Harbor Freight Tools 5 Watt Foldable Solar Panel Charger Product manual
Contents
1. instructions Improper installation can create hazards Wear ANSI approved safety goggles and heavy duty work gloves during installation Do not wear jewelry or metal watches when working near solar panels wiring or batteries 12 Keep installation area clean and well lit 13 Keep out of reach of children 14 Keep bystanders out of the area during installation 15 Do not install when tired or when under the influence of drugs or medication Maintain product labels and nameplates These carry important safety information If unreadable or missing contact Harbor Freight Tools for a replacement WARNING Handling the cord on this product will expose you to lead a chemical known to the State of California to cause cancer and birth defects or other reproductive harm Wash hands after handling California Health amp Safety Code 25249 5 et seq Ase THESE INSTRUCTIONS Item 60449 For technical questions please call 1 800 444 3353 Page 3 Specifications Peak Output 5V 5W Note Output will decrease as the panel 18 1 2 L x 12 3 4 W gets hotter than room temperature 70 F Panel Size x 9 3 16 H open Angle solar intensity cloud cover and 10 1 2 x 5 folded other factors will effect output Installation at the beginning of this manual including all text under Read the ENTIRE IMPORTANT SAFETY INFORMATION section subheadings therein before set up or use of this product2. Note For additional information regarding the parts listed in the following pages refer to Parts List and Diagram on page 7 Setup 1 Select a location for the Solar Charger 4 Before charging remove protective where the Solar Panels face the sun PE covering from each Solar Panel and are not blocked by shadows Choose a location that protects the Panels from accidental damage 2 To hang the Solar Charger if desired EKE Solar Panel Angle thread rope not included through the Grommets CAUTION When hanging atitude 5 unit secure so that it cannot move 5 Angle face of Solar Charger toward true south according to chart that follows 2 Lati 21 45 Latitude 10 and hit anything in windy conditions 46 64 Latitude 15 Note Angle towards true north if installed in southern hemisphere WARNING Verify that whatever rope is hung from can support weight of the Foldable Solar Charger 6 Once proper location and angle have been reached the Solar Panels will begin generating electricity 3 The Grommets may also be used to hang the Foldable Solar Charger from nails fastened to a wall Page 4 For technical questions please call 1 800 444 3353 Item 60449 The Foldable Solar Charger may be used to charge Cell Phones MP3 Players Handheld GPS devices and portable game consoles It can also power some AA battery chargers 1 Unfold the Foldable Solar Charger 4 After use untie the Foldable Solar allow
3. Charger when it is folded are connected through a regulator F 9 5 Do not focus light on panel 3 This solar panel kit is not designed for tie in to a grid Only a licensed electrician and a licensed building contractor can safely design and implement a grid tie in system Any grid tie in system must meet all applicable building and electrical codes and must meet 6 This product may occasionally produce more current and or voltage than its rated output Increase output ratings by 25 when determining component required voltage and amperage ratings Page 2 For technical questions please call 1 800 444 3353 Item 60449 Refer to Section 690 8 of the National Electrical Code for an additional multiplying factor of 125 percent 80 percent derating which may apply 7 Do not attach to battery or power grid without proper regulator inverter and or charge controller 8 Install and use according to applicable National Electrical Code NEC standards 9 Verify that installation surface has no hidden utility lines before drilling or driving screws Service Precautions 1 Disconnect items being charged before cleaning 2 Do not allow children to play with or near this item or electrical components 3 Inspect before each use do not use if damaged parts are loose water is found inside the housing electrical insulation is cracked or damaged or connections are loose 10 Install only according to these 11
4. D TO THE BUYER THAT HE OR SHE IS QUALIFIED TO MAKE ANY REPAIRS TO THE PRODUCT OR THAT HE OR SHE IS QUALIFIED TO REPLACE ANY PARTS OF THE PRODUCT IN FACT THE MANUFACTURER AND OR DISTRIBUTOR EXPRESSLY STATES THAT ALL REPAIRS AND PARTS REPLACEMENTS SHOULD BE UNDERTAKEN BY CERTIFIED AND LICENSED TECHNICIANS AND NOT BY THE BUYER THE BUYER ASSUMES ALL RISK AND LIABILITY ARISING OUT OF HIS OR HER REPAIRS TO THE ORIGINAL PRODUCT OR REPLACEMENT PARTS THERETO OR ARISING OUT OF HIS OR HER INSTALLATION OF REPLACEMENT PARTS THERETO Limited 90 Day Warranty Harbor Freight Tools Co makes every effort to assure that its products meet high quality and durability standards and warrants to the original purchaser that this product is free from defects in materials and workmanship for the period of 90 days from the date of purchase This warranty does not apply to damage due directly or indirectly to misuse abuse negligence or accidents repairs or alterations outside our facilities criminal activity improper installation normal wear and tear or to lack of maintenance We shall in no event be liable for death injuries to persons or property or for incidental contingent special or consequential damages arising from the use of our product Some states do not allow the exclusion or limitation of incidental or consequential damages so the above limitation of exclusion may not apply to you THIS WARRANTY IS EXPRESSLY IN LIEU OF ALL OTHER WARRANTIES EXPRESS
