Electrolux 96481470100 Trimmer User Manual
Contents
1. Caring for your Hedgetrimmer 2 Cleaning J 1 Using a soft brush remove debris from all air intakes and cutting blade Wipe over surface of your hedgetrimmer with a dry cloth IMPORTANT Never use water for cleaning your hed getrimmer Do not clean with chemicals including petrol or solvents some can destroy critical plastic parts Lubricating the Cutting Blade For easier operation and longer life lubricate the cutter blades before and after use Apply the oil so that it runs between the two blades See Pic K At the end of the Cutting Season Clean your Hedgetrimmer thoroughly Check that all nuts and bolts are secure Visually inspect the Hedgetrimmer for any worn or damaged parts contact your local Service Centre if any parts require replacement To store your Hedgetrimmer The Hedgetrimmer blade cover storage holder is provided with 2 hanging slots for storing the Hedgetrimmer on the wall See Pic L Ensure the blade cover storage holder is fitted before storage The use of 2 number 10 screws 40mm in length and the appropriate wall fixing plugs is recommended Drill 2 holes 47mm horizontally apart Fit wall plugs Fit screw ensuring enough length is avail able for secure location into hanging slot Your mains cable can be stored with the blade cover storage holder fitted Pic M amp N Store in a dry place where your2. Flymo PARTNER mcuuocn Electrolux Electrolux Electrolux HI4e2 420 H145 450 HT51 510 HT60 600 For all customer enquiries or for replacement parts contact 01325 300303 www flymo com gt lt eop customer services electrolux co uk Carton Contents Switch levers instruction Handguard manual blade cover storage holder IMPORTANT Please check the contents of the carton are correct BEFORE assembling your new product IF ANY PARTS ARE MISSING CONTACT Electrolux Outdoor Products Customer Service Department direct Telephone 01325 300303 Fax 01325 318193 Safety If not used properly this Hedgetrimmer can be dangerous This Hedgetrimmer can cause serious injury to the operator and others the warnings and safety instructions must be fol lowed to ensure reasonable safety and efficiency in using this Hedgetrimmer The opera tor is responsible for following the warning and safety instructions in this manual and on the Hedgetrimmer Explanation of Symbols on your product Do not use in the rain or leave the Warning Hedgetrimmer outdoors while raining 4 Read the user instructions carefully to LL make sure you understand all the con The use of eye protection is recom mended trols and what they do Switch off Remove plug from mains before adjusting cleaning or if cable is oN entangled
3. Never carry the product by the cable Never pull on the cable to disconnect any of the plugs Do not pull cable around sharp objects Always switch off at the mains before dis connecting any plug cable connector or extension cable Switch off remove plug from mains and examine electric supply cable for damage or ageing before winding cable for storage Do not repair a damaged cable replace it witha new one Use only Electrolux Outdoor Products replacement cable Always wind cable carefully avoiding kink ing Use only on AC mains supply voltage shown on the product rating label Our products are double insulated to EN60335 Under no circumstances should an earth be connected to any part of the product Preparation 1 Always wear suitable clothing gloves and stout shoes The use of safety glasses is rec ommended Do not wear loose clothing or jewellery which can be caught in moving parts 2 Thoroughly inspect the area where the Hedgetrimmer is to be used and remove all wires and other foreign objects 3 Before using the machine and after any impact check for signs of wear or damage and repair as necessary 4 Never attempt to use an incomplete Hedgetrimmer or one with an unauthorised modification Use 1 Use the Hedgetrimmer only in daylight or good artificial light 2 Avoid operating your Hedgetrimmer ona wet hedge where feasible 3 Know how to stop the Hedgetrimmer quickly in an emergency 4
4. Never hold the Hedgetrimmer by the guard 5 Never operate the Hedgetrimmer with dam aged guards or without guards in place 6 Remove plug from mains before passing Hedgetrimmer to another person 7 Avoid operating while people especially chil dren are nearby 8 Whilst using the Hedgetrimmer always be sure of a safe and secure operating position 9 Keep hands and feet away from the cutting means at all times and especially when switching on the motor 10 Do not use stepladders whilst operating the Hedgetrimmer 11 Remove the plug from the mains before leaving the Hedgetrimmer unattended for any period before clearing a blockage before checking cleaning or working on the appliance if you hit an object Do not use your Hedgetrimmer until you are sure that the entire Hedgetrimmer is in a safe operating condition if the Hedgetrimmer starts to vibrate abnor mally Check immediately Excessive vibra tion can Cause injury before passing to another person Maintenance and storage 1 Keep all nuts bolts and screws secure to be sure the Hedgetrimmer is in safe working condition Replace worn or damaged parts for safety Be careful during adjustment of the Hedgetrimmer to prevent entrapment of the fingers between moving blades and fixed parts of the machine After use the Hedgetrimmer should be stored using the blade cover storage holder provided 3 CABLES IMPORTANT Use only 1 00mm size cab
