OWNERS AND SERVICE MANUAL
Contents
1. OWNERS AND SERVICE MANUAL INNOVATIVE CONCEPTS IN ENTERTAINMENT INC TABLE OF CONTENTS SAFETY AND WARNINGS 7 Before You Begi 1 Installation ar GAME SETUP AND FEATURES form Assembly ADJUSTMENTS amp AUDIT MENU SYSTEM Main Menu Operator Adjustments Game Adjustments adjustments aver Cost Payout Volume General Audite Game Audits Ticket Audits System Audite Cain Audits Reset Menu System Te MAINTENANCE the Computer Adjustments Deal No Deal and Sut case Buttons and bulbs ide Light Replacement stem Wiring both TiO and 220v Spare Parts Lt Reva n n w E SAFETY AND WARNINGS BEFORE YOU BEGIN WARNING WHEN INSTALLING THIS GAME A GROUNDED AC RECEPTACLE MUST BE USED FAILURE TO DO SO COULD RESULT IN INJURY TO YOURSELF OR OTHERS LURE USE A GROUNDED RECEPTACLE COULD ALSO CAUSE IMPROPER GAME OPERA TION OR DAMAGE TO THE ELECTRONICS DEFEAT OR REMOVE THE GROUNDING PRONG ON THE POWER CORD FOR THE SAME REASON AS GIVEN ABOVE USING AN IMPROPERLY GROUNDED GAME COULD VOID YOUR WARRANTY HAVE A QUALIFIED ELECTRICIAN CHECK YOUR RECEPTACLE TO BE SURE THE GROUND IS FUNCTIONING PROPERLY INSTALLATION The game comes ready to play with just few simple things to keep in mind 1 Pug the game into the cult and tum on power to the game The switch for the game locate power module on he outside raar of he2. 2 Make sure the game is level aftr installato Lis necessary to make sure the game i love tor safely cancers Check that the AC voltage rating on the back of the game matches the voltage of Your locaton WARNING DO NOT remove any ofthe components on the main board e g compact Nash and eproms while the game is powered on This may cause permanent damage he the main board Removing any main board component part while powered fon wil void the warranty NOTE THIS GAME IS INTENDED FOR INDOOR USE ONLY ON THE BACK PANEL OF THE GAME WARNING SHOCK HAZARD DO NOT OPEN REFER SERVICING TO SERVICE PERSONNEL GAME SETUP AND FEATURES Player Controls To begin the gama insert the proper number of credits DEAL OR NO DEAL is a one payer Solo DEAL or DOUBLE DEAL to begin the game Selecting Double Dea dou bia the amount of cel Playing the Game The abject af the game ie to wind up with the highest value deal as possible The player se lacs hamer case Then the payer must determine which casas hold th lowest Value By selecting he casas the player potential values Round 1o round the Banker wil offer a value that the player enttied o ako If deal taken he game dis penses ha value in ticket andthe game enda If fe player does no he Bankera value toughout ie game hosha left with he value inside Nor case Tha Sama wil dis
3. UE DB PULSE DEFAULT 1 00 the aul cats noe s MAXIMUM CREDIS DEFAULT 500 00 E alba game pore De put CREDIT VALUE Coins Ony DEFAULT 025 when com as he curency ther opion ra cet ae ha slow he operator sean arate aE worn ony 905 cet wou be DIAGNOSTIC ADJUSTMENTS amp AUDIT MENU SYSTEM e game can be set o PAY UP FRONT where ere PAY PER ROUND whe an pic can e A ach round of y and he payer pompe ter mre manay abn game queso Pav Up Pont Pay PER ROUND GAME START cost DEFAULT 1 00 Eolo slari ha gre FREE max 2500 START COST DOUBLE DEAL DEFAULT 200 fne te mode Ie sarne as e regular game except at al te payout values we cute cat the Dounia game shoul amos alus e game Tin FREE max 2540 meer VALUE DEFAULT s001 evalu a a teket in reiaton oe tte tat rg 8 which iri S000 100 seca Rea a THE FOLLOWING ADJUSTMENTS ONLY APPEAR IF SET TO PAY PER ROUND ROUND 2 COST DOUBLE DEAL DEFAULT FREE ROUND 3 COST DOUBLE DEAL DEFAULT FREE ROUND 4 COST DOUBLE DEAL DEFAULT FREE aparator hs ose vital cu or och under pay prit round elo FREE t player aive i al round ee DIAGNOSTIC ADJUSTMENTS amp AUDIT MENU SYSTEM Pega ole min O max 32 ola oh trat mode fin O
4. chased the Deluxe version of Deal or Na Deal you wil need to attach the siol olo the base by Mtng the bottom callar ring up on fhe stool and exposing the four mounting holes See pictures below Insert four washers and four balts through the mounting holes and ighlan Soo diagram below Replace the collar Sco picture below Platform to Cabinet Assembly Now attach stool assembly to tha podium by removing the front bottom bezel Now side the stool assembly into the cabinet and attach two mounting screws on bath Sides See pictures below and diagram on the nex page GAME SETUP AND FEATURES Platform to Cabinet Assembly cont DIAGNOSTIC ADJUSTMENTS amp AUDIT MENU SYSTEM ust various game pay operan stings esa gto utr system testsiiagrostes Sas game songs lh currency pe coin swich values Sali of a garne andthe levai ot payout re Te number of kets per pay he amoun of imme that he user has to make an input beore he game makes an singu e rages ton 20 seconda rin er ptas given oU BY e game con a eld at ihe TICKETS or COUPONS Sse DIAGNOSTIC ADJUSTMENTS amp AUDIT MENU SYSTEM sow fe game tote played wihout rs Ei twos covet vier CURRENCY UNT VALUE DEFAULT 025 vate ofa red com vatur DEFAULT 025 the artes gen by one pe con 2vaLuE DEFAULT 025 1e amaun onda gen by one ue 3 VAL