5. OR IMPLIED INCLUDING THE WARRANTIES OF MERCHANTABILITY AND FITNESS To take advantage of this warranty the product or part must be returned to us with transportation charges prepaid Proof of purchase date and an explanation of the complaint must accompany the merchandise If our inspection verifies the defect we will either repair or replace the product at our election or we may elect to refund the purchase price if we cannot readily and quickly provide you with a replacement We will return repaired products at our expense but if we determine there is no defect or that the defect resulted from causes not within the scope of our warranty then you must bear the cost of returning the product This warranty gives you specific legal rights and you may also have other rights which vary from state to state THUNDERBOLT S yp 3491 Mission Oaks Blvd PO Box 6009 Camarillo CA 93011 800 444 3353
6. Owner s Manual amp Safety Instructions Save This Manual keep this manual for the safety warnings and precautions assembly operating inspection maintenance and cleaning procedures Write the product s serial number in the back of the manual near the assembly diagram or month and year of purchase if product has no number Keep this manual and the receipt in a safe and dry place for future reference THUNDERBOLT SOQ ITEM 60449 5 WAIT foldable solar panel charger Cell phone and cord not included Visit our website at http www harborfreight com Email our technical support at tech harborfreight com When unpacking make sure that the product is intact and undamaged If any parts are missing or broken please call 1 800 444 3353 as soon as possible AWARN l NG Copyright 2012 by Harbor Freight Tools All rights reserved No portion of this manual or any artwork contained herein may be reproduced in Read this material before using this product any shape or form without the express written consent of Harbor Freight Tools Failure to do so can result in serious injury Diagrams within this manual may not be drawn proportionally Due to continuing SAVE THIS MANUAL improvements actual product may differ slightly from the product described herein Tools required for assembly and service may not be included WARNING SYMBOLS AND DEFINITIONS This is the safety alert symbol It is used to alert you to potential personal injury hazard
7. ing the Solar Panels to have Charger if it is hanging Then full unobstructed sunlight fold the Solar Charger keeping it losed with the hook and tab Note The Foldable Solar Charger must eee ene me ie have at least four hours of direct sunlight 5 Keep the Foldable Solar Charger to fully charge a small electronic device closed when not in use 2 Insert the device s charging cord into the WARNING Do not apply pressure or Foldable Solar Charger s USB Output press down on the folded Solar Charger 3 Once the device is recharged remove the charging cord MERA SClar Item 60449 For technical questions please call 1 800 444 3353 Page 5 Procedures not specifically explained in this manual must be performed only by a qualified technician ACAUTION TO PREVENT INJURY FROM ELECTRIC SHOCK Before service maintenance or cleaning Disconnect solar panel TO PREVENT INJURY FROM ELECTRIC SHOCK OR CUTS Do not use damaged solar panel If wiring insulation is damaged or weathered glass is cracked or housing is opened have the problem corrected before further use Note Itis normal to see up to 20 degradation in amorphous silicon solar panel performance within the first 6 months before the amorphous coating stabilizes Cleaning Clean and inspect the Foldable Solar Clean solar panels one at a time with Charger MONTHLY or more frequently to maintain peak efficiency 1 Wear electrically insulated glove
8. s Obey all safety messages that follow this symbol to avoid possible injury or death n e a ak i aaad N cere opener ae rome rea nn alee CAUTION Important Safety Information WARNING Read all safety warnings and instructions Failure to follow the Addresses practices not related to personal injury warnings and instructions may result in electric shock fire and or serious injury Save all warnings and instructions for future reference The warnings precautions and instructions discussed in this instruction manual cannot cover all possible conditions and situations that may occur It must be understood by the operator that common sense and caution are factors which cannot be built into this product but must be supplied by the operator Installation Precautions 1 Install all sensitive electrical standards established by the area power components including wiring company Improper grid tie in can result connections regulator and battery in electrocution fire and other serious inside a weatherproof enclosure personal injury and property damage to prevent electric shock An incorrectly installed grid tie in system can cause feedback voltage resulting in 2 Do not wire multiple panels in series electrocution of electrical utility workers If you need to connect two or more solar panels together this work must be done 4 Do not apply pressure or press down by a qualified electrician unless they on the Solar
9. s and ANSI approved safety goggles Dry solar panels and outdoor wiring thoroughly 2 Disconnect batteries and any items being charged before cleaning Adjustment To increase efficiency mild non abrasive cleanser and soft cloth and paper towels Do not clean with brushes or abrasive cleaners Inspect the general condition of the Foldable Solar Charger Check for wiring insulation damage or weathering cracked glass cracked or broken parts loose or corroded contacts and any other condition that may affect its safe operation In the Summer decrease 1 In the Winter increase the panels angle by 10 Page 6 For technical questions please call 1 800 444 3353 the angle by up to 10 In the Spring and Fall keep the panels at the angle recommended on page 4 Item 60449 Parts List and Diagram Description Qty Part Description Record Serial Number Here Note Some parts are listed and shown for illustration purposes only and are not Note If product has no serial number available individually as replacement parts record month and year of purchase instead Item 60449 For technical questions please call 1 800 444 3353 Page 7 PLEASE READ THE FOLLOWING CAREFULLY THE MANUFACTURER AND OR DISTRIBUTOR HAS PROVIDED THE PARTS LIST AND ASSEMBLY DIAGRAM IN THIS MANUAL AS A REFERENCE TOOL ONLY NEITHER THE MANUFACTURER OR DISTRIBUTOR MAKES ANY REPRESENTATION OR WARRANTY OF ANY KIN
Download Pdf Manuals
Related Search