Home

Heartland Owners Manual

Contents

1. Irmik ee reid er et mE Fa PIE nw 1 ES eee 51 F ril T m 25 pimi BE Under no circumstances should the respective loads ever exceed these ratings Dealer installed equipment will reduce CCC If the loaded weight of your RV exceeds the GVWR or the weight of any axle exceeds that axle s GAWR the RV is overloaded and you must remove items to bring the weight down to or below the GVWR or GAWR Pin Weight To determine the pin weight of the vehicle you must weigh the tow vehicle with the trailer hitched Record this weight Then disconnect the trailer and weigh the tow vehicle again Subtract the difference between the two weights and you will arrive at your pin hitch weight Adjust your cargo accordingly to remain within 15 27 of the GVWR of the 5th wheel 10 15 on a Travel Trailer The GVWR is the GAWR added to the pin hitch weight HEARTLAND Recreational Vehicles LLC Loading Instructions Whether you start out for a weekend jaunt or a longer trip the first thing you are going to do is load such items as food clothing bedding and recreational equipment As you become experienced in RV living you will learn what is necessary and what merely takes up storage space __ Norice M EMPTY ALL HOLDING TANKS BEFORE FILLING FRESH WATER TANK OTHERWISE YOU WILL LIMIT CARGO CAPACITY MO
2. Holding Tank Flush System A holding tank flush kit may be installed on your unit To use this system connect a water hose to the flush kit connector After connecting your water hose turn on the water to begin to flush your tank For best results leave the dump valve closed until you have flushed the tank Do not leave the flush system unattended unless you decide to leave your dump valves open See the flush kits manufacturer s operating instruction for full details and instruction Sanitizing System A WARNING POTABLE WATER ONLY SANITIZE FLUSH AND DRAIN BEFORE USING SEE INSTRUCTION MANUAL FAILURE TO COMPLY COULD RESULT IN DEATH OR SERIOUS INJURY To assure complete sanitation of your potable water system the following procedures are recommended for a new system For one that has not been used for a period of time and for one which may have become contaminated 1 Prepare a chlorine solution using one 1 gallon of water and one quarter 1 4 cup of household bleach 5 sodium hypochlorite solution With tank empty pour one 1 gallon of solution into the tank for each fifteen 15 gallons of tank capacity NOTE As an option several commercial solutions are available and should be used as directed on the package 2 Complete filling of tank with fresh water Operate all faucets to release trapped air Pressuring entire system with pump if available and turn off pump 3 Allow to stand for three 3 hours
3. d mmo ee LIE ee ee mepo ee ee E RD ram umm ir rcumel ri Am i uam mm p m nr 11 mm a m Ema ee mri rmm m 55 PLUMBING Fresh Water Fresh water is provided by filling the FRESH WATER TANK or by hooking directly to a city water connection These sources supply water for the kitchen sink shower lavatory toilet and water heater Fill the FRESH WATER TANK using the connection shown on the left side of the photo below City Water and Gravity Fill Connections Located on the exterior of the coach is the CITY WATER INLET Connect a hose to a city pressurized faucet to the connection on the right of the photo above Fresh Water Tank UNLOCK the GRAVITY WATER FILL DOOR and use a hose or vessel to fill the water tank Watch your monitor panel inside to determine when the tank is full 85 NOTICE EB NEVER LEAVE YOUR COACH UNATTENDED WHILE FILLING THE FRESH WATER TANK ALTHOUGH PROPER VENTING IS ALLOWED FOR OVERFLOW THE WATER PRESURE CAN EXPAND THE TANK AND CAUSE SEVERE DAMAGE TO YOUR UNIT DEN NOTICE am A PRESSURE REGULATOR SHOULD ALWAYS BE USED WHEN CONNECTING TO CITY WATER EXCESSIVE WATER PRESSURE CAN DAMAGE LINES AND CONNECTIONS CAUSING WATER DAMAGE TO YOUR RV MAKE SURE WATER PRESSURE NEVER EXCEEDS 60 PSI 56
4. Any time a wheel is replaced be sure to tighten the wheel nuts following the sequence shown in the diagram to the specified torque If the wheel was replaced check the torque again at every 50 miles for the first 500 miles and prior to each trip thereafter If you notice wheel wobbling or hear a rattling sound coming from a wheel especially 30 at low speeds a wheel lug nut may have come loose This problem is usually caused by improper tightening or by faulty or damaged lug bolt threads If you have reason to believe a lug nut has come loose SAFELY STOP THE VEHICLE AT THE SIDE OF THE ROAD AS SOON AS POSSIBLE Put up warning devices Remove the lug caps and check the tightness of all the lug nuts Tighten all lug nuts to the specified torque of 120 ft lbs If lug bolt threads are damaged or faulty get professional service help Do NOT tow the trailer with missing lug nuts of faulty lug bolts DO NOT USE A SIZE AND TYPE OF TIRE AND WHEEL OTHER THAN THAT ORIGINALLY PROVIDED BY HEARTLAND RECREATIONAL VEHICLES LLC BECAUSE IT CAN AFFECT THE SAFETY AND PERFORMANCE OF YOUR VEHICLE WHICH COULD RESULT IN AN INCREASED RISE OF LOSS OF VEHICLE CONTROL VEHICLE ROLLOVER AND OR SERIOUS PERSONAL INJURY OR DEATH THE INSTALLATION OF INCORRECT WHEELS COULD CAUSE WHEEL SEPARATION WHICH COULD RESULT IN PROPERTY DAMAGE SERIOUS PERSONAL INJURY OR LOSS OF LIFE 1 Clean mounting surfaces lug nuts amp studs Do no lube lug joint unless
5. DANGER DANGER indicates a hazardous situation which if not avoided will result in death or serious injury WARNING indicates a hazardous situation which if not avoided could result in death or serious injury CAUTION used with the safety alert symbol indicates a hazardous situation which if not avoided could result in minor or moderate injury Ss NOTICE S NOTICE is used to address practices not related to personal injury This appliesto hazardous situations involving property damage only Important information regarding the maintenance of your recreational vehicle Very Important Your warranty is activated only after HEARTLAND RECREATIONAL VEHICLES LLC has received your signed warranty registration card from your selling dealer where it should have been signed If you never signed this card or wish to make sure your warranty is activated please contact your dealer or the HEARTLAND RECREATIONAL VEHICLES LLC Warranty Departmentat574 262 8030 or you may inquire in writingto HEARTLAND RECREATIONAL VEHICLES LLC 1001 All Pro Drive Elkhart IN 46514 8 HEARTLAND Recreational Vehicles LLC IMPORTANT SAFETY PRECAUTIONS You ll find many safety recommendations throughout this section and throughout this manual The recommendations on these pages are the ones we consider to be the most important Do Not Allow Passengers to Ride in the Trailer During Travel The transport of people puts their lives at risk and
6. DVD Viewing TV needs to be set to AV1 Press the TV video button on the remote until the proper input setting is reached Set radio to aux input Press the FNC button until aux is displayed on the front of the radio Insert disc into DVD player and enjoy AUXILIARY AUDIO Make sure the radio is on Set radio to aux function as above Turn DVD player to aux input by pressing input button on front of DVD player Plug audio source into jacks and enjoy Garage Area Your Heartland RV has one of the best designed garage areas in the industry From the Full Perimeter Aluminum Diamond Plate Wall Protection to the Standard D Ring Cargo Fastening System no detail was too small With the Cam Style locks on your RV s garage you can put your own padlock on ensuring that no one else can enter your RV Simply rotate the padlock hasp up flip the cam handle up and pull toward the outside of the unit The Ramp Door is spring assisted to allow easy open and closing of the door Although these high tensile steel springs greatly reduce the effort required to open and close the door care must be taken when operating the door LUBRICATE TAILGATE HINGES AT THE BEGINNING OF EACH SEASON AND EVERY THREE MONTHS OF USE THEREAFTER 79 Rear Ramp Door A non slip interior surface spring assisted hinges and cam style locking system allow 2500 Ibs of cargo to be loaded into the car
7. 4 Drain and flush with fresh potable water 5 To remove excessive chlorine taste or odor which may remain prepare a solution of one 1 quart vinegar to five 5 gallons water and pour into tank Allow solution to agitate in tank by vehicle motion several days if possible 6 Drain tank and flush with fresh potable water HEARTLAND Recreational Vehicles LLC Fresh Water Lines Vibration and flexing during traveling can cause pipes and fittings to work loose Check all of the plumbing connections for leaks on a regular basis and not less than annually If the water pump runs when all faucets are turned off check for aleak Be sure the drain valves are closed Connections and the kitchen and bathroom faucets normally seal with hand tightening and a half turn with a wrench If a fitting leak persists disconnect completely and check for mineral deposits or foreign material on the sealing surfaces Clean the surfaces thoroughly and reinstall the fitting Take the coach to an authorized service center for repairs if the system continues to leak Follow the winterizing instructions given on p 71 to reduce the risk of leaks caused by cracks from freezing pipes Freezing damage can be extensive and expensive Water Pump The RV water pump is a 12 volt DC appliance that is activated by a switch found on the monitor panel in the kitchen area This switch is designed to activate the pump This is a called a demand system Turn the faucet on
8. FIFTH WHEELS TRAVEL TRAILERS amp TOY HAULERS OWNER S MANUAL Compliments of PetesRV com PetesRVparts com DEAR VALUED CUSTOMER CONGRATULATIONS and thank you for your business This owner s manual outlines the HEARTLAND RECREATIONAL VEHICLES LLC One Year Bumper to Hitch Limited Warranty We encourage you to follow the Product Delivery Inspection procedures with your selling dealer You should receive an extensive walk through and demonstration of your RV and the warranty statement contained in this manual should be fully explained to you The desired result is that you have been informed of the warranty provided the operation the maintenance required and details of the responsibilities of the manufacturer dealer and retail partnership At HEARTLAND RECREATIONAL VEHICLES LLC we want you to be able to enjoy your new recreational vehicle In the following pages you will learn about your warranty the features of your HEARTLAND RV and the maintenance necessary to ensure years of enjoyable use We encourage HEARTLAND owners to review and pay special attention to the following Warranty Statement please read the full warranty statement Weight rating please review the proper loading hitching and towing instructions for your safety and that of others Care and Maintenance review sealant maintenance requirements Slide Room Operation review operation instructions maintenance adjustments
9. Home is where your heart is Please review the supplied fan owner s manual for additional operating instructions To keep condensation from accumulating open the vent lids slightly to help the air circulate Condensation occurs naturally from fluctuations in interior and exterior temperatures humidity and dew point changes showering and cooking To clean the screen remove the screws holding it in place Wash the screen using a non abrasive soap and water Re install the screen and tighten the screws Keep all the vents closed when using the Rain Sensor Fan Direct the airflow by slightly opening the windows s on the shaded side of the trailer to obtain the maximum air flow especially on hot sunny days Close all the roof vents The area between the open window s and the Rain Sensor fan supplies the maximum air flow and provides the most comfort DO NOT LEAVE ANY VENT COVER OPEN WHILE THE TRAILER IS IN MOTION STORED OR UNATTENDED FOR EXTENDED PERIODS OF TIME HIGH WINDS OR OTHER UNUSUAL CONDITIONS OR OBSTRUCTIONS MAY DAMAGE THE COVER AND PREVENT CLOSING LEAKAGE COULD RESULT CAUSING SERIOUS DAMAGE Water Heater The water heater is accessed by a panel on the outside of the vehicle Turn on the hot water faucet at the galley sink to see if the tank is full Before operating any gas appliance make sure the valve on the gas tank is open ALL PILOT LIGHTS APPLIANCES AND THEIR IGNITERS SEE OPERATING INSTRUCTIONS MUS
10. LP and Appliances review function and safety equipment provided Tire and Lug Nut review inflation and lug nut torque specifications Modifications Deviations review which changes or alterations can void the warranty Condensation review causes and advice on how to reduce and control Your unit has been inspected by the factory and received a final inspection at the dealership Please allow your dealership to assist you in remedying any warranty issues and should you need to contact our Elkhart Indiana service facility please contact us at 1 574 262 8030 877 262 8032 We wish you many seasons of happy camping with your HEARTLAND RECREATIONAL VEHICLES LLC product Best Regards This manual is based on the latest information available at the time of publication Duetocontinuous product development and improvements The HEARTLAND Team Heartland Recreational Vehicles LLC Heartland Recreational Vehicles Dealer Services Warranty Department LLC reserves the right to make 2912 Dexter Drive changes in product specifications and Elkhart IN 46514 components without prior notice or Ph 574 262 8030 877 262 8032 obligation The most recent version of the owner s manual can be found on our web site www heartlandrvs com under the customer service heading PUBLISHED MARCH 2011 REVISED JULY 2011 Home is where your heart is 1 This page left intentionally blank HEARTLAND Recreational Vehicles
11. occur in virtually every environment indoors and out Outdoors mold growth is important in the decomposition of plants Indoors mold growth is unfavorable Left unchecked molds break down natural materials such as wood products and fabrics According to the Center for Disease Control exposure to damp and moldy environments may cause a variety of health effects or none at all Some people are sensitive to molds For these people molds can cause nasal stuffiness throat irritation coughing or wheezing eye irritation or in some cases skin irritation People with mold allergies may have more severe reactions Immune compromised people and those with chronic lung illnesses such as obstructive lung disease may get serious infections in their lungs when they are exposed to mold What factors contribute to mold growth For mold growth to occur temperatures indoor or outdoors must be between 40 degrees and 100 degrees Fahrenheit and also have a source of moisture such as humidity standing water damp materials etc Indoors the most rapid growth occurs with warm and humid conditions How can mold growth be inhibited By controlling relative humidity the growth of mold and mildew can be inhibited In warm climates use of the air conditioner will reduce the relative humidity Vents are located in the bathing and cooking areas and constant use is advised during food preparation and bathing even during colder weather Addition
12. oil or other debris that may cause slippage e Do not allow persons or pets to ride inside the vehicle storage area at any time Close doors and windows in separation walls while the vehicles are present e Close tank fuel valves and operate the engine s to run fuel out of engine s of stored vehicles Donotstore or transport motor fuel anywhere inside the trailer e Ventilate the interior of the trailer to reduce the risk of fire explosion or asphyxiation Do not operate gas appliances pilot lights or electrical equipment when motorized vehicles or motorized equipment are inside the trailer FAILURE TO COMPLY COULD RESULT IN AN INCREASED RISK OF FIRE EXPLOSION OR ASPHYXIATION Load and store your equipment and motorized vehicles according to the Loading and Weighing chapter in this Owner s Guide During transit secure motorized vehicles and motorized equipment so that items do not move while in transit Remove carpet from section where fueled vehicles or motorized equipment will be stored THERE IS A HAZARD OF SERIOUS PERSONAL INJURY WHEN USING A LOADING RAMP NEVER RIDE MOTORIZED CARGO UP A LOADING RAMP 85 Loading Technique IF THE MOTORIZED CARGO LOSES TRACTION AND SPINS SIDEWAYS IT MAY SLIP SIDE WAYS OFF THE RAMP TIPPING SIDEWAYS AND POSSIBLY FALLING ON THE RIDER CAUSING INJURY Ramp Positioning The ramp angle from the trailer floor to the ground affects the risk when loading un
13. the RV to the tow vehicle Be sure the hitch components are tight before coupling the RV to the tow vehicle Hitching A Travel Trailer 1 Crank the tongue of the trailer jack up until the hitch coupler is high enough to clear the tow vehicle 2 Back the tow vehicle to the trailer until the hitch ball is directly under the coupler on the trailer 3 Set the parking brakes raise the locking latch on the coupler and crank it down on the ball Move the locking latch down to lock it on the ball 5 Engage the lock and the retainer clip 6 Raise the tongue by cranking the jack down The tow vehicle will come up with it if the high coupler is properly attached 7 Fasten safety chains to frame of the tow vehicle Do not fasten chains to any part of the hitch unless the hitch has holes or loops specifically for that purpose Cross chains underneath the hitch and coupler with enough slack to permit turning and to hold tongue up if the trailer comes loose 8 Connect the breakaway switch cable to the tow vehicle making sure it is not attached to any part of the trailer 9 Crank the jack all the way up A Home is where your heart is 10 Install and adjust side mirrors 11 Check all lights on trailer and tow vehicle 12 Pull forward and check the operation of the trailer brakes with hand control to assure proper operation Refer to manufacturer specifications on setting the brake control If aftermarket equalizer hi
14. these risks avoid hazards and enjoy your recreational activities safely by using an effective decision making strategy Look around you and your situation Get a good idea of what s going on around you before you act Identify hazards or specific problems in your path Equipment materials debris other vehicles children pets or any number of other things may be in your way when you load or unload cargo or vehicles Predict what may happen and think of the consequences of your actions If you are loading unloading alone are you physically capable of handling the load safely and keeping it under control Ask yourself what would happen if your load falls over slips off the ramp or falls out of the trailer If you are unable to control your cargo what will happen to it you and any other people equipment or materials if when it becomes uncontrollable If you tie down your load what will happen if a tie down comes loose What will happen if all tie downs come loose What will you do if someone else does something dangerous during your loading unloading Decide what to do based on your abilities and the capabilities of your equipment Always use proper lifting techniques and personal protection equipment as necessary such as gloves helmets kneepads and other protective clothing Be sure your cargo does not exceed the capacity of your loading ramp and the trailer Here are some general safety rules about loading and HEARTLAND
15. 7D a MAE aas MOTOR FUELS e ARE LUAFFRINIECONIMNEBL im WITH HOLD CRED Laces MOIZLI ATTE OL Aa PROIN MIU FORNT EM ANE NW sMEWERZFPHOH EY MOUTH SERE FUR US UE TUE ECT ELECTR Da DEVIEES RAJABDO DG NOT CiLLULAR FHOMTS QT MER EL DCT A DISCE S We BERS MOTOR FUELS Fuel Pump To dispense fuel Home is where your heart is Place nozzle in tank and actuate lever to dispense fuel Immediately turn silver switch level up to turn pump off WARNING IF FOR ANY REASON THE FUEL STATION EQUIPMENT DOES NOT FUNCTION AS INTENDED DISCONTINUE USE AND HAVE THE FUEL STATION SERVICED BEFORE RESUMING USE DANGER NO SMOKING BEFORE DISPENSING FUEL TURN OFF ALL ENGINES FUEL BURNING APPLIANCES AND THEIR IGNITORS CONNECT THE BONDING JUMPER WIRE TO THE VEHI CLER ECEIVING FUEI NOT DISPENSE UEL WITHIN 2 FEET OF AN IGNITION SOURCE fact IE TO COMPLY COULD RESULT IN IRE DEATH OR SERIOUS INJURY TT DO NOT LEAVE THE SYSTEM RUNNING WITHOUT FLUIDS DRY RUNNING CAN DAMAGE THE PUMP IF THE SYSTEM FAILS TO DELIVER FUEL AFTER 15 TO 20 SECONDS TURN THE SYSTEM OFF AND REFER TO THE TROUBLESHOOTING SECTION DO NOT PUMP THE TANK COMPLETELY DRY AS CONTAMINANTS FROM THE BOTTOM OF THE TANK MAY ENTER THE PUMP AN AUTOMATIC BYPASS VALVE PREVENTS PRESSURE BUIL
16. CORDS REDUCE THE AMPERAGE AND VOLTAGE BEING SUPPLIED TO THE RV AND MAY CAUSE DAMAGE TO ELECTRICAL COMPONENTS INCLUDING THE SHORELINE CORD IF YOU TRAVEL TO AN RV PARK THAT DOES NOT OFFER THE APPROPRIATE AMP SERVICE YOUR COACH REQUIRES YOU WILL HAVE TO USE AN ADAPTER TO HOOK UP TO SHORE POWER USE OF AN ADAPTER IS NOT RECOMMENDED BUT MAY NOT BE AVOIDABLE WHEN USING AN ADAPTER REMEMBER THAT YOUR COACH WILL NOT HAVE SUFFICIENT POWER TO RUN AS MANY OPTIONS AS WITH FULL AMP SERVICE YOU MAY BE ABLE TO RUN BOTH YOUR AIR CONDITIONERS FOR A LIMITED TIME HOWEVER THIS WILL CAUSE DAMAGE TO BOTH YOUR AC UNITS AS WELL AS OTHER COMPONENTS BY OPERATING THEM WITH INSUFFICIENT POWER 45 AMP Usage Listed below are components that might be used in HEARTLAND RECREATIONAL VEHICLES LLC vehicles and the typical maximum amperage draw each one has This chart may help you decide which components you can safely use for an extended period without damage Components Amperage Roof air conditioners each 15 Electric water heater 12 Microwaves 12 Hair dryer 8 TV 4 DVD 5 Charger 14 Refrigerator 3 5 110 volt lamp 1 0 Power Convertor Your vehicle is equipped with an electrical power convertor that changes 110 volt power to 12 volt power to run 12 volt powered appliances in your vehicle It gets the 110 volt power by way of the shoreline shown previously Shown here is the circuit breaker fuse box for the 110V
17. LEV HIULE T ee this important safety VENT CH Seen at 81 ian iene a non device Testthe smoke Eh LE iat ALEC IH detector after the unit has been in storage CETTE THO ELIT B Um Cui DES before each trip and at least once a week during use The detector should never be disabled because of nuisance or false alarm from cooking smoke or a dusty furnace Ventilate the unit with fresh air and AT WL PER eel De TO OcWIFLE ii FERE ee 50 the alarm will shut off Never disconnect or remove the battery from the smoke alarm The battery should be replaced no less than once a year or when the low battery signal sounds TEST SMOKE ALARM OPERATION AFTER VEHICLE HAS BEEN IN STORAGE BEFORE EACH TRIP AND AT LEAST ONCE PER WEEK DURING USE FAILURE TO COMPLY MAY RESULT IN SERIOUS INJURY SORTIE Emergency Exit Window Throughout the unit there are Emergency Exit egress windows These windows are designed to be used as an additional exit in emergency situations It can be identified easily by the red handle and red EXIT label To open the egress window familiarize yourself and occupants with proper procedure There should be two paths of escape from each sleeping area Familiarize yourself and occupants with these paths and the location of the exits Furnace The furnace util
18. LP gas container can result in uncontrolled gas flow which can cause fire or explosion A properly filled container will contain approximately 80 percent of its volume as liquid LP gas Safety regulation prevents filling over 80 percent Portable fuel burning equipment including wood and charcoal grills and stoves must not be used inside the recreational vehicle The use of this equipment inside the recreational vehicle may cause fires or asphyxiation Storage of LP gas containers gasoline or other flammable liquids inside your vehicle even for short periods of time presents a risk of fire and or explosion All flammable liquids should be stored safely in a well ventilated area outside your vehicle and in proper containers LP gas regulators must always be installed with the diaphragm vent facing downward Regulators that are not in compartments have been equipped with a protective cover Make sure that the regulator vent faces downward and that the cover is kept in place to minimize vent blockage which could result in excessive gas pressure causing a fire or explosion Home is where your heart is WARNING ALL PILOT LIHT SR APU AM Tem Te CPPS AT TORO PHL NT DREER Pa CN BI FUEL Ba Pehl CONTRE Fd LE DA T iid i AVERTISSEMENT LOS VLEs LET ET Lie ee aL Live roe Lidl m
19. Maintaining correct tire inflation pressure for your trailer is of the utmost importance and must be a part of regular vehicle maintenance You must weigh your trailer when it is fully loaded as you expect to use it You need to weigh all axles together and calculate the hitch weight You may find that even thought the total weight is within the GVWR one side may be overloaded For this reason you must know the weight of each side of the trailer When you know the weight on each side of the trailer the combined axle assembly and the hitch weight you will be able to manage your loading to be able to maintain good balance and assure good and safe handling on the road Here are some tips to help you plan your loading Do not overload Experiment with various loads starting with light loads and working up to heavier loads Take into consideration the load of the fresh water system The tow vehicle and the terrain will affect the true weight you should carry Distribute the load evenly over the axles as much as possible Keep heavy items low and forward preferably in the lower storage areas This will produce a lower center of gravity and improve road stability e Distribute the load evenly on each side of the trailer Place heavier object opposite the heavier appliances cabinets furniture etc when possible Experiment with various load positions until you find the best distribution e Avoid loading heavy items in or on the re
20. Recreational Vehicles LLC unloading your cargo trailer Other safety items will be covered throughout this section Always consider the equipment you are loading After use it may be hot wet slippery dirty or in some other condition that may be potentially hazardous e n all situations follow the loading and weight guidelines in the Loading and Weighing chapter of this Owner s Guide Never exceed the GAWR and GVWR ratings of either your trailer of your tow vehicle Connect to the tow vehicle and use wheel chocks in addition to the forward loading gear jack of spotted trailers when loading and unloading to prevent potential forward or backward movement when loading or unloading e the work loading area is well lit Avoid loading unloading at night or in conditions of poor visibility Do not allow anyone who is not engaged in loading or unloading to be inside the trailer cargo area while loading unloading e Visually inspect the trailer before loading A damaged spot in the floor can cause cargo to be unstable and damaged or missing tie down rings will prevent you from securing your load properly Use caution tape traffic cones or portable barricades to designate staging and loading areas in high activity situations where other vehicles and or pedestrians are present e Keep the loading area clean and free of clutter and debris Clean up water and oil on the floor Designate areas at your campsit
21. SHALL BE VENTILATED GAS APPLIANCES PILOT LIGHTS OR ELECTRICAL EQUIPMENT SHALL NOT BE OPERATED WHEN MOTORIZED VEHICLES OR MOTORIZED EQUIPMENT ARE INSIDE VEHICLE FAILURE TO COMPLY COULD RESULT IN AN INCREASED RISK e OF FIRE EXPLOSION ASPHYXIATION DEATH OR SERIOUS INJURY Many recreation ATV or motorcycle accidents and injuries happen while loading or unloading Steep inclines unstable ramps power and a short stopping area are what make loading motorized cargo difficult and unsafe There is no absolute safe way to drive your motorized cargo into the trailer Take the following steps to aid in Home is where your heart is reducing the risks associated with transporting storing or occupying the trailer Take the following steps to reducing the risks associated with transporting storing or occupying the trailer with motorized equipment and vehicles Wear personal protective equipment while loading and unloading vehicles to from the trailer This includes but is not limited to an approved motor vehicle helmet leather boots appropriate gloves and eye protection e Never stand in the path of equipment when loading unloading with the ramp and keep bystanders away from the ramps e Keep body parts completely clear of the ramp door hinge pinch area at all times e Check parking brakes on the vehicle s you are loading unloading and on the tow vehicles e Inspect ramp and trailer floor loading area for cracks damage
22. ST tires used on trailers All ST tires are speed restricted to 65 mph Never operate a vehicle in an unsafe or unlawful manner Tire speed ratings if indicated should never be associated with the ability of the vehicle to handle the speed for which the tire is rated HEARTLAND Recreational Vehicles LLC U S DOT Tire Identification Number This begins with the letters DOT and indicates that the tire meets all federal standards The next two numbers or letters are the plant code where it was manufactured and the last four numbers represent the week and year the tire was built For example the numbers 3197 means the 31st week of 1997 The other numbers are marketing codes used at the manufacturer s discretion This information is used to contact consumers if a tire defect requires a recall Tire Ply Composition and Materials Used The number of plies indicates the number of layers of rubber coated fabric in the tire In general the greater the number of plies the more weight a tire can support Tire manufacturers also must indicate the materials in the tire which include steel nylon polyester and others Maximum Load Rating This number indicates the maximum load in kilograms and pounds that can be carried by the tire Maximum Permissible Inflation Pressure This number is the greatest amount of air pressure that should ever be put in the tire under normal driving conditions Vehicle Load Limits Determ
23. Tic AL CORE pU er D Cea ET OF DES BOUTIHRLES 24 Lis rid LE see RERFECI DECUS Tee read Liquid Propane LP gas when properly handled is a clean burning dependable fuel for all your LP gas appliances The LP tank or tanks mounted on your unit contain liquid under high pressure The liquid vaporizes into a gas and passes through the regulator which automatically reduces the gas pressure The low pressure gas is then distributed to the appliances The arrow on the automatic gas regulator will always point to the gas tank in service When the red flag appears in the inspection glass this indicates that the tank is empty The arrow should be turned to allow the full tank to pressurize the system and the empty tank should be filled as soon as possible 1 MENT Each tank has an automatic eighty percent stop fill valve that allows space in the tank for vapor expansion The high pressure vapor in the tank is reduced in two stages as it makes its way to your appliance The tank pressure will vary with temperature and altitude but it may be in the range of 100 to 250 pounds per square inch psi or more It is reduced by a pressure regulator to about 12 psi in the first stage and then to about 6 35 ounces in the second stage The 6 35 ounces can also be expressed as 11 inches of water column The LP gas system is designed and built to rigid standard
24. a sudden stop or accident The amount and placement of cargo will also affect the amount of water and LP gas that you can carry Water weighs 8 3 pounds per gallon and propane weighs 4 2 pounds per gallon Periodically reweigh your unit Different traveling configurations may change your loading and weight pattern Home is where your heart is Traveling Towing A good way to practice towing is to choose a large parking lot where it is permissible Easing to a stop and starting smoothly saves wear and tear on your tow vehicle saves gas and prevents damage to the hitch and items stowed in the trailer Remember when towing the trailer always maintain at least three cars and a trailer approximately 85 ft length space between you and the car in front of you for every 10 miles of speed that you are traveling This should give you ample time to stop in case of emergency As you drive try to anticipate problems that may occur and prepare for them even though they may never happen Anticipate dips gutters and depressions in the street slowing down well in advance as these are the hardest jolts of any kind on your tow vehicle your hitch your trailer and items stored in your trailer Take dips and bumps slowly and be certain that the trailer wheels have passed the point before accelerating Cross railroad tracks slowly Always release your brakes before crossing On long grades shift into a lower gear or lower range if you h
