Empire Comfort Systems CHG Outdoor Fireplace User Manual
Contents
1. proximit de cet appareil ou tout autre appareil Que faire si vous sentez le gaz e N essayer pas d allumer un appareil e Ne toucher pas un interrupteur lec trique n employer pas un t l phone dans le batiment Appeler imm diatement votre fournis seur de gaz en employant le t l phone de votre voisin Suivre les instructions du fournisseur de gaz Si vous ne pouvez pas contacter votre fournisseur de gaz appeller le poste de pompiers L installation et le service doivent tre ex cut s par un installateur qualifi une agence d entretien ou un fournisseur de gaz AVERTISSEMENT Pour Utilisation l Ext rieur Seulement AVERTISSEMENT Si l installation l ajustement l alt ration le service ou l entretien est incorrectement fait des dommages la propri t ou des blessures peuvent s en suivre Lire compl tement les instructions pour l installation le fonctionnement et l entretien avant d installer ou de r parer cet quipement Page 1 TABLE OF CONTENTS Section Important Warnings Specifications Propane LP Gas Warnings LP Gas Cylinder Information Clearances Set Up Instructions Gas Conversion Instructions Leak Testing Lighting Instructions Maintenance and Service Main Burner Flame Pattern Trouble Shooting Parts List Parts View IMPORTANT WARNINGS For Outdoor Use Only If Stored Indoors Detach and Leave Cylinder Outdoors Read instructions before2. float cam triggers the pin to fall into the recess of the cam sealing this path off and preventing any more liquid propane from flowing through the lower valve body into the cylinder 3 The propane builds up pressure in the chamber center spring and pushes the piston up to form a seal effectively stopping the filling process 4 The use of the propane from the cylinder allows the OPD to reset itself for the next fill 5 Connects to all standard or quick connect couplings 6 The Overfill Protection Device affects incoming liquid pro pane flow only Does not affect normal propane gas discharge when properly connected to the appliance regulator 7 Allpropane cylinders should be filled by qualified profession als only Purging 1 Due to the decreased Btu delivery purging may take longer 2 Toincrease the speed of purging open the outage valve during release 3 Reminder Each new cylinder must be purged before filling 4 For purging instructions refer to NPGA 133 89 a Btu Delivery The OPD valve has a size 56 orifice through which the propane is released for consumption Depending on the propane s tem perature and pressure the release from the cylinder is approxi mately 125 000 Btu hour IMPORTANT INFORMATION ABOUT YOUR NEW TYPE 1 OUTDOOR GAS FIREPLACE CONNECTION Read all outdoor gas fireplace and related product literature before connecting or using your outdoor gas fireplace and read the following information co
3. lighting If ignition does not immediately take place turn the gas control knob to OFF wait 5 minutes and repeat the lighting procedure Certain materials or items when stored under the outdoor gas fireplace will be subjected to radiant heat and could be seri ously damaged CAUTION The LP gas pressure regulator provided with this outdoor gas fireplace must be used This LP regulator is set for an outlet pressure of 11 inches water column The gas supply must be turned off at the LP gas supply cylinder when this outdoor gas fireplace is not in use The LP gas supply cylinder must be disconnected when this outdoor gas fireplace is not in use Children and adults should be alerted to the hazards of high surface temperatures and should stay away to avoid burns or clothing ignition Young children should be carefully supervised when they are in the area of the outdoor gas fireplace Clothing or other flammable materials should not be hung from the outdoor gas fireplace or placed on or near the outdoor gas fireplace Any guard or other protective device removed for servicing the outdoor gas fireplace must be replaced prior to operating the outdoor gas fireplace Installation and repair should be done by a qualified service person The outdoor gas fireplace should be inspected before use and at least annually by a qualified service person More frequent cleaning may be required as necessary It is imperative that control compartment bur
