Powermate PMC606750 User's Manual
Contents
1. REF PART DESCRIPTION DESCRIPTION DESCRIPCION QTY NO NO 1 0063806 Carrier assembly Ensemble transport Transportador conjunto 1 2 Note A Engine 12 hp Yamaha OHV Moteur Motor 1 3 0051094 Isolator Sectionneur Aislador 4 4 0064107 Module low oil Module bas niveau d huile M dulo nivel bajo de aceite 1 5 0057512 Bolt whz 3 8 18 x 1 1 4 Boulon Perno 4 6 0062797 Connector panel Connecteur tableau Conector panel 1 7 0063935 Bolt hex 5 16 24 x 9 50 Boulon Perno 1 8 Note B Washer lock 5 16 Contre crou 5 16 Arandela de cierre 5 16 10 9 0008854 Lug ground Oeillet de mise la terre Terminal tierra 1 10 0040832 Nut nyloc 1 4 20 crous nyloc 1 4 20 Tuerca nyloc 1 4 20 8 11 Note B Bolt 5 16 18x 1 1 2 Boulon Perno 2 12 Note Washer flat 5 16 Rondelle plates 5 16 Arandela plana 5 16 5 13 0048736 Nut nyloc 5 16 18 crous nyloc 5 16 18 Tuerca nyloc 5 16 18 2 14 0049224 Assembly ground wire Ensemble fil de masse tress a tierra Conjunto cable trenzado 1 15 Note B Washer star external 5 16 Rondelle dents externa 5 16 Arandela estrella 2 16 Note B Bolt hex 5 16 18 x 3 4 Boulon t te hex 5 16 18 x 3 4 Perno 1 17 0063822 Muffler Silencieux Silenciador 1 18 0063701 Gasket Joint Empaquetadura 1 19 0064237 Panel wired Tableau complet c bl Panel cabeado completo 1 19A 0049071 Circuit Breaker 20 amp Disjoncteurs 202. son marcas comerciales registradas de The Coleman Company Inc utilizadas bajo licencia Powermate es una marca comercial registrada de Powermate Corporation
3. to the bolt to secure the foot bracket to the carrier Caution Do not over tighten so that the rubber foot material collapses LOCKING HANDLE 1 Attach the lanyards item 30 to the release pins item 34 and carrier as shown in the illustration 2 To lock the handle item 25 in the extended position align the holes in the handle brackets with the holes in the carrier brackets and insert the release pins item 34 English LIMITED WARRANTY Warranty Coverage Powermate Corporation the Company warrants to the original retail customer in North America that it will repair or replace free of charge any parts found by the Company or its authorized service representative to be defective in material or workmanship This warranty covers the cost of replacement parts and labor for defects in material or workmanship Not Covered Transportation charges for sending the product to the Company or its authorized service representative for warranty service or for shipping repaired or replacement products back to the customer these charges must be borne by the customer Damages caused by abuse or accident and the effects of corrosion erosion and normal wear and tear Warranty is voided if the customer fails to install maintain and operate the product in accordance with the instructions and recommendations of the Company set forth in the owner s manual The Company will not pay for repairs or adjustments to the product or fo
4. 38 0050298 Switch Rocker Interrupteur Interruptor 1 39 0002433 Wheel spacer Bague d espacement Espaciador de la rueda 2 40 0062495 Grip handle Poign e Empu adura 2 42 Note B Bolt 5 16 18 x 4 Boulon Perno 2 43 0063212 Bracket foot Support de pied Soporte del pie 1 44 0049268 Bolt M8 x 16mm Boulon Perno 3 45 Note B Bolt 1 4 20 x 1 1 4 Boulon Perno 1 46 Note B Bolt 1 4 20 x 1 Boulon Perno 4 47 0057254 Nut hex flg 5 16 18 crous 5 16 18 Tuerca 5 16 18 7 48 Note B Bolt 5 16 18 x 1 1 4 Boulon Perno 2 49 Note B Washer star external 1 4 Rondelle dents externa 1 4 Arandela estrella 2 50 0064138 Screw 10 x 75 Vis Tornillo 2 PARTS LIST LISTE DES PI CES LISTA DE PIEZAS Ref Part Description Description Descripci n Qty No No 51 0063821 Generator head Sumec T te de la g n ratrice Sumec Cabezal del generador Sumec 1 51A 0063300 Adapter engine Adaptateur pour moteur Adaptor motor 1 51B 0063940 Rotor Rotor Rotor 1 51C 0063941 Stator Stator Estator 1 510 0063942 Band stator cover Bande Banda 1 51E 0063943 Bolt M6 x 195 Boulon Perno 4 51F 0063229 Support bearing Support roulement Soporte Cojinete 1 51G _ 0063230 Brush module Brosser le module Cepille m dulo 1 51H 0063231 Screw M5 x 16mm Vis Tornillo 8 511 0063948 AVR module La tension automatique r gulatrice El regulador autom tico del voltaje 1 51 0063944 Bolt M5 x 230 Boulon Perno 2 51K 0063235 Nut
5. Yamaha OHV Manga de hierro fundido del cilindro El sensor del nivel bajo de aceite Recept culos sobre el panel de control El Centro de Informaci n Digital DIGITECH Tanque de metal para combustible con capacidad de 26 5 litros 7 galones Apagachispas Juego de transporte PANEL DE CONTROL A Tomacorriente GFCI de 120 Voltios El tomacorriente doble del interruptor accionado por corriente de p rdida tierra tiene una especificaci n tal que se puede tomar un total de 20 amperios indeferentemente a si se utilizan los dos medios o s lo un tomacorriente Este tomacorriente puede utilizarse al mismo tiempo que los otros tomas siempre y cuando no se tomada se mantenga dentro de las especificacciones de la placa de identificaci n Interruptor de corriente de p rdida a tierra Se ajusta a los requisitos de U L 93 Clase A y NEC Este dispositivo lo protege contra una sacudida el ctrica peligrosa que puede causarse cuando su cuerpo se convierte en una senda por la cual la electricidad viaja para alcanzar la tierra Esto podr a suceder cuando usted toca un aparato o la cuerda que es vive por mecanismo defectuoso aislamiento h medo o llevado etc B Recept culo de cierre giratorio de 120 240 voltios 30 amperes Puede extraerse un m ximo de 30 amp desde el recept culo de 120 240 voltios siempre y cuando sea el nico recept culo usado Sin embargo la corriente debe limitarse al valor nominal de la plac
