Dirt Devil FD50110 Use and Care Manual
Contents
1. CARPET WASHER Model s FD50100 FD50105 FD50110 oX 1 2 3 MANUAL 961151127 1D109742 RO 2014 All rights reserved LET S GO HI WELCOME Congrats on purchasing your new Dirt Devil Carpet Washer Inside you ll find everything you want to know from the quick start guide to how to So what are you waiting for LET S GO PRODUCT Oo REGISTRATION Warranty Registration Be sure to register your product online at www DirtDevil com or call 1 800 321 1134 to register by phone Hint Attach your sales receipt to this Owner s manual Verification of date of purchase may be required for warranty service of your Dirt Devil product For quick reference please record your product information below Model Mfg Code Mfg code located on the back or bottom of product Find GENUINE Replacement Parts at www dirtdevil com This product uses the following parts BELT STYLE 30 PRE M OT OR FILTER F 92 TABLE OF CONTENTS 12 3 Quick Start Assembly s Preparing the Carpet Hovv to Remove and Replace Clean Water Solution Tank Empty the Dirty Water Tank Place Dirty Water Tank in Base of Cleaner Remove the Brushroll Replace the Belt O Trouble Shooting Limited Warranty 10 12 14 15 16 17 18 19 A WARNING A IMPORTANT READ CAREFULLY BEFORE ASSEMBLY AND USE THIS PRODUCT IS INTENDED FOR HOUSEH2. unplug cleaner before servicing Do not use any chemicals when cleaning Hook the front of the tank into the base Make sure the tabs on the bottom of the tank are latched Now place the rear of the tank into the base of the cleaner Push handle down until it clicks A CAUTION To reduce the risk of injury from moving HI OW TO parts unplug cleaner before servicing Rotate brushroll manually to make sure belt is not twisted or pinched REMOVE THE BRUSHROLL Note Be sure to switch off the unit unplug amp remove the clean amp dirty water tanks before servicing 1 Flip your carpet washer 2 Use a Phillips screwdriver on its side like this to remove the 3 screws here Now pull cover off 4 Keeping tension on 4 Replace belt cover and the belt use two hands secure with the three to lift the brushroll up screws and out For Belt Style 30 replacements please call 1 800 321 1134 or visit our website at www DirtDevil com to locate a dealer nearest you REPLACE THE BELT 1 Take off cover Refer to 2 Place the new belt on page 16 Remove and the motorshaft then slip toss the old belt out it in the area without brushroll bristles 3 With belt in place pull and 4 Replace belt cover and slide brushroll into the secure with the three nozzle making sure that screws the brushroll ends are in the correct orientation A i JE g Any other servicing should be done by an a
3. hard sharp objects with this product as they may cause damage Store in a dry place Do not expose machine to freezing temperatures Do not use sharp objects to clean out hose as they can cause damage To assist in reducing drying time be certain the area is well ventilated when using detergents and other cleaners with this machine To help prevent matting and resoiling avoid contact with carpets until they are dry Keep children and pets away from carpets until they are completely dry Do not store extractor with solution in tanks With brushes on do not allow cleaner to sit in one location with brushes on for extended periods of time as damage to floor can result DO NOT USE THIS EXTRACTOR ON HARD FLOORS USING THIS MACHINE ON HARD FLOORS MAY SCRATCH OR DAMAGE YOUR FLOOR SAVE THESE INSTRUCTIONS GROUNDING INSTRUCTIONS This appliance must be grounded If it should malfunction or breakdown grounding provides a path of least resistance for electric current to reduce the risk of electric shock This appliance is equipped with a cord having an equipment grounding conductor C and grounding plug A The plug must be inserted into an appropriate outlet B that is properly installed and grounded in accordance with all local codes and ordinances A WARNING A Improper connection of the equipment grounding conductor can result in the risk of electric shock Check with a qualified electrician or service person if you are i