5. amp Development Director Electrolux Outdoor Products Aycliffe Industrial Park NEWTON AYCLIFFE Co Durham DL5 6UP ENGLAND Telephone 00 44 1325 300303 Fax 00 44 1325 310339 Our policy of continuous improvement means that the specification of products may be altered from time to time without prior notice Electrolux Outdoor Products manufacture products for a number of well known brands under various registered patents designs and trademarks in several countries Electrolux Outdoor Products Ltd Registered Office Electrolux Works Oakley Road Luton LU4 9QQ Registered number 974979 England 2 The Electrolux Group The world s No 1 choice The Electrolux Group is the world s largest producer of powered appliances for kitchen cleaning and outdoor use More than 55 million Electrolux Group products such as refrigerators cookers washing machines vacuum cleaners chain saws and lawn mowers are sold each year to a value of approx USD 14 billion in more than 150 countries around the world D 5119561 02 ee
6. or damaged Keep the cable away from the blade General 1 Never allow children or people unfamiliar with these instructions to use the Hedgetrimmer Local regulations may restrict the age of the operator Only use the Hedgetrimmer in the manner and for the functions described in these instructions Never operate the Hedgetrimmer when you are tired ill or under the influence of alcohol drugs or medicine The operator or user is responsible for acci dents or hazards occurring to other people or their property Electrical 1 11 12 13 14 The British Standards Institute recommend the use of a Residual Current Device R C D with a tripping current of not more than 30mA Even with a R C D installed 100 safety cannot be guaranteed and safe working prac tice must be followed at all times Check your R C D every time you use it Before use examine cable for damage replace it if there are signs of damage or ageing Do not use the Hedgetrimmer if the electric cables are damaged or worn Immediately disconnect from the mains elec tricity supply if the cable is cut or the insula tion is damaged Do not touch the electric cable until the electrical supply has been dis connected Do not repair a cut or damaged cable Replace it with a new one Your electric cable must be uncoiled coiled cables can overheat and reduce the efficien cy of your Hedgetrimmer Keep cable away from the cutting area
7. or tampered with by any person not authorised by Electrolux Outdoor Products f The machine has not been used for hire g The machine is owned by the original purchaser h The machine has not been used outside of the country for which it was specified i The machine has not been used commercially This guarantee is additional to and in no way diminishes the customers statutory rights Failures due to the following are not covered there fore it is important that you read the instructions con tained in this Operator s Manual and understand how to operate and maintain your machine Failures not covered by guarantee Replacing worn or damaged blades Failures as a result of not reporting an initial fault Failures as a result of sudden impact Failures as a result of not using the product in accordance with the instructions and recommen dations contained in this Operator s Manual Machines used for hire are not covered by this guar antee The following items listed are considered as wearing parts and their life is dependent on regu lar maintenance and are therefore not normally subject to a valid warranty claim Blades Electric Mains cable Caution Electrolux Outdoor Products does not accept lia bility under the warranty for defects caused in whole or part directly or indirectly by the fitting of replacement parts or additional parts that are not either manufactured or approved by Electrolux Ou
