Lanier 4800053
Contents
1. TICS Appearance Black Melting point 110C Form Powder Vapor pressure n a Odor Slight plastic odor Vapor density n a Solubility in Water Insoluble Evaporation rate n a Specific gravity N a Boiling point n a Bulk Density 1 2 g cm Section 10 Stability and Reactivity Conditions to avoid none Materials to avoid none Stability Stable Hazardous decomposition products CO and CO2 and other decomposition products when burned Section 11 Toxicological Information Ames test negative Acute oral toxicity gt 5000mg kg rat Section 12 Environmental Ecological Information Acute toxicity to fish gt 500 mg kg 96hr Section 13 Disposal Consideration Used Toner should be disposed of under conditions that meet all federal state and local environmental regulations Disposal regulations vary from locality to locality therefore consult your local Lanier office or the EPA to determine the proper method for disposal Do not incinerate loose or spilled Toner Section 14 Transportation Information None This is not a hazardous product Section 15 Regulatory Information WHMIS Legislation Canada This is not a controlled product UN No None allocated Section 16 Miscellaneous Information Judgment as to the suitability of information contained herein for user s purposes is the responsibility of the purchaser Therefore although reasonable care has been taken in the preparation of this information Lanier Worldwide Inc extend2. comfort Health Hazards of Long Term exposure Chronic A manufacturer sponsored chronic inhalation study in rats using a special test toner revealed there were no lung changes at all in the lowest exposure level 1mg m the most relevant level to potential human exposures A very slight degree of fibrosis was noted in 25 of the animals at the middle exposure level 4mg m while a slight degree of fibrosis was observed at the highest exposure level 16mg m in all animals These findings are attributed to Lung Overloading a generic response to excessive amount of any dust retained in the lungs for a prolonged interval The special test toner was ten times more respirable than commercially available toner to comply with EPA testing protocol and would not function properly in Xerographic equipment Carbon Black is listed on the IARC Monograph and the Massachusetts Substance List The IARC has evaluated the evidence for the carcinogenicity of Carbon Black as inadequate to determine a carcinogenic risk for humans This product contains no known hazardous materials as defined by the OSHA Hazard Communication Standard 29 CFR 1910 1200 Section 4 First Aid Measures Remove to fresh air if effects occur Get medical In case of contact immediately flush eyes with Inhalation attention if needed Eye Contact water for 15 minutes Get medical attention if needed Skin Contact Wash with soap and water Ingestion Dilute stomach contents with severa
3. l glasses of water Get medical attention Section 5 Fire Fighting Measures Suitable extinguishing media COs dry chemical foam or water Extinguishing media which may not be used for safety reasons none This material will burn in case of fire The decomposition products are CO COs and Nox Avoid inhalation of smoke Special protective equipment for fire fighters none UEL n a LEL n a MATERIAL SAFETY DATA SHEET Page2of 2 CP 342 Section 6 Accidental Release Measures Spill leak Procedures If spilled sweep up using an approved toner vacuum with a 0 5 micron filter or smaller such as the Atrix AAA Toner Vacuum or 3M Toner Vacuum Use of a vacuum cleaner not rated for toner particles could result in a fire or personal injury Remove residue with soap and cold water Miscellaneous Keep product out of sewers and watercourses Personal protection Avoid inhalation of dust Section 7 Handling and Storage Special Handling Cleanse skin after contact before breaks or meals and end of workday Special Storage Avoid direct sunlight Keep out of reach of children Store in a cool dry place Below 35C 95F Section 8 Exposure Control and Personal Protection Information Respiratory Protection none required under normal use Hand Protection none required under normal use Eye Protection none required under normal use Skin Protection none required under normal use Section 9 Physical and Chemical Properties CHARACTERIS
4. o LANiER Lanier Worldwide Inc 2300 Parklake Dr N E Atlanta GA 30345 2979 Emergency Telephone 800 551 3087 MATERIAL SAFETY DATA SHEET Section 1 Chemical Product and Company Information Identity 5635 5645 Toner MSDS No CP 342 Product ID 480 0053 Issued 11 08 2006 Supersedes 10 19 2006 Synonyms Date 11 08 2006 amp Common Toner for Lanier 5635 5645 2145 Names 2045 5235 5245 5435 5445 LP145n Prepared by EH amp S Department 770 496 9500 Approved by Larry Choskey Health amp Safety Manager Uses Lanier 5635 5645 2145 2045 5235 5245 5435 5445 LP145n Chemical Formula Mixture Section 2 Composition Information on Ingredients PERCENT CAS No EXPOSURE LIMITS SOURCE Polyester resin lt 60 117581 13 2 Not listed N a Polyester resin lt 60 116736 81 3 Not listed N a Polyester resin lt 30 149367 99 7 Not listed N a Carbon black lt 15 1333 86 4 3 5mg m 3 5mg m OSHA PEL ACGIH TWA Carnauba wax lt 10 8015 86 9 Not listed N a PEL as the product 15mg m total dust 5mg m respirable dust TLV as the product 10mg m total dust 5mg m respirable dust Section 3 Hazards Identification HMIS Rating FLAMMABILITY 1 HEALTH 1 REACTIVITY 0 SPECIAL none Health Hazards Acute Chronic Immediate and Potential Minimum irritation to respiratory tract may occur as with exposure to any non toxic dust May cause gasping if inhaled Inhalation should be avoided May cause temporary eye dis
5. s no warranties makes no representations and assumes no responsibility as to the accuracy or suitability of such information for application to user s intended purposes or for consequences of its use All materials may present unknown hazards and should be used with caution Although certain hazards are described herein we do not guarantee that these are the only hazards that exist Information on this data sheet represents our current data and best opinion as to the proper use in handling of this product under normal conditions On the basis of the data available to us this product is not a dangerous substance One should however observe the usual precautionary measures for dealing with chemicals
Download Pdf Manuals
Related Search