4. H JUST CLEAN or Sat 10 00 a m 6 00 p m EST WATER FOR RINSING Pick up the conversation on EMPTY DIRTY WATER E TANK WHEN FULL Ei Facebook com DirtDevil W Twitter DirtDevil PREPARING THE CARPET 1 Vacuum carpet thoroughly 2 Place plastic or foil under with a Dirt Devil cleaner and around the legs of furniture until the carpet has completely dried HELPFUL HINTS FOR CLEANING CARPET e Plan your route so you e Do not oversaturate your don t walk over previously carpet with cleaning cleaned areas solution e Additional applications e Be sure to rinse carpet may be needed for thoroughly with water heavily soiled areas e Stay off of the carpet e Wipe cleaning solution until it is dry from wood to prevent damage e After carpet is dry vacuum with a Dirt Devil cleaner A WARNING A CAUTION Do not use the carpet cleaner as a Do not store the carpet cleaner in garage dry vacuum or area where unit could freeze AFTER CLEANING e Allow carpet to dry completely Try not to walk on the carpet until it is dry e If you need to walk on the carpet place white towels on the areas you want to walk e If the carpet is not dry and the furniture must be placed back in the room use plastic or foil under the furniture to prevent staining the carpet e Thoroughly clean the dirty water tank with hot tap water See page 14 LLI QA 14 lt 8 LLI L 0 ra lt al LLI 14 QA NOTE Do not t
5. OLD USE ONLY IF USED COMMERCIALLY WARRANTY IS VOID IMPORTANT SAFETY INSTRUCTIONS When using an electrical appliance basic precautions should always be followed including the following READ ALL INSTRUCTIONS BEFORE USING THIS APPLIANCE WARNING TO REDUCE THE RISK OF FIRE ELECTRIC SHOCK OR INJURY Fully assemble before operating Operate cleaner only at voltage specified on data plate on bottom of cleaner Do not leave appliance when plugged in Unplug from outlet when not in use and before cleaning or servicing Use indoors only Do not immerse Use only on carpet moistened by cleaning process Use only DIRT DEVIL cleaning products intended for use with this machine See the Cleaning Products section of this manual Do not use a flammable or combustible liquid to clean a floor Do not allow to be used as a toy Not intended for use by children age 12 and under Close supervision is necessary when used near children To avoid injury or damage keep children away from product and do not allow children to place fingers or other objects into any openings Use only as described in this manual Use only manufacturer s recommended attachments and products Do not use with damaged cord or plug If appliance is not working as it should has been dropped damaged left outdoors or dropped into water take it to a service center prior to continuing use Do not pull or carry by cord use cord as a hand
6. ains clean it should be safe to clean the carpet upholstery A WARNING A CAUTION To reduce the risk of fire electric shock or To reduce the risk of damage Do not use this injury ensure the power cord is out of the extractor on hard floors Using this machine on way before attaching the upper handle hard floors may scratch or damage your floors a N x THEN INSERT THE FILL WATER HANDLE INTO THE SOLUTION TANK BODY INSERT SEE PAGE 12 THE SCREW AND TIP THE CLEAN TIGHTEN WATER SOLUTION TANK IN LIKE THIS IT WILL CLICK r p HANDLE 4 RELEASE PLUG UNIT IN STEP ON THE HANDLE RELEASE PEDAL AND PULL BACK ON THE UPPER HANDLE THEN STEP ON THE POVVER BUTTON TO TURN ON PULL TRIGGER TO SPRAY SOLUTION VVHILE MOVING FORVVARD THEN SLOWLY RELEASE THE TRIGGER AND PULL YOUR CARPET WASHER BACK TO REMOVE DIRTY WATER AND SOLUTION A CAUTION Never leave unit unattended with power on Turn OFF when emptying and filling tank Do NOT oversaturate the carpet If the sound of the motor changes to a high pitch this indicates the dirty water tank is full and must be emptied XX N x YOUR CARPET IS FRESH AND CLEAN LET S GO 7 o EMPTY CLEAN WATER NEED HELP SOLUTION TANK AND Go to dirtdevil com support or REFILL WITH CLEAN contact our Customer Service Department at 800 321 1134 WATER REPEAT STEP 8 00 a m 7 00 p m EST Mon Fri 6 WIT
7. an authorized retailer dealer or distributor of Royal products OTHER IMPORTANT TERMS This Warranty is not transferable and may not be assigned This Warranty shall be governed and construed under the laws of the state of Ohio The Warranty Period will not be extended by any replacement or repair performed under this Warranty THIS WARRANTY IS THE EXCLUSIVE WARRANTY AND REMEDY PROVIDED BY ROYAL ALL OTHER WARRANTIES EXPRESSED OR IMPLIED INCLUDING WARRANTIES OF MERCHANTABILITY OR FITNESS FOR PARTICULAR PURPOSE ARE DISCLAIMED IN NO EVENT WILL ROYAL BE LIABLE FOR ANY SPECIAL INDIRECT INCIDENTAL OR CONSEQUENTIAL DAMAGES OF ANY KIND OR NATURE TO OWNER OR ANY PARTY CLAIMING THROUGH OWNER WHETHER BASED IN CONTRACT NEGLIGENCE TORT OR STRICT PRODUCTS LIABILITY OR ARISING FROM ANY CAUSE WHATSOEVER Some states do not allow the exclusion of consequential damages so the above exclusion may not apply to you This warranty gives you specific rights you may also have others that vary from state to state Find GENUINE Replacement Parts at www dirtdevil com This product uses the following parts BELT STYLE PRE MOTOR FILTER Call our Customer Service Department at 800 321 1134 8 00 a m 7 00 p m EST Mon Fri or Sat 10 00 a m 6 00 p m EST www dirtdevil com 30 F92 OUR VACS SPEAK VOLUMES Pick Up the Conversation On Ei Facebookcom DirtDevil YI miterepirDev