25. and there are no people pets or obstructions in the unloading area at the end of the ramp Assure that the ground surface will support the vehicle and that the vehicle cannot roll away uncontrolled Stand at the front of the vehicle Push the vehicle backward in line with the ramp As the rear tires start down the ramp let go of the vehicle and let it roll backwards don t try and slow or control the vehicle as this can cause injury DANGER DO NOT SMOKE WHEN FILLING THE TANK BEFORE DISPENSING AON FUEL TURN OFF ALL ENGINES AND FUEL BURNING APPLI ANCES AND GROUND THE TRAILER DO NOT DISPENSE FUEL WITHIN 20 FEET OF AN IGNITION SOURCE Fuel Transfer System A fuel transfer system allows you to store gasoline for use in motorcycles snowmobiles ATVs or other vehicles and equipment while at a campsite This system consists of a fuel tank fuel tank filter fuel gauge fuel transfer pump fuel transfer valve and hose with fill nozzle A master pump switch is located on the inside control panel and an emergency shutoff switch is located on the trailer frame rail near the fuel transfer pump A metal ground clip reduces the possibility of static electricity discharge between the fuel station and the equipment being fueled To fill the tank remove the fuel filler cap and fill the tank with the grade gasoline required by your equipment When replacing the fuel fill cap be sure it seats squarely and turn it firmly to lock it on
26. are not recommended for use on trailers LT The LT indicates the tire is for light trucks or trailers EE NOTICE ALTHOUGH TIRES DESIGNATED LT ARE SOMETIMES USED ON TRAILERS THEY ARE NOT RECOMMENDED FOR USE ON YOUR TRAILER AND SHOULD NOT BE CONSIDERED AS REPLACEMENTS FOR THE ORIGINAL EQUIPMENT ST DESIGNATED TIRES ST An ST is an indication the tire is for trailer use only Next number This three digit number gives the width in millimeters of the tire from sidewall edge to sidewall edge In general the larger the number the wider the tire Next number This two digit number known as the aspect ratio gives the tire s ratio of height to width R The stands for radial Other tire designs may be bias ply or bias belted and are designated by other letters Next number This two digit number is the wheel or rim diameter in inches If you change your wheel size you will have to purchase new tires to match the new wheel diameter Next number This two or three digit number is the tire s load index It is a measurement of how much weight each tire can support You may find this information in your owner s manual If not contact a local tire dealer Note You may not find this information on all tires because it is not required by law Speed Rating The speed rating denotes the speed at which a passenger car tire is rated A speed rating will not be found on
27. be able to be accidentally unfastened or loosened while the trailer is in motion Proper Use of Tiedowns Avoid using tiedowns and securing devices with knots Be sure to attach and secure each tiedown so that it can t come loose unfastened opened or released while the trailer is in motion Also use edge protection whenever a tiedown could be damaged or cut at the point where it touches an article of cargo Tiedown Minimum Working Load Limit The working load limit of a tiedown associated connector or attachment mechanism is the lowest working load limit of any of its components including any tensioner device or the working load limit of the anchor points to which it is attached whichever is less When you choose tiedown hardware choose items that are strong 84 enough to hold the load you are securing The load limit of each tiedown used should be at least one half the working load limit of each tiedown that goes from an anchor point on the trailer to an attachment point on an article of cargo Check the tiedown manufacturer s specifications to determine working load limits TIEDOWN HARDWARE IS NOT SUPPLIED WITH YOUR TRAILER Minimum Number Of Tiedowns When an article of cargo is not blocked or positioned to prevent movement in the forward direction the number of tiedowns needed depends on the length and weight of the articles In all cases use enough tiedowns to secure the cargo from moving in any direction He
28. be washed away and harsh climates can accelerate the deterioration of sealants As a guideline inspect these areas four 4 times a year or whenever the RV is washed or waxed whichever is more frequent Unsealed areas can lead to expensive structure repairs in the future The bonded fiberglass wall may show a print through of the inner structure supports and beams This is normal and may be more evident in harsh climates Washing The exterior of your new recreation vehicle is made of pre finished aluminum or fiberglass Frequent washing and thorough cleaning is recommended to prevent damage to the vehicle finish caused by exposure to calcium chloride road tar tree sap insects and other foreign material Corrosive materials such as those used for ice and snow removal and dust control also accumulate on the underside of the vehicle These materials should be removed by flushing the underbelly regularly with water especially areas where mud and other foreign materials collect The change of corrosion can be minimized by frequent washings of the vehicle Corrosion Protection Your HEARTLAND RECREATIONAL VEHICLES LLC recreational vehicle has been designed to withstand normal environmental condition But the sand and salt used on the highways and the salt spray in the air near oceans can cause the metal components on your recreational vehicle to corrode To protect your recreational vehicle from this corrosion it must be th
29. charge your battery when the trailer is plugged into shore power Battery Disconnect Panel On some models this is done to prevent the coach batteries from being drained during storage It disconnects all the 12 volt circuitry from the batteries When taking the unit out of storage turn to re connect the batteries This will make the 12 volt system ready for use 48 Monitor Panel Your vehicle has a monitor panel that can provide you with important information about various systems on the RV This panel also houses the water pump switch This monitor panel will give you information including much potable fresh water remains e How full your black sewage tank is e How full your gray waste water tank is THE MONITOR PANEL WILL GIVE FALSE READINGS IF THE SENSORS IN THE HOLDING TANKS ARE COVERED WITH DEBRIS CLEAN YOUR WASTE HOLDING TANKS FREQUENTLY WITH APPROVED TREATMENTS HEARTLAND Recreational Vehicles LLC GENERATORS IMPORTANT MAKE SURE TO READ AND UNDERSTAND THE GENERATOR OWNER S MANUAL BEFORE OPERATING THE GENERATOR Observe all operating instructions and warnings as well as all recommended maintenance schedules and procedures The onboard generator makes your RV fully self contained It allows you access to 120 volts when there is no shore power available but keep in mind that carbon monoxide is deadly NEVER sleep in the RV with the generator running Before you start and use the
30. electric brake controllers provide a modulation function that varies the current to the electric brakes with the pressure on the brake pedal or amount of deceleration of the tow vehicle It is important that the brake control provide about 2 Volts to the braking system when the brake pedal is first depressed and gradually increases the voltage to 12 Volts as brake pedal pressure is increased If the controller jumps immediately to high voltage output even during a gradual stop the electric brakes will always be fully energized and will result in harsh brakes and potential wheel lock up Proper synchronization of tow vehicle to recreational vehicle braking can only be accomplished by road testing Brake lock up grabbing or harshness is often due to the lack of synchronization between the tow vehicle and the recreational vehicle being towed too high of a threshold voltage over 2 Volts or under adjusted brakes Before synchronization adjustments are made the recreational vehicle brakes should be burnished in by applying the brakes 2 or 3 times with about a 20 mph decrease in speed e g 40 mph to 20 mph Allow ample time for brakes to cool between applications letting brake shoes and magnets slightly wear in to drum surfaces Controllers To ensure safe brake performance and synchronization completely read the brake controller manufacturer s instructions before attempted synchronization procedure Make several hard stops from
31. engine or the engine of any vehicle longer than necessary when the vehicle is parked DO NOT simultaneously operate generator and a ventilator which could result in the entry of exhaust gas When exhaust ventilators are used we recommend that a window on the opposite side of the unit upwind of exhaust gases be opened to provide cross ventilation When parked orient the vehicle so that the wind will carry the exhaust away from the vehicle DO NOT open nearby windows ventilators or doors into the passenger compartment particularly those which can be down wind even part of the time DO NOT operate the generator when parked in close proximity to vegetation snow buildings vehicles or any other object could deflect the exhaust under or into the vehicle DO NOT touch the generator when running or immediately after shutting off Heat from the generator can cause burns Allow the generator to cool before attempting maintenance or service 49 FIRE SAFETY The possibility of fire exists in all areas of life and the recreation vehicle life style is no exception Recreational vehicles are complex machines They are made up of many materials some of which are flammable Like many hazards the possibility of fire can be minimized This is done by recognizing the danger and practicing common sense safety and maintenance habits For safety reasons your unit is furnished with both a fire extinguisher and a smoke alarm Fir
32. inflation levels 33 The most common causes of tire failure are overloading and underinflation Both result in excess flexing of the tire sidewall which causes heat buildup and eventual tire failure Continuing to run with a flat can cause it to catch fire The most important things you can do to avoid tire fires are Maintain proper tire pressure Stay within tire and vehicle road limits Avoid road hazards if possible e Inspect tires for cuts slashes and other irregularities Properly maintained tires improve the steering stopping traction and load carrying capability of your vehicle Make tire safety a regular part of your vehicle maintenance routine Recognize that the time you spend is minimal compared with the inconvenience and safety consequences of a flat tire or other tire failure Understanding Tire Pressure and Load Limits Tire inflation pressure is the level of air in the tire that provides it with load carrying capacity and affects the overall performance of the vehicle The tire inflation pressure is a number that indicates the amount of air pressure a tire requires to be properly inflated It is difficult to obtain the recommended tire pressure if your tires are not cold Because tires are designed to be used on more than one type of vehicle tire manufacturers list the maximum permissible inflation pressure on the tire sidewall This number is the greatest amount of air pressure that should ever be
33. instructed in your owner s manual Start all lug nuts by hand to prevent cross threading Tighten nuts in sequence shown below using a calibrated torque wrench Do not use an impact wrench Wheel nut torque requirements vary depending on the size and manufacturer Always use wheel manufacturer s recommendations 4 Wheel nuts should be torqued before first road use and after each wheel removal Periodically check and re torque per manufacturer s recommendations S Lag Nell d AET Tu e lee Berns 1 1 J 5 ud LETS 6 FD t ui i a 4 LUG S Lg LUG 8 LUG DO NOT TOW THE TRAILER WITH MISSING LUG NUTS OR FAULTY LUG BOLTS HEARTLAND Recreational Vehicles LLC Before each trip and any time a wheel is replaced be sure to tighten the wheel nuts following the sequence shown in the relevant lug pattern below Set the torque specification in three stages as seen in the chart below If the wheel was replaced check the torque every 50 miles of the first 200 miles of travel If you notice wheel wobbling or hear a rattling sound coming from a wheel especially at low speeds a wheel lug nut may have come loose This problem is usually caused by improper tightening or by faulty or damaged lug bolt threads If you have a reason to believe a lug nut has come loose safely stop the vehicle at the side of the road as soon as possible Put up warming devices Remove the lug caps and check the tightness of all
34. lights to a comfortable level to reduce glare Extreme Heat and Hot Weather Conditions Check tire pressure frequently when traveling in hot conditions Tire air pressure increases with heat Do not let air out of a hot tire When the tires cool down they return to the previous tire pressure Winter and Cold Climate Conditions Keep speeds slow and steady make moves gradually and increase the visual distance for a gain in reaction time If the road or weather conditions are treacherous find a safe stopping place and wait for conditions to improve Remove ice from the entry step to avoid slipping Wet Conditions The risk of hydroplaning is increased if tires are worn or improperly inflated Heavy rain or standing water can affect brake application Home is where your heart is Refueling Be aware of the fuel port location on the tow vehicle There may not be adequate space to turn around in the parking lot in order to reposition for the pump Check overhead clearance before pulling through the fuel island Be aware of the concrete steel posts installed around the fuel island Avoid running over the fuel hose as it can get caught and cause damage to the tow vehicle or recreational vehicle amp WARNING AVOID THE RISK OF FIRE OR EXPLOSION TURN OFF ALL PILOT LIGHTS AND APPLIANCES BEFORE REFUELING Emergencies If an emergency situation occurs use the appropriate braking technique and p
35. on the gasoline dispenser nozzle e Never jam or otherwise try to lock the refueling latch on the nozzle open Do not re enter your vehicle during refueling If you cannot avoid reentering your vehicle discharge any static build up BEFORE reaching for the nozzle by touching something metal with a bare hand such as the vehicle body or frame away from the nozzle e Inthe unlikely even a static caused fire occurs when refueling leave the nozzle in the fill pipe and back away from the vehicle Turn off the fuel pump master switch immediately Do not over fill or top of your vehicle tank which can cause gasoline spillage e Never allow children under licensed driving age to operate the pump Avoid prolonged breathing of gasoline vapors Use gasoline only in open areas that get plenty of fresh air Keep your face away from the nozzle or container opening Never siphon gasoline by mouth Never put gasoline in your mouth for any reason Gasoline can be harmful or fatal if swallowed If someone swallows gasoline do not induce vomiting Contact a emergency medical service provider immediately Keep gasoline away from your eyes and skin it may cause irritation e Remove gasoline soaked clothing immediately e Usegasoline as a motor fuel only Never use gasoline to wash your hands or as a cleaning solvent 88 FUEL SOAKED RAGS OR OTHER MATERIALS CONTAIN FLAMMABLE AND OR EXPLOSIVE FUEL VAPORS AND OTHER HAZARDOUS SUBSTANC
36. percent gauge They are both designed to be closed leak tight by hand If you cannot hand tighten the valve the valve may need repair or replacement Consult your gas dealer DANGER IF YOU SMELL PROPANE 1 Extinguish any open flames pilot lights and all smoking materials Do not touch electrical switches Shut off the propane supply at the container valve s or propane supply connection 4 Open doors and other ventilating openings 5 Leave the area until odor clears Have the propane system checked and leakage source corrected before using again FAILURE TO COMPLY COULD RESULT IN EXPLOSION RESULTING IN DEATH OR SERIOUS INJURY LP Gas Lines The primary manifold is a black pipe located under the unit Copper tubing with flare fittings are used as secondary lines running to the gas appliances Should any lines ever rupture NEVER attempt to splice them A new line should always be installed We recommend any LP gas line services be performed by your dealer or an authorized service technician HEARTLAND Recreational Vehicles LLC Always close main valve at LP tank when servicing any gas appliance This prevents any gas leakage which could result in an explosion or cause serious bodily injury NEVER CHECK GAS LINES FOR LEAKS WITH AN OPEN FLAME DO NOT CHECK FOR LEAKS USING AMMONIATED OR CHLORINATED HOUSEHOLD TYPE DETERGENTS THESE DETERGENTS CAN CAUSE CRACKS TO FORM ON THE METAL TUBING AND BRASS FITTINGS TAKE THE
37. pressure grease Every Six Months Electric Drive Motor Check the wiring connections at the battery Clean the terminals with a solution of baking soda and water Cover the terminals with a thin coat of grease THE ELECTRIC DRIVE MOTOR IS LUBRICATED AT THE FACTORY AND REQUIRES NO FURTHER LUBRICATION Stabilizer Jacks Stabilizing jacks located at the rear corner on the trailer are permanently attached and operated from a standing position These jacks are for stabilizing only Primary leveling should be done with wheel ramps and front landing legs Lower the stabilizing jacks until they contact the ground firmly Place wooden blocks under the pads if necessary THE STABILIZER JACK S MUST NOT BE USED FOR LEVELING ON UNEVEN GROUND OR TO CHANGE TIRES NEVER USE JACK S TO ELEVATE ANY WHEEL OFF THE GROUND DAMAGE TO THE STABILIZER JACK S AND RECREATIONAL VEHICLE FRAME CAN OCCUR HEARTLAND Recreational Vehicles LLC POWER SYSTEMS HEARTLAND RECREATIONAL VEHICLES LLC provides one of two different power systems Your coach has either the 30 amp or the 50 amp service detailed below 30 amp 110 Volt Service If you have 30 amp service your power cord will look like this typical 30 amp power cord which pulls out of the unit 30 amp service is also 110 volt service but it is capable of running up to 30 amps of draw 30 amp service has only one prong that carries 110 volts of AC power 50 Amp 110 Volt Servic
38. room movement push and hold the switch in When the room is fully retracted release the switch to lock into position Slide Out Awning Optional The slide out awning is automatic When the slide out moves in or out the cover reacts to the slide out direction A fixed edge of the slide out cover is installed into an awning rail mounted just above the slide out A spring loaded roller with special brackets mounts to the slide out In a hard rain the cover helps prevent water from penetrating the seal of the slide out The slide out cover will extend automatically attaining full coverage when the slide out achieves maximum extension The slide out cover retracts automatically and rolls up to the travel position when the slide out is completely closed WATER MAY POOL ON TOP OF THE EXTENDED COVER AS THE SLIDE OUT IS RETRACTED THE WATER IS REMOVED WHEN RETRACTING THE SLIDE OUT STOP THE ROOM ABOUT HALFWAY CONFIRM THAT THE FABRIC IS ROLLING PROPERLY BEFORE FULLY RETRACTING THE SLIDE OUT Electric Slide Out Systems Electrically operated slide out rooms utilize a gear drive to move in and out Each guide ram on the underside of the room has its own gear which is driven by a 65 shared electric motor Several different types of electric systems are used on HEARTLAND RECREATIONAL VEHICLES LLC products depending on the model But each is able to be operated by a hand crank in the event of a motor or power failure Slide
39. the fill pipe neck Home is where your heart is DANGER POTENTIALLY EXPLOSIVE FUEL VAPOR MAY BE PRESENT AT FUEL FILLING STATIONS AND DURING REFUELING OF EQUIPMENT WITH THE FUEL TRANSFER SYSTEM NEVER ENTER A FUEL FILLING STATING OR REFUEL EQUIPMENT IF YOUR FURNACE OR WATER HEATER IS OPERATING OR IF YOUR REFRIGERATOR IS OPERATING ON PROPANE BOTH THE FLAME AND THE IGNITORS IN THE BURNERS OF THESE APPLIANCES ARE SOURCES OF IGNITION AND COULD CAUSE AN EXPLOSION THESE APPLIANCES MUST BE TURNED OFF BEFORE ENTERING A FUEL FILLING STATION OR REFUELING EQUIPMENT TURNING OFF THE PROPANE MAIN TANK VALVE ONLY IS NOT SUFFICIENT THE APPLIANCES MUST BE OFF AT THEIR ELECTRICAL OPERATING SWITCHES DANGER ANY MOTORIZED EQUIPMENT POWERED WITH FLAMMABLE LIQUID CAN CAUSE FIRE AND EXPLOSION OR ASPHYXIATION IF STORED OR TRANSPORTED INSIDE THE TRAILER TO REDUCE THE RISK OF FIRE EXPLOSION OR ASPHYXIATION 1 DO NOT ALLOW PASSENGERS TO RIDE INSIDE THE STORAGE AREA AT ANY TIME 2 PRIOR TO STORING VEHICLES IN THE TRAILER RUN FUEL OUT OF THE ENGINE AFTER SHUTTING OFF FUEL AT THE VEHICLE FUEL TANK 3 DO NOT STORE OR TRANSPORT ANY MOTOR FUEL INSIDE THE TRAILER 4 VENTILATE THE INTERIOR OF THE TRAILER TO REDUCE THE RISK OF FIRE EXPLOSION OR ASPHYXIATION OPEN THE VENTILATION PANELS ON EITHER SIDE OF THE CARGO AREA 5 DO NOT OPERATE PROPANE APPLIANCES PILOT LIGHTS OR ELECTRICAL EQUIPMENT WHEN MOTORIZED VEHICLES OR MOTORIZED EQUIPMENT ARE INSIDE THE T
40. the top of the right arm to locked BE CAREFUL This will cause the awning to roll up if you don t have a good hold of the awning tube strap Holding the awning tube strap allow the awning to roll up until you can use the wand in the strap Using the wand allow the awning to roll all the way up Do not allow the strap to get rolled all the way in the awning fabric e Lock the awning arm travel latches e Re tighten the rafter arm knobs located in each awning arm To open your main awning Electric Press and hold the Extend button and the awning will automatically open If the button is released the awning will stop Continue pressing the button until awning is fully extended then release To close your main awning Electric Press and hold the Retract button and the awning will automatically close If the button is released the awning will stop Continue pressing the button until awning is fully retracted then release HE NOTICE J VISUALLY VERIFY THAT THE AWNING IS FULLY CLOSED AN AWNING LEFT PARTIALLY OPEN CAN DISLODGE DURING HIGH WIND OR TRAVEL AWARNNG BE SURE TO LOCK YOUR AWNING WHEN YOU CLOSE IT UP FAILURE TO DO SO CAN RESULT IN SERIOUS PERSONAL INJURY OR LOSS OF LIFE Awning Care Be sure to clean off all debris as you roll up your awnings Periodically wash of the awning fabric with a soapy water solution Long term exposure to the sun may cause some fading over time which
41. until an emergency occurs before using it Location of the brake hand controller is important and should be made easily accessible 28 2 Steer as little as possible while maintaining control of the vehicle Because of natural reaction lag time quick steering movements to counter trailer sway will actually cause increased sway and loss of control Keep both hands on the wheel Hold the wheel as straight as possible until stability is regained 3 Do jam on the brakes or attempt to press on the accelerator to speed your way out of the fishtailing Both actions make the situation worse and could cause severe injury or death 4 Once the swaying is under control stop as soon as possible Check tire pressures cargo weight distribution and look for any signs of mechanical failure Travel at reduced speeds that permit full control until the problem can be identified and corrected Turning Corners Here s where you find the first basic difference with a trailer The trailer wheels do not follow the path of your tow vehicle s wheels The trailer will make a closer turn than the tow vehicle Compensating for the action when making turns you will put the tow vehicle out further into the intersection than you would normally so that the trailer will clear the curb or clear any parked vehicles along the curb Making a left turn requires a technique similar to a right turn with a wider than normal swing into the new lane of tra
42. water heater drain and line drain 4 Run demand pump till water stops flowing from faucets Shut pump off immediately Allow drains faucets and valves to remain open for several hours or blow all extra water out with air Be sure lines are empty 5 Close all faucets valves and drains 6 It is a good idea to use an antifreeze solution for potable water for more positive protection Do not use automotive type antifreeze 7 Before using vehicle again you may want to sanitize the system 8 Completely drain holding tanks 9 Flush sink shower tub lavatory and stool with a solution of hot water and dish soap Allow to fully drain and flush with clean hot water 10 If possible agitate the water in the holding tanks by driving a few miles then drain tanks again 11 Analternate to step 9 is to use a chemical deodorant Let mixture stand for a few days then drain 12 Flush with fresh water drain and after tanks are dry close dump valves and drain cap 13 Fill traps with an antifreeze approved for use in ABS plastic pipes Normally a cupful per trap is adequate Do not use an antifreeze solution with an alcohol base 14 Turn the thermostat off 15 Put graphite in all the locks and lubricate all door hinges 16 Close all windows and roof vents Winterizing the Water Pump With the water drained from the potable water tank disconnect the water pump outlet hose and then turn the pump on to allow the remaining water
43. when you want water If the pump fails to turn on when the switch is activated check the fuse Typical Fresh Water System i Outside Shower Gravity Fill City Inlet Water Heater Potable Tank Home is where your heart is located in the converter If the pump continues to operate whether the faucet is open or closed check the water tank to see if it is empty and check to see if there is a leak in the system The water pump is self priming and totally automatic operating upon demand when water is required 1 Fill or partially fill freshwater supply tank 2 Open kitchen and bathroom faucets 3 Turn on switch for water pump and allow it to fill the water lines and hot water heater 4 Close each faucet after it delivers a steady stream of water 5 Water pump should stop running after all faucets are closed 6 Pump should now run when faucet is opened and stop when faucet is closed When using the demand system and no water comes when a faucet is turned use the following chart to correct the problem 57 Pump Running 1 Fill Tank No Water 2 Clear water line to pump Pump Doesn t Run 1 Check if pump switch is on and no water pressure 2 Check 12 volt fuses 3 Check electric connection All water should be drained from the fresh water system when not in use for more than one 1 week DO NOT RUN THE WATER PUMP WITHOUT WATER IN THE SYSTEM ALWAYS KEEP THE PUMP SWITCH OFF WHEN THE
44. your cargo will be positioned after your load unload activities 6 Use caution and proper lifting techniques when loading and unloading items from the cargo area 7 Use extreme caution when loading unloading ATVs motorcycles or other vehicles motorized cargo or vehicle s These machines are generally heavy and may be hot from operation and or covered with dirt oil or other substances that may make them slippery 8 Make certain that the door seals and hinge area are free of any debris such as sand or snow before closing the rear door loading ramp 9 Inspect the hinges assist springs and latch mechanism before each trip for signs of wear or damage and make any needed repairs for safe operation and towing Loading and Unloading Motorized Cargo ANY MOTORIZED VEHICLE OR ANY MOTORIZED EQUIPMENT POWERED WITH FLAMMABLE LIQUID CAN CAUSE FIRE EXPLOSION OR ASPHYXIATION IF STORE OR TRANSPORTED WITHIN THE RECREATIONAL VEHICLE TO REDUCE THE RISK OF FIRE EXPLOSION OR ASPHYXIATION PASSENGERS SHALL NOT RIDE IN THE VEHICLE STORAGE AREA AT ANY TIME OCCUPANTS SHALL NOT SLEEP IN THE VEHICLE STORAGE AREA WHILE VEHICLES ARE PRESENT DOORS AND WINDOWS IN WALLS OF SEPARATION IF INSTALLED SHALL BE CLOSED WHILE THE VEHICLES ARE PRESENT FUEL SHALL BE RUN OUT OF ENGINES OF STORED VEHICLES AFTER SHUTTING OFF FUEL AT THE TANK MOTOR FUEL SHALL NOT BE STORED OR TRANSPORTED INSIDE THIS VEHICLE THEVEHICLE STORAGE AREA
45. 20 mph on a dry paved road free of sandy and gravel If the recreational vehicle brakes lock immediately decrease gain setting on the controller If they do not approach progressive lock up slightly increase the gain setting ROAD TEST BEFORE USING BE SURE AREA IS CLEAR OF TRAFFIC AND PEDESTRIANS DO NOT EXCEED 30 M P H FOLLOW PROCEDURES OUTLINED BY THE CONTROLLER MANUFACTURER FAILURE TO DO SO COULD RESULT IN PROPERTY DAMAGE SERIOUS PERSONAL INJURY OR LOSS OF LIFE 39 MINIMUM VEHICLE STOPPING DISTANCES ARE ACHIEVED WHEN WHEELS APPROACH LOCK UP AVOID BRAKE LOCK UP AS IT RESULTS IN POOR VEHICLE STABILITY AND CONTROL DEPENDING ON THE LOAD BRAKE TYPE WHEELS AND TIRES NOT ALL RECREATIONAL VEHICLE BRAKES ARE CAPABLE OF WHEEL LOCK UP If the controller is applying recreational vehicle brakes before the tow vehicle brakes adjust controller level so the recreational vehicle brakes comes on in synchronization with the tow vehicle brakes Adjust controller to allow recreational vehicle brakes to come on just slightly ahead of the tow vehicle brakes When proper synchronization in achieved there will be no sensation of the recreational vehicle jerking or pushing the tow vehicle during braking Start by making sure the recreational vehicle brakes are properly adjusted Some controllers have a gain control to vary the amount of current to the brakes and a level control which sets the controller inertia sensor to sense dece
46. CATIONS CAN CAUSE SLIDE ROOM DAMAGE SHOULD LEVELING BLOCKS SHIFT OR SETTLE AFTERMARKET STABILIZER STANDS MUST BE PLACED ONLY UNDER CHASSIS FRAME RAILS IMPROPER PLACEMENT OF STABILIZER STANDS COULD CAUSE INSTABILITY AND STRUCTURAL DAMAGE TO THE UNIT 43 Fifth Wheel Landing Legs Operation The landing legs of the trailer are intended for positioning the RV during hook up and unhooking from the tow vehicle The landing legs also support the trailer during camping and storage The legs are not designed for the sole support of the fifth wheel weight during tire changes or servicing A CAUTION THE LANDING LEG WEIGHT RATING IS 3 500 LBS PER LEG DO NOT EXCEED THE WEIGHT RATING THE LEGS MAY BIND IN OVERLOAD CONDITIONS THIS WILL RESULT IN PREMATURE WEAR OF THE DRIVE GEAR AND STRIPPING OF THE GEAR PREMATURE GEAR WEAR WILL ALSO OCCUR WITH EXCESSIVE CLUTCHING OF THE MOTOR THIS OCCURS AT MAXIMUM EXTENSION AND RETRACTION ONCE CLUTCH NOISE IS HEARD RELEASE THE SWITCH TOLOWERLEGS WITH ELECTRIC or HYDRAULIC MOTOR Push the switch located at the front of the trailer to the extend position and hold until the landing legs raise the vehicle to the desired height Extend and retract indicate the travel direction of the legs not the fifth wheel TORAISE LEGS WITH ELECTRIC or HYDRAULIC MOTOR Push the switch located at the front of the trailer to the retract position and hold until the legs are fully retracted Release the tog
47. Cee ee ee ee pP S Lm dB eR el E DISVDMT men DIE HORUM OU Vamos mod iu cb a mim x BOUES ao ae OUS FTNCESERGE LI Ur BCTLLET Climate Differences The appliances in your vehicle will not function if the LP gas does not vaporize Propane will continue to vaporize down to 44 degrees F Propane has become the main type of LP gas used in RVs in recent years Butane should not be used The LP gas dealer will have the correct type or blend for his locale If you plan on traveling from a warm climate to a cold climate check with your local gas dealer to see if the blend he supplies is appropriate for the part of the country you plan on visiting Operation To operate any LP gas appliance the LP gas tank s service valve must be OPEN When first used or after a refill there may be some air in the gas lines that will escape when the range burner or similar gas valve is opened The air may extinguish the match or igniter the first time or two you attempt to light a stove burner Also remember that when you close the tank s service valve some gas will remain in the lines To completely bleed the lines of gas close the tank valve and light the range burner When the flame burns out turn off the appliance 53 Cverview of Typical LP Gas Hook Up up mom EEE v LIN jJ Is s 7 Regulator Pressure Have the gas regulator checked at beginning o
48. D UP WHEN THE PUMP IS ON WITH THE NOZZLE CLOSED TO AVOID MOTOR DAMAGE DO NOT RUN THE PUMP MORE THAN 5 MINUTES WITH THE NOZZLE CLOSED THE RATED DUTY CYCLE OF THIS PUMP IS 15 MINUTES ON AND 30 MINUTES OFF ALLOW THE PUMP TO COOL FOR 30 MINUTES THIS PUMP IS DESIGNED FOR USE ONLY WITH GASOLINE UP TO 15 ALCOHOL BLENDS SUCH AS E15 DIESEL FUEL UP TO 20 BIODIESEL BLENDS SUCH AS B20 AND KEROSENE DO NOT USE THIS PUMP FOR DISPENSING ANY FLUIDS OTHER THAN THOSE FOR WHICH IT WAS DESIGNED TO DO SO MAY DAMAGE PUMP COMPONENTS AND WILL VOID THE WARRANTY THIS PUMP IS DESIGNED TO OPERATE ON A TYPICAL 12 VOLT DC AUTOMOTIVE ELECTRICAL SYSTEM THE PUMP IS DESIGNED TO OPERATE WITH 12 VOLTS DC AT THE MOTOR LEADS AND THE RATINGS ARE DETERMINED AT THIS VOLTAGE PERFORMANCE MAY VARY DUE TO LENGTH OF POWER CORD BATTERY CONDITION OR OUTPUT FROM VEHICLE CHARGING SYSTEM THAT WILL AFFECT SYSTEM VOLTAGE ALWAYS FOLLOW SAFETY PRECAUTIONS WHEN OPERATING THIS EQUIPMENT REVIEW THE SAFETY INSTRUCTIONS BEFORE EACH USE REPAIR LEAKS AROUND SEALS OR CONNECTIONS MAKE SURE HOSES ARE IN GOOD CONDITION AND CONNECTIONS ARE TIGHT MAKE SURE THE PUMP IS PROPERLY GROUNDED REPAIR ANY CORRODED OR DAMAGED WIRING BEFORE USE ENSURE THE TANK CONTAINS ENOUGH FUEL MAKE SURE THE FUEL IS NOT CONTAMINATED WITH DEBRIS 78 TO DISPENSE FUEL THIS PUMP IS DESIGNED TO BE SELF PRIMING IF FUEL IS NOT DELIVERED WITHIN 15 TO 20 SECONDS TURN THE PUMP OFF AND REFER TO PRIMING
