Fellowes 520CC Paper Shredder User Manual
Contents
1. 10 11 12 the product Unplug this product from the wall outlet before cleaning Clean with a damp cloth using a mild soap and water solution Do not use abrasives or petroleum based cleaners Place this product as close as possible to power source for quick and easy unplugging Do not use this product near water This product should never be placed near or over a radiator or heat source Operate from the type power source indicated on the marking label If you are not sure of the type of power available consult your dealer or local electricity board Do not allow anything to rest on the power cord Do not place this product where people may walk on the cord If an extension cord is used with this product make sure that the total of the ampere ratings on the products plugged into the extension cord do not exceed the extension cord ampere rating Also make sure that the total of all products plugged into the wall outlet does not exceed 15 amps Do not attempt to service this product yourself as opening or removing covers may expose you to dangerous live parts or other risks Unplug this product and refer servicing to qualified personnel under the following conditions When the power cord or plug is damaged or frayed If liquid has been spilled on the product If the product has been exposed to rain If the product does not operate normally when the operating instructions are followed If the product has been dr2. FPM 25 FPM 25 FPM 143 mm s 100 mm s 100 mm s Entry width 16 16 16 400 mm 400 mm 400 mm Motor power 1 1 1 0 8 kw 0 8 kw 0 8 kw Input voltage 100 V 50 Hz 100 V 50 Hz 100 V 50 Hz Depending on country 115 V 60 Hz 115 V 60 Hz 115 V 60 Hz 220 240 V 50 Hz 595 x 470 x 918 mm 194 Ibs 88 kg In idle 60dB Under load 68 dB strip cuts and 75 dB cross cuts Edition 03 98 1 490 999 112 520 520 CC 520 HS Paper shredder Owes 4 Supplies 7 Operation Bags for cut material wa Read operating instructions before putting Packed in dispenser carton 50 or 100 bags to shredder into operation a roll depending on size Contact Fellowes or your local Fellowes dealer for the stock number Pa of the bag that fits your machine OD Insert plug in power outlet Cutting block oil for cross cut units Stock 35250 Install waste bag for shredded material 5 Installation Open front door and completely remove bag frame from cabinet Refer to separate set up instructions for proper Fold new bag around frame assembly Allow bag to overhang frame by Operate this product only from the type of appoximately 7 20 cm power source indicated on the marking label Slide frame with bag back into cabinet Install the paper shredder so that the plug is Close cabinet door easily accessible Shredder must be operated only in upright Switching equipment
3. on position Setup paper shredder so that the ventilation Set main power switch located on back slots are unobstructed To ensure sufficient of shredder to ON 1 position ventilation of the shredder a minimum distance 0 On the 520 HS the security key lock of 4 10 cm to the wall or to the furniture must switch must also be turned on be maintained Green LED lights 6 Caution O e Equipment is ready for operation standby Never insert hand fingers or any foreign objects into the feed Press green arrow button at least 4 sec erous Injury may Cutting system runs in forward direction To shred paper Keep all loose articles of clothing ties jewelery long hair or other loose objects away from feed opening Injury may result Insert paper into the paper feed opening Shredding occurs or Feed paper The shredding process is started by pho Aaye wri oti and unpligths to cell in the paper feeding opening machine before moving servicing cleaning or any other conduct other than normal operation Serious injury may result When the paper feeding opening is free again the cutting system automatically switches off after approx 3 sec and returns to standby When shredding is completed Push stop button Cutting system stops Equipment returns to ready to operate standby condition Switching equipment off Set main power switch located on ba
4. OT BE BINDING UPON FELLOWES 12 Customer Service United States Fellowes Manufacturing Co 1789 Norwood Avenue Itasca IL 60143 Tel 1 800 955 0959 Canada Fellowes Manufacturing of Canada 2750 John Street Markham Ontario L3R 2W4 Tel 1 800 665 4339 United Kingdom Fellowes Manufacturing UK Ltd Doncaster Road Kirk Doncaster South Yorkshire DN3 1HT Tel 01302 885 331 Australia Fellowes Manufacturing Australia Pty Ltd 10 Fellowes Court Tullamarine Victoria 3043 Tel 03 9330 3211 in Melbourne 1 800 331 177 outside Melbourne Nederland Fellowes P O Box 180 4130 Ed Vianen Nederland Tel 0347 377988 Germany Fellowes GmbH Dieselstra e 27 D 30827 Garbsen Tel 05131 49770 France Fellowes Lynx S A 194 all e de la Croix des Hormes 69250 Montanay Tel 33 72 08 25 50 8 1 490 999 112 Edition 03 98
5. POWERSHRED OPERATING INSTRUCTIONS NOTICE D UTILISATION MANUAL DEL PROPIETARIO BETRIEBSANLEITUNG 520 520CC 520HS 1 490 999 112 Edition 03 98 520 520 520 HS Paper shredder Owes Paper shredder Fellowes 520 520 520 HS 3 8 D chiqueteuse Fellowes 520 520 520 9 14 Destructora de documentos Fellowes 520 520 CC 520 15 20 D Aktenvernichter Fellowes 520 520 CC 520 HS 21 26 2 1 490 999 112 Edition 03 98 520 Fellowes 520 cC Contents Contents Page 1 Important Safety INSUUCNONS aid 4 2 Parts Identification zur 4 3 Technical Specifications zn seiner 5 Ele gt a 6 IM 2 6 67 6 7 IDEE 6 8 ee ne 7 ee 7 10 Checklist for Inoperative 7 ete aceite 8 12 Customer Service ida 8 Edition 03 98 1 490 999 112 3 520 520 Fellow 520 HS Paper shredder 1 Important Safety Instructions 2 Parts Identification 1 Read all instructions before use 10 2 Save these instructions for later use 3 Follow all warnings and instructions marked on
