User Manual - The Mogobike Electric Scooter
Contents
1. The speed level will display on the monitor Cycle through to return to the initial speed setting Hl MAINTENANCE AND CARE Maintenance and Care It is important to properly maintain your Mogobike to insure consistent long lasting performance Keep the unit clean of dirt and debris that collects on the unit over time Use a soft cloth to wipe down the frame and plastics Charging the Unit and Battery Care Only use the designated battery charger that comes with your unit Make sure all connections on the charger are properly connected before plugging the charger into the Mogobike and or wall socket The Mogobike charger plugs into a standard 120v wall socket A note about battery maintenance consistent charging will help to maintain and extend the life of your Lithium battery For best results don t let the charge exceed less than 25 percent of a charge before recharging and avoid completely discharging the battery if possible As a Safety feature the unit will not turn on once it is plugged in to the charger Checking Tire Air Pressure Maintaining recommended air pressure for the tires will provide better and safer performance when using the Mogobike Check the tire pressure with a pressure gauge and add air as needed Refer to the specifications page in this manual for the proper PSI rating Pg 14 Il MAINTENANCE AND CARE Checking Fasteners Perform regular checks on all the fasteners on the Mogobike Th2. com Address 6402 Montessouri Street Las Vegas NV 89113 Pg 20
3. hold the unit together when folded To unlock and unfold the unit begin at the rear of the unit With the toe of your shoe depress the front of the lock This will release the locking pin N Rotate the front portion ofthe unit towards the front of the bike as d shown in picture x lt Bu Bring the front and rear tires together as demonstrated This disengages both the middle and front locks completely unlocking the unit as a result y SC Pressure is applied to the interior locks 4 releasing both at the same time me S My AAA Move the rear swingarm to its starting position and lock the hinge Finish unfolding the unit by locking the middle and front hinges as shown below Front Middle E Pg 10 ll UNIT OPERATION Precautions Run through a simple safety check prior to running the vehicle e Check air pressure e Check folding locks and make sure they are fastened securely e Adjust seat height for the user e Not intended for highway use e Do not ride on sidewalks and areas intended for walking traffic only e Wear a helmet and eye protection e Make sure the battery is sufficiently charged Turning on the Mogobike The ignition switch is located under the seat on the left hand side Turn the key clockwise to turn the unit on Engaging the Motors The Green Multi Function Button The Mogobike includes a safety feature One of the problems with electric vehicles is the
4. 3 THE CONTROLS Display Monitor The Mogobike comes equipped with a backlight monitor for speed trip distance clock and battery life The distance counter located at the top right of the monitor acts as a mileage kilometer countdown estimating how much distance is available based on remaining battery life After a rider s first run the Mogobike creates a baseline for the rider as remaining distance depends on the weight and riding style of the rider The distance will be set accordingly on the next run based on the previous baseline Battery indicator is expressed as both a percentage at the top left corner and as a graph across the width of the monitor Adjusting Monitor Settings The two buttons on the monitor are used to change what displays on the monitor A user can toggle between and reset the trip meter clock or change from mileage to kilometers The left button is used to activate the settings mode for the monitor Click through on the right button to enter the various settings for adjusting the display Change the clock Hold down the left button to adjust the clock Once activated the blue headlamp light on the display will light up Click the right button to toggle between a 24 or 12 hour clock Hold down the left button to enter the clock settings Adjust the hour and minutes with the right button When the clock is adjusted to your preference the monitor will reset automatically with the updated settings aft
5. MOGOBIKE User Manual MB 6000 UD Rev 1 02 Table of Contents The Controls ll Unit Operations A Folding the Unit B Folding the Handlebars cC Unlocking and Unfolding D Precautions and Starting E Power Assist Mode lll Maintenance and Care IV Specifications Pg 2 Our Mission Here at FTR Systems we are committed to excellence in providing the highest level of customer service We believe that maintaining effective policies a positive attitude and providing swift responses will result in a valuable long term relationship between our company and the customer To Our Customers Thank you for purchasing the Mogobike We hope that our product will meet and exceed all of your expectations As a valued customer your comments and opinions are very important to us If you have any questions concerns or comments we hope you will bring them to our attention The Mogobike smart design uses a patented balanced controlled dual motor making the Mogobike a perfect last mile solution to your everyday commute The Mogobike was built for durability while also providing flexibility on the go Whether on a bus train boat or RV the Mogobike folds into a compact size for easy storage This user manual contains all essential information for the user to make full use of the Mogobike The manual includes descriptions of the system functions and capabilities and step by step startup and use Pg
6. e of the Mogobike in power assist can be cycled through by using the multi function control button e The user controls the amount of acceleration through use of the throttle Note the power assist function is not intended for riding Do not sit or ride on the unit when using power assist Initiating and Using Power Assist The power assist function is initiated when the unit is partially folded With the lower portions of the frame locked and the front and rear wheels in tandem engage the power assist function by following these steps Pg 12 ll UNIT OPERATION To begin make sure that the unit is off and that the throttle side handlebar is in an upright position Both front and rear portions of the frame should be locked before continuing Turn on the unit When the Mogobike is partially folded and turned on it will display the prompt Fold along with a number on the monitor The unit is now in power assist mode as indicated by the monitor The number indicates what speed level the unit is at when initiated In power assist the Mogobike gives the user three speed levels of walking pace Standing on the right side of the unit at the throttle grasp the throttle grip and angle the Mogobike downwards like a piece of roller luggage Give the Mogobike a light tug to initiate power assist Use the throttle to control speed Cycle through the three levels of speed by hitting the green multi function button
