X-Treme™ Electric Scooters XMB-320
Contents
1. 10 SGU AY eS 10 E 10 Maintenance 2 10 11 eee ts ee Reet eee ae ene ee ene ere 11 WINNI 12 RIDING SAFETY Like any sport cycling carries the risk of injury and damage By choosing to ride the XMB 220 you assume all responsibility for these risks Thus you need to know and practice the rules of safe and responsible riding YOUR INSURANCE POLICIES MAY NOT PROVIDE COVERAGE FOR ACCIDENTS INVOLVING THE USE OF THIS CYCLE TO DETERMINE IF COVERAGE IS PROVIDED YOU SHOULD CONTACT YOUR INSURANCE COMPANY OR AGENT Safety Basics Do s and Don ts The 5 o Always conduct a Safety Check before you ride your 320 Be thoroughly familiar with the controls of your XMB 420 Always wear an approved helmet when riding your XMB 320 Follow the helmet manufacturer s instructions for fit use and care of your helmet Always keep body parts and other objects away from the spinning wheels of your XMB 320 Always wear shoes that will stay on your feet and will stay on the floorboard Wear bright visible clothing that is not so2. 55 3 Quick Reference and Safety 4 ene ae 5 Ol hated Masia aes 6 PRIGING Sally t gsicrresshasgnearsussedetodereuesbauturesduasedabsiensuaslengurarweseidamsaesuewsbesessandudes 7 8 Safety Basics 5 amp 16 44 2 7 Operating Reminders and 7 8 8 NIONE Geeser nee en are ee een ee er eee cer ee nee 8 8 0 9 TT 9 RION 10 SOPPAN 10 BAKING oyo lN 10
3. X Treme Electric Scooters XMB 320 Electric Mobility Scooter Photo may vary from actual PLEASE READ ENTIRE MANUAL CAREFULLY BEFORE OPERATING BATTERY MAINTENANCE and CHARGING INSTRUCTIONS 1 You MUST charge completely prior to initial use Follow charging instructions in your Product Handbook Charge immediately after each use Charge before storage You must charge every 30 days if not in use Charge the unit for 6 8 hours or until the light on the charger turns red amp green DO NOT allow this unit to deep discharge the battery For safety purposes DO NOT charge for over 8 hours pot Oy Turn the unit OFF when not in use Failure to follow these INSTRUCTIONS will VOID YOUR WARRANTY THIS PRODUCT IS NOT INTENDED FOR EXTREME or OFF ROAD USE Please take care of your scooter DO NOT JUMP or ABUSE THIS PRODUCT DO NOT RIDE IN WET ICY CONDITIONS Failure to follow these instructions will VOID YOUR WARRANTY IMPORTANT PLEASE READ THIS BEFORE USING THIS PRODUCT WARNING This product does not conform to Federal Motor Vehicle Standards and is not intended for operation on public streets roads or highways Serious injury can result from the unsafe operations of this product Operator can minimize these risks by using certain safety equipment such as safety helmet goggles gloves elbow and kneepads and appropriate footwear DO NOT operate this product in traffic on
4. power to the motor When the unit feels like it is loosing power or not accelerating to full soeed the scooter is ready to be re charged Braking System The XMB 320 uses disc caliper system for the front wheel The brake 15 activated by hand brake lever on the left side of the handlebar Squeezing the hand brake lever activates the brake Make sure to release the HAND THROTTLE GRIP when engaging the brakes Your XMB 320 is equipped with a switch on the brake lever that will disengage power to the motor when the brake levers are depressed Practice braking on a smooth dry surface to get used to the feel of the braking system Braking distance is affected by wet conditions and loose and uneven riding surfaces Adjusting the Brakes The Brakes on the XMB 320 should come fully adjusted from the factory However it may be necessary to adjust the brakes from time to time For brakes that are too loose adjust the tension screw on the right hand brake lever by rotating it counter clockwise until the wheel spins freely For brakes that are too tight tighten the tension screw on the right hand brake lever by rotating it clockwise until the wheel has a slight drag Squeaky Brakes The brakes may squeak before they are broken in This is normal and will not affect the function or performance of the brakes With continued use the squeak should go away Tire Pressure The tire must be inflated to a maximum of 50 P S I It is also recommended
5. to use a tube additive like Slime available from any motorcycle shop to avoid inconvenient punctures Empty all air from the tire prior to loosening the bolt to split the rim Maintenance Schedule Proper care of your X Treme XMB 320 will insure optimal performance and longer life span The following few maintenance suggestions that will keep your X Treme XMB 320 10 running in top condition Daily Maintenance Perform each time you ride your XMB 320 Clean the exterior of the unit with a soft damp rag DO NOT WASH WITH A HOSE Check that all nuts and bolts are securely tightened Lubricate the chain with any silicone spray 3 amp 1 oil or any good clean motor oil Check battery charger for any frayed cut wires Troubleshooting SYMPTONS POTENTIAL CAUSE SOLUTION The charger light turns 1 This indicates the batteries 1 Continue to charge the green 8 red right are adequately charged batteries for 6 8 hours prior to initial use 2 Bad Fuse open connection between charger 2 Check Fuse Look for loose socket and batteries or disconnected wire Batteries do not hold 1 Batteries have reached the 1 Replace Batteries charge Unit does not end of their useful life 2 Replace Charger Unit have specified travel 2 Charger is malfunctioning range Unit moves 1 Batteries not fully charged 1 Charge or replace batteries intermittently or very 2 Loose Wire 2 Chec
