Scosche FD134030B mounting kit
Contents
1. and FD22 FD10 to FD20 adapter are included for aftermarket radio installations CAUTION Disconnect your vehicle s negative battery terminal before the installa tion to help prevent electrical damage We recommend the use of a volt ohm meter over a test light to check wiring A test light or grounded wire probe can cause damage to the vehicle s computer and or diagnostic systems Avoid all factory air bag wiring air bags can accidentally deploy causing serious injury or death FACTORY STEREO REMOVAL 1 Insert DIN removal tools to release factory stereo climate control panel Unplug all electrical connectors and vacuum lines remove panel FD134030 KIT PREPARATION CLIMATE CONTROL KNOB HOUSING REMOVAL 1 Align the control knobs to vertical position then carefully pull off three rotary control knobs from the face of the factory radio control panel 2 From the back side of the factory control panel extract one 1 5mm screw from the FAN switch twist out counter clockwise to remove Repeat this procedure clockwise for the TEMPERATURE switch 3 From the back side of the factory control panel loosen the three 3 torx head panel retention screws located next to the switches removed Carefully release the tape covering the bottom edge of the control panel the tape will be refitted Carefully separate bottom of panel about 1 4 Use a small screwdriver to release vacuum control retention clips 4 Reattach all switche2. FACTORY WIRING CODES NOTE e All wire codes are viewed as looking at the front of the plug with the wires exiting the rear Use these wiring codes as a guide Your vehicle might differ BLACK 14 SPEAKER INPUT frap ESRA 12345678 2 LR 9 Open 3 RR 10 Power Antenna oo0oo0oo0o o0oo0o oo0 4 RR 11 Open 5 LF 12 Ground 6 LF 13 Ground 7 RF 14 Battery 12V Located in trunk 9 10 11 12 13 14 1996 97 VEHICLES GRAY PLUG 8 PIN 1 Illumination 1 2 3 2 Ground 3 Battery 12V 4 Open 5 Open 6 Ground 7 Open 8 Accessory 12V 4 5678 BLACK 16 PIN 1 Led Defrost On 12V 9 Open 2 Open 10 Momentary Defrost on 3 Not Used 11 Open 4 Not Used 12 Open 5 Not Used 13 Not Used 6 Not Used 14 Open 7 Not Used 15 Not Used 8 Not Used 16 Not Used Not Used Substitute Not for aftermarket use 1998 UP VEHICLES POWER AND SPEAKER White Pink Not Used Blue White Not Used Black Not Used Green Violet Defroster on Indicator Black Pink 12V Accessory Empty Light Green Black Not Used Empty Light Blue Black Not Used 10 Black Larger Gauge 12V Chassis Ground 11 Brown Light Green Not Used 12 Gray Not Used 13 Empty 14 Blue Orange Defroster Switch Wire Momentary Ground 15 Red Yellow Not Used 16 Gray Red Not used 17 Tan Not Used 18 Light Blu
3. e Pink Not Used 19 Black Light Green Not Used 20 White 12V Constant OONDABRWDND SCOSCHE FD134030 IN DASH INSTALLATION KIT FOR 1996 99 FORD TAURUS 1996 99 MERCURY SABLE WITH ROTARY CLIMATE CONTROLS Minor modification may be necessary on console model See shaded area LIABILITY DISCLAIMER This instruction booklet is based on carefully documented data and research of automobile dash disassembly wire harness codes and information pertaining to installation of this kit FD134030 in 1996 99 Ford Taurus and Mercury Sable Vehicles Scosche Industries Inc can not be held responsible for discrepancies inconsistencies that may occur due to the automobile during the installation of components while using this booklet TECH HELP 1 800 621 3695 ext 3 SI 4 04 FD134030 3000408 If you have any further questions call 2004 SCOSCHE INDUSTRIES INC INTRODUCTION Thank you for purchasing the Scosche FD134030 installation panel The FD134030 replaces the factory radio integrated control panel while maintaining the original Rotary Climate Controls and hardware The factory radio dash panel is a control unit only the amplifier and tuner sections of the radio are remote located in left side of trunk on sedans or left rear behind the spare tire in wagons see illustration C The antenna cable is also located at the rear module The Scosche FD12 18ft soeaker connector extension FDA 18 antenna extension
4. right to the slots on kit opening and secure radio chassis to brackets using hardware supplied with radio See Illustration B e Snap iso trim ring to kit opening 3 Scosche recommends rear support on all installations by attaching the support strap supplied with the radio to the kit top support mount See Illustrations Bend strap as illustrated for maximum mounting depth REAR SUPPORT ILLUSTRATION A DIN RADIO INSTALLATION K CAUTION REAR SUPPORTING THE RADIO ADDS TO THE INSTALLATION S STRUCTURAL INTEGRITY ILLUSTRATION B DIN ISO MOUNT INSTALLATION REAR SUPPORT RADIO MOUNT SLEEVE TRIM PLATE ISO MOUNT ILLUSTRATION C DIN RADIO INSTALLATION MODULE FACTORY FORD ANTENNA LEAD TUNER AMP ICP s OUTPUT CONTROL PLUG HARNESS
5. s to the back side of the Scosche FD134030 installation panel in the corresponding slots using the factory screws 5 Reattach rotary control knobs MOUNTING CLIPS 1 Extract one 1 T 15 torx screw holding the factory mounting clip from each side Remove clips and reattach to the Scosche FD134030 using the factory screws AFTERMARKET RADIO WIRING CONNECTION 1 Use the supplied connectors constant ignition dimmer and ground wires for Aftermarket radio installation 2 Connect the new radio s speaker outputs to the bare wire ends of the FD12 18 ft speaker extension harness 3 Connect the new radio s antenna lead to the standard male end of the 18 ft antenna extension cable 4 Run extension cables to the rear of the vehicle to connect at the tuner amp unit 2 KIT INSTALLATION 1996 1997 MODELS The FD134030 installation kit comes prepared for 1996 1997 Ford Taurus Mercury Sable applications Connect both the 8 pin Radio power harness and the 16 pin defroster harness into the factory plugs 1998 1999 MODELS Use the supplied FD22 harness to adapt the FD134030 for 1998 1999 models Connect the 8 pin power plug from the FD22 with the corresponding plug on the kit panel Connect the 16 pin defroster harness with the corresponding plug on the kit panel See picture to the right STEREO INSTALLATION 1 DIN front load installation See Illustration A 2 DIN ISO installation e Attach ISO mount brackets left and
Download Pdf Manuals
Related Search