User Manual - Comkit Online
Contents
1. WARNING BE CAREFUL to never insert utensils metal objects or other rigid or sharp materials in the basket as it is dangerous and could cause injury During maintenance procedures and while unpacking do not hold or lift the appliance by the locking arm of the juicer cover When cleaning the appliance use care in handling the basket so you do not alter the alignment or reduce the performance of the appliance Do not use the appliance if it is damaged or has loose parts Immediately contact an authorized Service Center Do not push fruit or vegetables into the feed chute with your fingers Always use the food pusher provided Do not touch the sharp teeth of the grating disc Do not insert fruit with stones e g peaches apricots etc without first removing the stone On model with two feed chutes never insert the 50 pusher in the 75 chute WARNING DO NOT PUT FINGERS OR ANYTHING OTHER THAN THE APPROPRIATE FOOD PUSHER PROVIDED WITH THE APPLIANCE INSIDE THE FEED CHUTE ALWAYS USE THE FOOD PUSHER TO PUSH THE FRUIT TOWARDS THE ROTATING GRATING DISC SAVE THESE INSTRUCTIONS c6 INSTALLATION Comply with the safety recommendations indicated above and hereafter when installing the appliance 1 Make sure that the mains voltage is as indicated on the rating label of the appliance and that the electrical system is grounded and equipped with a switch 2 Install the appliance in a DRY PROTECTED place far from water s2. TO MAKE ANY ALTERATIONS TO THE APPLIANCE WITHOUT NOTICE a a sa a s saks asxgx x lt o FlDs00rs rers krrt Cod 80412
3. different consistencies it is a good idea to start with the softer ingredients and then subsequently use the harder ingredients When you make juice from herbs or lettuce you should press them together to form compact balls or mix them together with other ingredients to obtain a better result NOTE Herbs and lettuce give a low yield of juice This is due to the characteristics of the produce and of the juice extractor It is therefore advisable to always make juice from herbs and lettuce mixed together with other fruit or vegetables Different types of fruit and vegetables yield different quantities of juice The amount of juice varies even between fruit and vegetables of the same kind for example two apples of the same variety and with the same weight can produce different quantities of juice Given the fact that juice recipes are not an exact science using precise guantities of ingredients for each juice recipe is not a determining factor for the successful outcome of the recipe NOTE To obtain a high yield of juice always press the food pusher lightly TROUBLESHOOTING See Table on the next page In case of any malfunction defect of the appliance or if you suspect any breakage after a fall unplug the appliance immediately If you are unable to solve the problem referring to the table below contact an Authorized Service Centre Only gualified experts should repair the appliance We are not liable for any damage caused by repa
4. CEADO JUICE EXTRACTOR INSTRUCTION AND MAINTENANCE MANUAL Distrubuted in Australia by Roband Australia Pty Ltd JUICE EXTRACTOR This is a commercial juice extractor for the preparation of fruit and vegetable juices with automatic pulp ejection Like all appliances it should be used with particular care to avoid injury to personnel and damage to the appliance It is essential to read these instructions carefully before using the appliance and to follow the safety recommendations A Do not use the appliance if you have not read and understood these instructions JUICE EXTRACTOR Main parts Fig 1 Fig 2 1 Motor housing 9 Basket 2 Bowl 10 Pulp retainer 3 Spout 11 Grating disc 4 Juicer cover 2 Start button 5 Locking arm 13 ON OFF I O button 6 Food pusher 14 Motor shaft 7 Feed chute z 15 Drive disc 8 Pulp container 7 Not standard equipment on all models Fig 2 Fig 1 Model ES500 with feed chute 75 mm a Model ES700 with double feed chute Model ES300 with feed chute 50 mm g 50 g 75 mm 2 ae 50 mm Lf u oe J a 5 Fig 3 Model ES500 with feed
5. FEED CHUTE OR TO CLEAN THE CHUTE ALWAYS USE THE FOOD PUSHER PROVIDED 8 The juice will pour from the spout into the container placed below the spout The separated pulp will accumulate in the pulp container 9 Continue to use the appliance until the container is filled with juice or until you have finished the fruit or vegetables you are using or ensure the pulp container has become filled with pulp 10 Turn the motor off by pushing the ON OFF button in the OFF position Note Always wait until the motor has come to a complete stop before unhooking the locking arm A Never use the locking arm to turn the appliance off This could wear out the safety mechanisms safety microswitch and motor brake 11 When the appliance is not in use leave the locking arm hooked to the juicer cover and the ON OFF button in the OFF position A When using the appliance control the level of pulp in the pulp container with the motor turned off The quantity of fruit or vegetables that can be used before the pulp container is filled varies depending on the type of fruit or vegetables used A Should blockage occur while the appliance is in use before the pulp container is filled with pulp it is a good idea to turn the appliance off and find the cause of the blockage NOTE When using the juice extractor the pulp container can be emptied by turning the appliance off and carefully removing the pulp container Put the pulp contain