6. ck 0 of shredder to OFF 0 position 6 1 490 999 112 Edition 03 98 Paper shredder 520 520 CC 520 HS Feeding continuous forms Pass the leading edge of the form under the paper guide roller 1 and into the paper feed opening 2 Red LED on keyboard lights Shredder reverses automatically and runs in this mode for a few seconds Pull out jam and remove excess paper Caution ry Do not attempt to force the jammed material through the machine by alternating the cutting system between forward and reverse If paper jam cannot be removed Hold down reverse button until paper can be pulled out of the cutting system Press green arrow button at least 4 sec e Continue shredding in smaller quantities so as not to jam the machine further or Continue shredding in smaller quantities so as not to jam the machine further The shredding process is started by a photo cell in the paper feeding opening Note The 520 HS will not run forward again unless the jammed material has been completely removed from the throat Electronic motor overheated Allow shredder to cool down for approx 15 20 min Red LED on keyboard lights e Shredder switches off automatically Press green arrow button at least 4 sec Cabinet door contact ajar bag full Red LED lights Shredder switches off automatically e Make sure cabinet door is properly closed and or empty
7. opped or the casing has been damaged Keep out of the reach of children This shredder should be operated only with an operator in attendance 520 520CC 520HS 1 Membrane keyboard 6 Caution label 2 Security key lock 7 Cabinet 520HS only 8 Cabinet access door 3 Cover 9 Paper feed opening 4 Main power switch 10 Paper guide roller 5 Serial Label oA 1 490 999 112 E 8 OG 6 Ready for operation green LED Cut material bag full red LED Paper jam electric motor overloaded red LED Front door not closed red LED On shredder is switched cutting system runs forward Stop cutting head stops shredder remains ready for operation Reversing cutting system runs in reverse Edition 03 98 Ppaper DIN 19307 SM 4a 70 Dimensions Weight Waste container volume Noise level 220 240 V 50 Hz 2392 181 2 353 4 180 Ibs 82 kg 220 240 V 50 Hz 194 Ibs 88 kg 41 2 gallons 156 liters 520 Fellowes 520 Paper shredder 520 HS 3 Technical Specifications Model 520 Model 520CC Model 520HS Cutting style Strip cut Cross cut High Security Cross cut Shred size 5 32 1 4 BYE 2 1 16 x 5 8 1 32 x7 16 3 9mm 5 8mm 3 9 x 50mm 1 9 x 15mm 78 x 11mm Security rating DIN 32757 1 2 2 3 4 5 Sheet capacity 8 1 2 11 20 10 28 36 38 26 28 19 11 12 A4 70g m 16 Ib 35 50 32 23 15 Speed 32
8. rs are warranted for 5 years from the original purchase date and will be replaced without charge for material or labor if found by Fellowes to be defective Warranty Exclusions The parties agree that the buyer s sole and exclusive remedy against Fellowes shall be for the repair or replacement of defective parts as provided herein The buyer agrees that no other remedy including but not limited to incidental or consequential damages for lost profits lost sales injury to property or any other incidental or consequential loss shall be available to him This warranty shall NOT apply and is void under the following circumstances 1 When this product or any part thereof has been subjected to accident alteration abuse or misuse 2 When the original Model and Serial Number Plate has been altered effaced or removed 3 When repair or service covered under this warranty other than routine maintenance as described in the Owner s Manual has been performed by personnel without the express written consent of Fellowes 4 When the product has been used pursuant to any verbal or written rental lease or loan agreement THIS WARRANTY DESCRIBED HEREIN SHALL BE IN LIEU OF ANY OTHER WARRANTY EXPRESSED OR IMPLIED INCLUDING BUT NOT LIMITED TO ANY IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FORA PARTICULAR PURPOSE ANY REPRESENTA TIONS OR PROMISES INCONSISTENT WITH OR IN ADDITION TO THIS WARRANTY ARE UNAUTHORIZED AND SHALL N
9. waste container N Press green arrow button at least 4 sec 9 Maintenance Cross cut unit only When shredding capacity drops or the noise increases e Spray special cutting block oil onto cutting system Run cutting system forward and back ward several times without feeding paper 00 Continue shredding 10 Checklist for Inoperative Machine If the equipment does not work properly please check the following points first Is the plug inserted Is the switch turned on Is the cabinet door closed 15 the waste receptacle full Empty waste bag ls there a paper jam the shredder See Malfunctions 15 the motor overheated Switch machine off and allow motor to cool down for approximately 15 20 min If none of the above applies and the equipment still does not run please contact our customer service department Edition 03 98 1 490 999 112 520 520 CC 520 HS Paper shredder 11 Warranty FELLOWES POWERSHRED LIMITED WARRANTY 1 year on all parts and labor 5 years parts and labor on cutting cylinders Fellowes warrants this product to be free from defects in material and workmanship for a period of one year from the date of purchase by the original consumer At it s option Fellowes will repair or replace without charge for material or labor any component found to be defective during the warranty period Additionally the cutting cylinde
Download Pdf Manuals
Related Search