOCK LENGTH SUPPORTED a Format and Modes Supported CD Audio 8cm 12cm CD ROM mode 1 and mode 2 CD ROM XA mode 2 form 1 and form 2 Photo CD single or multiple sessions CD I FMV Video CD CD Extra CD TEXT b Block Length Supported CD Audio 2352 Bytes CD ROM mode 1 2048 Bytes CD ROM XA CD I form I 2048 and 2332 Bytes form 2 2332 Bytes 4 3 5 CD WRITE METHOD SUPPORTED a Uninterrupted Write Disc at Once b Interrupted Write Track at Once Session at Once Packet Writing Fixed size Packets Variable size Packets 4 3 6 CD WRITABLE MEDIA Refer to Support Media List for details of media and recording speed a CD R Media max 52x Media Mitsubishi Verbatim Tatyo Yuden b CD RW Media max 32x Media Mitsubishi Verbatim TEAC Corporation DVD CD Rewritable Drive Specification DV W5500S 000 Rev 0 94 9 24 4 3 7 TRANSFER RATE 4 3 7 1 READ SPEED AND TRANSFER RATE a b c d e Ww 8 USER BYTES SEC SUSTAINED 1 kBytes 1024 Bytes I Mbyte 1024KByte DVD ROM Read Speed and Transfer Rate Single Laye
11. DVD CD Rewritable Drive Product Specification Model DV W5500S 000 Drive Specification Confidential Revision 0 94 Mar 1 2012 TEAC Corporation Planned by Authorized by TEAC Corporation DVD CD Rewritable Drive Specification DV W5500S 000 Rev 0 94 1 24 TABLE OF CONTENTS 1 INTRODUCTION AND SCOPE 2 APPLICABLE DOCUMENTS 3 PRODUCT DEFINITION 3 1 3 2 GENERAL PRODUCT DESCRIPTION 4 PERFORMANCE AND FUNCTIONAL REQUIREMENTS 4 1 4 2 4 3 GENERAL SUMMARY OF STANDARD PERFORMANCE 4 2 1 DVD medium 4 2 2 CD medium PERFORMANCE REQUIREMENTS 4 3 1 DVD MODES AND BLOCK LENGTH SUPPORTED 4 3 1 1 DVD READABLE FORMAT MODES AND BLOCK LENGTH SUPPORTED 4 3 1 2 DVD WRITABLE FORMAT MODES AND BLOCK LENGTH SUPPORTED 4 3 2 DVD WRITE METHOD SUPPORTED 4 3 3 DVD WRITABLE MEDIA 4 3 4 CD MODES AND BLOCK LENGTH SUPPORTED 4 3 4 1 CD READABLE FORMAT MODES AND BLOCK LENGTH SUPPORTED 4 3 4 2 CD WRITABLE FORMAT MODES AND BLOCK LENGTH SUPPORTED 4 3 5 CD WRITE METHOD SUPPORTED 4 3 6 CD WRITABLE MEDIA 4 3 7 TRANSFER RATE 4 3 7 1 READ SPEED AND TRANSFER RATE 4 3 7 2 WRITE SPEED AND TRANSFER RATE 4 3 8 SERIAL ATA INTERFACE 4 3 9 ROTATION SPEED 4 3 9 1 DVD Rotation Speed 4 3 9 2 DVD RAM Version 2 Rotation Speed 4 3 9 3 CD Rotation Speed 4 3 10 ACCESS TIME INCLUDING LATENCY 4 3 10 1 DVD medium 4 3 10 2 CD medium 4 3 11 SPIN UP AND TRAY OPEN TIME 4 3 12 USER ERROR RATES 4 3 13 MPC3 COMPLIANCE 4 3 14 FLASH ROM UPDATE 4 3
12. UCTURE AD READ FORMAT CAPACITIES READ HEADER o READ SUB CHANNEL 4 READ TOC PMA ATIP i O READ TRACK INFORMATION REPAIR TRACK o REPORT KEY 4 REQUEST SENSE 4 gt gt U R IIN gt 5 mele AS S Nn a gt N gt 4 a 1Bh Nn ON Ww 5 D 5 gt ZIS 10 3 DATA BUFFER The drive electronics includes 1 MBytes read ahead data buffer in the Serial ATA System controller 11 PACKAGING 11 1 GENERAL The drives 20 sets will be packed in a bulk carton using a foam insert to protect against shock and vibration TEAC Corporation DVD CD Rewritable Drive Specification DV W5500S 000 Rev 0 94 23 24 Revision 1 00 2011 Oct 28th Released TEAC Corporation DVD CD Rewritable Drive Specification DV W5500S 000 Rev 0 94 24 24
