Home

Ignition

1. l reaches limit the Rev Master inter Wrupts coil triggering preventing T engine damage due to over revving Measures 4 4 x 2 2 Includes instructions Fits all 1948 99 Big Twin VT No 32 0152 269 V Tech Ignition Systems fit all 1970 98 carbureted models and requires sensor cup for 1982 and earlier applications Order tach interface sensor cup and screw separately if required Note Order Coils As Required VT No Fits 32 9501 Dual Fire Ignition fits Evo Shovel and Sportster through 1997 It can be set for Street or Race Electric start or Kick Start includes 4000 to 8000 adjustable RPM limiter Includes adjustment for rate of advance This unit is compatible with stock dual fire coils 32 9500 Single Fire Ignition fits Evo Shovel amp Sportster through 1997 It can be set for Street or Race Electric or Kick Start includes rear cylinder timing adjustment for rate of advance Compatible with single fire coils 32 9503 Single Fire Ignition Kit fits As Above Includes coil and 8 5mm wires 32 0588 8 5mm Wire Set 32 9255 Tach Adapter Interface 32 0559 Sensor Cup and Screw Set Sensor Cup and Screw Kit fits 1982 up models with stock or performance elec tronic ignition systems VT No 32 0559 32 9264 Dyna Application DC6 5 All FXR FXST and Dyna models DC6 4 Dual Spark Plug Head Application DYNA Dyna Twin Fire Ignition Coils are designed to work with Dyna 2000 HD I ignition modules Twin fire
2. 32 0801 SDK 6 1 Dual Fire x Ae rAr Dil Replacement Rotor for Dyna Ignitions VT No Fits 32 9300 DS 6 1 32 9301 DS 6 2 Dyna Coils 35 000 volt Works with all points ignitions after market or factory electronic ignitions Note 32 7792 is electron ic 32 7793 is for points ignition VT No Volt Ohm Dyna Type U M 32 7789 A 12V 3 DC 1 Angle Dual Pair 32 7790 A 6V 1 2 DC 2 Angle Dual Pair Use 2 for dual plug heads 32 7792 C 12V 3 DC 6 Stock Dual Each 32 7793 C 12V 5 DC 7 Stock Dual Each 32 8055 B 12V 3 DC 3 Angle Single Pair 32 8086 A 12V 5 DC 8 Angle Dual Pair 32 9035 B 12V 5 DC 10 1 Angle Single Pair Note Use 2 for single fire ignition Dyna Ignition Booster for single points systems only transforms inconsistent electrical surges into controlled bursts of energy to the coil power is not wasted VT No 32 7787 Dyna Electric Tach Adapter Kit must be used with Dyna S single fire ignition is installed on any twins with dual plugs when electric tach is used VT No 32 7799 K V Recommends the following coils for Dyna Ignitions DS6 1 Ignition VT No 32 7778 Street Single plugs use DC 7 or DC 8 Race Single plugs use DC 1 or DC 6 Street Race Dual plugs use 2 DC 2 or DC 5 wired in series DS6 2 Ignition VT No 32 7777 Race Single plugs use 2 DC 3 Street Dual plugs use 2 DC 7 or DC 8 Race Dual plugs use 2 DC 1 or 2 DC 6 Street Single plug uses 2 DC10 1 271 Fuel Inje
3. 4 90 FXST 1986 89 All FLT 1991 93 All FLT 1991 95 All FXST FLST Dyna amp FXR 1994 98 All FLT 1996 99 FXST FLST 1996 98 Dyna 32 0086 Ignition Module Adapters allow use of seven pin module 1991 93 going to eight pin Deutsch 1994 99 wiring harness or an eight pin module going to a seven pin harness Can not be used on EFI models VT No Fits 32 0085 7 Pin Adapter to 8 Pin Module VT No 32 9016 32 9322 32 9321 32 0527 32 0528 32 9014 OEM 32405 91 32426 94 32449 95 32568 00 32478 99 32408 90 32 0086 8 Pin at to 7 Pin Module Replacement Ignition Modules bolt on replacements Harness 32 9014 required as noted Fits A 1984 95 Evo BT except 94 95 FLT 1994 95 FLT A 1996 99 All BT Performance Ignition Modules 6000 RPM VT No OEM 32 9325 32596 96 32 9326 32630 96 Note 1 Cannot be used on EFI models Note 2 Use 32 9014 harness to install ignition module on all pre 90 models A 2000 up FXST A 2000 up FXD FLT A Harness for installing the above modules Fits Note 1984 95 BT 1 2 1996 99 Evo BT 1 Ignition Modules Twin Tec External Ignition for 1999 up Carbureted Twin Cam Models Wide timing advance adjustment range accommo dates stock to highly modified engines Digitally set RPM Limit 100 RPM Steps Selectable multi spark mode for quick start ing amp smooth cruise Coil outputs protected against short circuits Billet aluminum housing with black anodized fin