6. aper u du pourcentage fourni de puissance nominale T moin de charge en pourcentage LOAD II s agit d une version num rique de la plaque multiprises Competeur Horaire HOUR METER Il indique le nombre total d heures au cours desquelles la g n ratrice a t en marche depuis sa fabrication Indicateur de dur e de maintenance MAINTENANCE TIMER ll indique le nombre d heures au cours desquelles la g n ratrice a t en marche depuis la derni re r initialisation par l utilisateur Cet indicateur doit tre r initialis apr s chaque changement d huile ou apr s tous travaux de maintenance Suivez les directives contenues dans le manuel du propri taire du moteur pour conna tre les p riodes appropri es d entretien du moteur Bouton de r initialisation PUSH TO RESET Lorsque vous appuyez sur ce bouton l indicateur de dur e de maintenance est mis 0 HR DIGITECH Fran ais L INSTALLATION DE KIT DE TRANSPORT OUTILS N CESSAIRES Cliquet rochet de 1 2 po et 9 16 po blocs de bois minimum de 6 po de hauteur Reportez vous la liste des pi ces des page 9 INSTALLATION DES ROUES 1 Faire reposer l extr mit de la g n ratrice l oppos de celle ou se trouve le capuchon du r servoir d essence sur un bloc de fa on pouvoir effectuer la pose de la roue 2 Ins rer une bague d espacement article 39 dans le centre de la roue article 28 3 Enfiler le boulon de 3 8 x 4 25 po art
7. encuentren defectuosas en sus materiales o en su fabricaci n Esta garant a cubre el costo de partes de reemplazo y mano de obra por defectos en materiales o en fabricaci n No est n cubiertos Costos de transporte por el env o del producto a la Compa a o a sus representantes de servicio autorizados por servicio de garant as o por el reenv o de los productos reparados o de reemplazo al consumidor estos cargos los deber cubrir el cliente Da os ocasionados por el mal uso o por un accidente y los efectos de la corrosi n la erosi n el desgaste y el uso normales La garant a no ser v lida si el consumidor no instala da mantenimiento y hace funcionar el producto de acuerdo con las instrucciones y recomendaciones de la Compa a descritas en el manual del usuario La Compa a no pagar por reparaciones ni ajustes al producto ni costos ni mano de obra realizado sin la Compa ia s la autorizaci n previa Per odo de garant a Dos 2 a os de la fecha de la compra en productos utilizados nicamente para aplicaciones de consumo si un producto se utiliza para usos comerciales o con fines de lucro el per odo de garant a se limitar a un 1 a o a partir de la fecha de compra si el producto se utiliza como equipo de arrendamiento el per odo de garant a se limitar a noventa 90 d as a partir de la fecha de compra Para obtener el servicio de garant a el cliente debe proporcionar el comprobante de comp
8. nyloc M5 crous nyloc Tuerca nyloc 2 51L 0063236 Terminal block Bloc d limitant Bloque terminal 1 51M 0063237 Washer M5 Rondelle Arandela 8 51N 0063238 Washer lock M5 Contre crou Arandela de cierre 10 510 _ 0063239 Nut M5 crous Tuerca 8 51P 0063240 Cover end Couvercle Tapa 1 51Q 0063241 Screw flg M5 x 8mm Vis Tornillo 2 51R 0063225 Fan Ventilateur Ventilador 1 51S 0063364 Screw M5 x 20mm Vis Tornillo 4 51T 0063365 Bearing Roulement Cojinete 1 51U 0063932 Stator harness Harnais de stator Arreos de estator 1 STATOR HARNESS HARNAIS DE STATOR ARREOS DE ESTATOR 10 Note A Powermate Corporation will not provide engines as replacement parts Engines are covered through the engine manufacturer s warranty Consult the accompanying engine manual or contact our service department for assistance Note B These are standard parts available at your local hardware store Note C Contact your nearest Coleman Powermate Service Center for replacement fuel tanks WARNING To avoid possible personal injury or equipment damage a registered electrician or an authorized service representative should perform installation and all service Under no circumstances should an unqualified person attempt to wire into a utility circuit WARNING Remarque A Powermate Corporation ne fournit pas de moteurs dans ses pi ces d tach es Les moteurs sont couverts par la garantie du fabricant de moteurs Consulter le manuel du moteur inclus ou contacter notre
9. repr sentant du service autoris auront d termin comme tant d fectueuses du point de vue du mat riel ou de la fabrication La garantie couvre les co ts de remplacement des pi ces et de main d uvre pour tout d faut mat riel ou de fabrication Ce qui n est pas couvert Les frais de transport pour envoyer le produit la compagnie ou son repr sentant du service autoris pour effectuer le travail couvert par la garantie les frais d exp dition au client des produits r par s ou remplac s Ces frais doivent tre assum s par le client Les dommages caus s par un abus ou un accident et les effets de la corrosion de l rosion ainsi que de l usure normale La garantie est annul e si le client n arrive pas installer garder et faire fonctionner le produit conform ment aux directives et aux recommandations de la compagnie formul es dans le guide d utilisation La compagnie ne paiera pas de r paration ou des ajustements au produit ou pour les co ts ou main d uvre ex cut sans l autorisation pr alable de la compagnie P riode couverte par la garantie Deux 2 ans partir de la date d achat sur les produits utilis s uniquement pour les applications de consommateur Si le produit est utilis des fins d affaires ou commerciales la p riode couverte par la garantie se limite un 1 an partir de la date d achat Si le produit est utilis comme quipement de location la p riode couverte par la gara