4. 5649 RIGHT CROSS LOG 9 4 R 5640 ORIFICE NAT 3 R 5648 LEFT CROSS LOG 9 5 R 5641 SAFETY VALVE 4 R 5634 RAIN CAP WITH KNOB AND 9 6 R 5642 THERMOCOUPLE HANGER CLIP RED 9 7 R 3992 REGULATOR HOSE ASSEMBLY 4 R 5659 RAIN CAP WITH KNOB AND LPG 26 HANGER CLIP GREEN 9 8 R 2708 PIEZO IGNITOR 5 R 5631 CHIMENEA STACK CASTING 99 R 5908 ELECTRODE AND WIRE RED ASSEMBLY 5 R 5657 CHIMENEA STACK CASTING 910 R 5644 LABEL SET ON CHAIN GREEN ATTACHED TO VALVE COVER 6 R 5630 Sears BODY CASTING 911 R 3357 VALVE SPRING 9 12 R 3358 AIR SHUTTER 6 R 5656 CHIMENEA BODY CASTING GREEN 9 13 R 5645 VALVE KNOB 5 R 5651 DOOR SCREEN 10 R 5653 TANK SECURING HOOK WITH BOLT WASHER AND NUT 8 R 5633 LEG WITH RUBBER FEET RED 3 REQ D NOT SHOWN R 5635 STACK RESTRICTOR PLATE GREEN 3 REQ D NOT SHOWN R 5650 FLICKER SHIELD 2 REQUIRED 9 R 5636 BURNER ASSEMBLY NOT SHOWN R 5913 IGNITOR BRACKET 9 1 R 5909 CAST BURNER ASSEMBLY WITH PIPE AND VENTURI 9 2 R 5638 VALVE COVER CHG CHR Page 11 HOW TO ORDER REPAIR PARTS All parts listed in the Parts List have a Part Number When ordering parts first obtain the Model Number from the nameplate on your equipment Then determine the Part Number not the Index Number and the Description of each part from the appropriate illustration and list Be sure to give all this information Fireplace Model Number 22 Part Description Fireplace Serial Number 2 Type of Gas Propane or Natural Part Number Do not order bolts
5. CHR SPECIFICATIONS Instructions to Installer CHR and CHG 1 Installer must leave instruction manual with owner after installation Input BTU HR Natal LP Gas 2 The owner shall retain this instruction manual for future reference min 35000 32000 3 Installer must have owner fill out and mail warranty card supplied High 35 000 32 000 with outdoor gas fireplace 23 000 29 000 4 Installer should show owner how to start and operate outdoor gas 20 000 27 000 fireplace ee This appliance is design certified in accordance with requirement 4 96 Width 23 US and CGA certification requirement CR97 003 by the Canadian Gas Inlet 3 8 flare Standards Association as an outdoor gas fireplace The outdoor gas Accessories fireplace shall be installed according to these instructions GHK 12 Quick Disconnect 12 Ft Hose LP amp Nat Important All correspondence should refer to complete Model number Serial CHKN 1 Natural Gas Conversion Kit number and type of gas CHKT 1 Tank Cover for 201b Cylinder Note This outdoor gas fireplace is not portable Attention Solid fuels shall not be burned in this outdoor gas fireplace Any alteration of the original design installed other than as shown in these instructions or use with a type of gas not shown on the rating plate is the responsibility of the person and company making the change Do not use this outdoor gas fireplace if any part has been under water Immediately call a qualified ser
6. SUP UTDOOR PRODUCTS y a Chimen a WARNING Iftheinformation in this manual is not followed exactly a fire or explosion may result causing property damage personal in jury or loss of life Do not store or use gasoline or other flam mable vapors and liquids in the vicinity of this or any other appliance WHAT TO DO IF YOU SMELL GAS Do not try to light any appliance Do not touch any electrical switch do not use any phone in your building Immediately call your gas supplier from a neighbor s phone Follow the gas supplier s instructions If you cannot reach your gas supplier call the fire department Installation and service must be performed by a qualified installer service agency or the gas supplier WARNING For Outdoor Use Only WARNING Improper installation adjustment alteration service or maintenance can cause injury or property damage Read the installa tion operating and maintenance instructions thoroughly before installing or servicing this equipment R 5914 AND ar INSTRUCTIONS ET OWNER S MANUAL OUTDOOR GAS FIREPLACE MODELS CHR 2 EFFECTIVE DATE JUNE 2001 AVERTISSEMENT Si les informations dans ce manuel ne sont pas exactement suivies un feu ou une explosion peut en r sulter causant des dommages a la propri t des blessures corporelles ou la mort Ne pas entreposer ou employer de la gazoline ou d autres vapeurs ou liquides inflammables a