5. e the pas retainer cips and press ne red butona to eet the bulbs Replace in reversa onder See Red cle below Maintenance Monitor Enclosure Monitor Replacement access he monitor remove he six on screws shown below Remove he front plate and bezel Now remove ne mounting screws that hod ina montor othe abl fet See diagram Blow Speaker Replacement The speaker is accessed through the front of te assembly as shown below Unscrew the fur screws and remove the or cover Now remove he wo nuis haking the speaker to the speaker housing Unplug the speaker wire connection Assembly reverse See diagram below use at laste nat use ammonia based glass dearer car sate res Doing cuss te ate ba vera perot c tme Joy ona cans ae Nowe cleaner maken pecia pst cleaner Bi atate bl up are a ga ine back the ane Maintenance Monitor Enclosure Monitor Adjustments The conto of he manor are accessed through the back ofthe monitor cab rect undemeath the tack abel The configuration of the butions are in the fern printed Soo pictura below Maintenance Buttons Deal No Deal buttons Bulbs The Fluorescent bulbs 110V ac and should only be replaced with the power off nol replace with incandescent type bulbs as the socket is nat designed for this and fre hazard When replacing use ICE Part numbers 8980 red and B981
6. mix 32 he lowest el iat oth tha pare and act made can esata 0 max 32 New requnly sounds wl ply when SETTINGS OFF OCCASIONALLY ALWAYS Sci orl number t pigs garne ima rh uber fiche won average et outs for play up ime ele DIAGNOSTIC ADJUSTMENTS amp AUDIT MENU SYSTEM faa rumbero games payed Toro tardar garnas pays unter Doce Des ges layed or fis o Player ha won Ba highest pon vu Tiber c nee e Payer has won he lowest possi vau ttn serge spectes in minutes ne cuml ne game has een layed uber anes ayers have chosen he Dear amber cl es players have chosen No Dea eto number kts out by Ihe game he average number iio en ech game ihe payout he game Ns number changes a pore lay gre sna he gare vies 1o get a value a done o he pent pss TOTAL TICKETS 500 GAMES het numberof kate Pd Ie past 500 games AVG TICKETS 500 GAMES he average number kat gue out during past 50 games PAYOUT PCT so GAMES he payout patents t Pe pas 500 games ow many teat are curet owed to Be player he ruber wil be non zero if are as teen some Kind cel mache ula eel at jun DIAGNOSTIC ADJUSTMENTS amp AUDIT MENU SYSTEM tol pa tnelogge game engi he gane has been powered on namber fines he game hs force tai reset power he namber of times
7. ng them Replace the power supply with same type of unit and reconnect wires matching their previous locations han install the wo mounting screw To adjust the power supply turn the adjustment located at the bottom of he power supiy unti 5 is between 4 95 5 10 measure the power supply s voltage place na positive lead on the red wire and the negative lead on the black wire Set your meter to DC voltage See pictures below Maintenance Main Board and I O Replacement To Remove the main board unplug the JAMMA connector serial cable P2 audio ca ble PB and p1 Now remove the four plastic hex nuts Assembly in reverse To remove the VO board unplug connectors J2 33 J4 J8 J6 J7 and Re move the four plastic hex nuls Assembly in reversa Tian Board TO Board Maintenance Platform Light Bulb Replacement Remove the twa strips shown below to access the screws that hold he floor to he sage Now remove the oor You can now access fa fuorascent bulbs To replace bulbs 2 3 and 4 press the red bution remove the plastic retainers Ift up and side out as shown below To replace bulbs 1 and 5 press the red button remove the plastic retainers and ift up and out as shown below Maintenance Marquee Bulb Replacement To replace he fuorescan bubs inside he marquee remove the back panel by remov ing the upper and lower ats rom behind oniy The ar mounted onto Ihis panei Remov