13. VOLTAGE TOLERANCE 5V DC 12V DC 10 1 1 2 RIPPLE AND NOISE TOLERANCE 5V DC 12V DC 10 1 2 CURRENT max average 5 10 lt 120 mV peak to peak lt 200 mV peak to peak Spinup 5V DC lt 1050 1000 mA 12V DC lt 2400 2300 mA Seek CD 20 48x CAV 5V DC 12V DC Read CD 20 48x CAV 5V DC 12V DC Read DVD 6 6 16x CAV lt 1000 800 mA lt 1200 1000 mA lt 1000 800 mA lt 1200 1000 mA 5V DC lt 1100 900 mA 12V DC lt 1200 1000 mA Write CD 20 48x CAV 5V DC lt 1300 1200 mA 12V DC lt 1000 900 mA Write DVD R 10 24x CAV 5V DC lt 1450 1400 mA 12V DC lt 2300 2200 mA Tray Open Close 5V DC lt 700 600 mA 12V DC lt 1000 300 mA Idle CD 4 10x CAV Pause 5V DC 12V DC Standby laser amp motor off lt 750 650 mA lt 500 400 mA 5V DC lt 300 300 mA 12V DC lt 50 30 mA Sleep 5V DC lt 300 300 mA 12V DC lt 50 30 mA Note Average current is the arithmetic mean value of the current measured during a typical 4 second period Maximum current is the arithmetic mean value of the current measured during a typical 0 5 second period TEAC Corporation DVD CD Rewritable Drive Specification DV W5500S 000 Rev 0 94 21 24 10 2 Serial ATA INTERFACE 10 2 1 GENERAL This drive unit used Serial ATA interface which conforms to the Mt Fu
14. ce supports 6 6 16xCAV speed for DVD ROM data tracks transfer rate of 22MBytes sec outside track and 20 48xCAV speed for data tracks with a sustained mode 1 data transfer rate of 7200kBytes sec outside track respectively The Serial ATA controller has a 1Mbytes data buffer and insures that in all cases a full block of data is transferred at the designated data transfer rate on the Serial ATA bus as specified in section 4 3 7 As for the drive it is equipped with the buffer under run protection feature in writing The mechanical design of this drive is a completely sealed construction to prevent any air passage through the unit and dust contamination All of the through holes especially the openings around the connectors in the rear panel is sealed TEAC Corporation DVD CD Rewritable Drive Specification DV W5500S 000 Rev 0 94 5 24 4 PERFORMANCE AND FUNCTIONAL REQUIREMENTS 4 1 GENERAL The performance and functionality of the DVD CD rewritable drive system is determined in part by the world wide standards It is the intention of this document to adhere to these standards unless otherwise specifically noted A summary of these standard specifications are presented here for reference purposes only Refer to the applicable documents for additional detail 4 2 SUMMARY OF STANDARD PERFORMANCE Below is a brief summary of performance and functional specifications as set for by the standards cited above to be used as quick reference inf
15. e The pin out of the Serial ATA connector is shown in section 10 2 2 2 9 4 DRIVE CONNECTORS There are 2 connectors DC power connector section 9 4 1 and Serial ATA signal connector section 9 4 2 DC power connector and Serial ATA signal connector are molded to a piece of connector 9 4 1 POWER CONNECTOR The dirve has a DC power connector assembly which consists of a 15 pin shrouded keyed male power connector as shown below 9 4 2 Serial ATA CONNECTOR The drive has a standard 7 pin shrouded keyed male connector for Serial ATA signal For pin out description of Serial ATA interface refer to section 10 2 2 2 Serial ATA interface