7. er a brief pause Reset the trip meter Toggle through display modes by pressing the right button When the trip meter displays on the monitor hold down the left button to reset the counter to zero Change to mileage or kilometers Toggle through display modes by pressing the right button When the odometer displays on the monitor hold down the left button to toggle between mileage or kilometers Pg 4 THE CONTROLS Error and Diagnostic Information The Mogobike provides some error readings back to the rider in case the bike encounters a problem If the Mogobike emits an error the Vehicle Alert icon will display on the monitor In the case of an error contact the Mogobike support department If the overheating icon displays this can result from a number of components such as motors headlamp or control board In many cases it will typically be the motors The Mogobike comes with a built in shut off function so that when the vehicle overheats it will shut down in order to protect itself from incurring damage Note about driving styles Erratic driving such as quick starts and stops can be a factor in overheating Low Battery Battery Life MOGOBIKE A AN Card a ER Ny BE Distance Meter Vehicle Alert Mph kmh Left Hand Controls Headlight The headlight meets industry standards for DOT regulations Turn Signals The Mogobike is a fully equipped stree
8. ese include any screws nuts and bolts that might come loose over time Check the hinges and plastic locking clips Evaluate the locking strength of the latch in the clip and tighten if necessary Offseason Maintenance Store the Mogobike in a dry place that is not subject to large amounts of moisture or humidity Do not store the Mogobike outside during incidental weather The Mogobike uses electronic components that can incur damage if exposed to these elements for long periods of time Keep the battery charged Checking the Brake A proper functioning brake is essential when riding Pull the brake lever and push the vehicle forward Does the brake lever engage the pad against the brake disc If there is movement when the brake lever is engaged the brake may need to be adjusted See the Mogobike website for instructions about adjusting the brake Pg 15 IV SPECIFICATIONS Expanded size 57 Lx 24 W x 38 H Folded size 18 Lx 14 W x 25 H Axial distance 44 Wheel size 12 Maximum speed 20 mph on flat surfaces at a 200 Ib load weight Brake Mechanical Disc Brake Front and Electronic Braking Frame Aluminum alloy Aluminum alloy Tire Pressure 40 psi Certificate E mark 2002 24 EC EU and FMVSS US VIN Number Pg 16 NOTES Pg 17 NOTES Pg 18 NOTES Pg 19 Customer Support Contact Information Office 702 982 6598 Email support dmogobike com Web www mogobike
9. lack of an audible cue that the vehicle is on The green multi function button on the throttle bar acts as an initialization switch that engages the motor When the Mogobike is first turned on the motors remain in a neutral state Press the green button and the user has a five second window to engage the throttle When the user comes to a full stop or parks the vehicle the motors will return to a neutral state after three seconds ll UNIT OPERATION Setting the Cruise Control Riders can set the cruise control when in transit Simply press the green multi function button and the Mogobike will set the speed To disengage the cruise control press the green button again adjust the throttle or apply the brake Throttle Control and Braking Mogobike includes regenerative braking for added battery support Regenerative braking provides two benefits it reverses the direction of the motors and sends that energy back to the battery to increase battery life and offers a quick way to slow down When riding simply release the throttle and the motors will quickly act to slow the unit When using the brake use a smooth motion to apply the front brake s stopping power Power Assist Features e The user can move the Mogobike into interior spaces when it s partially folded and still control the unit under power e Power assist offers three speeds to adjust to a user s pace or on uneven terrain or inclines e The walking pac
10. ot until they come together as shown Rotate the opposite foot pad until it rests in place in a vertical position reach over the scooter and grab the steering column Rotate the steering column towards the inside of the battery box until it aligns with the rear wheel See next section Folding the Handlebars Pg 7 ll UNIT OPERATION Folding the Handlebars Rotate the mirrors 180 degrees until the narrow end of the mirror is pointing towards the unit Push the mirror downwards and fold it against the grip Release the handlebar pressure lock to expose the handlebar push pins Press the pushpin in until it seats below the pushpin hole and extract the handlebar Note for power assist users will want to make sure that the right hand throttle side of the handlebar remains in the riding position Both sides of the handlebar fit into the folding mount in different ways Pg 8 ll UNIT OPERATION When securing the left non throttle side clip the handlebar into place using the small hex fastener bolt that runs through the handlebar For the throttle side clip use the push pin to secure the handlebar Position your thumb on the clip to release tab Push the clip release tab away from the latch y zu u Mogobike completely folded and ready for storage ll UNIT OPERATION Unlocking and Unfolding The Mogobike uses a unique hinge locking system to
11. t machine with lights turn signals and brake lamp Move the blinker control switch left or right to initiate the turn signals The unit will emit a clicking sound to indicate the blinker signal is initiated Slide it back to the middle neutral position to turn the signal off Pg 5 ll UNIT OPERATION Folding the Mogobike Folding the Mogobike is a quick and easy operation but one that takes a little practice in the beginning To shorten the learning curve this section will walk users through folding their Mogobike Take notice of the position of the locking hinges There are three hinges that run along the frame and one on the steering column These hinges are made of tempered stainless steel The latch that runs along the top of the hinge is fastened by a hard plastic clip Position your thumb on the clip release Tab and push it away from the latch releasing the latch in the process Run down the length of the frame releasing the three hinges and rotating the latches upwards to unlock the hinges With the hinges now unlocked you will notice that the Mogobike can easily pivot at each break point on the frame Rotate the foot pad next to you upwards The pad will stay in place in a vertical position Pg 6 ll UNIT OPERATION To begin folding the unit from the left side of the unit position your hand on the rear of the seat Pull the seat towards you and the two rear hinges will piv
Download Pdf Manuals
Related Search