6. wet frozen oily or unpaved surfaces or under the influence of drugs and or alcohol Avoid uneven surfaces potholes surface cracks and obstacles DO NOT use a water hose to clean this product See Product Handbook for more information This product is recommended for riders 16 YEARS OF AGE and older SAFETY Persons without excellent vision balance coordination reflex muscle and bone strength and good decision making capabilities should not use this product Minors without adult supervision should not use this product Persons unwilling or unable to take responsibility for their own actions should not use this product The user of this product assumes ALL risks associated with its use To minimize these RISKS the user must wear safety helmet goggles gloves elbow and kneepads and appropriate footwear This product is ELECTRIC DO NOT ride this product in wet conditions puddles or rainy weather QUICK REFERENCE SAFETY GUIDE SAFETY GUIDE e The recommended minimum age for riding this scooter is 16 years old avoid damage to the motor and fooiplate do not overload the scooter e Never ride with more than one person e Inspect your scooter thoroughly before each use for loose or missing parts e Avoid unintentional starts by turning the scooter off while not in use avoid the risk of a short circuit in the electrical parts do not use your Electric scooter in the rain and never spr
7. area for operating a motorized scooter Obey the same road laws as all other road vehicles including yielding the right of way to pedestrians and stopping at red lights and stop signs Ride predictably and a straight line Never ride against traffic o Use the signal lights to indicate turning or stopping o Ride defensively To other road users you may be hard to see Concentrate on the path ahead Avoid potholes gravel and dirt wet road oil curbs speed bumps drain grates and other obstacles Be alert for unexpected events such as opening car doors or cars backing out of concealed driveways extra careful at intersections and when preparing to pass other vehicles Familiarize yourself with all the bike s features Practice signal lights braking and use of the horn Don t carry packages or passengers that will interfere with your visibility or control of the bike Don t use items that may restrict your hearing Maintain a comfortable stopping distance from all other riders vehicles and objects Safe braking distance and forces are subject to the prevailing weather and road conditions Wet Weather Riding Wet weather impairs traction braking and visibility both for the rider and for other vehicles sharing the road The risk of accident is dramatically increased in wet conditions In wet weather you need to take extra care In wet conditions the stopping power of your brakes as well as the brakes of
8. at posts clamps to secure 5 Loosen the front shaft nut and remove the washer from the front axle Place front wheel in place and slide the front axle back through and replace washer and nut and tighten as shown in Figure 4 Charging Your scooter comes charged out of the carton We still recommend charging the unit for 6 8 hours prior to its first use We also recommend charging your scooter after each use and prior to storage Do NOT charge for more than 8 hours at one time batteries may overcharge and result in damage 1 Make sure you unit is turned off 2 Locate the charging socket on the scooter and plug in your charger to the socket 3 Plug the charger into the power source When first plugged in the charger has one red light that will illuminate at the same time indicating that the charging process has started Once the light on the charger turns red amp green you may remove the charger and close the safety cap Riding 1 Make sure all the exposed bolts and screws are tightened 2 Ignition Key to the ON Position 3 Gently twist on the Throttle Grip on the right side of the handlebars The XMB 320 will begin to move on its own Your scooter has a variable speed throttle You can control the speed of your scooter by the how far you twist the hand throttle Stopping Braking To brake release the THROTTLE GRIP and depress the BRAKE LEVER on the LEFT side of the handlebar Depressing the brake will disengage
9. ay or wash off your scooter with water e Do not place the battery near fire or heat avoid damage to the battery do not use the charger if it has been damaged in any way e Keep hands face feet and hair away from all moving parts Do not touch the motor or wheels while they are rotating e Brakes are designed to control speed as well as stop the scooter Practice braking for proper slowing down and smooth stops e Maintain your scooter as recommended in this Product Handbook e Use only quality replacement parts as recommended by the manufacturer e Inspect the entire scooter prior to each use Replace any part that is cracked chipped or damaged before use ALLOW CHILDREN TO OPERATE THE SCOOTER WITHOUT ADULT SUPERVISION ATTEMPT TO OPERATE THE SCOOTER WHILE UNDER THE INFLUENCE OF ALCOHOL If a situation arises that is not covered in the manual proceed with caution and use good judgment DO NOT RETURN TO STORE Do not use this vehicle for the first time until you have inflated the tires to the correct PSI and completely charged the battery Failure to follow these instructions may damage your vehicle and void your warranty For technical support CALL OR GO ONLINE 1 253 777 0690 www x tremescooters com support Table of Contents Battery Maintenance and Charging 2