connectors Part of Power Part of serial ATA signal connector TEAC Corporation DVD CD Rewritable Drive Specification DV W5500S 000 Rev 0 94 19 24 9 5 DISC TRAY LOAD MECHANISM This drive uses motor powered tray mechanism to extend and retract the tray for loading and removing the disc from the drive When the drive is mounted in the vertical orientation only 120 mm discs can be used 9 5 1 MANUAL EJECT BUTTON The front bezel of the drive unit has a manual eject button to open and close the tray This manual eject button is enabled upon power up 9 5 2 PIN HOLE EMERGENCY EJECT A pin hole eject mechanism is required to open the tray in emergency situation Maximum force required is 1 5kg The pin hole is located on the front bezel 9 5 3 EJECT COMMAND The host can also o
16. e diagnostic ee o oe ATAPI Packet Command Fam ATAPI Identify Device me er ATAPI Soft Reset 08h o y Check Power Mode Esh fo Idle Immediate En y Idle 3h Set Features PH f Standby immediate OH PO Standby o a fk Sleep em TEAC Corporation DVD CD Rewritable Drive Specification DV W5500S 000 Rev 0 94 22 24 10 2 3 4 PACKET COMMANDS Command Op code Remark Z Er BLANK CLOSE TRACK SESSION 5Bh FORMAT UNIT 0 GET CONFIGURATION GET PERFORMANCE GET EVENT STATUS NOTIFICATION INQUIRY MECHANISM STATUS MODE SELECT 10 MODE SENSE 10 5Ah PREVENT ALLOW MEDIUM REMOVAL 1Eh READ 10 8 READ 12 READ BUFFER CAPACITY READ CAPACITY READ CD READ CD MSF READ DISC INFORMATION READ DVD STRUCTURE READ FORMAT CAPACITIES READ HEADER READ SUB CHANNEL READ TOC PMA ATIP READ TRACK INFORMATION REPAIR TRACK REPORT KEY REQUEST SENSE RESERVE TRACK REZERO UNIT SEND DVD STRUCTURE SEEK 2Bh SEND CUE SHEET SEND EVENT SEND KEY SEND OPC INFORMATION SET CD ROM SPEED SET STREAMING START STOP UNIT SYNCHRONIZE CACHE TEST UNIT READY 00h VERIFY 10 2Fh WRITE 10 A WRITE 12 WRITE AND VERIFY 10 2Eh X gt A Qe N NALS MN Q oo S gt gt 5 m gt nl dad 512 N Q a a PREVENT ALLOW MEDIUM REMOVAL READUO 4 READ S READ BUFFER CAPACITY READ CAPACITY o READCD 4 READCDMSF 4 READ DISC INFORMATION _ READ DVD STR
17. eed DVD R DL writing and 8xZCLV speed DVD RW writing Random Sequential and Multi Session 24xCAV speed DVD R writing and 12xCAV speed DVD R DL writing and 6xCLV speed DVD RW writing Disc at Once Incremental and Multi Border Restricted overwrite DVD RW only 48xCAV speed CD R writing and 32xZCLV speed CD RW writing Disc at Once Track at Once Session at Once Variable size Packets and Fixed size Packets This drive does not have CD DA audio circuitry and ADPCM audio circuitry required to support audio modes other than CD DA specified in CD ROM XA Also the audio circuitry inside this drive is not for DVD Audio This drive unit is designed with a sealed construction to ensure dust free operation This drive unit accepts a standard CD disc using a power tray for both loading and unloading and can operate in both the horizontal and vertical orientation This drive unit is used inside the host computer 3 2 PRODUCT DESCRIPTION The drive unit has an optical pickup head servo electronics to maintain correct focus tracking feed position radial tilt and spindle speed digital electronics to recover the recorded data and provide error correction in Mode 1 and Mode 2 Form I to the maximum capabilities of the CD ROM ECC and a Serial ATA interface to the host computer This drive has hardware layered error correction LECC for the main channel data of the CD ROM This drive unit also provides error correction of the DVD Video and DVD ROM This devi
