Dacor ERV36-ER User's Manual
Contents
1. Contact power company Immediately press Up Down switch then dis connect the power plug Remove the obstruc tion Reconnect the vent power plug and press Up Down switch to raise or lower intake Gas flame is being pulled by Short duct run or high output of Reduce blower speed to a lower setting draw of vent system make ventilating force very strong Vent intake raises or lowers An obstruction is interfering with partially then stops the vent intake movement Warranty and Service Product Maintenance Do not perform any maintenance other than that instructed in the Care and Cleaning section of this manual A qualified service technician should perform all other service Getting Help Before you obtain service please review the Before You Call for Service section of this manual starting on page 5 If you have performed the checks in the Prob lem Solution Guide and the problem has not yet been remedied please visit our web site or contact the Dacor Customer Service Team for a listing of Dacor authorized service agents Before requesting service become familiar with the warranty terms and conditions on this page Contact us through our web site at WWW Dacor Dacor Customer Service Team Tel 800 793 0093 Fax 626 403 3130 Business Hours 6 00 a m 5 00 p m Pacific Time You may also write us at Dacor Customer Service Team 1440 Bridge Gate Drive Diamond Bar CA 91765 At Dacor we believe tha2. A D Kitchen Dealer Showroom E Home Show 2 Where did you buy your Dacor appliances A A Appliance Dealer A B Kitchen Dealer a C Builder Supplier 3 For what purpose was the product purchased A A Replacement only A Partofa Remodel 4 Whatis your household income A A Under 75 000 a B 75 000 100 000 A 100 000 150 000 5 What other brands of appliances do you have in your kitchen A Cooktop B Oven 6 Would you buy or recommend another Dacor product Yes Comments or DO DO m Builder Architect Designer Another Dacor Owner Model Home Other Builder Other New Home Other 150 000 200 000 200 000 250 000 Over 250 000 C Dishwasher D Refrigerator Thank you very much for your assistance The information you have provided will be extremely valuable in helping us plan for the future and giving you the support you deserve Web site Corporate phone www Dacor com 800 793 0093
3. for assistance with any of your prod Dacor Customer Service Team ate Drive Telephone 800 793 0093 Fax 626 403 3130 Hours of Operation Monday through Friday 6 00 A M to 5 00 P M Pacific Time Web Site www Dacor com Thank you for choosing Dacor for your home We are a company built by families for families and we are dedicated liver a high evel of performance and We are confident that your new Dacor product will de to serving yours enjoyment for many years to come Sincerely Cheryl Crowe Director Customer Satisfaction 200 7 Dacor all rights reserved Important Safety Instructions INSTALLER LEAVE THESE INSTRUCTIONS WITH THE APPLIANCE CUSTOMER READ THIS USE AND CARE MANUAL AND THE USE AND CARE MANUAL FOR THE RANGE COMPLETELY BEFORE USING EITHER APPLIANCE SAVE IT FOR FUTURE REFERENCE IT CONTAINS IMPORTANT USE AND CARE INFORMATION KEEP YOUR SALES RECEIPT OR CANCELED CHECK IN A SAFE PLACE PROOF OF ORIGINAL PURCHASE DATE IS REQUIRED FOR WAR RANTY SERVICE If you have any questions call Dacor Customer Service Team 1 800 793 0093 U S A and Canada Monday Friday 6 00 a m to 5 00 p m Pacific Time Web site www Dacor com Have the complete model and serial number for your appliance available The model and serial number are printed on the appliance data label on the front of the unit Write these numbers belo
4. vary from state to state Notes Notes fold here BUSINESS REPLY MAIL FIRST CLASS MAL PERMT NO 4507 DIAMONDBAR CA POSTAGE WLL BE PAID BY ADDRESSEE DACOR INC ATTN WARRANTY PROCESSING DEPT 1440 BRIDGE GATE DR STE 200 PO BOX 6532 DIAMOND BAR CA 91765 9861 POSTAGE NECESSARY IF MAILED IN THE UNITED STATES gacor The Life of the Kitchen IMPORTANT Please visit www Dacor com to activate your warranty online WARRANTY INFORMATION Your warranty will not be activated until you activate it online or return this form to Dacor If you have purchased more than one Dacor product please return all forms in one envelope or activate the warranty for each product online Please rest assured that under no conditions will Dacor sell your name or any of the information on this form for mailing list purposes We are very grateful that you have chosen Dacor products for your home and do not consider the sale of such information to be a proper way of expressing our gratitude Owner s Name Last Please Print or Type First Middle Street City State Zip Purchase Date Email Telephone Dealer City State Zip Your willingness to take a few seconds to fill in the section below will be sincerely appreciated Thank you 1 How were you first exposed to Dacor products Please check one only A TV Cooking Show A B Magazine A C Appliance Dealer Showroom