49. EE OPERATIONG INSTRUCTIONS MUST BE TURNED OFF DURING REFUELING OF MOTOR FUELTANKS AND OR LP GAS CONTAINERS Home is where your heart is MEE EPIT E EG GU PARAI sen P ru Qm mim imeni hi ri Bee ee EUR eee ie ee eee Ss CU a EO mu aimi Pe mn Poe Toe Peed Ve Pe s carr EE ee ed Pe or dud dr Lem Pe Ep ph GEN DAE Eu iL E hi ee ee nima i ee ED LI Rm ee CY ARS URS ee ee Bs EAT LH ee eee PREGA ee eve mmm Pre ma BSR a DES eee es Gt Fuse PAT Feld ee ee LEER ee ee ke ee uim eun Ahia Pe CO Ce Tq ee ee Qoa mmum m ee el i CETTE a Tiii ECC CL EDM jj a Le eee ATE Ds LAT Sel GRANT BAS E ORG QUU gees Pee ees CS CAES AE See dee Wen BO PR Pe py ee ee eee dodi fs MUS ee AE a M E i 1 i a B E LI a D amu ee Sk oo TH ee RUE DU G7 mer BORITERIER die m mum a exem HN hime ee amc nsa Delos d Fi eH FRA 14 ET DEN rune 8 jm debate MP Ce NET La age miir Ete
50. ES CLEAN UP MATERIALS SHOULD BE TEMPORARILY STORED IN A NONFLAMMABLE VAPOR TIGHT CONTAINER UNTIL PROPER DISPOSAL FACILITIES ARE AVAILABLE DO NOT STORE FLAMMABLE CLEAN UP RAGS OR MATERIALS INSIDE ANY OTHER VEHICLE OR NEAR ANY SOURCE OF FLAME OR IGNITION Fuel Transfer System Operation To operate the fuel transfer system also see the Fuel Pump Owner s Manual in your Owner s Information Package 1 Lower the tongue jack or 5th wheel jacks to the ground This will electrostatically ground the trailer to reduce the possibility of static discharge while refueling 2 Setthe cargo area disconnect switch to ON 3 Close the vents in the side of the trailer to prevent fuel vapor from entering the trailer 4 Press the fuel transfer pump master timer switch ON Each press of the switch allows the pump to run 5 minutes When the pump stops press again if necessary for another 5 minute run 5 Attach the ground clip securely to a bare metal part of the equipment to be fueled frame handle bar axle bolt etc 6 Remove the fuel hose and nozzle from its compartment An automatic bypass valve prevents pressure buildup when the pump is on with the nozzle closed 7 Place the nozzle into the equipment fuel filler and squeeze the handle to allow fuel to flow Be careful not to overfill the equipment fuel tank Wipe up any spilled fuel 8 When finished release the nozzle handle return the nozzle to its compartment 9 Lock the fuel t
51. F EXACTLY THE SAME BEAD DIAMETER DESIGNATION AND SUFFIX LETTERS Tire Safety Information This portion of the Owner s Manual contains tire safety information as required by 49 CFR 575 6 The National Highway Traffic Safety Administration NHTSA has published a brochure DOT HS 809 36 that discusses all aspects of Tire Safety as required by CFR 575 6 It can be obtained and downloaded from NHTSA free of charge from the following web site http www NHTSA dot gov cars rules TireSafety ridesonit tires index html Studies of tire safety show that maintaining proper tire pressure observing tire and vehicle load limits not carrying more weight in your vehicle than your tires or Home is where your heart is vehicle can safely handle avoiding road hazards and inspecting tires for cuts slashes and other irregularities are the most important things you can do to avoid tire failure such as tread separation or blowout and flat tires These actions along with other care and maintenance activities can also e Improve vehicle handling Help protect you and others from avoidable breakdowns and accidents Improve fuel economy Increase the life of your tires Use this information to make tire safety a regular part of your vehicle maintenance routine Recognize that the time you spend is minimal compared with the inconvenience and safety consequences of a flat tire or other tire failure Safety First Basic Tire Ma
52. HESE CAN BE HARMFUL OR FATAL IF SWALLOWED YOUR DEALER CAN PROVIDE YOU WITH SPECIAL ANTI FREEZE THAT IS SAFE AND APPROVED FOR RV WATER SYSTEMS ALWAYS FOLLOW MANUFACTURER S INSTRUCTIONS FOR THESE ADDITIVES Water Heater Bypass To bypass the water heater turn the top and bottom valves off and the middle valves on Water Heater Bypass One Valve System 71 PROLONGED OCCUPANCY Effects Your trailer was designed primarily for recreational use and short term occupancy If you expect to occupy the trailer for an extended period be prepared to deal with condensation and the humid conditions that may be encountered The relatively small volume and tight compact construction of modern recreation vehicles means that the normal living activities of even a few occupants will lead to rapid moisture saturation of the air contained in the trailer and the appearance of visible moisture especially in cold weather This is also not covered under warranty Just as moisture collects on the outside of a glass of cold water during humid weather moisture can condense on the inside surfaces of the trailer during cold weather when relative humidity of the interior air is high This condition is increased because the insulated walls of a recreation vehicle are much thinner than house walls Estimates indicate that a family of four can vaporize up to three gallons of water daily through breathing cooking bathing and washing Unless the w
53. INFORMATION IN THE TROUBLESHOOTING SECTION AUXILIARY TEMPERATURE LIMITING DEVICE THE MOTOR IS PROVIDED WITH AN INTERNAL AUXILIARY TEMPERATURE LIMITING DEVICE EXCESSIVE MOTOR HEAT CAN TRIP THE DEVICE IT RESETS AUTOMATICALLY AFTER THE MOTOR HAS COOLED Generator To operate Make sure the generator exhaust is unobstructed Forgasoline models only press down on the generator switch located on the main switch panel and hold for 2 seconds to prime the generator This does not need to be done unless the generator has not run for awhile or has previously run out of fuel Press up on the switch to start generator There will be a slight delay in power due to the electronics built into the generator and the transfer Switch f there is still no power being generated after 45 seconds check that the breakers inside the front cover of the generator are turned on To open the front cover pull out on the top of the front cover There are two 30 amp breakers as well as another start stop Switch that operates in the same fashion as the interior switch HEARTLAND Recreational Vehicles LLC A fuel gauge is provided for gasoline and is located next to the interior pump switch Located next to the interior switch is an hour meter that will keep track of how many hours the generator has run for information and maintenance purposes To perform maintenance on your generator please refer to the supplied owner s manual for specif
54. LLC HEARTLAND RV LLC LIMITED WARRANTY IN THE UNITED STATES AND CANADA 1 WHAT IS COVERED Heartland RV provides to the original retail purchaser who purchases the unit from an authorized dealer and who uses the vehicle for private single family recreational travel camping and seasonal usage a one 1 year warranty under normal use against defects in material and or workmanship in the construction of the vehicle and its original components Defect means the failure of the unit and or the materials used to assemble the unit to conform to Heartland s design and manufacturing specifications and tolerances Any product used for a commercial or business purpose including not limited to rental charter or for other fees for service or as a residence is excluded from this Limited Warranty This residential limitation shall not apply to Land Mark Big Horn and Big Country brands This Limited Warranty is intended for the original retail owner and is non transferable The warranty coverage starts from the date of the original retail purchase This Limited Warranty covers only those defects that occur or exist within one year of the retail purchase date All obligations of Heartland RV pursuant to this Limited Warranty are limited to replacing or repairing the defective part or component This written Limited Warranty is the entire warranty authorized and offered by Heartland RV There are no warranties or representations beyond those expressed in t
55. LLC warranty Leveling and Stabilization Leveling of your trailer at the site is essential A level trailer is not only necessary for comfort but your refrigerator must be level in order to operate properly Stabilization is recommended to keep the vehicle from bouncing while unhitched when people are moving inside the vehicle Stabilizer jacks are intended to stabilize the vehicle body while the vehicle s full weight is supported by the hitch jack conventional vehicles or landing gear 5th Wheel trailers and running gear Stabilizer jacks are not designed to lift or support its entire weight If your coach is equipped with a slide out be sure to level main unit before extending the rooms Leveling Procedures for a Conventional RV 1 If the site is not an asphalt pad concrete slab or other prepared surface be sure it is as level as possible Be sure the ground surface is not soft and will support the weight of the trailer on the stabilizing jacks or other support devices Home is where your heart is 2 Before uncoupling level the vehicle from side to side with suitable lengths of 2 x 6 wood blocks under the trailer wheels Place the 2 x 6 wood blocks on the ground surface forward of the vehicle wheels and to the trailer onto the 2 x 6 blocks Block the trailer wheels so the trailer cannot roll 3 Unhook the 12 volt connector and the breakaway switch cable from the tow vehicle 4 Activate the power jack switch o
56. LOCKED POSITION KEEP HANDS CLOTHING BED COVERS AND LOOSE ARTICLES AWAY FROM THE LIFT STRAPS AND ROLLERS WHEN BED IS BEING RAISED OR LOWERED ARTICLES CAN BE CAUGHT IN THE ROLLERS AND CAUSE PERSONAL INJURY OR DAMAGE TO THE DRIVE MOTOR HEARTLAND Recreational Vehicles LLC The bed requires 12 Volt DC power and will operate when the house batteries are fully charged and the house disconnect switch is ON To Lower Bed Clear all objects from under the bed that may get crushed beneath the bed remove the travel lock pins press and hold the switch in the down position until the bed stops Switch is located on the wall near the bed To Raise Bed Clear all linens and other objects from bed press and hold switch in the up position until the bed is fully raised bed will stop automatically lock with the travel lock pins ADANGER _ mealoriregd vehicle gr al merhig ae pihe lon azphy lation Ht plored er hin Bre recrea ol Mia of 1 rida ia the vaniele xlorage anrea while a Es arg 2 Dia nat sleep on 5e m jiis pa while vehleles present 1 Clase and ia e separation 3 mhile Emi rr iz present 4 mds inet ol tiores vehicles shar shutting off at the nat store transport or dispense fuel inside provided le ion ths rapinta 7 Be nal eperns propane appliances cade or KC UC pee
57. M CAPACITY FOR EACH TIEDOWN POINT IN THE CARGO AREA IS 1500 POUNDS Chocks and Blocks Chocks and blocks prevent accidental or unintended movement of mobile equipment and cargo while you are loading unloading hitching unhitching or performing service or maintenance Wheel chocks are wedge shaped blocks placed in front of or behind the rear wheels of a trailer or tow vehicle to prevent the trailer from moving while the trailer is being loaded Trailer creep occurs when the sideways and vertical forces exerted each time a load enters and exits the trailer cause the trailer to slowly move away from the loading area The weight and speed of loading can affect trailer creep The grade the trailer it parked on the softness of the suspension and whether the trailer has been dropped off or if it is still connected to the tow vehicle are also factors Loading accidents can also occur when a driver prematurely pulls away while the trailer is still being loaded unloaded Always hitch the trailer to the tow vehicle and use wheel chocks or other vehicle restraining devices when loading and unloading the trailer Keep spare chocks on hand They often get left behind or lost during outdoor activities Chocking the wheels of a truck trailer or other piece of mobile equipment provides a physical stopper to the wheels to prevent runaways that can crush or injure people and damage equipment 83 When chocking use wheel chocks of the appro
58. NGTHEANTENNA MAKE AN OUTSIDE VISUALINSPECTION FOR ANY OBSTRUCTIONS OR OVERHEAD ELECTRICAL WIRES DAMAGE TO THE ANTENNA SEVERE SHOCK PERSONAL INJURY OR LOSS OF LIFE CAN OCCUR FROM INADEQUATE CLEARANCE To raise the antenna rotate the crank handle clockwise to raise the antenna about 14 15 turns Pull down on the outside directional wheel and rotate the antenna until the best picture is obtained the directional wheel is spring loaded To lower the antenna pull down on the directional wheel and align arrows then rotate crank handle counterclockwise lowering antenna fully into the cradle Make an outside visual inspection to ensure the antenna is properly stowed HEARTLAND Recreational Vehicles LLC SLIDE OUTS EN NOTICE mE DO NOT EXTEND THE SLIDE ROOM IN SNOW SLEET ICE OR FREEZING RAIN THERE MAY BE EXTENSIVE DAMAGE RESULTING FROM THE If your trailer is equipped with a slide out precautions must be taken before operation of the slide room Make sure you have clearance on the exterior Make sure that all your interior items are clear Make sure you have sufficient battery power Press and hold the slide out room switch in the OUT position The slide out room will move slowly to the out position The drive motor will not stop automatically To stop the slide out room before reaching the OUT position release the switch To continue room movement push and hold the switch Release the Switch to lock the room into positio
59. Out Circuit Breakers If attempting to move the slide and it is perceived that the electric motor has no power inspect the breakers and fuses If a fuse is blown you may need to replace it Slide Out Weather Seals Frequently check all seals and gaskets on the slide out walls for proper fit and operation The seals and gaskets should be coated with a silicone spray for easier operation and weather protection Inspect the condition of the slide tubes not the hydraulic ram under the slide out and if needed use bearing grease for ease of operation Although every attempt is made to have 100 air tight seal you will find that the best seal possible can be achieved with proactive maintenance and proper use Hydraulic Slide Out System The hydraulic slide out system uses a 12 volt DC power motor to drive a hydraulic pump which moves fluid through a system of hoses into a dual directional hydraulic actuator to extend and retract the room s Electricity for the pump motor and assembly is supplied by the RV Battery A simple press and release wall mounted switch provides normal operation to extend and retract the slide out room s Typical maintenance for the pump would be to verify and add an automotive type a fluid for the pump The pump has a see thru reservoir that makes checking for proper level easy For best performance the fluid level should be within 72 inch of the top of the reservoir with all room s retracted closed It is
60. PMENT POWERED WITH FLAMMABLE LIQUID CAN CAUSE FIRE EXPLOSION OR ASPHYXIATION IF STORED ORTRANSPORTED WITHIN THE RECREATIONAL VEHICLE TO REDUCE THE RISK OF FIRE EXPLOSION OR ASPHYXIATION PASSENGERS SHALL NOT RIDE IN THE RECREATIONAL VEHICLE DOORS AND WINDOWS IN WALLS OF SEPARATION IF INSTALLED ARETO BE CLOSED WHILE THE STORED VEHICLES ARE PRESENT RUN FUEL OUT OF ENGINE OF STORED VEHICLES AFTER SHUTTING OFF FUEL AT THE TANK DO NOT STORE OR TRANSPORT MOTOR FUEL INSIDE THE RECREATIONAL VEHICLE VENTILATE THE STORED VEHICLE STORAGE AREA DO NO OPERATE GAS APPLIANCES PILOT LIGHTS OR ELECTRICAL EQUIPMENT WHEN MOTORIZED VEHICLES OR MOTORIZED EQUIPMENT ARE INSIDE THE RECREATIONAL VEHICLE Roll Over Sofa amp Bed Optional The sofa can be used as a bed or a sofa When not in use the sofa is stored and secured to the sidewall To use the bed remove retaining straps fold all legs out lower bed and fold cushion out To use the sofa remove retaining straps fold out bottom legs only lower bottom cushion to rest on legs and rotate outer cushion to form the back rest Electro Majic Bed Optional The Electro Majic bed is designed with features including easy accessibility and operation When the motor is at rest an internal brake in the motor tube holds everything in place The gear reduction section and the brake will hold up to 300 pound at rest per bed WHEN THE RECREATIONAL VEHICLE IS IN MOTION THE BED MUST BE IN THE UP AND
61. RAILER SET THE CARGO ELECTRICAL DISCONNECT SWITCH TO OFF Fuel Transfer System Safety Static electricity related incidents when refueling are extremely unusual They appear to happen most often during cool or cold and dry climate conditions In rare circumstances these static related incidents have resulted in a brief flash fire occurring at the fill point You can minimize these and other potential fueling hazards by following safe refueling procedures A build up of static electricity can be caused by re entering a vehicle during fueling particularly in cool or cold and dry weather If you return to the fuel fill pipe during refueling the static may discharge at the fill point causing a flash fire or small sustained fire with gasoline refueling vapors 87 If you cannot avoid getting back into the vehicle always first touch a metal part of the vehicle with a bare hand such as the door or some other metal surface away from the fill point upon exiting the vehicle Here are some additional refueling safety guidelines when refueling your vehicle or filling up gasoline storage containers e Turn off vehicle engines Disable or turn off any auxiliary sources of ignition the trailer furnace water heater cooking unit and any pilot lights Turn off main propane valve Do not smoke light matches or lighters while operating the refueling system or when using gasoline anywhere else e Use only the refueling latch provided
62. ST CAMPGROUNDS SUPPLY DUMP STATIONS WHICH CAN BE UTILIZED Loading Tips After you have determined how much weight you can safely carry and selected those items to make up that weight make a list and keep it for future reference Load the RV and distribute the load so that you get proper weight on the axles and hitch Do not load upper cabinets with heavy items which can shift or fall during transit Secure and brace items so they won t move during travel thereby shifting the load in the RV Do not load heavy items near either end of the RV or on the rear bumper Adjust cargo storage to keep the side to side wheel loads as equal as possible Carry only as much water as needed for travel use or to balance the load Always empty your waste water and sewage holding tanks before traveling Make a loading diagram of your properly loaded RV It will help you locate where specific items are stored and will help speed the loading process Store emergency items in a readily accessible location Include tools first aid kit rain gear flashlight highway warning devices and an electric cord or light All items must be considered for their weight and stored according to how heavy they are Heavy items should be placed close to the floor and in the center of the vehicle DON T FORGET TO INCLUDE THE ITEMS YOU PURCHASE ON YOUR TRIP Luggage and similar cargo carried inside the vehicle must be secured to prevent possible damage in the case of
63. SYSTEM IS EMPTY OR WHEN CONNECTED TO CITY WATER RUNNING THE PUMP DRY CAN DAMAGE IT AND VOID THE WARRANTY WHEN LEAVING YOUR CAMPER OR WHEN PULLING IT DOWN THE ROAD BE SURE TO TURN OFF YOUR WATER PUMP SWITCH Waste Water System The waste drainage system was designed to provide adequate and safe storage and or disposal of waste materials All of the materials used in the making of this system are tested by a nationally recognized testing laboratory The drainage system uses plastic piping and fittings connected to the sinks toilet and holding tanks This provides for their drainage to an outside termination The unit should be reasonably level for best operation of the system There are two separate waste systems The gray water system is for waste water from the sinks and shower The black water system is generally for sewage waste from the stool Each tank has its own control valve and both tanks drain through the sewer drain hose The drainage system also includes vents that carry odors caused by drain water and waste out of the RV while also equalizing air pressure Drain clean outs are provided to clean lines between fixtures and holding tanks Drainage P traps By code all drains are equipped with P traps to keep holding tank odors from entering the vehicle If you detect a foul odor which you believe is from your holding tanks add water to all drains to ensure that your P trap water hasn t evaporated from long tern storage
64. T BE TURNED OFF DURING REFUELING OF MOTOR FUEL TANKS AND OR LP GAS CONTAINERS Central Vacuum Optional The vacuum is built into the recreational vehicle and is in a central location The hose receptacle is mounted in the side wall with the canister motor and filter bag mechanism attached Hose with various attachments are supplied To operate the vehicle must be plugged into shore power Lift the lid on the wall receptacle vacuum will turn ON automatically insert the hose in the receptacle and release lid Connect desired attachment on hose and start vacuuming The vacuum has a thermal protector built into the motor to prevent overheating If the motor will not operate it will automatically reset in about hour If motor brushes canister or bearings are worn out the circuit protector will trip Off again after a short period of time If this happens service should be performed by a qualified service representative 62 To keep your vacuum at top efficiency change the filter bag at regular intervals Since cleaning schedules differ check frequently at the beginning to determine proper interval To maintain clean ability replace the filter bag when it is about full To Change the Filter Bag Locate canister lift lid and pull bag collar off connector Open new bag slip collar securely onto inlet connector To reorder check bag for instructions To Remove Secondary Side and Bottom Filter for Cleaning Remove bag pull
65. T attach the cable to the plate handle hitch plate base or plate mounting brackets Adjust the cable so both vehicles may turn freely without pulling the pin from the switch Lubricate the breakaway pin periodically to ensure good operation Make sure the pin is securely in place each time before using the trailer The tow vehicle battery will supply power for the safety breakaway switch pin if a separation occurs However if the pigtail also disconnects the vehicles brakes will not engage unless an RV battery is installed in the vehicle and is charged NEN NOTICE EN DO NOT USE THE BREAKAWAY SWITCH AS A PARKING BRAKE AS IT IS INTENDED FOR EMERGENCY USE ONLY AND SUCH USE WILL DRAIN YOUR RV BATTERY SAFETY BREAK AWAY SWITCH WILL MOT OPERATE unles amp connected fo a power amp ource equivalent to or greater than an mulo motive type 12 volt 12 amp hour wet cell battery Ride Height of Vehicle Clearance When the vehicle is connected to the tow vehicle check the ground clearance and front to rear pitch of the vehicle If the front of the unit is too high weight will be transferred behind the axles causing the unit to fishtail and the rear axle tires to prematurely wear If the front of the unit is too low additional weight will be transferred to the truck To achieve proper ride height adjust the pin box by removing the bolts on each side and raising or lowering the box until the proper holes are aligned then reinsert a
66. TED ONE YEAR WARRANTY PLEASE FOLLOW THE RECOMMENDATIONS IN THIS SECTION TO ADDRESS THIS CONCERN Iria vehicle contains compedite weed Thal comply with he applicable Code of Aaquiations Section 83120 2 a Phare 2 P2 fasmaldehyde emission a3andasda agecsliad on ihe abes Cate of manu arclurg rag 15 76 This page left intentionally blank HEARTLAND Recreational Vehicles LLC TOY HAULERS KE GASOLINE O MAKE SU IE ALL P LIGHTS ARE FF BEF UNLEADED FUEL ONLY Fuel Station Unleaded Fuel Only These guidelines are written to help you understand and follow the proper procedures for using the fuel station on your recreational vehicle Gasoline and gasoline vapors are extremely flammable Proceed with caution after reviewing these operational guidelines Turn on switch inside of unit at main switch panel Red LED will come on The fuel pump is on a 15 minute timer that automatically starts when the switch is turned on This is to protect the pump from overheating CL RTECH Go to pump and move silver switch level located on left end of pump down to turn pump on e Attach grounding strap large alligator clip with braided silver wire to metal portion of vehicle container that you are going to fuel This is to help prevent any hazardous static spark anims Tou a HABBO LAP LR 1 BANI AHE
67. TIONAL VEHICLES LLC HEARTLAND RECREATIONAL VEHICLES LLC does not participate in retail sales or retail contracts in any instance other than by terms of this Limited Warranty 10 Tri hii rA cand mmi prmaams ie and g iid i is LI si dr SE DL im ian ama d inim IHE ip m RU v we ee bis margen d mg ri oe i DE Iu GE as a RN mem ug ee 4 om lm n gr Ph H x E ENE DNUNEND d ENUD GC RAE LOO E PY RD 08 88 Be 8 Dd Rad S l E SEN a ODUM eT De LAT 1 lel a eee ONSE Rut TIG um RU RE ES ducum PEN b Hr ERIS PU LGOCUDCGNDCGEED RU Pd Ri ee PLEIT ee ees i Bad opm che eem modd bpm Ths EME d ng a AFF er ee PING S sb Ping 28 dcn s md ERU CHE La mu ERI Pes RF LL amm made T ll LN mer immu j km p n ma sir imme d BU FA t WDIJAJAGSN GR E Important Facts HEARTLAND RECREATIONAL VEHICLES LLC reserves the unrestricted right at any time and from time to time to make changes in the design of and or improvements upon its product without thereby imposing any obligation upon itse
68. This is also true of the authorized service centers Please note your HEARTLAND RECREATIONAL VEHICLES LLC warranty covers warrantable repairs that are performed by an authorized HEARTLAND RECREATIONAL VEHICLES LLC dealer at their service center or facility only It is important for the owner to know that if you are unable to bring your unit in for repairs HEARTLAND RECREATIONAL VEHICLES LLC is not responsible for any costs incurred for the service call charge or time accrued to come out to your unit Can t find a dealer Have an emergency Heartland customer service can be reached at 574 262 8030 877 262 8032 We can help locate a dealer nearby or in case of emergency or special circumstances provide authorization to a local repair facility Before using any non authorized dealer for any warranty repair call Heartland first Home is where your heart is 11 This page left intentionally blank HEARTLAND Recreational Vehicles LLC CUSTOMER INFORMATION UPDATE FORM HEARTLAND RECREATIONAL VEHICLES LLC strives to keep the most accurate and current customer information in its files in order to maintain good customer relations If you bought this unit new we have your information from the warranty registration form which you have sent to us on file If however you purchased this unit as used then we ask that you complete the following information and mail it or fax it to us at 574 262 8340 so that we can be sure that o
69. UNIT TO A QUALIFIED LP GAS SERVICE TECHNICIAN TO FIND AND REPAIR THE LEAK KEEP THE TANK VALVE CLOSED AND ALL OF THE APPLIANCES TURNED OFF WHEN THE UNIT IS STORED IF ANY OF THE LP GAS VALVES DO NOT CLOSE LEAK TIGHT BY HAND CONSULT A SERVICE TECHNICIAN Although your LP gas system was thoroughly inspected for leaks before delivery gas fittings can loosen from vibration during travel Your LP gas system should be inspected at least every three months and before every trip If a leak is suspected check immediately Precautions and Recommendations e Inspect LP fill valve for foreign material before refueling Shut off tow vehicle and pilot lights when refueling gas tanks Never check for gas leaks with an open flame match etc Visually inspect gas lines for any problem periodically Have dealer inspect gas systems yearly and before and after long trips Always have a qualified technician check and make any repairs in your gas system THIS GAS PIPING SYSTEM IS DESIGNED FOR USE OF LIQUEFIED PETROLEUM GAS ONLY DO NOT CONNECT NATURAL GAS TO THIS SYSTEM DO NOT FILL CONTAINER S TO MORE THAN 80 PERCENT OF CAPACITY SECURELY CAP INLET S WHEN NOT CONNECTED FOR USE AFTER TURNING ON GAS EXCEPT AFTER NORMAL CONTAINER REPLACEMENT TEST GAS PIPING AND CONNECTIONS TO APPLIANCES FOR LEAKAGE WITH SOAPY WATER OR BUBBLE SOLUTION DO NOT USE PRODUCTS THAT CONTAIN AMMONIA OR CHLORINE ALL PILOT LIGHTS APPLIANCES AND THEIR IGNITERS S
70. ach Because of this the LP detector installed in your coach is located near the floor The detector is also sensitive to other fumes such as hair spray which contain butane as the propellant Butane like propane is heavier than air and will settle to the floor level where it may be detected The detector is equipped with a sensor activation strip This strip must be removed for the detector to operate properly This should have been done during the dealer s pre delivery inspection Please check the detector to verify that the activation strip has been removed Please consult your LP detector User s Guide for more detailed information Home is where your heart is A WARNING LABEL LOCATED IN THE COOKING AREA REMINDS YOU TO PROVIDE AN ADEQUATE SUPPLY OF FRESH AIR FOR COMBUSTION UNLIKE HOMES THE AMOUNT OF OXYGEN SUPPLIED IS LIMITED DUE TO THE SIZE OF THE RECREATIONAL VEHICLE PROPER VENTILATION WHEN USING THE COOKING APPLIANCE S WILL AVOID DANGER OF ASPHYXIATION IT IS EXPECIALLY IMPORTANT TO ENSURE A FLOW OF FRESH AIRWHEN THE APPLIANCE IS USED FOR LONG PERIODS OF TIME WARNING IT IS NOT SAFE TO USE COOKING APPLIANCES FOR COMFORT HEATING Cooking appliances need fresh alr for safe operation Before operation 1 Open overhead vent or turn on exhaust fan 2 Open window FAILURE TO COMPLY COULD RESULT IN DEATH OR SERIOUS amp BRI PRAE UTR RES 8 bi Dur i BFE i 0
71. ally opening a window during these activities will assist in ventilation In extremely humid conditions the use of a dehumidifier can be helpful Frequent use of your RV or cleaning regularly is an important preventive measure Further any spills should be wiped up quickly and dried as soon as possible Avoid leaving damp items lying about On safe surfaces use mold or mildew killing cleaning products Check sealants regularly and reseal when necessary to avoid water leaks Proper preventive maintenance to the RV and its accessories as described both in this manual and in accompanying literature will provide the best protection to the RV 74 For more information of controlling moisture in the RV please read Tips to Controlling Condensation located in this manual If using a dehumidifier please read and follow all manufacturer instructions and recommendations to the use and cleaning of the dehumidifier TIPS TO CONTROLLING CONDENSATION To avoid condensation problems try to follow these tips to help alleviate excess moisture Allow excess moisture to escape to the outside when bathing washing dishes hair drying laundering and using appliances and non vented gas burners Always use the vent hood when cooking Keep the bathroom door closed and the vent or window open when bathing and for a period of time after you have finished Do not hang wet clothes in the vehicle to dry n hot weather sta
72. and alignments within the first three 3 months from date of original purchase are subject to warranty coverage Thereafter these items are considered routine maintenance Description Of Service Work Performed Service Performed By C o Home is where your heart is 21 MAINTENANCE RECORD Lose T mies teen Of Service Work Performed Seca Performed Cot 22 HEARTLAND Recreational Vehicles LLC HITCHING amp LOADING Hitches You should become comfortable hooking up your vehicle with practice There are several types of vehicle hitches available Be certain to use the one recommended by your tow vehicle manufacturer and that meets the weight requirements of your vehicle Those described here are typical but have your dealer demonstrate and explain the proper hitching and unhitching procedure for your vehicle AN IMPROPERLY COUPLED TRAILER OR 5 WHEEL CAN RESULT IN DEATH OR SERIOUS INJURY USE OF A TOW VEHICLE WITH A TOWING CAPACITY LESS THAN THE LOAD RATING OF THE TRAILER CAN RESULT IN LOSS OF CONTROL AND MAY LEAD TO DEATH OR SERIOUS INJURY Be sure your hitch and tow vehicle are rated for the Gross Vehicle Weight Rating GVWR of your vehicle Be sure the hitch load rating is equal to or greater than the load rating of the coupler Be sure the hitch size matches the coupler size Observe the hitch for wear corrosion and cracks before coupling Replace worn corroded or cracked hitch components before coupling
