Turbo Air TBC-24SD, 24SB User's Manual
Contents
1. 5 and maintains about 38 F 3 C inside 3 Set toward 1 for warmer temperature and 7 for colder temperature Temperature Controller Thermostat 4 The thermostat controls compressor s cycling by sensing inside temperature 5 When unit will not be used for a long time turn the power switch off located under the thermostat knob BEFORE REQUESTING SERVICE SYMPTOMS CAUSES SOLUTIONS Cooler is freezing e Thermostat set too cold e Turn the temperature dial to a products warmer setting The unit does not e There is a power connection e Check the power cord to make refrigerate at all failure problem sure the unit is pluged in it correctly The unit does not e The unit is in sunlight or near a Move out of sunlight or away refrigerate well heating device from heater e Product was put in warm e Check the condition of stored e The unit lid is opened too product frequently or left open too long Check the position of the temp e The temp dial is not on the control dial correct position e The condenser is clogged There is a loud noise The floor is too weak or the e Check the installation leveling feet are set incorrectly e The backside of the unit is too close to the wall There are dew drops High moisture air can produce Wipe with a dry cloth on the unit exterior dewdrops during rainy seasons There are dew drops The lid is opened too frequently e Keep2. ANTY AND THE ADDITIONAL FOUR 4 YEAR COMPRESSOR WARRANTY AS DESCRIBED ABOVE THESE WARRANTIES ARE EXCLUSIVE AND IN LIEU OF ALL OTHER WARRANTIES INCLUDING IMPLIED WARRANTY AND MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE THERE ARE NO WARRANTIES WHICH EXTEND BEYOND THE DESCRIPTION ON THE FACE HEREOF OUTSIDE U S AND CANADA This warranty does not apply to and Turbo Air is not responsible for any warranty claims made on products sold or used outside the United State and Canada CHANGES MADE TO WARRANTY COMMENCED ON 5 1 2002 furb REFRIGERATOR MANUFA al TURER 1250 Victoria street Carson CA 90746 U S A amp Canada Toll Free 800 627 0032 For Service 800 381 7770 TEL 310 900 1000 FAX 310 900 1077 http www turboairinc com
3. TBC 50SD SB 110 120V 60Hz 235 los TBC 65SD SB 110 120V 60Hz 282 Ibs TBC 80SD SB 110 120V 60Hz 364 lbs TBC 95SD SB 110 120V 60Hz 375 los SERIAL NUMBER q The serial number is located on the rating label which is on interior right side wall Please retain the unit s serial number for service purpose INSTALLATION OF THE BOTTOM SHELVES 1 Before adding cans or boitles to cooler please install bottom shelves 2 Then install dividers see page 4 7 Note The size and quantities of the bottom shelves can be different according to model number INSTALLATION OF THE DIVIDERS 1 To re position divider push back wards 2 Spring in back of divider point C will be shorten to about 1 2 inch 3 Front of divider will be able to remove from point A and B 4 Position divider in the hole point C where you would like it 5 Push divider back wards 6 Insert front of divider in the holes point A and B where you would like it Note The shape and quantities of the dividers can be different according to model number INSTALLATION OF THE OPENER KIT 1 Bottle opener kit is inside cabinet 2 On the front outside wall of bottle cooler there are screws 3 Hook the opener kit onto the screws like drawing 1 4 Push down so head of screw will insert into smaller opening like drawing 2 5 To detach it follow above list in t
4. Turbo air Speeds Up the Pace of Innovation REFRIGERATOR MANUFACTURER Urbo ar Horizontal Bottle Cooler Installation and Operation Manual Please read this manual completely before attempting to install or operate this equipment TBC 24SD 24SB TBC 36SD 36SB TBC SOSD SOSB TBC 65SD 65SB TBC 80SD 80SB TBC 95SD 95SB SD series Stainless Steel Exterior SB series Black Laminated Vinyl Exterior or Black Powder Coating Exterior This picture shows TBC SOSD in the SD series CONTENTS q 21 eee an Ol er ee ee ee D CERIA NUNE E eea E EEEE an a E Eaa D INSTALLATION OF THE BOTTOM SHELVES ssasssssnennesnsnnnsensrrrsesrrrrnssrrrreen 3 INSTALLATION OF Tee ate ste eteseic ee escnceantuseeen eas enctpgeunere apaeaneecdeuet 4 INSTALLATION OF THE OPENER KIT ccceccseeeeeeeeeeeeeeeeeeeeeeeeaseaeeeeeaaaaes 5 HOW TO USE THE BOTTLE OPENER sssssnnsnnnnnnnnnnnnnnnnnnnnnnnrnnnnnrnnnnnrnnnnnennnne 6 NST ALCA RON en sti aeecaedautieo secaataceandenaeeesLatiteieteansd eee eee 7 CLEANING amp CAUTION scseciintssasvictnestasenenessmiesanneaxaeeendeewtnatcesdssneneisiaenceanants 8 BASIC OPERATION mere E eee ee re 9 BEFORE REQUESTING SERVICE sssssssssssssssnnssnsrrrressrrrresrrrrrsrrrrnrnrrrrrsrrrrenne 10 WARRANT oe E E E T E E E ET 11 13 SPECIFICATIONS F Horizontal Bottle Cooler MODEL COMP H P REFRIGERANT AMPS WEIGHT TBC 24SD SB 110 120V 60Hz 121 Ibs TBC 36SD SB 110 120V 60Hz 209 lbs