10. k for loose wires slow 3 Bad Throttle or controller 3 Replace Unit will not move when 1 Batteries not fully charged 1 Replace batteries or charger throttle lever is 2 Brake switches out of 2 Loosen brakes activated adjustment 3 Replace batteries 3 Batteries have reached the end of their useful life Unit stops abruptly 1 Fuse Blown 1 Replace Fuse during use 2 Loose or broken wire 2 Check for loose or broken wires and repair replace WIRING DIAGRAM general connection diagram main controller green black brown ey ed Rite black sa dk light Ss accelerator eae naar tH Desas 2 power switch Jock _ A uy gt ms 4 96 4 gt 5 left turning light _ eee oo storage battery 02 right turning turning light switch DO NOT RETURN TO STORE IF YOU NEED HELP CALL OR GO ONLINE 1 253 777 0690 www x tremescooters com support For General Information or Parts Visit www x tremescooters com Revised 6 12 13
11. loose that it can catch on moving parts of the XMB 320 or objects at the side of the road or trail Think about your speed and keep your speed consistent with safe operating conditions The ts Never ride with headphones They mask traffic sounds distract you from concentrating on your surroundings and their wires can tangle in the moving parts of the XMB 320 causing you to lose control Never carry a passenger The maximum carrying capacity is 240 165 o Never ride barefoot or wearing sandals Don t jump with your XMB 320 It puts great stress on everything from frame and forks to drive train Riders who jumping their XMB 320 risk serious damage to their XMB 320 and will void their warranty Never carry anything which obstructs your vision or your complete control of the XMB 320 or which could become entangled in the moving parts of the XMB 320 Never hitch a ride by holding on to another vehicle o Never ride your XMB 320 while under the influence of alcohol or other drugs If possible avoid riding in bad weather when visibility is obscured at dusk or in the dark or when you are very tired Each of these conditions increases the risk of accident Never allow children to ride Never allow others to ride without reading and understanding these instructions Operating Reminders and Suggestions Review all instructions carefully before riding XMB 320 Follow all rules and regulations in your
12. other vehicles sharing the road 15 dramatically reduced This makes it harder to control speed and easier to lose control To make sure that you can slow down and stop safely in wet conditions apply your brakes earlier and more gradually than you would under normal dry conditions Decrease your riding speed avoid sudden braking and take corners with additional caution Keep in mind that there is a direct but inverse relationship between speed and controllability Be more visible on the road Wear reflective clothing and use safety lights Potholes and slippery surfaces such as lane markings and train tracks all become more hazardous when wet Night Riding A rider is very difficult for motorists to see at dusk at night or at other times of poor visibility If you must ride under these conditions check and be sure you comply with all local laws about night riding follow the Rules of the Road and take the following precautions Make sure that your XMB 320 15 equipped with correctly positioned and securely mounted reflectors Make sure your clothing or cargo does not obstruct a reflector or light Ensure that the front lights are on Wear light colored reflective clothing and accessories any reflective device or light source that moves will help you get the attention of approaching motorists pedestrians and other traffic Ride slowly Avoid hazards such as potholes and curbs Avoid areas of heavy traffic dark areas and roads with s
13. peed limit over 35 mph If possible ride on routes already familiar to you Ride at night only if necessary Slow down and use familiar roads with street lighting if possible Other Reminders The XMB 320 works best on level ground Use caution while going down an incline such as a hill or a ramp Hill climbing and repeated acceleration braking will exhaust the battery much more rapidly The XMB 320 has an electrical brake cutoff system When you engage either brake the throttle becomes inoperative Release the throttle before braking Do not ride the brakes The battery does NOT require deep discharging If your XMB 320 is put into storage re charge its battery at least once every 90 days Do not store your XMB 320 direct sunlight for an extended time Store your XMB 320 in a dry place Exposing your XMB 320 to rain snow or other precipitation may result in damage Getting Started 1 Open scooter carton and remove your XMB 320 Inside you will find the following contents 1 X Treme XMB 320 Mobility Scooter 2 User Manual 3 Tool Kit 4 24V UL Battery Charger 2 Make sure your handlebar components are as shown in Figure 1 Loosen the flat bolt in the handlebar Remove the pin and insert the connector to the handlebar Insert pin and tighten bolt 3 Turn and tighten the folding unit shown in Figure 2 to secure the handlebar 4 Insert seat post and adjust to desired height as shown in Figure 3 Tighten se
Download Pdf Manuals
Related Search