18. ji Commands for CD and DVD Devices SFF8090v4 rev 1 00 to communicate with the host computer IDE interface ISO X3T9 2 791D addresses the electrical interface The ATAPI CD ROM specification SFF 8020 Rev 2 6 addresses command protocol 10 2 2 ELECTORICAL The Serial ATA bus uses differential drivers and receivers 10 2 2 1 CONNECTORS A standard 7 pin flat ribbon cable 10 2 2 2 CONNECTOR PIN DIFINITION 7 pin Serial ATA male connector IRRABQDN E Description GND 2 mate A Differential signal pair A from Phy A GND 2 mate B Differential signal pair B from Phy B GND 2 mate 10 2 2 3 SIGNAL CHARACTERITICS n units Comments Vcm de mV Common mode DC level measured at Receiver connector 10 2 3 COMMANDS 10 2 3 1 GENERAL This drive unit implements The ATAPI DVD R RW R RW RAM and CD R RW commands and features The following is a brief description of the ATAPI DVD R RW R RW and CD R RW features to be implemented Command description is provided by the ATAPI CD R RW specification ATA Packet Interface for CD ROMs SFF 8020i Revision 2 6 SCSI 3 Multimedia Commands X3T10 1048D Revision10A SCSI Multimedia Commands 2 T10 1228 D Revision10a SCSI Multimedia Commands 5 MMC 5 SFF8090iv5 Rev 0 7 Mt Fuji Commands for Multimedia Devices DV W5500S ATAPI IDE SATA Command Set Specification 10 2 3 2 TASK FILE RESISTER 10 2 3 3 TASK FILE COMMANDS NOP Execute driv
19. n DVD CD Rewritable Drive Specification DV W5500S 000 Rev 0 94 14 24 5 ENVIRONMENTAL This section establishes the environmental and physical conditions which apply to the product The CD R RW meet the following environmental requirements under normal operating conditions 5 1 TEMPERATURE NON CONDENSING 5 1 1 NON OPERATING 40 deg C to 65 deg C 5 12 OPERATING 5 deg C to 50 deg C 5 2 HUMIDITY 5 2 1 NON OPERATING 5 to95 No condensation Maximum wet bulb temp 38 deg C 5 2 2 OPERATING 20 to 80 No condensation Maximum wet bulb temp 29 deg C 5 3 VIBRATION 5 3 1 OPERATING The drive unit meet specification described below with continuous random vibration Acceleration CD Read 0 45Grms Write 0 2Grms DVD Read 0 45Grms Write 0 2Grms Vibration Random mode 5 to 500 Hz Direction of vibration X Y and Z axis 5 3 2 NON OPERATING The drive unit meet specification described below with continuous random vibration Acceleration 0 712GRMS Direction of vibration X Y and Z axis Frequeccy 7 800Hz Hz G 2 Hz 7 0 0003 20 0 00275 140 0 00275 312 0 00013 400 0 00008 600 0 00008 700 0 00007 800 0 000045 54 SHOCK 5 4 1 NON OPERATING The drive unit can withstand shock with a 1 2 sine wave shape Discs are not in the drive at all and the drive is powered off Pulse Duration and Peak level 10ms 100G and 2ms 200G Direction of shock X Y and Z axes 2 directions per axi