6. an easily encrust or obstruct the perforations you should frequently clean the basket THE BASKET HAS SMALL SHARP TEETH DO NOT TOUCH THE TEETH WHEN YOU HANDLE THE BASKET Do not use abrasive products or sponges to clean the basket Do not let traces of fruit or vegetables dry and harden on the pulp container basket juicer cover or food pusher Never use bleach or chlorine based cleaning products on the juice extractor O Fora periodic deep cleaning you can disassemble the parts of the basket by unscrewing the nut under the basket Fig 9 To disassemble the parts of the basket hold the basket still with one hand and unscrew the nut with a pipe wrench number 13 Fig 9 Pull the screw out of the basket Wash all of the parts in warm water with dish soap removing any residues with the brush provided Reassemble in reverse order Fig 9 and make sure that the base of the basket is mounted with the outer edge turned down To reassemble the parts of the basket tighten the screw to the nut with a pipe wrench number 13 Ensure that the parts are tightly attached to one another INFORMATION ON FRUIT AND VEGETABLE JUICES Freshly made juices should be consumed immediately following their extraction to obtain maximum vitamin content PURCHASE AND STORAGE OF FRUIT AND VEGETABLES Always wash fruit and vegetables before juicing Always use fresh produce To save money and obtain higher quality juices always use fruit and vegetables
7. ccording to the instructions in this instruction and maintenance manual Please retain any receipt as proof of purchase During the warranty period this product can either be repaired or replaced at the manufacturer s discretion at no additional cost If the product needs maintenance or repairs during the warranty period contact your retailer for shipping instructions The product should be shipped in its original package or other suitable packing The warranty does not apply in case of neglect misuse abuse or unauthorized repairs This warranty does not apply to parts subject to deterioration through normal use such as wear to the basket the grating disc etc This warranty does not apply to damage caused by foreign objects substances or accident The warranty is limited to the costs of repair or replacement of the product or its defective parts or an amount equivalent to the price paid for its purchase No additional requests of damages will be available to the purchaser This guarantee is in addition to and does not affect your statutory rights The manufacturer will not accept any liability and the warranty will be invalidated if there is a failure to follow these instructions and the technical and or safety standards in the country where the appliance is to be used In any case these instructions cannot cover every possible event and the user is recommended to use the appliance responsibly THE MANUFACTURER RESERVES THE RIGHT
8. chute o 75 Model ES500S with feed chute 50 mm w 2 75 mm lt 9 50 mm j e oo Fig 4 SAFETY RECOMMENDATIONS GENERAL INSTRUCTIONS Read the following instructions carefully before using the appliance 2 Installation and maintenance should be carried out by qualified personnel only 8 This appliance is intended for professional use and should therefore be used by adults and gualified personnel only CLOSE ADULT SUPERVISION IS NECESSARY WHEN CHILDREN ARE NEAR THE APPLIANCE 4 Never use this appliance for purposes other than extracting juice from pieces of fruit and vegetables Any other use is dangerous 11 C55 Always work under safe conditions do not use the appliance with wet hands or feet Do not use outdoors Keep the original package for possible future use It is the most suitable protection against damage during transport In case of fire use CO gt extinguishers Do not use water or powder extinguishers Never place the appliance in water Do not clean with the use of a Water Jet Do not disassemble the appliance or attempt to perform any repairs inside it Always unplug the appliance before performing any maintenance or cleaning and when it is not in use Never pull the appliance by the cord to move it Never unplug it by pulling the cord or touching it with wet hands A If the cord is damaged it must be replaced by an Authorized Service Center 12 13 14 15 16 17 18 19