5. UCT SPOILAGE CLAIMS WHETHER OR NOT BECAUSE of REFRIGERATION FAILURE WARRANTY IS NOT TRANSFERABLE This warranty is not assignable and applies only in favor of the original purchaser user to whom delivered ANY SUCH ASSIGNMENT OR TRANSFER SHALL VOID THE WARRANTIES HEREIN MADE AND SHALL VOID ALL WARRANTIES EXPRESS OR IMPLIED INCLUDING ANY WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE IMPROPER USAGE TURBO AIR ASSUMES NO LIABILITY FOR PARTS OR LABOR COVERAGE FOR COMPONENT FAILURE OR OTHER DAMAGES RESULTING FROM IMPROPER USAGE OR INSTALLATION OR FAILURE TO CLEAN AND OR MAINTAIN PRODUCT AS SET FORTH IN THE WARRANTY PACKET PROVIDED WITH THE UNIT ALTERATION NEGLECT ABUSE MISUSE ACCIDENT DAMAGE DURING TRANSIT OR INSTALLATION FIRE FLOOD ACTS OF GOD Turbo Air is not responsible for the repair or replacement of any parts that Turbo Air determines have been subjected after the date of manufacture to alteration neglect abuse misuse accident damage during transit or installation fire flood or act of God IMPROPER ELECTRICAL CONNECTIONS TURBO AIR IS NOT RESPONSIBLE FOR THE REPAIR OR REPLACEMENT OF FAILED OR DAMAGED COMPONENTS RESULTING FROM ELECTRICAL POWER FAILURE THE USE OF EXTENSION CORDS LOW VOLTAGE OR VOLTAGE DROPS TO THE UNIT NO IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE THERE ARE NO OTHER WARRANTIES EXPRESSED IMPLIED OR STATUTORY EXCEPT THE ONE 1 YEAR PARTS amp LABOR WARR
6. er refrigeration performance the Condenser coil must be free of dust dirt and grease This will require periodic cleaning Condenser fins should be cleaned at least every three months 90 days or as needed To clean condenser unplug at power cord Condenser can be cleaned with vacuum brush or CO high pressure air 3 CLEAN THE DRAIN PAN Empty the Drain Pan which is located under the unit periodically When reinstalling Drain Pan make sure Drain Hose is placed back in pan 4 CHECK AFTER CLEANING Plug unit back in and turn on power switch Check that the unit is operating properly CAUTION 1 POWER CORD Be sure the power cord is connected to the proper voltage A protected circuit of the correct voltage and amperage must be run for connection of the line cord Turn off the power switch before disconnecting the power cord whenever performing maintenance functions or cleaning the refrigerated cabinet Compressor warranties are void if compressor burns out due to low voltage 2 RE STARTING If disconnected wait 5 minutes before re starting 3 POSITIONING DRINKS Do not obstruct the air inlet which is located at the back inside of the unit BASIC OPERATION TBC 24SD TBC 24SB TBC 386SD TBC 36SB TBC 50SD TBC 50SB TBC 65SD TBC 65SB TBC 80SD TBC 80SB TBC 95SD TBC 95SB 1 The controller thermostat is located at the right inside of the unit 2 The factory setting for the control is
7. he reverse order HOW TO USE THE BOTTLE OPENER 1 In direction of arrow 2 Grip the bottle tightly so it will not fall on removing cap 3 The cap will drop to bottom of opener case 4 When opener case is full separate from cabinet 5 Turn opener case over to empty INSTALLATION 1 GOOD AIR CIRCULATION Do not place any object that will restrict air flow in front or back grills Turbo air highly recommends that there is ample space in rear of unit 3 inches or more is best 2 PLACE ON STRONG GROUND Be sure the location chosen has a floor strong enough to support the total weight of the cabinet and contents 3 DO NOT PLACE NEAR HEAT Be sure to avoid hot corners and locations near stoves High ambient temperature will make cooling efficiency lower 4 INDOOR USAGE ONLY Be sure to install this unit indoor so it will not get wet from the rain 5 STABILIZING Make sure the unit is installed in a stable condition 6 LEVELING Be sure that the unit is level from front to back and side to side 7 Do not plug in with other units on same breaker 8 Do not run on extension cord CLEANING Before cleaning turn unit off at power switch 1 CLEANING THE INTERIOR AND EXTERIOR The interior and exterior of the unit can be cleaned using warm water with soap Do not use an abrasive cleaner because it will scratch the surface 2 CLEANING THE CONDENSER FINS To maintain prop