7. door gas fireplace can be obtained by contacting Empire Comfort Systems Inc WARNING Inspect the fuel supply hose before each use of the outdoor gas fireplace If it is evident there is excessive abrasion or wear or the hose is cut it must be replaced prior to the outdoor gas fireplace being put into operation Contact Em pire Comfort Systems Inc to obtain a replacement fuel supply hose LP gas supply cylinder to be used must be constructed and marked in accordance with the specifications for LP gas cylinders of the U S Department of Transportation DOT or the National Standard of Canada CAN CSA B339 Cylinders Spheres and Tubes for the Transportation of Dangerous Goods The cylinder supply system must be arranged for vapor withdrawal The cylinder used must include a collar to protect the cylinder valve CHG CHR Page 3 OVERFILL PROTECTION DEVICE OPD ON 20 LB PROPANE CYLINDER Attention Consumer be advised this outdoor gas fireplace must be connected to an LP gas cylinder incorporating an OPD The OPD will help reduce the potential for the overfilling of the propane cylinder thus reducing the possibility of hydrostatic relief valve discharges Overfill Protection Device Valve Function 1 As the cylinder is filled the rising level of liquid propane lifts the float to the stop position to prevent dangerous overfilling Does not affect the filling process or use of the cylinder 2 Ata safe filling level the
8. e Construction Figures 2 and 3 Side 6 Rear 6 Top 47 from top of unit or 96 from floor Floor Combustible Minimum Clearances From Combustible Construction with 20 1b Propane LP Tank Attached to Outdoor Gas Fireplace Figure 4 Side 6 Side Corner Installation 7 Top 47 from top of unit or 96 from floor Floor Combustible Warning When selecting a location for your outdoor chimenea it is important to consider that any ceiling overhang or other surface located above the chimenea can discolor due to heat or carbon particles generated while unit is operating Figure 2 Attention Rain cap must be placed on outdoor chimenea when not in use Rain cap will prevent rain from entering top of chimenea Without rain cap in place rain can wash soot off logs on burner Soot from logs will stain your patio or deck Figure 4 Figure 3 CHG CHR Page 5 SET UP INSTRUCTIONS Remove packing material from top of box 2 Lift chimney section out and set aside the burner should be parallel with an imaginary line connecting the front legs 3 Remove remaining items and packing from inside outdoor gas fireplace firebox 4 Lift firebox out of box and sit on flat surface near desired final location Leave adequate room around outdoor gas fireplace to work Locking ring for chimney should be facing down Figure 5 5 Remove washers and nuts from three legs Install the three legs using the bolts washers and nuts pro
9. he lighting instructions before proceeding WARNING Failure to read and follow those instructions may result in a fire or explosion causing property damage personal injury or loss of life Figure 12 GAS CONVERSION INSTRUCTIONS Warning Conversion must be done by a qualified service technician Conversion Instructions from Propane LP gas to Natural gas 1 If installed turn off gas supply to outdoor gas fireplace If installed remove Propane LP gas hose from gas valve Remove electrode wire piezo ignitor Remove thermocouple from gas valve Remove two 2 bolts and two 2 nuts from valve bracket at bottom of outdoor gas fireplace Carefully remove valve bracket from outdoor gas fireplace As the valve bracket is being removed from outdoor gas fireplace an air shutter and spring will be removed with the main burner orifice from the end venturi of main burner Do not lose the spring or air shutter Remove Propane LP main burner orifice and tubing from gas valve Attach Natural gas main burner orifice MARKED 38 and tubing onto gas valve Place 1 2 diameter air shutter washer inside air shutter Place small diameter end of spring over Natural gas main burner orifice Hold spring in place as you place air shutter with lip of air shutter facing away from main burner orifice over main burner orifice Continue to hold air shutter and spring as you insert Natural gas main burner orifice into end venturi of main burner Attach
