Cooper Lighting HR117 User's Manual
Contents
1. SURE LITES Installation Instructions for HR87 HR117 HR12117 Series IMPORTANT SAFEGUARDS f WHEN USING ELECTRICAL EQUIPMENT BASIC SAFETY PRECAUTIONS SHOULD ALWAYS BE OBSERVED INCLUDING THE FOLLOWING Ea READ AND FOLLOW ALL SAFETY Some units do not require a toad fuse because the solid state transfer i i circuit is current limited Transfer circuit will automatically shut down if INSTRUCTIONS overloaded 2 Do not use outdoors 10 Higher current units utilize a transfer relay for remote load and require fusing Check fuse replacement label when replacing fuses DO NOT 3 Do not let power supply cords touch hot surfaces exceed rating shown on the fuse replacement label 4 Oo not mount near gas or electric heaters 11 Caution Halogen cycle lamp s may be used in the equipment To 5 Equipment should be mounted in locations and at heights where it will avoid shattering Do not operate lamp in ex of rated voltage not readily be subjected to tampering by unauthonzed personnel Protect lamp against abrasion and scratches and against liquids when 6 The use of accessory equipment not recommended by Sure Lites may lamp is operating Dispose of lamp with care cause an unsafe condition 12 Halogen cycle lamps operate at high temperatures Do not store or 7 Do not use this equipment for other than its intended purpose place flammable materials near lamp 8 The equipment covered by these instructions is approved for remote 42. SAVE THESE INSTRUCTIONS fixtures Check the remote wattage label to determine remote capability DO NOT exceed TOTAL OUTPUT RATING of equipment INSTALLATION Step 7 Remove cover and mount unt securaly in place Step 2 When connecting unit directly to an electrical box insert bushing supplied with unit 7 8 KO Stop 3 Extend unswitched D4 hour supply of rated voltage and connect per diagram Cap unused ine lad Connect ground in accordance with NEC or local codas Circuit should not be energized at this tune Step 4 if remote lamps are to be connected extend DC crcuit per Article 700 and 720 of the NEC and connect to yellow and violet leads provided Step 5 Install batterie and connect battery RED and SLUE battery leads per wiring diagram Lamps will not light at this time Step amp Turn on AC supply and operate test switch DC lamps will come on Charge indicator wil stay on Release test switch DC lamps will extinguish Step 7 Replace cover MAINTENANCE Replace batteries every 8 to 10 years accorcing to ambient Equipment should be tested regularly in accordance with local codes For multiple battery units replace all batteries at the same ume NOTE Servicing of any parts should be performed by qualfied personnel For replacement lamps fuse or PC board see fixture labels OPERATION 1 To test depress test switch DC lamps will come on 2 Release test switch DC lamps will exti
3. nguish CAUTION This series emergency light is furnished with a sophisticated low voltage dropout circuit to protect battery from over discharge after its useful output has been used Allow 24 hour recharge time after installation or power failure for full load testing TROUBLE SHOOTING GUIDE EMERGENCY LAMPS DO NOT COME ON PILOT LIGHT OUT BEFORE TEST 1 Check AC Supply Be sure unit has 24 hour AC supply 2 AC Supply on Pilot light out Replace charge circuit 3 Pilot light on Lamps do not light Higher output shorted or battery not connected EMERGENCY LAMPS COME ON DIM 1 Battery discharged Permit unit to charge 24 hours and then retest If larnps are stil on dim check charger for charge function If functioning properly raplace battery 2 Remote lamps dim Check wire size to remote lamps against wire size chart if following the above trouble shooling hints does not solve your problem contact you local Sure Lites Representative or the factory for assistance COOPER Lighting SURE LITES 1121 Highway 74 South Peachtree City GA 30269 1 01 049000008 LOCAL LAME LOCA LAMS THEE WIRES ARE POR THE HEAD FAATHERT FROM APE FOR THE THAD FARTHEGT es TECTO HUO MERRIER MHE THE CROUST JONO THE IGAD NEAREST RE CAGI SQA VPL NTG THE Coast FE DD 6 AG Ha te heu 204 a BOARD WIRING DIAGRAMS WITH RELAY WIRING DIAGRAMS WITHOUT RELAY BLUE FOR HAG amp HAIZI7 GAP UNUSED WIRES G
4. rientation of edge connect slots may vary kom thal shown COOPER Lighting SURE LITES 1121 Highway 74 South eee City GA 30269 1 01 049000098A
Download Pdf Manuals
Related Search