8. is limited to a period of one 1 year from the date of original installation or 15 months after shipment date from Turbo Air whichever occurs first Any parts covered under this warranty that are determined by Turbo Air to have been defective within one 1 year of original installation or fifteen 15 months after shipment date from manufacturer whichever occurs first is limited to the repair or replacement including labor charges of defective parts or assemblies The labor warranty shall include Standard straight time labor charges only and reasonable travel time as determined by Turbo Air Additional Four Year Compressor Warranty In addition to the one 1 year warranty stated above Turbo Air warrants its hermetically sealed compressor to be free from defects in both material and workmanship under normal and proper use and maintenance service for a period of four 4 additional years from the date of original installation but not to exceed five 5 years and three 3 months after shipment from the manufacturer Compressor determined by Turbo Air to have been defective within this extended period will at Turbo Air s option be either repaired or replaced with a compressor or compressor parts of similar design and capacity The four 4 year extended compressor warranty applies only to hermetically sealed parts of the compressor and does not apply to any other parts or components including but not limited to cabinet paint finish tempe
9. rature control refrigerant metering device driers motor starting equipment fan assembly or and other electrical component etcetera 404A 134A Compressor Warranty The four year compressor warranty detailed above will be voided if the following procedure is not carefully adhered to 1 This system contains R404A or R134A refrigerant and polyolester lubricant The polyol ester lubricant has rapid moisture absorbing qualities 2 Drier replacement is very important and must be changed when a system is opened for servicing A 620 copper drier or better is highly recommended 3 Micron level vacuums must be achieved to insure low moisture levels in the system 500 microns or lower must be obtained 4 When compressor is grounded suction filter drier and 620 drier or better must be replaced a Compressor must be obtained through Turbo Air Inc unless otherwise specified in writing through Turbo Airs warranty department What Is Not Covered By This Warranty Turbo Air s sole obligation under this warranty is limited to either repair or replacement of parts subject to the additional limitations below This warranty neither assumes nor authorizes any person to assume obligations other than those expressly covered by this warranty NO CONSEQUENTIAL DAMAGES TURBO AIR IS NOT RESPONSIBLE FOR ECONOMIC LOSS PROFIT LOSS OR SPECIAL INDIRECT OR CONSEQUENTIAL DAMAGES INCLUDING WITHOUT LIMITATION LOSSES OR DAMAGES ARISING FROM FOOD OR PROD
10. the lid closed to remove on the unit interior or left open too long dewdrops The following points are not malfunctions e A water flowing sound can be heard when the compressor stops This is the sound of REFRIGERANT flowing e The compressor does not run during the defrost cycle REFRIGERATOR MANUFA vil URER W t lurbo air ae Warranty Claims All claims for labor or parts must be made directly through Turbo Air If unit was manufactured more than one year proof of purchase must be faxed in or sent with claim All claims should include model number of the unit the serial number of the cabinet and all pertinent information supporting the existence of the alleged defect If compressor is replaced under warranty Turbo Air will either request the compressor or compressor tag be returned Compressor or tag must be returned with all information related to the unit Any action or breach of these warranty provisions must be commenced within one year after said cause of action has occurred One Year Parts amp Labor Warranty Turbo Air warrants to the original purchaser of every new Turbo Air refrigerated unit the cabinet and all parts thereof to be free from defects in material or workmanship under normal and proper use and maintenance service as specified by Turbo Air and upon proper installation and start up in accordance with the instruction packet supplied with each Turbo Air unit Turbo Air s obligation under this warranty
Download Pdf Manuals
Related Search