20. ocks Sec 20 48x CAV speed 74 minutes and 42 seconds 1 120 mm or 80 mm 15 mm diameter 1 2 mm 1 6 microns 15 875 TPD typical 1 2 1 4 meters sec Normal Speed Varies over radius 535 to 198 rpm Normal Speed Variable 55 to 150 msec Normal Speed Variable 9 1 to 21 1 blocks rotation Variable TEAC Corporation DVD CD Rewritable Drive Specification DV W5500S 000 Rev 0 94 7 24 4 3 PERFORMANCE REQUIREMENTS Unless otherwise indicated the following performance specifications will be met over the temperature humidity and voltage range called out in section 5 0 and 10 0 of this document and will be verified using a test disc The drive can write in maximum 24X CAV speed for DVD R and DVD R discs 8X ZCLV speed for DVD RW discs 6X ZCLV speed for DVD RW discs 12X CAV speed for DVD R DL discs 12X CAV speed for DVD R DL discs 5xCAV speed for DVD RAM Ver 2 discs 48X CAV speed for CD R discs and 32X ZCLV for CD RW discs The drive can operate in maximum 16X speed for DVD data tracks and maximum 48X speed for CD ROM data tracks The drive can read 5x CAV for DVD RAM discs Note The drive can read 12x speed for the DVD RAM that was written at 12x by the drive which supports 12x write for DVD RAM The drive changes operating speed automatically based on the disc quality The default setting is maximum speed 4 3 1 DVD MODES AND BLOCK LENGTH SUPPORTED 4 3 1 1 DVD READABLE FORMAT MODES AND BLOCK LENGTH SUPPORTE
21. ormat Specifications Ver 1 2 December 2002 Reference Only SFF8090iv5 Rev 0 7 Mt Fuji Commands for Multimedia Devices Reference Only ANSI Document SCSI Multimedia Commands 5 MMC 5 T10 1363D Rev 10g Nov 12 2001 Reference Only DVD RAM Part1 Physical Specifications Version 2 0 DVD Specifications for Re recordable Disc for Dual Layer Part1 Ver 1 9 Nov 29 2005 Reference Only Serial ATA High Speed Serialized AT Attachment Revision 1 0a Serial ATA International Organization Serial ATA Rev2 6 TEAC Corporation DVD CD Rewritable Drive Specification DV W5500S 000 Rev 0 94 4 24 3 PRODUCT DEFINITION 3 1 GENERAL This drive unit is compatible of playing DVD ROM DVD R DVD R DL DVD RW DVD R DVD R DL DVD RW DVD RAM Ver 2 CD Audio CD ROM mode 1 and mode 2 CD ROM XA mode 2 form I and form 2 Photo CD single and multiple sessions CD Extra CD R CD RW CD TEXT discs This drive unit can playback CD I FMV and VIDEO CD with special hardware This drive unit can also play DVD Video with special function such as MPEG decoder This drive unit can operate in 6 6 16xCA V Constant Angular Velocity speed at DVD ROM data and 20 48xCAV speed at reading CD ROM for data tracks with a sustained mode 1 data transfer rate of 7200kBytes sec outside track respectively This drive supports these writing modes and methods as below 5xCAV speed DVD RAM Ver 2 writing Random and Sequential 24xCAV speed DVD R writing and 12xCAV sp
22. ormation 4 2 1 DVD medium USER DATA CAPACITY 4 7GBytes Single layer 12cm 1 GBytes 1000 x 1000 x 1000 8 54GBytes Dual Double layer 12cm 1 46Gbytes Single layer 8cm 2 66Gbytes Dual layer 8cm USER DATA BLOCK Excluding sync header and ECC bytes 2048Bytes ADDRESS DESCRIPTION Block RECORDING SURFACES 2 LAYER Single or Dual DISC DIAMETER 120 mm or 80 mm DISC CENTER HOLE 15 mm diameter THICKNESS 1 2 mm TRACK PITCH 0 74 microns typical SCANNING VELOCITY 3 49 meters sec Single layer Normal