4. Accel Single Dual Fire Ignition Module Fits all carbureted 1970 2000 except TC 88 and all 1971 up Sportster models works in both single or dual fire appli cations and features 14 tuneable advance curves from stock to full performance adjustable rev limiter VOES input tachometer output and front cylinder static time LED Requires sensor cup for installation VT No Item 32 0091 Accel S D Fire Ignition Module 32 9087 Sensor Cup HI IGNITION SYSTE Fat Hiniey Davhtuer Moller ji Fo a Crane Cams Hi Intensity Ignition System converts early points type 1970 79 BT to electronic ignition On 1980 and later models it will replaces stock electronic ignition external module and rev limiter Kit includes Hi module stand off screws and hard ware Order VT No 32 7510 advance weight unit separately VT No Item 32 8075 Single module dual fire single coil for a dual fire ignition system that replaces the stock point and condenser type ignition Can be used with stock coil 32 9291 Rotor for Above 32 8076 Dual module Single Fire Single or Dual Coil when being used as single fire single plug requires VT No 32 9224 coil When used as dual plug applications VT No 32 9225 coil must be used 32 9292 Rotor for above 32 7510 Advance Unit 32 9255 Tach Adapter for Above CIMZE Crane Hi 4 fits all 1970 98 carbureted models and requires sensor cup for 1982 and earlier applica tions Order tach interface sensor cup
5. and is compatible with the facto ry security system A crankshaft position sensor is employed to establish accurate firing Rear cylinder timing can be offset from 5 to 4 the same for initial timing Both are easily adjusted by means of rotary switch on the unit An additional rotary switch is used to select the advance curve with choice of ten families This enables the ignition to optimize the performance potential of the Twin Cam 88 in any stage from stock to wildly modified Rotary switches also control the built in Sequential Rev Limiter which is adjustable from 1 500 to 9 900 RPM and won t cause popping and banging like conventional rev limiters Benefits of multiple spark system include easier starting hot or cold better low speed driveability and off idle response It puls es up to nine sparks per cycle at idle and three sparks ups to 6 000 RPM which also stops spark plug fouling and lean surge VT No Year 32 3160 1999 03 32 3180 2004 up Sensor Cup Kit includes spe cial screws to fit all Sensor type ignition kits VT No 32 0559 Controller by Comp Cams is a programmable performance ignition computer featuring e High Energy output with accurate spark timing e Uses stock rotor and pickup in both single and dual fire operation e 14 factory programmed curves e User friendly programming with switches e RPM switch for nitrous 2 stage rev limiter e Programmable rev limit e Bolt on easy ins
6. and screw sep arately if required Note Order Coils Listed Below Crane Fits 8 1100 Dual Fire Ignition fits Evo Shovel and Sportster through 1997 It can be set for Street or Race Electric start or Kick Start includes 4000 to 8000 adjustable RPM limiter Includes adjustment for rate of advance This unit is compatible with stock dual fire coils Single Fire Ignition fits Evo Shovel and Sportster through 1997 It can be set for Street or Race Electric or Kick Start includes rear cylinder timing adjustment for rate of advance Compatible with single fire coils Single Fire Ignition Kit fits As Above Includes coil and 8 5mm wires 8 5 mm Wire Set Tach Adapter Interface Sensor Cup and Screw Set 32 9087 Sensor Cup replaces 32402 83 32 9052 Cup Screw replaces 2611C Note When using HI 4 Single Fire Ignition with Dual Plug Cylinder Heads two dual fire coils must be used Crane Cams 8 3002 or 8 3006 Both the spark plug wires from one coil will go to the front cylinder while both plug wire from the other coil will go to the rear cylinder VT No 32 9217 32 9218 8 2100 32 4100 8 4100 32 0588 32 9255 32 0559 Single Fire Just the spark plug for the piston that is in its compression stroke will be fired The other piston being in its overlap position will not be ignited Dual Fire Both spark plugs are fired simultaneously at the time only one piston is in its compression stroke This is the way the stock