5. Jacor AND CARE MANUAL DOWNDRAFT RAISED VENT For use with models ERV36 ERV36 ER ERV48 ERV48 ER PRV30 PRV36 PRV46 Style Varies ERV36 Shown Table of Contents Important Safety Instructions pp 1 Operating Your Raised 3 Care and Cleaning use 4 Before You Call for 5 Warranty and Service pp 6 Nole A o ERROR 7 Part No 103107 Rev B cor Life of the Kitchen The To Our Valued Customer atulations ON your purchase of the very latest in Dacor products Our unique combination of features style and your home Cong performance make US The Life of the Kitchen and a great addition to rself with the controls functions and full potential of your new Distinctive Appliance we with the Important Safety Instructions In order to familiarize you suggest that you thoroughly read this USO and care manual beginning section are designed and manufactured with quality and pride Dacor appliances oduct please first check the Before You Call for company value Should you ever experience a problem with your Pf Service section of this manual for guidance provides us valuable customer input helps us 10 continuously improve our products and services so please feel free 10 contact our Customer Service Team
6. a damaged product immediately contact your dealer or builder Do not install or operate this unit if it has been damaged dropped has damaged electrical wiring or is not working properly Use this raised vent only for its intended purpose as outlined in this use and care manual Do not use this unit to vent hazardous or explosive materials or vapors This unit is not intended for commercial use If you have any questions contact Dacor This raised vent must be installed by a qualified installer according to the accompanying installation instructions All installation work must be performed in accordance with all applicable codes and standards including fire rated construction Keep all packaging materials away from children Plastic bags can cause suffocation Do not install repair or replace any part of this unit unless specifically recommended in the literature accompanying it A qualified service technician should perform all other service Contact the Dacor Customer Service Team for examination repair or adjustment Sufficient air is needed for proper combustion and exhausting of gases through the flue chimney of fuel burning equipment to prevent back drafting Follow the heating equipment manufacturer s guidelines and safety standards such as those published by the National Fire Protection Association NFPA and the American Society for Heating Refrigeration and Air Conditioning Engineers ASHRAE and the local code autho
7. any objects including cookware on top of the vent top cap Do not interfere with the movement of the vent intake in any way If the vent intake becomes jammed while being raised or lowered immediately press the Up Down switch once to stop the intake motion then disconnect the power cord Remove the obstruction reconnect the power plug and press the Up Down switch to continue raising or lowering the intake Clean this appliance only as instructed in this manual Use only the cleaners specified Never leave a cooktop or range unattended during use Operating Your Raised Vent Operation IMPORTANT Reduce the fan speed if the flame on a gas cooktop is being drawn by the vent system Drawing of the flame is anormal occurrence with powerful vent systems especially when installed with short duct runs Always raise the vent intake and activate the blower The direction of travel of the vent intake cannot be reversed while it is moving The intake must complete a full up or down cycle before changing directions id whenever using the cooktop Eliminate air currents in the vent vicinity by shut To operate the ERV downdraft vent press the switch located on the top cap when the vent intake is in the down position The intake will take approximately 10 seconds to reach its uppermost position where it will stop Once in the up position the blower will turn on at the speed at which the variable speed control was set whe
8. gasoline inside or in the vicinity of this or any other appliance Keep items that could explode such as aerosol cans away from the burners and oven Do not store flammable or explosive materials in adjacent cabinets or areas WARNING Always run the raised vent when operating the range Never allow the filters or vent openings to become blocked or clogged Do not allow foreign objects such as cigarettes or napkins to be sucked into the vent holes TO REDUCE THE RISK OF INJURY TO PERSONS IN THE EVENT OF A RANGE TOP GREASE FIRE e SMOTHER FLAMES with a close fitting lid cookie sheet or metal tray then turn off the burner BE CAREFUL TO PREVENT BURNS If the flames do not go out immediately EVACUATE AND CALL THE FIRE DEPARTMENT e NEVER PICK UP A FLAMING PAN you may be burned e DO NOT USE WATER including wet dish clothes or towels a violent steam explosion may result e Use a fire extinguisher ONLY if You have a Class ABC extinguisher and you already know how to operate it The fire is small and contained in the area where it started The fire department is being called You can fight the fire with your back to an exit READ AND SAVE THESE INSTRUCTIONS Important Safety Instructions General Safety Precautions To reduce the risk of fire electric shock serious injury or death when using your appliance follow basic safety precau tions including the following WARNING If you receive