8. le close a door on cord or pull cord around sharp edges or corners Do not place product on cord Do not run appliance over cord Keep cord away from heated surfaces Do not unplug by pulling on cord To unplug grasp the plug not the cord Do not handle plug or appliance with wet hands Do not put any object into openings Do not use with any opening blocked keep free of dust lint hair and anything that may reduce air flow Keep hair loose clothing fingers and all parts of body away from openings and moving parts Turn off all controls before unplugging Use extra care when cleaning on stairs To avoid personal injury or damage and to prevent the cleaner from falling always place cleaner at bottom of stairs or on floor Do not place cleaner on stairs or furniture as it may result in injury or damage Do not use to pick up flammable or combustible materials such as gasoline or fine wood sandings or use in areas where they may be present Connect to a properly grounded outlet only See Grounding Instructions Do not pick up anything that is burning or smoking such as cigarettes matches or hot ashes Do not use without tanks or filters in place Do not clean over floor electrical outlets WARNING This product contains chemicals known to the State of California to cause cancer birth defects or reproductive harm WASH HANDS AFTER USING CAUTION TO REDUCE THE RISK OF DAMAGE Avoid picking up
9. n doubt as to whether the outlet is properly grounded Do not modify the plug provided with the appliance If it will not fit the outlet have a proper outlet installed by a qualified electrician This appliance is for use on a nominal 120 volt circuit and has a grounding plug that looks like the plug A illustrated in Fig 1 A temporary adapter D may be used to connect this plug to a 2 pole receptacle E if a properly grounded outlet is not available Fig 2 The temporary adapter should be used only until a properly grounded outlet B can be installed by a qualified electrician Fig 1 The green colored rigid ear lug or the like F extending from the adapter must be connected to a permanent ground G such as a properly grounded outlet box cover Fig 2 Whenever the adapter is used it must be held in place by a metal screw NOTE In Canada the use of a temporary adapter is not permitted by the Canadian Electrical Code QUICK START NEED HELP Go to dirtdevil com support or contact our Customer Service Department at 800 321 1134 8 00 a m 7 00 p m EST Mon Fri or Sat 10 00 a m 6 00 p m EST 1 POP THE BACK PANEL SCREW IT INTO THE BASE TOGETHER CHECK FOR COLOR FASTNESS Before cleaning carpet upholstery test for color fastness Dampen a white cloth with solution Test a small area in a closet or under a cushion Gently rub the cloth over the area Check each color for color bleeding If the cloth rem
10. ng amp Cleaning the Dirty Water Tank Pg 14 Water 1 Dirty Water Tank is full 1 Emptying Dirty Water Tank Pg 14 escaping from gt Dirty Water tank is not installed 12 Review Placing Dirty Water Tank in base of Cleaner correctly cleaner Pg 15 3 Clean Water Solution Tank not 3 Review Clean Water Solution Tank installed properly Installation Pg 12 Cleaner won t 1 Clean Water Solution Tank not 1 Review Clean Water Solution Tank dispense installed properly Installation Pg 12 2 Needs service 2 Take to service center To find nearest location visit our website at www DirtDevil com or call 1 800 321 1134 Motor noise 1 The float in the Dirty Water Tank 1 Review Emptying amp Cleaning the Dirty Water becomes has been activated Tank Pg 14 high pitched A VVAR N N G A TO REDUCE THE RISK OF FIRE AND ELECTRICAL SHOCK DUE TO INTERNAL COMPONENT DAMAGE USE ONLY DIRT DEVIL BRAND DETERGENT PRODUCTS INTENDED FOR USE WITH THE APPLIANCE Dirt Devil Cleaning Product Guide Deep Clean Deep Clean Product Name Advanced Pet 64 oz 64 oz Dirt Devil Quick amp Light WARRAN UY LIMITED WARRANTY WHAT THIS WARRANTY COVERS When used and maintained in normal household use and in accordance with the Owner s Manual your Dirt Devil product is warranted against original defects in material and workmanship During the Warranty Period We will provide labor and parts at no cost to you to correc