8. Hedgetrimmer is protected from damage 6 Fault Finding Hints Fails to Operate 1 Is the Power Turned On 2 Check the fuse in the plug if blown replace 3 Fuse continues to blow Immediately disconnect from the mains electricity supply and consult your local approved Service Centre Cutting blade stops under load 1 Cut at a slower pace 2 If cutting blade still stops under load Disconnect from the mains electricity sup ply and consult your local approved Service Centre Fails to stop when one switch lever is released Immediately disconnect from the mains electricity supply and consult your local approved Service Centre Poor cut quality 1 Ensure the product is being used correctly see How to Use 2 Ensure blades are free from trapped debris 3 Damaged Blades Immediately disconnect from the mains electricity supply and consult your local approved Service Centre Excessive Vibration Immediately disconnect from the mains electricity supply and consult your local approved Service Centre Environmental Information Electrolux Outdoor Products are manufactured under an Environmental Management System ISO 14001 using where practical components manu factured in the most environmentally responsible manner according to company procedures and with the potential for recycling at the end of the products life e Packaging is recyclable and plastic compo nents have been labelled wh
9. er storage holder as illustrated in Fig D co To start your Hedgetrimmer 1 There are two switch levers fitted to your Hedgetrimmer 2 Both switch levers need to be held in the operating position See Fig E for the product to start To stop your Hedgetrimmer e Move Hedgetrimmer away from cutting area before stopping 1 To stop release one of the switch levers Fig F How to Use your Hedgetrimmer 1 Inspect area to be cut before each use remove objects which can be thrown or become entangled in the cutting blades 2 Always keep the Hedgetrimmer in front of your body Hold handle firmly with both hands and stand in a secure and stable position 3 Allow the cutting blades to reach full speed before entering the material to be cut 4 Always work going away from people and solid objects such as walls large stones trees vehicles etc 5 If blade stalls immediately stop the Hedgetrimmer Disconnect the Hedgetrimmer from the power source and clear jammed debris from the cutting blades Inspect blades and repair or replace as needed Top Cutting Use a wide sweeping motion See Fig G A slight downward tilt of the cutting blades in the direction of motion gives the best cutting results Side Cutting When trimming the sides of the hedge begin at the bottom and cut upwards See Fig H tapering the hedge inward at the top This shape will expose more of the hedge resulting in more uniformed growth
10. ere practical for categorised recycling e Awareness of the environment must be considered when disposing of end of life product e If necessary contact your local authority for disposal information The symbol oh the product or on its packag ing indicates that this product may not be treated as household waste Instead it shall be handed over to the applicable collection point for the recycling of electrical and electronic equipment By ensuring this product is disposed of correctly you will help prevent potential negative conse quences for the environment and human health which could otherwise be caused by inappropri ate waste handling of this product For more detailed information about recycling of this product please contact your local council office your household waste disposal service or the shop where you purchased the product Guarantee amp Guarantee Policy If any part is found to be defective due to faulty manufacture within the guarantee period Electrolux Outdoor Products through its Authorised Service Repairers will effect the repair or replacement to the customer free of charge providing a The fault is reported directly to the Authorised Repairer b Proof of purchase is provided c The fault is not caused by misuse neglect or faulty adjustment by the user d The failure has not occurred through fair wear and tear e The machine has not been serviced or repaired taken apart
11. le up to 40 metres length maximum Maximum rating 1 3 0Omm size cable 10 amps 250 volts AC YOUR HEDGETRIMMER IS SUPPLIED WITH CABLE WIRED DIRECTLY INTO THE PRODUCT Mains Cables and Extension Cables are avail able from your local Electrolux Outdoor Products Approved Service Centre Do not wire an extension cable directly to your product yourself Please contact your local Electrolux Outdoor Products Approved Service Centre for further information on the connec tors and kits available Only use extension cables specifically designed for outdoor use CONNECTORS IMPORTANT Connectors are suitable for use with 2 core cable only Under no circumstances should these connectors be used for earthed prod ucts All connectors and cables are of splashproof construction They are not waterproof and must not be left outside permanently nor should they be submerged or immersed in water Do not let cable lay or trail through pools of water or splashed with water from hose pipes MAINS PLUG REPLACEMENT IMPORTANT If the plug supplied is cut off it should be destroyed There is an electric shock haz ard if a cut off plug is inserted into a 13 amp socket No earth required Our products are double insulated to EN60335 and under no circum stances should an earth be connected to any part of the product Ensure the mains voltage suits your product 3 IMPORTANT The wires in the mains lead are co