10. ES PRINCIPALES DU GROUPE ELECTROGENE Moteur 12 HP Yamaha OHV Chemise de cylindres en fonte _ D tecteur de bas niveau d huile Prises sur tableau de commande Le centre d information num rique DIGITECH _ R servoir de carburant en m tal d une contenance de 26 5 litres 7 gallons Pare tincelles Kit de transport TABLEAU DE COMMANDE A Bo tier k interrupteur de circuit en cas de fuite la terre 120 volts Le bo tier de prise double d interrupteur de circuit en cas de fuite la terre a une valeur nominale telle qu un total de 20 A peut tre tir ind pendemment du bo tier utilis simple ou demi Ce bo tier puet tre utilis avec les autres bo tiers en autant que le g n rateur n est pas surcharg et que la puisance totale reste dans la fourchette de valeurs indiqu es sur la plaque signal tique Interrupteur de circuit en cas de fuite a la terre conforme U L 943 Cat gorie A et ixigences NEC Cet appareil vous prot ge contre les dangers de chocs lectriques qui peuvent itre caus s si votre corps devient un conduit pour l lectricit se rendant la terre Ceci peut se produire si vous touchez u appareil ou un cordon qui est sous tension suite un m canisme d fectueux un isolant us ou humide etc B Prise verrouillage de 120 240 V 30 A Cette prise de 120 240 V fournit un maximum de 30 Aa condition que ce soit la seule utilis e La charge totale doit par ail
11. PMC606750 Insert Additif Adici n Era Power male ELECTRIC GENERATOR GROUPE ELECTROGENE GENERADOR ELECTRICO Thank you for selecting a Coleman Powermate Generator The Coleman Powermate generator has been made to supply reliable portable electrical power when utility power is not available We hope you will enjoy your new generator Welcome to our worldwide family of Coleman Powermate generator users Merci d avoir choisi le groupe lectrog ne Coleman Powermate Ce groupe lectrog ne Coleman Powermate a t con u pour fournir le pouvoir lectrique portatif et fiable quand le pouvoir d utilit n est pas disponible Nous esp rons que votre groupe lectrog ne vous donnera enti re satisfaction Bienvenue dans la famille mondiale des utilisateurs de groupes lectrog nes Coleman Powermate Gracias por seleccionar un generador Coleman Powermate El generador Coleman Powermate ha sido dise ado para proporcionar energ a el ctrica confiable y port til cuando no hay servicio disponible de energ a p blica Esperamos que disfrute de su nuevo generador Bienvenido a nuestra familia de usuarios de generadores Coleman Powermate a nivel mundial IMPORTANT Please make certain that persons who are to use this equipment thoroughly read and understand these instructions and any additional instructions provided prior to operation IMPORTANT Pri re de vous assurer que les perso
12. STATEMENT YOUR WARRANTY RIGHTS AND OBLIGATIONS The California Air Resources Board and Powermate Corporation herein Powermate are pleased to explain the evaporative emission control system EECS warranty on your 2006 generator In California new generators must be designed built and equipped to meet the State s stringent anti smog standards Powermate must warrant the EECS on your generator for the periods of time listed below provided there has been no abuse neglect or improper maintenance of your generator Your EECS includes parts such as fuel hoses MANUFACTURER S WARRANTY COVERAGE This evaporative emission control system is warranted for two years The warranty period begins on the date the generator 1s delivered to an ultimate purchaser Powermate warrants to the ultimate purchaser and any subsequent owner that the generator is 1 designed built and equipped so as to conform with all applicable regulations and 11 free from defects in materials and workmanship that cause the failure of a warranted part to be identical in all material respects to that part as described in Powermate s application for certification If any evaporative emission related part on your generator is defective the part will be repaired or replaced by Powermate OWNER S WARRANTY RESPONSIBILITIES As the generator owner you are responsible for performance of the required maintenance listed in your owner s manual Powermate recommends that you retain all
13. a de identificaci n Si se utiliza un recept culo de 120 240 voltios junto con los recept culos de 120 voltios la carga total extra da no debe exceder los valores nominales de la placa de identificaci n C Interruptor Los recept culos se protegen mediante un cortacircuitos de CA Si se sobrecarga el generador u ocurre un cortocircuito externo el cortacircuitos saltar Si esto ocurre desconecte gt fase RL lt lt todas las cargas el ctricas y trate de determinar la causa del problema antes de usar el generador nuevamente Si la sobrecarga causa que salte el cortacircuitos reduzca la carga NOTA Si salta continuamente el cortacircuitos se podr a da ar el generador o el equipo El cortacircuitos puede restaurarse pulsando el bot n del cortacircuitos D El motor On Off En De Interruptor E El Centro de Informaci n Digital DIGITECHTM El Centro de Informacion Digital DIGITECH es una funci n patentada disponible nicamente en selectos generadores de la marca Powermate A primera vista el usuario puede ver de manera inmediata cu nta capacidad de producci n del generador se est utilizando y cu nta potencia permanece disponible La pantalla tambi n indica el tiempo desde que el ltimo restablecimiento por parte de un usuario y el tiempo de ejecuci n total acumulado del generador Barra de potencia POWER BAR Esta gr fica de barras ofrece una r pida indic