11. ransport the carpet cleaner with either the Clean Water Solution Tank or Dirty Water Tank full HOW VO REMOVE AND REPLACE CLEAN WATER SOLUTION TANK 1 Press the Clean Water 2 Tip it out like this Tank latch A WARNING To reduce the risk of fire and electric shock due to internal component damage use only Dirt Devil brand cleaning fluid intended for use with this appliance See Cleaning Fluid Section for recommended solutions 3 Unscrew measuring 4 For a full size room cap from the back place 5 capfuls of Dirt Devil solution into Clean Water Solution Tank 5 Fill remaining Clean 6 Place the Clean Water Water Solution Tank Solution Tank back in with hot tap water bottom first It will click Tightly screw cap back on A HOW VO EMPTY THE DIRTY WATER TANK 1 Pull the latch to release 2 Hold the handle and pull tank up and out 3 Pull lid out and 4 Rinse the tank and empty like this filter with hot tap water Wipe and let dry before storing to prevent mildew Replace the dirty water tank lid A IMPORTANT You will hear a noticeable change in the pitch of the cleaner This indicates a need to empty the dirty water tank PLACE DIRTY WATER TANK IN BASE OF CLEANER 1 Place carpet cleaner on a flat surface 3 The nozzle should be flush with the base If it s not this will result in poor water pickup A WARNING To reduce risk of personal injury
12. t any such defect in products purchased in the United States U S Military Exchanges and Canada HOW TO MAKE A WARRANTY CLAIM If this product is not as warranted take or send the product to a Dirt Devil Authorized Warranty Service Dealer along with proof of purchase For an automated referral to authorized service outlets in the U S A phone 1 800 321 1134 OR visit Dirt Devil online at www_DirtDevil com For additional assistance or information concerning this Warranty or the availability of warranty service outlets phone the Dirt Devil Consumer Response Center Phone 1 800 321 1134 Mon Fri 8am 7pm EST WHAT THIS WARRANTY DOES NOT COVER This Warranty does not cover use of the product in a commercial operation such as maid janitorial and equipment rental services brushroll belt bags filters improper maintenance of the product damage due to misuse acts of God nature vandalism or other acts beyond the control of Royal Appliance Mfg Co Royal we owner s acts or omissions use outside the country in which the product was initially purchased and resales of the product by the original owner This warranty does not cover pick up delivery transportation or house calls This warranty does not apply to products purchased outside the United States including its territories and possessions outside a U S Military Exchange and outside of Canada This warranty does not cover products purchased from a party that is not
13. uthorized service representative If appliance is not na working as it should has been dropped damaged left outdoors or dropped into water take it to a service center prior to continuing use TROUBLESHOOTING lf a minor problem occurs it usually can be solved quite easily when the cause is found by using the checklist below Any other servicing should be done by an authorized service representative If appliance is not working as it should has been dropped damaged left outdoors or dropped into water take it to a service center prior to continuing use A WARNING TO REDUCE THE RISK OF PERSONAL INJURY UNPLUG BEFORE CLEANING OR SERVICING PROBLEM POSSIBLE CAUSE POSSIBLE SOLUTION Cleaner won t 1 Power cord not firmly plugged 1 Plug unit in firmly run into outlet 2 Blown fuse or tripped breaker 2 Check fuse or breaker in home Replace fuse reset breaker in home 3 Needs service 3 Take to service center To find nearest location visit our website at www DirtDevil com or call 1 800 321 1134 Cleaner won t 1 Dirty Water Tank Lid not installed 1 Insert Dirty Water Tank Lid Pg 14 pick up or low 2 Dirty Water Tank is not installed 2 Review Placing Dirty Water Tank in base of suction correcily cleaner Pg 15 3 Dirty Water Tank is full 3 Empty Dirty Water Tank Pg 14 4 Dirty water passage clogged 4 Clean Dirty Water Tank Pg 14 5 Foam filter is dirty 5 Clean filter Review Emptyi
Download Pdf Manuals
Related Search