12. liffe Industrial Park Outdoor Products Aycliffe Industrial Park Outdoor Products Aycliffe Industrial Park NEWTON AYCLIFFE Co Durham DL5 NEWTON AYCLIFFE Co Durham DL5 NEWTON AYCLIFFE Co Durham DL5 6UP Certify that the product 6UP Certify that a sample of the above 6UP Certify that a sample of the above Hedgetrimmer product has been tested using directive product has been tested using ISO 5349 as Electrolux Outdoor 81 1051 EEC as a guide The maximum A a guide The maximum weighted root mean Products weighted sound pressure level recorded at square value of vibration recorded at opera Conforms to the specifications of Directive operator position under free field semi ane tor s hand position was 2000 14 EEC choic chamber conditions was Identification of Series Gee Product Rating Label HT42 HT420 HT45 HT450 HT51 HT510 HT60 HT600 Conformity Assessment Procedure ANNEX VI Blade Length 45cm 51cm 60cm Notified BOY ssssnsesneeens I T S Cleeve Road Leatherhead Surrey KT22 7SB England Guaranteed sound power level 101 dB A 105dB A 101 dB A 101 dB A Other Directives 98 37 EEC 89 336 EEC Measured Sound Power Level 98 dB A 97 dB A 98dB A 98 dB A 73 23 EEC 91 dB A 95 dB A 95 dB A amp applicable standards EN61000 3 2 EN61000 3 3 i 4 6 m s 7 5 m s 7 5 m s EN55014 1 EN55014 2 EN774 EN50144 1 EN50144 2 15 3 2 kg 3 5 kg 3 5 kg Newton Aycliffe 16 08 2004 M Bowden Research
13. loured in accordance with the following code BLUE NEUTRAL BROWN LIVE The wire which is coloured BLUE must be connected to the Terminal which is marked with the letter N or coloured BLACK The wire which is coloured BROWN must be connected to the Terminal which is marked with the letter L or coloured RED 4 It is important that the outer sheath is clamped correctly into the 3 pin plug 5 If in doubt consult your local Service Repairer or qualified electrician before the machine is used 6 13 Amp fuse must be fitted to the Mains Plug 7 The normal plug fuse and household fuse only protect the electrical equipment and are not a safeguard against electrocution If your product is hard wired i e non detachable mains electric cable a conver sion kit and extension cable is available from all Electrolux Outdoor Products Approved Service Centres which can be found in your local Yellow Pages Assembly Assembly of Handguard Insert Handguard into slot as illustrated in figure A ensuring that it is securely locat ed DO NOT USE THE PRODUCT WITH OUT FITTING THE HANDGUARD Starting and Stopping Before starting your Hedgetrimmer 1 Form a loop in mains cable and push the loop through the hole in the handle as illustrated in Fig B 2 To secure position the loop over the hook and pull back as illustrated in Fig C Connect to mains and switch on 4 Remove blade cov
14. tdoor Products or by the machine having been modified in any way Service Recommendations 1 We strongly recommend that your product take your complete machine including cable is serviced at least every twelve months and any extension cables used more often in a professional application A network of specialist dealers can be found in 2 Always use genuine Electrolux Spare Parts your local Yellow Pages To obtain service on 3 Prepacked spares are available from most your product simply telephone or visit your local Electrolux Outdoor Products stockists Service Centre Should you require service 4 Your product is uniquely identified by a sil under the terms of our guarantee the Service ver and black product rating label Centre will require proof of purchase 5 If you have a problem with your machine All of the centres listed stock genuine contact your local Approved Service Centre Electrolux Spare Parts ensuring you have full details of your product NOTE Our Service Repairers act on their own as described on the product rating label behalf and are not empowered to commit or 6 Should it be necessary for work to be carried legally bind Electrolux Outdoor Products in out by your Service Centre it is important to any manner whatsoever Declaration of Conformity I the undersigned M Bowden of Electrolux the undersigned M Bowden of Electrolux I the undersigned M Bowden of Electrolux Outdoor Products Ayc
Download Pdf Manuals
Related Search