8. o replace tha color sips with the correct color To access the Strips remove the back side panels The LED strips are mounted on this panel Refer to the diagram below for correct pari numbers when ordering ICE Part numbers DN8978x RED DN8979X BLUE QTY 4 per game Spare Parts Listing Mechanical Machine Sales Telephone 44 0 208 391 8090 Fax 44 0 208 391 8099 www sega amusements co uk SEGA Spares Telephone 44 0 208 391 8060 Fax 44 0 208 391 8096 www segatotalsolutions com Customer Services Telephone 44 0 208 391 8065 Fax 44 0 208 391 8096 PGi i Gi i GiGi Gigi AT A
9. pense the value cf ckets n Hisper case andthe game ends Initial Game Setup The game is setup at te factory wih the recommended factory setings The setings may be adjusted by accessing the system Tho game s menu system s a senas of on screen menus hat alow the operator to setup or adjust the setings Each menu provides ne aby to adusta specie seting or access another manu other game setings To access tne mena system press the program buton inside the coin door The main mona wil appear on he game sereen navigate menu system use volume up io sero up and vol down to serali down To select menu option use the program buton the volume Up and doen buttons to scrol rough the seting levels on specie menu screens Use he program buton select and save desired seing ievel Assembly Main cabinet to podium and speaker mount Start by attaching al electrica connections frst Now slide the glum to the main cabi ot and atach e side mounting brackets with hree mounting screws attach e side Speakers the man cabinet frat connect he vo wire connectar the speaker Then In Sia tma two cp and botom bats Finally instal he hree back wood screw complete the mounting af he speaker unit See dagrams below and on the nent page GAME SETUP AND FEATURES Assembly Main cabinet to podium Hardware GAME SETUP AND FEATURES Stool to Platform Assembly you pur
10. the game detected sotiare error type he numba of ies he game has detected a state errer or ype 2 Bv ai ene read by counter ll se or lil esa me game sud ll playa curent payout le Tesei he number of cedi curent he garme ese e qme armes game eos aes pao t ese al ome cet con unten and ikl DIAGNOSTIC ADJUSTMENTS amp AUDIT MENU SYSTEM Gain he stare versns or he pane ash coin counters tut vo test and servos buon peor a sees ol sereen tasis such a color and adjustment sais ot tast sound Lo diagnose austo probleme partam a test to vadat a fh used by game erhe stle ei sites on the board Tena reset cpt lh NOTE tnis reset he game Partar ave lame test or e 1 case buttons and Dei No Deal butions Maintenance Access the Computer CDROM Dive Power Fuse Located in the power modula is a 6 amp slow blow fuse To check or replace the fuse pul the tab with the label out There is only one fuse installed See diagram below Maintenance Power Supply Adjustment Replacement The power suppl is accessed hugh the back of the game Remove the back door panei to gan access tothe power supp To replace the power supply remove the two mounting screws and all wires connecting lo the power supply note in which wires ga into which connector before i
11. white access the bulbs remove the two swiiches holding the metal bracket with 1e bub socket on it Now side the bracket out and replace the bub Assemble in reverse See diagram below Switches The MEGA switch is made up with four smaller switchas acing as one When replac ing the switch itis important to connect the normally open lead of he switch and round No wire should connect to Normal closed When testing switches your me lar should read less then a ohm with it set to ohms test There two different sch assemblies used ICE number DN2OOGR red and DN2008V wbite Suit Case Buttons Bulbs and Switches The bubs used in the suit cases 12vo DC LEDs They are glued in the socket cannot be removed You must replace this as assembly The ICE part numbers are DN2004S01 through DN2004516 These are connected Normally open and no should be connected to Normaly closed lead When testing switches your meter should read less then a ohm with it set ta ohms test The positive wire orange must Connect 1o the lead on the LED bulb The yellow with color stip isthe on the LED bulb The Yellow start butions are DN2005DD double deal and DN20055 Deal Maintenance Cabinet Mood Lighting Side Light Replacement Your cabinet changes color depending on the action ofthe game To accomplish this LED technology is used There are three separate colors of LED strips which look the same tis important t
Download Pdf Manuals
Related Search