73. and that you take in to account the size and height of the mattress either originally installed by Heartland or later replaced by you so that the rails are the appropriate height above the top of the mattress This is important because residential mattresses differ in size from the RV mattresses originally installed by Heartland Home is where your heart is Please also make sure that the bed rail you select allows for adequate room to get in and out of the elevated bed after installation especially in the event of an emergency s for Safe Usage Please use sound judgment when allowing children to sleep in any style of elevated bed Generally it is not suitable for children under the age of 6 to sleep in an elevated bed or bed loft area Discuss proper usage of any elevated bed electric bed lift system with your children and make sure they are supervised if playing in the bedroom sleeping area of the trailer with elevated beds Please do not allow horseplay on or under the elevated beds and no items such as hooks belts jump ropes or towels should hang from any part of the elevated bed Place a night light in the bedroom sleeping area so users can see at night when getting in and out of the beds No more than one person should be in an elevated bed at once and make sure you follow the weight restrictions posted on the warning label near the beds e Do not allow children to operate the rear cargo area electric bed l
74. appearance Use a non abrasive cleaner with a soft cloth Ceilings Use a damp cloth to clean the ceiling Clean with a mild detergent in warm water Never use a strong chemical Excessive moisture may damage the ceiling Interior Finish The interior surfaces are easy to clean with mild soap and damp cloth Waxing is unnecessary Stubborn stains may be removed with a spray cleaner Scratches can usually be touched up with a good quality commercial furniture scratch remover Tub and Lavatory Do not use steel wool harsh abrasives or liquid cleaners with solvents These surfaces are best cleaned with soap and water or dishwashing detergent and water Windows The windows in your vehicle should open and close easily If they become clogged with dirt clean the mechanism with a small stiff brush and spray with a silicone lubricant Doors and Drawer Fronts The doors and the drawer fronts in your unit are made of high quality wood They should be wiped off with a dust cloth and a good household cleaner Bedspreads The manufacturer of the bedspreads recommends that the bedspreads not be washed but professionally dry cleaned HEARTLAND Recreational Vehicles LLC WINTER STORAGE Winter Storage Recommendations 1 Level the unit front to rear and side to side 2 Remove bottled and canned goods and other items that could be damaged by freezing 3 Open all the faucets valves and drains including the toilet stool valve
75. ar of the trailer This can cause both total weight problems and hitch weight distribution problems e Secure items so they won t move around while traveling Make sure all items and materials are properly stored Close and latch all drawers cabinet doors and closet doors Pull all loose furniture away from cabinets and walls and lie on their side or secure to prevent rubbing during travel Carry only as much water as you think you will need Home is where your heart is while traveling Water weighs over eight pound per gallon Whenever possible empty the holding tanks before going on the road f you are heading for rough terrain use heavy packing material in the cupboards to hold plates glasses etc Puta nonskid material beneath heavier items to prevent shifting Expensive and breakable belongings should be well packed and placed on the floor in the center of the trailer as the center rides best e Store emergency items such as fire extinguisher first aid kit highway warning devices gloves etc in a readily accessible place Do not bury these items beneath other cargo e When you have properly loaded your trailer with the things you need for your trip make a diagram that outlines where things are stored With this diagram your list of items and the weight of the items you will be able to find specific items easily and have a hand reference for determining proper weights e Weigh your trailer after you have loade
76. artland products are equipped with standard built in elevated beds or bed loft areas These beds can be 4 feet or higher above the floor level and are often enclosed on one two or three sides and sometimes even partially on a fourth side Because there are so many potential users and different types of elevated bed designs elevated beds are not equipped with bed rails Electric Bed Lift Systems Many of the Heartland Sports Utility Trailers Toy Haulers come equipped with rear cargo area electric bed lift systems See the label in the Toy Hauler for proper operation of the rear cargo area electric bed lift systems The bottom beds in some floor plans also can be converted to dual sofas Again like the standard built in elevated beds because of the design and the various uses the rear electric beds are not equipped with a bed rail system Use of Bed Rails We feel that you as the customer are best equipped to determine if a bed rail system is necessary or best for you based on your intended uses the actual users of the elevated beds and the comfort level of the users For those customers who would prefer using an elevated bed with a bed rail there are numerous bed rail styles sizes heights and designs available even in the style of bumpers which can be purchased at various retail locations and or on the internet When installing a bed rail please make sure that you follow the manufacturers installation instructions carefully
77. arts Check shoe return springs Hold down the springs and the adjuster springs to check for stretch or deformation Replace if necessary SOME BRAKE SHOE FRICTION MATERIALS CONTAIN ASBESTOS CERTAIN PRECAUTIONS MUST BE TAKEN WHEN SERVICING BRAKES AVOID CREATING OR BREATHING DUST AVOID MACHINING FILING OR GRINDING THE BRAKE LINING DO NOT USE COMPRESSED AIR OR DRY BRUSHING FOR CLEANING DUST CAN BE REMOVED WITH A DAMP BRUSH Maintain Safe Braking Distance Braking action involves perception time and reaction time First a person has to decide to push on the brake pedal That is perception time Then that person has to bring up their foot to do it That is reaction time Average reaction time is about of a second But that is only an average It will be less with one driver and more up to two or three seconds with another Age physical condition alertness coordination and eyesight all will play a part in the perception time and reaction time So do alcohol drugs and frustration But even in of a second a vehicle such as a truck moving at 60 mph 100 km h travels 66 feet 20 m That is without a trailer behind it That could be a lot of distance in an emergency so keeping enough space between your vehicle and others is very important Especially when considering that it takes ever longer to stop when you have a heavy trailer attached to your tow vehicle Of course actual stopping distances vary greatly with the s
78. ater vapor is carried outside by ventilation or condensed by a dehumidifier it will condense on the inside of the windows and walls as moisture or in cold weather as frost or ice It may also condense out of sight within the walls or the ceiling where it will manifest itself as warped or stained panels Appearance of these conditions may indicate a serious condensation problem When using your trailer you should at all times take necessary action to minimize the effects of excessive moisture and condensation For tips on controlling condensation see the Tips To Controlling Condensation section YOUR TRAILER IS NOT DESIGNED NOR INTENDED FOR PERMANENT HOUSING USE OF THIS PRODUCT FOR LONG TERM OR PERMANENT OCCUPANCY MAY LEAD TO PREMATURE DETERIORATION OF STRUCTURE INTERIOR FINISHES FABRICS CARPETING AND DRAPES DAMAGE OR DETERIORATION DUE TO LONG TERM OCCUPANCY IS NOT CONSIDERED NORMAL AND MAY UNDER THE TERMS OF THE WARRANTY CONSTITUTE MISUSE ABUSE OR NEGLECT AND THEREFORE VOID CERTAIN WARRANTY PROTECTIONS 72 Ventilation and Moisture Control You can reduce interior moisture condensation by taking the following steps 1 Ventilate with outside air Partially open one or more roof vents and one or more windows to provide circulation of outside air into the interior While this ventilation may increase furnace heating load during cold weather it will greatly reduce water condensation Even when it is raining or sno
79. ating of the tow vehicle in some instances To avoid overloading you must be aware of your vehicle weight situation at all times Know where you stand when it comes to GVWR GAWR and your current GVW AND UVW The following is a key to understanding these terms Gross Vehicle Weight Rating GVWR is the maximum permissible weight of this trailer when fully loaded It includes all weight at the trailer axle s and tongue or pin Unloaded Vehicle Weight UVW is the weight of this trailer as manufactured at the factory It includes all weight at the trailer axle s and tongue or pin If applicable it also includes full generator fluids including fuel engine oil and coolants Cargo Carrying Capacity CCC is equal to the GVWR minus each of the following UVW full fresh potable water weight including water heater and full LP gas weight Gross Axle Weight Rating GAWR is the value specified as the load carrying capacity of a single axle system as measured at the tire ground interfaces Gross Vehicle Weight GVW is the weight of the coach with all the items and supplies that are loaded into the unit at any point in time 20 Weighing your vehicle First locate a scale that will be large enough to weigh your trailer and tow vehicle They are generally available at truck stops concrete yards and grain elevators Before weighing your trailer fill the propane tanks 80 capacity and the fresh water tank if you plan on tak
80. ave automatic transmission before your engine labors When going downhill use the same procedure as going uphill well in advance the compression of your tow vehicle s engine will help to slow your whole rig safely Avoid conditions that require excessive and prolonged use of your brakes Apply and release brakes at short intervals to give them a chance to cool Controlling Sway or Fishtailing Sway or fishtailing is the sideways action of a trailer caused by external forces It is common for travel trailers to sway in response to strong winds or crosswinds or when passed by or passing a semi tractor and trailer or driving downhill EXCESSIVE SWAY OR FISHTAILING OF YOUR TRAVEL TRAILER CAN LEAD TO THE ROLLOVER OF THE TRAILER AND TOW VEHICLE SERIOUS INJURY OR DEATH CAN OCCUR IT IS IMPORTANT THAT YOU READ AND UNDERSTAND THE INFORMATION IN THIS SECTION Sway or fishtailing of your recreation vehicle can be controlled and is primarily impacted by four factors Equipment Tongue weight Driving Corrective measures 27 Equipment When hitched together the trailer and the tow vehicle must be level The tires of both the trailer and tow vehicle should be in good condition and inflated to the pressure recommended as noted on the exterior of the trailer and in the owner s manuals of the trailer and tow vehicle Your trailer brakes should work in synchronization with your tow vehicle brakes Never use your tow vehicle or t
81. avy tool chests or cabinets may require tiedowns around the bottom middle and top to secure them Be sure to lock or secure drawers in these chests or cabinets so they can t open while traveling Keep handle bars mirrors etc away from the trailer interior walls The walls can be damaged by contact with hard sharp objects WHEN THE TRAILER IS UNHOOKED FROM THE TOW VEHICLE LOWER AND CHECK THE STABILIZING JACKS BEFORE USING THE LOADING RAMP FAILURE TO DO SO COULD CAUSE THE TRAILER TO TIP BACK AS THE LOAD IS SHIFTED TO THE REAR OF THE CARGO AREA CAUSING PROPERTY DAMAGE PERSONAL INJURY AND OR DEATH HITCH THE TRAILER TO A TOW VEHICLE BEFORE LOADING AND UNLOADING THE REAR CARGO AREA Cargo Loading Procedure Rear Door Loading Ramp Operation 1 Hitch the trailer to a tow vehicle before loading and unloading the rear cargo area Select a parking site where the edge of the rear door loading ramp will rest entirely on a flat level surface and the corners of the door will be supported Avoid soft sand or mud surfaces When the trailer is loaded the added cargo weight may cause the trailer and or tow vehicle to become struck 2 Leveland stabilize the trailer 3 Unlock the rear door landing ramp and carefully lower it to the ground 4 fequipped with a power bunk raise both bunks fully 5 Move things out of the way of your cargo whether HEARTLAND Recreational Vehicles LLC you are loading or unloading Have an idea where
82. claims demands causes of action or disputes arising out of or relating in any way to this warranty or the recreational vehicle shall be resolved exclusively in arbitration in accordance with the Indiana Arbitration Act IC 34 57 1 1 et seq the Uniform Arbitration Act IC 34 57 2 2 et seq and the Indiana Rules for Alternative Dispute Resolution Rules 3 1 through 3 5 There shall be one 1 arbitrator appointed by the Elkhart Circuit or Superior Court Elkhart County Indiana who shall be an attorney with professional experience in the recreational vehicle industry All costs and expenses of the arbitration will be paid by the party against whom the arbitrator rules however each party will bear its own attorneys fees In the event that Heartland RV does not elect to submit any dispute to arbitration or the foregoing arbitration provision is found to be unenforceable the exclusive jurisdiction for deciding any and all claims demands causes of action or disputes arising out or relating in any way to this warranty or the recreational vehicle shall be the Elkhart Circuit or Superior Court Elkhart County State of Indiana By executing this warranty the retail purchaser agrees to the jurisdiction of the courts set forth above 7 APPLICABLE LAW The terms of Heartland RV s obligations under this Limited Warranty are drafted to comply with the Magnuson Moss Warranty Act To the extent other laws are deemed to apply in any respect to this Limite
83. conditions Use extreme caution when going downhill Excessive speed may cause loss of control Never attempt to pass on a curve or anywhere the view of the road ahead is restricted Always check recreational vehicle brakes lights and breakaway switch before starting out on a long trip Confirm that brakes are applied evenly Uneven braking will pull the trailer to one side which may cause a loss of control when towing DO NOTRIDE OR ALLOW OTHERSTO RIDE INSIDETHE RECREATIONAL VEHICLE WHILE ITIS BEINGTOWED SEAT BELTS ARE NOT PROVIDED AND TRANSPORTING OF INDIVIDUALS AND PETS COULD RESULT IN DEATH OR SERIOUS INJURIES OF THEM Tow Vehicle It is important that the recreational vehicle is matched with an appropriate tow vehicle A tow vehicle with an inadequate gross combined weight rating GCWR may experience mechanical failures and may not provide adequate towing stability Consult your dealer for help in selecting the vehicle hitch and related hitching accessories 16 Tips For Driving Due to the overall vehicle length the turning radius is much wider than a standard automobile Always pay close attention to the perimeters front sides rear roof and undercarriage Make sure the surrounding area is clear of any obstacles Swerves and sharp turns especially performed at high speeds could result in the loss of control of the vehicle Drive with extra caution to avoid situations which might require quick momentum chang
84. d Warranty the law applicable to this Limited Warranty and all claims demands disputes causes of action arbitration or litigation relating to this Limited Warranty or from the sale purchase or use of the recreational vehicle shall be the internal laws of the State of Indiana Heartland RV LLC is not responsible for any representation or warranty that is not herein stated Some states do not allow the exclusion or limitation of incidental or consequential damages This warranty gives you specific legal rights You may also have other rights that may vary from state to state or province to province Where any term of this warranty is prohibited by such laws it shall be null and void but the remainder of this warranty shall remain in full force and effect Model Serial No Date Signature Printed Signature Printed Home is where your heart is 5 This page left intentionally blank HEARTLAND Recreational Vehicles LLC TABLE OF CONTENTS Dear Valued Customer 1 Electrical System 47 Limited Warranty 3 Generators 49 Reporting Safety Defects 7 Fire Safety 50 Owner s Information 8 LP Gas System 51 Important Safety Precautions 9 Plumbing 56 Key Information 10 Appliances 60 Customer Update Form 13 Equipment 63 Pre trip Checklist 15 Slide Outs 65 Driving Safety 16 Elevated Beds amp Electric Bed Lift System 67 Maintenance Schedule 18 Exterior Maintenance 68 Maintenance Record 21 Interior Care 70 Hitching amp Loading 23 Winter Stora
85. d it You have to do this several times to get it right TIRE LOAD RATINGS ARE DEPENDENT ON TIRE INFLATION PRESSURES UNDER INFLATED TIRES CAN BE DAMAGED AND RESULT IN A LOSS OF INFLATION PRESSURE Check the trailer tires frequently Tires can lose air over a period of time In fact tires can lose 1 to 3 PSI per month This is because molecules of air under pressure migrate through the rubber from the inside to the outside A drop in tire pressure could cause the tired to become overloaded leading to excessive heat buildup If a trailer tire is under inflated even for a short period of time the tire could suffer internal damage A flat can go unnoticed on a multiple axle trailer while it is being towed Running with a flat can cause it to catch fire and burn up your rig With multiple axles or tandem wheels it is hard sometimes to see a flat tire as the other tires are supporting the weight of the rig and the flat tire is less noticeable A quick check can be made by thumping each tire with a tire iron or rod to make sure they all sound the same Each time you gas up walk around the trailer and give a quick check by feeling each tire with your hand A tire that is getting low will be hotter than the rest There is no substitute however for actually measuring tire pressures to make sure they are all within safe limits Always check the cold tire inflation pressures before each trip and at least once a week during the trip for proper
86. d weight of those installed regular production options weighing over 23 kilograms 5lbs in excess of those standard items which they replace not previously considered in curb weight or accessory weight including heavy duty brakes ride levelers roof rack heavy duty battery and special trim Radial Ply Tire A pneumatic tire in which the ply cords that extend to the beads are laid at substantially 90 degrees to the centerline of the tread Recommended Inflation Pressure This is the inflation pressure provided by the vehicle manufacturer on the Tire Information label and on the Certification VIN tag Reinforced Tire tire designed to operate at higher loads and at higher inflation pressures than the corresponding standard tire Rim A metal support for a tire or a tire and tube assembly upon which the tire bears are seated Rim Diameter This means the nominal diameter of the beat seat Rim Size Designation This means the rim diameter and width Rim Type Designation This means the industry of manufacturer s designation for a rim by style or code 42 Rim width This means the nominal distance between rim flanges Section Width The linear distance between the exteriors of the sidewalls of an inflated tire excluding elevations due to labeling decoration or protective bands Sidewall The portion of a tire between the tread and bead Sidewall Separation The parting of the rubber c
87. e If you have 50 amp service your power cord will look like this typical 50 amp power cord which attaches to the unit Home is where your heart is 50 amp service is also 110 volt service but it is capable of running up the 50 amps of load Some people believe that 50 amp service is the same as having 220 volts of AC power Yes 50 amps of service does have 220 volts but only 110 volts is capable of being supplied to any part of your system at any given time A unique four pronged power cord identifies 50 amp service as two of the four prongs each carry 110 volts of AC power Each of the 110 volt lines in a 50 amp cord supplies power to a designated part of your RV In doing this when 110 volt AC powered components are installed they can be put on separate power feeds according to how much amperage they draw One example of this method consists of installing two air conditioners for use at the same time Each one is powered by a different power supply feed with the 50 amp power cord therefore they can both be used simultaneously MAKE SURE YOUR POWER SUPPLY SHORELINE HOOKUP IS PROPERLY GROUNDED IF YOUR POWER SUPPLY TO THE TRAILER IS NOT GROUNDED YOU WILL EXPERIENCE A DANGEROUS SHOCK WHEN STANDING ON THE GROUND AND TOUCHING A METAL PORTION OF YOUR TRAILER POWER SUPPLY USE A CONTINUITY TESTER TO ENSURE PROPER DO NOT USE AN EXTENSION CORD WTH A CURRENT RATING LESS THAN THE AMPERAGE YOUR RV REQUIRES EXTRA EXTENSION
88. e non staining lubricant is recommended Covering Nicks amp Scratches Seal a nick or scratch with automotive grade primer to prevent rust Once the nick or scratch has been sealed cover the damaged area with an automotive grade or high gloss paint TO PREVENT THE POSSIBLITY OF SLIPPING ON THE ENTRY STEP AVOID EXCESS LUBRICANT ON THE SURFACE OF THE ENTRY STEP ITSELF CAREFULLY CLEAN THE ENTIRE ENTRY STEP AFTER LUBRICATING THE MECHANISM SILICONE LUBRICANTS AND WD 40 ARE NOT RECOMMENDED AS THEY TEND TO EVAPORATE AND DRY THE MATTED SURFACES WHICH LEAVES THEM VULNERABLE TO THE ELEMENTS EXMeM edd IF THE VEHICLE IS TRANSPORTED WITH THE STEP IN THE EXTENDED POSITION THERE IS POSSIBILITY OF CAUSING MAJOR DAMAGE TO BOTH THE STEP AND THE VEHICLE Home is where your heart is Entry Door The door uses two separate locks for personal safety and security The door handle incorporates a primary and secondary latching system One locking system is the door handle and the other is a dead bolt However keepingthe entry door in good operating condition requires some routine maintenance The following adjustments can help maintain the entry door performance The position of the striker plate may change over the course of time and settlement of the recreational vehicle The setting may need to be adjusted to insure that the door operates smoothly and efficiently To adjust the strike plate loosen the two screws holdin
89. e Extinguisher The fire extinguisher is rated for Class B grease gasoline diesel fuel flammable liquids and Class C electrical fires These are the most common types of fires in vehicles Read the operator s manual and the instructions on the fire extinguisher Be sure to know how and when to use the extinguisher and where it is located Fire extinguishers are mechanical pressurized devices Care must be exercised when they are handled They must be maintained as the operator s manual instructs for proper and safe operation The extinguisher should be inspected at least once a month More frequent inspections may be required if the extinguisher is exposed to the weather or the possible tampering Do not test the extinguisher by partially discharging doing this will cause a loss of pressure If a fire occurs in the vehicle evacuate the vehicle as quickly and as safely as possible Consider the cause and the severity of the fire and the risk involved before trying to extinguish it If the fire is major or fuel fed move away from and stand clear of the vehicle and wait for emergency assistance to arrive WARNING TEST DMCTEIC TOHR Ce FC EFTER HEN EPIA ETORADE E Ple TIER IER Smoke Detector The battery powered smoke detector is mounted on the ceiling in the living area of the unit Read the operating instructions PSSST for details on the vimm testing and care for
90. e or activity area for storage of trash tools equipment supplies and expendable containers such as food beverage oil and fuel containers e Give special attention to large loads that may obstruct the view of the loading crew e Wear boots that provide adequate ankle support and a slip resistant tread design and hand protection when loading unloading Always communicate with the person doing the loading Know what the plan is and make sure you agree Maintain eye contact with other persons involved at all times during loading unloading operations e Slow down and pay attention never hurry around loading unloading operations Train everyone in your travel group on the hazards of loading and unloading Establish and enforce compliance to all safety procedures Home is where your heart is Your Loading Equipment The loading equipment furnished with your trailer is the ramp door and the tiedown attachment points in the cargo area floor The rated capacity of the ramp door is 2500 pounds Each tie down D ring attachment is rated at 1500 pounds No tiedown straps cables hooks chains wheel chocks blocks etc are supplied with your trailer Refer to your trailers cargo capacity rating to determine the maximum load capacity of the trailer THE REAR CARGO DOOR WEIGHS APPROXIMATELY 200 POUNDS IT IS DESIGNED FOR TWO PERSON OPERATION THE MAXIMUM CARGO CAPACITY OF THE REAR CARGO DOOR RAMP 15 2500 POUNDS THE MAXIMU
91. e others may not have any reaction to the same levels of formaldehyde Amounts released decrease over time Ventilation To reduce or lessen exposure to chemicals from off gassing it is of utmost importance that you ventilate your recreational vehicle Ventilation should occur frequently after purchase and at times when the temperatures and humidity are elevated Remember off gassing is accelerated by heat and humidity Open windows exhaust vents and doors Operate ceiling and or other fans roof air conditioners and furnaces and use a fan to force stale air out and bring fresh air in Home is where your heart is Decreasing the flow of air by sealing the recreational vehicle increases the formaldehyde level in the indoor air Please also follow the recommendations contained in this chapter regarding tips to avoid condensation problems Many of the recommendations contained in this chapter will assist in avoiding exposure to chemicals that off gas Do Not Smoke Finally we recommend that you do not smoke inside your recreational vehicle In addition to causing damage to your recreational vehicle tobacco smoke releases formaldehyde and other toxic chemicals Medical Advice If you have any questions regarding the health effects of formaldehyde please consult your doctor or local health department Warranty Exclusion CHEMICAL OFF GASSING IS NOTA DEFECT IN YOUR RECREATIONAL VEHICLE AND IS NOT COVERED BY THE LIMI
92. e strongly recommend that you consult your dealer or local trailer brake specialist on these problems IF ANY KIND OR DEGREE OF BRAKE FAILURE OCCURS HAVE THE BRAKES REPAIRED IMMEDIATELY CONTINUED DRIVING IS DANGEROUS AND COULD RESULT IN SERIOUS INJURY OR LOSS OF LIFE Electric brakes should be checked prior to every trip to determine the condition of the magnets and drums and whether wiring connections are still secure see manufacturer s instructions Brakes can be adjusted to activate ahead of the tow vehicle brakes for best road control Consult the manufacturer s instructions or you dealer for detailed information and service procedures Synchronization of Brakes Recreational vehicle brakes are designed to work in synchronization with tow vehicle brakes Never use tow vehicle or recreational vehicle brakes alone to stop the combined load The recreational vehicle and tow vehicle will seldom have correct amperage flow to the brake magnets to give comfortable safe braking unless Home is where your heart is proper brake system adjustments are made Changing the recreational vehicle load and driving conditions as well as uneven alternator and battery output can mean unstable current flow to brake magnets It is imperative to maintain and adjust brakes as set forth in this manual use properly modulated brake controller and perform the synchronization procedure noted below In addition to the synchronization adjustments
93. e tire pressure is too high in any of the tires slowly release air by gently pressing on the tire valve stem with the edge of your tire gauge until you get to the correct pressure If the tire pressure is too low note the difference between the measured tire pressure and the correct tire pressure You will need to add air to get to the correct pressure Add air pressure to each tire that is under inflated Check all the tires again to make sure they have the same air pressure If you have been towing your trailer and think that a tire is under inflated fill it to the recommended cold inflation pressure Remember to recheck and adjust the pressure in all tires when you can obtain a cold reading Tire Tread The tire tread provides the gripping action and traction that prevent your vehicle from slipping or sliding especially when the road is wet or icy In general tires are not safe and should be replaced when the tread is worn down to 1 16 of an inch Tires have built in tread wear indicators that let you know when it is time to replace your tires These indicators are raised sections spaced intermittently in the bottom of the tread grooves When they appear even with the outside of the tread it is time to replace your tires Tire Life Trailer tires may be worn out even though they still have plenty of tread left This is because trailer tires have to carry a lot of weight all the time even when not in use lt is actually b
94. ed by using moisture 54 HEARTLAND Recreational Vehicles LLC free gas and keeping all tank valves CLOSED during storage If moisture is present have the tank purged by an authorized dealer and have him add the proper amount of ANHYDROUS METHANOL for your tank An overfilled tank can allow liquid gas rather than the needed vapor to flow through the regulator This can result in erratic regulator delivery pressure improper appliance operation and possible frosting of the regulator and gas line This can be avoided by following the procedures outlined in the Filling LP Gas Bottles section Always contact your local gas supplier for current procedures Hose Replacement The flexible LP gas hoses connected to your LP tank should be checked frequently for signs of deterioration and may need to be replaced every two to three years Be sure to replace the hoses with approved and properly rated products Regulator Vent Maintenance Since the LP gas regulator is equipped with a vent that allows the system to breathe you must check it on a frequent basis to see that is does not become clogged If dirt sealant or corrosion clogs the vent clean it with a toothbrush or similar device At least once a year have your LP service provider check the regulator adjustment and operation LP Gas Detector Liquid Propane LP gas is heavier than air and will settle to the lowest point of the room which is generally on the floor of your co
95. ehicles LLC 5 ADDITIONAL IMPORTANT INFORMATION CUSTOMER PLEASE READ e Please inspect your recreational vehicle at the time of delivery and make sure you accept it as delivered to you This recreational vehicle has been sold by Heartland RV to an independent dealer who is not an agent of Heartland RV for resale in the ordinary course of the dealer s business The sale to you is by the dealer not Heartland RV on terms and conditions and equipped as the dealer and you determine and your agreement is solely with the dealer not Heartland RV Heartland RV does not participate in retail sales or retail contracts in any instance and its sole obligation is this Limited Warranty e Heartland RV reserves the unrestricted right at any time and from time to time to make changes in the design of and or improvements upon its product without thereby imposing any obligation upon itself to make corresponding changes or improvements in or upon its products already manufactured Heartland RV further reserves the right to substitute parts or components of substantially equal quality in any warranty service required by operation of this Limited Warranty e Arecreational vehicle and the products installed in it will require care and maintenance attention by the owner and occupants Please read and follow all care and maintenance manuals and instructions supplied with your recreational vehicle 6 DISPUTE RESOLUTION At the option of Heartland RV any and all