Speed 3 84 meters sec Dual layer Normal Speed ROTATION SPEED Varies over radius 1388 to 574 rpm Normal Speed Variable TEAC Corporation DVD CD Rewritable Drive Specification DV W5500S 000 Rev 0 94 6 24 4 2 2 CD medium The following specification marked with an is a calculated and practical maximum figure based on a 1 6um track pitch USER DATA CAPACITY 1 MBytes 1024 x 1024 RECORDING PLA YING TIME NUMBER OF BLOCKS DISC 656MBytes Mode 1 748MBytes Mode 2 74 minutes and 42 seconds 336 150 USER DATA BLOCK Excluding sync header subheader and ECC bytes ADDRESS DESCRIPTION BLOCK RATE AUDIO PLAYING TIME DISC RECORDING SURFACES DISC DIAMETER DISC CENTER HOLE THICKNESS TRACK PITCH SCANNING VELOCITY ROTATION SPEED LATENCY AVERAGE BLOCKS ROTATION 2048 Bytes Mode 1 and Mode 2 Form I 2336 Bytes Mode 2 2328 Bytes Mode 2 Form 2 Min Sec Frame 1500 3600 Bl
23. pen the tray load from the drive through a ATAPI command 9 5 4 PUSH TRAY IN POSITION In addition to the eject button for closing the tray the tray will automatically close when the tray is in the open extended position by pushing the tray in 10 mm typical distance with a 500 g typical force 9 5 5 OPEN CLOSE TIME OUT TRAY OPEN TIME OUT If there is a physical obstruction that prevents the tray from opening extending all the way the power tray will remain on for two seconds If tray is still prevented from opening at the end of two seconds the drive will try to close the tray If tray is prevented to close after two seconds the power tray is turned off The user has to either push the manual eject button or send a ATAPI CD ROM eject command to reset the power tray TRAY CLOSE TIME OUT If there is a physical obstruction that prevents the tray from closing retracting all the way the power tray will remain on for two seconds If tray is still prevented from closing at the end of two seconds the drive will try to open the tray If tray is prevented to open then after two seconds the power tray is turned off The user has to either push the manual eject button or send a ATAPI eject command to reset the power tray TEAC Corporation DVD CD Rewritable Drive Specification DV W5500S 000 Rev 0 94 20 24 10 ELECTRICAL 10 1 POWER 10 1 1 VOLTAGE This drive requires two power supplies 5V DC 12V DC 10 1 1 1
24. r 6 6 16x CAV 8 7 21 1 MBytes sec Dual Layer 5 12x CAV 6 6 15 8 MBytes sec DVD R Data tracks Read Speed and Transfer Rate 6 6 16x CAV 8 7 21 1 MBytes sec DVD R DL Data tracks Read Speed and Transfer Rate 5 12x CAV 6 6 15 8 MBytes sec DVD RW Data tracks Read Speed and Transfer Rate 5 13x CAV 6 6 17 2 MBytes sec DVD Video with CSS protection Read Speed and Transfer Rate SL 6 6 16x CAV 8 7 21 1 MBytes sec DL 5 12x CAV 6 6 15 8 MBytes sec DVD RAM Data tracks Read Speed and Transfer Rate 5x CAV 6 6 MBytes sec CD ROM CD R Read Speed and Transfer Rate Mode 1 and Mode 2 Form 1 2048 Bytes 20 48x CAV CD RW Read Speed and Transfer Rate Mode 1 and Mode 2 Form 1 2048 Bytes 3000 7200 kBytes sec 17 40xPCAV 2550 6000 kBytes sec DAE Read Speed and Transfer Rate 17 40x PCAV 2550 6000 kBytes sec Mode 2 and Mode 2 Form2 Read Speed and Transfer Rate 8 20x CAV 1200 3000 kBytes sec 4 3 7 2 WRITE SPEED AND