7. coils are slightly larger than stock coils fit the stock mounting bracket Twin fire coils can be used with any electric advance ignition system that incorporates dwell control except Dyna DS6 2 or similar type ignitions VT No Dyna Ohms Type 32 9285 DC6 5 3 A Twin Fire II Miniature Dual Output Towers Replaces DC6 3 B Four output towers Fits Dual Spark Plug 32 9264 DC6 4 3 270 Dyna 2000 Digital Ignition Systems Systems include Dyna 2000 HD 1 Ignition Module and a matched Dyna Twin Fire Coil for each application VTNo Fits 32 0802 SFK 3 1995 up FXR FLT FXST FXD 32 0804 SFK 1 Pre1995 FXR FLT FXST FXD 32 9118 Programming Software for 32 0802 32 9117 Programming Software for 32 0804 Dyna 2000 Ignition Modules Replacement can used with stock electronic ignition Note The stock ignition consist of a sensor plate and rotating cup The 2000 will work on all 1970 up models but requires the 1983 up type ignition cup and sensor plate The 2000 Advance curves will not work properly if installed with the pre1983 igni tion cup and sensor Dyna 2000 HD 1 can be used with both single fire separate coils or Dual fire Single Coil the Dyna 2000 HD 2 can be used as dual fire only Both units feature programmable advance curves rev limiter and L E D diagnostic lamp for easy static timing plugs into stock harness and bolts to stock module location Also available with USB port that will allow mechanics or tuners m
8. cted Twin Tec TCFI Fuel Injection Kit for 2001 up TC 88 with Delphi Fuel Injection System Includes plug in fuel injection con troller PC link interface cable Wego wide band exhaust gas oxygen sensor and weld nut for exhaust pipe The TCFI solves tuning problems with highly modified engines Fully programmable plug in replacement for Delphi Controller Allows programming of advance curves idle air control includ ing idle RPM and cold start characteristics The TCFI communicates diagnostic information by blinking codes on the check engine LED The unit also has a built in data logging that stores data for the last 15 minutes of opera tion Fits all 2001 up Note Oxygen sensor must be installed in rear exhaust pipe VT No Item 32 1004 TCFI2D Kit 32 1016 TCFI3D Kit 32 1017 TCFI3D Kit Note Same features as 32 1016 with the addition of extended data logging and diagnostics gt Pro EFI Race Tuner This eo sii software package will make MER EVituning the EFI models a pro fessional endeavor It is divid per ed into two mode ae 7 e Data Real Time e Tuning Changes The kit includes e CD Software e User s Manual Requirements for use are Windows 98 a CD ROM serial port 32MB RAM 10MB hard drive and a highly skilled technician Replaces 32107 01H Order cable to connetc tuner to PC separately 32 3038 lt p gt VT No Item 32 0380 Tuner 32 0382 Cable Twin Tuner Fuel Injectio
9. equires use of high performance air cleaner VT No Fits 32 0293 2007 08 FXST B C SSE 2007 08 FLSTF 32 0291 2004 up FXD 2002 up V Rod 32 0292 2002 07 FLHT FLHR 32 0294 2008 up FLHT FLHR 32 0290 2001 08 ST except 2007 08 FXST B C SSE 2007 08 FLSTF Controller Mount Bracket zinc plated for 2000 up ST E VT No 31 0963