96. electrical system 46 Circuit Breakers Circuit breakers and fuses protect the circuits in the vehicle Locate the converter and see where the fuses are located If you blow a fuse turn off the appliance Unplug the fuse Check the fuse for breakage and replace it with a new fuse of the proper rating If the fuse continues to fail contact your nearest dealer NEVER REPLACE A FUSE WITH A HIGHER RATED FUSE THAN WHAT IS DESIGNATED NEVER REPLACE CIRCUIT BREAKERS OR FUSES OF HIGHER CURRENT RATING THAN THOSE ORIGINALLY INSTALLED THIS COULD OVERHEAT THE WIRING AND START A FIRE POSSIBLY RESULTING IN PROPERTY DAMAGE PERSONAL INJURY OR LOSS OF LIFE HEARTLAND Recreational Vehicles LLC ELECTRICAL SYSTEM Your electrical system is a combination of 12 volt and 110 volt systems every facet carefully engineered and installed to comply with the National Electric Code The combination system consists of 1 12 volt automotive system DC 2 110 volt outside power source AC 110 Volt System This is supplied by plugging the power cord into an outside 110 volt receptacle It furnishes current to 110 volt roof air conditioners refrigerator and all internal 110 volt receptacles It also supplies power for the 12 volt trailer system through the converter The 110 volt circuits are protected by resettable circuit breakers similar to the ones you would find in your home Depending on your recreational vehicle the number
97. en the water valve to allow water to spray inside the sewage tank This will clean the inside of the tank of any debris that may be left inside the tank After this is done disconnect the water hose and close the gate valve AWARNNG DO NOT USE THE SAME HOSE FOR THE NO FUSS FLUSH THAT IS USED FOR FILLING THE FRESH WATER TANK 59 APPLIANCES Refer to the individual manufacturer s owner s manual for additional operating and safety instructions on the following equipment Microwave Oven The microwave is no different than that found in your home It relies on 110 volt power for operation and should never be used while driving down the road Read over the microwave oven s owner s manual to find all the information on its operation and cleaning Propane Appliances and Equipment Maintenance Follow the instructions and warnings noted in the appliance and equipment owner s manual as well as the ones listed below e Annual maintenance should be conducted on the propane appliances and equipment by an authorized dealer or repair facility e Insects can build nests in the burners of the various appliances and equipment The burner and burner orifice of the propane appliances and equipment should be cleaned out by an authorized dealer or repair facility anytime circumstances or conditions warrant but no less frequently than on an annual basis Gas Electric Refrigerator Unlike your home refrigerator the un
98. ent of a flat tire it is recommended to call for roadside assistance The size and weight of the trailer requires the proper equipment to change the tire A professional service technician will have the equipment and training necessary to repair or replace the tire In the event of sudden tire failure avoid heavy braking HEARTLAND Recreational Vehicles LLC Slowly move to a safe off road location which should be a firm level area Turn the hazard flasher system on Inform roadside assistant of proper wheel mounting procedures IN CASE THE TRAILER REQUIRES TOWING ENSURE ALL PRECAUTIONS ARE FOLLOWED THE MANUFACTURER WILL NOT COVER DAMAGE TO THE TRAILER CAUSED BY A TOWING COMPANY NEVER ALLOW ANYONE TO GO UNDER A TRAILER WHILE IT IS BEING LIFTED BY TOWING EQUIPMENT SERIOUS INJURY OR LOSS OF LIFE COULD RESULT Electric Brake System The electric brakes on your vehicle are similar to those in your automobile the difference being that they are activated by 12 volt electrical impulse as opposed to a hydraulic system The impulse comes from a brake controller which in effect regulates the flow of electrical current to the trailer brakes Brakes are usually maintenance free however road and driving conditions may at times cause them to grab drag or fade Also improper grounding of the trailer to the tow vehicle irregular current or a short circuit in the wiring system will cause electric brakes to malfunction In any case w
99. ent products used in the construction of recreational vehicles such as carpet linoleum plywood insulation upholstery etc Formaldehyde is also the by product of combustion and numerous household products such as some paints coatings and cosmetics However recreational vehicles are much smaller than your home and therefore the exchange of air inside a recreational vehicle is significantly less than ahome These products when new or when exposed to elevated temperatures and or humidity may off gas different chemicals including formaldehyde This off gassing in combination with the minimal air exchange may cause you to experience irritation of the eyes nose and throat and sometimes headache nausea and a variety of asthma like symptoms Elderly persons and young children as well as anyone with a history of asthma allergies or lung problems may be more susceptible to the effects of off gassing Formaldehyde Most of the attention regarding chemical off gassing surrounds formaldehyde Formaldehyde is a naturally occurring substance It is also a key industrial chemical used in the manufacture of the numerous consumer products which we referred to above and used in the construction of recreational vehicles Trace levels of formaldehyde are also released from smoking cooking use of soaps and detergents such as carpet shampoos cosmetics and many other household products Some people are very sensitive to formaldehyde whil
100. er the recreational vehicle to the dealer or authorized repair location or manufacturing plant for warranty service as designated 4 WHAT IS NOT COVERED BY HEARTLAND RVS LIMITED WARRANTY e This Limited Warranty does not cover retail sold units for which Heartland RV has not received the Heartland RV LLC Warranty Registration Notice e Additional components which have been installed in the recreational vehicle including but not limited to microwave ovens ranges refrigerators leveling jacks furnaces heaters DVD CD players air conditioning icemakers vacuum cleaners televisions hot water heaters generators power converters batteries and other items not specifically manufactured by Heartland RV LLC are warranted by the component manufacturers as detailed in their individual manufacturers warranties and are not covered by this Limited Warranty Copies of the warranties may be found in the product owner s packet or by contacting Heartland RV LLC e Problems which may result from not following proper operating practices instructions warnings or regulations including but not limited to those contained in the owners manuals on labels or otherwise provided by law Failure which may be caused by or related to abuse misuse negligence or accident failure which may be related to alteration or modification failure as a result of not following instructions contained in the owners manuals e Normal deterioration due to wear or exposure
101. ere are a few things you can do to help facilitate the cleaning process later First you should always use some type of chemical additive in your holding tanks specifically designed for RV use These types of chemical will break down the contents of the tank and help ensure good drainage In addition try using tissue designed for recreational vehicles lt will break down more than residential style tissues and usually never clogs your drain valves Do s and Do Nots of Holding Tank Use DO Clean the holding tank with an approved cleaner DO Add a special chemical additive to sanitize and improve tank action DO Guard the tank against freeze up DO Keep the waste water tank dump valves closed to allow the tanks to get as full as possible to facilitate drainage DO Keep the dump valve closed and the drain cap in place to allow use of the system when not parked at a campsite DON T Put facial tissues paper automotive type antifreeze sanitary napkins diapers or household toilet cleaners in your holding tank DON T Put foreign objects in the system that could clog or damage it in any way DON T Travel with full holding tanks Holding Tank Flush System No Fuss Flush Your unit may be equipped with a waste holding tank flushing system When draining your sewer tank attach a water hose to the sewer spray hookup Open the dump valve and let the tank empty After the tank is drained leave the gate valve open and op
102. ern easy lube technologies Remove the rubber plug from grease cap Insert grease gun on the grease zerk Pump until new grease begins to appear Replace rubber plug Hubs and components should also be disassembled yearly and inspected for worn or otherwise damaged parts 32 KEEP TIRES PROPERLY INFLATED A TIRE THAT IS RUN LONG DISTANCES OR AT HIGH SPEEDS WHILE SERIOUSLY UNDERINFLATED WILL OVERHEAT TO THE POINT WHERE THE TIRE MAY LOSE AIR SUDDENLY AND OR CATCH FIRE POSSIBLY RESULTING IN DAMAGE TO THE VEHICLE AND ITS CONTENTS AND OR PERSONAL INJURY Tires and Wheels The tires should be checked before starting on every trip Check them regularly and keep inflated to recommended pressures The recommended tire pressure is on the side of the tire Rotate tires at least once every 5 000 miles or aS recommended by the tire manufacturer Most models have a spare tire available in case of an emergency All vehicles are equipped with tubeless tires They are designed for today s turnpike speeds and are rated to carry the weight of the trailer plus your family s personal needs for an extended vacation If you should require an adjustment on a faulty or defective tire secure the name of your nearest tire dealer or distributor and request an adjustment according to the conditions and terms of the warranty Changing Use emergency flares when near a road or highway Block wheels on the opposite side from the tire you w
103. es When passing another vehicle allow extra time and space due to the additional length and weight Practice using the brakes away from traffic to get the feel of the distance required to stop the vehicle When traveling make sure bridges can support the combined weight of the tow vehicle and recreational vehicle Tonnage limits for bridges should be posted at entrances Also check the posted height of overhead clearances Keep in mind road surfaces may have been repaved or become packed with snow Therefore the actual posted clearance height may not apply If a problem occurs do not panic If a sudden bumping or fish tailing occurs it may indicate a flat tire Do not jam on the brakes or suddenly accelerate in an attempt to drive out of it Instead come to a stop slowly while driving as straight as possible If conditions permit coast to a very slow speed and try to avoid braking except when the wheels are straight ahead and the trailer and tow vehicle are in line with each other If the vehicle begins to fishtail when accelerated to highway speed back off the accelerator This should stop the fish tailing If it begins again when speed increases stop and check the load which may not be distributed evenly from side to side or is too far back to put a sufficient load on the hitch pin Redistribute the load as necessary before continuing Driving Cautions Avoid getting to close to the edge of the road a soft shoulder ma
104. es of operation to reduce wear and provide easier turning As an alternative use a grease free lubrication pad between the hitch saddle and the pinbox plate Inspect and clean the hitch latch plate before each use Grease the pivot points between the rails and hitch with lithium based grease every 2 000 miles of operation Replace all worn or damaged parts Electrical Connection Plug the pigtail on the vehicle into the electrical harness on the truck Be sure there is enough slack to allow the vehicle to turn without disconnecting the pigtail Make sure all lights and the brakes work prior to moving the vehicle Current draw should not exceed ten amps for each designated light circuit The tow harness wires are coded as follows 1 White 8 gauge Ground 2 Blue 12 gauge Brake 3 Green 14 gauge Clearance Lights 4 Black 14 gauge Charge Line 5 Red 14 gauge Left Turn 6 Brown 14 gauge Right Tum T Yellow 14 gauge Aux OD 5 NOTICE WHILE IT IS POSSIBLE TO OPERATE 12V ITEMS IN THE RV THROUGH A TOW VEHICLE CHARGE LINE IT IS NOT RECOMMENDED DUE TO THE HIGH POWER CONSUMPTION OF SOME ITEMS he m i L mii E a p ah r a eee a H im E Jle F I on 4 LS D m E E I I a d HEARTLAND Recreational Vehicles LLC Safety Breakaway Switch Attach the safety breakaway tether to the truck body DO NO
105. ess whenever the trailer makes a tight turn When you go around corners especially slow tight ones the wheels on your trailer are subjected to these strong side loads This tends to flex the wheel and gradually loosen the wheel nuts Although the materials and manufacturing methods are maximized for this kind of service these extra load stresses and flexing can cause loosening It is critical that the wheels be properly torqued at the start of the trip and every 50 miles for the first 500 miles of road operation Although the wheels have been properly torqued before leaving the manufacturing plant settling and wearing in of components during the first few miles of operation may cause some loosening of the wheel nuts The wheel nut torque is 120 ft lbs Always use an accurate torque wrench to tighten wheel nuts A torque wrench with adequate accuracy is available at most automotive tool stores Considering the overall investment in the trailer this is a very reasonable cost Use of a torque wrench can also reduce the effort required to tighten the wheel nuts IT IS IMPORTANT TO MAINTAIN PROPER TORQUE TO PROVIDE SAFE AND SECURE ATTACHMENT OF THE WHEEL TO THE HUB DRUM BE SURE TO USE WHEEL NUTS THAT ARE COMPATIBLE WITH THE COIN IN THE WHEEL IMPROPERLY TORQUED WHEEL NUTS CAN CAUSE THE WHEEL TO SEPARATE FROM THE WHEEL MOUNTING SURFACE DURING OPEARTION THIS COULD RESULT IN PROPERTY DAMAGE SERIOUS PERSONAL INJURY OR LOSS OF LIFE
106. etter for a tire to be rolling down HEARTLAND Recreational Vehicles LLC the road than to be idle During use the tire releases lubricants that are beneficial to tire life Using the trailer tires often also helps prevent flat spots from developing The average life of a trailer tire is about five years under normal use and maintenance conditions After five years trailer tires may be degraded to the point that they should be replaced even if they have had minimal or no use Exposure to sunlight ultra violet damage and high speed towing in hot conditions also reduces tire life As heat builds up during driving the tire s internal structure starts to break down compromising the strength of the tire Have your tires inspected by a tire supplier to determine if your tires need to replaced ALL TIRES ON YOUR TRAILER SHOULD BE THE SAME TYPE SIZE CONSTRUCTION AND LEAD RATING DO NOT MIX BIAS BELTED AND RADIAL TIRES Replacement Tires To maintain tire safety purchase new tires that are the same type size construction and load ratings as the original tires Look at the tire Information placard or the sidewall of the tire you are replacing to find this information If you have any doubt about the correct size to choose consult with the tire dealer THERE IS A DANGER OF SERIOUS INJURY OR DEATH IF A TIRE OF ONE BEAD DIAMETER IS INSTALLED ON A RIM OR WHEEL OF A DIFFERENT RIM DIAMETER ALWAYS REPLACE A TIRE WITH ANOTHER TIRE O
107. ewall strain and tread deflection Cover the tires to block direct sunlight and ultraviolet rays The parking surface will affect moisture accumulation on the chassis and flooring Gravel covered parking areas allow moisture to evaporate into the underside of the recreational vehicle Sealed concrete pads allow better ventilation under the recreational vehicle Storage buildings with sealed concrete floors or heated facilities greatly reduce the amount of moisture accumulation and protect the recreational vehicle from moisture damage Avoid wet or greasy surfaces Avoid highly reflective surfaces like asphalt sand or snow e e e e e e e Before removing the vehicle from long term storage thoroughly inspect each tire tread area and air pressure In the pressure check indicates tires have lost air inflate to correct pressure for current load before use Support Tires When Leveling Extreme caution must be taken to ensure the tires are fully supported when placing blocks under the tires The load on the tire should be evenly distributed on the support block In case of dual tires distribute the load evenly on blocks for both tires If not properly supported the steel cables in the sidewall of the tires may be damaged and could lead to premature fatigue of the sidewall __ ACAUTION SUPPORTING TIRES PREVENTS DAMAGE TO THE SIDEWALL OF THE TIRES BUT DOES NOT PREVENT TIRE ROLL In Case of Flat Tire In the ev
108. f each season and whenever a problem occurs Proper line pressure is 11 inches of water column Your RV dealer or gas supplier can perform this needed check San er E GE ey Gas Line Check Check the gas line connectors and all other connections regularly To check turn OFF all burners and pilotlights Open all doors and windows OPEN the LP gas tank s service valve and use soapy water or an approved leak detector fluid to test all line connections Do not use products that contain AMMONIA or CHLORINE The appearance of bubbles in the soapy solution indicates a leak Tighten the connections with two 2 open end wrenches until the bubbles stop If this does not take care of the leak contact your gas dealer DO NOT OVERTIGHTEN Gas Tank and Regulator Freeze Up LP gas regulator freeze up can be prevented if owners are aware of the causes Freeze up may be caused by one of the following moisture in the tank an overfilled tank or a greater vapor withdrawal demand than the tank can deliver at a particular temperature Freeze up occurs more frequently in cold weather since liquid gas does not vaporize as quickly This along with a higher demand can cause frost on the tank and regulator Be sure to have your LP gas supplier add ANHYDROUS METHANOL before filling the tank in cold weather Moisture may enter the tank in the LP gas through condensation if air is allowed to enter the tank through an open valve This can be avoid
109. ffic to keep the trailer from edging into the opposing lane On sharply winding and narrow roads keep well to the center of your lane equally away from both the center line and the pavement edge This allows the trailer to clear the edge of the pavement without likelihood of the wheels dropping off onto the shoulder which could cause dangerous trailer sway Do not overcrowd or cross the center line All sharp turns should be taken at low speeds Professional drivers when rounding turns slow down well in advance of the turn enter it at reduced speed and then accelerate smoothly as they come out again onto the straightaway HEARTLAND Recreational Vehicles LLC Overtaking and Passing When you pass another vehicle remember that it takes longer to accelerate and you must allow for the length of the trailer to pass as well before returning to your lane Use your signals freely On freeways and expressways try to pick the lane in which you want to move and stay in it preferably the slow lane to the right Remember always pass very carefully Slippery Pavement On slippery and icy pavement drive slowly and if you feel you are skidding gently apply the trailer brakes only Backing and Parking After arriving at your destination your next task is to choose a good level parking space and back into it A recommended procedure for backing into a space is Stop near the site get out and look it over Check the Home is where your hea
110. g the plate to the jamb system Move the plate in or out as needed to obtain a proper seal closing force Retighten the screws HE NOTICE IF SCREWS ARE LOOSE ON THE OUT SWING DOORS THE BACKER PLATE WILL RELEASE AND DROP DOWN INTO THE DOOR JAMB SHOULD THIS HAPPEN REPLACE THE SHORT SCREWS WITH A SCREW THAT IS LONG ENOUGH TO GO THROUGH THE JAMB SYSTEM AND INTO THE FRAME WORK OF THE SIDEWALL The locking cylinder requires slight lubrication on an annual basis or as needed Use powdered graphite not a petroleum product which will gum the cylinder and inhibit smooth operations The upper lock is the dead bolt the lower lock is the privacy lock Applying a light coating of white lithium grease to the face of the lock bolt helps in retaining a smooth close The hinges for the door require slight lubrication annually or as needed with a high quality dry spray lubricant The screen door can be adjusted to sit flush in the door jamb This requires two separate adjustments to be performed The first adjustment made is at the screen door latch catch itself Loosen the two screws holding the latch to the door to permit vertical adjustment Move the latch far enough to catch on the striker mounted at the door frame Tighten both screws The striker mount on the door frame permits horizontal adjustment Again loosen the two screws holding the striker assembly Move the striker to center the latch and tighten the screws in place Itis a
111. ge 71 Wheel Nut Torque 30 Prolonged Occupancy 72 Tires amp Braking 32 Molds 74 Glossary of Tire Terminology 41 Chemical Sensitivity 75 Leveling 43 Toy Haulers 77 Power Systems 45 Cargo Ramp Trailer Weight Distribution 82 Reporting Safety Defects At the time a motor vehicle manufactured on or after September 1 1990 is delivered to the first purchaser for purposes other than resale the manufacturer shall provide to the purchaser in writing in the English language and not less than 10 point type the following statement in the owner s manual or if there is no owner s manual on a one page document If you believe that your vehicle has a defect which could cause a crash or could cause injury or death you should immediately inform the National Highway Traffic Safety Administration NHTSA in addition to notifying INSERT NAME OF MANUFACTURER If NHTSA receives similar complaints it may open an investigation and if it finds that a safety defect exists in a group of vehicles it may order a recall and remedy campaign However NTHSA cannot become involved in individual problems between you your dealer or INSERT NAME OF MANUFACTURER To contact NHTSA you may either call the Vehicle Safety Hotline toll free at 1 888 327 4236 TTY 1 800 424 9153 go to http www safercar gov or write to Administrator NHTSA 1200 New Jersey Avenue S E Washington DC 20590 You can also obtain other information about motor vehicle safety from h
112. generator be operated while sleeping Be sure to follow all instructions and warnings in this manual and the manual provided by the generator manufacturer see page 49 Lug Nut Torquing Being sure wheel mounting nuts lug nuts on trailer wheels are tight and properly torqued is an important responsibility that trailer owners and users need to be familiar with and practice Inadequate and or inappropriate wheel nut torque tightness is a major reason that lug nuts loosen in service Loose lug nuts can rapidly lead to a wheel separation with potentially serious safety consequences see page 30 Appliances and Equipment The appliances stove refrigerator outdoor grills etc and equipment hot water heater furnace generator etc typically operate on LP gas LP gas is flammable and is contained under high pressure Improper use may result in a fire and or explosion Be sure to follow all instructions and warnings in this manual see pages 60 64 as well as the specific owners manuals of the appliances and equipment Tire Safety Properly maintained tires improve the steering stopping traction and load carrying capability of your vehicle Underinflated tires and overloaded vehicles are a major cause of tire failure For more information on tire safety please see pages 35 KEY INFORMATION Specification Label There are two main numbers used to identify the vehicle The Vehicle Identification Number VIN is the legal ident
113. generator inspect the exhaust system Do not use it if the exhaust system is damaged Test the carbon monoxide detector every time you use the RV Know what the symptoms of carbon monoxide poisoning are e Dizziness Vomiting Nausea Muscular twitching Intense headache Throbbing in the temples Weakness and sleepiness Inability to think coherently If you or anyone else experience any of these symptoms get to fresh air immediately Shut the generator down and do not operate it until it has been inspected and repaired by a professional If the symptoms persist seek medical attention DANGER Carbon Monoxide is poisonous and can cause unconsciousness and death Follow all instructions in this section as well as the ones outlined in the generator operator s manual Home is where your heart is 1 10 DO NOT operate the generator while sleeping You would not be aware of exhaust entering the recreation vehicle or alert to symptoms of carbon monoxide poisoning Never store anything in generator compartment Always keep compartment clean and dry DO NOT operate the generator in an enclosed building or in a partly enclosed area such as a garage Review the safety precautions for fuel and exhaust fumes elsewhere in this manual DO NOT operate the generator when the recreation vehicle is parked in high grass or brush Heat from the exhaust could cause a fire in dry conditions Never operate your chassis or generator
114. gle switch as the lock pins in the landing legs near the end of the outside tubes to avoid unnecessary wear on the motor clutch LANDING LEGS MAY WORK WITH HANDLE IF THE ELECTRIC DRIVE MOTOR IS INOPERATIVE OR IF ELECTRICITY IS UNAVAILABLE REMOVE THE HANDLE BEFORE USING THE ELECTRIC MOTOR THE HANDLE MAY JERK CAUSING INJURY BEFORE TOWING CHECK FOR MAXIMUM CLEARANCE BETWEEN THE GROUND AND THE BOTTOM OF THE LANDING GEAR 44 TO LOWER LEGS MANUALLY Insert the crank handle into the alignment tube until the end engages the crank shaft The shaft is located at the front of the trailer Turn the crank handle counterclockwise to raise vehicle to the desired height Remove and store the handle TO RAISE LEGS MANUALLY Insert the crank handle into the alignment tube until the end engages the crank shaft The shaft is located at the front of the trailer Turn the crank handle clockwise to lower vehicle to the desired height Remove and store the handle MAINTENANCE SCHEDULE Before each use inspect the drop tube and the inner ram tube replace if they are bent or damaged Annually Extend landing legs as far as possible clean the drop tube and the inner ram tube Coatthe exposed surface of tubes and the inside ofthe handle alignment tube with a silicone spray lubricant Oil the shaft bushing in gear box and leg gear heads with SAE 30 oil Lubricate the gears in the gear box and the landing leg gear heads with extreme
115. go area WHILE THE INTERIOR SURFACE IS NON SKID DESIGNED SURFACE MAY STILL BECOME SLIPPERY DUE TO EXCESS MOISTURE OR CHEMICALS BE VERY CAUTIOUS WHEN WALKING ON THE RAMP DOOR Cargo D Rings are provided in the garage area to allow you to secure all cargo when in transit Each ring has a capacity of 2000 Ibs Remember to always secure your cargo when you are traveling with your RV Significant damage can occur when cargo shifts and is loose in the garage area when the vehicle is moving Some models are equipped with a chain drive bed lift in the cargo area Please refer to the product manual for proper operating procedures and precautions Never use the bed or sofa for anything except for it s designed purpose Optional rear screen wall This allows you to enclose your garage area to seal out insects while working or relaxing To use simply pull down retract from the top of the garage door to the floor Security lights are provided above the ramp door to allow for outdoor activities and nighttime visibility depending on model 80 SECURE CARGO AND VEHICLES AS FAR FORWARD AS POSSIBLE EXCESS WEIGHT IN THE REAR OF THIS RECREATIONAL VEHICLE CAN RESULT IN LOSS OF STABILITY WHEN TOWING MOVE CARGO AND OR VEHICLES TO MAINTAIN PROPER BALANCE DO NOT EXCEED GVWR TOTAL WEIGHT RATING OR GAWRS AXLE WEIGHT RATINGS OF THE RECREATIONAL VEHICLE OR TOW VEHICLE DANGER ANY MOTORIZED VEHICLE OR ANY MOTORIZED VEHICLE EQUI
116. han 60 days Mark the cables positive and negative for easy identification Batteries are not to be stored on concrete floors The batteries require periodic charging during storage Ifthe vehicle is to be stored for a long period of time it is recommended that all of the batteries inside the unit be removed from clocks radios smoke alarms etc This will prevent unnecessary drain and corrosion of the batteries Battery Types and Charging Only similar batteries should be connected together in one bank if you choose to have more than one battery Do not connect old and new batteries or wet and gel cell batteries together Deep cycle batteries are usually rated in Amp hours which is based on a 20 hour discharge rate Therefore a 100 amp hour battery can deliver 5 amps for 20 hours Deep cycle batteries can be discharged about 80 of capacity before damage occurs Shallow cycling 50 60 drain before recharge will result in much longer battery life To find out how long your batteries will last when using various equipment in your coach research the amperage of the items in use and use that number to gauge what size amp hour battery you think you need Keep in mind that you should recharge your batteries when they are 50 discharged so only half the amp hour rating is actually used Your battery will be charged slowly when the trailer is hooked up to the tow vehicle by the tow vehicle s electrical system The converter will also
117. he breaking away of pieces of the tread or sidewall Cold Inflation Pressure The pressure in the tire before you drive Cord The strands forming the plies in the tire Cord Separation The parting of the cords from adjacent rubber compounds Cracking Any parting within the tread sidewall or inner liner of the tire extending to cord material CT A pneumatic tire with an inverted flange tire and rim system in which the rim is designed with rim flanges pointed radially inward and the tire is designed to fit on the underside of the rim in a manner that encloses the rim flanges inside the air cavity of the tire Curb Weight The weight of a motor vehicle with standard equipment including the maximum capacity of fuel oil and coolant and if so equipped air conditioning and additional weigh optional engine Extra Load Tire A tire designed to operate at higher loads and at higher inflation pressures than the corresponding standard tire Groove The space between two adjacent tread ribs Gross Vehicle Weight Rating GVWR The maximum permissible weight of this fully loaded RV Home is where your heart is Gross Axle Weight Rating GAWR The value specified as the load carrying capacity of a single axle system as measure at the tire ground interfaces Hitch Weight The vertical trailer load supported by the hitch ball Innerliner The layer s forming the inside surface of a tubeles
118. his written document This written Limited Warranty cannot be amended by any dealer sales person or agent TO THE EXTENT PERMITTED BY APPLICABLE LAW ALL IMPLIED WARRANTIES INCLUDING THE IMPLIED WARRANTIES OF MERCHANTABILITY FITNESS FOR A PARTICULAR PURPOSE QUALITY DURABILITY AND AGAINST LATENT DEFECTS ARE HEREBY DISCLAIMED TO THE EXTENT THE IMPLIED WARRANTIES CANNOT BE DISCLAIMED UNDER APPLICABLE STATE LAW ALL SUCH IMPLIED WARRANTIES ARE LIMITED IN DURATION TO THE TERM OF THIS LIMITED WARRANTY AND ARE LIMITED IN SCOPE OF COVERAGE TO THOSE PORTIONS OF THE UNIT COVERED BY THIS WARRANTY Heartland is not responsible for any undertaking representation or warranty made by any dealer or other person beyond those expressly set forth in this Limited Warranty THE RETAIL PURCHASER SHALL NOT BE ENTITLED TO RECOVER FROM HEARTLAND ANY CONSEQUENTIAL OR INCIDENTAL DAMAGES RESULTING FROM ANY DEFECT IN THE UNIT THE EXLCUSION OF CONSEQUENTIAL AND INCIDENTAL DAMAGES SHALL BE DEEMED INDEPENDENT OF AND SHALL SURVIVE ANY FAILURE OF THE ESSENTIAL PURPOSE OF ANY LIMITED REMEDY ANY ACTION TO ENFORCE THESE EXPRESS OR IMPLIED WARRANTIES SHALL NOT BE COMMENCED MORE THAN NINETY 90 DAYS AFTER THE EXPIRATION OF THE ONE YEAR WARRANTY COVERAGE PERIOD DESIGNATED ABOVE 2 WHAT ARE THE DEALER S OBLIGATIONS The independent Heartland RV dealer by agreement with Heartland RV will maintain the recreational vehicle until it is sold to the first retail customer will perf
119. iage items Slide rooms are sealed tightly when closed INTERIOR Antenna lowered sentem Roof vents lowered see Refrigerator locked reet Water heater OFF certe Water pump Fresh water tank Waste water tank Toilet operational er eee F rnace ended LP Gas System checked Cooktop Cover Drawers Closets Windows CLOSED Television Swivel Trays LOCKED Home is where your heart is AT CAMPSITE FOLLOW THE PREVIOUS CHECKLIST WITH THESE ADDED POINTS EXTERIOR Disconnect all shore lines City water electric sewer cable Hook up tow vehicle cron Remove wheel Retract step eee Store camping CHECK CLEARANCES PRIOR TO PULLING OUT This checklist may seem like it contains basic items but many are taken for granted and can spoil a trip if not attended to prior to moving the trailer You may want to use this list as a start for your own Pre Trip checklist wh