TRANSFER RATE a DVD R Write Speed 24x CAV 13 2 31 7 MBytes sec 20x CAV 11 0 26 4 MBytes sec 18x CAV 9 9 23 8 MBytes sec 16x CAV 8 7 21 1 MBytes sec 13x CAV 6 6 17 2 MBytes sec 12x ZCLV 7 9 15 8 MBytes sec 8x ZCLV 7 9 10 6 MBytes sec 6x CLV 7 9 MBytes sec 4x CLV 5 3 MBytes sec 2 4x CLV 3 2 MBytes sec b DVD R DL Write Speed 12x CAV 6 6 15 8 MBytes sec 8x ZCLV 5 3 10 6 Mbytes sec 6x ZCLV 5 3 8 7 MBytes sec 4x CLV 5 3 MBytes sec 2 4x CLV 3 2 MBytes sec c DVD RW Write Speed 8x ZCLV 7 9 10
25. s so a total of 6shocks 5 42 OPERATING The drive unit can withstand shock with a 1 2 sine wave shape Data read with retry Not specified about audio play Pulse Duration 11 msec Peak level CD Read 6G Write 1 5G DVD Read 6G Write 1G Direction of shock X Y and Z axes 2 directions per axis so a total of 6shocks Pulse Duration and Peak level 2ms 60G Read CD amp DVD TEAC Corporation DVD CD Rewritable Drive Specification DV W5500S 000 Rev 0 94 15 24 Direction of shock Horizontal Z Left side down Z Right side down Z 5 5 VIBRATION AND DROP PACKAGED 5 5 1 VIBRATION PACKAGED The unit meets the specification described below Test time 30 minutes side Test Axes 6 surface Vibration Random mode Spectrum Break Points Frequency G2 Hz 1Hz 0 0001 4Hz 0 01 100Hz 0 01 200Hz 0 001 Total random vibration spectrum energy shall be 1 146 Grms Packaged Bulk Carton 20 sets 5 5 2 DROP PACKAGED The unit meets the specification described below Height 76cm 6 surfaces 1 corners 3 edges Packaged Bulk Carton 20 sets 6 QUALITY AND RELIABILITY 6 1 COSMETIC No scratches cracks stains and damages are visible on the front panel in case that you take a look at them at the distance of 400 mm from away it No scratches cracks stains and damages are visible on the top bottom side and rear panel in case that a look at them at the distance of 600 mm from away it
26. s sec 1 3 MBytes sec 6 6 MBytes sec 4 0 MBytes sec 2 6 MBytes sec 3000 7200 kBytes sec 2550 6000 kBytes sec 3000 4800 kBytes sec 3000 3600 kBytes sec 2400 kBytes sec 1200 kBytes sec 2400 4800 kBytes sec 2400 3600 kBytes sec 2400 kBytes sec 1500 kBytes sec 600 kBytes sec support support 13900 rpm Constant 11500 rpm Constant 10350 rpm Constant 9200 rpm Constant 7400 rpm Constant 6600 8800 rpm 4400 8800 rpm 4400 6600 rpm 3450 8300 rpm 3450 6600 rpm 5100 rpm Constant 4580 rpm Constant 3200 rpm Constant 2900 rpm Constant 2298 5554 rpm 1379 3333 rpm 1149 2777 rpm 574 1389 rpm 8253 9738 rpm 3439 8115 rpm 2063 4869 rpm DVD CD Rewritable Drive Specification DV W5500S 000 Rev 0 94 11 24 d 2x CLV 1375 3246 rpm 4 3 9 3 CD Rotation Speed a 20 48x CAV 9600 rpm Constant b 20 48x ZCLV 7970 9600 rpm c 17 40x PCAV 8350 rpm Constant d 20 40x ZCLV 7930 9600 rpm e 13 32x CAV 6950 rpm Constant f 17 32x PCAV 6350 8350 rpm g 20 32x ZCLV CD R 6350 9600 rpm h 16 32x ZCLV CD RW 4940 7400 rpm i 10 24x CAV 5460 rpm Constant j 17 24x PCAV 4760 8350 rpm k 20 24x ZCLV CD R 4760 9600 rpm 1 16 24x ZCLV CD RW 4760 7400 rpm m 8 20x CAV 4200 rpm Constant n 4 10x CAV 2100 rpm Constant o 16x CLV 3424 7952 rpm p 10x CLV 2140 4970 rpm q 8x CLV 1712 3976 rpm r 4x CLV 856 1988 rpm 4 3 10 ACCESS TIME INCLUDING LATENCY