10. fire both cylinders at the same time which has the wasted sparks on the exhaust stroke This eliminates this inher ent problem For use with either dual or single plug heads On 1980 up models use VT No 32 7510 Advance assembly VT No 32 7777 DS6 2 Dyna 2000i Digital Ignition available as a module only or com plete kits that include correct coil Features include single or dual fire operation 8 advance curves built in tach driver adjustable RPM limit from 6000 to 7500 and easy static timing with built in timing indicator Fits all 1970 98 carbureted models and requires 1983 up sensor cup for 1982 and earlier applications Advanced Programming Software allows the mechanic or tuner the ability to fine tune 20001 Ignition but requires adapter VT No Item Plug Fire Coil 32 9151 Kit Single Single DC3 1 32 9152 Kit Dual Single DC1 1 32 9153 Kit Dual Dual DC2 1 32 9155 Kit Single Single DC6 5 Miniature coil DC6 5 32 9159 Module Only 32 9087 Sensor Cup 32 9052 Cup Screw 10 pk 32 9120 Advanced Programming Software for Above Ignitions 32 9121 Software Adapter Harness DYNA Ignition kd i zena Dyna S Performance Ignition egy DAVIDSON Systems Available in dual or single Gye fire for street applications only Each d kit includes sensor plate assembly and correct coil for each application Single plug only 1980 up applications require 32 7510 advance mechanism VT No Type 32 0800 DSK 6 2 Single Fire
11. ish Easy plug in installation supports all sensors including theft security module VT No Years 32 1008 1999 02 32 1014 2003 up Twin Tec External Plug In Ignition for 1990 99 Evolution Big Twins features 4 rotary switches used to set the operating modes such as single or dual fire adjust the timing advance and select RPM limit Two diagnostic LED s indicate status and start of the VOES switch The Status led is also used for static timing as it will flash when the engine reaches top dead center VT No Item 32 1006 1990 94 with 7 pin Connector 32 1007 1995 99 with 8 pin Connector 32 101 3 z Tea am aie Model Tosa i i 32 1014 S amp S Spark Technology anian System aese an ECU module that will automatically adjust ignition timing When deto nation is detected by knock sensor the ECU retards the ignition timing to prevent engine damage When detonation is not pres ent ignition timing is advanced for maximum power and econo my Additional features include Simple installation plugs into stock harness No timing adjustments 7000 RPM rev limiter single fire operation automatic dwell adjust short circuit and reverse polarity protected VT No Fits 32 1013 Module Installation Kit 32 7805 2004 2006 carbureted TC 88 models 32 1012 1999 2003 carbureted TC 88 models 32 1049 1995 99 carbureted Big Twins Chrome Accel Rev Master is pre set by the rider to a specific WR P M Limit When engine speed
12. motor works Single Plug One spark plug in each head Total of 2 spark plugs in one engine Dual Plug Two spark plugs in each head Total of 4 spark plugs in one engine Crane Coils are available in high intensity for single or dual fire mounts to stock brackets VT No CraneNo Type 32 9224 8 3001 A Single Fire 32 9241 8 3005 D Single Fire 32 9225 8 3002 B Dual Fire 32 3006 8 3006 C Dual Fire 267 32 4102 Crane HI 4E Ignition Modules Module Coil Kits Improved Adjustable Spark Curve Produces Strong Torque Power Increases Multi Spark Technology Delivers Cleaner Low End Idling Crisper Throttle Response eEasy Plug In Installation No Harness Replacement required on 1991 up Bikes 1980 94 requires VT No 32 9014 OEM 32408 90 Harness Kit Selectable Single Fire or Dual Fire Adjustable Rev Limit 500 to 9 900 RPM in 100 RPM incre menis Accurate Easy Rear Cylinder Timing Offset Billet Aluminum External Mounted eKits include module coil and spark plug wires VT No item Description 32 0806 Module only 1980 94 with7 Pin connector Note 1980 90 requires harness kit VT No 32 9014 32 4101 Kit As Above 32 0807 Module only 1995 up with 8 Pin Connector 32 4102 Kit As Above 32 0733 32 0672 Crane HI4TC Ignition for TC88 Carbureted Engine Models offers multi spark performance variable advance curves and a digital rev limiter It is a plug in replacement of the stock module