120. ications Your generator runs on either LP or Gasoline depending on the model ordered You should be aware that running your generator will consume fuel that you may want to use for cooking heating LP models or items that will need fuel from your fuel station gasoline models Refer to your Owner s Manual for proper fuel usage Improper fuel could cause damage to the generator and void the warranty Cargo area Properly secure all cargo while in transit using the supplied D Rings Capacities typical for most models Fuel 30 gallons Fresh water 102 gallons Black 41 gallons Grey 82 gallons e LP 2 30 gallons e Cargo 2500 Ibs 2500 LB MAX Capacity For Cargo Area Audio Center Quick Use Guide These are a few instructions to help guide you through basic functions of the Audio Center For a complete guide to all the features and functions please refer to the individual audio component owner s manuals Television Viewing Set TV to proper reception mode go into the menu function of the TV and select either air or cable Antenna Make sure TV booster is turned on in bedroom TV cabinet for air reception TV booster needs to be in the off position for the park Home is where your heart is cable signal to be passed through to the TV Tune channel as needed Audio can be routed through the Audio System by turning radio to aux input FNC button
121. ich may include your personal camping gear and food preferences ITEMS TO CARRY Local state and national maps Truck atlases can be useful for showing maps refueling stations and truck repair facilities An emergency road kit and flashlight An assortment of spare fuses An assortment of hand tools 12 Volt DC test light may be helpful when speaking with a technician A battery hydrometer to check the condition of battery electrolyte Polarity tester to check 120 AC outlets Potable non potable water hoses and a water pressure regulator 15 DRIVING SAFETY Towing a recreational vehicle may be a new experience for you Find out what gears are right for your vehicle For sharp turns reduce your speed and swing wide after considering other traffic and obstacles in the intersection Proper braking is extremely important for safety The total weight being towed is much greater than a car so it is important to anticipate traffic signals stop signs and other traffic Decelerate slowly whenever possible to prevent undue wear on brakes and tires When passing a semi bus or other large vehicle from either direction air turbulence may cause the RV to sway slightly Improper use of a recreational vehicle may cause physical damage and or personal injury to the vehicle operator occupants and others Other precautions include Never exceed posted speed limit reduce speed when required by weather traffic or road
122. ification of the completed vehicle The VIN is the number used by the state for vehicle registration The HEARTLAND Serial Number is a six digit number that is comprised of the last six digits of the VIN This HEARTLAND Serial Number is needed whenever making an appointment for service or ordering parts through your HEARTLAND Dealer or Service Center This number can be found on the placard at the entry door and on the Customer Care Card received from HEARTLAND Below is a sample of the placard located in the kitchen On this Trailer Weight Rating placard you Will find 1 The VIN Number 2 GVWR of the unit 3 Cargo carrying capacity of the unit Important Facts If you are traveling or move any authorized dealer at their discretion may provide service Keep your warranty registration form with the vehicle at all times since it must be presented for warranty service This form is your proof of purchase and provides the date of retail sale both of which are necessary to determine warranty eligibility Important Facts Please inspect your recreational vehicle at the time of delivery and make sure you accept it as delivered to you This recreational vehicle has been sold to an independent dealer and not an agent of HEARTLAND RECREATIONAL VEHICLES LLC for resale in the ordinary course of the dealer s business on terms and conditions and equipped as he and you determine and your agreementis solely with the dealer not HEARTLAND RECREA
123. ift systems in Toy Haulers The lowering and raising of the electric beds should be only conducted by an adult No person should be on the electric beds when being lowered or raised If you have any questions about elevated beds Toy Hauler electric bed lift systems or bed rails please contact Heartland s Customer Service Department 67 EXTERIOR MAINTENANCE Please refer to the Maintenance Schedule at the beginning of this manual Seals The seals around doors windows vents and external seams must be checked every 3 months or change of season If deterioration is noted reseal the seams or seals with an approved sealant to prevent leaks Your dealer can perform the resealing inspections and work for you Your dealer is also able to inform you of the appropriate sealants to be used if you prefer to do the job yourself Sealants can be purchased from your dealer or manufacturer Seals are not covered under warranty HEARTLAND RECREATIONAL VEHICLES LLC DOES NOT RECOMMEND THIS RV FOR USE IN THE WINTER UNLESS IT IS EQUIPPED WITH ADDITIONAL INSULATION AND PROPERLY SEALED UNDERBELLY SEE YOUR DEALER OR CONTACT HEARTLAND FOR MORE DETAILS Rubber Roof The rubber roof system should be cleaned periodically and inspected for tears or voids in the sealants see maintenance schedule When cleaning the rubber roof you only need to use a mild detergent plenty of water and a medium bristle scrub brush Special cleaners are not neces
124. ing fresh water with you Your tow vehicle should have a full tank of fuel and have all passengers included with the tow vehicle weight Pull onto the scales and locate the trailer in the center of the scale block the wheels and unhitch the trailer making sure tongue jack or landing gears are set to level the trailer Record the weight of the recreational trailer Hitch the trailer raise the jacks and weigh both the trailer and the tow vehicle together Record this weight Pull forward until tow vehicle is off the scales then weigh trailer with axles on the scale Record this weight Subtract this weight from the trailer weight to find the hitch weight The Gross Vehicle Weight Rating from the weight label minus the recreational trailer weight equals the amount of supplies and personal gear you can carry If you have dual axles you can get a weight for each axle by stopping on the scale with one axle on the scale and the other off Record the weight of the one axle Then move the trailer so that both of the axles are on the scale Record this weight The difference between the two axles will be the second axle s weight It is equally important that the load is distributed evenly among all of the axles and wheels One axle or wheel may be overloaded even if the GVWR and GAWR weights are within limits Pull the trailer forward until the front axle is off of the scale On tandem axle trailers both axles should be carrying abo
125. ining the load limits of a vehicle includes more than understanding the load limits of the tires alone A Federal Certification Label is located on the forward half of the left road side of the unit The certification label will indicate the vehicle s gross vehicle weight rating GVWR This is the most the fully loaded vehicle can weigh It also provides the gross axle weight rating GAWR This is the maximum weight a particular axle can carry If there are multiple axles the GAWR of each axle will be provided In the same location as the certification label described above there is a vehicle placard This placard provides tire and loading information In addition this placard will show a statement regarding maximum cargo capacity Cargo Capacities Cargo can be added to the vehicle up to the maximum weight specified on the placard The combined weight of the trailer and cargo is provided as a single number In any case remember The total weight of a fully loaded vehicle can not exceed the stated GVWR Home is where your heart is Water and propane also need to be considered The weight of fully filled propane containers is considered part of the weight of the RV before it is loaded with cargo and is not considered part of the disposable cargo load Water however is a cargo weight and is treated as such If there is a fresh water storage tank of 100 gallons this tank when filled would weigh about 800 pounds If more cargo is bei
126. intenance Properly maintained tires improve the steering stopping traction and load carrying capability of your vehicle Under inflated tires and overloaded vehicles are a major cause of tire failure Therefore as mentioned above to avoid flat tires and other types of tire failure you should maintain proper tire pressure observe tire and vehicle load limits avoid road hazards and regularly inspect your tires Finding Your Vehicle s Recommended Tire Pressure and Load Limits Tire information placards and vehicle certification labels contain information on tires and load limits These labels indicate the vehicle manufacturer s information including e Recommended tire size e Recommended tire inflation pressure Vehicle capacity weight VCW the maximum occupant and cargo weight a vehicle is designed to carry e Front and rear gross axle weight ratings GAWR the maximum weight the axle systems are designed to carry Both placards and certification labels are permanently attached to the trailer on the forward half of the left side and are easily readable from outside the vehicle without moving any part of the vehicle 35 Tire Repair The proper repair of a punctured tire requires a plug for the hole and a patch for the area inside the tire that surrounds the puncture hole Punctures through the tread can be repaired if they are not too large but punctures to the sidewall should not be repaired Tires must be removed f
127. ire overloading and as a result abnormal tire flexing occurs This situation can generate an excessive amount of heat within the tire Excessive heat may lead to tire failure It is the air pressure that enables a tire to support the load so proper inflation is critical Since RVs can be configured and loaded in many ways air pressures must be determined from actual loads determined by weighing and taken from the load and inflation tables provided by the tire manufacturer These air pressures may differ from those found on the certification label However they should never exceed the tire limitation for load or air pressure If you discover that your tires cannot support the actual weights the load will need to be lightened 37 Tire Safety Tips Preventing Tire Damage e Slow down if you have to go over a pothole or other object in the road Do not run over curbs or other foreign objects in the roadway and try not to strike the curb when parking Tire Safety Checklist Check tire pressure including the spare at least once a month and before going on any trip Inspect tires for uneven wear patterns on the tread cracks foreign objects or other signs of wear or trauma Remove bits of glass and foreign objects wedged in the tread Make sure your tire valves have valve caps e Do not overload your vehicle Check the Tire Information and Loading Placard or User s Manual for the maximum recommended load for the
128. is normal 69 INTERIOR CARE The fading of upholstery carpet and other interior fabrics is generally caused by excessive sunlight The drapes blinds or shades should be kept closed when the vehicle is parked for an extended period of time to minimize fading Normal deterioration of appearance items due to wear and or exposure is not covered by the HEARTLAND RECREATIONAL VEHICLES LLC Limited Warranty Upholstery Do not launder upholstery fabrics Blot up stains promptly before they set Use an upholstery cleaner or mild solvent depending on the stain Never soak the fabric Use as little water as possible Blot rather than rub Towel dry or have professionally cleaned Fabrics and Draperies The fabrics that may be used in this vehicle for the bedspread draperies headboard and valances may be damaged by the use of improper cleaning products Therefore cleaning instructions for these items are DRY CLEAN ONLY Water based products are not recommended for cleaning the fabrics in your new unit Most water based household cleaning products are not formulated for use on these fabrics and may cause excessive shrinkage of fading Spills spots or stains should be treated as soon as possible to avoid permanent damage If a spill occurs blot the fluid with a dry towel Do not rub rubbing may cause the liquid to set in the fabric When attempting to clean a spot or stain always start from the outside and work inward to avoid sp
129. ish to change to prevent accidental movement 3 Position a hydraulic jack on the frame close to the spring hanger 4 Raise the trailer until the tire clears the ground CHECK TIRE PRESSURES BEFORE TRAVELING ALWAYS CHECK TIRE PRESSURE WHEN TIRES ARE COLD DO NOT EXCEED THE MAXIMUM RECOMMENDED PRESSURE The Importance of Proper Tire Inflation Your trailer tires and wheels and tongue or fifth wheel hitch support the entire weight of the trailer and its contents The tires are also the only contact the trailer has with the road surface Determining and maintaining proper inflation is the most important factor in maximizing the life of your tires Driving on a tire that does not have the correct inflation pressure for the trailer load is dangerous and may cause premature wear tire damage tread delaminating and or loss of control of the trailer and or tow vehicle HEARTLAND Recreational Vehicles LLC An under inflated tire will build up excessive heat that may go beyond the limits of the tire materials This could result in sudden tire failure An under inflated tire will also cause poor vehicle handling rapid and or irregular tire wear and an increase in rolling resistance which results in decreased tow vehicle fuel economy The maximum cold inflation pressure for your tires is stated on the tire sidewalls Keep your tires inflated to the maximum cold pressure This reduces the chance of a failure and improves towing stability
130. it on your RV can be operated on LP gas and 120 volt AC electricity Read the owner s manual provided in your owner s packet before putting the refrigerator into operation The refrigerator will not operate correctly if the vehicle is not level when parked The refrigerator coolant will not circulate properly if the unit is not level For best results make sure the outside sidewall vent and roof vent are always clear of debris Without proper circulation of the rear coils the unit will not keep food cold Upon initial operation or after being stored the refrigerator could take up to 24 hours before the unit is cool enough for use IT IS NORMAL FOR THE REAR COIL AREA OF YOUR REFRIGERATOR TO BE HOT BE CAREFUL WHEN CHECKING THIS AREA TO MAKE SURE PROPER AIRFLOW THROUGH THE REAR VENT IS NOT OBSTRUCTED 60 Furnace Your RV is equipped with a force air furnace similar to the type found in most homes with the exception that it is fueled by LP gas Each unit is equipped with a wall mounted thermostat that controls the temperature An operating manual for the furnace is included in your owner s packet The furnace is designed to have un obstructed airflow from all its vents including interior and exterior If any vent is blocked the furnace may shut itself off The furnace igniter is powered by your 12 volt battery system If the system battery is low the furnace blower will come on however the furnace will not ignite Make
131. izes a sealed combustion system which means the combustion chamber is completely sealed from the inner atmosphere of your vehicle Combustion air is drawn from the outside and combustion products are expelled outside through a vent Carefully read and follow the lighting and operating instructions from the furnace manual supplied with the unit New furnaces sometimes emit smoke and an odor when first used due to paint burning off the heating chamber Do not mistake this for a malfunctioning furnace You may want to open the windows during the initial breaking in of the furnace Thermostat readings may not always be a true indication of temperature throughout the living space Use these readings as a guide to obtain the most comfortable level for you WARNING DO NOT STORE COMBLSTIBLE MATERIAL IH THES ATHE A FA FRE TO COMPLY CORR A FEE CH PEHSDHAL MHAIRT HEARTLAND Recreational Vehicles LLC LP GAS SYSTEM IFYOU SMELL GAS EXTINGUISH ANY OPEN FLAMES PILOT LIGHTS AND ALL SMOKING MATERIALS DO NO TOUCH ELECTRICAL SWITCHES SHUT OFF THE GAS SUPPLY AT THE TANK VALVE S OR GAS SUPPLY CONNECTION OPEN DOORS AND OTHER VENTILATION OPENINGS LEAVE THE AREA UNTIL ODOR CLEARS HAVE THE GAS SYSTEM CHECKED AND LEAKAGE SOURCE CORRECTED BEFORE USING AGAIN A warning label has been located near the LP gas container This label reads DO NOT FILL CONTAINER S TO MORE THAN 80 PERCENT OF CAPACITY Overfilling the
132. ks off the ground as far as possible A lubrication point of major importance is the contact area where the pinbox plate rests on the hitch saddle A liberal quantity of grease is often used on this surface but that can be messy After market lubrication pads are also available which can be attached to the pinbox plate to eliminate the need for grease A typical type of lubrication pad is a thin sheet of graphite impregnated Teflon that is riveted to the pinbox plate When using lubrication pads make it a matter of routine maintenance to inspect for pad wear Before and after each trip all nuts bolts safety pins and other hitch related hardware should be inspected mE NOTICE USE OF A GOOSENECK ADAPTOR CAN CAUSE DAMAGE TO THE STRUCTURE OF YOUR FIFTH WHEEL AND WILL VOID YOUR LIMITED WARRANTY Inspect the kingpin box mounting bolts at least every 2 000 miles Using a torque wrench tighten kingpin box bolts to 60 70 ft Ibs Inspect the kingpin latch plate and saddle to make sure there is no evidence of excess wear or damage Inspect the kingpin pin box plate and saddle to make sure there is no evidence of excess wear or damage Lubricate the latch bolt and pivot point of the latch plate with SAE 30 oil at least every six months Typical Wiring Diagram for Seven Way z a Plug but Is re r 24 Grease the load bearing surfaces of the fifth wheel hitch with lithium based grease every 2 000 mil
133. leration The level adjustment can also vary when the recreational vehicle braking is felt Gain or output control adjustment usually controls maximum amount of amperage available to the brakes This can be adjusted for varying recreational vehicle load __ A CAUTION DO NOT ADJUST THIS CONTROL OUTSIDE THE PARAMETERS OUTLINED BY THE BRAKE CONTROLER MANUFACTURER S INSTRUCTIONS Brake Adjustment Brakes should be adjusted by a service dealer after the first 200 miles of operation when the brake shoes and drums have seated at 3 000 mile intervals or as use performance requires The electric brakes are of the drum and two shoe type and adjust the same as most automotive drum brakes The adjusting screw is accessible through a hole at the bottom of the backing plate Remove the hole plug and use a standard brake adjusting tool Turn the screw until the shoes contact the drum and with enough force to make the wheel hard to turn by hand Then back off the screw 34 to one full turn or until the wheel turns freely Brake Cleaning and Inspection The recreational vehicle brakes must be inspected and serviced yearly or more often Magnets and shoes must be changed when they become worn or scored Wear or scoring may inhibit vehicle braking Clean the backing 40 plate magnet arm magnet and brake shoes Make sure that all the parts are removed and replaced in the same brake and drum assembly Inspect the magnet arm for any loose or worn p
134. lf to make corresponding changes or improvements in or upon its products already manufactured HEARTLAND RECREATIONAL VEHICLES LLC further reserves the right to substitute parts or components of substantially equal quality in any warranty service required by operation of this Limited Warranty Important Facts Like any other product a recreational vehicle and the products installed in it will require care and maintenance attention by the owner and occupants Please read and follow all care and maintenance manuals and instructions supplied with your recreational vehicle HEARTLAND Recreational Vehicles LLC Key Information to have on hand HEARTLAND customer should fill out All warranty work needs to be completed during the term of the warranty Warranty beginning date Warranty ending date VIN Note All service work performed after the expiration date will not be covered by HEARTLAND RECREATIONAL VEHICLES LLC Original Owner Phone Number Dealership Purchased from Phone Number Second Owner Phone Number Person or Dealership Purchased from Phone Number OUR VALUED CUSTOMERS If for any reason you have a problem obtaining satisfactory and timely warranty service that may substantially impair the use value or safety of your HEARTLAND RECREATIONAL VEHICLES LLC product please call us so that we may attempt to resolve your concerns Authorized dealers are independent contractors and independently owned businesses
135. ll out the TERMINATION VALVE see photo on next page by pulling out the dump valve slide handle Close the valve after the tank has drained Flush or pour about two gallons of water through the toilet when emptying the black tank and drain again This flushes the tank and helps clean the drain hose Repeat as necessary HEARTLAND Recreational Vehicles LLC GRA TANF GRAY TANE z Follow the same procedure for the GRAY WATER HOLDING TANK S A repeat flush is not necessary When the tank is empty push the dump valve handle in until it seats Remove the hose wash and replace it in its storage location Replace termination outlet cap DRAIN THE TOILET BLACK HOLDING TANK FIRST FAILURE TO CLOSE THE GRAY BLACK TANKS DURING PERIODS OF STORAGE MAY ALLOW P TRAPS TO DRY AND ALLOW METHANE GAS OR OTHER COMBUSTIBLE GASSES TO BACK UP INTO THE UNIT CREATING A RISK OF FIRE EXPLOSION OR POISONING Holding Tank Maintenance Keep your tanks well flushed out when the vehicle is not in use Allowing the tank to sit with any contents for more than a couple of days will ensure some sort of build up on the monitor probes in the side of the tank and future monitor reading problems even if this is the first time you have used your RV One way to help flush them out is to drain them at the campground then add approx 10 gallons to each tank for the trip home Home is where your heart is Helpful Cleaning Hints When camping th
136. loading cargo If the ramp angle is reduced and all other conditions remain the same rick is reduced Always try to reduce the loading ramp angle the shallower the ramp angle the easier cargo loading will be Position the trailer to take advantage of any terrain features that will help reduce the ramp angle In all cases be sure the ends of the ramp door can be fully supported Always position the loading ramp so the ends in contact with the ground are level or at the same height An uneven ramp may cause the cargo to tip over sideways during loading unloading DO NOT LOAD MOTORIZED CARGO MOTORCYCLES ATVS ETC BY RIDING THEM UP THE RAMP DOOR LOSS OF CONTROL COULD CAUSE SERIOUS PERSONAL INJURY HEARTLAND DOES NOT RECOMMEND LOADING MOTORIZED CARGO UNDER POWER Loading Under Power Motorized cargo should be walked up the ramp When preparing to load the vehicle into the trailer the operator s hands should be positioned on the controls so as to keep the vehicle in control during loading 1 Shift into lowest gear before ascending ramps 2 Align wheels with ramps both loading and unloading 3 Approach straight on not on an angle If you are off to one side and the ground is uneven where the ramp touches the ground an unbalanced situation can occur 4 The operator should apply throttle smoothly and climb the ramp at low speed Too much or sudden increases in throttle will cause the vehicle to be harder to control and
137. m and the vehicle or in the case of a non pneumatic tire assembly not incorporating a wheel a mechanical device which attaches either integrally or separably to the non pneumatic tire and provides the connection between tires and the vehicle Wheel holding Fixture The fixture used to hold the wheel and tire assembly securely during testing HEARTLAND Recreational Vehicles LLC LEVELING FAILURE TO MAINTAIN ADEQUATE BRAKING DISTANCE BETWEEN YOUR VEHICLE AND THE VEHICLE OR ITEMS IN FRONT OF YOU CAN CAUSE PROPERTY DAMAGE SERIOUS INJURY OR LOSS OF LIFE Set Up Procedures This section outlines the procedures necessary to stabilize and set up your vehicle Before attempting to set up the vehicle carefully read and understand these instructions Setting up your vehicle requires forethought and care Your vehicle is designed to be efficient and comfortable Careful attention to detail and thoroughness during set up will ensure that you will benefit from all the features and comfort built into your vehicle During storage or after your vehicle has been set up you may notice a slight rippling or waviness of the fiberglass exterior sidewall panels if your vehicle is sitting in the sun This is caused by the normal expansion of the materials as they warm up As the temperature goes down these panels will tend to return to their original shape This condition is typical and is not covered under the HEARTLAND RECREATIONAL VEHICLES
138. matic tires and rims that are fitted to a passenger car in compliance with the requirements of this standard Non Pneumatic Tire A mechanical device which transmits either directly or through a wheel or wheel center member the vertical load and tractive forces from the roadway to the vehicle generates the tractive forces that provide the directional control of the vehicle and does not rely on the containment of any gas or fluid for providing those functions 41 Non pneumatic Tire Assembly A non pneumatic tire alone or in combination with a wheel or wheel center member which can be mounted on a vehicle Open Splice Any parting at any junction of tread sidewall or innerliner that extends to cord material Outer Diameter The overall diameter of an inflated new tire Overall Width The linear distance between the exteriors of the sidewalls on an inflated tire including elevations due to labeling decorations or protective bands or ribs Pin Weight The vertical trailer load supported by the king pin of a fifth wheel hitch Ply A layer of rubber coated parallel cords Ply Separation A parting of rubber compound between adjacent plies Pneumatic Tire A mechanical device made of rubber chemicals fabric and steel or other materials that when mounted on an automotive wheel provides the traction and contains the gas or fluid that sustains the load Production Options Weight The combine
139. may be illegal The trailer does not have seat belts therefore it is not designed to carry passengers Reducing Fishtailing or Sway Sway or fishtailing is the sideways action of a trailer caused by external forces Excessive sway of your travel trailer can lead to the rollover of the trailer and tow vehicle resulting in serious injury or death Be sure to follow the instructions and warnings as outlined on page 27 Mold There are mold and mold spores throughout the indoor and outdoor environment There is no practical way to eliminate all mold and mold spores in the indoor environment the way to control indoor mold growth is to control moisture see page 74 Towing and Weight Distribution Weight distribution is an important factor when loading your fifth wheel or travel trailer A recreational vehicle with the cargo distributed properly will result in efficient trouble free towing see page 27 Formaldehyde Formaldehyde is an important chemical used widely in building materials and numerous household products It is also a by product of combustion and certain other natural processes Thus it may be present inside the trailer with some individuals being sensitive to it Ventilation of the unit normally reduces the exposure to a comfortable level see page 75 Home is where your heart is Generator Safety Do not operate the generator in an enclosed building or in a partly enclosed area such as a garage Nor should the
140. may cause the vehicle to impact the front of the trailer cargo area or over turn 5 Stop when fully in the trailer Keep handle bars mirrors etc away from the trailer interior walls The 86 walls can be damaged by contact with hard sharp objects 6 After loading close the fuel valve and run the engine until it stops motorcycle and ATVs Turn the ignition key off and remove it Set the parking brake For manual clutch machines leave the machine in gear 7 Secure the vehicle with tie downs The attachment points you select on your equipment must be strong enough to support the weight of the equipment Usually attachment points that are low and centered on the equipment frame will be good An attachment to a decorative piece of chrome or plastic will usually not be a good tie down point Consider any leverage action that may occur An attachment point past the center of the equipment could cause the equipment to either swing around or flip over causing damage to the equipment or personal injury If you have any doubt about the attachment point you have selected stop and find a better attachment point WARNING FAILURE TO PROPERLY SECURE CARGO COULD CAUSE PROPERTY DAMAGE IN JURY AND OR DEATH Secure the Load Install blocking devices in the front back and on both sides of the wheels to keep it from rolling This block is strictly an additional safety precaution and does not reduce the need for strapping the
141. mfortable and effective in removing excess moisture from the interior air While use of a dehumidifier is not a cure all and ventilation storm windows and moisture reduction continue to be important operation of the dehumidifier will reduce the amount of outside air needed for ventilation Heating load on the furnace will be reduced and the interior will be less drafty AWARNING DO NOT COVER EMERGENCY EXIT WINDOW S THIS WINDOW MUST BE LEFT ACCESSIBLE AT ALL TIMES FOR EMERGENCY EXIT Dripping Ceiling Vents During cold weather and even in short term occupancy condensation frequently forms on ceiling vents and may even accumulate to the point of dripping onto the surfaces below This is frequently misinterpreted as a leaking roof vent but is most often condensation drippage Follow the preceding steps to control moisture condensation protect surfaces with plastic sheeting until the moisture has dissipated UREA FORMALDEHYDE IS USED IN THE PRODUCTION OF PARTICLE BOARD HARDWOOD PLYWOOD AND MOST PANELING UREA FORMALDEHYDE RESIN MAY RELEASE FORMALDEHYDE VAPORS INTO THE AIR WHICH MAY CAUSE HEADACHES AND IN SOME PEOPLE EYE NOSE AND THROAT IRRITATION FORMALDEHYDE MAY INTENSIFY SOME ALLERGIES OR UPPER RESPIRATORY PROBLEMS LIKE ASTHMA PROPER VENTILATION SHOULD REDUCE THE RISK OF SUCH PROBLEMS Home is where your heart is 73 ABOUT MOLDS What are molds Molds are microscopic organisms that naturally
142. n EN NOTICE ZN CONFIRM THERE IS FIVE OR MORE FEET OF CLEAR SPACE OUTSIDE OF SLIDE OUT ROOM TO THE OUT POSITION CHECK THAT ALL CABINETS ARE CLOSED BEFORE EXTENDING OR RETRACTING THE ROOMS NEN NOTICE a DO NOT OPERATE THE SLIDE OUT ROOM WHEN THE BATTERY HAS gt BEEN REMOVED FROM THE FIFTH WHEEL OPERATING THE SLIDE OUT BY USING ONLY THE CONVERTER MAY DAMAGE THE SLIDE OUT ELECTRICAL COMPONENTS CONTINUOUS OPERATION OF THE SLIDE OUT ROOM CAN DRAIN THE BATTERY AND DAMAGE THE SLIDE OUT MOTOR FROM OVERHEATING NEVER MOVE THE TRAILER WITHOUT HAVING THE SLIDE OUT ROOM RETRACTED D NOTICE EN DIRT AND GRIT TRAPPED UNDER THE SLIDE COULD RESULT IN DAMAGE TO THE FLOOR LEAVES TREE LIMBS AND OTHER DEBRIS COULD DAMAGE THE SLIDE OUT ROOF AND SEALS CLEAN SLIDE OUT ROOF BEFORE OPERATING NOTICE SEVERE WEATHER CONDITIONS SUCH AS HIGH WINDS OR HEAVY RAIN MAY CAUSE DAMAGE TO AN EXTENDED SLIDE OUT Home is where your heart is AWNING FREEZING IN THE EVENT THE SLIDE OUT ROOM IS EXTENDED IN SNOW SLEET ICE OR FREEZING RAIN CONDITIONS CLEAR THE AWNING AND ENSURE FREE MOVEMENT PRIOR TO RETRACTING THE SLIDE ROOM Retracting Slide Outs 1 Make sure you have clearance on the interior 2 If applicable clean the floor 3 Remove any debris from the top of the slide out room 4 Press and hold switch in the IN position To stop slide out room before it fully retracts release the switch To continue the