9. n the intake was last lowered The blower speed may be adjusted by turning the variable speed con trol The blower speed may be adjusted whenever the vent intake is in the fully raised position to cook to establish an airflow pattern in the room Adjust the fan speed according to the volume of the cooking exhaust ting nearby windows and doors turning off ceiling fans and closing adjacent heating and air conditioning outlets Place your largest frying pans skillets and stock pots on the rear burners whenever possible as the draft is strongest closest to the vent intake Variable Speed Control Higher O Lower e Turn the blower off by pressing the Up Down switch Countertop again Pressing the switch shuts off the blower and Top Cap Up Down Switch lowers the vent intake Filters Operating Tips e Activate the raised vent a few minutes before starting olo Parts the of Raised Vent Shown Appearance varies with model number Care and Cleaning WARNING Clean the vent only in the manner specified To avoid dangerous fumes or damage to your vent s surfaces use only the types of cleaning solutions specified in this manual To avoid personal injury turn off the range and vent and make sure all surrounding surfaces are cool before cleaning Always wipe stainless steel silver colored surfaces with the grain To prevent scratching do not use abrasive cleaners or scrubbe
10. overed e Service calls to educate the customer in the proper use and care of the product e Failure of the product when used for commercial business rental or any application other than for resi dential consumer use e Replacement of house fuses or fuse boxes or reset ting of circuit breakers e Damage to the product caused by accident fire flood or other acts of God e Breakage discoloration or damage to glass metal surfaces plastic components trim paint or other cos metic finish caused by improper usage or care abuse or neglect THE REMEDIES PROVIDED FOR IN THE ABOVE EXPRESS WAR RANTIES ARE THE SOLE AND EXCLUSIVE REMEDIES THERE FORE NO OTHER EXPRESS WARRANTIES ARE MADE AND OUTSIDE THE FIFTY STATES OF THE UNITED STATES THE DIS TRICT OF COLUMBIA AND CANADA ALL IMPLIED WARRANTIES INCLUDING BUT NOT LIMITED TO ANY IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR USE OR PURPOSE ARE LIMITED IN DURATION TO ONE YEAR FROM THE DATE OF ORIGINAL PURCHASE IN NO EVENT SHALL DACOR BE LIABLE FOR INCIDENTAL EXPENSE OR CONSEQUENTIAL DAM AGES NO WARRANTIES EXPRESS OR IMPLIED ARE MADE TO ANY BUYER FOR RESALE Some states do not allow limitations on how long an implied warranty lasts or do not allow the exclusion or limitation of inconsequential damages so the above limi tations or exclusions may not apply to you This warranty gives you specific legal rights and you may also have other rights that
11. rities Before performing any type of cleaning or service make sure that the power plug for the raised vent is disconnected from the electrical outlet Do not leave children or pets alone or unattended in the area around the range when it is in use Never allow children to sit or stand on an appliance Do not let children play with a range or the raised vent Do not store items of interest to children above or around the range Make sure individuals who use the range or cooktop and raised vent are able to operate it properly prong ground WARNING Clean the filters and all grease laden surfaces often according to the cleaning instructions in this manual to prevent grease fires and maintain performance Do not tamper with the controls DO NOT TOUCH THE SURFACES OF THE RAISED VENT OR RANGE DURING OR IMMEDIATELY AFTER USE Do not use water on grease fires A violent steam explosion may result Smother any flames with a lid cookie sheet or flat tray Use baking soda or a foam extinguisher to extinguish flaming grease Be careful to avoid getting burned Do not allow acids citrus juices tomato sauces etc to remain on the unit s surfaces The finish may stain Do not try to remove heavy spills with a sharp object such as a knife or metal spatula Sharp objects may scratch the appliance s surfaces This appliance is equipped with a three prong grounding plug for your protection against possible electric shock hazard