14. aci n visual del porcentaje de la producci n nominal que se est suministrando actualmente Indicador de de carga LOAD Se refiere a una versi n num rica de la Barra de potencia Contador de Hora HOUR METER Indica el n mero total de horas que ha estado en marcha el generador desde su manufactura Temporizador de mantenimiento MAINTENANCE TIMER Indica el n mero de horas que ha estado en marcha el generador desde el ltimo restablecimiento por parte de un usuario Este temporizador debe restablecerse despu s de cada cambio de aceite o de cualquier otra tarea de mantenimiento Siga las instrucciones en el manual del propietario del motor para verificar los intervalos apropiados de mantenimiento del motor Bot n Reset Restablecer PUSH TO RESET Al mantener presionado este bot n se restablecer el Temporizador de mantenimiento en 0 HRS GTEC Espa ol INSTALACION DEL JUEGO DE TRANSPORT HERRAMIENTAS NECESARIAS Cubos y trinquetes de 1 2 y 9 16 bloque s de madera m nimo de 6 de alto Consulte la lista de partes en las p gina 9 INSTALACI N DE LAS RUEDAS 1 Bloquee el extremo del generador situado en el lado opuesto a la tapa del tanque de combustible para instalar el juego de rueda 2 Inserte el espaciador de la rueda art culo 39 en el centro de la rueda art culo 28 3 Deslice el perno de 3 8 x 4 25 art culo 32 y arandela de 3 8 art culo 27 a trav s de la rueda art
15. acle provided it is the only receptacle used However current must be limited to the nameplate rating 120 240 volt receptacle is used along with the 120 volt receptacle the total load drawn must not exceed the nameplate ratings If the C Circuit Breakers The receptacles are protected by an AC circuit breaker If the generator is overloaded or an external short circuit occurs the circuit breaker will trip If this occurs disconnect all electrical loads and try to determine the cause of the problem before attempting to use the generator again If overloading causes the circuit breaker to trip reduce the load NOTE Continuous tripping of the circuit breaker may cause damage to generator or equipment The circuit breaker may be reset by pushing the button of the breaker D Engine On Off Switch E DIGITECH Digital Information Center The DIGITECH Digital Information Center is a patented feature available only on select Coleman Powermate Brand generators At a glance the user can instantly see how much of the generator s output capacity is being used and how much power remains available The display also indicates the time since last user reset and the total accumulated runtime of the generator Power Bar This bargraph provides a quick visual indication of the percentage of rated output currently being supplied Load Indicator This is a numeric version of the Power Bar Hour Me
16. alve body and carburetor spacer if applicable EGR rate feedback and control system Air Injection System Air pump or pulse valve Valves affecting distribution of flow Distribution manifold Catalyst or Thermal Reactor System Catalytic converter Thermal reactor Exhaust manifold Particulate Controls Traps filters precipitators and any other device used to capture particulate emissions Continued Miscellaneous ltems Used in Above Systems This warranty does not cover damage resulting from Vacuum temperature and time sensitive valves and accidents acts of nature or other events or occurrences switches beyond the control of Yamaha Yamaha Motor Electronic controls Corporation U S A expressly disclaims responsibility for Hoses belts connectors and assemblies any and all consequential damages such as loss of time inconvenience loss of use of the utility equipment engine Engine components damaged due to a failure under or commercial loss warranty of a warranted part The original spark plug s are warranted for the period of replacement indicated in the Owner s Manual and not the useful life of the utility equipment engine see your Owner s Manual DURING THE PERIOD OF THIS WARRANTY Yamaha Motor Corporation U S A will repair or replace any warranted part deemed defective by Yamaha during the scope of the warranty without charge to the owner including parts labor and diagnosis This work must be done
17. amp Cortacircuitos 20 amp 2 19B 0062199 Circuit Breaker 25 amp dual Disjoncteurs 25 amp Cortacircuitos 25 amp 1 20 0063830 Bracket low oil Support bas niveau d huile Soporte nivel bajo de aceite 1 21 0064084 Shield heat cran de chaleur Pantalla para el calor 1 22 Note C Fuel tank assembly Ensemble complet du r servoir Conjunto tanque 1 22A 0061817 Fuel Gauge Screws Combustible Indicador Tornillos Essence cartement Visser 1 22B 0061942 Strainer Basket Passoire Panier Colador Canasta 1 22 0061816 Fuel Cap Capuchon Tapa de combustible 1 23 0061811 Fuel Shut Off Fermeture d essence Apagado combustible 1 23A 0061876 Filter fuel valve and washer Filtre et rondelles Filtro y arandela 1 23B 0061875 Nut fuel valve crous Tuerca 1 24 Note B Bolt 1 4 20 x 3 4 Boulon Perno 3 29 0064178 Handle Poign e Manija 2 26 Note B Bolt 5 16 18 x 2 1 4 Boulon Perno 2 27 Note B Washer flat 3 8 Rondelle plates 3 8 Arandela plana 3 8 2 28 0057704 Wheel Roue Rueda 2 29 0055894 Rubber Foot Pied Pie 2 30 0062174 Lanyard Lanyard Acollador 2 31 0058933 Washer flat 1 4 W Rondelle plates 1 4 large Arandela plana 1 4 lejos 1 32 Note B Bolt 3 8 16 x 4 25 Boulon Perno 2 33 0057578 Nut nyloc 3 8 16 crous nyloc 3 8 16 Tuerca nyloc 3 8 16 2 34 0062502 Pin release Epingle de rel chement Alfileres de la liberaci n 2 35 0058955 Cap plastic Capuchon Tapa 2 36 Note B Washer flat 1 4 Rondelle plates 1 4 Arandela plana 1 4 6 37 0064108 Nut whz 8mm crous Tuerca 2
