Home

2016 Jay Flight Bungalow Manual

1. 2 8 ee 2 7 2 a a 2 1 2 1 Formaldehyde eT 2 7 Other Fire Safety 0 0 0 1 2 1 Secondary Means Of Escape 2 9 2 2 SECTION 3 PRE TRAVEL INFORMATION ead eet ads 3 1 Hitch Travel Trailer Customer 3 6 E E T ecu ex 3 3 Sway Control Travel Trailer Customer 3 7 Tow VehiGle Bae eee 3 1 3 2 Weighing Your Tow Vehicle amp 3 4 Weight Distributing System Travel Trailer Customer 3 7 ata en is a en ees 3 2 SECTION 4 TOWING amp SET UP Breakaway Ce 4 14 Changing
2. Turn the TV power supply OFF to view cable or satellite television or to use a VCR or DVD Fig 11 1 TV Power Supply TELEVISION ROOF ANTENNA To view local stations at either or both the front or bedroom television sets using the television antenna make sure the TV power supply is ON and the TV roof antenna is raised to the operating position The following is an overview of the antenna operation Refer to the manufacturer s user guide included in your Warranty Packet for detailed operating instructions or visit the manufacturer s website Raising the antenna To raise the TV antenna to the operating position turn the antenna elevating crank clockwise in the UP direction approximately 13 turns until some resistance to turning is noted Fig 11 2 On amplified models 12 volt DC power is required After the antenna is in the full UP position pull down on the round knob with both hands until it disengages from the ceiling plate Rotate the knob for best picture Fig 11 3 Fig 11 2 Fig 11 3 Test 1 sure the television set is working properly 2 Switch the power supply ON and OFF to see if there is a difference in the picture quality while watching TV If there is no difference refer to manufacturer s manual for further testing procedures AN CAUTION The TV power supply should be turned OFF when connecting disconnecting the cables to the power supply and antenna but should be t
3. dae ats in veo tana 1 5 elects 1 3 Jay Flight Bungalow Limited 1 8 Jayco Towable Rental Limited 1 13 A Notice To Jayco 044440 1 12 Obtaining Emergency Warranty 1 6 Obtaining Service At Jayco ee eeccesceeeseeeeseeeeneeeeaeeeeaeeseaeeseaeeeeaeeseaeeseaeeseeeeeaeees 1 7 Obtaining Service For Separately Warranted 1 7 ested ee ce 1 7 Reporting Safety Defects 2 2 1 11 1 00 1 2 Safety Alerts cece eh etal eerily eh ade enemas 1 1 Suggestions For Obtaining 1 4 Update Your Contact 1 1 5 ile eee 1 1 Section 2 OCCUPANT SAFETY Combination Carbon Monoxide Propane 2 4 Cold Weather USage eccceesseeseeceseteneeeeeeseeeeeaeeseaeeeeaeeseaeeeeaeeseaeeseaeeseaeeseaeete 2 8 Condensation
4. CENTRAL VACUUM IF SO EQuIPPED The RV must be hooked up to and be operating on 120 volt AC power for the central vacuum system to be operational The vacuum will automatically begin to operate when the hose wall fitting is inserted into the central vacuum wall port The vacuum will automatically cease to operate when the hose wall fitting is extracted from the central vacuum wall port Change the vacuum filter bags regularly to maintain maximum vacuuming power The filter is located inside the central vacuum assembly that is in turn located inside the front storage compartment A WARNING DO NOT PICK UP ANYTHING THAT IS BURNING OR SMOKING SUCH AS CIGARETTES MATCHES OR HOT ASHES RV damage personal injury or death may result from vacuuming up burning or smoking material AN WARNING DO NOT PICK UP FLAMMABLE OR COMBUSTIBLE LIQUIDS SUCH AS GASOLINE OR USE IN AREAS WHERE THEY MAY BE PRESENT RV damage personal injury or death may result from vacuuming up flammable or combustible material 10 3 SECTION 10 APPLIANCES JAYCO TOWABLE THIS PAGE 15 INTENTIONALLY BLANK 10 4 JAYCO TOWABLE SECTION 11 ELECTRONICS TELEVISION POWER SUPPLY For good station reception the TV power supply must be turned ON to view local television stations Turning the TV power supply ON sends 12 volt DC through the cable to the TV roof antenna The voltage energizes the transistors the antenna head amplifier
5. Size Function 1 Open 2 15 amp fuse Bathroom Lights amp Vent 3 15 amp fuse Pump Monitor Panel Range Hood Sink Lights 4 15 amp fuse Refrigerator Furnace 5 15 amp fuse Bedroom 6 15 amp fuse TV Radio Propane Detector 7 15 amp fuse Ceiling Lights 8 15 amp fuse Bunk Lights 9 15 amp fuse Slideout Lights 10 15 amp fuse Option 11 15 amp fuse Option 12 20 auto Slideout Motor 12 voLT DC OUTLET IF SO EQUIPPED There may be a 12 volt DC outlet not applicable on all models in your RV When the 12 volt DC outlet is used as a power source for an electric appliance make sure that the appliance operates on 12 volt DC power and that it consumes less than 60 watts 5 amps of 12 volt power To prevent short circuits do not allow metallic foreign matter to get into the 12 volt DC outlet REPLACING LIGHT BULBS Before replacing a bulb be sure the light is off Do not touch the glass part of the new bulb with your bare fingers The skin oil left on the glass will evaporate when the bulb gets hot the vapor will condense on the reflector and it will dim the surface Replacement light bulbs must be of the type voltage and wattage listed on the lamp fixture Use of incorrectly sized bulbs can overload lam circuits and may create a fire hazard by overheating the fixture Interior Ceiling Bunk Lights 921 Exterior Porch Light 922 Exterior Tail Light Signal 3157 Exterior Cle
6. Propane and sufficient power is needed for protection from possible freeze ups on the propane regulator Keep in mind that more frequent furnace operation will substantially increase battery draw and propane use During cool weather usage ventilation or the addition of a dehumidifier may be required to reduce condensation see Condensation Check outside extrusions on compartment doors locks slide outs windows vents etc for frozen moisture before operating to avoid damage to parts CONDENSATION AN WARNING Condensation should be taken seriously Ignoring it can damage the motor home damage caused by condensation is not warrantable and more importantly could lead to mold or mildew issues which could be a health hazard Condensation is a natural phenomenon The amount of condensation will vary with climate conditions particularly the relative humidity To reduce condensation Proper ventilation and if needed the use of a dehumidifier customer supplied will assist in controlling condensation Many RV and marine dealers carry small dehumidifiers sized for RV use Other suggestions are Crack open windows and roof vents to allow warm moist air to escape When taking a shower open the bath roof vent if so equipped approximately Y2 allowing the moisture to escape Use the range hood fan if so equipped when cooking or washing dishes Q Avoid hanging wet towels or cl
7. SERIE paso FRONT DENANT TIRE SIZE COLD TIRE PRESSURE SEE OWNER S FRONT ALAS ARRON MANUAL FOR venice TYPE TALER cARAt MUCTPURPO SE PAS NGEN E 0 TOURISME BAGES REAR ADDITIONAL INFORMATION F0 323 SPARE Fig 3 1 Tire and Loading Information Fig 3 2 Federal Certification label 3 2 JAYCO TOWABLE SECTION 3 PRE TRAVEL INFORMATION RECKEANON VEHICLE TRAILER CARGO CARIES CAPACITY Fig 3 3 Trailer Weight Information label You may question the total weight capacity of the tires on your RV being less than the GVWR this is correct In order to calculate the actual weight on the RV tires do not include the tongue weight The tongue weight is actually being carried by your tow vehicle not the RV tires For example If the tires are rated at 2 000 Ibs each x 4 tires 8 000 Ibs and the RV has a GVWR of 9 000 Ibs with a tongue weight of 1 200 lbs The actual weight on the RV tires is 7 800 lbs which is within the weight rating of the tires If you have further questions please contact your dealer or Jayco Customer Service LOADING YOUR RV A WARNING Never load the RV in excess of the GAWR for either axle Overloading your RV result in adverse handling characteristics and damage to the chassis A WARNING Your recreation vehicle s l
8. You will find that your RV will travel safely and comfortably at most posted trailer highway speed limits However it will take longer than a passenger automobile to reach that speed Keep this in mind when overtaking and passing another vehicle Allow more time to go around the vehicle you are passing 4 1 SECTION 4 TOWING amp SET UP JAYCO TOWABLE You cannot cut back into the traffic lane as quickly due to the longer length of your tow vehicle RV combination Drive with caution to avoid situations that might require quick momentum changes Even though your RV is equipped with brakes designed for GVWR we suggest practicing stopping away from traffic until you become accustomed to your RV s stopping distance A good way to practice is at a large parking lot where it is permissible Easing to a stop and starting smoothly saves wear and tear on your tow vehicle RV combination Be aware of road surface conditions Slow down well in advance of dips and bumps to reduce the jolting to your tow vehicle RV combination Drive over them slowly and let the trailer tires pass over them before accelerating Cross railroad tracks slowly always release your brakes before crossing When descending a long hill drop down into a lower gear or lower range if you have automatic transmission Avoid conditions that require excessive and prolonged use of your brakes Apply and release brakes at short intervals to give them a chance to cool The tow
9. wake up area Then touch and hold both the 3 4 button and the Enter Button for 2 seconds The system will provide three short beeps indicating it is ready to accept a new code Enter the new 4 digit code followed by the Enter button The system will provide four short beeps to indicate new code acceptance This new code will now activate the lock To reset the code remove the batteries for at least 10 seconds Re install the batteries and follow the steps to Programming New Code Please Enter Personal Code to prevent inadvertent programming System Fault Logic Action Response Ready to Accept New Code Three short beeps New Code Entered Four short beeps Wrong Code Entered One long beep Dead Bolt Locks Two short beeps Dead Bolt Unlocks Two short beeps Dead Bolt fails to Lock One long beep Dead Bolt fails to Unlock One long beep Low Battery One Long beep after the Lock Unlock beeps The lock will cycle up to 10 more times once the low battery indication occurs After this the final electric function in a low battery condition will be unlock and will not lock until the batteries have been replaced Please note that if the deadbolt is in the locked position and the batteries die the deadbolt will remain locked The key will always be able to activate the deadbolt lock 4 10 JAYCO TOWABLE SECTION 4 TOWING amp SET UP Wake Up 1 Touch the area next to Area the Buttons to Wake Up the lock 2 The Butt
10. 2 4 JAYCO TOWABLE SECTION 2 OCCUPANT SAFETY These chemicals can be found in commonly used items such as deodorants colognes perfumes adhesives lacquer kerosene glues wine liquor most cleaning agents and the propellants of aerosol cans High temperatures can activate glue and adhesive vapors If you close up a recreation vehicle on a hot day the chemicals used in its construction may be detected for months after the vehicle was constructed for more information refer to Section 2 Formaldehyde WARNING The carbon monoxide detector installed is intended for use in ordinary indoor locations of recreation vehicles It is not designed to comply with Occupational Safety and Health Administration OSHA commercial or industrial standards Do not disconnect the battery or the alarm Individuals with medical problems may consider using warning devices that provide audible and visual signals for carbon monoxide concentrations under 30 PPM This alarm will only indicate the presence of carbon monoxide gas at the sensor Carbon monoxide gas may be present in other areas The ultimate responsibility for protection against toxic carbon monoxide fumes rests solely on you Installing a carbon monoxide propane alarm is just the first step in protecting your family from toxic carbon monoxide poisoning What you should do if the alarm sounds WARNING Actuation of this detector indicates the presence of carbon mon
11. 5 Make sure the fresh water tank drain and low point drains are closed 6 Close the fresh water tank shutoff valve Valve D in Fig 8 8 NOTE Utility Center w Valves does have the fresh water tank shutoff valve Valve D in Fig 8 8 7 Open the valve on the water pump with the clear hose attached valve in Fig 8 8 and insert the opposite end of the clear hose into a container of RV antifreeze solution Utility Center w Valves Set the water valves to the Sanitize Winterize position insert a hose into the City Water Fill inlet opposite end of the hose goes in container of antifreeze 8 Turn the water pump ON Antifreeze will be drawn into the water lines 9 Open the hot water line faucets kitchen bath sinks shower and outside shower if So equipped until RV antifreeze begins to flow continuously 10 Close the hot water line faucets and repeat with the cold water line faucets 11 Flush the toilet a few times until you see antifreeze in the toilet bowl When you are done adding RV antifreeze 12 Turn the water pump OFF Remove the clear hose from the container of RV antifreeze Turn off valve E Fig 8 8 Leave Valve D closed Utility Center w Valves Remove hose amp container from the City Water Fill inlet Put the cap back on the City Water Fill inlet Leave valves in Sanitize Winterize position 13 Pour 1 cup of RV antifreeze into any all drain P traps 14 To prevent sta
12. HEATING amp COOLING DUCTING amp RETURN AIR All heat discharges registers and return air grills must be free and clear of obstructions This includes all closeable registers that are intended to reduce airflow not shut it off completely ATTIC FAN The 12 volt DC attic fan or powered roof vent allows fresh air to circulate through the RV Do not leave the attic fan open when the RV is stored or unattended for long periods High winds other unusual conditions or obstructions may prevent the dome from closing the resulting leakage could cause non warrantable damage CEILING FAN IF SO EQUIPPED AN WARNING Be careful to avoid placing any object in the path of the ceiling fan blades Ceiling fans are both functional and decorative Turn the ceiling fan ON OFF using the interior wall switch The 3 speed ceiling fan is controlled by the pull chain switch The sequence of operation for the pull chain switch is OFF High Medium Low OFF The slide switch located on the fan controls the direction of operation down for forward up for reverse Stop the fan first before reversing the operation direction NOTE During cooler temperatures set your fan settings to low and set the fan to turn clockwise to pull warm air from the ceiling back towards the floor In the summer the fan should turn counterclockwise to keep air moving For additional information refer to the manufacturer s owner s manual includ
13. Interior Q Close roof vents Close windows amp latch blinds Counter items put away or tied down Furnace turned off Latch drawers cabinets amp doors Turn off the interior lights and appliances Disconnect any cable TV or phone hookups and lower the TV antenna if so equipped Move slideout if so equipped in and lock it in place Fasten and secure the furniture for travel if so equipped Refrigerator door locked if so equipped Set refrigerator to 12 volt if so equipped Water heater turned off if so equipped Water pump turned off if so equipped Exterior Oooooo Ooooovoo Empty black holding tank rinse as needed if so equipped Q Empty gray holding tank if so equipped Pack equipment into compartments and secure it Q Propane turned off Retract awning and secure in place for transport if so equipped Retract step Retract leveling jacks to the travel position if so equipped Water hose amp electric cord unhooked and stored Q Check tire pressure include inner wheel and spare if so equipped Q Check wheel lugs Q Test brakes for proper operation Q Secure any loose heavy or sharp objects in the RV or exterior compartments Disconnect the shore line power and ensure it is stored correctly Fasten all interior and exterior doors securely Lock them if so equipped Q Secure and lock the entrance door Walk around your RV one last
14. Name Address City State Province _____Zip Code Phone E Mail Address 15 2
15. A iver ead nares 4 4 Detachable Hithau ti a Ai ae del et a eS 4 17 Emergency Stopping 2 2 de ees 4 8 Emergency TOWING e sve sees cette ee 4 8 Entrance 4 9 JAY FLIGHT BUNGALOW DST TRAVEL TRAILER TABLE OF CONTENTS Hitching Procedure Travel 4 14 Keyless Entry If So 4 9 dh pede Res ee 4 9 a 4 8 Salety CAINS es 4 14 5 5 5 ane ene ias 4 16 EEEE 4 15 Spare Tire Carrier If SO 4 5 2 4 8 a ne ee 4 3 TOWING eT 4 1 Towing Behind Your RV Travel 4 15 Wheel LUGS acre 4 6 Wire Harness Connector Plug ccccceesceceseeeeneeseaeeeeaeeeeaeeseaeeseaeeseaeeeeaeeseeeteaeees 4 1 SECTION 5 SLIDEOUT SYSTE
16. Open the tongue jack coupler latch RION 7 0 A JFB JFD JAYCO TOWABLE SECTION 4 TOWING amp SET UP 8 Turn the tongue jack crank to raise the coupler above the hitch ball 9 Level the RV front to back with the tongue jack crank 10 If applicable lower the stabilizer jacks 11 Pull the tow vehicle away as desired SEASONAL SET UP If you are setting up in a seasonal camp site consult your authorized dealer for guidelines in properly setting up your travel trailer Proper set up will insure your safety along with getting the most effective use from your RV and its features You should also familiarize yourself with all site requirements and local zoning ordinances that may apply Set up recommendations The camping site should be properly graded and sloped to prevent water accumulation under the travel trailer Make sure all load bearing supports and footings meet the local enforcement agency requirements for size capacity and application Remove grass and organic material from the area beneath any supports or footings Tie down instructions All travel trailers should be securely anchored to the ground with 6 tie downs and ground anchors minimum 3 per side to resist the sliding and overturning effects of high winds Where tie downs are required it will be necessary to follow the instructions herein Frame tie down procedure All travel trailers are equipped with tie down attachment
17. SMOKE ALARM Some of the most common fire safety issues are burning candles smoking in bed leaving children unattended and cleaning with flammable fluids The smoke detector is intended to help reduce those risks Your RV is equipped with a smoke alarm that is listed for use in a recreation vehicle They are not fool proof Smoke alarms only work if they are operational and maintained Be sure to read understand and follow the owner s information from the manufacturer of the smoke alarm included in your Warranty Packet including information regarding the limited life of smoke alarms Please be aware the smoke alarm cannot detect fires if the smoke does not reach it Anything preventing smoke from reaching the alarm may delay or prevent alarm i e a closed door may prevent smoke from reaching an alarm on the other side of the door etc There are instances when the smoke detector alarm may not be heard Though the alarm horn in this detector meets or exceeds current UL standards it may not be heard for many reasons These include but not limited to a closed or partially closed door the alarm may be drowned out by other noise like the TV stereo traffic weather air conditioner or other appliances WARNING This smoke alarm will not alert hearing impaired residents Special alarms with flashing strobe lights are recommended for the hearing impaired Operation The smoke alarm is operational once the battery i
18. Some cycling may occur depending on the volume of water being released Turn the water pump switch OFF when it is not in use The water pump switch should be in the OFF position when the RV is left unattended for any amount of time If something would happen to the water system this may help limit water damage to a smaller area NOTE When you want to use water in your RV and the RV is not hooked up to City Water you will need sufficient 12 volt DC power to run the water pump WATER HEATER The water heater is designed to heat water quickly and efficiently The water heater manufacturer has preset the sensing limit to maintain the water temperature when the water heater is activated WARNING Hydrogen gas may result if you have not used the water heater for two weeks or more HYDROGEN GAS IS EXTREMELY FLAMMABLE To reduce the risk of injury under these conditions open the hot water faucet for several minutes at the kitchen sink before you use any electrical appliance connected to the hot water system If hydrogen is present you may hear what sounds like air escaping through the pipe as the water begins to flow Hydrogen gas may be present even after water has been drained from the water heater tank Open the faucet at the sink and allow the system to vent for five to ten minutes Do not smoke or have any open flame near the open faucet while venting On DSI water heater models make sure the switch is OFF 8 5 SECTION
19. damage your bumper Damage caused by such aftermarket equipment installation or improper loading voids the Towable Limited Warranty The rear bumper of your RV is not designed to carry cargo Items that extend beyond the bumper OR weigh over 100 165 45kg will place undo strain on the bumper 100 lb bumper capacity includes the weight of the spare tire that may have been attached at the factory Some items may fall within the given weight range however can still cause damage Over time weight added to the bumper will cause damage from the motion created while traveling In addition extra weight behind the axle may reduce the hitch weight leading to adverse handling conditions from wind gusts and or passing traffic 13 5 SECTION 13 EXTERIOR JAYCO TOWABLE A CAUTION SEALANTS Failure to properly maintain or reseal your RV may result in serious water damage to the roof and other parts of the RV This damage is not covered by the Towable Limited Warranty Sealants perform a very important function and should be inspected closely and regularly maintained We incorporate many different types of sealants including butyl putty black butyl encapsulated foam silicone clear and colored roof sealant and foam In general sealants do not have set lifetimes Varying environmental factors affect the pliability and adhesiveness of sealants You or your dealer must Inspect all sealants a minim
20. there may be a Full System Canister style water filter This canister may be located in an enclosed compartment behind the Utility Center If the water supply has not been used for some time allow the water to flow for several minutes to flush the system When not in use the water filter cartridge should be stored out of freezing temperatures RV antifreeze will damage the water filter cartridge Certain RV models may not include a filtration system The manufacturer has supplied a clear plastic bypass hose with fittings on either end to replace the water filter cartridge when the RV is being winterized This clear plastic bypass hose is re usable store it in the RV when it is not in use NOTE If your RV has the Full System Canister style water filter it will not include a bypass feature The canister must be removed filter taken out of the canister and the empty canister replaced before sanitizing or winterizing The canister is normally located in an enclosed compartment behind the Utility Center Each new RV is winterized with RV antifreeze before it is shipped to the dealer To use the water purification system Full System Canister water lines need to be flushed of antifreeze and then the filter installed in the canister before use For Cartridge Filter systems the antifreeze must be flushed out of the system and then the clear plastic bypass hose must be removed before installing the cartridge filter Replacing the water fil
21. 1 Carefully remove Symbols 2 4x40 Screws 3 Install Battery Compartment Lid by Aligning the 3 tabs and 3 slots 2 Install 4 fresh AA Batteries according to the orientation symbols 4 Carefully install the 4x40 screws to Attach Battery Compartment Lid 4 12 JAYCO TOWABLE SECTION 4 TOWING amp SET UP TRAVEL TRAILER HITCHING PROCEDURE The following procedure will help to assist you in securely hooking up your RV to your tow vehicle 1 sure the trailer wheels are blocked 2 the tongue jack crank to raise the travel trailer tongue above the hitch ball 3 Open the coupler latch on the travel trailer hitch 4 Back the tow vehicle into the proper position 5 Turn the tongue jack crank to lower the coupler onto the hitch ball 6 7 Close the coupler latch after it is completely seated Install the customer supplied weight distributing bars equalizers as directed by the OEM 8 Remove the dolly wheel or platform and retract the tongue jack to its maximum height 9 Attach the breakaway switch cable to the tow vehicle 10 Attach the safety chains 11 Plug in your wire harness connector plug from the tow vehicle to the travel trailer 12 Walk around the RV to verify exterior lights are working correctly 13 Remove the trailer wheel blocks B gt NOTE If an Atwood brake actuator is used with an equalizing hitch be sure the hanger chains hang between straight down and forward
22. 2 eerie ke 9 1 9 1 SECTION 10 APPLIANCES Central Vacuum If So Equipped 10 3 Cooking With Propane sise niente tli 10 2 In Case of Grease Fire 2 10 1 Kitchen Range amp Oven If So Equipped 10 2 Ache Selo 10 1 25 ead E bale 10 1 Washer Dryer Prep If SO 10 3 SECTION 11 ELECTRONICS Satellite If So Equipped 2 11 2 Television Power 11 1 Television Roof 11 1 SECTION 12 INTERIOR 5 See atelier 12 3 Booth Dinette If So Equipped 12 4 6 12 2 Cleaning The Interior 12 1 12 2 IV JAY FLIGHT BUNGALOW DST TRAVEL TRAILER TABLE OF CONTENTS Rad Wee 12 1 Floor 1 80 12 3 FIOOMING 12 2
23. 4 Open the low point drains Fig 8 14 by turning then pulling the handles up As their name indicates the valves will be at the lowest point of water lines A label may be placed on the outside of the RV to indicate where the drains are located The drains will typically need to be opened from inside the trailer Once the label is found on the outside of the trailer go inside to find the corresponding location of the drains 5 Drain the sink by removing the drain cap Turn ON the water pump and allow it to run as needed 7 Make sure water heater valves A amp B are closed valve C is open Refer to Bypass Diagram Fig 8 8 8 Relieve the water pressure using the water heater P amp T valve BEFORE removing the water heater drain plug Otherwise if there is any water pressure present the water will spray out of the opening when the drain plug is removed When you are finished draining the fresh water system reverse these steps and dump the grey and black water holding tanks at an appropriate facility or according to local public codes It is normal for some liquid to remain in the fresh water tank after drainage procedure Sanitizing the Plumbing System When to sanitize When your RV is new Atthe beginning and end of each season When the water system becomes contaminated or every three months of use How to Sanitize with either a Utility Center or a Gravity Fill and pump 1 Turn water heater power
24. 8 13 SECTION 8 PLUMBING SYSTEMS JAYCO TOWABLE 10 11 12 13 8 14 Utility Centers w o Valves Pour the solution into the Gravity Fill Utility Center w Valves Attach a hose to the City Water Fill inlet do not use your non toxic drinking water hose then place the other end of the hose in a container holding the chlorine solution Set the water valves to the Country Fill position Fig 8 12 and turn the water pump ON Solution will be pumped into the fresh water tank When all sanitizing solution is pumped into the fresh water tank turn the pump OFF Remove the hose amp container used to pour the chlorine solution and continue filling the fresh water tank with clean potable water until tank is full Gravity Fill Pour fresh water into the Gravity Fill inlet until the tank is full Utility Center w o Valves Pour the fresh water into the Gravity Fill inlet until the tank is full Utility Center w Valves If filling from a pressurized source Attach a hose to the City Water Fill inlet set the water valves to the City Fill Tank position the water pump is not used for this Turn on the water source and fill the tank until full Turn off the water source and disconnect the hose from the City Water Fill inlet Utility Center w Valves If filling from a water container set the water valves to the Country Fill position insert one end of a hose into the City Water Fill inlet the other end into the water container t
25. Free Standing Table amp Chairs If So Equipped 12 4 12 1 Hide A Bed If So Equipped 12 3 J Steel Sofa If SO Equipped 2 04 000 12 3 gt 12 1 Pantry f So Equipped 12 3 Recliner Chair If So 12 4 SECTION 13 EXTERIOR BBQ Grill lESo Equipped senen ina 13 1 Cleaning The EXEO e 2 13 2 Exterior Roof amp Sidewall Vents 13 5 Axle 13 5 Frame dh Aly tren aay 13 5 Patio Awning If So 13 7 13 5 Roof Ladder If SO 13 8 ere teas 13 6 WINGOWS 13 7 SECTION 14 TRAVEL CAMPING STORAGE CHECKLISTS Maintenance Chechlist cceccceesceceseeeeeeeeeeeeeaeeseaeeseaeeeaeessaee
26. IS NOT COVERED By way of example only this Limited Warranty does not cover any of the following defects in materials components or parts of the RV not attributable to Jayco items that are added or changed after the RV leaves the possession of Jayco additional equipment or accessories installed at any dealership or other place of business or by any other party other than Jayco any RV not used solely for recreational travel and camping all soft goods normal wear tear or usage such as tears punctures soiling mildew fading or discoloration of exterior plastic fiberglass upholstery drapes carpet vinyl screens cushions mattresses and fabrics the effects of condensation or moisture from condensation inside the RV and failure to provide adequate ventilation mold or any damage caused by mold to the inside or outside of the RV imperfections that do not affect the suitability of the RV for its intended purpose of recreational use or items that are working as designed but that you are unhappy with problems related to misuse mishandling neglect or abuse including failure to maintain the RV in accordance with the owner s manual or other routine maintenance such as inspections lubricating adjustments tightening of screws tightening of lug nuts sealing rotating tires damage due to accident whether or not foreseeable including any acts of weather or damage or corrosion due to the environment theft vandalism fire or other
27. Jayco Jayco is not responsible for the safety or quality of design features materials or workmanship of any alterations by such suppliers UPDATE YOUR CONTACT INFORMATION Help keep your contact information current so that in the event of a recall or customer notification letter you are notified Please copy and mail your completed Change of Address or Ownership Stolen Totaled or Destroyed form to Jayco If you purchased your RV as used include proof of ownership i e a copy of your bill of sale insurance policy etc JAYCO TRAVEL CLUB All owners of Jayco RVs are eligible for membership in the Jayco Travel Club The club promotes family fp 0728 camping and the active use of your RV with others who 4 have similar interests the RV lifestyle One International Rally is held each year in various locations around the United States and Canada In addition the club offers a variety of local and regional activities throughout the year By belonging to the Jayco Travel Club you will find new ways to enjoy your RV and make friends all across the country For more information please visit www Jaycorvclub com or call 1 800 262 5178 JAYPLUS EXTENDED SERVICE CONTRACT Don t let unexpected repair costs keep you from traveling toward your dreams Jay THE COMPETITIVE ADVANTAGE Protect yourself with a JayPlus Extended Service Agreement For more information contact your dealer or call 1 800 527 3
28. SYSTEMS Calculating Propane 7 10 Cooking With Propane 4 7 9 Hoses Pipes Tubes amp 6 2 0 0 000 7 8 Installing Propane 7 5 2 aria eign ih die aaf 7 2 Rropane Gas SYSlOM 7 1 Propane Leak ed 7 1 Propane Regulator v ccc 7 7 Propane Safety Proce Cures ccceeeeeesceeeseeeeseeeeseeeesaeeeeeeeseeseaeesesaeseeesseeeeeees 7 2 Traveling With Propane vccicccccccccevevcedeee 7 10 Using 7 8 TABLE OF CONTENTS JAY FLIGHT BUNGALOW DST TRAVEL TRAILER SECTION 8 PLUMBING SYSTEM 12 volt Water PUMP amp 2 22 2 0 8 5 Bathroom Tub Shower 7 8 11 Black amp Grey Tank 8 20 Black Grey Water Holding 8 20 Black Grey Water 8 18 Draining the Fresh Water 8 12 Faucets Heine ee eh eee EL ei ee ts 8 10 Fresh Water Connections ceccceesceeesee
29. a mild solution of soap and lukewarm water with a soft sponge or cloth Do not use abrasive cleaners as they could cause the vinyl to scratch and turn dull Grease spots and stubborn dirt can be cleaned off with an all purpose spray cleaner Harsh cleaners and organic solvents can attack the printed vinyl they are not recommended 12 1 SECTION 12 INTERIOR JAYCO TOWABLE CABINETRY amp TABLES To keep hardwood doors cabinet fronts and hardwood tables looking like new regularly dust with a soft cloth dampened with a cleaning polish or mild detergent solution Avoid using ammonia based products or silicone oils as they may cause damage if used over a long period of time The finish is durable and resistant to most household spills However spills should be wiped up promptly to avoid potential problems Excessive prolonged exposure to direct sunlight high temperatures and high humidity can cause damage to both the finish and the wood itself These should be avoided COUNTERTOPS To prevent permanent damage Always use hot pads or trivets under hot pans dishes or heat producing appliances such as frying pans Q Always use a cutting board never use a knife on the countertop Q Avoid harsh chemicals such as drain cleaners oven cleaners etc Do not let cleaners with bleach set on the top Wipe them off promptly Laminate countertops if so equipped Glass rings food spills water spots and smudges usually wipe off with a