12. rs on stainless steel surfaces To avoid damage to the fan do not reinstall damaged filters To avoid damage do not clean the filters in a dishwasher Cleaning the Filters Clean the filters and surrounding areas regularly to pre vent grease build up 1 2 Raise the vent to the up position to clean the filters To remove the intake filters gently grasp each filter on both ends and push down Pull the top of the filter out toward the front of the unit After removing the filters wipe all surrounding areas external and internal with a sponge or cloth moist ened with a mild detergent Rinse off the surrounding areas with water Remove all moisture by wiping with a soft dry polishing cloth Hand wash the filters in hot water with mild detergent solution Dry the filters completely before re installing them Filter Removal Cleaning the Top Cap Clean the top cap only when the intake vent is in the low ered position Gently wipe the top cap surfaces with a sponge or soft cloth moistened in a mild detergent solution whenever they becomes soiled Avoid introduction of moisture into the switch area Before You Call for Service Problem Solution Guide Nothing works Raised vent not connected to elec Make sure power plug is connected to electri trical power cal outlet Power to vent s electrical outlet is Turn on power at circuit breaker or fuse box off Check for tripped breaker or blown fuse
13. s It must be plugged into a dedicated grounded electrical outlet Where a standard two prong wall receptacle is encountered it is the responsibility of the customer to have it replaced with a dedicated properly grounded three prong wall receptacle Do not under any circumstances Cut or remove the third ground prong from the power cord Use an adapter plug Use an extension Use a power cord that is frayed or damaged Use of a ground fault interrupter GFI is not recommended Power cord Grounded with three type ing plug N 2 electrical a outlet Important Safety Instructions WARNING Before operating the raised vent verify that pot handles or other objects will not interfere with the raising and lowering of the vent intake To prevent spillage and damage to the vent system turn cookware handles to the side so that they will not be hit when the vent moves to the up position Clean liquid spills immediately If liquid enters the vent intake then turn off the blower disconnect the power supply and carefully wipe up all liquid See the Care and Cleaning section of this manual Never operate the vent without the filters in place Do not operate the blower if a flame or flare up develops In the event of a flame immediately turn off the blower Smother the flame or use an appropriate class dry chemical or foam type fire extinguisher WARNING Do not set or rest
14. t our quality of service equals that of our product Should your experience with our ser vice network or product be different please contact our Customer Service Team and share your encounter with us We will do our utmost to resolve the situation for you and deliver on our Dacor promise If you need anything clarified just let us know Warra nty What Is Covered CERTI FI CATE OF WARRANTIES DACOR RAI SED VENTS WITHIN THE FIFTY STATES OF THE U S A THE DIS TRI CT OF COLUMBIA AND CANADA FULL ONE YEAR WARRANTY If your DACOR product fails to function within one year of the original date of purchase due to a defect in material or workmanship DACOR will remedy the defect without charge to you or subsequent users The owner must pro vide proof of purchase upon request and have the appli ance accessible for service Warranty is null and void if non CSA approved product is transported from the U S OUTSI DE THE FIFTY STATES OF THE U S A THE DISTRICT OF COLUMBI A AND CANADA LIMITED FIRST YEAR WARRANTY If your DACOR product fails to function within one year of the original date of purchase due to a defect in material or workmanship DACOR will furnish a new part F O B factory to replace the defective part All delivery instal lation and labor costs are the responsibility of the pur chaser The owner must provide proof of purchase upon request and have the appliance accessible for service What Is Not C
15. w for future reference Model Number Serial Number Date of Purchase For service and warranty information see page 6 Since Dacor continuously improves the quality and perfor mance of our products we may need to make changes to the appliance without updating this manual Important Information About Safety Instructions The Important Safety Instructions and warnings in this manual can t cover all possible problems and condi tions that can occur Use common sense and caution when installing maintaining or operating this appliance Always contact the Dacor Customer Service Team about problems or conditions that you don t understand Safety Symbols and Labels DANGER Immediate hazards that WI LL result in severe personal injury or death WARNING Hazards or unsafe actions that COULD result in severe personal injury or death CAUTION Hazards or unsafe actions that COULD result in minor personal injury or property damage DANGER IMPORTANT If you smell gas e Do not use or light any appliance e Do not touch any electrical switch or use any electrical devices including the telephone in your building e From neighbors phone immediately call the gas supplier Follow the gas supplier s instructions e f you cannot contact the gas supplier call the fire department IMPORTANT To avoid the possibility of explosion or fire do not store or use combustible flammable or explosive vapors and liquids such as
Download Pdf Manuals
Related Search