18. at an authorized Yamaha dealer Give notice to an authorized Yamaha dealer of any apparent defect s within a reasonable period of time after discovery The utility equipment engine must be made available for inspection by an authorized Yamaha dealer OWNER S RESPONSIBILITY The owner of the utility equipment engine is responsible for the performance of required maintenance see you Owner s Manual Receipts and maintenance records covering the performance of regular maintenance should be retained in the event questions arise concerning maintenance The receipts should be transferred to each subsequent owner of this utility equipment engine The emission control systems of your Yamaha utility equipment engine were designed built tested and certified as being in conformity with California emission control regulations using genuine Yamaha parts Accordingly it is recommended that any replacement part s used for maintenance replacement or repair of emission control systems be Yamaha parts The owner may elect to have maintenance replacement or repair of the emission control devices and systems performed by any repair establishment or individual and may elect to use parts other than Yamaha parts for such maintenance replacement or repair without invalidating this warranty However the cost of such service or parts will not be covered under the warranty EXCLUSIONS No warranty coverage will be allowed if the part s failure was cause
19. culo 28 y luego a trav s del soporte de la rueda en el transportador colocando el lado descentrado del centro de la rueda en contra del soporte 4 Atornille la tuerca de nyloc de 3 8 art culo 33 en el perno y apri tela para fijar firmemente el conjunto de la rueda a la transportador 5 Repita el procedimiento anterior para la otra rueda INSTALACION DEL PIE 1 Bloquee el lado del motor del generador para colocar el soporte de la pie art culo 43 bajo el canal portador Enrosque un perno de 5 16 18 x 4 art culo 42 con una pie art culo 29 a trav s de los orificios de montaje y enrosque una tuerca brida de 5 16 art culo 47 al perno para asegurar el soporte de la pie al portador Precauci n No apriete demasiado para que el material de la pie no colapse MANIJA QUE CIERRA 1 Conecte los acoladores art culo 30 a los alfileres de la liberaci n art culo 34 y el portador como mostrado en la ilustraci n 2 Para cerrar el manija art culo 25 en la posici n extendida alinea los hoyos en los soporte del manija con los hoyos en los soporte de transportador y mete los alfileres de la liberaci n art culo 34 Espa ol GARANTIA LIMITADA Cobertura de la garant a Powermate Corporation la Compa a garantiza al cliente minorista original en Am rica del Norte que reparar o reemplazar sin costo alguno cualesquiera partes que la Compa a o cualquiera de sus representantes de servicio autorizados
20. d partement de service apr s vente pour toute assistance Remarque B Ces pi ces sont des pi ces standard disponibles en quincaillerie Remarque C Pour commander un r servoir de rechange contacter Centre de service Coleman Powermate le plus proche AVERTISSEMENT Pour viter toute blessure personnelle ou dommage l quipement l installation et tout entretien devralent tre effectu s par un lectricien qualifi ou un pr pos au service autoris En aucun cas une personne non qualifi e ne devrait essayer de faire le raccord au circuit principal AVERTISSEMENT Nota A Powermate Corporation no proporcionar los motores como repuestos Los motores est n cubiertos por medio de la garant a del fabricante del motor Consulte el manual adjunto del motor o comun quese con nuestro departamento de servicio para recibir ayuda al respecto Nota B Estas son piezas est ndar disponibles en su ferreter a local Nota C Para hacer pedidos de tanques localice el Centro de Servicio de Coleman Powermate m s cercano ADVERTENCIA Para evitar posibles lesiones fiscas o da os materiales es necesario que la instalaci n y todo el servicio sea realizado por un electricista matriculado o representatnte de servicio autorizado Bajo ninguna circunstancia debe permitirse que una persona que no est capacitad trate de apverrencia Manipular cables dentro del circuito de servicio el ctrico 11 CALIFORNIA EMISSION CONTROL WARRANTY
21. d by owner operator abuse neglect tampering improper adjustment unless performed by a dealer during warranty repair work modification misuse alteration or improper maintenance see your Owner s Manual Use of parts which are not qualitatively equivalent to genuine Yamaha parts improper service or lack of required maintenance which causes failure or a warranted part may constitute abuse and or improper service thereby invalidating warranty liability hereunder TANARA MO Ren en ee ra ea Post Office Box 6555 Cypress California 90630 ae hote Re ut hero E Te A ARE E E E Soro ae oa RQ TBE US TRE RE Cat TRES TRUST RE Cat PRE TRE ae cae E li h NOTES REMARQUES NOTAS Powermate 4970 Airport Road P O Box 6001 Kearney NE 68848 1 800 445 1805 1 308 237 2181 Fax 1 308 234 4187 2006 Powermate Corporation All rights reserved Coleman and feet are registered trademarks of The Coleman Company Inc used under license Powermate is a registered trademark of Powermate Corporation 2006 Powermate Corporation Tous droits reserves Coleman et sont des marques d pos es de The Coleman Company Inc utilis es sous licence Powermate est une marque d pos e de Powermate Corporation 2006 Powermate Corporation Reservados todos los derechos Coleman y fer