10. inimum of 7 0 w c 1 743kPa for the purpose of input adjustment to a maximum of 10 5 w c 2 615kPa Propane Gas The Propane gas models will have a manifold pressure of approximately 11 0 w c 2 739kPa at the orifice holder with the inlet pressure to the gas valve from a minimum of 11 0 w c 2 739kPa for the purpose of input adjustment to a maximum of 13 0 w c 3 237kPa A 1 8 3mm N P T plugged tapping accessible for test gauge connection is located on the orifice holder LIGHTING INSTRUCTIONS 1 Pushin gas control knob slightly and turn clockwise yg to OFF Note Knob cannot be turned from HIGH to OFF unless knob is pushed in slightly Do not force 2 Wait five 5 minutes before attempting to light the burner from a cold start or when a hot outdoor gas fireplace is relit 3 Turn knob on gas control counterclockwise ge to HIGH 4 Pushin control knob all the way and hold in Immediately light the burner with the piezo ignitor Continue to hold the control knob in about one 1 minute after the burner is lit Release knob and it will pop back up Burner should remain lit If it goes out repeat steps through 4 CHG CHR If knob does not pop up when released stop and immediately call your service technician or gas supplier If the burner will not stay lit after several tries turn the gas control knob to OFF and call your service technician or gas supplier 5 Turn gas control knob counterclockwi
11. kPa 5 After the installation of all gas related items 1 e hose regulator LP gas cylinder natural gas hose or natural gas regulator the outdoor gas fireplace control valve should be turned OFF and the gas turned ON This is known as charging the system All gas connections must be checked with a soapy solution while the whole system is under pressure To make a soap solution mix together an equal amount of liquid detergent and water 6 Apply soap mixture to all gas connections Soap bubbles will appear if there is a leak Tighten connections to make a proper seal If you cannot stop a gas leak turn off the gas supply and call your local gas utility or the dealer from whom the outdoor gas fireplace was purchased Only those parts recommended by the manufacturer should be used on the outdoor gas fireplace Substitutions will void the warranty Do not use the outdoor gas fireplace until all connections have been checked and do not leak A gas system MUST be tested yearly or whenever the LP gas cylinder is replaced or any other gas system part WARNING Locate the gas hose out of pathways where people may trip over it or in areas where the hose may be subject to accidental damage When lighting your outdoor gas fireplace always keep your face and body as far away from the burner housing screen as possible GAS PRESSURE Natural Gas The Natural gas models will have an inlet pressure to the gas valve from a m
12. leaning spark You should see a spark jump from tip of the electrode d Is the air shutter too far open or closed If there is a spark check the gas supply Is the tank full Is e Is the gas supply or gas pressure low the line purged of air Can you light the burner with a 4 The smell of gas with flames appearing sooty yellow match a Check for spiders or insects Check air shutter adjustment close as needed b Spiders and insects can nest in the burner and cause a disruption in the flow of gas from the burner This is dangerous and can cause a fire behind the valve cover damaging the outdoor gas fireplace and making it unsafe to operate You should inspect the burner immediately if any of these b c Check the orifice for blockage d Is the electrode tip clean and free from debris e Clean electrode tip 2 Burner flame is yellow or orange and there is a smell of gas a Check the burner inlet for obstructions b Check the air shutter for proper adjustment conditions occur or persist c Check for spiders spider webs and debris 5 The burner makes popping noises Low heat with control knob set on HI a Check air shutter adjustment a Is the fuel hose bent or kinked b Check burner for clogged ports PLEASE NOTE When ordering parts it is very important that part number and description of part coincide Index Part Index Part No Number Description No Number Description 1 R 5647 BOTTOM LOG 9 3 R 5639 ORIFICE LPG 2 R
13. mpletely before attempting to con nect your outdoor gas fireplace to a propane cylinder Keep these instructions in a safe place You may need to refer to them when connecting other cylinders after filling Your new outdoor gas fireplace regulator is equipped with a coupling nut Do not attempt to connect any propane cylinder not equipped with a mating Type 1 cylinder valve Connecting the Regulator to the Valve Figure 1 This Type 1 cylinder valve contains a backcheck which is designed to prevent propane from flowing until the valve is properly connecting to a regulator When connecting the regulator to the Type 1 cylinder valve be sure the pressure relief valve is directed away from the front of the outdoor gas fireplace and away from any building If the pressure relief valve should open the propane will then be directed where it is likely to do the least harm if ignited Page 4 WARNING Do not insert any foreign objects into the valve outlet You may damage the backcheck A damaged backcheck can be the source of a leak Leaking propane may result in explosion fire personal injury or death Regulator Coupling Nut The coupling nut connects to the large outside threads on the valve outlet To complete the connection follow the steps below 1 Be sure main burner knob is in the OFF position 2 Make sure the cylinder valve handwheel is in the closed position Turn clockwise left to right to a full stop 3 Remove the pr