30. all faucets using the 12 volt water pump Set upper switch to 3 lower switch to 5 Sanitize Winterize Lines This setting allows you to sanitize or winterize your fresh water system Set upper switch to 2 lower switch to 4 Sanitize Tank This setting allows you to sanitize the fresh water tank Set upper switch to 1 lower switch to 4 2 amp 6 City Fixtures 1 amp 6 City Fill Tank Fig 8 12 1 amp 4 Country Fill Utility Center Label 3 amp 5 Normal 2 amp 4 Sanitize Winterize Lines 1 amp 4 Sanitize Tank 8 9 SECTION 8 PLUMBING SYSTEMS JAYCO TOWABLE Utility Center w o Valves Fig 8 11 May include the following e City Water Fill inlet e Sewer tank flusher inlet e Water pump switch e Outside shower hookup e Shampoo dispenser and light e Dump valve for waste tank e Input for satellite cable if so equipped NOTE There will be a Gravity Fill inlet on the outside of the RV also OUTSIDE SHOWER IF SO EQUIPPED An optional handheld shower assembly with both hot and cold water faucets may be included for use outside the RV Fig 8 10 or 8 11 1 sure the water heater is ON and has had sufficient time to heat the water Water heater bypass valves should be set in the Normal mode Fig 8 8 2 Open the outside shower compartment door 3 If dry camping turn the water pump switch ON A pump switch is conveniently located at the outside shower controls 4 Utility Center w Valves Rem
31. an odor similar to rotten eggs is added as a warning agent If you smell propane within the vehicle quickly and carefully perform the procedure listed on the label below This label has been placed in the RV near the range for models equipped with a propane system A DANGER IF YOU SMELL PROPANE Extinguish any open flames pilot Fig 7 1 lights and all smoking materials Shut off the propane supply at If you smell propane label the container valve s or propane Label appearance may not be exact supply connection Do not touch electrical switches Open doors and other ventilating openings Leave the area until odor clears Have the propane system checked and leakage source corrected before using again Ignition of flammable vapors could lead to a fire or explosion and result death of serious injury When propane container is low occasionally there may be a concentration of an onion or garlic like odor which can be mistaken for a propane gas leak After the propane container has been refueled the odor will usually disappear If not turn off the valve s and have the propane system inspected by an independent Jayco dealer or qualified propane service representative PROPANE GAS CONTAINER Propane container is a general all inclusive term used to describe a vessel that is used for storage and delivery of propane gas The most common of these are DOT Department of Transportatio
32. and if dry camping the 12 volt water pump is turned ON before operating To open the faucets turn the hot and cold knobs ON and adjust the temperature to your comfort level Close the faucets when a sufficient amount of water is released turn the pump OFF if dry camping BATHROOM SHOWER OR TUB IF SO EQUIPPED The shower faucet if so equipped includes a vacuum breaker for the shower There are two purposes for this breaker To prevent siphoning water through the hose from another fixture To prevent water from being retained in the hose The showerhead DOES NOT have a complete shut off valve the complete shut off is at the faucet The showerhead may drip slightly in the OFF position after use this is normal and does not indicate a leak or defect There may be air in the plumbing lines that will need to be bled out before a steady stream of water comes from the faucet The bathing facilities in your RV function similar to those in your home Prepare the bath or shower curtains if so equipped to prevent water from spilling onto the floor Keep the water heater and holding tank capacities in mind when using the fresh water system The used water will drain through the plumbing pipes into the grey water holding tank 1 sure the water heater is ON and has had sufficient time to heat the water 2 If dry camping be sure your 12 volt water pump is 3 Adjust the hot and cold faucets to the desired temper
33. are model dependent There are two types of Utility Centers With Valves amp Without Valves Utility Center w Valves Fig 8 10 May include the following e Water Heater Bypass valves e Holding tank dump valves e Two valves used to select the following functions City Fixtures City Fill Tank Country Fill Normal Sanitize Winterize Lines and Sanitize Tank e Water pump switch e Outside Shower Fixture with Shampoo Dispenser and Light e City Water Fill Inlet and a Sewer Tank Flusher Inlet e will NOT be a Gravity Fill inlet on the outside of the RV The following information explains the functions of the two Utility Center water valves in regards to the large label located on the Utility Center front panel Refer to Fig 8 12 below which is a representation of this label City Fixtures Position This setting allows you to access water at all faucets using a pressurized external fresh potable water source referred to as City Water Set upper switch to 2 lower switch to 6 City Tank Fill This setting allows you to fill your fresh water tank using City Water Set upper switch to 1 lower switch to 6 Country Fill This setting allows you to fill your fresh water tank using the 12 volt water pump and a water container when you do not have access to City Water Set upper switch to 1 lower switch to 4 Normal If the RV is not connected to City Water this setting allows you to pump water from the fresh water tank to
34. are recommended If Torque falls below the Acceptable Torque Range additional torque is required See Wheel Torque Instructions and Wheel Lug Nut Diagram for the correct pattern and recommended final torque value During travel wheel lug nuts must be checked and re torqued as required after the first 10 miles 25 miles 50 miles then periodically during travel 16 kilometers 40 kilometers 80 kilometers then periodically during travel See Wheel Torque Instructions and Wheel Lug Nut Diagram for the correct pattern and recommended final torque value Failure to follow these instructions may result in wheel loss an accident or loss of control resulting in death or serious injury A WARNING Check and tighten wheel lug nuts regularly to make sure they did not loosen during travel Wheel lug nuts must be applied and maintained at the proper torque levels to prevent loose wheels broken studs and possible separation of the wheel s from your trailer The lug nuts on the wheels of your RV must be maintained according to listed torque values see Wheel Lug Torque Chart Over torqued and or under torqued wheels may result in component failure A WARNING Failure to maintain proper torque of the wheel lug nuts could lead to separation of the tire and wheel while driving possibly resulting in property damage or personal injury SECTION 4 TOWING amp SET UP JAYCO TOWABLE EMERGENCY STOPPING Always carry road flar
35. be adequate to accommodate weighing each side of your RV To weigh your tow vehicle and RV A WARNING Total weight of your tow vehicle and RV must not exceed the GCWR Do not assume that you can tow a RV that happens to be within the capacity of the tow vehicle hitch By doing so you may exceed the total GCWR of your tow vehicle and RV towing combination 3 4 JAYCO TOWABLE SECTION 3 PRE TRAVEL INFORMATION WARNING It is important to redistribute the load to avoid component failure as well as to improve the handling characteristics of the vehicle Read through all the weighing instructions before you begin If you have further questions consult with your dealer or the scale operator Your RV must be weighed fully loaded that is with food clothing fuel water propane supplies etc 1 Weigh the RV including the tongue weight while detached from the tow vehicle This actual overall weight must be less than or equal to the GVWR for safe operation If the overall weight is greater than the GVWR some contents must be removed until the actual overall weight is less than or equal to GVWR 2 Hitch the RV to your tow vehicle Weigh the RV and the tow vehicle to determine the GCW Make sure that this rating is less than or equal to the GCWR as specified by the manufacturer of your tow vehicle If this overall weight is greater than the GCWR some contents must be removed to bring the combination into compliance with t
36. caution to avoid over tensioning the straps as this may pull the trailer off the piers It is recommended that all straps be tightened only enough to remove the slack Then after all THE straps are installed and the slack removed tension the straps 4 The strap tension should be rechecked at frequent intervals until all pier settlement has stopped lt Fig 4 7 Frame SHOULDER TYPE tie down diagram EYEBOLT NUT amp WASHER NOT PROVIDED TIE DOWN BRACKET AN CAUTION During the re leveling process do not jack the travel trailer against tight straps Inspection Checklist Once the travel trailer has been set up for long term seasonal camping the following items should be checked for proper set up prior to occupancy Installation Placement Q Level Foundation Tie Downs Utility connections Q Fuel Q Water Electric Sewage DETACHABLE HITCH The hitch is detachable the instructions to remove and install it are listed below SUGGESTED MATERIALS CUSTOMER SUPPLIED Quantity Item Description 4 3 ton jack stands 2 7 8 open end wrench 1 3 4 socket and drive 1 3 8 socket and drive 4 Wood blocks to chalk tires Block tires on both sides of trailer 1 Unscrew flexible gas hose from main bulkhead on front steel crossmember and cap both fittings 2 Remove gas bottles from tongue 3 Remove electrical wiring and safety break a way switch from tongue by r
37. creates any warranty either expressed or implied nor does it cover every possible detail of equipment standard or option installed on or in your RV Information illustrations and specifications in this manual reflect the most current available at the time of publication approval are subject to change and not intended to indicate actual size WARRANTY PACKET The Warranty Packet contains original equipment manufacturer operator manuals warranty cards and or registrations It is important you complete and mail the warranty cards and registrations within the prescribed time limits to avoid loss of warranty coverage This manual and the Warranty Packet should be considered a permanent part of the RV If the RV is sold they should remain with the RV for the next owner SAFETY ALERTS Your safety and the safety of others is very important To help you make informed decisions we have provided operating procedures and other information on safety labels affixed to your RV and in this manual Please call your dealer or Jayco Customer Service if you are unsure how to proceed Always use the appropriate safety gear when servicing or maintaining your RV This is the safety alert symbol It is issued to alert you to potential personal injury hazards Obey all safety messages that follow this symbol to avoid possible injury or death DANGER This indicates an imminently hazardous situation that if not avoided will result in death o
38. cylinder invites moisture Tow vehicle battery The tow vehicle battery is the primary source of power for your RV s electric brake operation To ensure available power when needed keep your tow vehicle battery and charging system working properly Brake controller customer supplied The brake controller should be installed in the tow vehicle to work in conjunction with the RV electric brakes Consult with your dealer or the brake controller OEM to decide what is right for your towing combination VEHICLE LABELS Decals and data plates used throughout the RV aid in its safe and efficient operation others give service instructions Read all decals data and instruction plates before operating your RV If any decal data or instruction plate is painted over damaged or removed it should be replaced Keep a record of the 17 digit vehicle identification number VIN and your license number in the event theft or vandalism requires you to supply this information to the authorities WEIGHT LABELS WARNING The factory installed weight labels are specific to the recreation vehicle for which they are supplied and are not interchangeable Vehicle weight labels are posted on Jayco manufactured RVs so you can make an informed decision before your purchase Do not remove these labels from your RV If the labels are missing contact your dealer or Jayco Customer Service for replacements TIRE AND LOADING INFORMATION
39. damp sponge Stubborn stains can be removed with a general purpose spray cleaner Some stains can be removed by squeezing fresh lemon juice over the stain and allowing the juice to soak for approximately forty five minutes After 45 minutes sprinkle baking soda over the lemon juice and rub with a soft cloth Solid surface countertops if so equipped Solid surface materials are easy to care for Soapy water ammonia based cleaners not window cleaners as they can leave a waxy build up that may dull the surface or commercially available solid surface cleaners will remove most dirt and residue from all types of finishes A damp cloth followed by a dry towel will remove watermarks Disinfect the surface periodically with diluted household bleach one part water to one part bleach For additional information on the removal of difficult stains or surface damage repair refer to the countertop manufacturer s user guide FLOORING Always test a cleaning agent in an inconspicuous area for colorfastness Carpet if so equipped Vacuum regularly using a vacuum cleaner with a revolving brush or beater bar Be sure the vacuum does not have teeth combs or rough edges as they may damage the carpet It is important to remove loose soil and debris while it is on the surface Heavily traveled areas i e walkways areas in front of the furniture may be protected with small throw rugs to prolong the life of the carpet Some spills contain chemica
40. during warmer weather The main shut off valve must be kept closed at all times unless you are using the propane system or filling the propane cylinder When the cylinder is disconnected from the hose install the valve cover that is attached to the container Close the propane cylinder main shut off valve by hand tightening only Use of tools creates a potential to over tighten the valve damaging the interior seals on the cylinder valve seat If this type of damage occurs the cylinder will not close properly The following label should be kept permanently affixed to your RV WARNING Fig 7 2 Use propane only label Label appearance not be exact 7 3 SECTION 7 FUEL SYSTEM JAYCO TOWABLE Servicing or filling Have the RV checked for leaks at the connections on the propane system soon after the purchase and the initial filling of each propane cylinder When you have a new cylinder filled for the first time make sure your propane supplier purges your new cylinder of trapped air Otherwise an improper mixture of gas and air will make it impossible to light your propane appliances AN WARNING Before entering a propane or fuel service station make sure all pilot lights are extinguished Shut off gas to all appliances by closing the propane gas main shut off valve Always shut OFF any engine before refueling Do not smoke and do not operate other ian
41. extended will damage the switch and motor After the slideout is extended verify that the corners of the black rubber seal are set up correctly The corners of this seal are cut at a 45 angle The top of the seal must overlap the side of the seal to avoid the possibility of water penetration 5 1 SECTION 5 SLIDEOUT SYSTEM JAYCO TOWABLE Fig 5 2 Slideout overlap Retracting slideout room Press the IN section of the slideout control switch and hold it until the motor stops Operating the switch after the room is fully retracted will damage the switch and motor WARNING Maintenance Do not work on your system unless the 12 volt DC auxiliary battery customer supplied and 120 volt AC electrical systems shore line power cord have been disconnected Your slideout system has been designed to require very little maintenance To ensure a long life of your slideout system read understand and follow these simple instructions This system contains a pre lubed bearing that is lubricated when the room is moved in and out Do not spray oil or grease on the rails while the room is extended TROUBLESHOOTING THE SLIDEOUT If the slideout does not move when the slideout switch is depressed follow these steps Q Check the auxiliary battery customer supplied for a full charge and good wire connections Check the 12 volt fuse or circuit breaker Q Check for loose connections at the slideout motor If the slid
42. felt to insure proper seating of the tire for travel Reverse this process to release the spare tire for usage 4 5 SECTION 4 TOWING amp SET UP JAYCO TOWABLE Bumper mounted The spare tire bracket can be released and extended down to access a storage compartment at the rear of the trailer without removing the tire To extend the tire down 1 Remove the cotter key from the pin holding the tire carrier in place 2 Remove the pin and extend the tire carrier away from the trailer 3 Always return the tire carrier to the upright position and lock it in place while traveling To remove the tire from the tire carrier 1 Remove the lug nuts holding the tire in place 2 Remove the support bracket from the bottom lug 3 Pull the tire from the tire carrier Fig 4 5 Bumper mount To install the tire on the tire carrier 1 Place the tire on the carrier with the top lug bolt inserted into one of the holes in the tire rim and the bottom lug bolt in the center of the rim 2 Install the top lug nut 3 Place the support bracket over the bottom lug bolt across the center of the rim 4 Install the bottom lug nut over the support bracket 5 Make sure the lug nuts are tightened securely before returning to travel WHEEL LUGS After your first trip check the wheel lug torque periodically for safety Check the wheel lugs after winter storage after a wheel removal before starting a trip or following extensive braking Us
43. following grey tank waste water can help rinse any solids or debris from the dump outlet and sewer hose 1 make drainage easier level the RV 2 Remove the sewer hose housing dust cap and attach the sewer hose customer supplied 3 Place the end of the sewer hose into the approved dump station Fig 8 15 Black Grey tank 4 Open the black tank dump valve dump valves Valve may be located on the Utility Center if so equipped Close the dump valve when the black water holding tank is emptied 5 Open the grey tank dump valve Valve may be located on the Utility Center if so equipped Close the dump valve when the grey holding tank is emptied 6 Remove clean and store the sewer hose 7 Close the sewer hose housing dust cap You can locate many dump stations throughout the United States and Canada in Woodall s Rand McNally Camp Guide Good Sam Camp Guide KOA Kampgrounds Camp Guide and various other publications Some fuel stations also have dump stations Please contact your RV dealer for assistance in the purchase and installation of a sewer hose or sewer hose extension if needed Sewer Tank Flusher Inlet If So Equipped Sewer Tank Flusher Inlet also known CAUTION as the No Fuss Flush will have an identifying black amp chrome label next to it as shown This inlet is provided to assist in flushing out the black water tank Connect a pressurized water hose usually provided at the du
44. is completely set up and you are prepared for camping enjoyment use the following steps for propane operation 1 Close ALL burner valves controls and pilot light valves 2 Open the main valve in the propane container slowly to avoid a fast rush of propane vapor through the excess flow valve causing propane freeze up Should you experience propane freeze up close the main valve and wait 15 minutes before trying again 3 Listen carefully as propane begins to flow If a hissing noise is heard for more than one or two seconds close the main valve and contact your dealer to have the propane system tested 4 Light the appliances as needed and directed in the appropriate appliance manufacturer s owner manual located in the Warranty Packet Make sure that you read and fully understand ALL safety requirements for handling and operation of the propane system The Warranty Packet contains operator s manuals for the various appliances hooked to your propane system The propane system provides added benefits to your camping enjoyment however it must be handled with care If you have any questions or concerns consult with your dealer and or the specific manufacturer If you have double cylinders on your RV use only one at a time Otherwise the propane supply will be drawn equally from both cylinders until the supply has been totally exhausted Using one cylinder until it is empty then using the second cylinder will allow you
45. jacks must be fully retracted before moving or towing the RV to prevent stabilizer jack damage WARNING DO NOT USE THE STABILIZER JACKS TO LEVEL THE RV It is important to remember that the stabilizer jacks are to be used only for support while occupying and moving around the RV They are not designed to support the weight of the RV ENTRANCE DOOR A CAUTION Make sure the entrance door is completely closed and locked when traveling Locking the door helps prevent it from opening unintentionally The entrance door is located on the curbside of the RV Always hold onto the entrance door when opening or closing it as damage caused because you failed to do so is not covered by the Towable Limited Warranty KEYS LOCKS Several keys are provided when you purchase your RV Most keys have an individual key number stamped on the plate Record these key numbers and keep the information in safe place You can order a key blank from your RV dealer to have duplicate keys made If you lose the keys contact your RV dealer or a locksmith for assistance NOTE Locks on entrance and baggage doors need biannual lubrication using a light coat of silicone spray Conditions such as rain salt dust and pollution may increase the maintenance needs KEYLESS ENTRY IF SO EQUIPPED If your RV is equipped with a keyless entry system it is a battery operated system Programming and changing batteries on the lock system are descri
46. label Fig 7 10 Cooking comfort heating fresh air label Canada Units only CALCULATING PROPANE USAGE It is important to remember that if applicable your furnace refrigerator water heater and range all may use propane to operate Each has a different BTU rating and you will need to consider them to determine how long your propane supply will last Most RV gas appliances are operated intermittently Propane consumption depends on individual use of appliances and the length of time operated Unless there is heavy use of hot water the water heater consumption of propane is minimal During cool temperature or high wind conditions furnace consumption can be extremely high To calculate your propane supply take the BTU ratings for your propane appliances and divide that into the BTU availability Each gallon of propane 3 86 liters produces about 91 500 BTU s 46 514 kilojoules of heat energy The following chart provides average propane consumption information 7 10 Average BTU Appliance Consumption Hr Kilojoules Hr Water Heater 8800 9280 Refrigerator 640 1200 680 1270 Furnace 16 000 35 000 16 880 36 930 Range w Oven 7100 7490 Range Rear Burner 6500 6860 Range Front Burner 9000 9490 Outside Grill 10 000 10 550 JAYCO TOWABLE SECTION 7 FUEL SYSTEM Traveling with Propane Use care when fueling your tow vehicle Make certain your propane container is proper
47. model or serial numbers Complete and return the Warranty Registration and Customer Delivery Form to Jayco within 10 days of delivery to activate the applicable warranty coverage The Towable Limited Warranty is activated only after Jayco receives a signed and dated Warranty Registration and Customer Delivery Form from your dealer SECTION 1 WARRANTY amp SERVICE JAYCO TOWABLE SUGGESTIONS FOR OBTAINING SERVICE The independent dealers authorized to sell Jayco RVs are also there to provide service after the sale We work closely with them in an effort to keep you satisfied To help ensure your dealer provides the level of service you expect here are some suggestions we would like to make Contact your dealer at once Do not wait until you are ready to use your RV Your dealer may not be able to service it immediately and or the repair may require parts be ordered The dealer s service department is busiest on Mondays Fridays and before the holidays Prepare for the appointment If you are having warranty work performed be sure to have the right papers with you Take your warranty folder and have your vehicle information available Not all the work to be performed may be covered by the warranty discuss additional charges with the dealer s service management Prepare a list Provide your dealer with a written list of specific repairs needed It is important that you pro
48. observe the following 1 Keep the washing nozzle about 16 inches 40 cm more away from the RV body 2 When washing around the door vent and glass areas hold the nozzle at right angles to the surface Depending on your model the exterior is constructed of aluminum or fiberglass Refer to the general instructions that follow for care information Ooocoo 13 2 JAYCO TOWABLE SECTION 13 EXTERIOR Washing Chemicals contained in dirt and dust picked up from the road surface can cause damage if left on the RV for a long time Frequent washing and waxing is the best way to protect your RV from this damage Frequent washings also protect your RV from environmental elements such as rain snow and salt air Do not wash the RV when it is in direct sunlight Park the RV in the shade and spray it with water to remove dust Next using an ample amount of clean water and a car washing mitt or sponge wash the RV from top to bottom Use a mild car washing soap if necessary Rinse thoroughly and wipe dry with a chamois or soft cloth Carefully clean the joints and flanges of the slideout if so equipped doors hood etc where dirt is likely to remain Some types of hot water washing equipment apply high pressure and heat to the RV They may cause heat distortion and damage to the resin parts and may flood the RV s interior Therefore be sure to observe the following 1 Keep the washing nozzle about 16 inches 40 cm m
49. on appliances or furniture are secured WEIGHING YOUR TOW VEHICLE amp RV A WARNING The actual weight of the vehicle all options liquids the hitch weight and your personal cargo is important for you to know so you do not exceed the Gross Vehicle Weight Rating GVWR of the recreation vehicle The volume of space available for storage may exceed the amount of available cargo capacity Large storage compartments have been designed to accommodate normal camping items which are bulky but not necessarily heavy A WARNING DO NOT EXCEED YOUR GVWR This means you should weigh your RV as loaded for your normal travel to determine the actual weight A WARNING If you exceed the GVWR you MUST remove items from the RV or drain liquids then re weigh the vehicle to ensure you have achieved a safe weight Weight labels are posted inside your recreation vehicle so you can make a decision before you buy about how much cargo capacity is important for you personally There are two important factors when loading your RV total weight and balance It is imperative that you verify compliance within all applicable weight ratings Overloading your RV will void the Towable Limited Warranty and the warranties of many component part manufacturers Have your RV weighed periodically at a public scale to determine the proper load distribution Keep in mind that individual scales will operate differently The surroundings of the scale need to
50. part of your RV maintenance If you have any questions consult your dealer 6 2 JAYCO TOWABLE SECTION 6 ELECTRICAL SYSTEM AN WARNING Replacement circuit breakers must be of the same voltage amperage rating and type Never use a higher rated replacement circuit breaker doing so may cause a fire by overheating the RV wiring Please contact your dealer for repair assistance when replacing circuit breakers BATTERY DISCONNECT SWITCH IF SO EQUIPPED The Battery Disconnect switch is located in an enclosed exterior compartment at the front side of the RV This switch shuts off all 12VDC power to the main 12V fuse panel and the interior of the RV The photos at the right show the switch turned ON Green 1 showing and the switch turned OFF CCW Red 0 showing Fig 6 3 Battery Disconnect Switch CONVERTER The power converter converts 120 volt AC power to useable 12 volt DC power when the shore power cord is connected to an external power source The converter has a built in protective thermal breaker that will shut it down should overheating occur Overheating can be caused by operating the converter above its maximum power output for an extended period of time or by an obstruction to its ventilation air flow To reduce converter heat build keep unnecessary 12 volt lights and motors turned off Keep the converter cooling fins and fan clear of obstructions Inspection and maintenance If the 12 vo
51. period drain the chlorine solution from the fresh water system see Draining the Fresh Water System JAYCO TOWABLE SECTION 8 PLUMBING SYSTEMS Rinse the system with fresh water 14 Fill the fresh water tank full of clean potable water Gravity Fill Must be filled from an external container Pour fresh water into the inlet Utility Center w o Valves Pour fresh water into the Gravity Fill Utility Center w Valves If filled from a pressurized source set the water valves to the City Fill Tank position pump is not used Attach hose to the City Water Fill inlet and turn on the water source Utility Center w Valves If filling from a water container set the water valves to the Country Fill position Insert a hose into the City Water Fill inlet place other end of the hose in the water container Turn pump ON to draw water into the tank After the tank is full turn the pump OFF Remove the hose and the container 15 Power to water heater should be OFF Electric amp LP GAS switches When the fresh water tank is full Gravity Fill Turn the pump ON to begin sending water through the lines Utility Center w o Valves Turn the pump On to send water through the lines Utility Center w Valves Turn off the pressurized water source disconnect the hose from the City Water Fill inlet set the water valves to the Normal position and turn the pump ON If you are not using a pressurized water source just set the water valves to
52. test all connections and lights READY TO LEAVE CHECKLIST Before leaving or returning home it is critical that you complete the necessary procedures to ensure a safe trip As you develop a routine it is possible that a checklist will be helpful This is a general list which you may want to customize as you determine your own needs Make sure you follow all safety precautions noted this owner s manual in any manufacturer s operators manual when preparing to travel Check the area under the RV after overnight parking and look for water or other fluid leaks If leaks are detected find the cause and correct it immediately Make sure all tow vehicle fluids are at proper levels Check the engine oil transmission fluid engine coolant power steering fluid and wind shield washer fluid Check the lights on the RV Have someone observe the operation of all exterior lights while you activate the controls Check the turn signals and brake lights Examine the tires for excessive tread wear or uneven wear patterns Check for stones nails glass or other objects lodged in the tread Inspect for tread cuts or sidewall cracks Check wheel lug nuts for tightness and tires for proper air inflation pressure Check the propane cylinder gauge to make sure there is propane available Make sure the propane cylinder is in place and secure for transport 14 1 SECTION 14 TRAVEL CAMPING STORAGE CHECKLISTS JAYCO TOWABLE
53. tested with a propane leak detector or soapy water solution 3 Open the main valve slowly to avoid a fast rush of propane to the excess flow valve causing propane freeze up If you experience a propane freeze up close the main valve and wait at least fifteen 15 minutes before trying again Refer to the regulator manufacturer s operator manual 4 Listen carefully a hissing sound longer than one second may indicate a propane leak If you feel there may be a leak present close the valve and contact your dealer or qualified propane technician for repair assistance Replace all protective covers and caps on the propane system after filling Make sure the valve is closed and the compartment door is securely latched Maintenance Propane gas is normally non corrosive you need not worry about the inside of your container However the outside should be kept free from rust by a periodic coat of paint in a light reflective color Rust scratches and or dents can affect the safety of the cylinder Inspect the cylinder at regular intervals If there is a problem have it evaluated by a qualified technician and discard it DOT requires that a visual inspection be made prior to each filling Any cylinder that has been exposed to fire leaks or seems damaged should not be refilled Do not attempt to repair any containers container valves regulator or appliances by yourself Use only trained certified propane gas service technicia
54. the circuit etc All ground faults must be repaired before use of the RV 12 vo_t DC SYSTEM The majority of your RV lighting is powered by 12 volt electricity The 12 volt DC system is composed of components that will operate when the following conditions are met Power is supplied by the tow vehicle alternator when the engine is running and the 7 way trailer plug is connected This powers the RV s running lights brake lights turn signals and brakes In addition the 7 way trailer plug provides a common ground and a 12 volt charge line to charge the auxiliary battery The converter will supply interior 12 volt DC power when the power cord is plugged into campground power The converter will also charge the RV battery in most situations Refer also to the Battery Disconnect section The auxiliary battery powers many interior 12 volt components including the lighting fixtures water pump 12 volt motors 12 volt appliances etc It also powers the breakaway switch AUXILIARY BATTERY CUSTOMER SUPPLIED Your RV has many 12 volt DC loads When combined their total is more than the converter can produce High demands for 12 volt power can be met by an auxiliary battery for limited periods of time The 12 volt DC electrical system is designed for usage with a Group 27 deep cycle battery Dry camping Consider the charge condition of the auxiliary battery when dry camping If the auxiliary battery is