13. n Controller for 2008 up FLT models Features include increased horsepower improved thottle response easy plug in installation and setup can be used with Dyno Jet Power Commander Maps and is compatible with Twin Scan Il service tool VT No 16 0378 The Twin Tuner allows you to easily adjust your fuel injection to match the requirements of per formance parts You can add or subtract fuel by using the mode and up down push button switches VT No 32 3038 272 Power Commander III USB Engine Management Systems for Fuel Injected Models Allows for both fuel and ignition adjust ments Each unit includes a specific map designed to improve performance over stock The Power Commander includes an IBM compatible link cable and software package which allows you to fully map the fuel ignition curves on an IBM compatible computers If a comput lt er is not available the 2 fuel curves can be adjusted by using three touch buttons on the face plate Model Evo Big Twins TC 88 Touring TC 88 Touring TC 88 Softail V Rod TC 88 Dyna TC 88 Dyna FLT FXST Dyna 32 3037 2008 up FLT Note Includes O eliminators Vance amp Hines Fuel Pak A throttle position sensor mibased system that simplifies the process of fuel injection Aart tuning Enables you to fine tune the fuel mixture throughout the entire RPM range No computer or software is required Simply punch in the values supplied with the fuel pak R
14. ove advanced programming but requires separate purchase of Dyna Programming kit Note Can only be used with suppression spark plug wires On 1984 90 models Dyna extension harness must also be used VT No ltem Plug Years 32 9112 A Dyna 2000 HD 1E 7 Pin 1984 95 With USB Port 32 9049 A Dyna 2000 HD 2E 7 Pin 1984 95 32 9113 As Above with USB Port 32 9318 A Dyna 2000 HD 1E8 8 Pin 1996 99 32 9114 As Above with USB Port 32 9317 A Dyna 2000 HD 2E8 8 Pin 1996 99 32 9115 As Above with USB Port 32 9116 A Dyna 2000 TC 88 1 1999 2000 TC88 amp Carb As Above with USB Port 32 9308 A Dyna 2000 TC 88 3 2004 06 TC88 Carbureted Only with USB Port 32 9050 B Extension Cable 32 9085 C 7 8 Pin Conversion Harness 32 0559 Ignition Cup Kit 32 9087 Ignition Cup Only 32 9020 Sensor Assembly 32 9052 Cup Screw 10 pk 32 9117 Programming Software for 32 9112 32 9113 32 9118 Programming Software for 32 9114 32 9115 32 9119 Programming Software for 32 9116 Dyna S Hi Performance Ignition System is self contained fits behind ignition cover uses magnetic rotor with 6 the original spark J advancer so factory advance curve is main tained Improves perform ance extends spark plug E a a life eliminates points and condensers Note For dual plugged heads on 1980 up use advance mech anism VT No 32 7510 VT No 32 7778 DS6 1 Dyna S other which allows accurate timing of each cylinder Stock igni tion systems
15. tallation with style connectors Controller by Comp Cams VT No V Thunder Description Year 32 0672 VTI2000A Ignition Controller 1995 earlier 1993 earlier 32 0673 VTI2000B Ignition Controller Model Softail Dyna FXR FX w conv Harness XL except 1994 up FLT amp XL models 1996 up Softail Dyna FXR FX w conv Harness 1993 up Softail Dyna FLT except F I XL 32 0733 VTI2001A Power Adapter 7 pin Fits all 32 0672 applications Connector 32 0734 VTI2001B Power Adapter 8 pin Fits all 32 0673 applications Connector RPM Switch Harness For use with VTI2000 A or B Note For 1979 and earlier models use pickup VT No 32 9020 OEM 32400 80A and rotor VT No 32 9087 OEM 32402 83 For 1991 and earlier models use OE harness VT No 32 9014 OEM 32408 90 32 0741 VTE2200 268 32 8204 TC 88 Performance Available with 6200 RPM limit for engines with slight modifications and stock compression or 7000 RPM limit for engines with raised compression Big Bore Cylinder amp Performance Cams installed 6200 RPM OEM VT No 32 8204 31710 01 32 8205 32721 01 7000 RPM 32 8206 31713 01 32 8207 32724 01 Vacuum Switch Assembly VT No 32 9079 32 9080 32 9082 32 9083 32 9084 32 9156 32 9157 OEM 26557 83 26558 84 26999 91 26566 91 26555 94 26566 96 26569 96 Models Years Dyna 1999 up FXST 2000 up FLT 1999 2001 Dyna 1999 up FLT 1999 01 L Fr 32 9083 Fits 1984 90 All FXR 198

Ignition

Contents

Download Pdf Manuals

Related Search

Related Contents