143. nd tighten the bolts Retighten the pin box bolts every 50 miles for the first 500 miles and prior to every trip thereafter NEVER OVERLOAD YOUR 5TH WHEEL DO NOT EXCEED THE RATED LOAD OF THE RV OR THE RATED LOAD OF ANY AXLE OVERLOADING CAN CAUSE LOSS OF CONTROL OF THE UNIT WHICH CAN RESULT IN SEVERE PERSONAL INJURY OR DEATH OVERLOADING CAN ALSO CAUSE PROPERTY DAMAGE TO THE UNIT ITS CONTENTS AND THE TOW VEHICLE Dangers of Overloading During the design and development of our vehicles the Home is where your heart is number and size of storage compartments and the liquid tankcapacities are maximized for value and convenience However be mindful that if all holding tanks are filled to capacity and all storage compartments and cupboards are filled to the maximum volume the vehicle could be overloaded causing an unsafe condition Refer to the manufacturer s labels posted inside and outside of the unit for weight information eyes UNDER NO CIRCUMSTANCES SHOULD THE ENGINE OF YOUR TOW VEHICLE BE ALLOWED TO LUG OR PULL HARD FOR EXTENDED PERIODS OF TIME SUCH MISUSE CAN CAUSE ENGINE FAILURE In addition to causing premature wear overloading can cause problems in the area of handling characteristics overloaded vehicle will take longer time and distance to stop in an emergency Overloading can also cause added wear to components such as tires and wheel bearings Overloading can also cause overhe
144. ng transported water can be off loaded to keep the total amount of cargo added to the vehicle within the limits of the GVWR so as not to overload the vehicle Understanding this flexibility will allow you the owner to make choices that fit your travel and camping needs When loading your cargo be sure it is distributed evenly to prevent overloading front to back and side to side Heavy items should be placed low and as close to the axle positions as reasonable Too many items on one side may overload a tire The best way to know the actual weight of the vehicle is to weigh it at a public scale Talk to your RV dealer to discuss the weighing methods needed to capture the various weights related to the RV This would include weights for the following axles wheels hitch or pin in the case of a trailer and total weight How Overloading Affects Your RV and Tires The results of overloading can have serious consequences for passenger safety Too much weight on your vehicle s suspension system can cause spring shock absorber or brake failure handling or steering problems irregular tire wear tire failure or other damage An overloaded vehicle is hard to drive and hard to stop In cases of serious overloading brakes can fail completely particularly on steep hills The load a tire will carry safely is a combination of the size of tire its load range and corresponding inflation pressure Excessive loads and or under inflation cause t
145. ny LP refueling stations available Many RV parks also have LP gas available Caution your supplier not to over fill your tank Room is required to let the liquid vaporize There are approximately 90 000 BTUs of heat produced from each gallon of LP gas During extreme cold temperatures check fuel tanks frequently to avoid running out of fuel Make sure that all burners and pilot lights are turned OFF prior to having a gas supplier refill your LP tank 1 Make sure the arrow on the cylinder selector is pointed to the full cylinder Verify the hose route to the full cylinder on a split system 2 Close the valve on the empty cylinder and remove the hose from the valve NOTE left hand thread 3 Loosen the clamp that holds the cylinder in place 4 Remove the cylinder and have it refilled 52 5 Slide the cylinder back in place and tighten clamp 6 Connect the left hand hose and tighten securely The 80 percent STOP FILL VALVE may close the valve before liquid appears at the 20 percent liquid level gauge but if liquid does appear stop filling immediately the tank is filled to its LP capacity YOUR LP TANKS MUST BE KEPT FREE OF RUST AT ALL TIMES IF RUST DOES DEVELOP THE TANK SHOULD BE CLEANED COMPLETELY FREE OF THE RUST PRIMED AND PAINTED WHITE OR SOME OTHER HIGHLY REFLECTIVE COLOR WHICH WILL HELP TO REDUCE EXPANSION OF THE LP GAS BECAUSE OF HEAT Do not use a wrench to tighten the service valve or the 20
146. of 110 volt appliances available the circuit panel may have a 50 amp main or a 30 amp main breaker All breakers are labeled for what appliance they protect and maximum amperage for the circuit breaker Your bathroom kitchen and exterior receptacles are protected by a highly sensitive device known as a Ground Fault Interrupter which is designed to sense the slightest electrical short at those receptacles and instantly disconnect the current before a person can be injured This device protects against fault currents only It does NOT protect against over current The GFI receptacle is located in the bathroom it should be tested at least once a month for maximum protection To test the GFI receptacle push the TEST button The RESET button will pop out Power is now off at the outlets protected by the RESET button during the test and indicates the device is functioning properly If the RESET button does not pop out when testing do not use any outlets on this circuit Protection is lost Call your dealer if this device malfunctions After a successful test restore power by pushing RESET Your test is complete when the RESET button stays pushed in Home is where your heart is THIS CONNECTION IS FOR LOW VOLTAGE BATTERY OR DIRECT CURRENT ONLY DO NOT CONNECT TO 120 OR 240 VOLTS AC Battery Your trailer in most cases needs to be equipped with a 12 volt battery Check the electrolyte fluid levels on a regular ba
147. ompound from the core material in the sidewall Test Rim The rim on which a tire is fitted for testing and may be any rim listed as appropriate for use with that tire Tread That portion of a tire that comes into contact with the road Tread Rib A tread section running circumferentially around a tire Tread Separation Pulling away of the tread from the tire carcass Treadwear Indicators TWI The projections within the principal grooves designed to give a visual indication of the degree of wear of the tread Vehicle Capacity Weight The rated cargo and luggage load plus 68 kilograms 150 lbs times the vehicle s designated seating capacity Vehicle Maximum Load On The Tire The load on an individual tire that is determined by distributing to each axle its share of the maximum loaded vehicle weight and dividing by two Vehicle Normal Load On The Tire The load on an individual tire that is determined by distributing to each axle its share of the curb weight accessory weight and normal occupant weight distributed in accordance with Table of CRF 49571 110 and dividing by 2 Weather Side The surface area of the not covered by the inflated tire Wheel Center Member In the case of a non pneumatic tire assembly incorporating a wheel a mechanical device which attaches either integrally or separably to the non pneumatic rim and provides the connection between the non pneumatic ri
148. onal activities Many combinations of hazards and a large volume of activities occur in this area Some of these hazards are e Ramps And Inclines e Overhead Obstructions e Dissimilar Surfaces That Are Often Wet And Slippery e Poor Lighting During Night Or Early Morning Activities e Other Vehicular Traffic e Pedestrians Restricted Views e Awkward Heavy Or Unbalanced Loads Sheer Drops Trailer Creep e Congested Staging Areas e Accumulations Of Empty Containers And Debris These are all hazards which can all be present at the 82 same time within a very confined area You need to be aware of these potential hazards when loading unloading and rigging your cargo Your continuous attention to safety measure will help prevent accidents and possibly serious injuries and property damage The biggest reason to put a priority on loading safety is not so much related to the frequency of accidents as it is to the potential severity of injuries that can occur in these types of accidents The kinds of injuries sustained when a load tips over falls from the ramp falls out of the trailer or those that occur if the load shifts unexpectedly during travel tend to be very serious and sometimes fatal You can prevent these types of accidents by paying attention to what you are doing and thinking through the consequences of poor loading Poor hazard assessment decisions directly responsible for many accidents You can help minimize
149. or splashed out of the sink and shower drain while traveling Places to add water include the kitchen sink bathroom sink shower tub wet bar sink and the washer dryer drain 58 Black Water Holding Tank The tanks should be emptied frequently or as indicated on the monitor panel and especially before travel MOST STATES HAVE LAWS PROHIBITING EMPTYING SEWAGE ANYWHERE BUT AN APPROVED DUMPING STATION While camping it is normal practice to leave our GRAY WATER HOLDING TANK valve open if your campsite is equipped with sewer hook up NEVER leave the BLACK WATER TANK valve open while using the coach Since the system utilizes gravity to empty the BLACK WATER TANK will not drain properly unless it has sufficient liquid to help drain out the solids Dual Gray Holding Tanks Some models are equipped with two gray holding tanks due to the floor plan You must use the dump lever for each tank to empty the contents Pulling the dump lever for one tank will not empty the other The second holding tank has its own termination valve The gray water holding tank is primarily used for drainage from the kitchen and bath sink and shower Emptying Holding Tanks To empty the holding tanks be certain that your RV is level since the process depends upon gravity Remove the sewage drain hose from its storage location below the docking center Remove the cap from the termination outlet and connect the drain hose To drain either holding tank pu
150. orm a comprehensive pre delivery check procedure and inspection will repair or replace any identified defective parts will correct identified defects in workmanship will present the retail owner with a copy of this warranty prior to the retail owner s entering into any written contract to purchase a recreational vehicle and will mail to Heartland RV a warranty registration notice and the signed Limited Warranty 3 WHAT ARE THE OWNER S OBLIGATIONS The owner is responsible for proper maintenance and cleaning of the recreational vehicle including its exterior and interior products and components as more particularly described in the owner s manual and in the materials provided by the component manufacturers Failure of any product or component caused by improper care cleaning procedures negligence or faulty maintenance are expressly excluded from this warranty Notwithstanding the foregoing for a period of ninety 90 days minor adjustments to components including but not limited to adjustments to the interior or exterior doors LP regulator pressure cabinet latches and TV antenna control will be performed by the dealer free of charge to the retail customer for a period of ninety 90 days from the original retail purchaser taking possession of the unit Home is where your heart is 3 It is the owner s responsibility to use the recreational vehicle for its intended purpose as described above and to observe and comply with all proper ope
151. oroughly cleaned as soon as possible after exposure to these elements Washing the undercarriage with a high pressure washer will remove the majority of HEARTLAND Recreational Vehicles LLC the salt But this will not replace the paint that is literally sandblasted off the undercarriage by the road salt and sand Sandblasted and corroded frame components must be refinished This is not covered under warranty This can be done with readily available rust preventative paint and undercoating This is necessary to properly maintain your recreational vehicle Aftermarket undercoating processes are also beneficial in rust prevention But to remain effective these treatments must be inspected and renewed annually as most undercoating agents can dry and peel with age Therefore regularly scheduled inspections and maintenance are necessary to protect your recreational vehicle and its various components and fixtures from the elements and keep it corrosion free In addition to maintenance you should keep from storing your vehicle in grassy areas for long periods of time The stagnant moist air developed under the coach will speed up the corrosion process Always store your vehicle on pebble concrete or asphalt surfaces Awnings Awnings installed on your trailer may have been added by your dealer Proper use care and maintenance procedures for awnings are included in the literature provided with the awning To open your main awning Man
152. priate size and material to securely hold the vehicle Don t use lumber cinder blocks rocks or other make shift items to chock Make it easy to find and use the correct chocking equipment store chocks inside the trailer or tow vehicle Keep chocks available at places where you typically load and unload Use extra caution when loading from the ramp f the trailer rolls away you and the equipment you are loading can fall with severe injuries or death Never load equipment from the ramp into the trailer until you ensure that the wheels are properly chocked Ensure that the trailer floor is in good condition and that it can support the weight of the equipment you are loading Blocking stabilizes loaded cargo to prevent shifting and trailer overturns If the load shifts while in motion the sudden shift in position and center of gravity may cause towing instability possibly causing the trailer to overturn Securely block all cargo not just wheeled equipment and round or oddly shaped items Block items separately and on all four sides using wood blocks thick enough to prevent cargo movement Use tie downs and D rings carabiners strong enough to secure the load Avoid using other cargo as a block Cargo Placement and Restraint Cargo that is likely to roll vehicles tool chests barrels etc should be restrained by chocks clocks wedges a cradle or other equivalent means to prevent rolling Whatever you use to prevent rolling should not
153. put in the tire under normal driving conditions The air pressure recommended on the tire information placard is for the original standard equipment tires only Your trailer may be equipped with optional sized tires Always follow the pressure recommendations stamped on the tire sidewall for any replacement tire Checking and Adjusting Tire Pressure It is important to check your vehicle s tire pressure at least once a month always before each trip and at least once a week while on the road Not only do tires naturally lose pressure over time but they can lose air suddenly if you drive over a pothole or other object or if you strike the curb It is difficult to determine tire inflation pressure by looking at the tire Purchase a tire pressure gauge to keep in your vehicle Gauges can be purchased at tire 34 dealerships auto supply stores and other retail outlets The recommended tire inflation pressure that vehicle manufacturers provide reflects the proper psi when a tire is cold A cold tire is one that has not been driven on for at least three hours When you drive your tires get warmer causing the air pressure within them to increase Therefore to get an accurate tire pressure reading you must measure tire pressure when the tires are cold Refer to the tire s sidewalls for the recommended tire pressure Your trailer may be equipped with optional tires Check and write down the pressure in all tires If th
154. r caps that could affect proper seating of the wheel to the hub surface Certain tests are recommended by the manufacturer s of factory installed equipment such as the cornering fatigue test based on SAE J1095 SAE J267 and field tests are recommended for all wheels and rims to be installed in place of original factory equipment Contact the wheel manufacturer to verify compatibility with the factory installed equipment prior to replacement 31 TIRES amp BRAKING Tire Inspection The following chart is meant to be helpful in determining the condition and maintenance of your tires Over Inflation Wear Outside Wear Smooth Side Wear One Side Feathering Across The Face Under Inflation Loss of Camber or Overloading Axle Not Square To Frame or Incorrect Toe In Check amp Adjust Pressure When Cold Check amp Adjust Pressure When Cold Check amp Unload As Necessary Have Alignment Checked Square Axles Have Alignment Checked Check Bearing Adjustment and Wheel amp Tire Balance Loose Bearings or Wheel Balance Cupping Flat Spot Wheel Lockup Adjust Brakes WHEN REPLACING TIRES CONSULT THE WHEEL AND TIRE MANUFACTURERS SPECIFICATIONS FOR COMPATIBILITY IMPROPERLY MATCHED WHEELS AND TIRES MAY FAIL AND CAUSE PROPERTY DAMAGE SERIOUS PERSONAL INJURY OR LOSS OF LIFE Wheel Bearing Lubrication There is no need to lift the vehicle before greasing axles equipped with today s mod
155. r desired temperature Therefore if you know the weather will be hot turn your air conditioner on early The two most common complaints with roof air conditioners are they won t turn on at all or when they do turn on they won t put out cold air HEARTLAND Recreational Vehicles LLC Thermostat Operation _ Cool Operation 1 Set System button to Cool 2 Set slider to desired temperature 3 Set desired fan speed Hi or Low 4 SetFan operation Auto cycles fan with compressor or On runs fan constantly 5 A C runs until desired temperature is reached Furnace Operation 1 Set System button to Furnace 2 Set slider to desired temperature 3 Fan controls have no function for furnace operation 4 Furnace runs until desired temperature is reached Electric Ceiling Fan Operation The ceiling fan used in your coach is designed to ventilate the interior when cooking or if the use of your air conditioner is not desired If used properly the roof fan can cool the interior by as much as 15 degrees within a short period of time When used the fan pulls hot air from high inside the coach and will pull fresh air from an open window This fan is usually controlled by a wall mounted thermostat some models have a thermostat built right on the fan which must be turned on and adjusted to your desired temperature before use The wall mounted thermostat is not the same that is used for the furnace or air conditioners
156. r use the hand crank to slightly raise the front of the trailer hitch to relieve the hitch pressure Release the hitch latch disengaging the locking bar If applicable slightly rock the tow vehicle in reverse to disengage locking bar Pull forward slightly and raise the recreational vehicle hitch to clear the tow vehicle hitch Move the tow vehicle away from the recreation vehicle 5 Level the vehicle front to rear It may be necessary to place a sturdy 2 x 6 wood block under the jack post to support the jack post on soft ground surfaces 6 Check the level of the vehicle with a carpenter s level both crosswise and lengthwise on the vehicle floor To assure reasonable level at the refrigerator use the round bubble level inside the refrigerator Acceptable level is when the bubble is within the marked area of the bubble level 7 After stabilizing the vehicle be sure the vehicle frame is not twisted buckled or stressed Check that all doors and windows operate freely and do not bind 8 Connect the shore power open the LP Gas valves at the LP tanks and connect the fresh water supply and the water systems if necessary If applicable start the refrigerator water heater and furnace MEE NOTICE NEN DO NOT ATTEMPT TO RAISE OR OTHERWISE PLACE ALL OF THE WEIGHT OF THE TRAILER ON THE STABILIZER JACKS STABILIZER JACKS ON THE TRAILER WITH SLIDE ROOMS SHOULD NOT BE PLACED AT EXTREME CORNERS OF THE FRAME LOCATING STABILIZERS IN THESE LO
157. railer brakes alone to stop the combined load Your brake controller must be set up according to the manufacturer s specifications to ensure proper synchronization between the tow vehicle and the trailer Additionally you may have to make small adjustments occasionally to accommodate changing loads and driving conditions Also we recommend a hitch with built in sway control be provided for your unit Please consult your dealer regarding this equipment as the RV manufacturer does not provide sway control devices Tonque weight The tongue weight should be between 10 to 15 of the total travel trailer weight See page 26 of this manual regarding the proper weight distribution of your recreation vehicle Driving This is the most important component The tendency for the vehicle to sway increases with speed therefore obey all speed limits and reduce speed during inclement weather or windy conditions Corrective measures If sway occurs the following techniques should be used 1 Slow down immediately remove your foot from the accelerator Avoid using the tow vehicle brakes unless there is a danger of collision Reduce speed gradually whenever possible If you can do so safely use the brake hand controller independent of the tow vehicle brakes to gently and progressively apply the trailer brakes This will help to keep the vehicles aligned Practice using the brake hand controller on a deserted parking lot Don t wait
158. ransfer nozzle compartment to prevent unauthorized use The nozzle compartment must be locked at all times when not dispensing fuel 10 When you are finished with all fueling turn of the pump master switch All parts of the fuel transfer system including but not limited to the hoses pump nozzle fittings and tank have been selected for their quality safety and intended application Any alteration or replacement of any part by other than Heartland parts could jeopardize the integrity of the system and may result in serious injury or even death HEARTLAND Recreational Vehicles LLC If your fueling system is not working properly or you need additional information on the use of the system contact your authorized Heartland dealer immediately or call Heartland directly IF A FUEL SPILL OCCURS IN THE STORAGE AREA OF THE TRAILER OPEN THE WINDOWS AND SIDEWALL VENTS AND WIPE UP THE FUEL WITH CLOTH OR PAPER TOWELS DISPOSE OF THE TOWELS IN A SUITABLE HAZARDOUS WASTER CONTAINER DO NOT HOSE OUT THE TRAILER WITH WATER CLEAN THE FUEL SPILL AREAS WITH A GREASE OIL DISSOLVING CLEANER SUCH AS 409 THOROUGHLY DRY THE SPILL AREAS PORTABLE CONTAINERS When dispensing gasoline into a container use only approved portable containers and place it on the ground to avoid a possible static electricity ignition of the fuel vapors Never fill a container while the container is inside a vehicle a car trunk the bed of a pickup truck or the floor of a
159. rating practices instructions and safety regulations listed on the safety labels or in the owner s manual and or operating practices and safety regulations required by law Failure to comply with all rules regulations and instructions will invalidate this Limited Warranty If a problem occurs which the owner thinks is covered by this Limited Warranty the owner is responsible for contacting Heartland RV or his her authorized Heartland RV dealer by certified mail telephone or e mail giving specific notice of the problem s being experienced with the recreational vehicle Such notice must be sent to Heartland RV LLC 1001 All Pro Drive Elkhart IN 46514 Heartland RV will arrange for repair or replacement parts if materials or workmanship are identified as defective by Heartland RV The owner is advised that he she must notify Heartland RV of any items believed to require warranty service Heartland RV reserves the right to cure all warranty claims Warranty work repairs or service provided under this warranty conducted by any party not specifically authorized by Heartland is specifically not covered by this Limited Warranty and WILL VOID THIS LIMITED WARRANTY The owner agrees to maintain all evidence of any defect or damage through the ultimate resolution of any claim and make such evidence available to Heartland RV and further agrees that the failure to preserve evidence will result in loss of the claim The owner at his her expense will deliv
160. reading it further Some stains or soils are extremely difficult or impossible to be removed completely These should receive immediate professional attention Spills spots stains or soils are the responsibility of the owner and are not covered by the HEARTLAND RECREATIONAL VEHICLES LLC Limited Warranty WHEN CLEANING THE UPHOLSTERY AND FABRIC IN THE UNIT DO NOT USE LACQUER THINNER NAIL POLISH REMOVER LAUNDRY SOAPS OR BLEACH NEVER USE CARBON TETRACHLORIDE OR GASOLINE FOR ANY CLEANING PURPOSES THESE ITEMS MAY CAUSE DAMAGE TO THE MATERIALS BEING CLEANED AND MOST ARE HIGHLY FLAMMABLE FAILURE TO HEED THIS WARNING CAN RESULT IN SERIOUS PERSONAL INJURY OR LOSS OF LIFE 70 Carpet Weekly vacuuming the carpet and fabrics throughout the vehicle is recommended to prevent an accumulation of dirt that can detract from the material s appearance and shorten its life Countertops Countertops are made of several materials that are highly resistant to normal spills and scuffs Avoid regular use of abrasive pads and scouring powders which will dull the surface and make it more stain prone Confine knife blades and slicing to a chopping block not supplied Pots and pans straight from the oven or burner and irons should be placed on lined hot pads Appliances Refer to the individual manufacturer s owner s manuals for proper care and cleaning of your appliances Walls The walls should be cleaned periodically to maintain a new
161. recommended to check the fluid level every month 66 The Hydraulic pump is wired to an auto reset breaker that is mounted within 18 inches of the RV battery If an electrical overload would occur this breaker would interrupt the operation of the slide out room temporarily Causes for this to occur could be a low battery loose or corroded battery terminals or ground wire The slide room may be binding unit may not be level sticks leaves or other wedged items between the room and the wall The slide room and system may be out of adjustment Something may be blocking the extension or retraction of the slide room The hydraulic system can be manually overridden in case of failure or when electrical power is either interrupted or not available For proper operation please refer to the manufacturer s instructions supplied with your unit Please refer to the manufacturer s instructions supplied with your unit for proper care and operation of the hydraulic system HEARTLAND Recreational Vehicles LLC ELEVATED BEDS AND ELECTRIC BED LIFT SYSTEMS XXX LBS MAX LOAD CAPACITY FAILURE TO COMPLY WITH THE LOAD CAPACITY COULD CAUSE BED FAILURE WHICH MAY RESULT IN INJURY BED S MUST BE STOWED IN THE UP POSITION DURING TRAVEL ELEVATED BEDS MAY PRESENT A FALL HAZARD WHICH MAY RESULT IN INJURY PLEASE CONSULT THE OWNER S MANUAL FOR MORE INFORMATION REGARDING ELEVATED BEDS AND THE USE OF BED RAILS Standard Elevated Beds Various He
162. rom the rim to be properly inspected before being plugged and patched Tire Fundamentals Federal law requires tire manufacturers to place standardized information on the sidewall of all tires This information identifies and describesthe fundamental characteristics of the tire and also provides a tire identification number for safety standard certification and in case of recall Tire Label Information Diameter of Wheel in Inches Load Index amp Speed Symbol Ratio of Height to Radial Width Aspect Ratio Width of Tire in Millimeters U S DOT Safety Standard Code Passenger Car Tire Max Permissable Inflation Pressure Boos naro Y Yun Maximum Load Rating Tire Ply Composition and Materials Used Treadwear Traction and Temperature Grades NOTICE YOUR TRAILER IS EQUIPPED WITH TIRES DESIGNATED AS ST THIS DESIGNATION MEANS THAT THE TIRES ARE BUILT SPECIFICALLY FOR TRAILER APPLICATIONS THEY ARE CORRECT FOR YOUR TRAILER AND THE MAXIMUM LOADS THE TRAILER WAS DESIGNED AND RATED TO CARRY TIRE INDUSTRY STANDARDS REQUIRE THAT TIRES WITH ST DESIGNATION ARE SPEED RESTRICTED TO 65 MPH UNDER NORMAL INFLATION AND LOAD CONDITIONS UNLESS A DIFFERENT SPEED RESTRICTION IS INDICATED ON THE SIDEWALL OF THE TIRE IT IS BEST THAT YOU DO NOT OPERATE YOUR TRAILER AT SPEEDS ABOUT 65 MPH 36 P The P indicates the tire is for passenger vehicles NOTE Passenger car tires
163. rt is site for low hanging tree limbs posts large rocks etc which are to be avoided Always try to place the site to your left This way you can see what the trailer is doing while you are backing If the site is on your right you will be backing onto your blind side which is more difficult With everything clear maneuver the vehicle into position for backing into the site Now grasp the steering wheel at the bottom never at the top and back up Turn the steering wheel in the direction you wish the vehicle to go If the site is on your left move your hand to the left and back slowly watching the vehicle When the vehicle starts into the turn follow it by easing up on the steering wheel The vehicle will move into position Once in site pull vehicle forward amp back again to prevent trailer from maintaining a binded position which can damage the trailer and components 29 WHEEL NUT TORQUE Proper wheel nut torque is essential to safe and dependable trailering The wheel and axle systems used in RVs are similar in many ways to those used in cars and trucks but they differ in several important ways These differences require special attention to wheel nut torque both while the trailer is new and throughout the trailer s life Trailer wheels must carry much higher loads per wheel than passenger car or truck wheels Furthermore wheels on tandem axle trailers do not steer and are subjected to very high side load str
164. rt the air conditioner early as it removes excess humidity from the air while lowering the temperature e Keep the temperature as reasonably cool during cold weather as possible The warmer the vehicle the more cold exterior temperatures and warm interior temperatures will collide on wall surfaces thus creating condensation Use a fan to keep air circulating inside the vehicle so condensation and mildew cannot form in dead air spaces Allow air to circulate inside closets and cabinets leave doors partially open Please keep in mind that a closed cabinet full of stored goods prevents circulation and allows the exterior temperature to cause condensation e The natural tendency would be to close the vehicle tightly during cold weather This will actually compound the problem Simply put you need to remove some of the warm air and allow some cool outside air to get inside the vehicle so the furnace will not recycle the humid interior air e Usefluorescent ceiling lights and minimize prolonged use of incandescent lights which produce heat and contribute to condensation in the roof above the ceiling lights HEARTLAND Recreational Vehicles LLC CHEMICAL SENSITIVITY After you first purchase your new recreational vehicle and sometimes after it has been closed up for an extended period of time you may notice a strong odor and chemical sensitivity This is not a defect in your recreational vehicle Like your home there are many differ
165. s and tested before leaving the factory Your dealer also tests the system prior to customer delivery YOUR DEALER IS RESPONSIBLE FOR A THOROUGH LP GAS SYSTEM CHECK PRIOR TO DELIVERY DO NOT ACCEPT THE UNIT UNTIL THIS CHECK HAS BEEN COMPLETED Except for simple maintenance and occasionally tightening a connection you should take your unit to an authorized dealer for LP gas problems An authorized LP supplier should always fill the LP gas tank 51 LP GAS CYLNIDERS SHALL NOT BE PLACED OR STORED INSIDE THE VEHICLE LP GAS CYLINDERS ARE EQUIPPED WITH SAFETY DEVICES THAT RELIEVE EXCESSIVE PRESSURE BY DISCHARGING GAS TO THE ATMOSPHERE FAILURE TO COMPLY COULD RESULT IN DEATH OR SERIOUS INJURY YOURUNIT SMANUFACTURERISNOTRESPONSIBLE FOR PERSONAL INJURY OR PROPERTY DAMAGE RESULTING FROM IMPROPERLY MAINTAINED LP GAS APPLIANCES AND SYSTEMS THIS GAS PIPING SYSTEM IS DESIGNED FOR USE WITH LP GAS ONLY DO NOT CONNECT NATURAL GAS TO THIS SYSTEM SECURELY CAP THIS INLET WHEN NOT CONNECTED FOR USE AFTER TURNING ON GAS EXCEPT AFTER NORMAL CYNLINDER REPLACEMENT TEST GAS PIPING AND CONNECTIONS TO APPLIANCE FOR LEAKAGE WITH SOAPY WATER OR BUBBLE SOLUTION DO NOT USE PRODUCTS THAT CONTAIN AMMONIA OR CHLORINE NEVER ADJUST THE REGULATOR YOURSELF HAVE YOUR DEALER OR AN AUTHORIZED SERVICE TECHNICIAN MAKE ANY REQUIRED ADJUSTMENTS Filling LP Gas Bottles When your LP gas tank is empty have it refilled as soon as possible There are ma
166. s tire that contains the inflating medium within the tire Innerliner Deparation The parting of the inner line from cord material in the carcass Intended Outboard Sidewall The sidewall that contains a whitewall bears white lettering or bears manufacturer brand and or model name molding that is higher or deeper than the same molding on the other sidewall of the tire or the outward facing sidewall of an asymmetrical tire than has a particular side that must always face outward when mounted on a vehicle Light Truck LT Tire A tire designated by its manufacturer as primarily intended for use on lightweight trucks or multipurpose passenger vehicles Load Rating The maximum load that a tire is rated to carry for a given inflation pressure Maximum Permissible Inflation Pressure The maximum cold inflation pressure to which a tire may be inflated Maximum Loaded Vehicle Weight The sum of curb weight accessory weight vehicle capacity weight and production options weight Measuring Rim The rim on which a tire is fitted for physical dimension requirements Non Pneumatic Rim A mechanical device which when a non pneumatic tire assembly incorporates a wheel supports the tire and attaches either integrally or separably to the wheel center member and upon which the tire is attached Non pneumatic Spare Tire Assembly A non pneumatic tire assembly intended for temporary use in place of one of the pneu