14. ne cylinder and check the hose and regulator connections for leakage with a soap and water solution before operating your outdoor gas fireplace Be sure there is gas in the 20 1b propane cylinder 1 Before lighting your outdoor gas fireplace check all connections for leaks using a mild soapy water solution DO NOT use matches lighters or flame to check for leaks you could cause an explosion With the outdoor gas fireplace burner control turned OFF slowly open the cylinder valve by turning the handwheel counterclockwise right to left Apply mild soapy water to the connection If bubbles appear a leak is indicated Do not put the product in service Immediately close the cylinder valve handwheel for propane gas or the manual shutoff valve for natural gas A qualified service person must be contacted to make the needed repairs 2 DO NOT SMOKE WHILE LEAK TESTING 3 For LP gas propane models leak test with a full propane cylinder 4 For systems other than self contained LP gas propane systems A The outdoor gas fireplace and its individual shut off valve must be disconnected from the gas supply piping system during any pressure testing of that system at test pressures in excess of 1 2 psig 3 5kPa B The outdoor gas fireplace must be isolated from the gas supply piping system by closing its own manual shut off valve during any pressure testing of the gas supply piping system at pressures equal to or less than 1 2 psig 3 5
15. ners and circulating air passage ways of the outdoor gas fireplace be kept clean DO NOT put anything around the outdoor gas fireplace that will obstruct the flow of combustion and ventilation air DO keep the outdoor gas fireplace area clear and free from combustible material gasoline and other flammable vapors and liquids Do make visual check of burner flames Clean and replace damaged parts FOR YOUR SAFETY Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance Page 2 Lire les instructions avant d allumer l appareil Si appareil ne s allume pas imm diatement tournez le bouton de commande de gaz dans la position ferm e attendez 5 minu tes puis proc der de nouveau a l allumage Certains mat riaux ou articles lorsqu ils sont entrepos s sous le radiateur pour patio seront expos s a la chaleur radiante et peuvent tre endommag s MISE EN GARDE Vous devez utilisez le r gulateur de gaz PL de pression 4 gaz fourni avec ce radiateur pour patio Ce r gulateur de gaz PL est r gl pour une pression de sortie de 11 pouces de colonne d eau L alimentation du gaz doit tre ferm e a la bouteille de gaz PL lorsque ce radiateur pour patio n est pas utilis La bouteille d alimentation en gaz PL doit tre d branch e lorsque ce radiateur pour patio n est pas utilis Les enfants et les adultes doivent tre avis s des dangers des parois tr
16. otective caps from the cylinder valve and coupling nut 4 Turn the coupling nut clockwise left to right to tighten to a full stop Be sure the coupling nut is not cross threaded CYLINDE HAN FGULATOR AND OSE ASSEMBLY 20 LB PROPANE CYLINDER NOT SUPPLIED Figure 1 Qualified Installing Agency Installation and replacement of gas piping gas utilization equip ment or accessories and repair and servicing of equipment shall be performed only by a qualified agency The term qualified agency means any individual firm corporation or company which whether in person or through a representative is engaged in and is responsible for a the installation or replacement of gas piping or b the connection installation repair or servicing of equipment who is experienced in such work familiar with all precautions required and has complied with all the requirements of the authority having jurisdiction The installation must conform with local codes or in the absence of local codes with either the American National Standard National Fuel Gas Code known as NFPA 54 and ANSI 2223 1 or CAN CGA B149 1 NATURAL GAS INSTALLATION CODE or CAN CGA B149 2 PROPANE INSTALLATION CODE Available from the American National Standards Institute Inc 11 West 42nd St New York NY 10036 CHG CHR CLEARANCES Minimum Clearances From Combustibl