22. icle 32 et rondelle de 3 8 po article 27 dans la roue article 28 puis dans le support de la roue sur le transporteur en le pla ant de fa on ce que le c t le plus en creux du moyeu de la roue repose contre le support 4 Enfiler l crou frein lastique de 3 8 po article 33 sur le boulon et serrer de facon a bien fixer la roue sur la transporteur 5 Proc der de la m me fa on pour l autre roue INSTALLATION DU PIED 1 En bloquant le c t moteur de la g n ratrice mettre en place le support de pied article 43 sous le profil en U Visser un boulon de 5 16 18 x 4 article 42 avec une pied article 29 dans les trous de fixation puis visser sur le boulon un crou bride de 5 16 po article 47 pour fixer le support de pied au profil Attention ne pas trop serrer pour ne pas craser le mat riau du pied POIGNEE VERROUILLANT 1 Attacher le lanyards article 30 aux pingles de rel chement article 34 et le transporteur selon l illustration 2 Pour verrouiller la poign e article 25 dans la position tendue aligner les trous dans les support de poign e avec les trous dans les support de transporteur et ins rer les pingles de rel chement article 34 Fran ais GARANTIE LIMIT E Couverture limit e Powermate Corporation la compagnie garantit au revendeur d origine en Am rique du Nord qu elle r parera ou remplacera sans frais toutes les pi ces que la compagnie ou que son
23. leurs rester dans les limites indiqu es sur la plaque signal tique Si la prise de 120 240 V est utilis e en conjonction avec les prises de 120 V la charge totale ne doit pas d passer les limites indiqu es sur la plaque C Disjoncteurs Les prises sont prot g es par un disjoncteur alternatif En cas de surcharge ou de court circuit ext rieur le disjoncteur saute Si cela se produit d brancher tout appareil reli au groupe lectrog ne et essayer de d terminer la cause du probleme avant d essayer de le r utiliser Si le disjoncteur saute en raison d une surcharge r duire la charge REMARQUE Le groupe lectrog ne ou les appareils branch s dessus peuvent se trouver abim s si le disjoncteur saute continuellement Appuyer sur le bouton du disjoncteur pour le r enclencher D Commutateur On Off Sur De du moteur E Le centre d information num rique DIGITECHTM Le centre d information num rique DIGITECH est une caract ristique brevet e disponible seulement sur certains mod les de g n ratrice Powermate s lectionn s D un coup d il l utilisateur put imm diatement voir la puissance nette utilis e par la g n ratrice et l alimentation toujours disponible L affichage indique galement quand s est faite la derni re r initialisation et le temps de marche total accumul par la g n ratrice Plaque multiprises POWER BAR Cet indicateur statique colonnes donne un
24. n or modified parts that are not exempted by the Air Resources Board may not be used The use of any non exempted add on or modified parts by the ultimate purchaser will be grounds for disallowing a warranty claims Powermate will not be liable to war rant failures or warranted parts caused by the use of a non exempted add on or modified part 10 The repair or replacement of any warranted part otherwise eligible for warranty coverage may be excluded from such warranty coverage if the generator has been abused neglected or improperly maintained and such abuse neglect or improper maintenance was the direct cause of the need for repair or replacement of the part WARRANTED PARTS The following emission warranty parts list is covered Fuel Hose 12 English YAMAHA MOTOR CORPORATION U S A UTILITY EQUIPMENT ENGINES CALIFORNIA EMISSION CONTROL WARRANTY YOUR WARRANTY RIGHTS AND OBLIGATIONS The California Air Resources Board and Yamaha Motor Corporation U S A are pleased to explain the emission control system warranty on your 1995 or later utility equipment engine In California new utility and lawn and garden engines must be designed built and equipped to meet the State s stringent anti smog standards Yamaha must warrant the emission control system on your utility equipment engine for the periods of time listed below provided there has been no abuse neglect or improper maintenance of your utility equipment engine Your emission co
25. nnes destin es a utiliser cet appareil ont pris soin d en lire et d en comprendre le mode d emploi ou les directives avant de le mettre en marche IMPORTANTE Aseg rese que las personas que utilizar n este equipo lean y entiendan completamente estas instrucciones y cualquier instrucci n adicional proporcionada antes del funcionamiento www powermate com 08 06 0064238 MAJOR GENERATOR FEATURES 12 HP Yamaha OHV engine Cast iron cylinder sleeve Low oil sensor Receptacles on control panel DIGITECHTM Digital Information Center 7 gallon metal fuel tank Spark arrester Portability Kit CONTROL PANEL A 120 Volt GFCI Receptacle Ground Fault Circuit Interrupter duplex receptacle is rated so that a total of 20 amps may be drawn regardless of whether both halves or just one receptacle is used This receptacle may be used along with other receptacles provided the generator is not overloaded and total power drawn is kept within nameplate ratings Ground Fault Circuit Interrupter Conforms to U L 943 Class A and NEC requirements This device protects you against hazardous electrical shock that may be caused if your body becomes a path through which electricity travels to reach ground This could happen when you touch an appliance or cord that is live through faulty mechanism damp or worn insulation etc B 120 240 V 30 Ampere Twistlock Receptacle A maximum of 30 amps may be drawn from the 120 240 volt recept