55. the hitch manufacturer instructions to adjust the weight distributing hitch to the proper height 3 6 JFTT WHKTT JFULE OCST JAYCO TOWABLE SECTION 3 PRE TRAVEL INFORMATION If you have additional questions consult with your dealer Make certain your Dealer is aware of the tow vehicle you are using so a compatible hookup is achieved Depending on the model your required travel trailer hitch ball diameter is either 2 or 2 5 16 consult your dealer for assistance TRAVEL TRAILER SWAY CONTROL CUSTOMER SUPPLIED A WARNING A sway control device customer supplied should be used with your tow vehicle travel trailer combination Consult with your Dealer to obtain the proper equipment for your needs Sway control devices are available to reduce the sway produced by crosswinds air displacement caused by other vehicles passing you in transit incorrect weight distribution excessive speed the RV tires dropping onto the shoulder of the road etc You will also want to discuss this purchase with your Dealer The use of a sway control device will help to control the side to side movement and keep sway in check Suggestions for sway situations Q Slowly ease your foot off the accelerator Turn the steering wheel as little as possible Natural lag time reaction when counter steering to correct sway could possibly make it worse Ifthe trailer is equipped with electric brakes using the hand control will help to keep
56. the other off of 120 volt 60hz AC power All installations have been made in compliance with industry standards applicable on the date of manufacture Because the electrical equipment and associated circuitry are engineered into a dedicated system specific to your RV we recommend you do not make unauthorized changes or add fixed appliances to it Changes or additions made after delivery may result in a hazardous condition Service and or modification of the electrical system should only be performed by qualified electrical technicians using approved materials components and methods meeting current safety and code requirements Please consult your dealer s service department for assistance To read more about the various components incorporated into the RV electrical system please refer to the information contained in your Warranty Packet ELECTRICAL SYSTEM MAINTENANCE Before working on the electrical system always disconnect the shore power cord turn off the Battery Disconnect switch if so equipped and turn off the 120V main circuit breaker if so equipped Then disconnect the negative 12VDC battery terminal from the battery Refer to the sections on Battery Disconnect switch amp Load Center AN WARNING Use caution when using metal tools If a tool contacts a battery terminal or metal connected to it a short circuit could occur which could cause personal iniurv exolosion or fire IN CASE OF AN ELECTRICAL FIRE AN WARNI
57. to the smoke detector users manual provided in the Warranty Packet 2 3 SECTION 2 OCCUPANT SAFETY JAYCO TOWABLE Replacement Smoke alarms have a limited life and are not foolproof Smoke alarms will wear out over time like any appliance Always replace the detector immediately if it is not working properly it displays any type of problem or within five years of use Refer to the smoke detector manufacturer s information in your Warranty Packet for additional information COMBINATION CARBON MONOXIDE PROPANE ALARM Your RV is equipped with a combination carbon monoxide CO propane alarm that is listed for use in recreation vehicles The combination carbon monoxide propane alarm will only work if it is operational and maintained The alarm is wired directly to the RV 12 volt electrical system with continual power being supplied by the RV battery There is no 9 volt battery power supply in the carbon monoxide propane alarm If the battery cable is disconnected at the battery terminals the combination alarm will not work Be sure to read understand and follow the owners information from the manufacturer of the combination CO propane alarm that has been supplied in your Warranty Packet This includes information regarding the limited life of the alarm Carbon monoxide CO is an insidious poison It is a colorless odorless and tasteless gas Many cases of reported carbon monoxide poisoning indicate while victims are aware they ar
58. water heater At the end of every trip you should drain any unused water from the fresh water system The fresh water or potable water system needs periodic sanitization and winterization to take care of all the components within the plumbing system and help discourage the growth of bacteria and other organisms that can contaminate the water supply There are labels affixed to the exterior of the RV s sidewall that indicate the locations of the water system drains and fills Be aware some drains may be located inside the RV once the exterior label is found go inside to find the drain corresponding location Do not remove these labels FRESH WATER SYSTEM A WARNING DO NOT drink water deemed microbiologically unsafe or of unknown quality All water contains contaminant and mineral particles that can cause fresh water system odors Untreated well water is a major source of water system odors The fresh water or potable water system needs periodic sanitization and winterization to take care of all the components within the plumbing system and help discourage the growth of bacteria and other organisms that can contaminate the water supply MONITOR PANEL IF SO EQUIPPED The interior wall mounted Monitor Panel allows you to monitor the fresh water grey water black water and auxiliary battery levels These functions are controlled using the tact switches located on the monitor panel f
59. will flash and the alarm will sound a steady tone These signals indicate immediate action is required Q Alarm malfunction low battery The gas LED will remain off and the Operational CO LED will alternate re green and the alarm will sound once every 15 seconds Q End of life alarm The LED will flash red red green green and the alarm will BEEP every 25 30 seconds The alarm should be immediately replaced AN WARNING Never turn the 12 volt battery disconnect control to the off position and disconnect the battery cable to silence the alarm WARNING The alarm will automatically sense when the level of carbon monoxide in the air reaches below dangerous levels You should stay outside the vehicle in fresh air until the alarm is silenced When the alarm sounds do not stand too close to the alarm The sound produced by the alarm is loud because it is designed to wake a person in an emergency Prolonged exposure to the alarm at a close distance may be harmful to your hearing Maintenance Vacuum the alarm cover at least once a year Clean the cover by hand using a cloth dampened in clean water Dry with a soft cloth Do not spray the front panel of the alarm with cleaning agents or waxes This action may damage the sensor causing an alarm or cause the alarm to malfunction Do not paint the face of the alarm Testing the combination carbon monoxide propane alarm WARNING Test the alarm operation after the RV ha
60. 12 VOLT FUSES The 12 volt fuses are located in the Load Center Fig 6 2 and are labeled to indicate fuse sizes positions and the components powered At the beginning of camping season inspect all the 12 volt fuses and replace as needed Replacing a fuse Before replacing a fuse always turn off electrical component s protected by it 1 Disconnect the shore power cord 2 Disconnect the RV auxiliary battery main negative battery cable 3 Remove the fuse panel cover to check fuses 4 Pull the fuse straight out of the fuse block If the fuse is not blown something else must be causing the problem Please contact your dealer for further assistance 5 Insert a new fuse of the same specified voltage amperage rating and type in the original location Never use a higher rated replacement fuse The fuse panel label should be kept permanently affixed to your RV The fuses will not offer complete protection of the RV electrical system in the event of a power surge or spike 6 5 SECTION 6 ELECTRICAL SYSTEM WARNING JAYCO TOWABLE Replacement fuses must be of the same voltage amperage rating and type Never use a higher rated replacement fuse doing so may cause a fire by overheating the RV wiring DC FusE PANEL LAYOUT Below is a typical wiring layout Your individual RV may be different Refer to the diagram inside the Load Center Fig 6 2 for specific fuse assignments
61. 2 or more service attempts have been made to correct any covered defect that you believe impairs the value use or safety of the RV or if it has taken longer than thirty 30 days for those types of repairs to be completed you must to the extent permitted by law notify Jayco directly in writing at the above address of the unsuccessful repair s of the alleged defect s so that Jayco can become directly involved in making sure that you are provided service pursuant to the terms of this limited warranty WHAT IS NOT COVERED By of example only this limited warranty does not cover of the following defects in materials components or parts of the RV not attributable to Jayco items that are added or changed after the RV leaves the possession of Jayco additional equipment or accessories installed at any dealership or other JFB JFD 1 9 SECTION 1 WARRANTY amp SERVICE JAYCO TOWABLE place of business or by any other party other than Jayco any RV used for rental or other commercial purposes Note It shall be concluded that the RV has been used for commercial and or business purposes if the RV owner or user files a tax form claiming any business or commercial tax benefit related to the RV or if the RV is purchased titled or registered in a business name any RV sold or used outside the United States U S Territories or Canada any RV purchased through auction or wholesale any RV purchased from a dealer that is not an
62. 2016 JAY FLIGHT Jayco Generations of family fun 0190626 2016 PRINTED ON RECYCLED PAPER THE JAYCO ECOADVANTAGE IS OUR COMPANY S COMMITMENT TO PROTECTING THE ENVIRONMENT Through Jayco s company wide sustainability program we re creating better ways to build better RVs using fewer natural resources Already our initiative has created significant impact As of 2014 our company has Recycled 7 192 tons of wood msn 2 354 tons of scrap metal 1 428 tons of cardboard and paper Conserved e 9 997 400 gallons of fresh water enough to meet the daily needs of 133 293 Americans 34 277 gallons of gas enough for Americans to drive more than 957 600 miles e Enough electricity to power 1 745 homes for a year Saved 60 900 mature trees 4 Enough landfill airspace to meet the annual disposal needs of a community of 44 683 people We re proud of our results and we know those numbers show that a little initiative can go a long way The Jayco EcoAdvantage is our way of making sure endless generations can enjoy the Great Outdoors JAY FLIGHT BUNGALOW DST TRAVEL TRAILER TABLE OF CONTENTS A WARNING READ ALL INSTRUCTIONS IN THIS MANUAL AND COMPONENT MANUFACTURER SUPPLIED INFORMATION BEFORE USING YOUR RV This manual has been provided by Jayco Inc for the sole purpose of providing instructions concerning the operation and maintenance of this vehicle and its components Nothing
63. 426 Your dealer can help you obtain a JayPlus insurance quote from GMAC Insurance or call 1 877 484 2261 Savings Code GL 2A SECTION 1 WARRANTY amp SERVICE JAYCO TOWABLE JAYCO CUSTOMER FIRST EMERGENCY ROADSIDE ASSISTANCE Jayco has teamed up with Coach Net to offer 24 7 motorist assistance We are offering this free of charge for the first year of ownership certain restrictions apply You may continue your emergency roadside assistance benefits in the following years by contacting Coach Net to discuss terms and rates for this independently continued coverage For details on accessing your emergency roadside assistance benefits please refer to your Member Benefit Guide that is sent out 6 8 weeks after your completed Warranty Registration and Customer Delivery Form is received by Jayco or contact Coach Net www coach net com at 1 877 801 0333 To qualify for coverage your RV must be eligible as set forth under the terms of the Towable Limited Warranty OBTAINING EMERGENCY WARRANTY REPAIR A roadside emergency can happen at any time whether your RV is new or old If you are traveling using the following guidelines can help get you back on the road faster 1 Call 1 800 RV JAYCO or use our website dealer locator to find an authorized Jayco dealer in your area Contact them for an appointment they will handle all warranty repair billing and returned parts for you 2 If you cannot locate an authorized Jayco dea
64. 7 0 AMPS Momentary Load 12 Volts Labeled watts divided by 12 Power consumed in AMPS 6 10 50 Amp JAYCO TOWABLE SECTION 7 FUEL SYSTEM PROPANE GAS SYSTEM Propane or LP liquefied petroleum gas is a clean and efficient form of energy when proper handling and safety precautions are observed The propane system in your RV furnishes the fuel for cooking heating and hot water Propane can also be used as an alternative energy source for refrigeration The propane fuel system is comprised of numerous components such as the propane container hoses the propane gas regulator piping and copper tubing lines to each appliance Propane is heavier than air the gas tends to flow to lower areas and will sometimes pocket in these low areas such as the floor Your RV is equipped with a propane alarm refer to Sec 2 Safety Precautions Combination Carbon Monoxide CO Propane Alarm A WARNING Propane cylinders should not be placed or stored inside RV LP gas cylinders are equipped with safety devices that relieve pressure by discharging gas into the atmosphere Maintenance Although both Jayco and your selling dealer carefully test for leakage travel vibrations can loosen fittings Have the propane system checked at all connections soon after the purchase of your RV and after the initial filling of the propane tanks All propane lines have been checked with air pressure at the time of manufacture De
65. 8 PLUMBING SYSTEMS JAYCO TOWABLE AN WARNING Do not replace any component part with an accessory part that is not authorized by the water heater manufacturer such as an add on electric heating element Such items are not approved to be installed and could create an unsafe condition and will void all warranties WARNING Operating instructions If you smell propane gas then STOP and follow the procedures listed in the Fuel Systems section of this manual before attempting to operate the water heater Read the safety and operating information provided in the manufacturer s manual before attempting to activate the water heater Make sure the water heater is filled with water before use even momentary operation of the water heater without water in it may result in damage to the tank heating element and or controls Double check the bypass valves make sure they are set properly Always open both the hot and cold water faucets when filling the fresh water tank to allow air pockets to be forced out of the water heater Draining and winterization If the RV is to be stored over the winter months the water heater must be drained to prevent damage from freezing It is recommended the water heater be drained and bypassed during the winterization process particularly if introducing RV antifreeze into the plumbing system Water Heater Bypass Use the factory installed water heater bypass available in most floo
66. D IN SCOPE OF COVERAGE TO THE SCOPE OF COVERAGE OF THIS LIMITED WARRANTY Jayco makes no warranty of any nature beyond that contained in this limited warranty Jayco does not authorize any person to create any other obligation or liability for it regarding this RV and Jayco is not responsible for representation promise or warranty made by any dealer or other person beyond what is expressly stated in this limited warranty and no one has the authority to enlarge amend or modify this limited warranty Any selling or servicing dealer is not Jayco s agent but an independent entity JAYCO SHALL NOT BE LIABLE FOR ANY INCIDENTAL OR CONSEQUENTIAL DAMAGES THAT MAY RESULT FROM BREACH OF THIS LIMITED WARRANTY OR ANY IMPLIED WARRANTY THIS EXCLUSION OF CONSEQUENTIAL AND INCIDENTAL DAMAGES SHALL BE INDEPENDENT OF ANY FAILURE OF THE ESSENTIAL PURPOSE OF ANY WARRANTY AND THIS EXCLUSION SHALL SURVIVE ANY DETERMINATION THAT THIS LIMITED WARRANTY OR ANY IMPLIED WARRANTY HAS FAILED OF ITS ESSENTIAL PURPOSE Some states do not allow limitations on how long an implied warranty lasts or the exclusion or limitation of incidental or consequential damages so the above limitations or exclusions may not apply to you JFB JFD 1 13 SECTION 1 WARRANTY amp SERVICE JAYCO TOWABLE HOW TO GET SERVICE To obtain reimbursement of warranty service the owner must do all of the following 1 Notify Jayco of the substantial defect in material or workmanship attribu
67. Jayco of the substantial defect in material or workmanship attributable to Jayco within the warranty coverage period designated above 2 Provide the notification mentioned in 1 above within ten 10 days of when the owner discovered or should have discovered the substantial defect in material or workmanship attributable to Jayco 3 Promptly schedule an appointment with and take the RV to an independent authorized dealer of Jayco or Jayco for repairs except for the first three 3 service calls as noted above and 4 Pay any freight or transportation costs import duties fees and all incidental expenses associated with obtaining warranty service For warranty service simply contact one of Jayco s independent authorized service centers for an appointment and then deliver your RV to the service center on the specified appointment date If you need assistance you may contact Jayco at 903 S Main Street P O Box 460 Middlebury Indiana 46540 Attn Customer Service 574 825 5861 800 283 8267 or www jayco com NOTE Jayco does not control the scheduling of service work at the independent authorized dealerships You may encounter some delay scheduling or completion of work Also you must notify the selling dealer at time of delivery to have work performed on any defect that occurred at the factory during manufacture at no cost to you as provided by this limited warranty See below under WHAT IS NOT COVERED If two
68. LE CUSTOMER RESPONSIBILITY It is important you read and understand the information in this manual and your Warranty Packet using your RV Familiarize yourself with the applicable warranties You are responsible for ensuring the procedures for obtaining warranty repair are followed properly It is your responsibility and obligation to return your RV to your dealer for warranty service repair As the owner of the RV you are responsible for regular and proper maintenance performed in accordance with this manual and the OEM manuals Regular and proper maintenance will help prevent conditions arising from neglect that are not covered by warranty As with your other personal belongings it is important to protect yourself and others with insurance coverage Your insurance agent can assist you in obtaining the appropriate insurance coverage for personal liability theft collision property damage etc DEALER RESPONSIBILITY At the time of sale of the new RV your dealer is expected to Deliver your RV in the best condition possible Your RV must pass the dealer s pre delivery inspection PDI including all systems tests Provide orientation of the RV its systems components and operation Request that you read all warranty information and explain any provision not clearly understood Ensure you receive the Warranty Packet Your dealer can assist you in completing the OEM warranty cards or registrations and locate any required component
69. LIMITED WARRANTY AND IS LIMITED IN SCOPE OF COVERAGE TO THE SCOPE OF COVERAGE OF THIS LIMITED WARRANTY Jayco makes no warranty of any nature beyond that contained in this limited warranty Jayco does not authorize any person to create any other obligation or liability for it regarding this RV and Jayco is not responsible for any representation promise or warranty made by any dealer or other person beyond what is expressly stated in this limited warranty and no one has the authority to 1 8 JFB JFD JAYCO TOWABLE SECTION 1 WARRANTY amp SERVICE enlarge amend or modify this limited warranty Any selling or servicing dealer is not Jayco s agent but an independent entity JAYCO SHALL NOT BE LIABLE FOR ANY INCIDENTAL OR CONSEQUENTIAL DAMAGES THAT MAY RESULT FROM BREACH OF THIS LIMITED WARRANTY OR ANY IMPLIED WARRANTY THIS EXCLUSION OF CONSEQUENTIAL AND INCIDENTAL DAMAGES SHALL BE INDEPENDENT OF ANY FAILURE OF THE ESSENTIAL PURPOSE OF ANY WARRANTY AND THIS EXCLUSION SHALL SURVIVE ANY DETERMINATION THAT THIS LIMITED WARRANTY OR ANY IMPLIED WARRANTY HAS FAILED OF ITS ESSENTIAL PURPOSE Some states do not allow limitations on how long an implied warranty lasts or the exclusion or limitation of incidental or consequential damages so the above limitations or exclusions may not apply to you HOW TO GET SERVICE To obtain warranty service the owner must do all of the following 1 Notify an independent authorized dealer of Jayco or
70. MS 51 5 1 Troubleshooting the 2 4 4 1 0 5 2 SECTION 6 50 ELECTRICAL SYSTEM 120 volt Circuit Breakers 6 2 120 6 1 12 volt DC Outlet If So Equipped 2 6 5 12 VOIt DG SYSIOM 6 3 12 07 Fuse Panel 6 4 5SOrAMP SYSlSM he hgh ea a 6 6 Approximate Electrical Load Ratings 22 6 9 Auxiliary Battery Customer Supplied 6 3 Battery Isolator For Your Tow Vehicle Customer Supplied 6 4 Calculating Electrical 6 8 22 harassed eee 6 2 DG Fuse 2 2 cases tees raaa ee dusk aide E aa ia 6 5 Electrical System Maintenance 2 44440 400 0 6 1 Receptacle Outlet 6 3 In Case Of An Electrical Fire 2 6 1 Inverter If So Equipped assioni istenip mend eatas 6 8 Powel neeite a E a 6 6 Replacing Light Bulbs 6 5 SECTION 7 FUEL
71. Method This method will utilize an air hose to blow excess water from the water lines Recommended pressure is 40 PSI exceeding this pressure may rupture water line couplings and void your warranty 1 sure all holding tanks are empty and all drain valves OPEN 2 Run the water pump until it is dry this will take approximately 15 20 seconds 3 OPEN all faucets and drains including outside shower faucets if so equipped and hold the flush lever open on the toilet 4 Using an air hose and adapter customer supplied blow air through the City Water connection Any remaining water will blow out in five to ten minutes 5 Pour one cup of non toxic RV antifreeze into any all drain P traps Demand Power Plumbing System Method It may be easier to winterize the RV with another person to assist you Antifreeze should never enter the water heater water filter or fresh water tank 1 Turn water heater power OFF Electric amp LP Gas switches 2 Level the RV and drain the fresh water plumbing system See Draining the Fresh Water System 3 Replace the water filter cartridge with the clear plastic bypass hose if so equipped On Full System Canister water filters remove the canister take out the filter and reattach the empty canister 8 17 SECTION 8 PLUMBING SYSTEMS JAYCO TOWABLE 4 Water heater should be empty after performing Step 2 Water heater valves A amp B should still be closed valve C open
72. N 8 PLUMBING SYSTEMS 12 Refill the fresh water system with clean water Turn the water heater power ON when the water heater is full of water WINTERIZING THE PLUMBING SYSTEM AN WARNING Automotive antifreeze ethylene glycol and windshield washer antifreeze methanol are poisonous Never use these products in your fresh water system These products are harmful and may be fatal if swallowed Preparing your RV for colder weather or storage is very important for most states and Canada Failure to prepare your RV may cause water supply lines and the water heater to freeze Use ONLY RV ANTIFREEZE in your fresh water system for freeze protection No other product or commodity should be used The RV should be winterized at the end of the camping season or when the RV will be exposed to temperatures that will fall at or below 32 F 0 C Repairs due to freezing are not covered under the terms of the Towable Limited Warranty The water heater must be drained to prevent damage from freezing It is recommended the water heater be drained and bypassed during the winterization process particularly if introducing RV antifreeze into the plumbing system Ensure the water heater is bypassed Refer to Fig 8 8 antifreeze should be kept out of the water heater There are two methods of winterizing your trailer based upon your model Please read and understand the following instructions before beginning Air Pressure
73. NG Do not attempt to use water to put out an electrical fire Water can spread some types of fire and electrocution is possible with an electrical fire Have everyone evacuate the RV immediately Disconnect the power cord from the shore power receptacle Switch the 120 volt main circuit breaker in the trailer to the off position Disconnect the negative battery cable s at the battery Always have faulty or damaged wiring and electrical components repaired immediately NOTE It is important that everyone knows where to find the120 volt main circuit breaker and how it operates Refer to Load Center section OVP SS LOAD CENTER The Load Center contains 12VDC fuses and 120VAC circuit breakers for almost all of the electrical appliances and circuits in the RV The 120V Main Breaker if so equipped is located in this panel The Load Center is a black plastic panel which is usually attached to a cabinet face 6 1 SECTION 6 ELECTRICAL SYSTEM JAYCO TOWABLE The location can vary by RV model the panel can be mounted down low at floor level or up higher on a cabinet usually in the living area Fig 6 1 amp 6 2 F Converter Reverse Polarity fuses 120V Main Fig 6 1 Load Center Panel Closed Fig 6 2 Load Center Panel Open 120 voLT AC SYSTEM The following electrical components if so equipped will only operate when your RV is connected to shore power 120 to 12 volt
74. Normal and turn the pump ON 16 Run water through all faucets hot amp cold including outside shower until chlorine smell is gone Turn faucets and outside shower off turn pump OFF 17 Then drain the fresh water system again see Draining the Fresh Water System 18 Close bypass valve C open valves A amp B on water heater replace water heater drain plug remove bypass tube at the water filter replace the cartridge water filter If the RV has the Full System Canister water filter remove the canister reinstall the filter and reattach the canister 19 Refill the fresh water tank with fresh water again and when water heater is full of water turn the water heater power ON Lingering Chlorine Taste If a chlorine taste lingers in the water flush the water system with a solution consisting of one quart vinegar to five gallons of clean water Re flush as necessary This vinegar solution may damage the water heater or the water filter so both must be bypassed again before performing this operation Follow the steps outlined in Draining the Fresh Water System with one exception do not drain the water heater Make sure the inlet valves A amp B are closed so no water will enter the water heater Bypass valve C should be open Do not remove the water heater drain plug Remove the cartridge water filter if equipped and replace it with the clear tube supplied For the Full System Canister water filter Remove the canister t
75. OFF Electric amp LP GAS switches Valves A amp B on water heater should be closed valve C should be open Refer to Fig 8 8 2 Level the RV and drain the fresh water system see Draining the Fresh Water System 3 Close the low point drain valves and the fresh water tank drain valve 4 Bypass the cartridge water filter if equipped Use the clear plastic tube supplied with RV to bypass the water filter Full System Canister waiter filter Remove the canister take the filter out of the canister then reattach the empty canister 5 Prepare a chlorine solution using 1 4 cup of household bleach sodium hypochlorite solution to one gallon 3 785 liters of water in a container Prepare one gallon of solution for every 15 gallons of tank capacity This will result in a residual chlorine concentration of 50 ppm in the water system If a 100 ppm concentration is required as discussed step 12 use cup of household bleach with one gallon of water to prepare the chlorine solution One gallon of the solution should be used for each 15 gallons of tank capacity Fresh water tank sizes vary by RV model please contact your dealer or Jayco Customer Service for your specific tank size 6 Gravity Fill Insert one end of a hose into the Gravity Fill inlet insert the other end into a container holding the chlorine solution Do not use your non toxic drinking water hose Pour the chlorine solution into the Gravity Fill
76. PING STORAGE CHECKLISTS RV START UP The following checklist will help ensure a trouble free camping season Q Inspect and work all interior and exterior latches and locks lube if necessary Make sure the batteries are fully charged and installed correctly Inspect the power cord and carefully clean the contacts if necessary Plug in the power cord to an appropriate power source Turn on the interior lights and check outlets for polarity If needed replace any blown fuses Check the circuit breakers and test the GFCI Inspect and test all safety detectors If needed replace any drained or discharged batteries If you have a defective or damaged safety detector replace it immediately Inspect and turn on the propane system If you have any questions contact your dealer or a qualified propane service representative for assistance If the propane system is functioning properly test the pilot lights on range refrigerator furnace and water heater if so equipped Inspect the leveling jacks if so equipped for operation If needed perform maintenance as specified by the leveling jack manufacturer Test all exterior and interior lights Replace any bulbs if they are burnt out Inspect the tires for wear cracks and inflation pressure Wash the exterior of the RV Do a sealant inspection and repair as necessary De winterize and sanitize the fresh water system Connect your tow vehicle to the RV and
77. able to always have four to six inches 10 15 cm of water in the toilet bowl To prevent help toilet blockage always use RV grade single ply toilet paper Do not flush paper towels diapers sanitary napkins or other foreign objects down the RV toilet Sewage black tank preparation AN WARNING It is important to add enough water to prevent solid waste buildup Follow the directions listed below and in the manufacturer s operator manual 1 Release one to two quarts 1 or 2 liters of water into the toilet bowl 2 Follow the directions on your toilet chemical bottle customer supplied by placing the recommended quantity of holding tank chemical into the toilet bowl 3 Flush the toilet and allow at least two gallons 8 liters of water to flow into the holding tank Waste grey holding tank preparation No special preparation is required however placing a small quantity of chemicals into this tank such as baking soda or an approved RV chemical will reduce odors from food particles in the system Cleaning amp Maintenance The toilet should be cleaned regularly for maximum sanitation and operational efficiency Do not use chlorine undiluted or caustic chemicals such as laundry bleach or drain opening types in the toilet system These products damage the seals in toilets and dump valves 8 21 SECTION 8 PLUMBING SYSTEMS JAYCO TOWABLE This Page Is Intentionally Blank 8 22 JAYCO TOWABLE SECTION 9
78. aceplate The Monitor Panel operates on 12 volt DC power supplied by either the converter or auxiliary battery No power is drawn from the battery unless a switch is pushed or turned ON Fuses for the Monitor Panel are located in the load center Refer to the manufacturer s operators manual for further information 8 1 SECTION 8 PLUMBING SYSTEMS JAYCO TOWABLE Tact Switches Fig 8 1 Monitor Panel Fig 8 2 Monitor Panel Monitor panel appearance may vary Operation Press only tact switch at a time As you push either the FRESH BLACK GREY1 or GREY2 switch one or more LED lights will illuminate from left to right indicating the content level for that tank When pushing the BATT switch the LED lights illuminate from left lowest to right highest to indicate the estimated auxiliary battery condition When the RV is using shore power all 4 LEDs will light If disconnected from shore power 3 LEDs will light to indicate a full charge The 4 LED may blink The LEDs corresponding to the letters C G F L on the panel indicate the following C Charge at 12 7 volts G Good at 12 1 volts F Fair at 11 6 volts L Low at 6 0 volts Water pump switch if so equipped This lighted red switch is located on the Monitor Panel the Utility Center or both depending on your RV model When the water pump switch is ON the water pump runs until 45 lbs of pressure has been achieve
79. after dumping the grey and black water holding tanks always add the proper amount of deodorant to the black water tank to prevent malodors and help break down holding tank contents unless winterizing Follow the deodorant bottle or package instructions Driving to a disposal site will normally loosen any accumulated waste debris or solids from the sides of the holding tanks A WARNING Do not add automotive antifreeze or caustic chemicals such as laundry detergents into the holding tanks Although these products may have a deodorizing effect they may damage the plastic and rubber parts of the plumbing system or the components Drain pipes With P Trap If So Equipped The drain pipes may be equipped with a P trap installed to help prevent odors from escaping into the RV During travel water from the P traps may spill and permit odors into the RV By adding water and using a RV approved deodorizing agent you will dissolve the contents faster and will keep the drain lines and tanks clean and free flowing These chemicals are available at an RV supply store or your dealer Drain pipes With Dry Sealing Valve If So Equipped Your RV may be equipped with a dry sealing valve that prevents the escape of odors from your waste system and eliminates the need for P traps Should the RV drain piping system become clogged and a mechanical cleanout tool is used to open the drain pipe it is important that the dry valve be removed before