167. sana mecs DEATH GA SERIOUS INJURT Home is where your heart is 81 CARGO RAMP TRAILER WEIGHT DISTRIBUTION It is not safe for persons or pets to occupy the vehicle storage area while vehicles are present Failure to follow these important precautions may result in serious injury or death All loaded trailers must remain within GVWR and GAWR limits Proper load distribution is especially important for ramp cargo trailers These trailers are designed to carry a variety of cargo and or vehicles in the cargo storage area These cargo items are typically heavy and you must consider how they are loaded Incorrectly loaded trailers can have too little weight resting on the hitch or pin and can become unstable when towing Therefore you must maintain a hitch weight percentage of 10 15 for travel trailers and 15 25 for fifth wheels Keep 60 of the cargo weight forward of the axle s center line Cargo Ramp Trailer Loading The rear cargo door loading ramp gives you complete access to the trailer cargo area When lowered the loading ramp allows you to easily load rolling cargo bicycles small motorcycles ATVs and small vehicles This section outlines the safety precautions you should take when loading and unloading cargo and vehicles as well as loading unloading procedures techniques and tips Cargo Ramp Trailer Loading Safety The loading ramp door area of your trailer can be a very hazardous part of your recreati
168. sary You should check with the rubber roof manufacturer prior to using cleaners coatings or sealants advertised to prolong the life of your rubber roof as they are not necessary When cleaning your roof it is recommended that you use along handled bristle brush and a steady ladder to reach all parts of the roof Lack of maintenance may allow mildew to form and discolor the rubber membrane Although this may be unsightly it is not cause for roof replacement Simply use a scrub brush to clean as much as possible and touch up and areas of sealant that look suspicious This is not covered under warranty Rubber Roof Repair Small tears or punctures in the rubber roof membrane can easily be repaired and will have the same life span as the rest of the rubber roof Most RV dealers carry rubber roof repair kits at a very nominal price Please refer to your specific repair kit for proper applications 68 Fiberglass Exterior Skin Optional Wash the RV with a quality mild soap There are special fiberglass cleaners on the market and available at most RV dealers DO NOT USE STRONG ALKALINE CLEANERS OR CLEANERS WITH ABRASIVES Waxing the exterior will further protect the outside surfaces USE A WAX FORMULATED FOR FIBERGLASS Follow the instructions found on the product label When washing and waxing the exterior of your RV be sure to inspect all seams and trim for damaged or missing sealants Occasionally during washing some sealants may
169. side filter out of canister Pull bottom filter out Clean filters and reassemble in reverse order bottom filter must be installed first TO REDUCE THE RISK OF FIRE ELECTRIC SHOCK OR INJURY UNPLUG AND DISCONNECT POWER BEFORE SERVICING ELECTRICSHOCK COULD OCCUR IF USED ON WET SURFACES DO NOT ALLOW TO BE USED AS A TOY USE ONLY MANUFACTURER S RECOMMENDED ATTACHMENTS DO NOT USE WITHOUT DUST BAG AND OR FILTERS IN PLACE HEARTLAND Recreational Vehicles LLC EQUIPMENT This section covers the basic operation and care of various equipment found in your Heartland RV More detailed information as well as CAUTION or WARNING instructions about specific equipment may be found in each product manufacturers manual Optional equipment will also be discussed in this section which does not apply to all vehicles Entry Step Entry steps folds under the vehicle when traveling To extend step pull assembly out from underneath the vehicle Bottom step is folded over second step roll bottom step out and down after step assembly is extended To store steps fold bottom step up over second step and push assembly underneath the vehicle Lubricating the Mechanism Lubricate the mechanism every 30 60 days Carefully clean the area around the pivot points the rivets involved in the motion of the mechanism After cleaning lubricate the pivot point between the pelt to pinpoint this area locate the washer between the parts An automotive grad
170. simple procedure to replace the sliding cover Place the slider in the center Pull from the center of the slider it will bow enough to allow easy removal To re install reverse this procedure Install the upper left corner first and pay attention to the location of the stop tabs 63 Sofa Bed Conversion Optional The sofa will convert easily into a bed Before converting the sofa to a bed clear the area of obstruction Sofa to Sleeper raise the sofa seat base until the seat base and backrest form a V shape by lifting up from the center of the sofa just below the seat cushions push down on the seat base until the seat base and back rest are flat Sleeper to Sofa Lift the seat base up until seat and back rest are in a V shape and push down on the seat base Roll Over Dinette amp Bed Optional The dinette can be used as a bed or a dinette When not in use the dinette is stored and secured to the sidewall There are two dinette sections used one for each side A fold up portable table is used and should be properly stored when in transit To Use The Bed Remove straps from each section and fold all legs out lower bed sections and fold cushions out to form the bed To Use The Dinette Remove retaining straps from each section and fold out bottom cushion legs of each section only lower each section bottom cushion to rest on the legs and rotate inner cushions to form back rests Dinette Bed Conversion Optional To convert
171. sis especially during hot weather conditions Refill as necessary with either distilled water or clean tap water in an emergency DO NOT ALLOW THE FLUID LEVELS IN THE BATTERIES TO FALL BELOW THE INTERNAL BATTERY PLATES DAMAGE TO THE BATTERIES MAY RESULT AND SHORTEN THE LIFE OF THE BATTERIES DO NOT ALLOW THE BATTERY FLUID TO CONTACT YOUR SKIN EYES FABRIC OR PAINTED SURFACES THE FLUID COULD CAUSE SERIOUS PERSONAL INJURY OR PROPERTY DAMAGE WEAR EYE PROTECTION WHEN WORKING WITH ANY BATTERY When charging the battery s do not charge at such a fast rate as to cause spewing of the electrolyte from the cells If your battery has problems prior to the end of their warranty period consult the nearest representative of the battery manufacturer When it is time to replace the batteries be sure to replace them with quality batteries of equal electrical and physical properties Contact your nearest dealer for advice in the selection of new batteries DO NOT ALLOW CORROSION TO DEVELOP ON THE BATTERY TERMINALS CORRODED TERMINALS CAN CAUSE A LOSS OF AVAILABLE POWER CUT DOWN ON THE EFFICIENCY OF THE CHARGING ELECTRICAL SYSTEM OR POSSIBLE BATTERY FAILURE 47 DO NOT SMOKE OR USE AN OPEN FLAME AROUND BATTERIES AVOID MAKING ELECTRICAL SPARKS NEAR BATTERIES FUMES FROM THE BATTERIES ARE COMBUSTIBLE The batteries should be removed and stored in a warm place when not used in your vehicle for an extended period of time i e more t
172. such as fading of fabrics or drapes carpet wear exterior surfaces etc Maintenance items such as light bulbs fuses lubricants minor adjustments Use of the Recreational Vehicle for any commercial or rental purpose voids the warranty from the time that the vehicle is first used for commercial or rental purposes and at all times thereafter e Transportation to and from dealer or manufacturing plant locations for any purpose including but not limited to warranty purposes e All consequential and incidental expense such as but not limited to loss of time commercial loss loss of use towing charges lodging food phone calls inconvenience bus and plane fares or rental charges defect or shortages readily apparent on delivery to the initial retail purchaser unless noted on the delivery sheet completed by the driver transporting the RV to the independent dealer Environmentally caused conditions such as rust or sealant deterioration Chemical off gassing is not a defect in your recreational vehicle and is not covered by the limited one year warranty Please follow the recommendations in this section to address this concern Some states or provinces do not allow limitations on how long an implied warranty lasts the exclusion or limitation of incidental or consequential damages or the reduction in the statute of limitations so the above limitation exclusion reduction may not apply to you 4 HEARTLAND Recreational V
173. sure your have sufficient battery power before operating the furnace Your furnace is designed to sustain a desired temperature in the vehicle at most times Due to varying weather conditions the furnace may not be able to keep up with sub freezing tempteratures The amount of vehicle occupants and the position the vehicle is parked may help or hinder the furnace s ability to keep up with freeze conditions Consult the furnace owner s manual for more information DO NOT SUPPLEMENT THE FURNACE WITH ANY PORTABLE FUEL BURNING APPLIANCE FOR HEATING THE INTERIOR OR THE VEHICLE THESE APPLIANCES ARE NOT SAFE MONOXIDE POISONING IS POSSIBLE IN ANY WELL SEALED SPACE AND CAN RESULT IN SERIOUS PERSONAL INJURY OR LOSS OF LIFE Air Conditioner Many vehicles are equipped with a roof air conditioning System that works with electrical power from either a shore line or a portable generator Air conditioners are capable of cooling air a maximum of 18 to 22 degrees below ambient temperature in a 50 humidity environment As the humidity goes up the cooling difference goes down f the temperature inside your coach is 100 degrees when you turn on the air conditioner it will only put out 80 degrees Eventually the air inside the coach will cool and as it cools the air put out by the air conditioner will cool also However when starting out at 100 degrees this cooling could take several hours before it reaches you
174. tch bars are attached see manufacturer s instructions IMPROPER RIGGING OF THE SAFETY CHAINS CAN RESULT IN LOSS OF CONTROL OF THE TRAILER AND TOW VEHICLE LEADING TO DEATH OR SERIOUS INJURY IF THE TRAILER UNCOUPLES FROM THE TOW VEHICLE DO NOT CONNECT THE BREAKAWAY SWITCH LANYARD TO THE HITCH BALL OR ANY REMOVABLE PART OF THE HITCH FAILURE TO DO SO MAY RESULT IN DAMAGE TO THE CABLE COMPROMISING THE EMERGENCY BRAKING SYSTEM Always use safety chains when towing They maintain the ball connection between the trailer and tow vehicle in the event of separation of the ball and trailer coupling Safety chains are included with every travel trailer and in most states are required when towing a travel trailer Attach chain to the designated wing areas on the right and left of the hitch ball crossing the under the trailer s tongue Inspect the length of the chains once attached to the tow vehicle frame They should be long enough to allow for turns but short enough to avoid any drag Hitching a Fifth Wheel Trailer To hitch a 5th wheel lower or remove the tailgate Release the plate jaws by pulling the handle It may be necessary to raise or lower the trailer with the front landing gear to align the pin with the jaw plates Once connected put your truck in drive and apply pressure to the hitch to ensure it is locked Then retract your landing gear by using the switch or by turning the crank handle if equipped to raise the jac
175. the dinette into a bed remove the tabletop from the leg supports and set aside remove the leg supports from the base and store slide the tabletop between the booth benches allowing it to rest on the guide rail and lay both seat cushions and back cushions together to form a mattress Storage Under Bed Optional To use the storage compartment located under the bed lift up the bed by the front edge of the mattress platform Gas struts hold the mattress and platform open FOR MORE DETAILED INFORMATION AND OPERATING INSTRUCTIONS REFER THE TO THE MANUFACTURER S MANUAL 64 Overhead Storage The overhead storage is to be used for light weight items only Entertainment Center AM FM CD DVD Player The entertainment center stereo system consists of AM FM Stereo Tuner CD DCD Player and interior speakers FOR MORE DETAILED INFORMATION AND OPERATING INSTRUCTIONS REFER THE TO THE MANUFACTURER S MANUAL Television Antenna The television antenna is a manual crank up antenna with built in electronics that use 12 Volts DC to boost signal strength Weak signals can be amplified by turning on the boost switch The antenna and booster work together to provide the best possible picture for most situations Certain conditions occur when no amplification is needed and the booster may make the picture worse DO NOT MOVE THE RECREATIONAL VEHICLE WITH THE ANTENNA RAISED DAMAGE CAN OCCUR FROM LOW TREE LIMBS OR WIRES BEFORE RAISI
176. the lug nuts Tighten all lug nuts to the specified torque using a torque wrench lug stud threads are damaged or faulty get professional service help WHEEL SEPARATIOM CAM OCCUR V eri args trip tegen ugs at gu gn 25 mri rules Pagina In rrasrigacturee g pens mi cusa iri Thay Creenapr m ee 2 Threat yee hag belong mech Lip bella wie cine rhaci b being ing goaded brake Raped loge APS Home is where your heart is Wheel Compatibility __ A WARNING DO NOT MISMATCH WHEELS AND TIRES Axle systems are installed with hubs and drums that are compatible with many wheels used in the recreational vehicle industry that have matching bolt patterns If the original manufacturer installed equipment is in need of replacement the wheel manufacturer should be contacted for proof of compatibility prior to replacement and use Customers replacing original equipment that has not been tested for compatibility must ensure the replacements are compatible to the hub and drum assembly installed Such elements of compatibility include but are not limited to Diameter of the hub mounting surface Stud length and diameter Location and number of studs Center hold diameter for the wheel Wheel mounting offset from the rim center Rated capacity of the wheel Wheel fastener torque Wheel nut size and shape Impact of any added wheel accessories such as decorative cente
177. to be pumped out less than one cup EMe ied d DRAINING THE WATER SYSTEM ALONE MAY NOT BE ENOUGH TO PROVIDE COMPLETE COLD WEATHER PROTECTION FOR AN RV UNIT THAT WILL BE STORED IN AN UNHEATED ENVIRONMENT WHERE TEMPERATURES DROP BELOW FREEZING CONSULT YOUR DEALER FOR MORE INFORMATION ON THE BEST METHOD OF WINTERZING YOUR VEHICLE Home is where your heart is If you desire you can blow out the water lines with compressed air by opening all valves and placing the air nozzle into the system where the outlet hose has disconnected Replace pump hose System Winterizing Drain the fresh water tank Drain pipes by turning the water pump ON and opening a cold water faucet Wait for the water flow to stop Turn pump OFF Leave faucets OPEN 3 Turn ON all faucets 4 OPEN the WATER HEATER drain valve located at the bottom of the heater or remove plug Let the water drain out OPEN the heater SAFETY VALVE 5 Bypass the water heater 6 Use the siphon hose to add RV anti freeze to your system or use air pressure to remove all remaining water from the system 7 After each faucet has been opened drained and closed CLOSE the WATER LINE DRAIN VALVES 8 Drain the WASTE WATER HOLDING TANK 9 Double check that ALL WATER has been drained 10 Some water may remain in the fresh tank This will not damage the tank DO NOT USE AUTOMOTIVE ANTI FREEZE OR WINDSHIELD WASHER FLUID ANTI FREEZE IN THE VEHICLE S WATER SYSTEM T
178. trailer When filling a portable container manually control the nozzle valve throughout the filling process Fill a portable container slowly to decrease the chance of static electricity build up and minimize spilling Keep the fuel nozzle in contact with the rim of the container opening while refueling Fill container no more than 95 percent full to allow for expansion Place cap tightly on the container after filling do not use containers that do not seal properly Store gasoline only in approved containers Never store gasoline in glass or any other unapproved container If gasoline spills on the container clean up the spill immediately When transporting gasoline in a portable container make sure it is secured against tipping and sliding and never leave it in direct sunlight or in the trunk of a car Home is where your heart is 89
179. ttp www safercar gov Home is where your heart is IMPORTANT OWNER S SAFETY INFORMATION This guide has been provided by HEARTLAND RECREATIONAL VEHICLES LLC for the purpose of providing instructions about the operation and maintenance of this vehicle and its components The only warranty offered by HEARTLAND RECREATIONAL VEHICLES LLC is set forth in the written One Year Limited Warranty that applies to this vehicle See pp 3 5 Nothing in this manual creates any other warranty either expressed or implied Instructions are included in the manual for operating some of the components that are standard on this vehicle Instructions may also be given for components that are options and may not appear on all vehicles For more detailed information on the components installed refer to the individual component manufacturer s operating instructions contained in the Owner s Information Package HEARTLAND RECREATIONAL VEHICLES LLC has attempted to compile the most current information available at the time this guide was published If the components in your unit vary significantly from what is described within this manual then consult the instructions provided by the component manufacturer found in the Owner s Information Package Throughout this guide reference is made to the following terms Warning Caution and Note These terms indicate important information that must be understood and followed The definitions of these terms are
180. ual Make sure that you have sufficient clearance from obstructions e Unlock the awning using the provided wand by pulling down the locking latch located on the top of the right awning arm if equipped e Unlock the travel lock on the awning arm if equipped Loosen the rafter arm knobs located in each awning arm Using the wand hook the loop hanging in the center of the awning and pull the awning completely out Slide each rafter arm to the top of each awning arm and tighten the rafter knobs make sure the awning fabric is not loose e Near the base of each awning arm is a flip out lever handle which is also an awning arm slide lock When the lever is flipped out the awning arm can be slid up to raise the awning Flipping the lever back down will allow the arm to lock e Your awning is now in place You may choose to use anchor straps for extra support in windy conditions e For further details see the awning manufacturer s instruction manual Home is where your heart is To close the main awning e Flip the awning arm levers out and slide the awning arms back down being careful not to let the awning drop down as flipping the levers out will unlock the arm and allow it to slide down Loosen the rafter arm knobs and slide the rafter arm as far down as it will go Do not re tighten the rafter arm knobs at this time e While holding the wand strap in the awning tube push the awning main latch located on
181. ull off the roadway a safe distance from traffic if possible Set the parking brake and turn on the hazard warning flashers especially when parked alongside traffic lanes An emergency road kit should include at least three reflective warning signs road flares a flashlight spare automotive fuses and an assortment of hand tools The recreational vehicle is equipped with a fire extinguisher inside near the entry door Display road flares or reflective warning signs if the vehicle is along the road for any length of time Guidelines for placing the warning triangles depend upon the road characteristics and visibility The standard placement is 10 100 and 200 from the rear of the recreational vehicle when on a divided highway or one way road On a two way road with traffic traveling both directions the same placement would also be required at the front of the recreational vehicle Roads with curves and hills may require placing warnings 500 behind the vehicle in order to safely warn approaching traffic 17 MAINTENANCE SCHEDULE Tighten wheel bolts or nuts every 50 miles for the first 200 miles amp after every change in wheel mounting Torque to 120 125 ft Ibs Adjust brakes after first 200 miles then at above listed intervals Axle and springs INSPECT TEST BEFORE EACH TRIP MONTHLY EVERY 3 MONTHS EVERY 6 MONTHS AS REQUIRED BY ee MANUFACTURER Batteries Water level Brakes E
182. ur records are updated Please note that the date of purchase on the card will show the original date the vehicle was first purchased and is the date applicable warranties originated Note the warranty on a HEARTLAND RECREATIONAL VEHICLES LLC coach is non transferable This customer information update form is for record keeping purposes only If you have any questions please contact a HEARTLAND RECREATIONAL VEHICLES LLC service representative DATE COACH VIN NO CUSTOMER FULL NAME CUSTOMER ADDRESS TELEPHONE NUMBER EMAIL ADDRESS PURCHASED FROM ADDRESS HEARTLAND RECREATIONAL VEHICLES LLC ATTN Dealer Services Warranty Department 2912 Dexter Drive Elkhart IN 46514 Phone No 574 262 8030 Home is where your heart is 13 This page left intentionally blank HEARTLAND Recreational Vehicles LLC PRE TRIP CHECKLIST AT HOME Have read and understood your owner s manual If not please do so now EXTERIOR All Obj CtS secure eerie AWNINGS locked in Tires at proper pressure including spare check for wear damage Wheel lug nuts tightened to proper torque Hitch and or pin box secured properly All exterior lights operational Battery batteries fully charged fluid level okay Brakes checked for Secure cargo and lock compartment doors Under carr
183. urface of the road whether it is gravel or pavement the condition of the road wet dry icy tire tread the condition of your brakes the weight of the vehicle and the amount of brake force applied The distance required to properly stop when towing a vehicle is often underestimated As a good rule of thumb when towing the trailer always maintain at least 3 cars and a trailer approximately 85 ft length space between you and the car in front of you for every 10 miles of speed you are traveling This should give you ample time to stop in case of an emergency HEARTLAND Recreational Vehicles LLC GLOSSARY OF TIRE TERMINOLOGY Accessory Weight The combined weight in excess of those standard items which may be replaced of automatic transmission power steering power brakes power windows power seats radio and heater to the extent that these items are available as factory installed equipment whether installed or not Bead The part of the tire that is made of steel wires wrapped or reinforced by ply cords and that is shaped to fit the rim Bead Separation This is the breakdown of the bond between components in the bead Bias Ply Tire A pneumatic tire in which the ply cords that extend to the beads are laid at alternate angles substantially less than 90 degrees to the centerline of the tread Carcass The tire structure except treat and sidewall rubber which when inflated bears the load Chunking T
184. ut the same load If not level the trailer or redistribute the load Also check weight distribution at each wheel Use the above technique weighing only the right or left side Calculate the weight at each wheel Be sure that no one wheel is overloaded If you have trouble calculating or interpreting the weights contact your dealer or vehicle manufacturer Weight Rating Located on the units front roadside lower corner is a Federal Certification Label This label gives the maximum weight carrying capacities of your unit and for each axle designated by the letters GVWR and GAWR respectively The serial number of your unit is located on this label also Here is a sample label as found on the pin box abii in ieee Se Bog im ira amati zac ee Pu EG Lm Lp rmm EE RE dade TUM Au e EI Ud Bap ae um FHER um RE SPS eS ee Doe mimm EE P r Em bi DRE m rie Sat amem es de ie n a ee eee ee ee OH ee eee ee a ee 1 ee ee ee eee i l a ee ee ee a NH UM TS Ge eee ee ee eee eee ee a a GERD CV HO UU Gg ee OEGEO Dd Mu LENST ee 1 ee PNOROGSGS Hl L EE P Du HAE a CE jn SS bere
185. vals Air pressure INSPECT TEST BEFORE EACH TRIP X MONTHLY MAINTENANCE SCHEDULE EVERY 3 MONTHS EVERY 6 MONTHS YEARLY AS REQUIRED BY MANUFACTURER Wheel rims Brake shoes Brake magnets Wheel bearings and cups Hub drum Seals XXIX KI Xx x XxX Air pressure best to check daily Lug bolts or nuts Pin box bolts 5 wheel Retighten the pin box bolts every 50 miles for the first 500 miles Safety chains Other Home is where your heart is 19 20 This page left intentionally blank HEARTLAND Recreational Vehicles LLC MAINTENANCE RECORD ROUTINE MAINTENANCE All routine maintenance is the responsibility of the owner and is not covered by the HEARTLAND RECREATIONAL VEHICLES LLC Limited Warranty Use the maintenance record to record all performed maintenance as required Please note that damage caused by improper or un applied maintenance is not covered by the HEARTLAND RECREATIONAL VEHICLES LLC Limited Warranty Use and conditions may dictate more frequent maintenance than suggested Items supplied by other manufacturers may require specific individual maintenance not listed herein Please refer to the manufacturers suggested maintenance guidelines in the Owner s Information Packet IMPORTANT All adjustments
186. vehicle Steps for determining correct load limit Locate the statement The weight of cargo should never exceed XXX KG or XXX LBS on your vehicles placard e The figure stated on the placard is the available amount of cargo load capacity Determine the weight of cargo being loaded in the vehicle That weight may not safely exceed the available cargo capacity For further information about wheel and tire safety 1 888 327 4236 TTY 1 800 242 9 53 http www safercar gov and NHTSA 400 Seventh St S W Washington DC 20590 Storage of Tires Rubber tires degrade faster when not being used A cool dry sealed garage is the preferred storage location Many recreational vehicles are stored outside Some storage surfaces may cause tires to prematurely age Placing a barrier plastic or plywood between the tire and storage floor ground helps to protect the tires When the tire may be out of service for 30 days or more the vehicle should be in long term storage condition 38 IF THE RECREATIONAL VEHICLE IS STORED WITH WEIGHT ON THE TIRES INFLATE THEM TO MAXIMUM INFLATION PRESSURE AS INDICATED ON THE FEDERAL IDENTIFICATION TAG e Thoroughly clean the tires Unload the vehicle so there is minimum weight on the tires Ensure the surface is reasonably level firm clean and has good drainage Move recreational vehicle every three months to prevent cracking in bulge areas as well as flat spotting from prolonged sid
187. vehicle in securely Use a minimum of three tiedowns to secure the vehicle to the trailer Use one tiedown to secure the front of the vehicle to the trailer Use two tiedowns to secure the rear of the vehicle to the trailer Four tiedowns one at each corner are preferred Attach tiedown hooks to the vehicle s frame not to an accessory such as a mirror handle bar pedal etc Hooks on the other end must be attached to vehicle cargo anchors installed in the trailer Fortransport motorized cargo with manual transmissions should be left in first gear Vehicle s with automatic transmissions should be in the Park position The vehicle s ignition key should be turned off and removed the parking brake set the run stop switch in the stop or off position and the fuel lever turned to the off position The Safest Way to Unload Your Motorized Cargo The safest method of unloading is to push the vehicle HEARTLAND Recreational Vehicles LLC down the ramp carefully braking to ensure control of the vehicle If you loaded your vehicle forward front in that means you will unload it in reverse Driving a motorized vehicle backwards down a hill the ramp is not recommended A slight turn of the handle or slip of a wheel can cause your vehicle to fall tip or roll sideways If you are on or in the vehicle you can be inured or killed Unload the vehicle safely as follows 1 Be sure the back tires of the vehicle are aligned with the ramp
188. wing ventilation from outside will be far drier than interior air and will effectively reduce condensation inside the trailer 2 Minimize moisture released inside the trailer Run the range vent fan when cooking and the vent fan or open the bath vent when bathing to carry water vapor out of the trailer Avoid making steam from excessive boiling or use of hot water Remove water or snow from shoes before entering to avoid soaking the carpet Avoid drying overcoats or other clothes inside the trailer FIRE HAZARD DO NOT USE COOKING APPLIANCES FOR COMFORT HEATING COOKING APPLIANCES NEED FRESH AIR FOR SAFE OPERATION BEFORE OPERATION 1 OPEN OVERHEAD VENT OR TURN ON EXHAUSE FAN AND 2 OPEN WINDOW In addition to the hazards of toxic fumes and oxygen depletion open flames add moisture to the interior air increasing condensation Do not use an air humidifier inside the trailer Water put into the air by the humidifier will greatly increase condensation 3 Ventilate closets and cabinets During prolonged use in very cold weather leave cabinet and closet doors partially open to warm and ventilate the interiors of storage compartments built against exterior walls The air flow will warm the exterior wall surface reducing or eliminating condensation and minimizing possible ice formation HEARTLAND Recreational Vehicles LLC 4 Install dehumidifier During prolonged continuous use a dehumidifying appliance may be more co
189. xterior lighting Fresh water system X XI XIXI X X Have all appliances serviced Lp gas system Pigtail connection Roof sealant Roof vents Safety breakaway switch operation Sidewall sealants Tire lug nuts after initial 50 mile check Tires condition and pressure Underbelly check for tears or leaks Wheel bearings Seals doors windows vents external seams Clean exhaust fan filter and blades Test smoke alarm and lp detector Check operation of windows latches and hinges Clean the roof ducted air conditioner filter s Inspect and reseal shower area where necessary Lubricate exterior door hinges and latches with a graphite silicone lubricant Check clean and tighten battery cables Rotate tires as recommended by the tire manufacturer Check all appliances for proper operation Have the heat and ignition inspected by qualified technician Inspection of roof seams and joints performed by an authorized service center suggested Sanitize the fresh water system Wax and buff all gel coat surfaces as described in owner s guide where applicable 18 HEARTLAND Recreational Vehicles LLC Tighten wheel bolts or nuts every 50 miles for the first 200 miles amp after every change in wheel mounting Torque to 120 125 ft Ibs Adjust brakes after first 200 miles then at above listed inter
190. y not support the weight of the vehicle Driving lanes in work zones can be uneven congested and more narrow than usual Be cautious of road debris which can damage the undercarriage of the vehicle or cause damage to the tires or wheel rims Keep in consideration that posted speed signs are for passenger automobiles Therefore use extra awareness of the driving conditions and an appropriate speed for a vehicle with trailer especially on corners and mountain roads HEARTLAND Recreational Vehicles LLC Downgrade speed should be at least 5 mph less than upgrade speed or downgrade speed should be attainable within three seconds of a brake application Beya TOWING ANYTHING BEHIND YOUR RV COULD CAUSE DAMAGE TO THE FRAME AND WILL VOID YOUR FRAMES WARRANTY Right Turns Negotiating a right hand turn while pulling a recreational vehicle can be difficult but can be negotiated well using these tips As the turn approaches look into the mirror to ensure the lane to the left is clear then move wide over to the left Make the turn slowly Check mirrors frequently Be aware of necessary clearance and space management for the trailer while turning Night Driving Be well rested and alert when driving If necessary find a safe stopping place to rest until you are ready to continue Avoid using any interior lights while driving They can create a glare on the windshield decreasing visibility Dim dash

Download Pdf Manuals

Related Search

Related Contents

LG GB175 User's Manual  Manual de Instruções  Selecionar e imprimir página  MANOBS Manuel d`observations météorologiques de surface  mode d`opération user maintenance instructions consignes d  Infinity HTS10A System  Aliens™ Extermination System Manual  公開講座「パソコンを利用した点訳入門」の概要と結果  HP DVD100I User's Manual  User`s Guide  

Copyright © All rights reserved. Failed to retrieve file