9. er in place before turning the juice extractor back on Fig 6 CLEANING AND MAINTENANCE Suggestions to reduce the cleaning procedures to a minimum we suggest placing a biodegradable plastic bag inside the pulp container folding the top of the bag over the edge of the pulp container see Fig 5 By using this method once you have finished using the appliance you can put the waste directly in a composting or waste bin A Before each cleaning turn the appliance OFF and remove the appliance s plug from the socket or turn the socket off By keeping the appliance well cleaned and in working order you can maximize the quality of the juice extracted and guarantee a longer life for the appliance itself For this reason after every use you should clean the basket bowl juicer cover pulp container pulp retainer and food pusher so that residues do not harden and encrust the appliance O To clean the motor housing clean with a cloth dampened with water or alcohol or with a spray neutral solution Wipe with a dry cloth A Never put the motor housing under running water and never immerse in water O To clean the juicer cover bowl basket pulp container pulp retainer and food pusher rinse under running water and wash with warm water and washing liquid Rinse and dry Not standard equipment on all models ED To disassemble these components unhook the locking arm and remove in this order food pu
10. irs not made correctly and or by unauthorized personnel In these cases the warranty does not apply Problem Solution The appliance does not turn on Make sure the feed chute is empty Make sure it is plugged in Make sure the safety circuit breaker is closed Make sure the locking arm is correctly hooked onto the juicer cover Make sure the start button on the appliance is turned ON If the problem occurs itself after a long period of intensive use or overfilling the motor could be in thermal protection lock Wait at least 20 minutes and try again The waiting time can be reduced by putting the appliance in a cool place The appliance vibrates in an abnormal manner The vibration can be caused by Incorrect positioning of the basket Check alignment Deterioration of the structural components of the basket Check and replace if necessary e Accumulation of pulp in the basket Check and empty pulp if necessary Full container Juice does not come out of the spout Blockage of the basket Check and clean the basket The opening of the spout is blocked Check and clean the bowl and spout Use of fruit that has too much pulp or is too ripe Check and clean the bowl and basket Excessive accumulation of pulp in the basket Try to alternate between soft and hard fruits when using the juice extractor Pulp appears excessively wet and a low quantity of juice is produced Tr
11. prays or splashes heat sources open flames and inflammable substances Place the appliance on a flat horizontal stable surface where it cannot tip over 3 Make sure the switch on the appliance is in the OFF position and plug it into a socket protected by a suitably rated circuit breaker MCB or fuses Do not use an adaptor plug 4 Stretch the power cable out to full length Do not let it pass over sharp edges or hot surfaces Do not let oil spill on it Do not let the power cable hang loose from the counter on which the appliance stands 5 To use the appliance more easily we suggest that the appliance is placed on a table or counter top so that the juice spout and the controls face towards the right side of the user suggested height for counter top from a round level 90 cm 36 inches to be adjusted according to the height of the user USE A A A _ 1 KI Make sure the tabletop and feet are clean to ensure grip during operation Before first use rinse all of the parts that will have contact with food in running water i e food pusher juicer cover basket bowl pulp container and pulp retainer To disassemble the various parts see Fig 8 and Fig 9 Not standard eguipment on all models Suggestions to reduce the cleaning procedures to a minimum we suggest placing a biodegradable plastic bag inside the pulp container and folding the top of the bag over the edge of the pulp container see Fig 5 By u
12. sher juicer cover basket pulp retainer and bowl Fig 8 Reassemble in the reverse order taking care to place the juice spout in the appropriate slot of the motor housing place the pulp retainer in its correct place with the internal edge facing up Fig 8 place the basket in the bowl making sure that the basket s clutch disc is correctly inserted on the drive disc and position the juicer cover on the bowl Not standard eguipment on all models The removable parts of the juice extractor with the exception of the pulp container are dishwasher safe The pulp container should not be immersed in hot water Hot water can deform the pulp container making it impossible to use To obtain a higher yield of juice always control that the basket is well cleaned by using the nylon brush provided Put the basket under running water and use the brush to clean the inside of the strainer see Fig 7 Hold the basket up against the light to make sure that none of the perforations are blocked Should the perforations of the strainer remain blocked immerse the basket in a solution of hot water with 12 lemon juice or vinegar to loosen the blocked material Alternatively wash the basket in a dishwasher Handle the basket with care as even the slightest damage to the pulp container can cause the juice extractor to vibrate undesirably during use Fig 7 gt Pe P As some products such as peeled citrus fruits celery and tomatoes c