80. airs and or part replacement CARE AND MAINTENANCE It is the owner s responsibility to perform proper care and maintenance of the RV and to assure correct load distribution and proper semi permanent site location set up For details regarding this please see your Jayco owner s manual and other component part manufacturers These outline various care and maintenance that is required to maintain your RV and for proper set up Please review all manuals supplied with your RV and contact your selling dealership or supplier of the component part if you have questions Note Failure to maintain or set up the RV as noted in those manuals voids this limited warranty and any damage to the RV as a result of your failure to properly set up the RV or perform such care is not covered by this limited warranty THIS WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS AND YOU MAY ALSO HAVE OTHER RIGHTS THAT VARY FROM STATE TO STATE JAYCO INC 903 S Main Street P O Box 460 Middlebury IN 46540 Telephone 574 825 5861 or 800 283 8267 JFB JFD 444 SECTION 1 WARRANTY amp SERVICE JAYCO TOWABLE NoTICE To JAYCO DEALERS Pages 8 11 of this Owner s Manual contains the warranty that applies to this RV However if the Jayco dealer decides to use this RV for rental purposes then the warranty contained in pages 8 11 will not apply to this RV The rental warranty located on pages 13 16 applies in that situation If on the other hand the Jayco dea
81. ake out the filter then reattach the empty canister 8 15 SECTION 8 PLUMBING SYSTEMS JAYCO TOWABLE After draining the system 1 2 10 11 8 16 Water heater power should still be OFF Electric amp LP Gas switches Water heater valves A amp B should still be closed valve C open Pour the vinegar solution into the fresh water tank Gravity Fill Pour the vinegar solution into the Gravity Fill Utility Center w o Valves Pour the vinegar solution into the Gravity Fill Utility Center w Valves Attach a hose to the City Water Fill inlet do not use your non toxic drinking water hose then place the other end of the hose in a container holding the vinegar solution Set the water valves to the Country Fill position Fig 8 12 and turn the water pump Vinegar solution will be drawn into the fresh water tank After the vinegar solution is pumped into the fresh water tank turn the pump OFF Remove the hose amp container from the Fill inlet Fill the fresh water tank Gravity Fill Must be filled from an external container Pour fresh water into the inlet Utility Center w o Valves Must be filled from an external container Pour fresh water into the Gravity Fill inlet Utility Center w Valves If filling from a pressurized source set the water valves to the City Fill Tank position pump is not used Attach the hose from the pressurized water source to the City Water Fill inlet and turn on the water at the source U
82. aler either the reasonable costs of repair or the reasonable costs of replacement of the defect Jayco s option in accordance with the terms conditions and limitations of this limited warranty Jayco s obligation to reimburse Dealer for the reasonable costs of repair or replacement of defective materials or workmanship is the sole obligation of Jayco under this limited warranty Jayco reserves the right to use new or remanufactured parts of similar quality to complete any work and to make parts and design changes from time to time without notice to anyone Jayco reserves the right to make changes in the design or material or its products without incurring any obligation to incorporate such changes any product previously manufactured Jayco makes no warranty as to the future performance of this RV and this limited warranty is not intended to extend to the future performance of this RV or any of its materials components or parts In addition the Dealers obligation to notify Jayco of a claimed defect does not modify any obligation placed on the Dealer to contact Jayco directly when attempting to pursue remedies under state or federal law LIMITATIONS EXCLUSIONS AND DISCLAIMER OF IMPLIED WARRANTIES ANY IMPLIED WARRANTY THAT IS FOUND TO ARISE BY WAY OF STATE OR FEDERAL LAW INCLUDING ANY IMPLIED WARRANTY OF MERCHANTABILITY OR ANY IMPLIED WARRANTY OF FITNESS IS LIMITED IN DURATION TO THE DURATION OF THIS LIMITED WARRANTY AND IS LIMITE
83. alers are required to recheck and adjust pressure before retail delivery Continued periodic checks of the propane system at 5 000 miles of travel or at least once a year by a qualified propane service representative as part of your normal maintenance is recommended Hand tighten the LP gas system valves only do not use a wrench or pliers as over tightening may damage the valve seals and cause them to leak PROPANE LEAK TEST Leaks may be found easily with a soapy water solution Do not use a solution containing ammonia or chlorine when locating leaks These products are corrosive to copper gas lines and brass fittings which could result in deterioration of the copper and brass components Apply the soapy solution to the outside of the gas piping fittings If a leak is present the soapy solution will bubble at the leak point If a leak is indicated shut off the propane system valve s and contact an independent Jayco dealer or qualified propane service representative immediately AN DANGER Never use an open flame to test for a propane leak Do not check for leaks using products that contain ammonia or chlorine these products can cause cracks to form on the metal tubing and brass fittings 7 1 SECTION 7 FUEL SYSTEM JAYCO TOWABLE PROPANE SAFETY PROCEDURE Propane is a colorless and odorless gas that in the liquefied state resembles water An odorant mercaptan that is described by many people as having
84. anode rod or any other component such as an add on electric heating element with an accessory part that is not authorized by the water heater manufacturer Such items are not approved to be installed and could create an unsafe condition and will void all warranties Anode rod protection The tank in the water heater is protected by a magnesium or aluminum anode to prolong the life of the tank by absorbing the corrosive action of hot water Under normal use the anode rod will deteriorate and because of this the water heater manufacturer recommends the anode rod be replaced yearly Water with high levels of iron and or sulfate will increase the rate of deterioration therefore more frequent replacements may be required If an anode rod is mostly eaten away replace it with a new one The water heater manufacturer recommends replacement of the anode rod when consumption or weight loss is greater than 75 percent Refer to Fig 8 9 0 Fig 8 9 Anode rod replacement chart 7 100 Operating the water heater without the proper anode rod protection will decrease tank life and will void the tank manufacturer s warranty on the tank To extend the anode life drain the water from the water heater tank whenever the RV is not being used Avoid any extended time of non use with water in the tank To prevent a water leak when replacing the anode rod a pipe thread sealant approved for potable water such as T
85. arance 194 6 6 JAYCO TOWABLE SECTION 6 ELECTRICALSYSTEM 50 AMP SYSTEM A WARNING Make very certain the external power source 50 amp systems only you connect the power cord to is a 50 amp NEMA 14 50 RV receptacle and not 240 volt AC Your RV may be equipped with a 50 amp 120 volt 60hz AC electrical system The entire system is designed to operate on 2 legs of 120 volt power at a maximum current flow of 50 amperes per leg Exposure to voltages higher or lower than a nominal 120 volts will damage or shorten the service life of the electrical system and appliances The 50 amp 120 volt 60hz AC electrical system can be powered by the 120 volt 60hz utilities found in RV campgrounds or by 120 volt 60hz generator power 50 AMP POWER CORD The power cord is also commonly referred to as the shore power cord This power cord is designed to ground the RV electrical system through the external power source receptacle It is also designed to carry the voltage and current output from campground power receptacles Occasionally the electrical service provided by a campground may experience low or high voltage i e surges or spikes Any prolonged exposure will shorten the life of the electrical system and appliances Consult your dealer for recommendations on power surge protection WARNING Plugging the shoreline power cord into an incorrectly wired power source could damage the RV electrical system and result i
86. assifications identify the kinds of fires or burning materials they are designed to fight Class Solid materials such as wood paper cloth rubber and some plastics Class Liquids such as grease cooking oils gasoline kerosene or other flammable liquids Class Electrical such as electrical wires or other live electrical equipment A dry chemical fire extinguisher has been installed in your RV It is suitable for extinguishing small fires of the Class B or C type only We suggest you become thoroughly familiar with the operating instructions displayed on the side of the fire extinguisher NOTE For information on how to use your fire extinguisher refer to the fire extinguisher user s manual provided in your Warranty Packet Inspection and Maintenance Read and follow all instructions on the label and owner s manual provided by the fire extinguisher manufacturer AN WARNING Do not check the pressure test or practice using the fire extinguisher by squeezing the trigger even briefly The fire extinguisher is not rechargeable or refillable Once used it will gradually lose pressure and will not be fully charged for use in an emergency DANGER Do not turn the electrical power back on or plug in any appliances after the use of a fire extinguisher Please refer to the fire extinguishers user manual for further instructions on maintenance and clean up 2 1 SECTION 2 OCCUPANT SAFETY JAYCO TOWABLE
87. ature before bathing 4 conserve water while showering wet down and turn the water OFF while you use soap then rinse 5 When you are finished shut the water faucets OFF If dry camping turn the water pump OFF Unlike your home the RV does not contain a water pressure balance valve If someone is using the shower it is recommended that the fresh water system NOT BE USED until they are finished Maintenance Read the manufacturers operator manual The tub and shower walls if applicable in your RV are made of ABS plastic material Use a mild detergent soap and warm water to clean these cleaning instructions are similar to those recommended for fiberglass tubs and shower walls Contact your RV dealer for repair or replacement DO NOT use gritty or abrasive particle soaps or scouring compound to clean ABS plastic Avoid using Citrus or biodegradable cleaners which contain D Limonene They will damage plastic materials HARDWARE amp SINK OR SHOWER FIXTURES Use mild dish soap and water to clean these fixtures Do not use harsh chemicals or sprays A mild solution of vinegar and water works well to remove hard water spots and stains from the sink or shower fixtures 8 11 SECTION 8 PLUMBING SYSTEMS JAYCO TOWABLE WATER PURIFICATION SYSTEM IF SO EQUIPPED Depending on the RV model there may be a cartridge type water filter located under the kitchen sink or if the unit has an outside Utility Center
88. authorized dealer of Jayco normal wear tear or usage such as tears punctures soiling mildew fading or discoloration of exterior plastic or fiberglass or soft goods such as upholstery drapes carpet vinyl screens cushions mattresses and fabrics the effects of condensation or moisture from condensation inside the RV and failure to provide adequate ventilation mold or any damage caused by mold to the inside or outside of the RV imperfections that do not affect the suitability of the RV for its intended purpose of recreational use or items that are working as designed but that you are unhappy with problems including water leaks related to misuse mishandling neglect or abuse including failure to maintain the RV in accordance with the owners manual or other routine maintenance such as inspections lubricating adjustments tightening of screws and fittings tightening of lug nuts sealing rotating tires damage due to accident whether or not foreseeable including any acts of weather or damage or corrosion due to the environment theft vandalism fire or other intervening acts not attributable to Jayco service items such as windshield wiper blades lubricants fluids filters etc damage resulting from tire wear or tire failure defacing scratches dents chips on any surface or fabric of the RV damage caused by off road use overloading the RV or alteration of the RV or any of its components or parts damage caused by improper
89. bed in the following sections For detailed instructions please refer to the manufacturers operators manual included in your warranty packet 4 9 SECTION 4 TOWING amp SET UP JAYCO TOWABLE Battery powered keyless entry system The battery powered entry system is a 4 button touch pad programmable deadbolt lock The 4 buttons are labeled 1 2 3 4 5 6 7 8 The button labeled 1 2 is the same button whether the number 1 or 2 is desired Please note this handle uses touch technology The buttons are activated by touch and do not require pressing the buttons Touch the button and lift finger from button for proper code entry Operation The entry system incorporates proximity sensing to determine when you want to activate the lock To operate the lock you first must wake up the lock by touching the wake up area to the right of the buttons The buttons will illuminate once the Touch Pad is wakened This indicates that the touch pad is ready for the code to be entered Refer to the diagram on next page Preset Factory Code The entry system has a factory set code of 3 7 1 5 followed by the Enter button The Enter button is the bottom button with the picture of the key The Enter button is required to be touched after the code is entered The factory code resets every time the batteries are removed for at least 10 seconds Programming New Code To set a new code wake up the lock by touching the
90. ble for sleeping and walking The refrigerator is designed to operate when level for best performance due to the absorption system The water drainage systems are designed with proper slope and must be level for proper operation The appliances perform best when level STABILIZER JACKS 1 Each stabilizer jack can be individually adjusted to stabilize the trailer for use 2 When setting your RV up on soft ground you may wish to place a wood pad or the equivalent under each stabilizer jack foot This will help keep the stabilizer jack from sinking into the ground Manual stabilizer jacks if so equipped To lower each jack insert the jack crank onto the applicable stabilizer jack shaft 1 To lower each jack insert the jack crank onto the applicable stabilizer jack shaft 2 Turn the crank clockwise to lower each leg until it contacts the ground and stabilizes the trailer To raise each jack insert the jack crank onto the applicable stabilizer jack shaft and turn the crank counter clockwise 4 8 JAYCO TOWABLE SECTION 4 TOWING amp SET UP Electric stabilizer jacks if so equipped Control switches for the stabilizer jacks are located on the door side of the unit above the stabilizer jack s To lower each jack press the control switch until each leg contacts the ground and stabilizes the unit To raise the jack press the control switch until the jack is returned to the retracted position NOTE The stabilizer
91. brass com 800 447 9513 Range Atwood www atwoodmobile com 815 877 5700 RANGEHOOD VENTLINE INC www ventline co 574 848 4491 REFRIGERATOR NORCOLD NORCOLD www norcold com 800 543 1219 SMOKE ALARM CONTACT YOUR DEALER TANK SPRAYER BLK amp MOLDERS www bandbmolders com 574 259 7838 THERMOSTAT RV PRODUCTS www rvcomfort com rvp 316 832 4357 TOILET THETFORD CORP www thetford com 800 521 3032 TV CONTACT YOUR DEALER TV ANTENNA WINEGARD COMPANY www winegard com 800 788 4417 WATER HEATER TANK DSI ATWOOD GREENBRIER OPERATIONS www atwoodmobile com 800 546 8759 WATER HEATER TANKLESS GIRARD SYSTEMS www girardsystems com 800 382 8442 WATER 12V SHURFLO EAST www shurflo com 800 854 3218 15 1 SECTION 15 ADDITIONAL INFORMATION JAYCO TOWABLE Jayco Ownership Notification Fax Form To 800 825 7876 ATTENTION Federal record keeping laws require that we maintain a file of owners of our product Your cooperation in filling out this from will be appreciated O Change of Owner L Transfer of Limited Warranty see limited warranty for details Model Information Serial Chassis Odometer Reading Motorized only New Owner Information Purchased Date Name Address City State Province _ 21 Code Phone E Mail Address Previous Owner Information Purchased Date
92. cause personal injury or death Connecting the power cord Always test the external power source i e the campsite power receptacle or electrical box with a ground monitor before connecting your power cord to it If the ground monitor indicates reverse polarity an open ground DO NOT connect the power cord 1 Turn off the load center main 120 volt circuit breaker 2 Carefully extend the entire length of the power cord approximately 25 35 from the electric cable hatch to the external power source 3 Plug the power cord into the receptacle Be sure all the power cord prongs are properly plugged into the receptacle 4 Return to your RV and turn the load center main circuit breaker 5 To help prevent power surges from damaging the connected loads please follow these instructions when hooking up to the external power source The shore line power cord should be unplugged when the RV is left unattended If something would happen to the electrical system this may help limit potential damage When you are ready to leave reverse the power cord connection process Use care to prevent damaging the power cord electrical connection pins when connecting or disconnecting the shore line power cord Grasp the plug to remove the power cord from the outlet do not unplug it by pulling on the cord Maintenance Inspect the power cord for cuts cracks and worn insulation Have the power cord replaced immedia
93. ched nicked or cracked have your dealer inspect the RV Your RV is exposed to many environmental conditions that have an adverse affect on the paint finish Road Salt and Sodium Chloride Road Tar Bugs Bird Droppings Tree Sap Industrial Fallout Acid Rain Pollution UV Exposure and Moisture The most common problems resulting from these conditions are corrosion staining and chemical spotting Generally the longer the foreign material remains in contact with the exterior finish the more extensive the damage These problems can be minimized by regularly scheduled washing and polishing Wash your RV as soon as possible if it becomes contaminated with foreign material Avoid parking under trees or near ocean sea salt Ice or snow should not be scraped from the painted surface Brush off Anti freeze gasoline or washer solvents if spilled on the painted surface should be rinsed off with water immediately Bugs and bird droppings should be rinsed off daily We recommend that you do not take your RV through automatic car washes Extreme caution should be used if utilizing any type of pressure sprayer around all attachments doors windows appliance vents etc Avoid forcing water inside the RV which could possibly damage component parts Some types of hot water washing equipment apply high pressure and heat to the RV They may cause heat distortion and damage to the resin parts and may flood the RV s interior Therefore be sure to
94. control purposes See Wheel Lug Nut Torque Chart and Wheel Lug Nut Diagram Stage 3 Torque Use calibrated torque wrench to torque each lug nut in a star pattern to the values indicated Wheels must remain stationary during torquing process for control purposes See Wheel Lug Nut Torque Chart and Wheel Lug Nut Diagram WHEEL LUG NUT TORQUE CHART Stage 2 Stage 3 Stage 1 Clicker Setting Clicker Setting Acceptable Lug Nut ji Impact 3ft lbs 3ft lbs Torque Range 4 Lug Nuts 40 50 ft lbs 60 ft lbs 70 ft lbs 50 75 ft lbs 5 Lug Nuts Chrm Steel 40 50 ft lbs 60 ft lbs 70 ft lbs 50 75 ft lbs 5 Lug Nuts Chrm Steel Alum_ 40 50 ft lbs 95 fi lbs 115 ftlbs 90 120 fi lbs 5 Lug Nuts Chrm Steel Alum_ 40 50 ft lbs 95 115 ft lbs 90 120 ft lbs 6 Lug Nuts Chrm Steel Alum_ 40 50 ft lbs 95 ft lbs 115 ft lbs 90 120 ft lbs 6 Lug Nuts Chrm Steel 40 50 ft lbs 95 ft lbs 115 ft lbs 90 120 ft lbs 8 Lug Nuts Steel Aluminum_ 40 50 ft lbs 95 ft lbs 115 ft lbs 90 120 ft lbs TRANSPORTATION INSTRUCTIONS 1 Prior to travel and after excessive braking all wheel lug nuts must be checked for torque This also applies to any service involving wheel or lug removal during the life of the recreational vehicle 2 Torque readings must fall within the Acceptable Torque Range See Wheel Lug Nut Torque Chart 3 Torque specifications must be checked by using a torque wrench Digital or Dial Torque Wrenches
95. d It will recycle when pressure drops The switch will light up when turned ON Turn the water pump switch OFF when it is not in use Waiter heater switches if so equipped These lighted red switches are located on the Monitor Panel The LP GAS water heater switch 12V enables propane operation of the water heater The ELECTRIC water heater switch 120V enables electric operation of the water heater Normally both switches should be turned on which will provide the fastest hot water recovery time The water heater can be operated in Electric only or Gas only modes by pressing each switch independently Switches light up when turned ON DSI FLT Direct Spark Ignition Fault This light located between the water heater switches will indicate a problem with the LP portion of the water heater When the LP GAS switch is turned on the light will blink quickly 3 times and the water heater should fire The light should then remain off If the light comes on and stays lit it indicates the Gas side of the water heater has not fired and there is a problem with the igniter 8 2 JAYCO TOWABLE SECTION 8 PLUMBING SYSTEMS FRESH WATER HOLDING TANK The fresh water tank can be filled from a water container using the Gravity Fill or from an external pressurized source using the City Water Fill Plastic overflow tubes are plumbed into the fresh water holding tank to allow water to flow out of the water tank Occasionally you may see water com
96. d the warranty coverage period or this limitation period In addition this warranty is not intended to extend to future performance and nothing in this warranty or any action of Jayco or any agent of Jayco shall be interpreted as an extension of the warranty or this limitation period Some states do not allow a reduction in the statute of limitations so this reduction may not apply to you WARRANTY REGISTRATIONS Your warranty registration records should be completed and delivered to the manufacturers of component parts The Jayco product warranty registration form must be returned to Jayco within ten 10 days of your taking delivery of the RV Your Jayco warranty will not be registered unless this warranty registration is completed and received by Jayco Failure to file this warranty registration with Jayco will not affect your rights under this limited warranty as long as you can present proof of purchase but it can cause delays in obtaining the benefits of this limited warranty and it may inhibit any servicing facilities ability to provide proper repairs and or part replacement JFB JFD 1 15 SECTION 1 WARRANTY amp SERVICE JAYCO TOWABLE CARE AND MAINTENANCE It is your responsibility to perform proper care and maintenance of the RV and to assure correct load distribution For details regarding this please see your Jayco owner s manual and other component part manufacturers These outline various care and maintenance that
97. does not replace modify or apply to the warranties provided by the manufacturers that supply the products used by Jayco to assemble the RV like the frame You may contact an independent authorized dealer for details Jayco s obligation to repair or replace defective materials or workmanship is the sole obligation of Jayco under this limited warranty Jayco reserves the right to use new or remanufactured parts of similar quality to complete any work and to make parts and design changes from time to time without notice to anyone Jayco reserves the right to make changes in the design or material of its products without incurring any obligation to incorporate such changes in any product previously manufactured Jayco makes no warranty as to the future performance of this RV and this limited warranty is not intended to extend to the future performance of this RV or any of its materials components or parts In addition the RV owner s obligation to notify Jayco or one of its independent authorized dealers of a claimed defect does not modify any obligation placed on the RV owner to contact Jayco directly when attempting to pursue remedies under state or federal law LIMITATIONS EXCLUSIONS AND DISCLAIMER OF IMPLIED WARRANTIES ANY IMPLIED WARRANTY THAT IS FOUND TO ARISE BY WAY OF STATE OR FEDERAL LAW INCLUDING ANY IMPLIED WARRANTY OF MERCHANTABILITY OR ANY IMPLIED WARRANTY OF FITNESS IS LIMITED IN DURATION TO THE DURATION SET FORTH IN THIS
98. e manufacturer s instructions convert the hide a bed back into the upright sofa position reverse the process J STEEL SOFA IF SO EQUIPPED The J steel sofa functions much the same as a residential futon To make the J steel sofa in to a bed lift up on the bottom seat cushion and pull it towards you The sofa back will drop down to provide a sleeping surface For additional comfort and to reduce fabric damage you may want to place a cover or air mattress customer supplied over the J steel sofa when it is in the sleeping position 12 3 SECTION 12 INTERIOR JAYCO TOWABLE RECLINER CHAIR IF SO EQUIPPED Like a residential recliner the recliner has side controls allowing you to recline the chair To reverse the recliner chair back to the upright position depress the side control and gently apply pressure to the recliner leg rest Refer to the furniture manufacturer s care instructions for this product FREE STANDING TABLE amp CHAIRS IF SO EQUIPPED The free standing dinette table can be positioned to seat up to four people To prevent damage the standard free standing dinette chairs should be fastened securely at the dinette table when you are traveling BOOTH DINETTE IF SO EQUIPPED The dinette is designed to seat up to four adults You can access the dinette bench storage by removing all the cushions and lifting the bottom seat supports If the dinette bottom seat support is screwed shut it is to protect
99. e not feeling well they become so disoriented they are unable to save themselves by either exiting the vehicle or calling for assistance Young children and household pets may be the first affected AN WARNING The following symptoms are related to carbon monoxide poisoning and should be discussed with all members of the household Mild exposure Slight headache nausea vomiting fatigue often described as flu like symptoms Medium exposure Severe throbbing headaches drowsiness confusion fast heart rate Extreme exposure Unconsciousness convulsions cardio respiratory failure death Your combination carbon monoxide propane alarm is designed to detect the toxic carbon monoxide fumes that result from incomplete combustion such as those emitted from appliances furnaces fireplaces and auto exhaust A carbon monoxide propane alarm is NOT A SUBSTITUTE for other combustible gas fire or smoke alarms This carbon monoxide alarm is designed to detect carbon monoxide gas from ANY source of combustion It is not designed to detect smoke fire or any other gas Please note that there are hazards against which carbon monoxide detection may not be effective such as natural gas leaks or explosions This alarm is designed to sense the presence of carbon monoxide propane gas however there are other combustible fumes or vapors that may be detected by the sensor including but not limited to acetone alcohol butane and gasoline
100. e the correct star pattern sequence to attach the RV wheels see Wheel Lug Torque Chart 1 Start all nuts by hand to prevent cross threading 2 Tighten the nuts in the sequence shown 3 Tighten the lug nuts equally in stages as indicated for your trailer s wheels see Wheel Lug Torque Chart Check and re torque after the first 10 25 and 50 miles 16 40 and 80 kilometers Thereafter check and maintain the torque according to the listed torque values see Wheel Lug Torque Chart NOTE The proper method of tightening wheel lug nuts is with a properly calibrated torque wrench and socket not with an impact wrench or by hand Do not use a 4 way lug wrench or any other type of wrench that does not measure the actual pressure applied to the lug nut Because of the importance of having proper torque on the wheel lug nuts you should always have the wheels mounted and properly torqued by a qualified technician using the proper tools 4 6 JAYCO TOWABLE SECTION 4 TOWING amp SET UP WHEEL LUG NUT DIAGRAMS 4 Lug Nuts 5 Lug Nuts 6 Lug Nuts 8 Lug Nuts WHEEL TORQUE INSTRUCTIONS Start lug nuts with fingers on studs to avoid cross threading Stage 1 Torque Impact lug nuts a star pattern until snug to See Wheel Lug Nut Diagram Stage 2 Torque Use calibrated torque wrench to torque each lug nut in a star pattern to the values indicated Wheels must remain stationary during torquing process for
101. e top of your RV to prevent damage to the unit s structure 14 3 SECTION 14 TRAVEL CAMPING STORAGE CHECKLISTS JAYCO TOWABLE A CAUTION Excessive snow 8 or more or ice 2 or more places excessive weight on the RV roof Remove excessive snow or ice as needed Care MUST be exercised to not damage the roof material when removing snow amp ice Excessive weight can damage the roof seals etc Water leaks and poor fit or operation are the results of this damage MAINTENANCE CHECKLIST This list is a quick reference sheet for suggested areas of regular maintenance Review all manufacturer s operators manuals supplied with your RV to perform these listed maintenance items Prior to First Trip Inspect and reseal as needed Have the propane system checked for leaks by your dealer Check wheel lug nuts at specified intervals to listed torque specifications re torque as needed Sanitize the fresh water system Test the safety alarms First Two Hundred Miles Check wheel nuts at specified intervals to listed torque values Re torque as needed Have brakes adjusted by a qualified service technician Each Trip Q Inspect and reseal as needed Q Check the auxiliary battery If so equipped Have the propane system checked for leaks by your dealer Check running lights Q Check tire pressure and wear including spare if so equipped Make sure the tires are cold when checking the
102. e you have vacuumed Never use water cleaners or solvents to clean the smoke alarm as they may damage the smoke alarm Do not paint the smoke detector For information on how to maintain your smoke detector refer to the smoke detector user s manual provided in the Warranty Packet Battery The smoke alarm will not function if the battery is missing disconnected dead the wrong type of battery is used or the battery is not installed correctly The smoke detector requires one standard 9V battery When the battery becomes weak the smoke alarm will beep about once a minute the low battery warning The low battery warning should last for 30 days but you should replace the battery immediately to continue your protection When the battery is removed from the alarm the battery flag in the compartment will pop up therefore the alarm cannot be installed to the mounting bracket without a battery WARNING Only use the replacement battery recommended by the smoke detector manufacturer The smoke detector alarm may not operate properly with other batteries Never use a rechargeable battery as it may not provide a constant charge Never disconnect the battery to silence the alarm Regardless of the manufacturer s suggested battery life you MUST replace the battery once the smoke alarm starts beeping the low battery warning For information on the correct battery and battery installation for your smoke detector refer
103. ed in your warranty packet THERMOSTAT There are may be up to two 12 volt DC thermostats in your RV Use the controls to set the temperature to your comfort setting FURNACE AN WARNING The furnace should be inspected periodically monthly during the heating season for presence of soot on the vent Soot is formed whenever combustion is incomplete This is a visual warning that the furnace is operating in an unsafe manner If soot is observed on the vent immediately shut the furnace OFF and contact a qualified service agency Operating the furnace under this condition could lead to serious property damage personal injury or loss of life 9 1 SECTION 9 HEATING amp COOLING JAYCO TOWABLE AN WARNING To ensure your personal safety do not obstruct or alter the furnace in any manner Do not install screens over the vent for any reason Screens will become restricted and cause unsafe furnace operation For your safety only the manufacturer s factory authorized parts are to be used on your furnace The furnace installed in your RV is controlled a thermostat The furnace requires both 12 volt power and propane gas for full operation Make sure you have sufficient power available before operating your furnace If you have any questions contact your dealer or our customer service department A qualified RV technician should perform all furnace maintenance at least once a year more often depending on furnace
104. ed to your dealer or Jayco 4 4 JAYCO TOWABLE SECTION 4 TOWING amp SET UP WARNING When replacing a tire make sure to replace it with a tire of the same size and specifications refer to the Federal Certification label If you have questions regarding your tires contact the tire manufacturer or Jayco Customer Service SPARE TIRE CARRIER IF SO EQUIPPED If your RV is equipped with a spare tire it will either be mounted under the unit hoist or on the rear bumper Under the unit hoist mounted WARNING DO NOT exceed the maximum load capacities of 100 Ibs for the hoist DO NOT use air driven guns or impact wrenches to lift the spare tire to the travel position The following diagram illustrates the travel position of the spare tire the spare tire must contact the brackets as shown s SEES SPARE TIRE Fig 4 2 Hoist mount spare tire position To secure the spare tire in the travel position Fig 4 3 Fig 4 4 1 Put the steel hoist lift support located on the end of the cable through the rim of the tire The hoist lift support clips need to seat inside the center hole of the tire rim The valve stem of the tire MUST be pointed in the up position or toward the bottom of the trailer 2 Insert the crank handle into the hole located in the center of the rear bumper Turn the crank handle to lift the tire to the travel position 3 Two crisp breaks must be heard and