17. r where it would be patio doivent utiliser une bouteille d une capacit maximale de exposed to high temperatures Relief valve may open allow 20 Ib 9kg ou moins ing a large amount of flammable gas to escape Ne pas utiliser entreposer ou transporter la bouteille en l ex When transporting keep cylinder secured in an upright posant une temp rature excessive car la soupape de s ret position with cylinder valve turned off risque des ouvrir et de laisser chapper une grande quantit de gaz inflammable Pour transporter une bouteille de gaz PL la maintenir solide ment fix e en position verticale avec la soupape ferm e LP GAS CYLINDER INFORMATION This outdoor gas fireplace shall be used only outdoors in a well ventilated space and shall not be used in a building garage or any other enclosed area If the outdoor gas fireplace is not in use the gas must be turned off at the supply cylinder Storage of an outdoor gas fireplace indoors is permissible only if the cylinder is disconnected and removed from the outdoor gas fireplace Cylinders must be stored outdoors in a well ventilated area out of the reach of children Disconnected cylinders must have threaded valve plugs tightly installed and must not be stored in a building garage or any other enclosed area The pressure regulator and hose assembly supplied with the out door gas fireplace must be used A replacement pressure regulator and hose assembly for this out
18. s chaudes et doivent rester loin pour viter les br lu res ou l allumage des v tements Les petits enfants doivent tre surveill s troitement lorsqu ils sont au m me endroit que le radiateur Les v tements ou d autres mat riaux inflammables ne doivent pas tre suspendus plac s sur ou pr s du radiateur Si un cran ou tout autre dispositif de s curit est enlev lors d une r paration du radiateur celui ci doit tre replac avant de remettre l appareil en marche L installation et la r paration doivent tre faites par une per sonne qualifi e Le radiateur doit tre inspect avant l usage et au moins une fois par ann e par une personne qualifi e Si cela est n cessaire de fr quents nettoyages seront requis Il est imp ratif que les compartiments de commandes les br leurs et les passages de circulation d air de l appareil soient gard s propres NE RIEN mettre autour du radiateur pour patio qui pourrait obstruer la circulation d air de combustion et de ventilation Les mat riaux combustibles la gazoline ou les vapeurs et liquides inflammables ne doivent jamais tre dans le m me endroit que le radiateur pour patio Faire une inspection visuelle de la flamme du br leur Nettoyer et remplacer les pi ces d fectueuses AVERTISSEMENT Ne pas entreposer ni utiliser de l essence ni d autres vapeurs ou liquides inflammables dans le voisinage de l appareil ni de tout autre appareil CHG
19. screws washers or nuts They are standard hardware items and can be purchased at any local hardware store Order parts through your local dealer Shipments contingent upon strikes fires and all causes beyond our control Page 12 Empire Comfort Systems Inc Nine Eighteen Freeburg Ave Belleville Illinois 62222 0529 CHG CHR
20. se ww from HIGH to MED or to LOW To Turn Off Gas to Outdoor Gas Fireplace 1 Pushin gas control knob slightly and turn clockwise gy to OFF Do not force 2 Turn off gas supply to outdoor gas fireplace when not in use Page 9 MAINTENANCE AND SERVICE ADJUSTING FOR PROPER FLAME Air Shutter Figure 13 Each burner is tested and adjusted at the factory prior to shipment However variations in the local gas supply may make it necessary to adjust the burner The flames of the burner should be visually checked The burner flames should be yellow If the burner does not operate correctly check if the air shutter or burner ports are blocked by dirt debris spider webs etc and proceed with air shutter adjustment The amount of air which is drawn into a burner is governed by a metal cup at the inlet of the burner called an air shutter AIR SHUTTER ROTATE TO ADJUST Figure 13 Air Shutter Adjustment Be careful as the burner may be very HOT The air shutter is located behind the valve cover There is an access area at the bottom of the valve cover where you can adjust the air shutter with your fingers A sooty yellow flame indicates insufficient air Open the air shutter to allow more air to the burner If flame is noisy blows out or lifts away from burner or will not light this indicates too much air Close the air shutter to decrease the amount of air to the burner BURNER MAINTENANCE AND CLEANING Inspec