13. sing this method once you have finished using the appliance you can put the waste directly into a composting or waste bin Wash the fruit or vegetables you will use NOTE Many types of fruit and vegetables for example apples carrots and cucumbers fit through the feed chute without having to be cut into pieces When you make juice from carrots it is a good idea to insert the larger end of the carrot first or to cut the carrot in two or three pieces For models with feed chute 50 mm use the latter to juice carrots To optimize the juice output chop fruit into smaller pieces Ensure that the juice extractor is correctly assembled Ensure that the basket is properly cleaned before each use Check to see that the ON OFF button is in the OFF position and that the locking arm is hooked on to the juicer cover Place a container under the spout of the bowl Turn the appliance on by pushing the ON OFF button in the ON position Turn on the motor by pushing the start button q 5 m With the motor in action put fruit and or vegetables in the feed chute Use the food pusher to gradually push down the fruit and or vegetables towards the spinning grating disc at the bottom of the feed chute without exerting excessive pressure see Fig 6 To obtain more juice always press the food pusher lightly san i Fig 5 A NEVER USE YOUR FINGERS TO PUSH THE FRUIT AND OR VEGETABLES DOWN THE
14. that are in season Always keep produce ready to juice by washing it before putting it in the refrigerator Most fruit and vegetables can be kept at room temperature Delicate fruit and vegetables such as tomatoes berries lettuce celery cucumbers and herbs should be kept in the refrigerator until use Do not use overly ripe fruit because it clogs the basket very quickly PREPARATION OF FRUIT AND VEGETABLES Fruit or vegetables with a hard or inedible skin or rind such as melon pineapple mango kiwi etc must be peeled before being inserted in the juice extractor All citrus fruits must be peeled be fore being inserted in the juice extractor Remove the stones from fruits such as peaches apricots plums etc before inserting the fruit in the juice extractor A small quantity of lemon juice can be added to apple juice to prevent discoloration Suggestions the juice extractor also gives a high yield of juice from oranges Remember to always peel oranges and all citrus fruits before inserting them in the juice extractor we also suggest putting the oranges in the refrigerator before use Screw i Grating disc Internal edge turned up x Outer edge turned down CCD Clutch disc Washer B vut AR Fig 8 Fig 9 Not standard equipment on all models 125 RECOMMENDATIONS FOR PROPER USE When you make juice from different types of ingredients with
15. y to insert the fruit or vegetables more slowly and with less force Make sure that the basket is always carefully cleaned with the nylon brush provided Put the basket under running water and use the brush to clean the inside of the strainer see Fig 7 holding the basket up against the light to make sure that none of the perforations are blocked Should the perforations of the strainer remained blocked immerse the basket in a solution of hot water with 12 lemon juice or vinegar to loosen the material that blocked them Alternatively wash the basket in a dishwasher Fruit too ripe DISPOSAL Correct disposal of this product waste electrical and electronic equipment Applicable in the European Union and other countries with separate collection systems This product has been made from high quality parts and materials which can be re used and recycled Therefore do not throw the product away with normal household waste at the end of its working life Take it to a collection point for recycling electrical and electronic devices This is indicated by this symbol on the product and in the operating manual Please contact your local government office for information about the exact location of the closer collection point WARRANTY This product has been manufactured to a high quality standard This product is guaranteed against faulty materials and workmanship for a period of one year from the date of purchase when it is used a
Download Pdf Manuals
Related Search