105. eflon Tape must be applied to the threads of the anode rod Proper application of a thread sealant will not interfere with the anode s installation or operation 8 7 SECTION 8 PLUMBING SYSTEMS JAYCO TOWABLE High altitude deration Operation of the water heater at high altitudes may require derating If the water heater is not properly derated lack of sufficient oxygen for combustion may produce improper burner operation Pilot outage caused by burner lift off or sooting from a yellow burner may occur indicating the possibility of carbon monoxide You may also notice a lack of efficiency in heating the water because of incomplete combustion of the burner at these higher altitudes Consult with the local propane company your dealer or the water heater manufacturer for proper derating of the water heater Change out of the orifice derating should be done by the dealer or a qualified service agency It is important that once the RV has returned to lower elevation below 4500 feet any high altitude deration or other adjustments be reversed for proper operation of the water heater Pressure amp temperature P amp T relief valve When cold water is heated in the water heater tank the water pressure will rise For this reason a Pressure and Temperature P amp T relief valve is required for safety in all water heaters It is normal for the P amp T relief valve to release a small quantity of water during the heating cyc
106. emoving 3 8 screws could be 3 or more 4 16 JFB JFD JAYCO TOWABLE SECTION 4 TOWING amp SET UP Electrical break a way switch 4 5 6 8 9 Fig 4 8 Detachable Hitch Coil wires up and place behind front crossmember Raise tongue up with tongue jack Place two jack stands 3 ton minimum rating each one on each side of the trailer approximately 4 behind the front crossmemeber under the main beam Fig 4 9 Jack stands Lower frame down onto jack stands Place another 2 jack stands 3 ton minimum rating each one each side of tongue under tongue between 2 tongue connection plates Remove tongue from trailer by removing 3 bolts and nuts 4 per connection plate 16 total To reinstall the hitch reverse these steps tighten the bolts to 60 70 ft lbs torque It is your responsibility to take your travel trailer to the dealer for warranty or service repair please refer to the Limited Warranty in Section 1 JFB JFD 4 17 SECTION 4 TOWING amp SET UP JAYCO TOWABLE THIS PAGE 15 INTENTIONALLY BLANK 4 18 JFB JFD JAYCO TOWABLE SECTION 5 SLIDEOUT SYSTEM AN WARNING Ensure that the trailer is level before operating the slideout room Water leaks and other problems could result if the slideout is operated without leveling the trailer Ensure there are no people or obstructions blocking the path of the room when it is moving Keep away from the slide rails when the room
107. en store it Setting up the grill bumper mount grill only if so equipped Insert the grill mounting bar into the bracket mounting tube on the rear bumper of the RV Insert the pin through the hole in the bracket and mounting bar The pin must be installed to insure the mounting bar is secure during use Set the BBQ grill on the mounting bar by inserting the 2 pegs on the bar into the grill mounting bracket Make sure the mounting bar and the grill are securely in place before proceeding with the propane connection Attaching the quick coupler connection The quick coupler is directly connected to the RV propane system The quick coupler connection has a positive shut off valve as required by code and standards 1 Place the quick coupler handle in the OFF position and push back the sleeve The valve handle must be OFF to make the connection 2 Insert the plug and release the sleeve 3 Push the plug until the sleeve snaps forward locking the plug into the socket Turn the handle ON to allow propane to flow to the drop in stove 13 1 SECTION 13 EXTERIOR JAYCO TOWABLE Socket lt Plug Sleeve On Fig 13 1 Quick connect coupler CLEANING THE EXTERIOR To protect your RV s exterior finish wash it often and thoroughly Regular cleaning and waxing will help protect the exterior If chalking occurs wash and try to wax a small area to see if the luster returns If the exterior becomes scrat
108. eout still will not operate follow these steps the slideout is extended refer to the following section on overriding the specific slideout system installed on your RV Ifthe slideout is retracted leave it in that position Q Contact your dealer or customer service for repair assistance 5 2 JAYCO TOWABLE SECTION 5 SLIDEOUT SYSTEM V tech slideout override If the RV has an underbelly locate and remove the access panel to access the slideout motor this panel is typically under the RV on the opposite side of the slideout room Use a 3 4 or 5 8 socket size will vary depending on model and ratchet on the hex head located on the end of the drive shaft Turn the drive shaft until the slideout is in the position you desire Contact your RV dealer for service Fig 5 2 V tech slide hex head M Tec slideout override In the event of a power failure or low battery the slide out room may be operated manually with a 5 8 ratchet wrench not supplied The manual crank shaft is located on the motor transmission housing Turn the crank clockwise to move the room counter clockwise to move the room out 5 3 SECTION 5 SLIDEOUT SYSTEM JAYCO TOWABLE THIS PAGE 15 INTENTIONALLY BLANK 5 4 JFTT JFDB JFD JAYCO TOWABLE SECTION 6 ELECTRICAL SYSTEM The RV electrical system is comprised of two independent electrical systems One operates off of 12 volt DC power and
109. es or reflective warning signs to display if necessary Pull off the roadway as far as possible for emergency stopping or tire changing Turn ON your RV hazard warning flashers If traveling at night use three red warning indicators such as flares reflectors or lanterns as follows 1 Place the first warning indictor on the traffic side of the RV directed at the nearest approaching traffic 2 Place the second warning indicator 100 feet behind the RV in the center of the lane and toward approaching traffic 3 Place the third warning indicator 100 feet in front of the RV in the center of the lane and away from the traffic approaching from behind The hazard warning flasher provides additional safety if the RV is stopped on the side of the roadway and presents a possible hazard to other motorists When the flasher is on it serves as a warning to others to approach and overtake your vehicle with caution For personal safety always stand off the road and out of the way of traffic Curves and or hills may affect the safe placement of warning indicators EMERGENCY TOWING A WARNING Never allow anyone to go under the RV while it is being lifted and or being towed If your RV needs to be towed please contact an emergency road service provider or a qualified service facility for assistance LEVELING THE RV Now that you have parked your RV you need to ensure it is level Leveling is very important A level RV is more comforta
110. factory installed equipment do not use that area for storage To convert back to a booth dinette reverse the process The booth dinette can be converted into a bed To convert remove all the cushions from the booth dinette Lift the tabletop remove the detachable table legs and place the tabletop on the ledges provided between the booth dinette benches Lay the seat back cushions against the back of the booth dinette bench Lay the dinette seat bottom cushions in between the seat back cushions The area where the cushions meet should be slightly raised Push the raised cushion ends down gently The cushions are designed to fit snugly Reverse this process when converting back to the booth dinette Extendable dinette if so equipped Your travel trailer may be equipped with side extensions on the dinette benches that can be used only when the slideout is extended 1 Remove the snap strap located at the back of the dinette bench that secures the extensions in the travel position 2 Pull out the dinette bench extension until it hits the factory installed stops 3 Remove the seat seat back cushion and plywood seat extender from the revealed storage compartment put the cushions off to the side Fig 12 1 Extendable 4 Position the plywood seat extender across the dinette dinette bench extension brackets The plywood seat extender MUST be in place to use the extendable dinette 5 Place the seat and seat back cushions on the ex
111. food items should be arranged so air can circulate freely Keep the area at the back of the refrigerator clean and free of debris Check for obstructions in the exterior refrigerator vent area i e spider webs bird nests etc Use a soft cloth to dust off the debris For optimum efficiency and performance it is recommended the refrigerator be checked at least twice a year as part of the routine maintenance For detailed operating and safety information refer to the manufacturer s user guide included in the warranty packet or visit the manufacturer s website Gas electric models AN WARNING If you smell propane gas STOP Follow the directions located in the manufacturer s operators manual and in this manual Residential models Make sure you are connected to a 120 volt power source AN CAUTION The ice maker should be turned off and the ice tray emptied when power to your recreation vehicle has been shut off With no power the ice will melt and water will pool in the refrigerator door When power is restored the vibration will cause this water to run out of the door and on to the vehicle floor MICROWAVE IF SO EQUIPPED Make sure there is sufficient 120 volt power available before operating the microwave Ensure the microwave turntable if so equipped is secured prior to traveling WARNING Never use the microwave cavity for storage The microwave cavity should always be empty whe
112. g with the RV connected the tow vehicle charging system will charge both batteries Replacement and maintenance Some equipment in your RV will draw small amounts of current even when turned OFF To prevent the auxiliary battery from being discharged when your RV is not connected to shore line power disconnect the auxiliary battery negative cable at the battery During storage it is important to check the voltage monthly and recharge the auxiliary battery as needed If you remove the auxiliary battery from your RV store it in a dry cool area per the manufacturer s instructions When it is time to replace the auxiliary battery replace it with a Group 27 deep cycle battery only Contact the battery manufacturer for further information Do not reverse the positive and negative battery cables doing so will blow the reverse polarity fuse s that protect the converter BATTERY ISOLATOR FOR YOUR TOW VEHICLE CUSTOMER SUPPLIED You may want to consider the installation of a battery isolator on your tow vehicle as a convenience feature It receives current from the tow vehicle alternator and controls distribution of energy to both the RV auxiliary battery and the tow vehicle battery It serves as a check valve to prevent energy from being drawn from your tow vehicle chassis battery so you can start your tow vehicle engine Your dealer can assist you with the selection purchase and installation of this aftermarket part
113. gh pressure Water pressure regulators customer supplied are available from your RV dealer to protect the plumbing system against such high pressure AN CAUTION Not using a water pressure regulator when using City Water may cause the o rings to fail To prevent damage to the plumbing system or components when using the City Water connection a water pressure regulator rated for 40 Ibs is recommended 8 4 JAYCO TOWABLE SECTION 8 PLUMBING SYSTEMS 12 VOLT WATER PumP amp SWITCH IF SO EQUIPPED Once activated the water pump also known as the on demand pump will self prime and provide water The water pump has a built in check valve to prevent water from back flowing Read the safety and operating information provided in the manufacturer s literature regarding care and operation of the 12V water pump Periodically check the in line water pump strainer for accumulated debris To clean shut off the water pump unscrew the clear cap remove the re useable metal strainer and clear any debris then reinstall Fig 8 6 Water Pump Switch if so equipped The red water pump switch will be located on the Monitor Panel Fig 8 1 8 2 or the Utility Center Fig 8 10 8 11 or both depending on your RV model When the water pump switch is ON the pump runs until 45 lbs of pressure has been achieved The red light will stay ON Fig 8 6 Water Pump Strainer The water pump automatically recycles when pressure drops
114. hase touch up paint use the closest automotive paint available locally match possible Cleaning plastic parts Use a sponge or chamois to clean plastic parts Use warm water and a soft cloth or chamois to remove any white residue from dark colored plastic surfaces Do not use a scrubbing brush or other hard tools as they may damage the plastic surface Do not use wax containing abrasives that may damage the plastic surface CAUTION Do not allow plastic to come into contact with brake fluid engine oil grease paint thinner or battery acid These will damage plastic Use a soft cloth and a mild deteraent solution to wipe awav anv such contact Chrome parts if so equipped To prevent chrome parts from spotting or corroding wash with water dry thoroughly and apply a non abrasive automotive wax If the chrome is severely damaged or pitted use a commercially available chrome polish product Stone Guard if so equipped Wash the stone guard with mild liquid dishwashing soap or liquid car washing soap and water Do not use powdered detergent powdered soap liquid and spray cleaners or pressure washing Wax frequently to protect the surface and make cleaning easier 13 4 JAYCO TOWABLE SECTION 13 EXTERIOR EXTERIOR ROOF amp SIDEWALL VENTS While you are cleaning the exterior roof also inspect the roof vents including sealants for cracks and keep them clean Inspect the refrigerator and holding tank vents for b
115. he listed ratings 3 Weigh the RV while attached to but excluding the tow vehicle This will result in the actual weight that is exerted on all of the RV tires This weight may be subtracted from the overall RV GVWR to determine the actual tongue weight 4 With the RV still attached to the tow vehicle weigh each wheel position separately to ensure each tire is not overloaded To determine the wheel position weight 5 Pull the RV onto the scale so only one tire is on the scale Record the weight Your RV must remain as level as possible on the scale even though an axle or side is not physically on the scale Obviously to obtain the side to side weights there must be enough space on either side of the scale to accommodate the RV being partially off the scale 6 To calculate the opposite side of the RV wheel position weight subtract the first side s weight from the weight determined in step 3 If there is a difference in the weights on one side of the vehicle as compared to weights on the other side components tires wheels brakes springs etc on the heavier side could be overloaded even though the total axle load is within the GAWR It is important to redistribute the load to avoid component failure improve the handling characteristics of the tow vehicle and not void the Towable Limited Warranty With these actual weights it is now possible to compare them against the Trailer Weight Information label weight rati
116. his limited warranty and to have work performed on the items at no cost to you as provided by this limited warranty EVENTS DISCHARGING JAYCO FROM OBLIGATION UNDER WARRANTY Certain things completely discharge Jayco from any obligation under this warranty and void it By way of example the following shall discharge Jayco from any express or implied warranty obligation to repair or replace any defect that results from any rental or other commercial use or purchase of the RV as defined 1 10 JFB JFD JAYCO TOWABLE SECTION 1 WARRANTY amp SERVICE in this warranty any RV sold outside of or used outside of the United States U S Territories or Canada through an auction or wholesale or by non authorized dealer any defect in a separately manufactured component part owner neglect or failure to provide routine maintenance See Owner s Manual unauthorized alteration off road use collision or accident whether or not foreseeable including any acts of weather or damage or corrosion due to the environment theft vandalism fire explosions overloading in excess of weight ratings and tampering with any portion of the RV or any use of the RV asa permanent home LEGAL REMEDIES Any action to enforce any portion of this limited warranty or any implied warranty shall be commenced within six 6 months after expiration of the warranty coverage period designated above Any performance of repairs shall not suspend this limitation peri
117. hment parts Failure to comply could result in property damage personal injury or death 1 Keep the RV attached to the tow vehicle Block the tire on the opposite side of the RV from the tire you are changing 2 Loosen the wheel lug on the tire you are changing before jacking up the RV DO NOT remove the lug nuts only loosen them for ease of removal when the tire is off the ground 3 Locate the main frame rail of the trailer it spans from front to back just inside the tires 4 raise the RV place the jack hydraulic or screw under the main frame rail It must be just ahead of the front tire or just behind the rear tire A WARNING Be sure to use only tires that are rated for RV use The use of passenger tires should be avoided The load rating range embossed on the sidewall of passenger tires must be de rated accordingly they do not have the same load capability as tires that are specifically identified for RV use Failure to use tires that are properly matched to your recreation vehicle could lead to premature tire wear or less than optimum trailer handling Replacement If you experience flat tire on your RV while driving gradually decrease your vehicle speed if possible Hold the steering wheel firmly and move the RV to a safe place on the side of the road Any service or warranty coverage on tires is to be handled by the tire store representing the brand installed on your RV They are not to be return
118. in this manual creates any warranty either expressed or implied The only warranty offered by Jayco Inc is as set forth in the limited warranty applicable to this vehicle The owner s failure to provide required service and or maintenance could result in the loss of warranty The owner should review Jayco s limited warranty and the limited warranties that apply to specific components that are offered with this vehicle Instructions are included in the manual for operating various components which are optional on some vehicles or may not be available on your particular model If so equipped does not indicate or imply that the component s or option s were at any time available or can be retrofitted to your model In addition the owner should refer to individual manufacturer s operating instructions contained in the owner s packet TABLE CONTENTS JAY FLIGHT BUNGALOW DST TRAVEL TRAILER Section 1 WARRANTY amp SERVICE 5 lt 1 1 Customer Relations i ii i ge ee 1 4 Customer Responsibility 1 3 Dealer iiss evens as aces eee 1 3 Jayco Customer First Emergency Roadside 1 6 JayPlus Extended Service 2 1 5 Jayco Travel
119. ing from the overflow tubes located underneath the RV when the fresh water holding tank is filled This is normal and is caused by external circumstances including the RV being parked on an incline or the motion caused by starting or stopping the RV during travel AN CAUTION Be careful not to overfill the fresh water holding tank It can pressurize the tank causing leakage and water damage and void the warranty DO NOT leave the tank unattended while filling Do not cap block or modify the fresh water tank overflow tubes in any way Enough water pressure can build up during the filling process to damage the plumbing system if the overflow tubes are obstructed FRESH WATER CONNECTIONS Your RV may be equipped with one or both of the following fresh water connections City Water and Gravity Fill The City Water Fill has a threaded connector with a City Water Connection label next to it Do not remove this label To use the City Water Fill Fig 8 3 1 If needed sanitize the water system Refer to Sanitizing the Plumbing System section 2 Unsnap the connection cap and thread a non toxic drinking water hose to the threaded inlet NOTE The other end of this hose should be connected to a pressurized Fig 8 3 City Water Fill with fresh water source e g faucet or spigot City Water Connection label 3 ON the water at the water source Enter the RV and open the cold water supply faucets to bleed air from the wa
120. ining wipe the RV antifreeze out of the sinks shower or tub and toilet using a soft dry cloth If needed contact your RV dealer for assistance BLACK GREY WATER SYSTEM Water from the sinks and shower flows into the gray water or waste water holding tank Water from the toilet will flow into the sewage or black water holding tank WARNING Never travel with full black or grey water holding tanks This not only wastes your fuel but depending on the location of the tank s it can affect your tow vehicle handling characteristics The weight of the holding tank contents is not calculated into the RV cargo carrying capacity this extra weight would reduce your available cargo capacity Traveling with full holding tank s could possibly cause you to exceed the individual tire ratings and or the RV GAWR or RV GVWR Potential damage to suspension components such as springs tires and axles could result If your RV holding tank s are located behind the axles the weight of the full tank s will reduce the hitch weight Trailer sway and other handling difficulties can be the result of the hitch weight being too light 8 18 JAYCO TOWABLE SECTION 8 PLUMBING SYSTEMS Dump the gray and black water holding tanks before traveling to avoid carrying unnecessary weight If you are dry camping and cannot immediately empty your holding tanks reduce your vehicle speed until you reach a dumping station Before using the RV or
121. intervening acts not attributable to Jayco service items such as windshield wiper blades lubricants fluids filters etc damage resulting from tire wear or tire failure defacing scratches dents chips on any surface or fabric of the RV damage caused by off road use overloading the RV or alteration of the RV or any of its components or parts 1 14 JFB JFD JAYCO TOWABLE SECTION 1 WARRANTY amp SERVICE In addition this limited warranty does not cover any material component or part of the RV that is warranted by another entity including by way of example handling braking wheel balance muffler tires tubes batteries gauges generator hydraulic jacks inverter converter microwave television DVD CD player radio speakers television refrigerator range hot water heater water pump stove carbon monoxide detector smoke detector propane detector furnace or any air conditioner Note the written warranty provided by the manufacturer of the component part is the direct responsibility of that manufacturer Defects and or damage to interior and exterior surfaces trim upholstery and other appearance items may occur at the factory or during delivery of the RV to you These items are usually detected and corrected at the factory You must inspect the RV for this type of damage when you take delivery from Jayco If you find any such defect or damage you must notify Jayco within three 3 days of delivery of the RV to you
122. ion should be monitored closely Failure to do so could result in the overheating of a tire which could result in a blowout Inflation pressure should be as recommended by the tire manufacturer or as the federal label for the RV indicates A WARNING It is recommended that the tire pressure be checked at the beginning of each journey to obtain the maximum life of the tire Follow the instructions listed on the Federal Certification label affixed to the roadside front corner of your trailer to determine the correct tire pressure Under inflation may cause tire failures and swaying this may result in loss of control injury death or property damage 4 3 SECTION 4 TOWING amp SET UP JAYCO TOWABLE DANGER Failure to follow proper inflation guidelines may result in tire failure which under certain circumstances can cause loss of vehicle control or accidents that may result in property damage bodily injury and or death CHANGING A TIRE WARNING Do not use the stabilizer jacks to support the RV while under the vehicle or changing tires The stabilizer jacks are designed as a stabilizing system only Do not use the stabilizer jacks as a jack or in conjunction with a jack Attempts to change tires while supporting the RV with the stabilizer jacks could result in damage to the RV and risk causing serious injury or death A WARNING Never raise the RV by placing the jack under the axle springs or any attac
123. ir systems or the entire air box non central air conditioners Consult the manufacturer s operators manual or your RV dealer for more information For additional information refer to the manufacturer s owner s manual included in your warranty packet 9 2 JAYCO TOWABLE SECTION 9 HEATING amp COOLING AIR CONDITIONER WALL Mount IF So EQUIPPED The wall mounted air conditioning system is controlled by a thermostat Cooled air enters the RV through the grill sure you have sufficient power available before operating the air conditioner Do not operate the air conditioner without the return air filter Operating the system without the filter allows the lint and dirt that is normally stopped by the filter to accumulate on the cooling coil of the air conditioner This will lead to a loss of air volume along with possible machine failure Keep the air inlet grill and cabinet clean by wiping with a cloth dampened with warm water and a mild detergent For additional information refer to the manufacturer s owner s manual included in your warranty packet 9 3 SECTION 9 HEATING amp COOLING JAYCO TOWABLE THIS PAGE 15 INTENTIONALLY BLANK 9 4 JAYCO TOWABLE SECTION 10 APPLIANCES REFRIGERATOR The refrigerator is not intended for quick freezing or cooling We recommend stocking it with pre frozen or pre cooled food when possible The shelves should not be covered with paper or plastic and the
124. is why you should always talk to your dealer s service management first When making contact with your dealer please provide the following information Your name location and phone number Your RV 17 digit vehicle identification number VIN Your date of purchase The name of your selling dealer If different from above the contact information for the RV repair facility you are contacting Jayco to discuss A detailed description of the concern If applicable the component description serial number and model number 1 4 JAYCO TOWABLE SECTION 1 WARRANTY amp SERVICE Mailing address Shipping address Jayco Inc Jayco Inc Customer Service Customer Service P O Box 460 100 Bontrager Drive 903 S Main Street Bldg 42 Door 4220 Middlebury IN 46540 Middlebury IN 46540 Phone toll free 800 283 8267 Phone local 574 825 0608 Fax toll free 866 709 9139 Brochure request info Jayco com Service email service Jayco com Website www Jayco com An important note about alterations and warranties Installations or alterations to the original equipment vehicle as distributed by Jayco are not covered by the Towable Limited Warranty The special body company assembler equipment installer or upfitter is solely responsible for warranties on the body or equipment and any alterations or any effect of the alterations to any of the parts components systems or assemblies installed by
125. is in motion The gear assembly may pinch or catch on loose clothing causing personal injury Ensure the slideout is in the closed position prior to hooking the unit to the tow vehicle FAILURE TO FOLLOW THESE INSTRUCTIONS COULD RESULT IN SERIOUS INJURY OR DEATH AN CAUTION Do not place excessive weight in the slideout room It can cause the slideout room to malfunction and cause damage to the slideout The slideout room system is designed for additional floor space and comfort The mechanical components are gear driven Electric powered slideout room systems have a manual override to allow you to extend or retract the slideout room s in case of a power loss Make sure you have sufficient power available before operating your slideout system AN CAUTION Additional support jacks are not needed under the slideout Damage can occur to your slideout room from improper use of aftermarket support jacks OPERATING THE SLIDEOUT 1 auxiliary battery customer supplied must be fully charged and connected If possible the RV should be hooked up to 120 volt AC power so the converter operates 2 The RV must be level and the stabilizer jacks in the extended position 3 Locate the slideout control switch Fig 5 1 slideout control switch 4 To move the room out press the OUT section of the switch and hold it until the motor stops travel time is approx 25 seconds Operating the switch after the room is fully
126. is required to maintain your RV Please review all manuals supplied with the RV and contact Jayco or the supplier of the component part if you have questions Note failure to maintain the RV as noted in those manuals voids this limited warranty and any damage to the RV as a result of your failure to perform such care is not covered by this limited warranty THIS WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS AND YOU MAY ALSO HAVE OTHER RIGHTS THAT VARY FROM STATE TO STATE JAYCO INC 903 S Main Street P O Box 460 Middlebury IN 46540 Telephone 574 825 5861 or 800 283 8267 1 16 JFB JFD JAYCO TOWABLE SECTION 2 OCCUPANT SAFETY FIRE SAFETY If a fire does start follow these basic safety rules 1 everyone evacuate the RV immediately 2 After everyone is clear and accounted for check the fire to see if you can attempt to put it out 3 If it is large or the fire is fuel fed get clear of the RV and have the fire department handle the emergency 4 Do not attempt to use water to put out the fire Water can spread some types of fire and electrocution is possible with an electrical fire OTHER FIRE SAFETY INFORMATION Refer to the following sections for additional fire safety information Q See the Electrical Systems Section in case of an electrical fire See the Appliance Section in case of a grease fire FIRE EXTINGUISHER Fire extinguishers are classified and rated by fire types A B and C These cl
127. ition sources while refuelina No one should be inside and only the qualified propane service technician should be near the RV while the propane tank is being filled The new propane container must be carefully purged for best performance and must NEVER BE OVERFILLED The following label should be kept permanently affixed to your RV ADANGER ALL PILOT LIGHTS APPLIANCES Fig 7 3 1 THEIR IGNITORS SEE Shut off for re fueling label OPERATING INSTRUCTIONS SHALL BE TURNED OFF BEFORE REFUELING Label appearance may not be exact OF MOTOR FUEL TANKS AND OR PROPANE CONTAINERS FAILURE TO COMPLY COULD RESULT IN DEATH OR SERIOUS INJURY The position of the propane container s and the hoses are critical to proper operation and propane flow Follow these instructions to make sure your propane container s are connected properly WARNING The pigtail hose must be installed to avoid tension or pulling stress at either end of the hose Keep the pigtail hose away from sharp edges of the cylinder collar rigid corners walls doors or other compartment structures including the cover LP gas container overfill Never allow your propane tank to be filled above the maximum safe level as indicated by the fixed liquid level gauge Do not allow the visible gauge to be used for filling Overfilling the propane container above the liquid capacity indicated on the container could allow liquid propane to enter the s
128. le and does not indicate a defective P amp T relief valve One way to reduce the frequency of the water weeping or dripping from the P amp T relief valve is to maintain an air pocket at the top of the water heater This air pocket will form in the tank by design however it will be reduced over time by the everyday use of your water heater refer to the manufacturer s manual If the weeping persists consult your dealer or a service agency authorized by the water heater manufacturer UTILITY CENTER IF SO EQUIPPED Outside Shower Fig 8 10 Utility Center w Valves Fig 8 11 Utility Centers w o Valves The City Water connection inlet is located in the Utility Center Fig 8 10 or 8 11 We recommend that you use a non toxic drinking water hose dedicated only to supplying the RV with fresh water to reduce the chance of contamination prevent the non toxic drinking water hose from coming into contact with the ground Install the City Water connection inlet cap when the fresh water connection is not being used Do not remove the Potable Water Label Fig 8 4 The fresh water connection should be unplugged the non toxic drinking water hose disconnected when the RV is unattended for any amount of time 8 8 JAYCO TOWABLE SECTION 8 PLUMBING SYSTEMS If something would happen to the water system this may help limit water damage to a smaller area The Utility Center is located in an exterior compartment in the RV Utility Centers
129. ler near you ask the campground staff for referrals or check the local telephone yellow pages Or contact Jayco Customer Service or your selling dealer for assistance in locating a repair facility a Contact the RV repair facility to discuss your situation and make an appointment Ask how their billing will be handled They may choose to bill Jayco directly otherwise you are expected to pay them b Have the RV repair facility inspect your RV Either they or you must call Jayco Customer Service to discuss applicable warranty coverage prior to any repair work being performed c Jayco Customer Service will issue an authorization number upon warranty repair approval and advise if any original parts need to be returned d Once Jayco Customer Service has issued an authorization number the RV repair facility may begin actual repair to your RV e Inspect the completed repair work thoroughly If you are not satisfied communicate that immediately to the RV repair facility management Make sure you are satisfied with the repair before you pay or leave the premises f For reimbursement either you or the RV repair facility must send copy of your itemized repair bill and all requested return parts by UPS regular ground freight pre paid within 60 days of the completed repair date To expedite processing your warranty claim include your name address phone number RV_17 digit VIN and authorization number If returning parts include c