27. sec and no less than 16 KB of block size 4 3 14 FLASH ROM UPDATE The firmware is updated via Serial ATA interface with Flash ROM Utility 4 3 15 DVD Content Scramble System Authentication This drive fully complies with the ATAPI DVD Key Exchange and Authentication specification which is a digital cryptograph 4 3 16 Region Playback Control This drive supports RPC phase II provided by SFF8090v4 Rev 1 5 The user can change the region code which is stored in the drive up to 5 times by sending the appropriate command Usually the command is issued by MPEG Player application 4 3 17 Maximum Playback Speed with various Disc The maximum playback speed with various disc is limited as follows DVD ROM Dual Layer 5 12x CAV DVD Video with CSS protection SL 3 3 8x CAV DL 3 3 8x CAV DVD R DL Data tracks 5 12x CAV DVD RW Data tracks 5 13x CAV DVD RAM Data tracks 5x CAV CD DA DAE 8 20x CAV CDROM mode form2 8 20x CAV CD RW model mode2 form1 17 40x PCAV In addition the drive will limit the maximum playback speed automatically by the quality of the disc The drive may playback with lower speed than the speed mentioned above 4 3 18 Tolerance pertaining to Media TEAC Corporation DVD CD Rewritable Drive Specification DV W5500S 000 Rev 0 94 13 24 The drive can read the following Media Black dot Finger Print CD less than 0 6 mm less than 65 um DVD less than 0 6 mm less than 65 um TEAC Corporatio
28. speed CD ROM reading capabilites and supports various DVD and CD formats The drive have a power tray disc loading mechanism The drive will be mounted and used in the horizontal orientation and vertical orientation The drive has Busy LED 2 APPLICABLE DOCUMENTS DV W5500S ATAPI IDE SATA Command Set Specification CD Audio Red Book Reference Reference Only CD ROM Yellow Book Reference Reference Only CD ROM XA Reference Reference Only CD I Green Book Reference Reference Only CD WO Orange Book Part 2 Reference Reference Only CD RW Orange Book Part 3 Reference Reference Only Video CD White Book Reference Reference Only ATAPI CD ROM specification SFF 8020i Rev 2 6 Reference only CD TEXT Red Book Reference Reference Only ANSI Document AT Attachment with Packet Interface 7 Volume1 3 ATA ATAPI 7 T13 1532D Rev 4b 21 Apr 2004 CD TEXT Red Book Reference Reference Only DVD Specifications for Read Only Disc Ver 1 0 August 1996 Reference Only DVD Specifications for Recordable Disc for General Ver 2 0 May 2000 Reference Only DVD Specifications for Re recordable Disc Ver 1 2 December 2003 Reference Only DVD R 4 7Gbytes Basic Format Specifications Ver 1 2 July 2003 Reference Only DVD R 8 5GBytes Basic Format Specifications Ver 1 0 March 2004 Reference Only DVD Specifications for Recordable Disc for Dual Layer Version 3 0 February 2005 Reference Only DVD ReWritable 4 7Gbytes Basic F

Download Pdf Manuals

image

Related Search

Related Contents

KIT TEN-R  View LX Installation Instructions  Manual de usuario Beetel Lynx  Manual mando a distancia  Samsung i100 Manuel de l'utilisateur  Télécharger la notice complète en pdf  DISQUE DUR EXTERNE 320Go MSDD320  KM 150/500 R Bp  Méditations  Kenwood TR-7400A User's Manual  

Copyright © All rights reserved.
Failed to retrieve file