21. t the burner before each use of the outdoor gas fireplace The burner must be replaced prior to the outdoor gas fireplace being put into operation if itis evident that the burner is damaged A replacement burner for this outdoor gas fireplace can be obtained by contacting Empire Comfort Systems Inc Page 10 Flashback from Spiders Figure 14 In some areas of the country spiders or small insects have been found to create flashback problems The spiders spin webs and or insects build nests in the burner venturi tube The web and or nests can lead to gas flow obstruction which results ina flashback a fire in the venturi tube Clean interior of burner with a flexible soft bristle bottle brush in order to remove spiders spider webs and debris Apply air pressure to burner ports to remove debris Figure 14 Burner Orifice Cleaning Apply air pressure into the burner orifice and orifice tubing to remove spiders spider webs dust lint and debris A flexible soft bristle bottle brush can be used to clean the orifice tubing MAIN BURNER FLAME PATTERN Figure 15 Refer to the following photograph for proper main burner flame characteristics ERS ai 4 i i Figure 15 CHG CHR TROUBLE SHOOTING 1 Fireplace won t light when the piezo ignitor is depressed b Is there an adequate gas supply a With the gas tuned off depress the piezo ignitor to check the c Does the orifice or burner need c
22. th the cut out around the pipe Interlock the right half with the left half CHG CHR Figure 8 10 Place the hold down bar under the flicker shield Push the flicker shield and hold down bar up to the bottom of the outdoor gas fireplace Figure 9 11 Insert the 4 5 8 hold down bolt through the hole in hold down bar and flicker shield and rear burner cross support Secure with 5 16 nut from inside of firebox Figure 9 12 Move the outdoor gas fireplace to its permanent location Follow installation instructions to determine the proper distances to adjacent combustible materials Adequate room must be left behind the outdoor gas fireplace for the LP tank and to the left side for access to the control panel Figure 10 13 Install the three cast iron logs Install the diagonal center bottom 1 log first Holes in 1 log are to be positioned closer to front of burner assembly Add the left cross 3 log and then the right cross 2 log Recesses tabs and holes are provided to locate the logs properly See Figure 10 for proper placement Installation of logs is completed CHG CHR Figure 10 Refer to the following warning Warning Failure to position the parts in accordance with this photograph or failure to use only parts specifically approved with this appliance may result in property damage or personal injury Figure 11 14 Attach the 20 lb LP tank support hook to the hole located in the rear center of
23. the outdoor gas fireplace firebox wall This hole is approximately 18 from the floor Use the bolt washer and nut provided and tighten by reaching into the firebox Figure 11 15 Set the LP tank in place The gas outlet fitting on the tank should be facing toward the left when viewed from the front The alternate is to face the outlet connection toward the rear Lift the tank slightly and hook onto the tank support hook One of the holes in the tank handle will fit over the hook 16 Connect the QCC 1 fitting on the regulator hose to the fitting on the tank and tighten securely by hand Page 7 Figure 12 17 Located on bottom of stack are two securing bolts Unscrew securing bolts approximately 1 2 Attention Do not remove securing bolts from bottom of stack Place the stack on top of the body aligning the two securing bolts on the chimney with the large end of the keyhole slots on the securing ring Once the chimney is in place twist to lock it down Note that aesthetic pattern on the chimney should align with that on the firebox section If it doesn t remove the chimney rotate 180 degrees and reinstall 18 Insert the cast iron stack restrictor plate in the top of the chimney KEYHOLE 19 To install door screen hook top of door screen onto firebox Raise door screen upward Pivot bottom of door screen inward to hook bottom of door screen and then lower screen 20 You are now ready to light your outdoor gas fireplace See t