130. ler sells this RV to a retail customer then the rental warranty would not be applicable The rental warranty does not apply to retail consumers Jayco s rental program is applicable to the following product lines Jay Series Camping Trailers Baja Camping Trailers Jay Feather Ultra Lite Travel Trailers Jay Feather Ultra Lite EXP Travel Trailers Jay Feather Ultra Lite SLX White Hawk Travel Trailers Jay Flight Travel Trailers Jay Flight Swift Travel Trailers Jay Flight Bungalow Park Trailers Jay Flight Destination Eagle Travel Trailers Eagle Fifth Wheels Eagle HT Fifth Wheels Eagle Premier FW Pinnacle Fifth Wheels Octane ZX Lite Weight Toy Haulers If you have any questions regarding this please contact Jayco Customer Service at 800 283 8267 or 574 825 0608 1 12 JFB JFD JAYCO TOWABLE SECTION 1 WARRANTY amp SERVICE JAYCO TOWABLE RENTAL LIMITED WARRANTY WHAT AND WHO 15 COVERED The Jayco warranty covers this recreational vehicle RV when used only for recreational travel and camping including recreational travel and camping by renters of the Dealer for one 1 year This limited warranty applies to the original Dealer only and it is not transferable The warranty period begins on the date that Dealer first places the RV in rental service In the event that a substantial defect in material or workmanship attributable to Jayco is found to exist during the warranty period Jayco will reimburse the De
131. location for two 2 years It covers RV s sold and remain in the United States U S Territories and Canada only The warranty period begins on the date that the RV is delivered to the first retail purchaser by an independent authorized dealer of Jayco or if the dealer places the vehicle in service prior to retail sale on the date the RV is first placed in such service In the event that a substantial defect in material or workmanship attributable to Jayco is found to exist during the warranty period it will be repaired or replaced at Jayco s option without charge to the RV owner in accordance with the terms conditions and limitations of this limited warranty Jayco will cover the costs of having service performed at the permanent site location of the RV for the first three 3 service calls on the RV as long as service is requested in accordance with and within two 2 years of the start of the warranty and as long as the semi permanent site location is within one 1 hour travel time round trip from an independent authorized dealer of Jayco Jayco reimburses travel time at the independent authorized dealer s approved labor rate This limited warranty applies to the first consumer purchaser only All rights and limitations within this warranty are applicable to the original owner of the RV only Jayco s limited warranty only covers substantial defects in materials components or parts of the RV attributable to Jayco It
132. lockages from bird nests spider webs leaves etc Water heater furnace and refrigerator exterior doors need to be kept clean and free of obstructions insect nests mud daubers etc while the appliances if so equipped in use TRAILER FRAME Sand pebbles objects on the highway climate salt air exposure or ice inhibiting chemicals used during the winter months will damage the paint inviting rust and other deterioration Periodically inspect the exterior exposed areas clean and repaint the steel members occasionally and whenever you notice rust or paint chipped away to insure protection E Z LUBE AXLE IF 0 EQUIPPED The E Z lube feature on your axles provides the ability for the bearings to be periodically lubricated without removing the hubs from the axle This feature consists of axle spindles that have been specially drilled and fitted with grease zerks in their ends When grease is pumped into the zerk it is channeled to the inner bearing and then flows back to the outer bearing and eventually back out the grease cap hole If you have further questions consult with your dealer The convenient lubrication provisions of the E Z lube must not replace periodic inspection and maintenance of the bearings Use a hand operated grease gun improper use of a commercial grease gun may damage the seals REAR BUMPER AN CAUTION Do not add items to the RV rear bumper Add on items will eventually
133. ls that will destroy carpet fibers and dyes If you have doubts about what caused the spot contact a professional carpet cleaner Because of the additional dirt typically associated with camping we recommend that you vacuum the carpet frequently Have tough and deep stains professionally steam cleaned Use spot removers for minor spills Always test the carpet for color fastness in an inconspicuous area before using any product 12 2 JAYCO TOWABLE SECTION 12 INTERIOR Vinyl flooring if so equipped Periodically vacuum or sweep to remove dirt and gritty particles Although most common spills will not permanently stain the vinyl floors they are usually easier to remove if wiped up before they set Simply blot with a paper towel and wipe clean with a damp cloth As part of a regular maintenance program sponge mop the entire floor Do not use dish detergents or vinegar and water because they will dull your floor To avoid problems of yellowing linoleum the flooring manufacturer recommends avoiding cleaners that contain oil based solvents i e cleaners containing lemon oil Murphy s Oil Soap etc To care for the vinyl floor covering use a damp mop with water and a mild cleaner DO NOT SOAK THE FLOORING Use care to avoid wetting the carpet edges ABS PLASTICS ABS plastic components will retain their original beauty with reasonable care Dust and wipe clean with soft damp cloth or chamois wiping gently Do not use gritty o
134. lt power converter is not working auxiliary battery not being charged check the reverse polarity fuse s in the Load Center fuse panel Fig 6 2 There are no customer serviceable parts inside the converter case and the manufacturer s warranty will be void if the case has been removed If you have further concerns contact your dealer 4 Seas A e GFCI RECEPTACLE OUTLET Grounding is your personal protection from electrical shock Each RV has a ground fault current interrupter GFCI engineered into the electrical system This device has been designed to reduce the possible injury caused by electric shock The will not protect against short circuits or circuit overloads Test all receptacles monthly Q Push the GFCI TEST button The RESET button should pop out indicating the GFCI receptacle has been tripped and interrupted 120 volt power Q Push in the GFCI RESET button to restore 120 volt power Contact your independent dealer for assistance if the GFCI RESET button does not restore 120 volt power and pops back out 6 3 SECTION 6 ELECTRICAL SYSTEM JAYCO TOWABLE A tripped GFCI receptacle indicates that abnormally high 120 volt current flow a ground fault was detected through the electrical system grounding circuit A fault condition can be caused by faulty wire insulation wet wiring inside an appliance or faulty electrical equipment connected to
135. ly fastened in place Some states prohibit propane appliances to be operated during travel especially in underground tunnels Make sure you know the laws for the areas where you travel The label listed below should be kept permanently affixed to your RV DANGER ALL PILOT LIGHTS APPLIANCES AND THEIR IGNITORS SEE Fig 7 11 OPERATING INSTRUCTIONS SHALL Re fueling Warning Label BE TURNED OFF BEFORE REFUELING OF MOTOR FUEL TANKS AND OR PROPANE CONTAINERS FAILURE TO COMPLY COULD RESULT IN DEATH OR SERIOUS INJURY 7 11 SECTION 7 FUEL SYSTEM JAYCO TOWABLE THIS PAGE 15 INTENTIONALLY BLANK 7 12 JAYCO TOWABLE SECTION 8 PLUMBING SYSTEMS There are two different water systems in your RV the fresh water system and the waste water system The fresh water system consists of the fresh water holding tank fresh water connections water pump outside shower assembly if so equipped water heater faucets shower or tub and water purification system if so equipped The waste water system consists of the waste water holding tank sewage holding tank drains and toilet PLUMBING SYSTEM MAINTENANCE Check all fittings pressure and waste for leaks before each trip or before vehicle storage as part of your normal maintenance Inspect all faucets the water purification system if so equipped and sink connections including drain baskets or filters Inspect connections at the water pump and
136. mping station to this inlet Do not use your fresh water hose The drain valve for the black water tank must be OPEN to use this feature When the hose is connected and when the water source is turned on it sprays water into the black water tank which aids in moving out the waste and cleaning Fig 8 16 Sewer Tank Flusher Inlet the interior of the tank 8 20 JAYCO TOWABLE SECTION 8 PLUMBING SYSTEMS AN WARNING It is important to prevent solid waste buildup Follow the toilet manufacturer s TOILET recommended instructions each time after emptying the black water holding tank The toilet is efficient and easy to operate Generally more water is required only when flushing solids Prior to using the sanitation system it is strongly recommended to flush the toilet several times to release sufficient water into the holding tank If there is not a sufficient amount of water used during flushing the waste materials may not evacuate properly from the drain line to the tank Clogged tanks and pipes could eventually occur The toilet system will perform better when water is run for ten to fifteen seconds after flushing to ensure that the waste will proceed to the bottom of the tank Unlike a toilet in a home which uses four to seven gallons 18 32 liters of water per flush the average recreation vehicle system uses one to three quarts 1 3 liters For added convenience and better sanitation system performance it is advis
137. n cylinders are transportable and are commonly used on RV trailers The capacity of DOT propane cylinders is expressed in pounds DOT propane cylinders are required to be removed from the RV for filling and must be filled by weight by a qualified propane facility DOT Propane cylinders are equipped with an OPD or Over Fill Protection Device designed to reduce the potential of overfilling DOT propane cylinders are also equipped with an ACME service valve that is for connection of the TYPE 1 ACME pigtail hose assembly to the RV two stage regulator The TYPE 1 ACME pigtail hose assembly is a wrenchless user friendly right hand threaded connector that features a thermally sensitive sleeve and excess flow device output is 200 000 BTU hr It is used to connect propane cylinders to regulators hoses and other fittings It is not for use on gas grills and other low pressure devices DOT cylinders equipped with an OPD and ACME type 1 service valve are identified by the triangular service valve knob DOT cylinders are typically marked with top or an arrow to indicate the correct orientation of the cylinder s Do not mount store or transport any cylinder other than the in proper position indicated 7 2 JAYCO TOWABLE SECTION 7 FUEL SYSTEM Be sure to securely re install DOT cylinder s to the RV after they have been removed for filling or replacement Always close the service valve and install a dust cap or plug when transporting or s
138. n in Door Frame Code not working e Remove Batteries for 10 seconds then Program New Code Inside Paddle not Opening Latch e screws not secured to the Housing Buttons light but the Dead Bolt does not activate e Replace the batteries If the problem is not found on this list please refer to the manufacturer s operators manual Battery Installation The entry system uses 4 AA batteries for operation We do not recommend zinc carbon batteries for this application Fresh batteries should be installed as necessary Battery Life is highly dependent upon battery quality usage and environment temperature Remove batteries if the lock will not be used for extended periods of time The following steps are shown on the enclosed Battery Installation schematic 1 Remove 2 4x40 screws from Battery Compartment Lid These screws are very small so please take care in removal and installation 2 Install the AA batteries in accordance with the orientation symbols shown the Battery Compartment The batteries will fit tightly 3 Install Battery Compartment Lid by aligning the 3 tabs on the lid with the 3 slots on the Inside Plate Assembly These tabs act as a hinge for closing the Battery Compartment Lid 4 Install the 2 4x40 screws back to attach the Battery Compartment Lid to the Inside Plate Assembly ig 2 4x40 Screws D Tan 4 AA Batteries Battery Compartment Lid Battery Orientation
139. n not in use IN CASE OF A GREASE FIRE AN WARNING Do not attempt to use water to put out the fire Water can spread some types of fire and electrocution is possible with an electrical fire 10 1 SECTION 10 APPLIANCES JAYCO TOWABLE Grease is flammable Never allow grease to collect around top burners or on the cook top surface Wipe spills immediately Refer to Section 2 for fire safety and fire extinguisher information COOKING WITH PROPANE See Section 7 Fuel System for important safety instructions Refer to the manufacturer s owners manual for detailed operating and safety instructions for all propane appliances KITCHEN STOVE RANGE OR OVEN IF SO EQUIPPED To prevent damage always use the manufacturer s recommended size flat bottom pan s Generally the pan should be large enough to cover the burner but not be more than one inch larger than the burner grate Do not use a broiler pan griddle or any other large utensil that covers more than one burner at a time This will create excessive heat that may cause melting sooting or discoloration In addition the use of undersized pans could expose a portion of the heating element to direct contact and may result in ignition of clothing Proper relationship of pans to burner will improve efficiency AN WARNING During and after use do not touch or let clothing or other flammable material come in contact with the top burners or heating element
140. n severe or fatal injury N WARNING The power cord must be fully extended when in use and not left coiled in the electrical compartment or on the ground If the power cord is left coiled it may potentially create enough heat to melt its protective casing WARNING PLUG INTO 50 AMP SERVICE ONLY 50 Amp 6 7 SECTION 6 ELECTRICALSYSTEM JAYCO TOWABLE N WARNING Do not hook up the power cord to any receptacle until you have verified proper polarity and grounding Polarity indicators can be purchased in most electrical and hardware stores Do not use any cheater plug adapter or extension cord to reconfigure incoming AC power or break the continuity of the circuit connected to the grounding pin Do not connect the power cord into an outlet that is not grounded or adapt the power cord plug to connect it to a receptacle for which it is not designed Do not remove the grounding pin to connect to a non grounded receptacle Removal of the ground pin disables an important safety feature designed to prevent shock and electrocution hazards Do not connect the power cord to an extension cord Use of an improper extension cord will cause overheating of the cord as well as potentially causing premature failure of the AC equipment It is the responsibility of the owner of the electrical receptacle to ensure that the receptacle is properly wired and grounded Reverse polarity and or improper grounding of your RV can
141. nal outlets such as furnace exhaust etc to prevent mice or other rodents from entering Cover the roof air conditioner if so equipped Disconnect 120 volt AC power to the RV Do not use the stabilizing jacks during storage Drain all water lines Drain and flush all holding tanks fresh water gray water black water and or hot water tanks Remove all batteries from the RV and store in a place where they won t freeze Batteries that have been frozen will never hold a proper charge Store your RV indoors under a roof or purchase a breathable cover for use during storage Thoroughly wash the interior and the exterior of your RV To prevent weather checking and other UV damage cover tires that are exposed to sunlight Turn all cushions on edge to prevent the moisture mildew buildup during storage Turn off 12 volt DC 120 volt AC propane to the refrigerator defrost and clean if so equipped Prop or block the doors open so air can circulate and prevent mildew or use crumpled newspaper or open boxes of baking soda in the refrigerator to eliminate odors during storage Remove all perishables from the cabinets Leave the cabinets and doors ajar to allow air circulation and prevent mildew and musty odors Remove all perishables from the cabinets Leave the cabinets and doors ajar to allow air circulation and prevent mildew and musty odors Lubricate locks and hinges on exterior doors During Storage Period Remove snow from th
142. ngs to ensure you are below the posted minimum ratings 3 5 SECTION 3 PRE TRAVEL INFORMATION JAYCO TOWABLE TRAVEL TRAILER HITCH CUSTOMER SUPPLIED Hitch selection is important because it affects the towing and handling characteristics of your RV There are many kinds of hitches available for various uses and assuring that you have the correct hitch installed is critical to a safe towing experience Ask your dealer about the proper class and type of hitch you need to purchase for your individual tow vehicle RV combination A travel trailer requires a frame mounted hitch The hitch manufacturer assigns a hitch class rating based on the capacity that hitch has for towing and a weight classification The weight classification is determined from the hitch s weight carrying capacity also Known as the tongue weight on a travel trailer Before selecting a hitch you must know your GVWR and tongue weight The rating of the hitch package purchased should be equal to or greater than the RV s GVWR and the hitch weight A CAUTION Using an oversized or undersized hitch can cause damage to the RV frame Jayco cannot be responsible for the tow vehicle suspension system The final ball height after the tow vehicle travel trailer combination is completely hooked up is a factor that must be considered To avoid overloading your trailer axles and minimize possible handling difficulties your trailer should be level when hooked to your t
143. not being recharged and power is being drawn from it it will eventually discharge A battery will discharge at a faster rate as its energy level becomes depleted It is recommended you plan your electrical usage accordingly For accuracy test the auxiliary battery voltage using a volt ohm meter customer supplied A fully charged auxiliary battery will read 12 7 volts DC and 1 265 specific gravity at 80 F 32 C The auxiliary battery is considered discharged at 11 8 volts and dead at 11 65 volts When voltage drops below those levels permanent damage may occur Typically a deep cycle battery has an amp hour rating of 75 100 amps If you run the furnace and refrigerator simultaneously you will be using approximately 12 0 3 0 15 0 amps per hour This does not include any 12 volt lights water pump or any other 12 volt component If the furnace and refrigerator in the above example operated constantly a 75 amp hour battery would become fully discharged in 5 hours 75ah 15a 5h 6 4 JAYCO TOWABLE SECTION 6 ELECTRICAL SYSTEM The auxiliary battery should be installed in parallel with the battery in your tow vehicle When the 7 way trailer plug is connected both batteries power the RV so it is important not to discharge your tow vehicle battery below the level required to start the engine To prevent this from occurring disconnect the 7 way trailer plug or install a battery isolator When the tow vehicle engine is operatin
144. ns to perform repairs Propane cylinder recertification If you have an older RV you should know that according to Federal law DOT cylinders may only be used for 12 years after their manufacture date the number of years for certification may vary in your area After that the cylinders must be recertified which provides another five years of use The cylinders can be recertified every five years thereafter Federal DOT Department of Transportation regulations require periodic inspections and re qualifications of the propane cylinders DO NOT USE damaged or rusted containers Verify with your local propane dealer that all required inspections and certifications have been completed on the propane cylinder within the correct time period before refilling the cylinder Have the LP system checked for leakage each time a cylinder is refilled or after any part of the propane system has been disconnected 7 7 SECTION 7 FUEL SYSTEM JAYCO TOWABLE AN WARNING Propane regulators must always be installed with the regulator vent facing PROPANE REGULATOR downward Regulators that are not located in baggage compartments have been equipped with a protective cover Make sure the regulator vent faces downward and if applicable the cover is in place to minimize vent blockage that could result in excessive gas pressure causing fire or explosion Single stage regulator Some models are equipped with a single stage regulator Tw
145. nsed We have a dumping station available for customer use The propane system and all electrical systems must be shut down and turned off We are not responsible for discharged batteries or propane tanks During the appropriate season please ensure your RV is winterized Unless prior approval has been obtained from the Jayco Factory Service Center all personal items must be removed from the area where you are requesting service repair and the refrigerator emptied We are not responsible for loss of food items You are responsible for all transportation costs You may need to arrange for alternative accommodations for some types of repairs Please be prepared accordingly Jayco Customer Service occasionally utilizes local independent repair facilities Your RV may be referred to or repaired by one of these local repair facilities REPLACEMENT PARTS Parts for Jayco RVs are distributed exclusively by authorized Jayco dealers Jayco does not sell parts retail direct or to non authorized dealers If an original part is no longer available Jayco will try to provide an appropriate substitute SECTION 1 WARRANTY amp SERVICE JAYCO TOWABLE JAY FLIGHT BUNGALOW amp DST LIMITED WARRANTY WHAT AND WHO IS COVERED The Jayco warranty covers this Jay Flight Bungalow and DST recreational vehicle RV when used only for its intended purpose of seasonal a semi permanent site
146. nuity of the power cord grounding circuit Do not connect the power to an outlet that is not grounded or adapt the power cord plug to connect to a receptacle for which it is not designed APPROXIMATE ELECTRICAL LOAD RATINGS 120 Volt System Air Conditioner 18 AMPS Coffee Maker 6 12 AMPS Converter each 8 AMPS Curling Iron or Hair Dryer 10 14 AMPS DVD System 3 AMPS Microwave 12 AMPS Refrigerator 6 AMPS Satellite Receiver 2 AMPS TV 2 4 AMPS Vacuum Cleaner 8 AMPS Washer Dryer 12 AMPS Water Heater 12 AMPS 120 Volts Labeled watts divided by 120 Power consumed in AMPS 50 Amp 6 9 SECTION 6 ELECTRICALSYSTEM JAYCO TOWABLE 12 Volt System Aisle Lights 1 0 AMP Baggage Compartment Lights 1 4 AMPS Decorative Wall Lights 1 5 AMPS Dinette Light 4 5 AMPS Exterior Entertainment Center 5 7 AMPS Fantastic Fan 1 5 AMPS Fluorescent Double Lights 12 2 0 AMPS Fluorescent Double Lights 18 2 5 AMPS Furnace 12 0 AMPS Generator Start 95 0 AMPS Halogen Light 1 7 AMPS Illuminated Switch 125 AMP Inverter variable Leveling System 95 0 AMPS LP Detector 125 AMP Map Light 1 5 AMPS Porch Light 1 5 AMPS Power Awning 10 0 AMPS Power Vent 5 0 AMPS Refrigerator 3 0 AMPS Shower Light 1 4 AMPS Step Cover 10 0 AMPS TV Plate Antenna Booster 1 0 AMP Vanity Light 4 2 AMPS Water Heater 6 0 AMPS Water Pump
147. o not have access to City Water Allow extra time to fill the fresh water system if you are using this method The Gravity Fill will have a Potable Water Label next to it Do not remove this label Fig 8 5 27 7 Gravity Water Fill use the Gravity Water Fill Fig 8 5 1 If needed sanitize the water system Refer to Sanitizing the Plumbing System section 2 Remove the connection cap and insert a non toxic drinking water hose into the gravity fill connector The hose will not attach to the gravity fill it will only slide into the connector opening 3 Place the other end of the non toxic drinking water hose into a container of fresh potable water 4 Pour the fresh water into the Gravity Fill inlet until the fresh water tank is full 5 When the fresh water tank on the RV is full remove the non toxic drinking hose and container from the Gravity Water Fill Replace the connection cap This cap should always be installed if the water fill is not in use A WARNING Fig 8 4 POTABLE WATER ONLY SANITIZE Potable Water FLUSH AND DRAIN BEFORE USING Label SEE INSTRUCTION MANUAL FAILURE TO COMPLY COULD RESULT IN DEATH OR SERIOUS INJURY AD O4 WATER PRESSURE REGULATOR CUSTOMER SUPPLIED Excessive pressure from water supply systems may be encountered in some parks especially in mountain regions Water pressure regulators are available to protect your system against such hi
148. o stage regulator The two stage regulator has the only moving components in the propane system Its sole function is to reduce the pressure from the propane containers to a safe and consistent low operating pressure The first stage reduces the container pressure to 10 13 lbs The second stage reduces the 10 13 lbs of pressure further to an operating pressure of 11 W C water column or 6 35 oz of outlet pressure to your appliances The second stage is adjustable and will need to be adjusted by your dealer or qualified propane service technician for optimum performance this adjustment should always be made with a properly calibrated manometer If the pressure is too high it affects performance and safety if the pressure is too low your appliances will not operate correctly If your RV is equipped with the automatic two stage regulator with both cylinders full of propane turn the lever on the regulator towards the cylinder you wish to use first This will now be the supply cylinder and the other the reserve Slowly open both cylinder valves The indicator on top of the regulator will turn bright green When the cylinder becomes empty the indicator will change to bright orange Now turn the regulator lever to the side of the reserve cylinder and the green signal should return You may now remove the empty cylinder to have it refilled without interrupting the flow from the full bottle After filling the cylinder c
149. oad capacity is designated by weight not by volume so you cannot necessarily use all available space when loading the vehicle Do not exceed your GVWR and ensure you are loading the vehicle as evenly as you can for the best possible handling Ensure heavy items are secured so they do not shift during travel A WARNING DO NOT EXCEED YOUR GVWR This means you should weigh your RV as loaded for your normal travel to determine the actual weight If you exceed the GVWR you MUST remove items from the RV or drain liquids then re weigh the vehicle to ensure you have achieved a safe weight Do not travel with full grey black holding tanks This not only wastes gas but depending upon the location of the grey or black holding tanks can affect handling characteristics A WARNING Store items in areas designated for storage Do not store anything in the areas reserved for the converter electrical panels or the furnace or water heater etc SECTION 3 PRE TRAVEL INFORMATION JAYCO TOWABLE Store and secure all loose items inside the RV before traveling Overlooked items such as canned goods or small appliances on the countertop cooking pans on the range or free standing furniture items can become dangerous projectiles during a sudden stop Distribute cargo side to side so the weight on each tire does not exceed one half of the GAWR for either axle For traveling safety it is important to make sure any tie down straps if so equipped
150. od from expiring Any performance of repairs after the warranty coverage period has expired or performance of repairs regarding anything excluded from coverage under this limited warranty shall be considered good will repairs and they will not alter the express terms of this limited warranty or extend the warranty coverage period or this limitation period In addition this warranty is not intended to extend to future performance and nothing in this warranty or any action of Jayco or any agent of Jayco shall be interpreted as an extension of the warranty period or this limitation period Some states do not allow a reduction in the statute of limitations so this reduction may not apply to you WARRANTY REGISTRATIONS Your warranty registration records should be completed and delivered to the manufacturers of component parts The selling dealership will assist you in completing and filling out the Jayco product warranty registration form That form must be returned to Jayco within ten 10 days of your taking delivery of the RV Your Jayco warranty will not be registered unless this warranty registration is completed and received by Jayco Failure to file this warranty registration with Jayco will not affect your rights under this limited warranty as long as you can present proof of purchase but it can cause delays in obtaining the benefits of this limited warranty and it may inhibit any servicing facility s ability to provide proper rep
151. onnect the pigtail hose and slowly open the bottle valve Hoses PIPES TUBES amp FITTINGS The hoses pipes tubes and fittings used in your propane system are designed to withstand pressures exceeding those of the propane system However because environment and time can both contribute to the deterioration of these components they must be inspected for wear at regular intervals Be sure to inspect the hose before each season and when having the tank refilled Look for signs of deterioration such as cracks or loss of flexibility When replacing the hose or other propane components make sure to always replace them with components of the same type and rating check with your dealer Fittings are used to connect the various system components to each other The P O L fitting at the end of the propane supply hose is made of brass so that pipe sealants are not necessary to prevent leaking 7 8 JAYCO TOWABLE SECTION 7 FUEL SYSTEM It also has a left handed thread which means that it is turned clockwise to remove and counter clockwise to tighten The P O L fitting has been designed to help restrict the flow of LP gas in the event of a regulator failure or hose malfunction USING THE PROPANE SYSTEM AN WARNING Do not use portable fuel burning equipment including wood and charcoal grills and stoves inside the RV The use of these items inside a RV may cause fires or asphyxiation inability to breathe After the RV
152. onnector plug Q Trailer battery Breakaway switch Hydraulic brakes if so equipped Your camping trailer may be equipped with hydraulic surge brakes These brakes operate automatically as the tow vehicle s brakes are applied When the tow vehicle operator begins to decrease speed and apply the brakes the weight of the moving trailer pushes forward and the coupler moved downward This pressure moves the plunger which in turn pushes the piston and rubber cup inside the master cylinder Brake fluid presses inside of the wheel cylinder and activates the brake shoes against the drum As designed the weight of a trailer pushing forward will activate the surge brake system When backing a trailer up hill the trailer weight may activate the surge brake system making it difficult to continue to reverse 3 1 SECTION 3 PRE TRAVEL INFORMATION JAYCO TOWABLE 1 Prior to backing up a slope or through soft ground pull the RV forward slightly to assure that the actuator socket is in the forward position 2 Move the lever on the side of the actuator downward from the towing position along the curved slot in the actuator frame to the backup position The slot has a notch at the bottom of its travel Push the lever down to engage the locking notch 3 RV will now back up This lever will slide into the correct position when pulling forward It is extremely important to keep the master cylinder full at all times An empty
153. ons will illuminate when the lock is awake and ready to accept the code 3 The factory default code is activated by touching the 3 7 1 5 Buttons followed by the Enter Button 4 To program your Personal Code touch and hold the 3 4 Button and Enter Button for 2 seconds The lock will beep 3 times indicating itis ready to accept a new code Enter a 4 digit code followed by the Enter Button The lock IMPORTANT Enter v me 4 bk Button een entered The first time the new 4 digi The Touch Pad onl activates the Dead cade is entered there will be a long beep Bolt The Paddle Lock is Master Keyed indicating the new code is accepted The new for Dealer and Service Center use The code can be entered now and will activate the Dead Bolt provides Maximum Securit dead bolt Please enter your Personal Code to prevent inadvertent programming General Maintenance and Operating Guidelines Q Install fresh batteries as necessary The lock is designed to function for months of normal usage with fresh high quality AA batteries Battery life is highly dependent upon battery quality usage and environment temperature Make sure there are no obstructions the door frame to prevent Dead Bolt extension Do not wash with power washer or high pressure cleaner The lock is designed to resist water intrusion to protect its electrical components from normal water enco
154. opy of your return freight bill 1 6 JAYCO TOWABLE SECTION 1 WARRANTY amp SERVICE Obtaining weekend or after business hours repair assistance If an authorized Jayco dealer is not located nearby contact your selling dealer for assistance If your dealer is closed check with the campground staff or telephone yellow pages for an RV repair facility Have the item repaired and contact Jayco Customer Service immediately the following business day Failure to contact Jayco Customer Service unauthorized or improper warranty repairs or failure to return requested original parts may result in loss of reimbursements and or loss of warranty OBTAINING SERVICE FOR SEPARATELY WARRANTED ITEMS Your selling dealer is responsible for servicing your RV before delivery and has an interest in your continued satisfaction We recommend your dealer perform all inspection warranty and maintenance services Some dealers may be authorized service centers for those OEMs whose products are warranted separately and excluded from the Towable Limited Warranty OBTAINING SERVICE AT JAYCO Should your RV be in need of service and your dealer recommend that the repairs be made at the Jayco Factory Service Center your RV may be returned to us with the following guidelines You or your dealer must make a confirmed appointment a minimum of 60 days prior to dropping off your RV at the Jayco Factory Service Center The holding tanks must be emptied and ri