26. nted part that is scheduled for replacement as required maintenance in the written instructions supplied is warranted for the period of time before the first scheduled replacement date for that part If the part fails before the first scheduled replacement date the part will be repaired or replaced by Powermate according to Subsection 4 below Any such part repaired or replaced under warranty will be warranted for the remainder of the period prior to the first scheduled replacement date for the part 4 Repair or replacement of any warranted part under the warranty provisions herein must be performed at an authorized Powermate warranty service center at no charge to the owner 5 The generator owner will not be charged for diagnostic labor that is directly associated with diagnosis of a defective emission related warranted part provided that such diagnostic work is performed at an authorized Powermate warranty service center 6 Powermate is liable for damages to other engine or generator components proximately caused by a failure under warranty of any warranted part 7 Throughout the generator warranty period stated above Powermate will maintain a supply of warranted parts sufficient to meet the expected demand for such parts 8 Any replacement part may be used in the performance of any warranty maintenance or repairs and must be provided without charge to the owner Such use will not reduce the warranty obligations of Powermate 9 Add o
27. ntie se limite quatre vingt dix 90 jours partir de la date d achat En ce qui concerne l entretien couvert par la garantie le client doit pr senter une preuve de la date d achat et il doit aviser la compagnie au cours de la p riode couverte par la garantie Pour tout ce qui touche l entretien couvert par la garantie Composez sans frais le 1 800 445 1805 ou crivez Powermate Corporation Product Services 4970 Airport Road P O Box 6001 Kearney NE 68848 U EXCLUSIONS ET LIMITATIONS LA COMPAGNIE NE PR SENTE AUCUNE AUTRE GARANTIE EXPRESSE OU IMPLICITE LES GARANTIES IMPLICITES INCLUANT LES GARANTIES DE QUALIT MARCHANDE ET DE CONFORMIT AUX BESOINS SONT PAR LA PR SENTE ABANDONN ES L ENTRETIEN COUVERT PAR LA GARANTIE D CRIT CI DESSUS EST UN RECOURS EXCLUSIF EN VERTU DE CETTE GARANTIE LA RESPONSABILIT POUR DES DOMMAGES ACCESSOIRES ET INDIRECTS EST EXCLUE JUSQU LA LIMITE AURORIS E PAR LA LOI Cette garantie vous donne des droits sp cifiques reconnus par la loi Vous pouvez galement b n ficier de certains autres droits lesquels varient d une province tat l autre Certaines provinces ou certains tats n autorisent pas de clauses de renonciation des garanties implicites ou de limites l gard de dommages accessoires ou indirects ainsi les clauses de renonciation et les exclusions ci dessus peuvent ne pas s appliquer vous CARACTERISTICAS PRINCIPALES DEL GENERADOR _ Motor 12 HP
28. ntrol system may include parts such as the carburetor or fuel injection system the ignition system and catalytic converter Also included may be hoses belts connectors and other emission related assemblies Where a warrantable condition exists Yamaha will repair your utility equipment engine at no cost to you including diagnosis parts and labor MANUFACTURER S WARRANTY COVERAGE The 1995 and later utility engines are warranted for two years If any emissions related part on your engine is defective the part will be repaired or replaced by Yamaha OWNER S WARRANTY RESPONSIBILITIES e As the utility equipment engine owner you are responsible for the performance of the required maintenance listed in your owner s manual Yamaha recommends that you retain all receipts covering maintenance on your utility equipment engine but Yamaha cannot deny warranty solely for the lack of receipts or for your failure to ensure the performance of all scheduled maintenance e As the utility equipment engine owner you should also be aware that Yamaha may deny you warranty coverage if your utility equipment engine or a part has failed due to abuse neglect improper maintenance or unapproved modifications e You are responsible for presenting you utility equipment engine to a Yamaha dealer as soon as a problem exists The warranty repairs should be completed in a reasonable time not to exceed 30 days If you have any questions regarding your
29. r any costs or labor performed without the Company s prior authorization Warranty Period Two 2 years from the date of purchase on products used solely for consumer applications if a product is used for business or commercial applications the warranty period will be limited to one 1 year from the date of purchase if a product is used for rental applications the warranty period will be limited to ninety 90 days from the date of purchase For warranty service the customer must provide dated proof of purchase and must notify the Company within the warranty period For warranty service Call toll free 800 445 1805 or write to Powermate Corporation Product Services 4970 Airport Road P O Box 6001 Kearney NE 68848 EXCLUSIONS AND LIMITATIONS THE COMPANY MAKES NO OTHER WARRANTY OF ANY KIND EXPRESS OR IMPLIED IMPLIED WARRANTIES INCLUDING WARRANTIES OF MERCHANTABILITY AND OF FITNESS FOR A PARTICULAR PURPOSE ARE HEREBY DISCLAIMED THE WARRANTY SERVICE DESCRIBED ABOVE IS THE EXCLUSIVE REMEDY UNDER THIS WARRANTY LIABILITY FOR INCIDENTAL AND CONSEQUENTIAL DAMAGES IS EXCLUDED TO THE EXTENT PERMITTED BY LAW This warranty gives you specific legal rights and you may also have other rights which vary from state to state Some states do not allow a disclaimer of implied warranties or the exclusion or limitation of incidental and consequential damages so the above disclaimers and exclusions may not apply to you CARACT RISTIQU