24. valve bracket at bottom of outdoor gas fireplace with two 2 bolts and two 2 nuts from Step 5 Adjust air shutter to closed position Attach thermocouple into gas valve Insert electrode wire into piezo ignitor Attach conversion label onto top portion of rating plate Attach 3 8 flared fitting from Natural gas supply line or hose kit onto gas valve Turn on Natural gas supply to outdoor gas fireplace and check all gas connections for leaks with soap solution watching for bubbles on all gas connections The Natural gas inlet supply pressure to the gas valve on outdoor gas fireplace will be from a minimum of 7 0 w c 1 743 kPa for the purpose of input adjustment to a maximum of 10 5 w c 2 615 kPa Ignite and operate outdoor gas fireplace according to lighting instructions on Page 9 Attention The main burner flame must be checked for proper flame characteristics as outlined on Page 10 Gas conversion is completed Page 8 CHG CHR LEAK TESTING Turn gas valve knob to the OFF position Inspect the gas supply piping or hose prior to turning the gas ON If there is evidence of cuts wear or abrasion it must be replaced prior to use The replacement pressure regulators and hose assembly must be the type specified by the manufacturer Do not use the outdoor gas fireplace if the odor of gas 1s present For LP gas the pressure regulator and hose assembly supplied with the unit must be used Install the regulator into the 20 Ib propa
25. vice technician to inspect the outdoor outdoor gas fireplace gas fireplace and to replace any part of the control system and any gas control which has been under water PROPANE LP GAS WARNINGS CUSTOMER WARNING AVERTISSEMENTS POUR LE CONSOMMATEUR e Know the odor of LP Gas If you hear see or smell leaking LP e Savoir reconna tre l odeur du gaz PL Si vous entendez un gas immediately get everyone away from the cylinder and sifflement ou si vous sentez une odeur de gaz PL loignez call the Fire Department Do not attempt repairs imm diatement toutes les personnes qui sont pr s de la bouteille LP Gas is heavier than air and may settle in low places while et appelez le service d incendie N essayez pas de r parer dissipating Le gaz PL tant plus lourd que l air il peut s accumuler pr s Contact with the liquid contents of cylinder will cause freeze du sol avant de se dissiper burns to the skin Tout contact de la peau avec la phase liquide de la bouteille Do not allow children to tamper or play with cylinder causera des brilures par le froid When not connected for use keep cylinder valve turned off Ne laissez pas les enfants manipuler ou jouer avec la bouteille Self contained outdoor gas fireplaces shall be limited to a Lorsque la bouteille n est pas raccord e a l appareil gardez la cylinder of 20 Ib capacity or less soupape de la bouteille ferm e Les radiateurs autonomes pour Do not use store or transport cylinde
26. vided Reach through the opening in the outdoor gas fireplace to tighten the leg bolts securely Figure 6 Figure 5 6 Invert the outdoor gas fireplace firebox to sit on its legs 7 Remove the 4 5 8 bolt and 5 16 nut that are holding the burner in place Carefully remove the burner from the firebox Remove the 2 screws and nuts that are holding the hold down bar in place Remove the packing materials from the burner Unpack the cast iron logs and set aside Figures 6 and 7 8 Holding the burner assembly securely with two hands tip the burner to a position where it will fit through the front door opening The gas inlet plumbing control panel and regulator hose assembly should be pointing to the left and somewhat down as you maneuver the burner through the door Guide the regulator hose and control panel through the large hole in the Figure 7 bottom of the outdoor gas fireplace The burner should come to rest on the three flat tabs that protrude from the firebox wall Figure 8 and the control panel should be approximately centered 9 The installation sequence is to interlock the flicker shield between the left front leg and the rear leg The burner should be repositioned if needed so that there is an equal gap of approximately 1 2 between the outer curved perimeter of the burner and inner firebox wall The flat edge on the rear of Page 6 halves first to prebend the tabs Place the left half under the outdoor gas fireplace wi
Download Pdf Manuals
Related Search