155. ore away from the RV body 2 When washing around the glass areas hold the nozzle at right angles to the glass surface During cold weather Salt and other chemicals that are spread on winter roads in some geographical areas can have a detrimental effect on the RV s underbody If your RV is exposed to these conditions spray the underbody with a high pressure hose every time you wash the exterior of your RV Take special care to remove mud or other debris that could trap and hold salt or moisture After washing your RV wipe off all water drops from the rubber parts around the slideout and doors If the slideout or door is frozen opening it by force may tear off or crack the rubber gasket that is installed around the slideout or door Pour warm water on the gasket to melt the ice wipe off the water thoroughly after opening the slideout or door To prevent the weather stripping from freezing treat it with a silicone spray Waxing your RV Wax your RV once or twice a year or when painted surfaces do not shed water well Use a soft cloth to apply a small amount of wax to the painted surfaces After the wax has dried polish the RV with a dry soft cloth Do not wax your RV in direct sunlight Wax it after the surfaces have cooled Do not apply wax to any area having a flat black finish as it can cause discoloration If the finish has been stained with wax wipe off the area with a soft cloth and warm water When waxing the area around the
156. osed for a period of time To aide in dissipation ventilate the RV by opening all windows and circulate the air with a fan The following label is located inside the RV near the entry door This label should be left permanently affixed to the RV ACAUTION Product in this vehicle may contain Fig 2 2 formaldehyde which may be an irritant to you Formaldehyde warning label You may experience a greater concentration Label appearance may not during high humidity and temperatures be exact Ventilate to remove Consult your owner s manual for additional information DO NOT REMOVE THIS LABEL EXTENDED DRY CAMPING AN CAUTION Continuous living in your RV could cause accelerated wear and damage to component parts Use of the RV other than for its intended purpose of recreational travel and camping may affect your warranty coverage Your RV has been built for enjoyment in a recreational manner It is not intended to be used as full time living quarters 2 7 SECTION 2 OCCUPANT SAFETY JAYCO TOWABLE COLD WEATHER USAGE Proper care should be taken when planning to use your RV in cold weather Please keep in mind that your RV was not designed for use during sub freezing weather When used in freezing or below freezing temperatures the following precautions need to be taken More protection will be needed to protect the fresh water and drainage systems to avoid freezing problems see Winterizing the Plumbing System
157. othes inside the RV to dry If condensation is found in cabinets or closets open those doors slightly to equalize the temperature and provide ventilation Uncontrolled condensation can cause dampness mildew etc inside your RV Be sure to make strong effort to control condensation Repairs due to condensation are not covered under the terms of the Towable Limited Warranty or the Extended Limited Warranty 2 8 JAYCO TOWABLE SECTION 2 OCCUPANT SAFETY SECONDARY MEANS OF ESCAPE EXIT WINDOW The emergency egress window is designed to allow quick exit from the RV during an emergency if access to the main entrance door is not available e Make sure all occupants know how to open and operate the egress window before an emergency occurs e When pulling into your campsite make sure the egress is not blocked by trees or other obstacles Make sure the ground below the window is solid and can be used as an escape path The Egress window must be locked during transit Do not remove the following label from your RV Fig 2 3 Emergency egress window label 2 9 SECTION 2 OCCUPANT SAFETY JAYCO TOWABLE THIS PAGE 15 INTENTIONALLY BLANK 2 10 JAYCO TOWABLE SECTION 3 PRE TRAVEL INFORMATION Tow VEHICLE If you plan to tow your RV with a tow vehicle you already own contact your automotive dealer to find out your vehicle towing capacity If you plan to purchase a new tow vehicle be certain to tell your automoti
158. ove the hand held showerhead and hose from its holder Utility Center w o Valves This hose may have to be manually connected to the adapter between the faucets 5 Turn ON the hot and cold faucet knobs and adjust the water temperature as desired 6 To activate the hand held shower turn ON the sprayer head attachment some models To turn off the water close the faucet knobs The lever at the shower head will not completely shut off the flow of water this is intentional Turn water pump OFF if dry camping After the water has been allowed to drain from the shower head replace it in the outside shower compartment Any remaining water in the shower hose will drip or run out this is not a leak but performs as intended The showerhead can be removed to drain the hose faster If you choose to remove the showerhead to drain the hose reassemble it for storage Coil the hose and arrange it with the showerhead inside the faucet assembly Make sure that the hose is not being pinched and the showerhead is not being damaged when the door is closed FAUCETS A WARNING Water temperatures over 125 49 C can cause severe burns instantly or death from scalds therefore be careful when using hot water Always test the water temperature before showering or washing 8 10 JAYCO TOWABLE SECTION 8 PLUMBING SYSTEMS The faucets operate much the same way as the faucets in your home Make sure there is sufficient water available
159. ow vehicle Do not overload your tow vehicle Equipment that sometimes gives autos trucks and sport utility vehicles a softer ride can accentuate swaying when pulling a RV conversely suspension that is too stiff will increase vibration bounce and accelerate wear of your tow vehicle and RV combination Jayco cannot be responsible for the suspension system of any tow vehicle There are a variety of tow vehicle suspension systems available that will affect the ball height stability and levelness of a hooked up RV Make sure your dealer is aware of the tow vehicle you are using so a compatible hookup is achieved Travel trailer hitch weight Maintain the proper tongue weight of the trailer Stay within the target range of 10 15 of the overall gross weight travel trailer weight plus contents Travel trailer hitch height amp hitch ball To determine the hitch height for your model make sure that This unit hitch the trailer is level When the loaded RV is hitched to the tow height is vehicle check the hitch ball height This can be determined by measuring the distance from the center of the hitch ball to the ground Record this number in the box for future reference Adjust the equalizing bars of the hitch assembly so that the tow vehicle and the trailer are essentially level A high hitch will transfer weight behind the axles and cause the vehicle to fishtail A low hitch will transfer additional weight to the hitch Refer to
160. oxide which can kill vou Operate the RESET SILENCE button Call your emergency services fire department or 911 Immediately move to fresh air outdoors or by an open door or window Do not re enter the premises or move away from the open door or window until the emergency service responders have arrived the premises have been aired out and your alarm remains in its normal condition If your alarm reactivates within a 24 hour period repeat steps 1 4 and call a qualified appliance technician to investigate for sources of carbon monoxide from fuel burning equipment and appliances and inspect for proper operation of this equipment Make sure that motor vehicle s are not and have not been operating in an attached garage or adjacent to the RV If problems are identified during this inspection have the alarm serviced immediately Note any combustion equipment not inspected by the technician and consult the manufacturer s instructions or contact the manufacturer directly for more information about carbon monoxide safety and this alarm Pe 2 5 SECTION 2 OCCUPANT SAFETY JAYCO TOWABLE Alarm Signals Q Normal Operation The LED will maintain a steady green light indicating that the alarm is powered CO alarm condition The red LED light will remain steady and the alarm will sound 4 BEEPS then silent for 5 seconds These signals indicate immediate action is required Q Propane gas alarm The red LED light
161. passing the cleanout tool through the piping Passing a mechanical cleanout tool through the waterless valve may cause damage to the internal seal that may potentially allow sewer gases to escape into the RV interior A label has been placed near the location of the waste valve that reads as follows REMOVE WATERLESS TRAP BEFORE USING MECHANICAL DRAIN CLEANING DEVICES Vents Another important part of this system is the vent pipes and vents that release air from the grey and black water holding tanks The exterior vent cap is attached to the roof and must be kept clear of obstructions to perform as intended On some models the vent pipe may be part of the drainage system referred to as a wet vent water flows downward as air flows upward in the same pipe 8 19 SECTION 8 PLUMBING SYSTEMS JAYCO TOWABLE BLACK GREY WATER HOLDING TANKS When connected to the sewer drain line at a campground keep the black tank drain valve closed until the holding tank is at least full This should provide sufficient water to assist in complete draining of the black water holding tank Repeat as needed Never leave the black tank drain in the open position continuously when connected to the campground sewer system BLACK GREY TANK DRAINS There are labels on the exterior of the RV indicating the location of the grey tank drain and black tank drain also called dump valves Always drain the black water holding tank first so the
162. power converter air conditioner 120 volt refrigerator microwave oven television s fireplace and appliances plugged into convenience receptacles 120 VoOLT CIRCUIT BREAKERS The 120 volt AC circuit breakers located inside the main Load Center protect all 120 volt wiring and components in the RV from circuit overloads and short circuits Should a circuit overload or short circuit occur the circuit breaker protecting the affected circuit will trip preventing the flow of electricity through that circuit If a circuit breaker trips shut off the appliance on that circuit i e power converter etc and allow the circuit breaker to cool down for a brief period of time After the cooling down period reset the circuit breaker by moving its lever off and then back to the on position If the circuit breaker re trips or frequently trips contact your dealer to have the electrical problem diagnosed and repaired A circuit breaker identification label is permanently attached to the inside surface of the 120 volt Load Center A CAUTION Circuit breakers and fuses will not offer complete protection of the electrical system in the event of power surge or voltage spike Maintenance and Replacement At the beginning of camping season inspect the circuit breakers and replace as needed Test by turning each circuit breaker off and back on Circuit breakers are wearable parts and must be replaced as needed as
163. provisions on the main beams See Fig 4 6 Any one of the three methods featured may be used In the tie down system it is important to use materials of proper design and of adequate quality The material specifications contained herein should be considered as minimum requirements Materials not furnished with the travel trailer which will be necessary to complete the tie down system must meet the requirements set forth below Such materials would include 1 or steel strap with a breaking strength of at least 4 725 pounds e g galvanized aircraft cable at least 1 4 inch in diameter or Type 1 Finish B Grade 1 steel strapping 1 1 4 inches wide and 0 035 inches thick conforming with F S QQ S 781 H 2 Galvanized connection devices such as turnbuckles eyebolts strap buckles and cable clamps should be rated at 3 150 working load minimum 3 Ground anchors capable of withstanding at least a 4 725 pound pull Anchors must be installed as specified by the anchor manufacturer THE UNIT MUST BE IN ITS FINAL LEVEL POSITION PRIOR TO TYING IT DOWN The procedure for tying down the travel trailer is as follows 1 Position and install the ground anchors to line up with the provided tie down brackets 2 Connect the straps to the frame and ground anchors JFB JFD 4 15 SECTION 4 TOWING SET UP JAYCO TOWABLE 3 Tighten the straps using the tensioning device provided with the ground anchors Use
164. r abrasive particle soaps or scouring compound to clean ABS plastic Avoid using Citrus or biodegradable cleaners which contain D Limonene as they may damage plastic materials PANTRY IF SO EQUIPPED Depending on the kitchen layout of your RV you may have a pantry that you can use to store items you wish to take with you as you travel and camp Ensure items stored in the pantry are secured so they do not shift during travel The cabinetry has been designed to accommodate the normal camping items i e paper plates flatware cookware etc which are bulky but not necessarily heavy Remember your RV s load capacity is designed by weight not volume so you cannot necessarily use all available space FLOOR SAFE IF SO EQUIPPED Your RV may have a safe mounted on the floor of the closet or under the bed The safe is intended to help to safeguard valuable items Jayco cannot be held liable for loss of personal property that is placed within the safe To secure items in the safe utilize the key provided with the safe and lock it after placing items in the box Store the key in a location away from the safe HIDE A BED IF SO EQUIPPED The hide a bed sofa functions much the same as a regular residential hide a bed sofa To make the hide a bed sofa into a bed remove the seat cushions and pull the sofa back towards you firmly and gently Activate or deflate the air mattress if so equipped using the supplied furnitur
165. r plans to avoid filling the water heater with RV antifreeze Bypass valves are normally located in close proximity to the water heater On the Large Utility Center the 3 valves are located on the Utility Center front panel with a label explaining how to set them for Normal or Bypass modes Fig 8 7 a N 04 Normal Camping Usage Valves A amp B Open Valve C is Closed Fig 8 7 Bypass valves on the Bypass Mode Valves A amp B Closed Large Utility Center if so Valve C is Open equipped Fig 8 8 Water Heater Bypass Diagram 8 6 JAYCO TOWABLE SECTION 8 PLUMBING SYSTEMS In Fig 8 8 valve D is the fresh water tank shutoff and valve E is used to introduce RV antifreeze into the lines to Winterize the system See section on Winterizing the Plumbing System Water heater switches if so equipped Switches are located on the Monitor Panel For explanation on their operation refer to the Monitor Panel section Page 8 2 Fig 8 1 or 8 2 Odor from the hot water system Many water supplies contain sufficient amounts of sulfur to produce an odor often called sulfur water Sulfur water can be caused by a chemical action or by bacteria Generally sulfur water is not harmful only unpleasant to smell Refer to the water heater manufacturer s owners manual for details on eliminating the odor from sulfur water Odor from sulfur water is not a service problem WARNING Do not replace
166. r serious injury A WARNING This indicates a potentially hazardous situation that if not avoided will result in death or serious injury SECTION 1 WARRANTY amp SERVICE JAYCO TOWABLE AN caution This indicates a potentially hazardous situation that if not avoided will result in minor or moderate injury CAUTION This indicates a potentially hazardous situation that if not avoided may result in property damage REPORTING SAFETY DEFECTS In the United States If you believe that your RV has an alleged defect that could cause a crash or cause injury or death you should immediately inform the National Highway Traffic Safety Administration NHTSA and Jayco If NHTSA receives similar complaints it may open an investigation and if it finds that a safety defect exists in a group of vehicles it may order a recall and remedy campaign However NHTSA cannot become involved in individual problems between you your dealer or Jayco For additional information please refer to the NHTSA website www safercar gov To contact NHTSA by phone Call the Department of Transportation DOT Vehicle Safety Hotline at 1 888 327 4236 and a NHTSA representative will record your complaint information TTY 1 800 424 9153 or 1 202 484 5238 To contact NHTSA by mail Office of Defects Investigations CRD NVS 216 1200 New Jersey Ave SE Washington DC 20590 In Canada If you believe your RV has an alleged safe
167. recommended the fabric be professionally cleaned if it becomes stained or soiled For more information refer to the specific furniture manufacturer s care instructions Suede Upholstery if so equipped It is recommended the suede be professionally cleaned if it becomes stained or soiled Vinyl Upholstery if so equipped Do not dry clean vinyl components If they are dry cleaned the vinyl on the reverse side will shrink become hard and crack If a spill does occur water base cleaners are recommended solvents are not recommended as they may have an adverse reaction to the specific backing of your upholstery fabric Blot up the spot but do not rub it in or saturate the area Use a professional furniture cleaning service for an overall cleaning Clean the suede or vinyl upholstery only as recommended Using other processes than those listed may produce undesired results and possibly damage the upholstery This type of damage is not warrantable DECOR ITEMS D cor items should be cared for as follows Window treatments curtains blinds and shades Dust occasionally with a vacuum and soft brush attachment Professionally clean only Shower Curtain if so equipped To help prevent mildew or mold clean the shower curtain D cor Glass if so equipped Use a glass cleaner to remove smudges smears and spots If there is any decorative etching on the d cor glass use care when cleaning around that area PANELING To clean use
168. rn Swerves and sharp turns especially at high speeds could result in loss of control of the RV Backing up If your camping destination does not have pull through sites pick a level site and back in carefully We suggest you stop near the site get out of the RV and observe the surrounding area Check to ensure there are no obstacles in your path and that you have plenty of vehicle clearance Check for low hanging tree limbs posts large rocks or other obstacles Try to choose a site that is on the driver s side so you can see what the rear of the RV is doing With the site on the passenger side you would be backing into the site on your blind side which is more difficult 4 2 JAYCO TOWABLE SECTION 4 TOWING amp SET UP When you determine the site conditions are satisfactory maneuver the RV into position for backing up into the site space Back the RV up slowly using your tow vehicle mirrors as a guide Have another person outside the RV assist you until the RV is parked in the desired position Parking After the RV is in the desired location set the tow vehicle parking brake and place the transmission in park Turn OFF the ignition switch Go outside the RV and block all wheels securely with wheel chocks The wheel chocks can be wood blocks or purchased items as long as they prevent the RV from rolling TIRES Read and understand the following before taking your first trip in your RV Proper care and maintenance of your
169. s burner grates or other areas near the top burners or oven until they have had sufficient time to cool These areas can get hot enough to cause burns Never leave cooking food unattended Turn pan handles inward but not over the tops of the other range burners Ensure that pans used are large enough to contain the food and avoid boil overs Heavy splattering or spills left on the cook top can ignite and cause burns If using glass glass ceramic ceramic earthenware or other glazed utensils or cookware verify it is safe for use on the top burners Only certain types of utensils or cookware are suitable for surface or top burner use OVEN IF So EQUIPPED AN WARNING Do not cover the oven vent openings while the oven is in operation Restricting the flow of combustion air will create an asphyxiation hazard The propane gas oven must have 12 volt power to operate If you have any questions contact your dealer or our customer service department Do not use the oven as a storage area For additional information refer to the manufacturer s owners manual included in the warranty packet 10 2 JAYCO TOWABLE SECTION 10 APPLIANCES WASHER DRYER PREP IF SO EQUIPPED If your RV was built with this feature be aware the cabinet space provided is intended for the installation of an aftermarket washer dryer combo unit customer supplied only Please consult your dealer or the manufacturer for installation assistance
170. s been in storage before each trip and at least once per week during use The TEST RESET button tests all ELECTRICAL functions of the alarm The TEST Mute switch is located on the front of the alarm Press and hold the test button for 1 second The alarm is working properly if the GREEN indicator light changes color to RED and the horn beeps 4 times The Gas LED should also blink red 2 6 JAYCO TOWABLE SECTION 2 OCCUPANT SAFETY Pressing the test button does not check the sensor operation Refer to the carbon monoxide propane alarm manufacturers user s manual provided in the Warranty Packet for additional information on testing the sensors Repair or replace the combination carbon monoxide propane alarm when the alarm no longer functions As with any electronic product it has a limited life Alarms that do not work cannot protect you The carbon monoxide propane alarm manufacturer strongly recommends replacement of the detector five years after the date of purchase Refer to the Warranty Packet for more information from the carbon monoxide propane alarm manufacturer FORMALDEHYDE Some components in the RV contain formaldehyde based adhesives that may release formaldehyde fumes into the air for an unknown period of time Individuals who are allergic to formaldehyde gas fumes may experience irritation to eyes ears nose and throat Indoor air quality may also be affected by leaving your RV cl
171. s correctly installed The LED light will indicate the battery is functioning properly When the production of combustion is sensed the smoke detector sounds a loud alarm that continues until the air is cleared The LED light will also give a visual indication of a sounding alarm How to test Stand at arm s length from the smoke alarm when testing as the alarm horn may be harmful to your hearing The alarm horn is loud to alert you to an emergency The test button will accurately test all functions Never use an open flame from a match or lighter to test this smoke alarm AN WARNING Test the smoke alarm operation after the vehicle has been has been in storage before each trip and at least once per week during use Do not disconnect the battery or the alarm 2 2 JAYCO TOWABLE SECTION 2 OCCUPANT SAFETY A warning label is located near the smoke alarm Fig 21 Please do not remove the following label from your RV Test smoke alarm operation after vehicle has been in storage before each trip and at least once per week during use Failure to do so can result in death or serious injury RIFIER LE DETECTEUR DE FUMEE SI LE VEHICULEAETE ENTREPOSE AVANT CHAQUE DEPLACEMENT ET AU MOINS UNE FOIS PAR SEMAINE EN SERVICE Fig 2 1 Test smoke alarm Label appearance may not be exact Maintenance Gently vacuum off any dust on the cover of the smoke alarm with your vacuum s soft brush attachment Test the smoke alarm onc
172. seaeeseaeetsaeeneeeeeaes 14 4 Ready to Leave 14 1 RV Start Up icin et ees ans 14 1 FAV 14 2 SECTION 15 ADDITIONAL INFORMATION Featured Components Quick Reference 15 1 Change of Address Ownership 15 2 TABLE OF CONTENTS JAY FLIGHT BUNGALOW DST TRAVEL TRAILER THIS PAGE Is INTENTIONALLY BLANK VI JAYCO TOWABLE SECTION 1 WARRANTY amp SERVICE Congratulations Thank you for selecting a Jayco RV We are excited to welcome you to our growing RV family Jayco is the largest privately held manufacturer of recreation vehicles in the world We are committed to being the most respected name in RVs We invite you to drop by our Visitors Center located in Middlebury Indiana To book a group tour or check our scheduled factory tour times free admission closed holidays please call 1 800 RV JAYCO ABOUT THIS MANUAL This manual is a guide to the operation and maintenance of your RV Jayco RVs are available in several sizes and models so accessories and components may differ Some equipment described in this manual may not apply to your RV If you find the components vary significantly from what is described contact your dealer to ensure you have the correct information Nothing in this manual
173. set up of the RV on a semi permanent site location wheel alignment or adjustments to axles when caused by improper maintenance loading or damage from road hazards including off road travel wheel damage or balancing or damage from tire failures Also the travel costs for any service after the first three 3 service calls are specifically excluded from the coverage of this warranty In addition this limited warranty does not cover any material component or part of the RV that is warranted by another entity including by way of example handling braking wheel balance muffler tires tubes batteries gauges generator hydraulic jacks inverter converter microwave television DVD CD player radio speakers television refrigerator range hot water heater water pump stove carbon monoxide detector smoke detector propane detector furnace or any air conditioner Note The written warranty provided by the manufacturer of the component part is the direct responsibility of that manufacturer Defects and or damage to interior and exterior surfaces trim upholstery and other appearance items may occur at the factory These items are usually detected and corrected at the factory or by the selling dealer prior to delivery to the retail customer You must inspect your RV for this type of damage when you take delivery If you find any such defect or damage you must notify the selling dealer at time of delivery to have these items covered by t
174. side especially during heavy rainstorms Condensation will also cause water to accumulate on windows and in the tracks The window glass can normally be cleaned with a sponge and water Use glass cleaner to remove wax oil grease dead insects etc After washing the glass wipe it dry with a clean soft cloth PATIO AWNING IF SO EQUIPPED Please refer to the awning manufacturer s operators manual Keep your awning in good condition to prevent costly repairs It is very important to keep the awning clean If weather conditions are windy or stormy close the awning into the travel mode position Shut the awning in the travel position if you will be away from the RV for an extended period of time The 12 volt power awning may need to be adjusted retracted to operate the entry door some models CAUTION Awnings must be closed and locked if applicable while the RV is in transit JFBTT JFDTT 13 7 SECTION 13 EXTERIOR JAYCO TOWABLE LADDER IF SO EQUIPPED Your RV may be equipped with an optional roof ladder The RV roof has decking under the rubber roof membrane to allow you to walk on the roof with caution to do maintenance A WARNING If your RV is equipped with a roof ladder do not leave items attached to it while traveling The ladder has a weight limit of 350 when using it to access the roof DO NOT exceed this weight limit 13 8 JFBTT JFDTT JAYCO TOWABLE SECTION 14 TRAVEL CAM
175. table to Jayco within the warranty coverage period 2 Provide the notification mentioned in 1 above within ten 10 days of when the owner discovered or should have discovered the substantial defect in material or workmanship attributable to Jayco 3 Promptly and appropriately make the necessary repairs and 4 any freight or transportation costs import duties fees and all incidental expenses associated with obtaining warranty service If you need assistance you may contact Jayco at 903 S Main Street P O Box 460 Middlebury Indiana 46540 Attn Customer Service 574 825 5861 800 283 8267 or www jayco com Also you must notify Jayco within three 3 days of delivery to you to have work performed on any defect or damage to appearance items that occurred at the factory during manufacturer or during delivery at no cost to you as provided by this limited warranty See below under WHAT 15 NOT COVERED If two 2 or more service attempts have been made to correct any covered defect that you believe impairs the value use or safety of the RV or if it has taken longer than thirty 30 days for those types of repairs to be completed you must to the extent permitted by law notify Jayco directly in writing at the above address of the unsuccessful repair s of the alleged defect s so that Jayco can become directly involved in making sure that you are provided service pursuant to the terms of this limited warranty WHAT
176. teeeeeeeeeseeeeeeeeeseaeeeseeeseeeeseeeseeeesieeeeeeeeeaes 8 3 Fresh Water Holding 8 3 Fresh Water 8 1 Hardware amp Sink or Shower 2 8 11 A ee ee ee 8 1 Outside Shower If So 8 10 Plumbing System Maintenance cecccceeceeseeeceeeeeeeeeseeeeeeeeeeeeeeeeeeseeeeeseeeeeeeeeaes 8 1 Sanitizing the Plumbing 8 13 8 21 Utility Center If SO 8 8 Water Heater assccchiveteccte accents seesselincdsdetanscoubasnssecets paraaan e N aa 8 5 Water Pressure Regulator Customer 8 4 Water Purification 8 12 Winterizing the Plumbing 8 17 SECTION 9 HEATING amp COOLING Air Conditioner Roof Mount If So 9 2 teens aR aa eek meee Sis eee 9 1 Ceiling Fan If So Equipped 9 1 amp 1 9 1 Fireplace If SO Equipped 000 0 9
177. tely if these symptoms are noticed CALCULATING ELECTRICAL LOAD When connecting appliances to the electrical system remember that 120 volt power usage is limited to a total of 100 amps for 50 amp systems 6 8 50 Amp JAYCO TOWABLE SECTION 6 ELECTRICALSYSTEM Be mindful of the fact that each operating appliance collectively places an added load on your 120 volt electrical system An unintentional trip of a circuit breaker may occur if you overload the RV s and or campgrounds electrical system The amperage rating of individual appliances can be calculated by dividing appliance wattage consumed normally listed on the appliance by nominal design voltage 120 for a 120 volt appliance For example 1200 watts divided by 120 volts equals 10 amps N WARNING To help prevent power surges from damaging the electrical system and its connected devices please follow the instructions listing below when connecting to shore power Only connect the shore power cord to properly wired power receptacles 50 amp systems 50 amp NEMA 14 50 120 volt Do not connect the shore power cord to any power receptacle until you have contacted the campground owner and or premise attendant to verify proper shore receptacle polarity and grounding Polarity indicators can be purchased in most electrical and hardware stores Do not use a cheater plug adapter or extension cord to reconfigure incoming AC power or to break the conti
178. tensions and repeat the process for the other dinette bench extension To close the extendable dinette reverse the process The extendable dinette must be closed the snap strap secured and the tabletop put in the bed position BEFORE the slideout room is retracted for transit 12 4 JAYCO TOWABLE SECTION 13 EXTERIOR BBQ GAILL IF SO EQUIPPED WARNING Make sure that you read understand and follow all information supplied with your RV about propane before operating the BBQ grill The propane hose must be correctly connected before lighting the grill Failure to follow instructions supplied by the grill manufacturer with your RV or to use any other components than those originally supplied with the grill could lead to death or serious injury from fire or explosion AN WARNING The maximum weight limit for the bracket on the side of your trailer is 50 Ibs This limit includes the weight placed on the BBQ gill Exceeding this weight limit could cause damage to the unit and possibly cause personal injury from hot equipment The BBQ grill is for use outside of the RV Never use this grill inside a compartment or the RV Before operating the BBQ grill make sure that it is securely placed on the support bracket The BBQ grill must be COMPLETELY cooled before storing to avoid damaging the carrying case if so equipped and causing injury from handling the grill when it is hot Wait until the grill is completely cooled th
179. ter cartridge Replace the water filter cartridge at least once a year 1 Drain the fresh water system 2 Place a container beneath the water cartridge filter to catch any spillage 3 Unscrew the fittings at the top and bottom of the water filter cartridge Pull the water filter cartridge down and out of the fittings Insert the new water filter cartridge and tighten the fittings securely by hand Dispose of the used water cartridge filter For more information Refer to the manufacturer s owner s manual and the label on the water filter cartridge DRAINING THE FRESH WATER SYSTEM Permanent water tanks may be drained through a valve located near the tank An RV with a demand pressure pump system will have low point drains attached to the water lines normally located near the water tank These low point drains will release water in the supply lines by opening the valves and all faucets The water heater has its own drain plug To drain the permanent fresh water holding tank and supply lines 1 Turn the water heater power OFF Turn off the Electric amp LP GAS switches 2 Open all faucets including the outside shower faucet if so equipped 3 Open the exterior fresh water tank drain valve on the permanent fresh water holding tank This knob turns 45 to open or close Fig 8 13 Fig 8 13 Exterior Fig 8 14 fresh water 9 fe Low point drain drains 8 12 JAYCO TOWABLE SECTION 8 PLUMBING SYSTEMS