30. ra fechado y debe notificar a la Compa a dentro del per odo de garant a Para el servicio de garant a Llame sin costo al n mero 800 445 1805 o escriba a Powermate Corporation Product Services 4970 Airport Road P O Box 6001 Kearney NE 68848 EE UU EXCLUSIONES Y LIMITACIONES LA COMPA A NO OTORGA NINGUNA OTRA GARANT A DE NING N TIPO EXPL CITA O IMPL CITA POR ESTE MEDIO SE RENUNCIA A LAS GARANT AS IMPL CITAS INCLUYENDO GARANT AS DE COMERCIABILIDAD O DE ADAPTABILIDAD PARA UN PROP SITO PARTICULAR EL SERVICIO DE GARANT A DESCRITO ANTERIORMENTE ES EL RECURSO EXCLUSIVO CUBIERO POR ESTA GARANT A LA RESPONSABILIDAD CIVIL POR DA OS INCIDENTALES Y CONSECUENTES SE EXCLUYEN EN LA MEDIDA EN QUE LA LEY LO PERMITA Esta garant a le otorga derechos legales espec ficos y tambi n puede ser objeto de otros derechos que var an de estado a estado Algunos Estados no permiten la exenci n de responsabilidad de garant as impl citas o la exclusi n o limitaci n de da os incidentales o consecuentes de manera que las exenciones y exclusiones de responsabilidades pueden no ser aplicables a usted PARTS DRAWING SCHEMA DES PI CES DIAGRAMA DE PIEZAS TORQUE SERREZ TORSI N 30 50 FT LB 40 7 67 8 Nem TORQUE SERREZ TORSI N 10 17 FT LB 13 6 23 Nem TORQUE SERREZ TORSI N 7 10 FT LB 9 5 13 6 Nem PARTS LIST LISTE DES PI CES LISTA DE PIEZAS
31. receipts covering maintenance on your generator but Powermate cannot deny warranty solely for the lack of receipts You should however be aware that Powermate may deny you warranty coverage if your generator or a part has failed due to abuse neglect or improper maintenance or unapproved modifications You are responsible for presenting your generator to an authorized Powermate warranty service center as soon as the problem exists The warranty repairs should be completed in a reasonable amount of time not to exceed 30 days If you have a question regarding your warranty coverage you should call Powermate Product Service at 1 800 445 1805 DETAILS OF YOUR WARRANTY Subject to certain conditions and exclusions as stated below the warranty on emission related parts is as follows 1 Any warranted part that is not scheduled for replacement as required maintenance in the written instructions supplied is warranted for the period stated above If the part fails during the period of warranty coverage the part will be repaired or replaced by Powermate according to Subsection 4 below Any such part repaired or replaced under warranty will be warranted for the remainder of the period 2 Any warranted part that is scheduled only for regular inspection in the written instructions supplied is warranted for the warranty period stated above Any such part repaired or replaced under warranty will be warranted for the remaining warranty period 3 Any warra
32. ter This indicates the total number of hours the generator has run since manufacture Maintenance Timer This indicates the number of hours the generator has run since the last user reset This timer should be reset after every oil change or any other maintenance task Follow the instructions in the engine owners manual for proper engine maintenance intervals Reset Button Pressing and holding this button will reset the Maintenance Timer to 0 HRS CT C English PORTABILITY KIT INSTALLATION TOOLS REQUIRED 1 2 and 9 16 sockets and ratchets block s of wood minimum of 6 tall Refer to the parts list on page 9 WHEEL INSTALLATION 1 Block up end of generator opposite the fuel tank cap to install wheel kit 2 Insert wheel spacer item 39 into the center of the wheel item 28 3 Slide 3 8 x 4 25 bolt item 32 and 3 8 washer item 27 through the wheel item 28 then through the wheel bracket on the carrier with the offset side of the wheel hub against the wheel bracket 4 Thread 3 8 nyloc nut item 33 onto the bolt and tighten to securely clamp the wheel assembly to the carrier 5 Repeat above instructions for the remaining wheel FOOT INSTALLATION 1 Blocking up the engine side of the generator place the foot bracket item 43 under the carrier channel Thread a 5 16 18 x 4 bolt item 42 with a rubber foot item 29 through the mounting holes and thread a 5 16 flange nut item 47
33. warranty rights and responsibilities you should contact the Yamaha Customer Relations Department at 1 800 962 7926 Yamaha Motor Corporation U S A warrants to the ultimate purchaser and each subsequent purchaser Effective Date 1 1 95 thereafter that each new 1995 and later model year utility engine certified for sale and registered in California are Designed built and equipped so as to conform at the time of sale with all applicable regulations adopted by the California Air Resources Board and All warranted parts are free from defects in material and workmanship for the warranty period of the utility engine or the period prior to the first scheduled replacement point of the warranted part as required by the maintenance schedule if applicable whichever is less A defect exists when a deficiency in material or workmanship is such that an emission related warranted part does not function as designed The warranty period begins on the date that the utility equipment engine is delivered to an ultimate purchaser or on the date it is first placed in service WARRANTED PARTS INCLUDE the following Fuel Metering System Carburetor and internal parts or fuel injection Air fuel ratio feedback and control system Air Induction system Controlled hot air intake system Intake manifold Ignition System Spark plugs Magneto or electronic ignition system Spark advance retard system Exhaust Gas Recirculation EGR System EGR v
Download Pdf Manuals
Related Search