180. ter lines When the water lines are nearly full you may experience some air pockets Allow them to escape before closing the cold water supply faucets The city water fill will not fill the fresh water tank unless the RV has a utility center w valves It sends pressurized water to the water heater faucets amp water lines The Gravity Fill would be used to fill the fresh water tank 4 water heater will fill first followed by the supply lines and faucets Water heater valves A amp B must be open to allow water into the water heater valve C should be closed Refer to Page 8 6 Fig 8 8 Water Heater Bypass section for an explanation on configuring the bypass valves Bypass valves are normally located near the water heater The fresh water connection should be unscrewed i e the non toxic drinking water hose disconnected when the RV is left unattended for any amount of time If something would happen to the water system this may help limit water damage to a smaller area 8 3 SECTION 8 PLUMBING SYSTEMS JAYCO TOWABLE To disconnect the City Water Fill 1 Shut OFF the water at the pressurized water source 2 Unscrew and disconnect the non toxic drinking water hose and reinstall the connection cap The connection cap should always be installed if the water fill is not in use Using the Gravity Fill You can fill the fresh water tank from a container of fresh water and the Gravity Water Fill inlet if you d
181. the vehicles aligned Q As soon as possible stop to determine the cause of the sway Check all equipment and load distribution If the problem cannot be solved immediately contact your Dealer for a service appointment travel at a much reduced speed on your way there TRAVEL TRAILER WEIGHT DISTRIBUTING SYSTEM CUSTOMER SUPPLIED A weight distributing hitch system provides a more stable tow vehicle RV combination This system will spread the weight evenly to distribute it to the tow vehicle front and rear axles and the trailer axle Consult with your dealer to familiarize yourself with the operation and requirements of the weight distributing hitch system Be certain your tow vehicle can carry the hitch weight JFTT WHKTT JFTT OCSTT 3 7 SECTION 3 PRE TRAVEL INFORMATION JAYCO TOWABLE THIS PAGE 15 INTENTIONALLY BLANK 3 8 JFTT WHKTT JFULE OCST JAYCO TOWABLE SECTION 4 TOWING amp SET UP Driving safety and protection against injury cannot be fully ensured However we recommend you pay special attention to the following Keep the tires inflated to the specified levels Replace the tires before they are excessively worn The propane cylinder s should be turned off when traveling Most refrigerators will keep food cold or frozen for eight hours without running while you travel Adverse weather conditions and extremes in terrain may affect the performance and handling of your tow vehicle Do not operate the to
182. tight enough so they do not drag on the ground 1 Inspect chains to determine if they are 2 Criss cross left chain and attach to right Fig 4 6 Safety chain properly attached to trailer frame mounting slot in tow vehicle hitch installation 3 Repeat Step 2 with right chain Slack for 4 Properly mounted safety chains Note that each length should be the same but not the jack is fully raised and dolly sheel more than necessary to permit the vehicle to removed turn at the minimum radius Crisscross the left safety chain under the coupler and attach to the right mounting slot in the trailer hitch repeat with the right safety chain Slack for each length should be the same but not more than necessary to permit the vehicle to turn at its minimum radius TOWING BEHIND YOUR RV TRAVEL TRAILERS WARNING Towing items behind your Jayco trailer or overloading the rear will void the warranty and may result in damage to the trailer or add on items towing difficulties property damage and or personal injury DO NOT tow anything behind your RV The RV frame and bumper are not designed for towing TRAVEL TRAILER SET 1 Position the RV as desired Level the RV side to side Block the wheels securely to prevent the RV from moving Unhook the wire harness connector plug safety chains and breakaway switch lanyard Install the dolly wheel or platform Release the weight distributing bars customer supplied
183. tility Center w Valves If filling from a water container set the water valves to the Country Fill position Insert a hose into the City Water Fill inlet place other end of the hose in the water container Turn pump ON to draw water into the tank After the tank is full turn the pump OFF Remove the hose and the container Run water through all faucets hot amp cold including outside shower until chlorine smell is gone Gravity Fill Turn the pump ON to send water through the lines Utility Center w o Valves Turn the pump On to send water through the lines Utility Center w Valves Turn off the pressurized water source set the water valves to Normal remove hose from City Water Fill inlet and turn the pump ON Close all faucets including outside shower Turn pump OFF Drain the system again but don t drain the water heater Leave valves A amp B closed Bypass valve C is still open Do not remove water heater drain plug Close low point drains and fresh water tank drain Refill the fresh water tank with clean potable water Using City Water Fill or Gravity fill Refer to step 3 above Open faucets and check that the chlorine taste is gone Drain the system one more time See Draining Fresh Water System Remove the clear tube and replace the cartridge filter if so equipped Or remove Full System Canister insert filter and reattach canister to the mount Open the water heater valves A amp B close bypass valve C JAYCO TOWABLE SECTIO
184. time to make sure everything is stored away and the baggage compartments are closed and locked RV STORAGE Properly preparing your RV for storage during periods of non usage will prevent problems from arising It will also make it easier to get started again for the following camping trip or season To prevent costly freeze ups winterize the plumbing system when it will not be in use for an extended period of time especially if it is stored in colder climates Periodically inspect your RV for damage during storage and seal off any area that can offer an entry point for rodents birds or insects Damage from birds rodents insect etc is not covered under the Towable Limited Warranty applicable to your RV 14 2 JAYCO TOWABLE SECTION 14 TRAVEL CAMPING STORAGE CHECKLISTS When storing your RV it is recommended that the auxiliary battery customer supplied be disconnected to avoid battery discharge Prior to Storage If storing for the winter be sure the RV is winterized refer to Sec 8 Plumbing System Winterizing the plumbing system Q Q Oocodo D D Check your roof and other surfaces to ensure there is damage and potential leakage that might otherwise go unnoticed until it is too late Close all windows and roof vents Close the propane cylinder valve s If you do not have a propane cylinder cover we recommend purchasing one to make sure the regulator is covered Cover all exter
185. tire pressure Flush out water heater tank Inspect safety chains for signs of wear if so equipped Test brakes Test safety alarms 14 4 JAYCO TOWABLE SECTION 15 ADDITIONAL INFORMATION FEATURED COMPONENTS QUICK REFERENCE CHART Your RV may be equipped with some of the items listed below This is a partial listing and it is not intended to cover all components in your RV All information is the latest available at the time of publication Jayco reserves the right to change any of the following information without notice COMPONENT AIR CONDITIONER MANUFACTURER RV PRODUCTS WEBSITE www rvcomfort com PHONE NO 316 832 4357 CAREFREE OF AWNING COLORADO www carefreeofcolorado com 800 622 3230 AXLE Dexter Axle www dexteraxle com 574 295 7888 DVD CD CONTACT YOUR RV DEALER ENTRANCE STEP Hickory Springs www hickorysprings com 800 438 5341 FAN EXHAUST 12V VENTLINE www ventline com 574 848 4491 FIRE EXTINGUISHER CONTACT YOUR DEALER FURNACE www atwoodmobile com 800 546 8759 MICROWAVE CONTACT YOUR DEALER MONITOR PANEL KIB ENERPRISES www kibenterprises com 800 250 7051 OUTSIDE SHOWER amp MOLDERS www bandbmolders com 574 259 7838 PROPANE TANK MANCHESTER TANK www mantank com 800 877 8265 PROPANE CARBON MONOXIDE ALARM CONTACT YOUR DEALER PROPANE REGULATOR Marshall Brass www marshall
186. tires is essential to ensure your safety as well as the safety of others as you travel Taking time to become educated on the special qualities of RV tires and care they require will enhance your travel enjoyment Routine maintenance on your RV is important but it cannot be overstated just how critical proper tire maintenance is to the safety operation and durability of your new RV You must follow the manufacturer s inflation guidelines for maximum load capacity under inflation is just as dangerous as over inflation To insure your tires are operating safely regular inspection of your tires and checking tire pressures is absolutely mandatory Examine your tires frequently for unusual wear Alignment balance and bearing wear will affect tire wear Make sure to look for cracking bulging uneven tread wear etc When you are using your RV check inflation pressure weekly to insure maximum tire life and travel wear Pressure should be checked when the tires are cold During travel tires heat up and pressure increases Do not bleed air from hot tires or your tires may then be under inflated B gt NOTE Cold tire inflation pressure is defined as a tire that has not been used for three more hours or has been driven less than one mile Tire inflation pressure of a hot tire may show an increase of as much as 6 psi over a cold tire Tire pressure is the most important factor in the life and performance of your tires Proper inflat
187. to fill the empty cylinder at your convenience without running totally out of propane COOKING WITH PROPANE Unlike homes the amount of oxygen supply is limited due to the size of the recreation vehicle Proper ventilation when using the cooking appliance s will help you avoid the danger of asphyxiation It is especially important that cooking appliances not be used for comfort heating as the danger of asphyxiation is greater when the appliance is used for long periods of time FAILURE TO COMPLY MAY RESULT IN DEATH OR SERIOUS INJURY 7 9 SECTION 7 FUEL SYSTEM JAYCO TOWABLE AN WARNING Do not turn gas range burner controls ON and allow propane gas to escape before lighting The following warning labels are located in the cooking area to remind the user to provide an adequate supply of fresh air for combustion TO ENSURE A SUPPLY OF FRESH AIR TO OCCUPANTS OPEN VENTILATORS WHEN FUEL BURNING RANGE FUEL BURNING CARRY ON APPLIANCE AND OR FUEL BURNING LIGHTS ARE IN OPERATION COOKING APPLIANCES SHOULD NOT BE USED FOR SPACE HEATING PURPOSES 5 need fresh air for safe operatior DE MANIERE A ASSURER UNE ALIMENTATION EN AIR FRAIS AUX OCCUPANTS OUVRIR LES VENTILATEURS LORSQUE LA CUISINERE LES APPAREILS DE CHAUFFAGE PORTABLES ET OU LES LAMPES DE COMBUSTION D HUILE SONT EN FONCTIONNEMENT LES APPAREILS DE CUISSON NE DOIVENT PAS SERVIR AU CHAUFFAGE DES LOCAUX 0014367 Fig 7 9 Ensure a supply o fresh air
188. to have these items covered by this limited warranty and to have work performed on the items covered by this limited warranty EVENTS DISCHARGING JAYCO FROM OBLIGATION UNDER WARRANTY Certain things completely discharge Jayco from any obligation under this warranty and void it By way of example the following shall discharge Jayco from any express or implied warranty obligation to repair or replace any defect that results from any defect in a separately manufactured component part any neglect or failure to provide routine maintenance by you or anyone you rent the RV to See Owner s Manual unauthorized alteration off road use collision or accident whether or not foreseeable including any acts of weather or damage or corrosion due to the environment theft vandalism fire explosions overloading in excess of weight ratings and tampering with any portion of the RV LEGAL REMEDIES Any action to enforce any portion of this limited warranty or any implied warranty shall be commenced within six 6 months after expiration of the warranty coverage period designated above Any performance of repairs shall not suspend this limitation period from expiring Any performance of repairs after the warranty coverage period has expired or performance of repairs regarding any thing excluded from coverage under this limited warranty shall be considered good will repairs and they will not alter the express terms of this limited warranty or exten
189. toring disconnected containers whether full or empty ASME tanks are permanently mounted to the RV and are commonly used on RV motor homes The capacity of ASME tanks is expressed in gallons ASME tanks are filled while the tank is tank is attached to the motor home by a qualified propane facility ASME tanks are equipped with an automatic stop fill valve designed to reduce the potential of overfilling ASME propane tanks are also equipped with a P O L service valve that is for connection of the supply hose with a left hand threaded brass P O L fitting from the tank service valve to the two stage regulator Not for use on gas grills and other low pressure devices AN WARNING DOT propane cylinders must be transported and stored in an upright position so the pressure relief device will function properly Laying a DOT propane cylinder on its side may potentially create a very dangerous situation Tanks are to be installed fueled and maintained in accordance to State and Local codes rules regulations or laws Propane is a true gas compressed into a liquid form As the fuel is released from the container it changes to vapor which is then used for the operation of the appliances Propane will not run through the appliances in the liquid state Propane expands 11 2 percent for every ten degrees of increase in temperature It is imperative to leave sufficient space inside the container to allow for natural expansion of gas
190. ty defect you should contact Transport Canada and Jayco Transport Canada prefers to be called instead of posted mail or email as it enables their investigators to confirm that your information is correct and to answer your questions accurately For additional information please refer to the Transport Canada website at www tc gc ca To contact Transport Canada by phone Call 1 800 333 0510 or 1 613 993 9851 if you are calling from the Ottawa region and ask to speak to a defect investigator To contact Transport Canada by mail Road Safety and Motor Vehicle Regulation Directorate Transport Canada Tower C Place de Ville 330 Sparks Street Ottawa Ontario K1A 0 5 1 2 JAYCO TOWABLE SECTION 1 WARRANTY amp SERVICE MANUFACTURING PROCESS Jayco recreation vehicles are manufactured for use as temporary living quarters for recreation camping and travel uses all as defined by the bylaws of the Recreation Vehicle Industry Association RVIA NUTLEY This recreation vehicle is not intended for use as full time residence or for commercial use Commercial use means using the RV as a business asset such as a mobile office or using the RV for lease or rental purposes Jayco reserves the right to discontinue or change specifications or design at any time without notice and without incurring any obligation whatsoever RV s built for sale in Canada may differ to conform to Canadian Codes RECREATION VEHIC
191. um of every six months Make sure to check the roof and all four sides of the RV including al moldings doors vents and exterior attachments A quick walk around the RV before leaving may help prevent potential problems during trips and vacations Q Have the sealant replaced if you notice any cracks peeling voids gaps breaks looseness or any sign of physical deterioration Reseal at lease one time each year as preventative maintenance Q Always use the same type of sealant that was removed Your dealer service or parts manager can help you obtain the correct sealant s The sealants may become damaged due to ultraviolet exposure air pollution freezing temperatures and exposure to other elements If deteriorated repair immediately to prevent damage If you notice water inside the RV immediately have the dealer check for the source of the leak Failure to correct the leak may result in serious damage to your RV this damage may not be warrantable Although the diagrams below may not accurately reflect the exact model of your RV make sure you inspect all sealants as indicated in the text If you have questions and or need assistance with sealing your RV consult with your RV dealer 13 6 JAYCO TOWABLE SECTION 13 EXTERIOR Travel Trailers 1 Trim Edges 4 Windows Doors 2 Roof items 5 Storage Compartments 3 Slideout Roof Floor Access Doors Wheel Wells 6 Lights WINDOWS Any ventilating window may permit water in
192. unter such as rain The lock uses Touch Technology The buttons are activated by touching not pressing Remove batteries when storing or not using this lock for extended periods of time Note the factory code will reset when the batteries are removed for longer than 10 seconds Rain Sensing Technology The lock system has Rain Sensing Technology to preserve battery life Rain will wake up the touch pad and illuminate the buttons After a few seconds of contact from rain water the lights turn off but a code can be entered and the lock will function normally The same effect occurs if the operator touches a button for a prolonged period of time The buttons will illuminate but then turn off Again the lock will function normally Additional Security Feature The lock system recognizes the first 4 digits entered as the code However if you feel someone is watching you enter the code you can continue to enter digits after the first 4 prior to touching the enter button For example if your code is 8 1 3 9 and you felt like you were being watched you would enter 8 1 3 9 then continue to touch additional digits before touching the enter button and the lock will still operate 4 11 SECTION 4 TOWING amp SET UP JAYCO TOWABLE Trouble shooting After installation the touch pad does not work e Batteries are dead e Batteries are not installed properly e Plug not engaged properly Dead Bolt not engaging into Door Frame e Obstructio
193. up to 34 Do not use less than 6 1 2 hanger chain length For optimum brake performance hang chains forward 34 Refer to the manufacturers owners manual for more information TRAVEL TRAILER BREAKAWAY SWITCH A CAUTION NEVER use the breakaway switch and trailer brake system as a parking brake Doing so would create a high amp draw on the battery and converter This can cause damage to wiring connectors and the breakaway switch The breakaway switch is a crucial part of the RV braking system Located on the travel trailer A frame this switch will apply the trailer brakes if the trailer becomes detached from the tow vehicle Attach the breakaway switch lanyard to a permanent part of the tow vehicle on a travel trailer do not attach it to the hitch ball or similar removable parts when hitching the trailer If the RV becomes detached from the tow vehicle the pull pin will be pulled from the switch This automatically causes the switch to close and activates the RV brakes A battery customer supplied must be installed to activate the breakaway switch TRAVEL TRAILER SAFETY CHAINS Safety chain requirements vary from state to state Your RV is equipped with chains to meet SAE standard requirements for maximum gross trailer weight JFB JFD 4 13 SECTION 4 TOWING amp SET UP JAYCO TOWABLE Always have the safety chains attached when towing Install them as shown below so they do not restrict sharp turns but
194. urn the water pump ON This draws water into the fresh water tank When the tank is full turn the pump OFF and remove the hose and the container After the recommended amount of sanitizing solution is in the tank the water tank is full and cartridge water filter if so equipped bypassed NOTE The Full System Canister must have the filter removed Gravity Fill Turn the pump ON to begin sending sanitized water to the faucets Utility Center w o Valves Turn the pump ON to begin sending sanitized water to the faucets Utility Center w Valves Change the water valve positions to the Normal setting Turn the pump ON to send sanitized water to the faucets Open all hot water faucets one by one until water begins to flow continuously and a chlorine smell is noticeable Include outside shower faucets if so equipped Close the hot water faucets and repeat opening all cold water faucets one by one until you smell chlorine Include outside shower faucets if so equipped Turn OFF the water pump Let the solution remain in the tank amp lines for at least four hours when disinfecting with 50 PPM residual chlorine If a shorter time period is desired then a 100 PPM chlorine concentration should be permitted to sit in the system for at least one hour NOTE To thoroughly sanitize the fresh water tank the unit should be driven around for a period of time allowing the solution to splash the sides and top of the tank After the required
195. urned ON when testing for voltage SECTION 11 ELECTRONICS JAYCO TOWABLE Lowering the antenna Rotate the antenna until the pointer on the directional handle aligns with the pointer on the ceiling plate Turn the elevating crank counterclockwise in the DOWN direction until resistance is noted The antenna is now locked in the travel position A CAUTION Make sure the television antenna is in the travel position cranked down before moving the motor home Failure to lower the antenna into the travel position before traveling may damage the antenna SATELLITE IF SO EQUIPPED Please refer to the manufacturer s instructions for setup care and maintenance JAYCO TOWABLE SECTION 12 INTERIOR CLEANING THE INTERIOR To keep the value of your RV perform regular maintenance using the proper materials and procedures Using the wrong cleaner may result in damage to the surfaces in your RV Check with the manufacturers information for the recommended cleaning agent If in doubt check to see if the cleaner will cause damage by testing a small area out of sight or contact your independent dealer for assistance Do not use flammable liquids or sprays to clean your RV FURNITURE UPHOLSTERY To retain the value of your RV maintain the furniture upholstery carefully and keep the interior clean Vacuum the furniture regularly using a soft brush attachment to remove any loose dirt or debris Fabric if so equipped It is
196. usage Never attempt to repair the furnace yourself FIREPLACE IF SO EQUIPPED You may have a fireplace installed in your RV Refer to the manufacturer s owner s manual If you have further questions please contact your dealer or Jayco Customer Service AIR CONDITIONER ROOF Mount IF 0 EQUIPPED The roof mounted air conditioning system is controlled by a thermostat Cooled air enters the RV through the adjustable chill grill Make sure you have sufficient power available before operating the air conditioner Do not operate the air conditioner without the return air filter Operating the system without the filter allows the lint and dirt that is normally stopped by the filter to accumulate on the cooling coil of the air conditioner This also will lead to a loss of air volume possible equipment damage and an expensive cleaning process A special foam gasket is placed between the roof material and the subframe of the air conditioner to guard against water leakage The air conditioner is subjected to wind pressures along with motor vibration during normal operation Inspect the mounting bolts for tightness to ensure there is no leakage or looseness at least annually Re tighten bolts when they are loose DO NOT over tighten these bolts as it may damage this gasket The air conditioner gasket is a wearable part that eventually will need to be replaced To gain access to the bolts remove the filtered panel cover on central a
197. uts and washers provided 3 If a vinyl cylinder cover is used slip it over the new single cylinder or a double cylinder cover may be used in lieu of single covers 4 Attach the second 24 hose to the tee check valve on the regulator and the right handed swivel nut to the cylinder valve Located in a recessed compartment or housing if so equipped Fig 7 7 Two propane cylinders 1 Connect the 3 8 low pressure hose to the outlet of the two stage regulator 2 Place the cylinder on the bracket in the recess compartment or housing and secure them so the outlets of the cylinder valves are facing the sidewalls of the compartment or housing opposite of each other 3 Mount the regulator on the center back wall of the compartment or housing so the vent is pointed downward 4 Attach the 1 4 inverted flare x 18 Type 1 pigtail hose to the regulator inlet and the right hand swivel nut to the cylinder valve Main Supply Hose Low Pressure Attach the main supply hose from the regulator to the brass manifold fitting in the frame of the trailer The swivel brass nut on the main hose will be your final attachment 3 8 MPT x 1 2 Female Fig 7 8 Main supply Flare Swivel hose NY 7 6 JAYCO TOWABLE SECTION 7 FUEL SYSTEM Several things to remember each time the propane container is removed 1 Check that ALL fittings are tight 2 Check that ALL connections are
198. various openings do not apply any wax on the weatherstrip If it is stained with wax the weatherstrip cannot maintain a weatherproof seal around the opening 13 3 SECTION 13 EXTERIOR JAYCO TOWABLE AN CAUTION Do not use waxes containing high abrasive compounds Such waxes remove rust and stains effectively but they are also harmful to the luster of the surface since they may scrape off the coating Further they are detrimental to glossy surfaces such as the grille garnish moldings etc Do not use gasoline or paint thinners to remove road tar or other contamination to the painted surface Polishing your RV If painted surfaces have been severely damaged and have lost their original luster and color tone polish the surface lightly with a fine polishing compound Avoid limiting your polishing to the damaged surface only polish a somewhat wider area moving the polishing cloth in one direction After polishing flush the compound from the surface and apply a coat of wax to regain a beautiful luster AN CAUTION Do not use a buffer and a buffing compound as it may damage the exterior surface Please contact a professional paint body shop for assistance Damaged paint To prevent corrosion touch up small cracks and scratches in the paint coat as soon as possible with touch up film or paint Carefully check the body areas facing the road and the tires for damage to the paint coat caused by flying stones etc To purc
199. ve dealer the GVWR size and type of RV that you will be towing some tow vehicles can be purchased with an optional tow package As a minimum requirement the Gross Vehicle Weight Rating GVWR of your RV must not exceed your tow vehicle s towing rating Some automotive manufacturers publish brochures that discuss towing considerations Ask your automotive dealer how to obtain a copy of this information If applicable verify if the brochure ratings are listed with or without an optional tow package RV BRAKE SYSTEM AN WARNING Failure to maintain the brakes in proper working condition as specified in the operators manual supplied by the axle OEM will cause property damage personal injury and possibly death Consult with your dealer for assistance The electric brakes are designed to work with the tow vehicle brakes To maintain proper braking performance both the RV and tow vehicle brakes must be used together Separate use of the braking systems will cause accelerated wear and damage When your RV is new it is impossible to adjust the brake shoes precisely It takes approximately 1 000 miles and or 50 medium to heavy stops to burnish fit or seat the shoes to the brake drum After the initial break in period your brake shoes must be adjusted accurately for best performance and increased durability Braking system components include Tow vehicle battery Brake controller Wire harness c
200. vehicle transmission and engine will help in controlling downhill speed and can lengthen brake life The distance required to stop the RV is greater than an automobile s Use care when accelerating or decelerating on a slippery surface Abrupt speed changes can cause skidding and loss of control Driving through water deep enough to wet the brakes may affect stopping distance or cause the vehicle to pull to one side Check the RV s brake operation in a safe area to be sure they have not been affected Never operate any vehicle if a difference in braking efficiency is noticeable Vehicle Clearance Remember some bridges older ones in particular may not support the weight of your tow vehicle RV combination Know the weight and size of your towing combination and observe any posted weight and clearance limits The added height of roof air conditioners TV antennas or floodlights may cause clearance problems around some tunnels canopies and hanging signs Turning Corners When turning the tires do not follow the path of your tow vehicle tires The RV will make a tighter turn than the tow vehicle You must compensate for this action by carefully pulling the tow vehicle out into the intersection further than you would normally so that the RV clears the curb or any parked vehicles along the curb When making a turn check the road clearance and be aware of others Have someone help guide you out of a difficult parking space or traffic patte
201. vide any vehicle repair history to the dealer s service manager Keep a maintenance log of your RV service history This can often provide a clue to the current issue Be reasonable with your requests If you leave a list with several items and you need your RV returned back by a specific time discuss the situation with the dealer s service management and list your items in order of priority This may include making a second appointment for work not completed or parts that the dealer may need to order Don t expect to look over the technician s shoulder Please do not be offended if you are told you cannot watch the work being done Some insurance requirements forbid admission of customers to the service area Inspect the work performed Finally check out the service or repair job when you pick up your RV Notify the dealer s service management immediately of any dissatisfaction If you cannot return your RV immediately for repair make an appointment as soon as possible Please be aware that all repair businesses require notification of any issues with their repairs within a specified time limit Make sure you are familiar with your dealer or RV repair center s repair policies CUSTOMER RELATIONS Jayco has empowered its dealers to make warranty and repair decisions If a special circumstance occurs that requires information from Jayco we have asked your dealer s service management to make the contact on your behalf This
202. w vehicle cruise control on icy or extremely wet roads winding roads in heavy traffic or in any other traffic situation where a constant speed cannot be maintained WIRE HARNESS CONNECTOR PLUG A 7 way wire harness connector plug is wired into your trailer to connect electrical power from the tow vehicle for travel This supplies power to the RV brakes tail lights clearance lights turn signals brake lights etc Wiring to operate your brakes must be the same size in both the tow vehicle and RV the RV brake wiring is 12 gauge wire When attaching wires to your tow vehicle carefully and tightly tape all the connections for moisture protection White 1 Ground Blue 2 Brakes Green 3 Running lights Black 4 Auxiliary battery charge line Red 5 Stop amp left turn Fig 4 1 Brown 6 Stop amp right turn 7 way trailer plug Car end rear view Yellow 7 Back up The connector plug may build up corrosion with extended use and should be cleaned periodically to insure good electrical contact Make sure the connector plug is kept clean and protected from road elements as you travel TOWING A WARNING Your RV braking system is rated for operation at GVWR not GCWR A WARNING Whenever possible do not travel with waste in the holding tanks Liquid or debris in the holding tank s may affect the towing characteristics and may result in property damage or personal injury
203. wo stage regulator 2 Attach the regulator with the Z bracket on the center of the front wall with the vent pointing down 3 Attach the protective plastic cover to the regulator 4 The regulator has a 90 elbow that directs the inlet toward the trailer curbside 5 Place the cylinder on the bracket provided on the A frame and position it so the outlet of the cylinder valve is pointed directly outward to the curbside wall 6 If a vinyl cylinder cover is provided slip it over the cylinder and leave the zipper open if so equipped 7 Attach the 1 4 inverted flare x 24 Type 1 pigtail hose to the regulator inlet and the right hand swivel nut to the cylinder valve 8 If applicable close the cylinder cover zipper if so equipped up to the hose 9 Secure the cylinder to the A frame bracket using the bolts nuts and washers provided 7 5 SECTION 7 FUEL SYSTEM JAYCO TOWABLE Double Cylinder Mounted On A Frame if so equipped When a second cylinder is installed a tee check valve is used to replace the 90 elbow at the top of the regulator and another 1 4 inverted flare x 24 Type 1 pigtail is added The regulator stays in the original position Flexible Pigtail Hose Fig 7 6 Double cylinder Cylinder Collar 1 Place the second cylinder on the A frame bracket so the cylinder valve is pointed to the roadside of the folding camping trailer 2 Secure the second cylinder to the A frame using the bolts n
204. ystem that is designed for vapor only creating a hazardous condition AN WARNING If you suspect your propane container has been overfilled contact your independent Jayco dealer or a qualified propane technician for assistance immediately Do not attempt to service a propane container overfill yourself 7 4 JAYCO TOWABLE SECTION 7 FUEL SYSTEM The following label should be kept permanently affixed to your RV NOT FILL PROPANE CONTAINERS TO MORE THAN 80 PERCENT OF CAPACITY FAILURE TO COMPLY COULD RESULT PERSONAL Fig 7 4 Do not fill to more than CAUTION 80 label THIS PROPANE PIPING SYSTEM IS DESIGNED FOR USE WITH PROPANE ONLY DO NOT CONNECT NATURAL GAS TO THIS SYSTEM Label appearance may not be exact Securely cap inlet when not connected for use After tuming on propane except after normal cylinder replacement test propane piping and connections to appilance for leakage with soapy water or bubble solution Do not use products that contain ammonia or chlorine Refer to your Warranty Packet for more information on the LP gas system components INSTALLING PROPANE CYLINDER S A WARNING Ensure that all fasteners are secured before travelina Single Cylinder Mounted On A Frame if so equipped Pigtail Hose Regulator Acme Connector Cylinder Fig 7 5 Single cylinder 1 Connect the 3 8 low pressure hose to the outlet of the t

2016 Jay Flight Bungalow Manual

Contents

Download Pdf Manuals

Related Search

Related Contents